2004 Hyundai Santa FE
Problems, recalls and owner-reported issues
Suspension is the leading concern among 303 owner complaints filed for this model year. This is the 9th highest complaint count among 25 Santa FE model years with reports.
Of the 2004 reports, 32 involved a crash and 7 involved a fire. 35 people were injured.
What owners report most often
Recalls and investigations
Suspension, front, springs, coil springsJul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 salt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. The affected vehicles may experience front coil spring corrosion from road salt, causing the coil spring to fracture and make contact with the tire.
If the front coil spring fractures due to corrosion it could cause the coil spring to make contact with the tire, possibly puncturing the tire and increasing the risk of a vehicle crash.
Hyundai will notify owners, and dealers will inspect and if necessary replace the coil spring, free of charge. The recall began on October 24, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 124.
Campaign 14V435000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleMar 16, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5 LITER V-6 ENGINES, 4-WHEEL DRIVE AND ANTILOCK BRAKING SYSTEMS (ABS), IF THE BRAKE PEDAL IS DEPRESSED AT SPEEDS BETWEEN 3 AND 12 MPH WHEN THE BRAKE PAD FRICTION SURFACES ARE WET, A VIBRATION MAY OCCUR BETWEEN THE BRAKE DISCS AND PADS CAUSING ABS SENSOR ELECTRONIC SIGNAL NOISE TO DEVELOP. AT SPEEDS BELOW 5 MPH, THE ABS SENSOR SIGNAL NOISE MAY CAUSE THE ABS ELECTRONIC CONTROL UNIT (ECU) TO ACTIVATE THE ABS, EXTENDING THE STOPPING DISTANCE.
IF AN EXTENDED STOPPING DISTANCE OCCURS, IT COULD RESULT IN A CRASH.
DEALERS WILL REPROGRAM THE ABS ECU. OWNER NOTIFICATION BEGAN ON MARCH 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 04V131000 on NHTSA.gov
Equipment, other, labelsDec 18, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
THE TIRE PRESSURE LABELS DO NOT CONTAIN THE INFORMATION REQUIRED BY THE STANDARD.
OWNERS WILL BE PROVIDED WITH A CORRECT LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 29, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 03V520000 on NHTSA.gov
Representative owner complaints
303 reports, newest first.
Suspension, Air bags, Jun 1, 2015
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP FLASHED RANDOMLY. THE VEHICLE WAS ALSO INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). THE PART WAS UNAVAILABLE TO SCHEDULE THE RECALL REPAIR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.
Suspension, Service brakes, Hydraulic, Apr 8, 2015
2004 HYUNDAI SANTA FE. CONSUMER REQUESTS REMAINING REIMBURSEMENT FOR RECALL REPAIRS. *SMD
Suspension, Apr 1, 2015
GOT INTO CAR MORNING OF THE TENTH. CAR WAS MAKING NOISE. PARKED CAR. HUSBAND TOOK LOOK AT IT NOTICE HEAT SHIELD LOSE. THAT DID NOT TURN OUT TO BE NOISE.ON CLOSER INSPECTION NOTICE BROKEN COIL SPRING FRONT DRIVERS SIDE. FUNNY THEY ARE RECALLING THIS MODEL CAR FOR THIS POTENTIAL PROBLEM, BUT MY 2004 SANTA FE ACTUALLY HAD THIS FAILURE AND IT IS NOT COVERED ! *TR
