2001 Hyundai Elantra
Problems, recalls and owner-reported issues
Air bags is the leading concern among 329 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Elantra model years with reports.
Of the 2001 reports, 72 involved a crash and 5 involved a fire. 59 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Suspension, front, control armApr 16, 2009
HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT USED DURING THE WINTER MONTHS IN THESE JURISDICTIONS MAY RESULT IN INTERNAL CORROSION AND THINNING OF THE STEEL IN THE FRONT LOWER CONTROL ARMS. THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM'S UPPER AND LOWER PANELS BECOME PERFORATED. A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.
THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTROL ARMS DO NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE FRONT LOWER CONTROL ARMS AND WILL TREAT THE FRONT LOWER CONTROL ARMS WITH RUST-PROOFING MATERIALS TO ARREST THE INTERNAL CORROSION PROCESS. THESE PROCEDURES WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 17, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 09V125000 on NHTSA.gov
Air bags, frontal, sensor/control module-inactiveOct 14, 2008
HYUNDAI IS RECALLING CERTAIN MY 2001-2002 ELANTRA VEHICLES. MOVEMENT OF THE SIDE IMPACT AIR BAG WIRING HARNESS MOUNTED UNDER EACH FRONT SEAT, POSSIBLY CAUSED BY CONTACT FROM MATERIALS PLACED UNDER THE SEAT, MAY RESULT IN AN ELECTRICAL RESISTANCE THAT WOULD CAUSE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) WARNING LIGHT ILLUMINATION.
THIS CONDITION ONLY RELATES TO THE DRIVER AND PASSENGER SEAT MOUNTED SIDE IMPACT AIR BAGS AND MAY PREVENT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT DURING A CRASH WHERE SUCH DEPLOYMENT SHOULD OCCUR. NON-DEPLOYMENT OF THE SRS AIR BAGS MAY INCREASE THE RISK OF INJURY TO THE DRIVER AND FRONT PASSENGER UNDER CERTAIN CRASH CONDITIONS.
DEALERS WILL INSTALL NEW SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR CLIPS AND REVISED SIDE IMPACT AIR BAG WIRING HARNESS ATTACHMENTS UNDER THE DRIVER'S AND FRONT PASSENGER'S SEATS. THE RECALL IS EXPECTED TO BEGIN DURING THE FOURTH QUARTER OF 2008, AND WILL BE SENT OUT IN SIX MAILINGS. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 08V533000 on NHTSA.gov
Air bags, frontal, sensor/control module-inactiveOct 14, 2008
HYUNDAI IS RECALLING CERTAIN MY 2001 ELANTRA VEHICLES. IF A LIQUID IS SPILLED IN THE AREA OF THE CUPHOLDER ON THE CENTER CONSOLE, IT MAY SEEP THROUGH THE CONSOLE OPENING FOR THE PARKING BRAKE LEVER AND THEN DRIP ONTO THE AIR BAG CONTROL MODULE ELECTRICAL CONNECTOR. THE SPILLED LIQUID MAY CONTAMINATE THE AIR BAG CONTROL MODULE AND ITS ELECTRICAL CONNECTOR TO THE AIR BAG WIRING HARNESS AND CAUSE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) WARNING LIGHT TO ILLUMINATE.
THIS CONDITION MAY AFFECT THE DRIVER AND PASSENGER FRONTAL AIR BAGS AND MAY PREVENT AIR BAG DEPLOYMENT DURING A CRASH WHERE SUCH DEPLOYMENT SHOULD OCCUR. NON-DEPLOYMENT OF THE SRS AIR BAGS MAY INCREASE THE RISK OF INJURY TO THE DRIVER AND FRONT PASSENGER UNDER CERTAIN CRASH CONDITIONS.
DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE VEHICLE'S AIR BAG CONTROL MODULE CONNECTOR. THE RECALL OWNER NOTIFICATION BEGAN ON NOVEMBER 30, 2008, AND LETTERS WILL BE SENT OUT IN SIX MAILINGS. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 08V532000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsDec 3, 2003
ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.
CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.
Campaign 03V496000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsJul 22, 2003
ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.
FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 03V257000 on NHTSA.gov
Air bags, side/windowOct 17, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SUPPLEMENTAL RESTRAINT SYSTEM SIDE AIR BAG SATELLITE SENSORS INSTALLED WERE IMPROPERLY MANUFACTURED, CAUSING THE AIR BAG WARNING LIGHT TO ILLUMINATE AND THE SIDE AIR BAGS TO NOT DEPLOY AS INTENDED IN THE EVENT OF A CRASH.
