2017 Hyundai Santa FE
Problems, recalls and owner-reported issues
Engine is the leading concern among 967 owner complaints filed for this model year. This is the highest complaint count among 25 Santa FE model years with reports.
Of the 2017 reports, 14 involved a crash and 23 involved a fire. 18 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideFeb 3, 2022
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
An engine compartment fire while parked or driving can increase the risk of injury.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.
Campaign 22V056000 on NHTSA.gov
Engine and engine cooling, engineSep 20, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.
The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.
Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.
Campaign 17V578000 on NHTSA.gov
Latches/locks/linkages, hood, latchJun 5, 2017
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Campaign 17V358000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsMar 6, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
An underinflated inflated tire can increase the risk of a crash.
Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.
Campaign 17V142000 on NHTSA.gov
Electrical system, wiringNov 21, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Campaign 16V842000 on NHTSA.gov
Seat belts, front, warning light/devicesMar 10, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.
Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.
Campaign 16V145000 on NHTSA.gov
Representative owner complaints: engine
668 reports, newest first. Show all
Other or unspecified, Engine, Jun 15, 2026
vehicle serviced on 5/7/2026 for Hyundai service campaign 9C2 immediately after noticed car was not driving as it had been prior to this update, sluggish acceleration on start, chugging and then rapid sudden acceleration. returned to service dept May19. Diagnostics revealed no issues, problem persisted. returned to service dept. May22. Informed Hyundai was looking into this issue related to the 9C2 update and awaiting a new update to fix the problem. As of todayJune15 there has been no action to remedy the problem. Do not feel safe driving a vehicle that hesitates when starting to drive and then accelerates roughly. this has happened consistently upon cold start up thus far but concerned it may happen while in traffic or at other times and result in an accident.
Engine and engine cooling, Jun 10, 2026
See attached document for complaint.
Engine, Jun 10, 2026
My wife was driving our 2017 Hyundai Santa Fe around March 8, 2023 with our 3 children in the vehicle. She began merging onto interstate 70 when the vehicle made a noise and became undriveable. She could still steer but pushing the pedal down did not do anything. She had to carefully pull over off of the highway so that she did not get in an accident. This vehicle had to be towed to a mechanic who said the engine had seized up and that the oil is gone from the engine and that I would need to have it sent to a Hyundai dealer. This vehicle had 108,334 miles on it so it was just past Hyundai's 100,000 mile warranty. This vehicle was towed to a Hyundai dealer who confirmed that the engine was locked up and that an oil sample found metal in the oil. The dealership recommended to replace the engine with a used one for over $11,000 which I declined then charged me $160 for evaluating. No warning lights or indicators were ever showing any issues. We did notice sometimes after an oil change that they would state on the invoice that the oil was a half quart low. This vehicle was parked in a garage and never had a drop of oil leak. Hyundai recently extended the warranty for this vehicle to 150,000 miles and then declined my repair claim due to the repair not being done at a dealership. The sudden loss of power while driving was a scary incident for my family but thankfully no one was hurt.
Engine, Jun 9, 2026
The engine burns oil fast. You have to replace oil on a regular bases. The car also looses fluids fast as well. This causing the engine to over heat. This causes the cylinder to head blow.
Engine, Jun 9, 2026
I was told my top side of my engine failed, and they only cover bottom side engine failure. As well as pieces was missing. When I looked at the video it showed that my screws has fell off vs removed.
Engine, Jun 5, 2026
Air compressor and compression failed engine diagnostic test. Vehicle had high oil and gas consumption.
Engine, Fuel/propulsion system, Jun 4, 2026
Hi, my name is [XXX], i bought used Hyndai Santafe sport 2017 from dealership in 2020. It had around 47,000 Miles on it, intitially it was running fine but after driving 2 years i discovered that engine is burning oil and after the oil change right after 1000 miles i had to add a quart of oil and it was like every two weeks. I had many srevices from dealership and other auto mechanic stores but it didn't improved. I had no choice but to keep driving the card on XXX th the engine crashed with out any sign on dashboard. There was slight noise and it increase by the way car was parked on the side road from Highway. The car was towed to my local mechanic and confirmed that engine is crashed. After i had to towed to dealership and i am still waiting for their response. Now we have put 43,000 miles in 6 years (91,000) total mileage. I had bought the waranty from dealership by $ 2500 which expired in 2025 Currently no warranty. My question here is that the car is still under 100,000 and engine failed. What if the dealership refuse to replace the engine. What are my leagal rights. Thanks [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Forward collision avoidance, May 27, 2026
reporting a serious safety concern involving my 2017 Hyundai Santa Fe Sport with the Theta II engine. While driving on the highway, my vehicle suddenly lost power without warning. The vehicle became unsafe to drive and I had to pull over and have it towed. There was no warning light before the failure. The vehicle has been regularly maintained. Hyundai later stated there was internal engine damage. My vehicle also shows an open engine-related recall/campaign since November 2025. I have found many similar complaints from other Hyundai owners describing sudden loss of power, excessive oil consumption, and engine problems involving the Theta II engine. I contacted Hyundai Motor America and provided documentation and videos, but I have not received a meaningful response. I am concerned this issue may represent a serious safety defect because the sudden loss of power occurred while driving on a highway.