Power train, Engine, Mar 5, 2015
AS I APPROACHED A STOP LIGHT AND MY CAR BEGAN TO SLOW, IT DIDN'T SHIFT ALL THE WAY INTO FIRST GEAR. WHILE STOPPED AT THE LIGHT, IT REMAINED AT A HIGH RPM WHILE THE BRAKE WAS PRESSED. WHEN THE LIGHT CHANGED, AND THE GAS PEDAL WAS PRESSED, MY CAR "KICKED" DOWN INTO FIRST AND IMMEDIATELY BACK IN TO SECOND. A FEW DAYS LATER WHILE AT A STOP LIGHT, MY CAR DIED. AFTER A FEW MINUTES, IT STARTED BACK UP. AFTER BRINGING IT TO THE DEALER (IT HAD DIED ON MY THREE TIMES AT THIS POINT) TO HAVE IT SERVICED, I WAS TOLD THAT THEY COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE. THEY WERE ABLE TO "FEEL" THE SHIFTING ISSUES WHEN STOPPING BUT THEY COULDN'T TELL ME WHAT WAS WRONG WITH IT. SINCE I'VE HAD MY VEHICLE BACK FROM THE SHOP, IT HAS BEEN HAVING HIGH IDLE SURGES WHERE THE RESTING IDLE RPM IS AT 2000, IN ADDITION, WHEN THE VEHICLE IS IN NEUTRAL IT ACTS AS IF SOMETHING IS PUSHING THE GAS PEDAL WHILE MY FOOT IS ON THE BRAKE GOING BACK AND FORTH BETWEEN 800 AND 2000 RPM. WHEN THE VEHICLE IS IN DRIVE AND MY FOOT IS ON THE BRAKE, IT ALSO FEELS LIKE MY VEHICLE WANTS TO GET UP AND GO (AGAIN LIKE SOMETHING IS PUSHING ON THE GAS PEDAL). I HAVE TAKEN MY VEHICLE TO TWO DIFFERENT PLACES AND BOTH PLACES CAN'T PINPOINT WHAT IS WRONG WITH MY VEHICLE. IT'S STARTING TO BECOME A SAFETY CONCERN. WHAT IF WHATEVER IS GOING ON WITH MY VEHICLE OVERRIDES THE BRAKE SYSTEM AND I END UP HURTING SOMEONE? *TR
Steering, Service brakes, Engine, Jan 27, 2015, fire
THIS VEHICLE WAS DRIVEN APPROX. 1/2 MILE FROM HOME WHEN POWER STEERING AND BRAKES FAILED. IT WAS PULLED OFF OF THE ROAD AND STOPPED WITH THE EMERGENCY BRAKE. IMMEDIATELY FLAMES SHOT UP THE WINDSHIELD. THE ENTIRE INTERIOR WAS COMPLETELY DESTROYED AS WELL 3/4 OF THE EXTERIOR. *TR
Suspension, Jan 15, 2015
HYUNDAI RECALL CAMPAIGN 124/THE DEALER ORDERED THE FRONT COIL SPRING ON 12/16/2014 AND HAS NEVER RECEIVED IT. HYUNDAI CAN NOT TELL THEM WHERE THE PART IS AND HAS NOT BEEN HELPFUL IN LOCATING ANOTHER PART. A TIRE BURST DUE TO THE RECALLED PART SO THE CAR HAS BEEN SITTING UNDRIVEABLE AT THE MAGUIRE DEALERSHIP IN ITHACA NY FOR OVER A MONTH. AS A CONSUMER WE HAVE NOT BEEN ABLE TO GET ANY ANSWERS FROM HYUNDAI. THIS IS A RECALLED PART AND THEY ARE NOT MAKING ANY EFFORT TO FIX THE VEHICLE. *TR
Suspension, Dec 26, 2014
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THERE WAS A LOUD NOISE COMING FROM THE FRONT END AS THE VEHICLE VEERED TO THE RIGHT. THE VEHICLE WAS SHIFTED TO PARK TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FRONT DRIVER'S SIDE COIL SPRING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. ADDITIONALLY, THE CONTACT NOTICED THAT THE COIL SPRING OF THE FRONT PASSENGER'S SIDE FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V350000 (SUSPENSION). THE FAILURE MILEAGE WAS 92,000.