NON-DEPLOYMENT OF THE SIDE AIR BAGS COULD INCREASE THE RISK OF INJURY DURING A CRASH WHERE SIDE AIR BAG DEPLOYMENT IS INTENDED.
DEALERS WILL REPLACE THE TWO SATELLITE SENSORS.
Campaign 00V332000 on NHTSA.gov
Representative owner complaints: hydraulic
21 reports, newest first. Show all
Service brakes, Hydraulic, Jan 18, 2012
SINCE NEW, OUR 2001 ELANTRA HAS HAD AN INTERMITTENT "THUMPING" SOUND IN THE REAR WHEELS WHILE BRAKES ARE APPLIED. IT WOULD GO AWAY FOR MONTHS, THEN RETURN, USUALLY AFTER SOME MAINTENANCE EVENT SUCH AS A TIRE ROTATION. INTERNET SEARCHES REVEAL THAT THIS IS A VERY COMMON COMPLAINT. PEOPLE HAVE REPLACED ALL SORTS OF PARTS; WHEEL BEARING, SUSPENSION PARTS ETC., USUALLY WITH NO FIX. I FOUND THE CAUSE, AND THERE NEEDS TO BE A RECALL !! ON OUR MODEL, THE WHEEL NUTS ARE "CLOSED", MEANING THAT THEY ARE NOT DRILLED AND TAPPED ALL THE WAY THOUGH. ON OUR CAR, SOME OF THE WHEEL NUTS BOTTOM OUT ON THE WHEEL STUDS BEFORE THE BRAKE DRUM IS SECURED. WHEN BRAKES ARE APPLIED, THE RESULTING LOOSE BRAKE DRUM CAN "WOBBLE" ON THE STUDS, MAKING THE SOUND,. ANOTHER ISSUE CONTRIBUTING TO THE PROBLEM: THERE IS ONE PHILLIPS SCREW WHICH SECURES THE BRAKE DRUM TO THE HUB. IN MY CASE THIS SCREW WAS MISSING, PROBABLY HAVING BEEN LEFT OFF DURING A SAFETY INSPECTION. HOWEVER, IF THE NUTS WERE NOT BOTTOMED OUT, THE DRUM WOULD BE SECURE EVEN IF THE SCREW IS MISSING. IT WOULD SEEM THAT THIS CONDITION COULD EVENTUALLY LEAD TO STUD FAILURE. AT THE VERY LEAST, IT IS A SERIOUS AGGRAVATION. PROBABLY THE LEAST EXPENSIVE WAY TO FIX THIS WOULD BE TO REPLACE THE WHEEL NUTS WITH ONES THAT ARE DEEPER, ALLOWING MORE CLEARANCE FOR THE END OF THE WHEEL STUD.
Service brakes, Hydraulic, Dec 28, 2009
TL* THE CONTACT OWNS A 2001 HYUNDAI ELANTRA. HIS VEHICLE WAS REPAIRED ACCORDING TO RECALL 03V257000 ( SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS). AFTER THE REPAIR, HE NOTICED THAT THE BRAKE LINES HAD HOLES IN THEM WHICH CAUSED BRAKE FLUID LEAKAGE. THERE WAS NO COMPRESSION IN THE BRAKE LINE , SO THE PEDAL FELL COMPLETELY TO THE FLOOR DURING APPLICATION. HE TOOK THE VEHICLE TO THE DEALERSHIP AND WAS ADVISED THAT THE ENTIRE BRAKE LINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS PROVIDED. NO REPAIRS WERE MADE. THE CURRENT MILEAGE WAS APPROXIMATELY 58,000. THE FAILURE MILEAGE WAS APPROXIMATELY 37,000.
Suspension, Service brakes, Hydraulic, Structure, Feb 24, 2009, crash
TL*THE CONTACT OWNS A 2001 HYUNDAI ELANTRA. WHILE DRIVING 25 MPH, THE DRIVER WAS UNABLE TO STOP THE VEHICLE. THE DRIVER'S SIDE OF THE VEHICLE CRASHED INTO A CURB. THERE WERE NO INJURIES. THE CONTACT NOTICED THAT THE FRAME OF THE VEHICLE WAS ROTTED. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE LOWER FRONT CONTROL ARM WAS RUSTED. NO REPAIRS HAVE CURRENTLY BEEN MADE TO THE VEHICLE. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT THEY WOULD COVER THE REPAIR COSTS. THE FAILURE MILEAGE WAS 99,000.
