2005 Hyundai Santa FE
Problems, recalls and owner-reported issues
Air bags is the leading concern among 216 owner complaints filed for this model year. This is the 13th highest complaint count among 25 Santa FE model years with reports.
Of the 2005 reports, 18 involved a crash. 14 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Suspension, front, springs, coil springsJul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 salt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. The affected vehicles may experience front coil spring corrosion from road salt, causing the coil spring to fracture and make contact with the tire.
If the front coil spring fractures due to corrosion it could cause the coil spring to make contact with the tire, possibly puncturing the tire and increasing the risk of a vehicle crash.
Hyundai will notify owners, and dealers will inspect and if necessary replace the coil spring, free of charge. The recall began on October 24, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 124.
Campaign 14V435000 on NHTSA.gov
Air bags, frontalNov 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN OCCUPANT CLASSIFICATION SYSTEM (OCS) THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY CERTAIN SMALL CHILDREN SEATED ON THE FRONT EDGE OF THE SEAT AS AN ADULT.
THE POSSIBILITY OF MISCLASSIFICATION OF CERTAIN SMALL CHILDREN AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG TO DEPLOY IN A FRONTAL COLLISION CRASH OR THE SIDE IMPACT AIRBAG TO DEPLOY IN A SIDE COLLISION CRASH; SEVERE INJURY OR DEATH COULD OCCUR.
DEALERS WILL ENSURE THAT THE VEHICLE'S OCS WILL PROPERLY CLASSIFY CERTAIN SMALL CHILDREN WHEN SEATED ON THE FRONT EDGE OF THE SEAT AND WILL DISABLE THE RIGHT FRONT AIRBAGS. DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT TO PROVIDE AN INCREASED MARGIN FOR RECOGNITION OF CERTAIN SMALL CHILDREN. THE RECALL BEGAN ON DECEMBER 6, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
Campaign 05V527000 on NHTSA.gov
Air bagsOct 4, 2005
ON CERTAIN VEHICLES EQUIPPED WITH AN OCCUPANT CLASSIFICATION SYSTEM (OCS) THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY CERTAIN SMALL CHILDREN SEATED ON THE FRONT EDGE OF THE SEAT AS AN ADULT.
THE POSSIBILITY OF MISCLASSIFICATION OF CERTAIN SMALL CHILDREN AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG TO DEPLOY IN A FRONTAL COLLISION CRASH OR THE SIDE IMPACT AIRBAG TO DEPLOY IN A SIDE COLLISION CRASH; SEVERE INJURY OR DEATH COULD OCCUR.
DEALERS WILL ENSURE THAT THE VEHICLE'S OCS WILL PROPERLY CLASSIFY CERTAIN SMALL CHILDREN WHEN SEATED ON THE FRONT EDGE OF THE SEAT AND WILL DISABLE THE RIGHT FRONT AIRBAGS. DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT TO PROVIDE AN INCREASED MARGIN FOR RECOGNITION OF CERTAIN SMALL CHILDREN. THE RECALL BEGAN ON DECEMBER 21, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 05V450000 on NHTSA.gov
Representative owner complaints
216 reports, newest first.
Vehicle speed control, Feb 28, 2006