Electrical system, Air bags, Seats, Nov 30, 2014
WHILE LOOKING FOR A PARKING PLACE, THE AIR BAG IN THE BACK OF THE DRIVER SIDE FRONT SEAT SPONTANEOUSLY DEPLOYED, INJURING MY BACK AND MY LEFT KNEE. MY CHIROPRACTOR GOT MY BACK SOMEWHAT REPAIRED, BUT MY KNEE ENDED UP HAVING A MENISCUS TEAR THAT HAS NOT YET BEEN REPAIRED. HYUNDAI IS WILLING TO REPLACE WHAT MY INSURANCE COMPANY PAID OUT FOR MEDICAL CARE AND TO FIX MY CAR. I WILL BE HAVING MEDICAL ISSUES FOR THE REST OF MY LIFE THANKS TO THIS AIR BAG INCIDENT. I BELIEVE HYUNDAI SHOULD PAY FOR ALL FUTURE MEDICAL ISSUES RESULTING FROM THIS INCIDENT BUT .... THEY INVESTIGATED AND ARE SAYING THAT THE "COMPUTER SHOWS AN IMPACT SEVERE ENOUGH TO CAUSE THE DEPLOYMENT" SO THEY ARE WILLING TO REPLACE THE SEAT AND REIMBURSE ONLY THE INSURANCE COMPANY. THEY SAY FUTURE MEDICAL ISSUES ARE MY RESPONSIBILITY. I DO NOT BELIEVE THIS SHOULD BE THIS WAY. THEIR PRODUCT CAUSED IT, THEY SHOULD BE RESPONSIBLE! *TR
Vehicle speed control, Engine, Nov 25, 2014
THE VEHICLE ACCELERATED TO A HIGH RATE OF SPEED WHEN JUST TOUCHING THE GAS PEDAL. THE BRAKE MUST IMMEDIATELY BE ENGAGED TO SLOW THE CAR. ONCE THE CAR IS MOVING THE ACCELERATOR WORKS. WHILE CRUISING THE ENGINE RPM SURGES FORCING THE BRAKES TO BE ENGAGED.THIS IS A DANGEROUS SITUATION IN TRAFFIC. THE PREVIOUS OWNER SAID THE VEHICLE HAS BEEN DOING THIS FOR YEARS AND SHE JUST LIVED WITH IT. IT IS UNSETTLING TO HAVE A VEHICLE SURGE WHENEVER IT WANTS. *TR
Service brakes, Nov 13, 2014
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THERE WAS A STRONG VIBRATION COMING FROM THE FRONT BRAKES. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER ON MULTIPLE OCCASIONS WHERE IT WAS REPAIRED BUT THE FAILURE RECURRED. THE REPAIR SPECIFICS WERE NOT AVAILABLE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V131000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE. UPDATED 12/22/14*LJ THE CONSUMER STATED THE VEHICLE HAS HAD A PULSATING SENSATION FROM THE BRAKES. THE VEHICLE WOULD TAKE LONGER TO STOP AND THERE WOULD BE VIBRATION IN THE STEERING WHEEL. THE CONSUMER WAS INFORMED THERE WAS THE VEHICLE WAS NOT INCLUDED IN THE RECALL FOR THE BRAKES. THE CONSUMER NEARLY HAD AN ACCIDENT WITH A SEMI TRUCK DUE TO THE FAILURE. UPDATED 05/26/2015 *JS
Suspension, Nov 12, 2014
TOOK MY HYUNDAI SANTA FE IN FOR THE RECALL ON THE SPRING ISSUE. AFTER RETURNING HOME AND LOOKING AT THE WORK ORDER THAT LISTED THEIR ACTIVITY AS INSTALLING A ?FRONT SPRING PROTECTOR INSTALLATION,? I CALLED THEIR NATIONAL CONSUMER HELP NUMBER AND ASKED ABOUT THE PARAMETERS USED IN EVALUATING THE REPAIR DECISION. HER ANSWER WAS: THE DEALER WILL INSPECT AND DO EITHER A SPRING REPLACEMENT IF SEVER DAMAGE IS FOUND OR INSTALL A FRONT SPRING PROTECTION KIT AND SPRAY APPLICATION (OF SOMETHING) IF MODERATE DAMAGE IS FOUND. I QUESTIONED THE PARAMETERS FOR LEADING TO A DECISION, THE FIRST PERSON I TALKED TO SAID IT WAS THE DEALERS RESPONSIBILITY. I RESPONDED BY ASKING FOR A SUPERVISOR, AFTER TRANSFER SHE REPEATED THE PREVIOUS ANSWER. I HAVE BEEN INVOLVED IN MANY STRUCTURAL EVALUATIONS OF RUSTY