Steering, Service brakes, Hydraulic, Engine and engine cooling, Air bags, Sep 16, 2008, fire
TL*THE CONTACT OWNS A 2001 HYUNDAI ELANTRA. WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN IT WAS DEPRESSED. THE BRAKES WERE PUMPED SEVERAL TIMES BEFORE THE VEHICLE CAME TO A COMPLETE STOP. A SMALL AMOUNT OF SMOKE APPEARED UNDERNEATH THE HOOD. THE AIR BAG AND ENGINE WARNING LIGHTS ILLUMINATED INTERMITTENTLY ON THE INSTRUMENT PANEL. IN ADDITION, THE CONTACT EXERTED MORE EFFORT TO TURN THE STEERING WHEEL AS IF THERE WERE NO POWER STEERING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY REPLACED THE POWER STEERING HOSE. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 98,000.
Service brakes, Hydraulic, Engine and engine cooling, Air bags, Equipment, Nov 9, 2007
TL*THE CONTACT OWNS A 2001 HYUNDAI ELANTRA. THE FRONT PASSENGER SIDE WINDOW AIR BAG WAS REPLACED IN 2004. THE DAY AFTER THE REPLACEMENT, THE AIR BAG LIGHT ILLUMINATED AGAIN. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY STATED THAT THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT DISCOVERED AN AIR BAG SAFETY RECALL ONLINE, BUT THE DEALER STATED THAT NO RECALL WAS AVAILABLE. IN 2004, THE CONTACT ALSO INFORMED THE DEALER THAT THE WEATHER STRIPPING ON THE BACK DOOR FRAME WAS TOO SMALL. THE VEHICLE WAS STILL UNDER WARRANTY. THE DEALER PUSHED THE WEATHER STRIPPING BACK ON THE DOOR. IN 2005, THE CONTACT HEARD A STRANGE NOISE COMING FROM THE ENGINE COMPARTMENT AND THE VEHICLE STALLED IN HOT WEATHER. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. WHILE AT THE DEALER, SHE WAS INFORMED OF A BRAKE LINE RECALL AND CLIPS WERE APPLIED. THE FOLLOWING DAY, THE VEHICLE BEGAN SQUEAKING WHEN SHE APPLIED AND RELEASED THE BRAKES. THE RECALL NUMBERS WERE UNKNOWN. THE CURRENT MILEAGE WAS 84,448 AND FAILURE MILEAGE WAS 1,000. ABL.PCO
Service brakes, Hydraulic, Air bags, Mar 15, 2007, crash
ABS SYSTEM FAILED DURING BRAKING, CAUSING REAR END COLLISION AIR BAGS DID NOT DEPLOY. *JB
Service brakes, Hydraulic, Air bags, Feb 6, 2007, crash
10/28/05 CAR DID NOT STOP IMMEDIATELY WHILE PARKING, WENT THROUGH FENCE AND HIT DECK. BRAKES DID NOT HOLD IN SAND. CAR TOWED TO DEALERSHIP WHO INFORMED, NOTHING WRONG WITH BRAKES. ADVISED BY DEALERSHIP THAT THE RECALL ON BRAKES FOR HYUNDAI ELANTRA 2001 WAS REMEDIED BY THEM. BRAKES STILL DO NOT HOLD WELL, ADVISED BY ANOTHER MECHANIC THAT BRAKE SHOES ARE FINE. STILL DO NOT HAVE A GOOD COMFORT LEVEL WITH BRAKES. AIR BAG LIGHT ON, RECALL ON FILE FOR MODEL AND YEAR, DEALER ADVISED NOT FOR MY CAR. WILL FIX AT COST OF APPROXIMATELY $700.00. *NM