Engine, May 24, 2026
The engine in my 2017 Hyundai Santa Fe Sport equipped with the 2.4L Theta II GDI engine is experiencing severe excessive oil consumption. The vehicle consumes approximately 2–2.5 quarts of oil every 1,000 miles despite multiple repair attempts and dealership-performed combustion cleaning procedures. Hyundai Motor America and the dealership documented the condition under PA #[XXX] and recommended engine replacement. Hyundai Motor America advised me in writing that the vehicle should not be operated in its current condition because of the excessive oil consumption and pending engine replacement. Excessive oil consumption creates a risk of sudden engine failure, engine seizure, stalling while driving, and potential engine fire if oil levels drop unexpectedly. Because the engine rapidly loses oil between normal service intervals, the vehicle may become unsafe to operate without warning, placing myself, passengers, and other motorists at risk. The defect was confirmed multiple times by Capital Hyundai in San Jose, CA through two official Hyundai oil consumption tests. The dealership documented oil consumption of approximately 2–2.5 quarts per 1,000 miles and submitted the results to Hyundai Motor America under PA #[XXX].The dealership also performed multiple repair attempts, including spark plug replacement, fuel induction cleaning, combustion chamber cleaning, and repeated oil changes, but the excessive oil consumption continued. Prior symptoms included: Check engine light illumination, Cylinder #4 misfire condition, Engine noise, Excessive oil loss between oil changes, and Oil level dropping significantly within short mileage intervals. The check engine light and misfire condition first became severe enough to require dealership diagnosis on or around [XXX], when the vehicle was towed to the dealership. The excessive oil consumption issue was formally documented beginning [XXX] during Hyundai’s oil consumption testing process. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Fuel/propulsion system, May 19, 2026
I am submitting a complaint regarding a turbocharger failure on my 2017 Hyundai Santa Fe VIN [XXX] . The vehicle experienced turbocharger-related failure symptoms including loss of power and drivability concerns. This created a potentially dangerous situation because the vehicle was unable to accelerate normally and could have caused difficulty merging into traffic or maintaining safe roadway speeds. I contacted Hyundai Motor America requesting assistance with repair coverage. Hyundai denied assistance solely because the vehicle was outside the warranty period by time and mileage, despite the seriousness of the failure. I am concerned this issue may be related to broader engine or oil-related defects reported in Hyundai vehicles, including possible oil starvation, excessive oil consumption, or internal engine contamination that could contribute to turbocharger damage or failure. I believe this condition may represent a safety-related defect because sudden power loss during operation increases the risk of a crash. I request that NHTSA review this issue and investigate whether similar turbocharger or related engine failures are occurring in 2017 Hyundai Santa Fe vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Vehicle speed control, Engine, May 19, 2026
After the installation of the Service Campaign 9C2 engine update, the car now seems to surge or rev up briefly at lower speeds like it can't find the right gear or is trying to briefly accelerate. It doesn't seem to be as noticeable at highway speeds, but in residential or low speeds, it's very noticeable and a little unsettling as the car feels like it wants to briefly lunge forward. No lights are on the dash and there is no indication of any malfunction, but it did not behave this way prior to the 9C2 engine program update. I waited for a couple weeks before contacting Hyundai Corporate about this issue because I was hoping maybe the transmission or engine was relearning after a battery disconnection, but it has not gone away.
Engine and engine cooling, May 11, 2026
The contact owns a 2017 Hyundai Santa Fe. The contact stated that the vehicle was using an excessive amount of oil. There were no warning lights illuminated. There was no indication of a leak. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The dealer informed the contact the failure was related to combustion chamber cleaning. The manufacturer was contacted, who informed the diagnostic fees were at her expense and there was no coverage. The failure mileage was approximately 94,700.
Engine, May 4, 2026
Engine seized up on the interstate. Vehicle has ~97,000 miles. Towed to dealership. Dealership wanted $8,000+ to replace engine. Hyundai refused to honor their warranty of 15 years/150,000 miles. Remains at the dealership, unrepaired.