STRUCTURAL ELEMENTS. ONE CANNOT JUST EYEBALL A SITUATION LIKE THIS, THERE ARE PARAMETERS FOR THE REPAIR OR REPLACEMENT. I FOUND THE SUPERVISORS ANSWER, THAT SHE COULD NOT DIRECT ME TO A CORPORATE ENGINEERING OFFICE FOR SPECIFIC DESIGN PARAMETERS AND THAT THE DEALERS WOULD BE MAKING THE DECISIONS WAS QUESTIONABLE AT BEST IN TERMS OF THEIR ANSWER, WITH NO DEFINED EVALUATIVE CRITERIA AND THEIR RELIABILITY ON THE DEALERS TO MAKE A SAFETY CHOICE OVER A ECONOMIC ONE. THE RECALL WAS FROM HYUNDAI NOT THE DEALER I PURCHASED FROM. THERE WERE TWO OTHER INSTANCES RELATING TO RUST ON THIS CAR, THE CAR NEEDED TO HAVE ITS FUEL TANK REPLACED A FEW YEARS AGO BECAUSE IT WAS RUSTING AND LEAKING GASOLINE, I HAVE THE EXTENDED BUMPER TO BUMPER 100,000 MILE WARRANTY. LITTLE DID THAT HELP, THEY CLAIMED IT WAS NOT COVERED (WHAT DOES BUMPER TO BUMPER MEAN) AND DENIED COVERAGE. A SEPARATE ISSUE OCCURRED WHEN THE CAR DIED ABOUT 100 YARDS FROM MY SERVICE GARAGE, PUSHED IT IN, THEY FOUND A CORRODED WIRE (WHAT EVER) AND REPLACED IT. WHEN I CALLED FOR REIMBURSEMENT, THEY DENIED IT. *TR
Suspension, Nov 12, 2014
I WAS COMING HOME FROM THE STORE AND HAD JUST TURNED INTO MY DRIVEWAY WHEN MY CAR SUDDENLY VEERED TO THE RIGHT AND STOPPED. I HEARD A LOUD NOISE AND THE ENTIRE SIDE OF MY CAR COLLAPSED ON THE RIGHT SIDE. SOMETHING WAS STICKING INTO THE TIRE. I HAD TO HAVE IT TOWED TO THE DEALERS AND REPAIRED. IT COST US OVER $500. IT WAS STILL UNDER THE DEALERS WARRANTY, BUT WAS NOT COVERED. WE FEEL WE SHOULD BE REIMBURSED. *TR
Suspension, Nov 10, 2014
2004 HYUNDAI SANTA FE. CONSUMER WRITES IN REGARDS TO FRONT COIL SPRING RECALL. *SMD THE CONSUMER STATED SHE WAS DRIVING AT A SLOW SPEED, WHEN THE FRONT COIL SPRING FAILED AND THE VEHICLE IMMEDIATELY CAME TO STOP WITH THE COIL SPRING PUSHING AGAINST THE RIGHT TIRE . THE CONSUMER IS SEEKING REIMBURSEMENT FOR THE DECEMBER 19, 2011 INCIDENT. *JB
Steering, Suspension, Wheels, Nov 4, 2014
ON 12/31/2012, THE COIL SPRING ON MY 2004 HYUNDAI SANTA FE FRACTURED AND PUNCTURED THE RIGHT FRONT TIRE OF THE VEHICLE. I PAID UPWARDS OF $2000 ON 1/7/2013 TO HAVE THIS REPAIRED. I HAVE SINCE TRADED IN THE VEHICLE AND NO LONGER OWN IT. I RECENTLY RECEIVED A RECALL NOTICE FROM HYUNDAI USA DESCRIBING THE SAME COIL SPRING FRACTURE THAT I EXPERIENCED A COUPLE OF YEARS EARLIER. THIS RECALL IS CALLED 'CAMPAIGN124' BY HYUNDAI. TODAY (11/4/2014), I CALLED TO INQUIRE ABOUT THE POSSIBILITY FOR SOME REIMBURSEMENT FOR THE REPAIR I HAD PERFORMED AFTER MY INCIDENT. I WAS INFORMED THAT THIS WAS NOT POSSIBLE SINCE I NO LONGER OWNED THE VEHICLE AND THE REPAIR COULD NOT BE INSPECTED BY HYUNDAI, I DON'T FEEL THAT THIS IS RIGHT AND I SHOULD BE ENTITLED TO SOME REIMBURSEMENT. IF REQUESTED, I WOULD BE ABLE TO PROVIDE DETAIL OF THE WORK PERFORMED BY THE MECHANIC WHO PERFORMED THE SERVICE. *TR
Suspension, Oct 30, 2014
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, A LOUD NOISE EMITTED FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FRONT COIL SPRING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). THE FAILURE MILEAGE WAS 70,000.