2005 SANTA FE 3.5 BUCKS WHEN CRUISE CONTROL DISENGAGED AT ALL SPEEDS. DEALER ORDERED PARTS CORRECTED PROBLEM AT SPEEDS UNDER 60 BY REPLACING BODY ASSEMBLY THROTTLE AND GASKET THROTTLE B. STILL BUCKS AT SPEEDS OVER 60 MPH WHETHER HITTING BRAKE OR CANCEL BUTTON TO DISENGAGE CRUISE. DISTRICT SERVICE MANAGER SAYS ALL SANTA FE 3.5'S DO THIS THEY ARE DESIGNED WITH THE ELECTRONIC CONTROL THROTTLE. BUCKING OF CAR IS SO PRONOUNCED EVERY ONE IN THE CAR FEELS IT. I WILL NEVER FEEL SAFE IN THIS VEHICLE USING THE CRUISE OVER 60 AND WILL NEVER USE IT WHEN OTHER PEOPLE ARE IN THE VEHICLE. JUST BECAUSE IT WAS DESIGNED THIS WAY AND THEY ALL DO IT DOES NOT MAKE IT RIGHT. I FEEL THIS IS A SEVERE SAFETY ISSUE WITH THIS MODEL. I WAS TOLD ONLY THE 3.5'S BUCK WHEN THE CRUISE IS DISENGAGED. *NM
Vehicle speed control, Feb 11, 2006
I PURCHASE A NEW 2005 HYUNDAI SANTA FE EQUIPPED WITH THE 3.5 ENGINE AND 4 WHEEL DRIVE IN JULY OF 2005. AS I NOW FOUND OUT, THIS OPTIONAL 3.5 ENGINE IS EQUIPPED WITH A COMPUTER OPERATED ACCELERATION THROTTLE ENGINE. THIS NEW SET UP IS VERY POORLY DESIGNED, HAS A FEW SECOND DELAY AND THEN THE CAR DARTS OFF FAST, SOMETIMES SPINNING ALL DRIVE WHEELS ON DRY PAVEMENT. I BOUGHT A 4 WHEEL DRIVE UNIT FOR OUR RAIN, SNOW COVERED ROADS IN OREGON, HOWEVER IT'S MUCH WORST ON THIS TYPE OF CONDITIONS. I'VE ALMOST REAR ENDED THE CAR AHEAD OF ME SEVERAL TIMES AND ALSO HAVE TO HAVE ONE FOOT ON BRAKE PEDAL IN HEAVY TRAFFIC OR WHERE I HAVE TO STOP FOR PEOPLE CROSSING THE STREET. THIS I KNOW IS A VERY DANGEROUS WITH PEDESTRIANS AND HEAVY STOP AND GO TRAFFIC IN EVERY DAY SITUATIONS. I'VE QUIT DRIVING THIS VEHICLE IN THOSE SITUATIONS AS I DON'T WANT TO CAUSE PROPERTY DAMAGE OR LOST OF LIFE, SINCE I'VE HAD A STROKE AND SLOWER NOW. I CALLED MY LOCAL HYUNDAI DEALER AND THEY SUGGESTED I HAVE IT TOW 55 MILES TO THEM, WHICH I DID. AFTER SEVERAL DAYS THERE, THEY SAID THEY RE PROGRAMMED THE COMPUTER AND IT WAS SOMEWHAT BETTER. I PICKED IT UP AND WITHIN A FEW CITY BLOCKS I NEW IT WAS JUST THE SAME AS BEFORE. I WAS PLANNING A TRIP TO LAS VEGAS, NV. AND DECIDED I WOULD TAKE IT THERE AND THEN TO A DEALER IN THAT TOWN, WHICH I DID. WHAT A SURPRISE, THAT DEALERSHIP WAS VERY WELL A WHERE OF THE PROBLEM AND HAD HUNDREDS OF COMPLAINTS CONCERNING THE EXACT PROBLEM. THE SERVICE MANAGER AND MECHANIC CAME OUT TO TELL ME THAT THERE WAS A REAL PROBLEM WITH THE 3.5 ENGINE AND THAT THERE WAS NO FIX FOR IT AT THAT TIME, MY BEST CURE WOULD BE TO TRADE IT IN FOR A ANOTHER CAR !!. THEY WOULD NOT EVEN TRY TO FIX IT. I PAID 25,000.00 DOLLARS FOR IT AND CAN'T EVEN KNOW DRIVE IT SAFELY. *JB
Vehicle speed control, Jan 29, 2006
THE THROTTLE HANGS UP WHEN GOING FROM A DEAD STOP. THIS CAUSES THE CAR TO LURCH AHEAD SO FAST IT SPINS THE TIRES. THIS WILL CAUSE YOU TO REAREND A CAR IN TRAFFIC , OR TO PULL OUT IN TRAFFIC TO LATE WHICH COULD ALSO CAUSE AN ACCIDENT.*AK
Service brakes, Hydraulic, Structure, Jan 24, 2006
WHILE DRIVING AND STEPPING ON BRAKE PEDAL HAD TO APPLY EXTENSIVE FORCE TO THE BRAKE PEDAL. TOOK VEHICLE TO DEALER, WHO CLAIMED BRAKES WERE OKAY. THE SECOND PROBLEM INVOLVED REAR DOOR MISALIGNMENT. THE THIRD FAILURE WAS PAINT PEELING OFF UNDER THE HOOD. *AK
Vehicle speed control, Dec 27, 2005