Service brakes, Hydraulic, Jul 13, 2004
2001 ELANTRA REGARDING REAR BRAKE TUBES RECALL NOTICE.*MR IT TOOK SEVERAL TRIES TO GET THE RECALL PERFORMED ON THE CONSUMERS VEHICLE. THE CONSUMER MADE AN APPOINTMENT TO HAVE THE REPAIRS MADE, HOWEVER WHEN THE CONSUMER SHOWED UP, THE DEALER WAS CLOSED, THE CONSUMER WAS TOLD THE DEALERSHIP HAD CHANGED OWNERSHIP AND TO CALL BACK. THE CONSUMER CALLED BACK TWICE AND WAS TOLD THEY WERE STILL CLOSED. THE CONSUMER TOOK THE VEHICLE TO ANOTHER DEALERSHIP AND WAS TOLD THEY WERE BOOKED DESPITE HAVING AN APPOINTMENT. THE CONSUMER TOOK THE VEHICLE BACK TO THE DEALERSHIP THE FOLLOWING DAY AND WAS TOLD IT WOULD TAKE MOST OF THE DAY, BUT WHEN THE CONSUMER RECEIVED THE VEHICLE, THE INVOICE STATED THE PART HAD TO BE ORDERED. *JB
Service brakes, Hydraulic, Feb 10, 2004
CONSUMER COMPLAINED ABOUT A BRAKE PROBLEM. WHEN APPLYING THE BRAKES THEY VIBRATED.*AK
Steering, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Visibility, Equipment, Jan 15, 2004
IT IS BACK AT EARNHARDTS, FOR THE ELEC. SYSTEM AGAIN 4TH TIME. IT STARTED IN 3/02 AND WENT OUT AGAIN LAST FRI. 6/6/03 BUT THEY DON'T CONSIDER IT A PROBLEM. BECAUSE I FILED A LEMON LAW ON THE PREVIOUS ACCENT AND REPLACED IT WITH THE ELANTRA 2001 AND I FILLED OUT A SURVEY SAYING THEY HAD BAD CUSTOMER SERVICE, THE NORMAL USE OF A RENTAL WHILE THEY FIXED IT FOR DAYS WAS NOT GRANTED. I AM SO UPSET I SPENT A DAY OUT IN THE AZ SUN WAITING FOR A TOW OF 205 MILES TO THE NEXT DEALERSHIP AND THEY TELL ME I HAVE A BAD RECORD WITH THEM AND DON'T DESERVE THE COURTESY OF A RENTAL CAR. THIS IS MY SECOND HYNDAI AND I HAVE HAD NOTHING BUT TROUBLE WITH IT AND THE DEALERSHIP. I HAVE SENT LETTERS TO THE ATTORNEY GENERAL, THREE ON MY SIDE, HYNDAI AND EARNHARDTS DEALERSHIP. I WANT OUT OF THIS CAR AND DON'T FEEL SAFE IN IT ANY MORE. I WAS GOING DOWN THE SALT RIVER CANYON (IF YOU ARE NOT FROM AZ PICTURE GOING DOWN THE TWISTING ROAD TO THE GRAND CANYON) WITHOUT ANY POWER STEERING, BRAKES AND TRYING TO KEEP CONTROL OF THE CAR WITH KIDS IN IT. AND THEY TELL ME I SHOULDN'T BE EXCITED! 1 1/2 HRS IN THE SUN WAITING FOR THE TOW, THE NEXT DEALERSHIP 200 MI AWAY, NO RENTAL CARS AUTHORIZED, SO MY HUSBAND HAS TO DRIVE UP AND GET ME (198) MILES FROM MY HOUSE AND GO BACK SO HE COULD BE AT WORK IN 3 HRS. NO SLEEP FOR HIM. THE DATES ARE 3, 4, 6 OF 2002 AND NOW 6/6/03. THE MILEAGE IS 27,694. THE COST IS THEIRS BECAUSE IT HAS THE 100,000 WARRANTY. JUST THE MENTAL AND PHYSICAL ANGUISH AND INCONVIENCE OF ANOTHER CAR THAT WON'T WORK RIGHT NOW.