Suspension, Oct 28, 2014
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 40 MPH, A LOUD NOISE EMITTED FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FRONT COIL SPRING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.
Electrical system, Engine, Oct 27, 2014
THE FIRST OCCURRENCE WAS TUES. OCT. 21 BACKING OUT OF A DRIVEWAY AND WENT TO PUT THE CAR IN DRIVE. IT STALLED RIGHT IN THE MIDDLE OF A VERY BUSY ROAD. I PUT IT IN PARK AND TRIED TO START IT AGAIN. IT DID START BUT DID NOT FEEL LIKE IT WOULD CONTINUE TO RUN. HOWEVER, IT DID. THE SECOND TIME WAS YESTERDAY WHEN I WAS DRIVING DOWN A FOUR LANE ROAD AT 40 MILES AN HOUR AND IT JUST STOPPED RUNNING. I WAS SO THANKFUL IT WAS LATER IN THE EVENING AND TRAFFIC WAS VERY MINIMAL. I PUT IT IN PARK AND IT DID START BUT AGAIN DID NOT FEEL LIKE IT WOULD CONTINUE. IT FELT LIKE IT WOULD STALL AGAIN BUT DID NOT, 2 MORE TIMES BEFORE I GOT HOME. I CALLED THIS MORNING TO GET IT RIGHT IN AND NEVER HEARD BACK. I AM AFRAID TO DRIVE IT BECAUSE OF THE TRAFFIC ON MOST OF THESE ROADS. I DO NOT FEEL LIKE I WAS TAKEN SERIOUSLY EVEN THOUGH I RECEIVED A RECALL NOTICE IN SEPT. BUT HAVE MANAGED TO MISPLACE IT. I DO NOT REMEMBER WHAT THE RECALL WAS FOR. THE SECOND TIME THIS HAPPENED A PANEL LIGHT DID COME ON. IT WAS THE MALFUNCTION INDICATOR LIGHT. I AM WORRIED ABOUT AN ACCIDENT AND POSSIBLE DEATH WITH THIS HAPPENING TO THE CAR. *TR
Suspension, Wheels, Oct 20, 2014
THIS VEHICLE HAS BEEN DRIVEN EXTENSIVELY YEAR ROUND, INCLUDING SNOWY NORTHEAST OHIO WINTERS. ON A SOMEWHAT COLD DAY IN MARCH 2014, MY 2004 SANTA FE SAT OUTSIDE ON A SURFACE LOT FOR APPROXIMATELY 14 HOURS. AS I PULLED MY CAR OUT OF THE PARKING SPACE, THE CAR LURCHED TO THE FRONT RIGHT AND CAME TO A HALT. I HAD PULLED FORWARD APPROXIMATELY 3 FEET, HAD TURNED THE WHEEL SLIGHTLY TO THE RIGHT, AND JUST BEGAN TO HIT THE GAS TO PULL OUT OF THE PARKING SPACE. IT WAS QUITE OBVIOUS THAT MY FRONT RIGHT TIRE HAD BLOWN VIOLENTLY. NO ACCIDENTS OCCURED WITH OTHER VEHICLES AND NO INJURIES OCCURED; HOWEVER, SHOULD SOMEONE HAVE BEEN STANDING NEAR THE FRONT RIGHT TIRE, SOMEONE MAY HAVE BEEN HURT. WHILE TRYING TO CHANGE THE TIRE, IT BECAME OBVIOUS THAT THE SPRING HAD BROKEN AND MADE CONTACT WITH THE TIRE. THE VEHICLE NEEDED TO BE TOWED ON A FLATBED AND REPAIRS WERE MADE. I STILL OWN THE VEHICLE, AND I AM NOW AWARE THAT THIS PART HAS BEEN RECALLED FOR THIS EXACT ISSUE. I AM CONCERNED ABOUT THE INTEGRITY OF THE SPRING ON THE OPPOSITE SIDE AS IT IS CURRENTLY AN ORIGINAL PART. *TR
Suspension, Oct 15, 2014
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Suspension, Structure, Oct 14, 2014
RECEIVED LETTER FROM HYUNDAI THAT THE COMPANY WAS "PREPARING A REMEDY" FOR POSSIBLE RUSTING SPRINGS ON MY SANTA FE. I WAITED ABOUT A MONTH FOR SECOND LETTER AS TO WHERE AND WHEN TO GET SPRINGS INSPECTED. CALLED HYUNDAI 1-855-671-3059 GOT RUN AROUND NO ASSISTANCE. I CAN GET CAR INSPECTED MYSELF AND PAY FOR SPRINGS MYSELF. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Suspension, Oct 10, 2014
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE FRONT END OF THE VEHICLE SWAYED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.