DT: WHILE THE CONTACT WAS PULLING INTO A PARKING PLACE THE VEHICLE SURGED, CAUSING THE ENGINE TO REV ABOVE 6500 RPMS. THE VEHICLE ACCELERATED AND TOOK OFF ON ITS OWN. HE REPORTED HAVING NO PROBLEMS WITH THE VEHICLE PRIOR TO THE ABOVE INCIDENT. HE HAS NOT TAKEN THE VEHICLE TO A DEALER.*AK
Electronic stability control, Engine and engine cooling, Electrical system, Vehicle speed control, Dec 14, 2005
DT: THE CONTACT COMPLAINED ABOUT SEVERAL PROBLEMS. THE FIRST PROBLEM WAS THE TRACTION CONTROL, WHICH ALLOWED THE FRONT WHEELS TO SLIP IN THE SNOW. THE ELECTRONIC ACCELERATOR CUT IN AND OUT WHEN THE TRACTION CONTROL WAS ON. THE DEALER WAS CONTACTED, AND THEY SUGGESTED TURNING THE TRACTION CONTROL OFF. THE CONTACT TRIED THE DEALER'S SUGGESTION. AND NOW, ONLY ONE WHEEL WILL TURN IN THE SNOW, THE ENGINE IDLED LOW, AND THE VEHICLE DID NOT MOVE FORWARD. THE SECOND PROBLEM OCCURRED ON NORMAL ROAD CONDITIONS THE VEHICLE LURCHED FORWARD AFTER A COMPLETE STOP. THE LAST PROBLEM WAS THE CHECK ENGINE LIGHT WHICH INTERMITTENTLY ILLUMINATED. THE DEALER REPLACED THE DPS VALVE SENSOR AND REPROGRAMMED THE COMPUTER SOFTWARE. THE CONTACT HAD ONLY DRIVEN THE VEHICLE ONCE SINCE THE REPAIRS WERE COMPLETED, AND DID NOT NOTICE ANY DIFFERENCE IN THE PERFORMANCE OF THE VEHICLE. *AK
Air bags, Dec 6, 2005
PASSENGER AIR BAG SYSTEM DOESN'T WORK AS PER DASH LIGHT. DEALER STATES THE SENSOR INDICATES THE SYSTEM IS WORKING PROPERLY. *JB
Air bags, Nov 16, 2005
PASSENGER AIRBAG SYSTEM DOESN'T ALWAYS WORK AS PER DASH LIGHT, DEALER CAN' T FIND ANYTHING WRONG WITH SYSTEM SUGGEST TURNING OFF ENGINE AND RESTARTING TO RESET COMPUTER. I TRIED THIS WHILE DRIVING IN HIGHWAY TRAFFIC AND LOST POWER TO MY BRAKES AND STEERING , MY WIFE WEIGHS 135 POUNDS THIS SHOULD WORK THE SENSORS. *JB
Vehicle speed control, Equipment, Nov 15, 2005, crash
WHEN PUT INTO REVERSE 2005 SANTA FE ENGINE ROARED. *TS THE CONSUMER HAD NO CONTROL OVER THE VEHICLE. WITH THE VEHICLE STILL IN REVERSE, THE CONSUMER CRASHED INTO A NEIGHBORS DECK CAUSING A CONSIDERABLE AMOUNT OF DAMAGE TO THE VEHICLE AND THE DECK. THE CONSUMER HAD A LEFT FOOT ACCELERATOR INSTALLED ON THE VEHICLE AND WONDERED IF THAT WAS THE CAUSE OF THE SUDDEN ACCELERATION. *JB
Vehicle speed control, Oct 17, 2005
ACCELERATOR PEDAL. VEHICLE HESITATES WHEN TAKING OFF FROM A STOP,THEN SUDDENLY ACCELERATES SOMETIMES MUCH TO QUICKLY CAUSING SOME LOSS OF CONTROL. MECHANIC AT HYUNDAI TRIED TO RESET COMPUTER BUT INFORMED US THAT IT IS SET TO MANUFACTURERS STANDARDS PROBLEM HAS SO FAR BEEN UN-FIXABLE AND THE VEHICLE REMAINS UNSAFE. *JB
Vehicle speed control, Sep 29, 2005
COMPLAINT IS ABOUT A 2005 HYUNDAI SANTA FE LX WITH 3.5L ENGINE. THERE IS A PROBLEM WITH THE ACCELERATOR THAT THERE IS A DELAY IN RESPONSE WHEN THE ACCELERATOR IS PRESSED. THIS DELAY IS OVER A SECOND LONG, AND CAUSES THE DRIVER TO KEEP PRESSING DOWN ON THE ACCELERATOR. WHEN THE SENSOR FINALLY REACTS, THERE IS MORE ACCELERATION APPLIED THAN IS DESIRED, CAUSING THE VEHICLE TO START OUT FASTER THAN INTENDED, OR NOT STARTING OUT WHEN THE DRIVER WANTED TO. THIS IS DANGEROUS AS THE DRIVER DOES NOT KNOW HOW MUCH ACCELERATION WILL BE APPLIED TO THE ENGINE, OR WHEN THE CAR WILL START MOVING, THUS MAKING IT DIFFICULT WHEN TO APPLY GAS, AND NOT KNOWING HOW THE CAR WILL REACT. *NM
