2005 Hyundai Santa FE
Problems, recalls and owner-reported issues
Air bags is the leading concern among 216 owner complaints filed for this model year. This is the 13th highest complaint count among 25 Santa FE model years with reports.
Of the 2005 reports, 18 involved a crash. 14 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Suspension, front, springs, coil springsJul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 salt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. The affected vehicles may experience front coil spring corrosion from road salt, causing the coil spring to fracture and make contact with the tire.
If the front coil spring fractures due to corrosion it could cause the coil spring to make contact with the tire, possibly puncturing the tire and increasing the risk of a vehicle crash.
Hyundai will notify owners, and dealers will inspect and if necessary replace the coil spring, free of charge. The recall began on October 24, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 124.
Campaign 14V435000 on NHTSA.gov
Air bags, frontalNov 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN OCCUPANT CLASSIFICATION SYSTEM (OCS) THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY CERTAIN SMALL CHILDREN SEATED ON THE FRONT EDGE OF THE SEAT AS AN ADULT.
THE POSSIBILITY OF MISCLASSIFICATION OF CERTAIN SMALL CHILDREN AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG TO DEPLOY IN A FRONTAL COLLISION CRASH OR THE SIDE IMPACT AIRBAG TO DEPLOY IN A SIDE COLLISION CRASH; SEVERE INJURY OR DEATH COULD OCCUR.
DEALERS WILL ENSURE THAT THE VEHICLE'S OCS WILL PROPERLY CLASSIFY CERTAIN SMALL CHILDREN WHEN SEATED ON THE FRONT EDGE OF THE SEAT AND WILL DISABLE THE RIGHT FRONT AIRBAGS. DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT TO PROVIDE AN INCREASED MARGIN FOR RECOGNITION OF CERTAIN SMALL CHILDREN. THE RECALL BEGAN ON DECEMBER 6, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
Campaign 05V527000 on NHTSA.gov
Air bagsOct 4, 2005
ON CERTAIN VEHICLES EQUIPPED WITH AN OCCUPANT CLASSIFICATION SYSTEM (OCS) THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY CERTAIN SMALL CHILDREN SEATED ON THE FRONT EDGE OF THE SEAT AS AN ADULT.
THE POSSIBILITY OF MISCLASSIFICATION OF CERTAIN SMALL CHILDREN AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG TO DEPLOY IN A FRONTAL COLLISION CRASH OR THE SIDE IMPACT AIRBAG TO DEPLOY IN A SIDE COLLISION CRASH; SEVERE INJURY OR DEATH COULD OCCUR.
DEALERS WILL ENSURE THAT THE VEHICLE'S OCS WILL PROPERLY CLASSIFY CERTAIN SMALL CHILDREN WHEN SEATED ON THE FRONT EDGE OF THE SEAT AND WILL DISABLE THE RIGHT FRONT AIRBAGS. DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT TO PROVIDE AN INCREASED MARGIN FOR RECOGNITION OF CERTAIN SMALL CHILDREN. THE RECALL BEGAN ON DECEMBER 21, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 05V450000 on NHTSA.gov
Representative owner complaints: fuel/propulsion system
14 reports, newest first. Show all
Other or unspecified, Engine, Fuel/propulsion system, Apr 18, 2023
Car all of a sudden stopped running like normal. Can't go above 20 mph without sounding like backfiring or dying
Vehicle speed control, Fuel/propulsion system, Jan 1, 2020
WHILE BACKING OUT OF GARAGE THROTTLE STUCK NEARLY CAUSING A MAJOR ACCIDENT. FAULTY TPS SEEN MANY WITH SAME COMPLAINTS..
Fuel/propulsion system, May 15, 2019
GAS TANK HAS CORROSION AND MECHANIC CONFIRMS THE TANK IS LEAKING GASOLINE DUE TO THE CORROSION!!!!
Engine, Fuel/propulsion system, Jun 25, 2018
GAS IS LEAKING OUT OF OF THE CAR THE GAS TANK IS BAD I WAS DRIVING THE CAR AND IT STOPPED
Fuel/propulsion system, Nov 10, 2017
LEAKY GAS TANK WAS REPLACED THIS SUMMER AND NOW I HAVE GAS FUMES AGAIN
Power train, Engine, Fuel/propulsion system, Jul 26, 2017
I WAS DRIVING COMING UP TO A TURN, TOOK THE LEFT TURN, AND ACCELERATED LIKE A NORMALLY DO, THE CAR'S RPMS WENT UP TO ABOUT 5 THOUSAND RPMS. I HEARD A POP LIKE NOISE AND THE RPMS JUST STARTED DROPPING AND THERE WAS NO RESTRICTION ON THE GAS PEDAL (FELT LIKE I WAS PUSHING AIR). THE VEHICLE THEN JUST ROLLED ONCE IT WAS AT ABOUT 10 MPH RPMS WENT UNDER 1 THOUSAND AND THE VEHICLE DIED. WHEN I TRIED TO RESTART IT IT WAS JUST CRANK AND CRANK, DOESN'T EVEN SOUND LIKE IT WANTS TO TURN OVER. PLEASE HELP.