Service brakes, Hydraulic, Nov 19, 2003, crash
CONSUMER COMPLAINED ABOUT A BRAKE PROBLEM. WHEN DRIVER APPLIED BRAKES WHILE DRIVING 25-30 MPH VEHICLE DID NOT STOP. CONSUMER'S VEHICLE REAR ENDED VEHICLE IN FRONT. CURRENTLY, VEHICLE WAS BEING RECALLED FOR BRAKE MALFUNCTION.*AK
Service brakes, Hydraulic, Nov 6, 2003
WHILE DRIVING AT VARIOUS SPEEDS DRIVER DEPRESSED THE BRAKE PEDAL THE VEHICLE TOOK LONGER TO OPERATE, SO EXTENDED STOPPING DISTANCE WAS NECESSARY. *AK
Service brakes, Hydraulic, Oct 30, 2003, crash
WHILE DRIVING AT 30 MPH DRIVER APPLIED THE BRAKES AND THEY FAILED. VEHICLE TOOK LONGER TO STOP,AND IT REAR ENDED ANOTHER VEHICLE. PRIOR TO THE ACCIDENT, CONSUMER CALLED THE DEALER TO VERIFY IF NHTSA RECALL 03V25700 CONCERNING ABS FAILURE APPLIED TO HER VEHICLE. DEALER DENIED IT. THREE WEEKS AFTER THE ACCIDENT CONSUMER RECEIVED A RECALL LETTER ON THE ABS SYSTEM.*AK
Service brakes, Hydraulic, Sep 9, 2003
BRAKING FROM HIGHWAY SPEEDS 70 DOWN TO 50 RESULTS IN SERIOUS VIBRATION AND PULSATION DUE TO OUT OF ROUND DISC BRAKE ROTORS. FEELS LIKE POSSIBLE LOSS OF BRAKING CONTROL. PROBLEM HAS EXISTED SINCE VEHICLE WAS NEW AND CORRECTED ONLY BY MACHINING THE FRONT BRAKE ROTORS. ORIGINAL ROTORS MACHINED 3 TIMES IN 65000 MILES. ORIGINAL ROTORS RECENTLY REPLACED WITH NEW OEM PARTS AND PROBLEM OCCURED AGAIN WITHIN 5K MILES. COMPLAINED TO DEALER AND HYUNDAI REGIONAL MANAGER. EXPLANATION WAS THAT ROTORS ARE NOT DEFECTIVE IF OUT OF ROUND AND CONDITION CAN BE CORRECTED BY MACHINING. APPEARS ROTORS ARE UNABLE TO WITHSTAND BRAKING TEMPERATURES AND WARP AS RESULT. QUALITY OF STEEL MATERIAL USED IN MANUFACTURING THE ROTORS APPEARS POOR. HYUNDAI DOES NOT SEEM TO ACKNOWLEDGE PROBLEM WITH FLAW IN MANUFACTURING PROCESS.*AK
Service brakes, Hydraulic, Air bags, Aug 22, 2003
ABS WARNING LIGHT INTERMITTENTLY FLASHES ON AND STAYS ON WHILE DRIVING. THIS COULD RESULT IN EITHER NONE DEPLOYMENT OR PREMATURE DEPLOYMENT OF AIR BAGS. CAUSE OF THE PROBLEM UNDETERMINED. *AK ABL.PCO
Service brakes, Hydraulic, Air bags, Jul 10, 2003
AIR BAG LIGHT CONTINUED TO ILLUMINATE EVEN AFTER (4) ATTEMPTS BY THE DEALERSHIP. THE ACTUAL CAUSE HAD NOT BEEN IDENTIFIED. MR ALSO THE VEHICLE EXPERIENCED BRAKE PROBLEMS. PH *JB ABL.PCO
Service brakes, Hydraulic, Nov 12, 2002
THE BRAKE ROTOR OVERHEATED, WHICH CAUSED A GRINDING NOISE WHEN THE BRAKES WERE APPLIED. DEALER IS AWARE OF THE PROBLEM. MR *TT *JB
Service brakes, Hydraulic, Aug 26, 2002
THE NEXT DAY AFTER PURCHASE AND THE FIRST TIME I USED THE AUTO IN REVERSE THERE WAS A LOUD CLUNK FROM THE REAR RIGHT SIDE OF THE BRAKES. IT SOUND LIKE THE BRAKE SHOES WERE LOOSE AND THE RETAINING SPRINGS PULLED THE SHOES INTO PROPER ALIGNMENT WHEN THE SELF ADJUSTING BRAKES CAME INTO OPERATION. I WAS ON AN APPROCH RAMP AT 55 MILES AN HOUR TO MERGE AT 65 TO ONCOMING TRAFFIC. I WAS LOOKING BACK FOR ON COMING TRAFFIC, I LOOK UP AND A CAR WAS STOPPED, I SLAMMED ON THE BRAKES. THE CAR FINALLY STOP INCHES FROM THE AUTO AHEAD. NO SKID MARK. THE WHEELS DIDNT LOCKUP. I BROUGT THE CAR IN. ON ADVISE OF THE FACTORU THE CLEAND