Engine, Fuel/propulsion system, May 2, 2026
My vehicle had oil consumption problems that were fixed with a new replacement engine now my catalytic converter is going bad due to engine oil consumption problems and the dealer I deal with is refusing to help with this issue. There is only around 50k miles on the new engine. I would greatly appreciate your help with this Thank you!
Other or unspecified, Engine, May 1, 2026
On 4/17/26 McDonalds Hyundai of [XXX] , dealership performed an ECU update for THETA II Emissions logic improvement (Hyundai campaign number 9C2). Ever since that time the vehicle has been lurching during acceleration. This happens particularly when the vehicle has been sitting for several hours. I reported this to the dealership on 4/28/26 (Scott, service manager) and to Hyundai on 4/29/26 (Hyundai Case Management #: 42610495). I noted to Hyundai that this same/similar problem has been reported by other owners ( see [XXX] ) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine and engine cooling, May 1, 2026
The contact owns a 2017 Hyundai Santa. The contact stated that while driving at approximately 55 MPH, the vehicle stalled and hesitated to accelerate while the accelerator pedal was depressed. The check engine and check engine oil warning lights illuminated. The vehicle was taken to a local O'Reilly's, where it was diagnosed with ignition coil #3 misfire. The vehicle was not repaired. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the engine needed to be replaced due to severe engine oil consumption. The vehicle was then to a local dealer, where it was diagnosed with abnormal engine oil consumption, and the dealer determined that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle required an engine oil refill 800-1,000 miles before an engine oil change was due. The contact related the failure to several unknown Hyundai TSBs. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 87,000.
Engine, Apr 27, 2026, fire
While driving home on the highway from our sons hockey game at about 8:30 pm we were going about 60 mph when the car made a noise and began smoking and as we were trying to pull over on the side of the highway noticed by the reflection of a passing car that the engine on our vehicle was on fire under the vehicle. We had to evacuate the vehicle quickly and get our children out on the side of a busy highway with fire showing under the front end of the car.
Engine, Apr 23, 2026
My wife's 2017 Hyundai Santa Fe Limited experienced a sudden crack in the engine and lost oil without any warning signs. There were no warning lights, no check engine light, and no unusual noise before the engice crack. A certified independent mechanic inspected the vehicle and confirmed the engine has no oil, whick it did a couple days before when I checked the oil and topped it off, which is the same issue described in Hyundai’s known engine safety recalls. I was never notified of any safety campaigns or recalls. I am not the first owner, so the required recall inspections and updates were never completed on this vehicle before I bought it. The sudden engine crack and loss of oil created a serious safety risk, especially because there was no warning before it happened and it almost left our family stranded two hours from home. This failure matches the symptoms described in Hyundai’s Theta II engine defect investigations. While at the mechanic shop, we were quoted $10,000 to get a new remanufactured engine put into this car. I certainly (and I know most families) don't have $10k sitting around waiting to be used for car repairs. I am requesting that NHTSA investigate whether this vehicle should be included in the affected group, and whether this engine failure is part of the broader safety defect already identified in many Hyundai engines from the same model years. This vehicle is currently parked in our yard waiting to be repaired or sold. I would prefer it be repaired by Hyundai since one of the car plants is only 1 hour from our house. I was unaware of the current safety recall until I read it today.