Steering, Structure, Oct 3, 2014
FOR A LONG TIME I KEPT HEARING THIS CLUNKING TYPE NOISE BUT WE COULDN'T FIGURE OUT WHAT IT WAS. THEN ON SUN. SEPT. 21, 2014 I NOTICED SOME EXTRA PLAY IN THE WHEEL. WHEN I MADE A TURN I HAD TO TURN THE WHEEL TWICE AS MUCH AS NORMAL AND THEN IT LOCKED AND I HAD TO REALLY PULL HARD TO GET IT BACK STRAIGHT. WE VERY CAREFULLY DROVE IT TO THE AUTO SHOP ONLY A MILE AWAY. THEY SAID MY POWER STEERING LINE WAS RIPPED OPEN. THEY SAID THE BOLT THAT ATTACHES TO THE POWER STEERING GEAR RACK SHEARED OFF OF THE SUBFRAME. I HAVE PICTURES. ALSO SINCE THERE IS A RECALL ON THE COIL SPRINGS FOR CARS SOLD IN THE SALT BELT I THOUGHT THIS ALSO COULD BE A CORROSION ISSUE BECAUSE THE MECHANIC SAID HE HAS NEVER SEEN THIS BEFORE. THE BOLT DIDN'T COME LOOSE, THE ACTUAL SUBFRAME TORE APART AND THE STEERING RACK WAS JUST HANGING THERE BY ONE BOLT AND OVER TIME IT RIPPED THE RUBBER TO SHREDS. THIS COULD HAVE CAUSE FATALITIES. WE HAD TO PURCHASE A NEW SUBFRAME AND STEERING RACK TO GET THE CAR DRIVABLE. IT SEEMS TO ME IT WAS FAULTY MANUFACTURING OR A RUST CORROSION ISSUE. THE SUBFRAME IS A HUGE THICK IRON FRAME WHERE YOU WOULD THINK NOTHING COULD BREAK IT, BUT IN THIS INSTANCE IT ACTUALLY RIPPED. I WOULD LIKE SOME COMPENSATION FOR THE REPAIRS. I WANTED THIS COMPLAINT OUT THERE BECAUSE IT COULD BECOME A SAFETY ISSUE FOR OTHER DRIVERS. *TR
Suspension, Oct 3, 2014
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE DRIVER AND PASSENGER SIDE FRONT COIL SPRINGS DEVELOPED CRACKS. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION); HOWEVER, THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE DEALER COULD NOT PROVIDE A SPECIFIC TIMEFRAME FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 100,000.
Fuel/propulsion system, Oct 2, 2014
I BROUGHT THE VEHICLE IN FOR AN OIL CHANGE. THE GENTLEMAN SAID THAT THE FUEL TANK HAS A RUST HOLE IN IT AND IS LEAKING FUEL. THIS IS CAUSED BY A PLASTIC COVER THAT RETAINS SALT AND MOISTURE AND CAUSES THE TANK TO RUST. *TR
Electrical system, Sep 29, 2014
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE DECELERATED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE ACCELERATOR POSITION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 65,000.