UP THE ROTORS, REPLACED THE FRONT PADS. THIS A POSITIVE INDICATION THAT THEY ARE AWARE OF SUCH A PROBLEM. UPON A TEST DRIVE ON MY OWN I FOUND I COULD NOT LOCK UP THE BRAKES. LATER I TOOK THE CAR BACK AND HAD THE SERVICE MANAGER TEST DRIVE THE CAR WITH ME. HE ALSO COULD NOT LOCK UP THE BRAKES. HE SAID HE TEST DROVE 2 OTHER ELANTRAS AND THEY REACTED THE SAME. POLICE MEASURE SPEED AT AN ACCIDENT BY THE SKID MARKS LEFT. IF I WERE TO GET INTO AN ACCIDENT THEY WOULD FIND NO SKID AN ASSUME I DIDNT EVEN APPLY THE BRAKES!!! THESE ARE NOT ANTI LOCK. I'M WORRIED. I NEED HELP BEFORE I'M KILLED AND THE ACCIDENT REPORT SAYS, HE DIDNT EVEN APPLY THE BRAKES. THERE WERE NOT SKID MARKS AND THE POLICE COULD ONLY SPECULATE AT WHAT SPEED HE MUST HAVE BEEN TRAVELING. H E MUST HAVE BEEN DRUNK, HAD A HEART ATTACK OR PASSED OUT.*AK
Service brakes, Hydraulic, Air bags, Jun 13, 2002, crash
CONSUMER APPLIED BRAKES AT 30-35 MPH, VEHICLE DID NOT SLOW DOWN. CONSUMER PUMPED BRAKE PEDAL NUMEROUS TIMES, NO BRAKING ACTION, VEHICLE HIT A CONCRETE WALL. VEHICLE WAS TOTALLED.*AK DRIVER AND PASSENGER SUFFERED INJURIES. NONE OF THE AIR BAGS DEPLOYED IN THE ACCIDENT. *JG
Steering, Service brakes, Hydraulic, Engine and engine cooling, Air bags, Jan 19, 2002
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Service brakes, Hydraulic, Sep 7, 2001
BRAKES ENGAGING AND OVERHEATING ON THE FREEWAY, INTERMITTENTLY; THIS MAY AFFECT THE ABILITY TO STOP QUICKLY ENOUGH IN AN EMERGENCY. DETAILS: SINCE THE BRAKES WERE FIRST SERVICED AT JUST UNDER 4,000 MILES, THERE IS A CONTINUING PROBLEM WITH THE BRAKES RANDOMLY ENGAGING BY THEMSELVES ON THE FREEWAY. WHEN THIS HAPPENS, ITS NOT SUFFICIENT TO CAUSE THE VEHICLE TO STOP, BUT THE CAR AT TIMES WILL LABOR TO MAINTAIN SPEED. THE CAR ALSO PRODUCES A LOW PITCH HUMMING SOUND AND A STIFF VIBRATION (SHIMMY) IN THE STEERING WHEEL. THE BRAKE PEDAL PULSATES WHEN BARELY TOUCHED (AT THE TIME THIS PHENOMENON IS OCCURRING). AFTER A NUMBER OF MILES THE SYMPTOMS DISAPPEAR. THE FREQUENCY OF THIS EVENT IS ABOUT ONCE EVERY 100 TO 200 MILES. I BELIEVE THE HUMMING, STEERING WHEEL VIBRATION, AND PULSATING FEELING OF THE BRAKE PEDAL IS BECAUSE THE BRAKES ARE IN AN OVERHEATED STATE DUE TO THE CALIPERS DRAGGING. HYUNDAI SERVICE IS UNABLE TO REPLICATE THIS PROBLEM, BUT I STRONGLY BELIEVE THIS IS BECAUSE OF THEIR FAILURE TO SUFFICIENTLY ROAD TEST THE VEHICLE; I.E., THEY MAY HAVE TO ROAD TEST THE VEHICLE FOR 2 HOURS IN VARYING CONDITIONS, HOT WEATHER, MOSTLY FREEWAY TO REPLICATE. HYUNDAI, AFTER BEING GIVEN THE ABOVE DESCRIPTION OF PROBLEMS ON TWO DIFFERENT SERVICE CALLS, HAS NEVER RESOLVED THE ISSUE (OF COURSE, MEANING THE CAUSE OF THE PROBLEM REMAINS A MYSTERY). I HAVE VIDEOTAPED THIS PHENOMENON, WHICH HAPPENS ABOUT 30 MINUTES INTO THE VIDEOTAPING SESSION. I AM WILLING TO MAKE COPIES AND SEND TO THOSE WHO FEEL VIEWING THE TAPE WOULD BE HELPFUL IN DETERMINING THE APPROPRIATE COURSE OF ACTION. PLEASE ADVISE IF YOUD LIKE A COPY OF THE VIDEOTAPE, AND IF SO, WHERE IT SHOULD BE SENT. PLEASE E-MAIL AT: JKUNST@SWIFTCOR.COM. *AK