Other or unspecified, Aug 18, 2005
I JUST BOUGHT A NEW 2005 HYUNDAI SANTA FE(2.7L AWD AT4) ON AUG 15, 2005. THEN TWO DAYS LATER I FOUND OUT THAT THE VEHICLE HAS FAILED THE NHTSA ROLL OVER TEST (TIP). *JB " NHTSA 2005 SUV CRASH, ROLLOVER RATINGS <HTTP://WWW.THEAUTOCHANNEL.COM/NEWS/2005/06/22/133124.HTML>" 1. WHY THE DEALERSHIP/MANUFACTURER NOT MANDATED TO WARN THE CUSTOMERS THE SAFEY DEFICIENCY INFO? A. DO I HAVE GROUND FOR RETURNING THE PURCHASE AND ASKING FOR REFUND? 2. WHAT ARE THE FOLLOW-UPS FOR THE MANUFACTURER TO REMDEY THE DEFICIENCIES OF THE VEHICLES ON ROAD? 3. WITH SANTA FE HAS BEEN IN THE MARKET FOR MANY YEARS ALREADY, DOES THE TRAFFIC STATISTICS INDICATES THAT IT IS INVOLVED IN MORE ROLL OVERS THAN OTHER VEHICLES, SAY HONDA CRV? PROMINENT UNDER WHICH CIRCUMSTANCES ( ROAD/WEATHER/DRIVER)? WHERE TO FIND THIS TYPE OF INFO? THANKS. LI CHEN, CALGARY, CANADA, (403) 685-8101 4. 3.
Vehicle speed control, Aug 8, 2005
DT: THE VEHICLE EXPERIENCED DELAYED ACCELERATION. CONTACTED THE DEALER AND MANUFACTURER. THEY SAID IT WAS A CHARACTERISTIC OF THE VEHICLE. IF AT A COMPLETE STOP AND CONSUMER PUSHED THE GAS PEDAL IT TOOK A FEW SECONDS BEFORE VEHICLE WILL ACCELERATE. *AK
Service brakes, Air, Jul 16, 2005
AFTER STARTING THE CAR EACH TIME, AND EITHER BACKING UP AND THEN PULLING FORWARD OR PULLING FORWARD, THERE IS A POPPING SOUND AND A SLIGHT VIBRATION IN THE ACCELERATOR PEDAL. I TOOK THE CAR BACK TO THE DEALER AND WAS TOLD THAT IT WAS THE MOTOR MOUNTS, THEN IT WAS THE MASTER CYLINDER. AFTER HAVING MY BOSS WHO IS A MECHANIC, DRIVE THE CAR, HE SAID THAT IT WAS NEITHER OF THOSE ITEMS, AND COULD POSSIBLY HAVE SOMEETHING TO DO WITH THE DRIVE TRAIN OR THE U-JOINTS. I RELAYED THIS INFORMATION TO THE SERVICE DEPARTMENT AND THEY THEN WENT BACK OVER THE CAR, AND SAID THAT THEY HAD TO CALL THEIR CORPORATE OFFICE. AFTER THAT CALL, I WAS INFORMAED THAT THE NOISE HAD TO DO WITH THE ABS SYSTEM, CHECKING ITSELF. BUT I WONDER IF THIS IS THE CASE, SINCE IT ONLY HAPPENS WHEN I AM IN A FORWARD MOTION. I ENJOY DRIVING THIS CAR, AND WOULD RECCOMMEND IT TO ANYONE WHO ASKED. IT IS COMFORTABLE, FUN TO DRIVE AND THE NOISE HASN'T SEEMD TO ALTER THE OPERATION OF THE CAR AND ANY FORM.
Vehicle speed control, Apr 26, 2005
MY 2005 SANTA FE 3.5L ENGINE HAS A COMPUTER OPERATED GAS PEDAL THAT MAKES IT DIFFICULT TO ACHIEVE A SMOOTH LINEAR ACCELERATION. I FEEL THIS PROBLEM SHOULD BE CORRECTED BEFORE AND ACCIDENT OR INJURY OCCURS. *AK THERE WAS A DELAY IN ACCELERATION THAT OCCURRED BETWEEN THE GAS PEDAL AND THE TRANSMISSION. THIS SITUATION WAS ESPECIALLY AGGRAVATED ON WET, SNOWY OR ICY ROADS. *SC THE MANUFACTURER CHANGED THE CABLE SYSTEM GAS PEDAL TO A COMPUTER OPERATED GAS PEDAL. *JB
Power train, Apr 4, 2005
DRIVER NOTICED THAT WHILE SHIFTING THE TRANSMISSION VEHICLE WOULD DOWN SHIFT ON ITS OWN. DRIVER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC INSISTED THAT THE PROBLEM COULD NOT BE DUPLICATED. *AK