Engine, Apr 23, 2026
My engine just died wont start has 121099 and hyundai wont fix it
Engine, Apr 20, 2026
Seem like there was a recall on the 3.3L engines on the Hyundai Santa Fe starting January 26, 2017, for engine related knocking noise. My Vin is [XXX] according to the Manufacturing plate it was made in Korea released on January 04, 2017. I realize it is a 22-day window on the recall but after an oil change the motor has started knocking the oil is the right viscosity, full to capacity, and oil filter changed. I drove 200 miles after an oil change then the motor started knocking. Is there a certain stamp on the cam shafts to verify which of the 420 vehicles are affected by this recall? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Apr 16, 2026
My 2017 Hyundai Santa Fe Sport 2.0T (Theta II 2.0L GDI Turbo engine) has been diagnosed with burned exhaust valves requiring a complete engine replacement. This is the second catastrophic powertrain failure on this vehicle in under two years. In July 2024, I paid $2,754 to replace the turbocharger at an authorized Hyundai dealership (Wright Hyundai, [XXX] ). The burned valves are consistent with carbon buildup on intake valves, a widely documented and known deficiency of the GDI fuel delivery system used in the Theta II engine family. Carbon deposits restrict airflow, cause valve seating issues, and lead to valve failure. This is an inherent design characteristic of the engine, not a maintenance-related failure. At no point during my ownership — including during the turbocharger repair — was I informed of this known issue or advised of any preventive measures such as fuel system cleaning treatments. I am additionally concerned that the dealership's diagnostic process was incomplete. The service center diagnosed the burned valves and immediately recommended an engine replacement without performing a bearing clearance test or completing the full diagnostic flowchart. The dealership has refused to perform further diagnostics unless I pay additional fees, and has refused to share documentation from a tech line case opened with Hyundai corporate. Because diagnostics were halted at the burned valve finding, a connecting rod bearing failure — the specific defect covered under the Theta II class action settlement (In re: Hyundai and Kia Engine Litigation, NoXXX) — has not been ruled out as a contributing cause. Hyundai's National Consumer Affairs office (Case #XXX) denied my goodwill request without addressing either the known GDI carbon buildup issue or the fact that this is the second catastrophic failure on this engine platform. This vehicle has approximately 86,000 miles. I purchased it as a second owner in August 2020 at 42,730 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Mar 29, 2026
The vehicle is burning oil even when oil changes are done routinely. Then all of a sudden I have total loss of power will not go over 35 miles an hour. And climbing hill would not go over 20. It just happened no warning lights on dash So now I have a car that is still owning 8 grand on. So now a lawn ornament. I have seen on different formats. That there is hundreds having the same issue. Hyundai is not fixing the issue for any of us
Engine, Mar 29, 2026
ENGINE. IT HAPPENED WHILE I WAS DRIVING. NO IT WASNT REPRODUCED OR CONFIRMED BY A DEALER, BUT HAVE BEEN TOLD BY A COUPLE AND ALSO ME SEEING THAT THE ENGINE WASNT ABLE TO MANUALLY BE CRANKED AT ALL. NO INSPECTION WAS DONE BY MANUFACTURR, POLICE, OR INSURANCE, BECAUSE IT DIDNT CAUSE A ACCIDENT. JUST ENGINE LIGHT WHICH HAVE BEEN REPORTED TO THE DEALERSHIP AND WAS TOLED THEY COULDNT FIX IT, BUT THAT WAS JUST STAYING ON ALL THE TIME FOR QUITE SOME TIME. NO FINALLY I WOULD LIKE TO SEE IF THIS CAN BE INVESTIGATED ON TO BE A RECALL SINCE THE ORIGINAL MILES ARE ONLY ABOUT 68000 AND SHOULDNT HAVE THESE PROBLEM AT THIS LOW MILEAGE.
Power train, Engine, Fuel/propulsion system, Mar 28, 2026
I purchase the 2017 Santa Fe Sport in October of 2023 with just short of 80K miles. It was in great condition and had no issues. I have maintained it according to Hyundai specification and regular on schedule oil changes with recommended 5w-20 full synthetic. At approximately 100K miles, I experienced an oil pressure light on the dash, when checked, the engine was approximately 2 quarts low. From this point on, the engine started consuming oil at an increasing rate all while I maintained regular maintenance. First, 1 quart a month, or about 1200 to 1500 miles, then to 1 quart every 2 weeks or 800 miles. I maintained weekly checks on the oil level and on the evening of 3/24/2026, I had added a quart, bringing the level to the midway point between the high and low dipstick markings. On the afternoon of 3/24/26 while driving on the highway in heavy, but at speed limit, traffic on the highway, I experienced a loss of power and a check engine light. I was able to exit the highway but the car started to run very rough and unable to idle. Luckily, there was no traffic approaching when I turned off the exit and made a left into parking lot to shut off the vehicle. I will be having it towed to a dealership in the next few days for their analysis.
Engine, Mar 23, 2026
These vehicles are not suitable to be on the road, and you NHTSA and Hyundai are doing NOTHING ABOUT IT. These vehicles are EATING oil, a quart every 200 miles. My daughter(college) can't even go on a short road trip to another city without adding oil. The engines in these crap cars are blowing up left & right. There are numerous Facebook page groups for these and sister Kia vehicles with the same 2.4 engines. Thousands upon thousands of posts about engine oil and engines blowing up, no one doing anything about it. My daughter's car is beautiful, but worth NOTHING due to this issue, so we are out thousands of dollars on this. We are about to go to WAR with Hyundai on this and I'm sure we'll get nowhere. If we're lucky, they'll install a rebuilt engine...BUT IT"S THE SAME CRAP ENGINE!!!!!!! So we are ALL back to square ONE and NHTSA is doing NOTHING. This is a well known FLAW for years now.