Fuel/propulsion system, Oct 24, 2016
PURCHASED A 2005 HYUNDAI SANTA FE AND FOUND AFTERWARD THAT THE FUEL TANK WAS LEAKING FROM INSIDE THE PLASTIC SHELL SURROUNDING IT. DISCOVERED AT THAT TIME THAT THIS IS A COMMON PROBLEM IN STATES THAT HAVE CORROSION (ROAD SALT) AND IT IS DIFFICULT TO SPOT BECAUSE OF THE PLASTIC SHELL. FOUND THAT HYUNDAI HAD NOT DONE A RECALL BUT EXTENDED THE WARRANTY, BUT ONLY AN ADDITIONAL 5 YEARS OR 50, 000 MILES ON THE FUEL TANK. CONTACTED HYUNDAI BECAUSE LOCAL DEALER STATED THAT THEY (THE COMPANY) HAVE REPAIRED THESE AFTER THE VEHICLE HAS EXCEEDED 150,000 MILES AT COMPANY COST BUT I WENT THROUGH THE STEPS WITH THEIR CONSUMER AFFAIRS DIVISION AND WAS TURNED DOWN. VEHICLE CANNOT BE DRIVEN BECAUSE OF LEAKING FUEL RIGHT NEXT TO HOT EXHAUST PIPE. THIS NEEDS TO BE A RECALL.
Fuel/propulsion system, Jun 28, 2016
TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. WHILE DRIVING 35 MPH, THE CONTACT NOTICED A FUEL ODOR INSIDE THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE EVAC CANISTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000. UPDATED 10/19/16*LJ THE CONSUMER STATED THE FUMES CAUSED THE DRIVER AND PASSENGER TO BECOME NAUSEOUS AND NEARLY PASSED OUT WHILE DRIVING. *JS
Fuel/propulsion system, Jun 23, 2016
TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING, A FUEL ODOR EMITTED IN THE INTERIOR AND EXTERIOR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL TANK WAS RUSTED AND LEAKING. AS A RESULT, THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V317000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 94,000.
Fuel/propulsion system, Jun 22, 2016
TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT THERE WAS A STRONG FUEL ODOR COMING FROM THE VEHICLE, AS WELL AS A FUEL PUDDLE UNDER THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V317000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
Fuel/propulsion system, Mar 7, 2016
GAS TANK IS CORRODED AND LEAKING FUEL DUE TO ROAD SALT BECAUSE I LIVE IN THE NORTHEAST. I WAS NOTIFIED THAT HYUNDAI HAS "EXTENDED THE WARRANTY" ON MODEL YEARS 2001-2006 UP TO 150,000 MILES. I DO NOT BELIEVE THIS "EXTENDED WARRANTY" SHOULD HAVE A MILEAGE RESTRICTION, AND I ALSO DO NOT BELIEVE THIS SHOULD BE AN EXTENSION OF THE WARRANTY BUT AN ALL OUR RECALL BY HYUNDAI. CARS ARE LEAKING GAS! MY CAR HAS NO OTHER RUST ON IT AND I KEEP MY CAR CLEAN AND PARKED IN MY GARAGE. MY GAS TANK SHOULD NOT BE RUSTED OUT ON A CAR THAT IS 10 YEARS OLD. I ALSO OWN A 1999 AND ANOTHER 2005 HYUNDAI (ELANTRA & SONATA) AND NEITHER HAVE ANY GAS TANK CORROSION. THIS IS A DESIGN FLAW AND A DANGEROUS SITUATION.
Fuel/propulsion system, Oct 29, 2014
IN CRUISE CONTROL MODE, THE VEHICLE WOULD NOT DECELERATE WHEN THE REDUCE SPEED/COAST BUTTON WAS PUSHED. THIS INCIDENT WAS NOT THE FIRST SUCH INCIDENT; AT LEAST 10 SIMILAR INCIDENTS OCCURRED PREVIOUS TO THAT INCIDENT, AND 4 INCIDENTS SINCE. *TR
Fuel/propulsion system, Sep 22, 2014
TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT FUEL FUMES WERE EMITTING IN AND AROUND THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT FUEL WAS LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL TANK WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THAT APPROXIMATE FAILURE MILEAGE WAS 68,000. UPDATED 11/06/14*LJ
Fuel/propulsion system, Apr 1, 2014
TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT THERE WAS AN OVERPOWERING AND CONSISTENT ODOR OF GASOLINE COMING FROM THE VEHICLE. THE CONTACT EXAMINED THE VEHICLE AND NOTICE THAT THERE WAS A FUEL LEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THERE WAS A SMALL FRACTURE IN THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000. THE VIN WAS NOT AVAILABLE.