2017 Hyundai Santa FE
Problems, recalls and owner-reported issues
Engine is the leading concern among 967 owner complaints filed for this model year. This is the highest complaint count among 25 Santa FE model years with reports.
Of the 2017 reports, 14 involved a crash and 23 involved a fire. 18 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideFeb 3, 2022
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
An engine compartment fire while parked or driving can increase the risk of injury.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.
Campaign 22V056000 on NHTSA.gov
Engine and engine cooling, engineSep 20, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.
The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.
Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.
Campaign 17V578000 on NHTSA.gov
Latches/locks/linkages, hood, latchJun 5, 2017
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Campaign 17V358000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsMar 6, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
An underinflated inflated tire can increase the risk of a crash.
Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.
Campaign 17V142000 on NHTSA.gov
Electrical system, wiringNov 21, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Campaign 16V842000 on NHTSA.gov
Seat belts, front, warning light/devicesMar 10, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.
Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.
Campaign 16V145000 on NHTSA.gov
Representative owner complaints: engine
668 reports, newest first. Show all
Engine, Dec 20, 2024
Problems with oil consumption/oil burning. Engine noise - mechanic said the timing chain socket is coming apart. Hyundai has had multiple issues with vehicles that have GDI LAMBDA II engine. In 2019, they recalled several makes with Lambda engine however my vehicle wasn’t one of them. Mechanic said it would cost $6200 to repair. Just to diagnose the issue was $440.
Power train, Engine, Dec 16, 2024
Catastrophic engine failure without warning. Rod bearings blew car unable to produce power.
Other or unspecified, Engine, Dec 11, 2024
The engine on my car was consuming oil at a rapid rate. The dealer service department gave me the run around for many month. Stating they could never duplicate the issue. when clearly the whitish blue smoke pouring out of tailpipe and horrible combustion fumes inside cabin of car. At some point bluish smoke turned to black smoke and that when the $800 combustion test was suggested. Which they say will tell me if the engine is bad. how do they not know the signs of a bad engine. my car sat in service department for 2 months for them to say it's not covered under warranty. I tried everything to hold the manufacture responsible and they was unwilling to budge and help. The car has the extended warranty and my car was under the mileage and years. My car been sitting in my driveway since May 2024 needing a engine replacement. The fumes in cabin of vehicle was unbearable which cause me to have to drive with window down. Vehicle never show any warning lights when engine oil was low or empty. another incident was with the radio not turning off even after the battery went died. The radio continue to work and connect to phone when battery was died. After charging battery radio would again kill battery and not shut off. The only way it would shut off is to disconnect radio. How dealer explained the issue was that of a modem. That the car probably need to be reset when radio was disconnected it worked. But after that it happen 3 more times. these cars need to be recalled and all customer should get there money back. To own a 2005 Santa Fe with over 216,000 miles with no oil burning / leaking or smoke out tailpipe say a lot on the manufacturing of this vehicle. I have no mechanical issues with this car and that was the reason i wanted to upgrade to 2017. Now I wish I had never brought the 2017. Beware before buying this brand because they are no good.
Engine, Dec 10, 2024
Over the past year, the engine light continues to come on. The first time this happened, there was no oil in the reservoir even though it had recently had an oil change. They did another oil change and sent us on our way. The next time.[XXX], the check engine light came there was a loud clanking sound and low oil again. This was the code the dealership said it was: Code P0021 [XXX] . He suggested a tune-up at this time. He says the engine light should stay off. We just need to continue to check the oil. [XXX]. Check engine light came on again as my son was driving. He lost pressure is the gas pedal. When he pushed it, the vehicle would not accelerate. We has it towed to the same dealership On 10/2/24, they were finally able to tell us what Hyundai felt was wrong: Timing components will need to be replaced- the timing tensioner or chain has failed $4363.20. We pushed back because our personal mechanic said the following: We were told by our mechanic and some of the research that we did that the breaking of the timing chain is connected to the loss of oil pressure that has been happening because of the default in the engine which is part of the recall for that vehicle. What can they tell us about that? Those timing chains are supposed to last a long time and not go out at 130,000 miles or whatever the odometer reading is now. Can this be considered in the recall information for replacing the engine? It does not seem that they're really working with us or helping us on this. Our contact person went back to his shop foreman who went back to Hyundai to ask about this. He then said his shop foreman said it doesn't seem to be directly related to that warranty extension TXX8 - but we will submit all information to Hyundai prior approval and see what they say. It then took him until October 14 to say the following: Hyundai is asking my master technician to remove the valve valve cover and inspect timing parts closer. We took it to another INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Dec 9, 2024
[XXX] this engine was replaced under the Hundai Theta Engine Settlement at 91,654 miles. I am the original owner. This problem first started when oil light was on and my regular mechanic sent me to Hyundai because engine required excessive amts of oil. Oil usage test conducted, engine replaced under the NATIONAL RECALL. I have maintained car with regular service before and since that time. 10-14/2024 Good Year Center did my routine oil change at 190,027 on this replacement engine. At time of service, this second engine had 91,463 miles since being replaced in 2022. I did service in readiness for upcoming Thanksgiving vaca. 11/29/29. on [XXX] [XXX] at Greenville, Ala...check engine light began flashing... car was vibrating, shaking, making noise...oil light also went on, I began losing power . I pulled off hwy at [XXX} exit..still making noise, slowing down.. got to bottom of ramp was able to coast into parking lot of station/rest. 189 miles from home. Checked oil...none on dipstick, still vibrating and making noise. man from station came to help and told me to shut it off. he checked oil, looked under car. nothing running out, filter on tight. He worked at restaurant was also a mechanic... Got his meter and read the codes...saying that spark plugs 3 &4 were bad. Spark plugs changed 1/18/24 at Good year service center. He put in 4 qts of oil. tried to start car, oil light and check engine light still flashing. When he removed 3 and 4 plug tips were burnt and singed black. replaced plugs, started car... both check in light (now steady on) and oil light still on. still idling very rough and vibrating with noise. checked spark plugs again.. when he removed plug, it was coated in oil. Car towed 189 miles. dealer said burnt valve, not related to oil all over engine. Engine cost at 7000-9000. Not warranty issue per dealer. reported to corporate, still no response INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Service brakes, Engine, Dec 1, 2024
My complaint is the dealership that said had completed the recall on my brake systems according to both your and state records was not completed. They gave me a service notice stating the work was done. Since then the braked have continued to act up and the vehicle as a strange acceleration problem. The dealership is Don Wood Hyundai in Athens Ohio.
Vehicle speed control, Other or unspecified, Engine, Nov 26, 2024
The engine seized due to an issue with the oil plug and another part, leading to a lack of oil in the system. The vehicle is currently with Hyundai and available for inspection upon request. How Safety Was Put at Risk: While driving on the highway, I suddenly lost acceleration (below 40mphs). I was forced to pull over to the left side of the highway where it was shallow, where I risked being hit by passing vehicles until there was a safe break in traffic, allowing me to maneuver to an exit. This created a hazardous situation for both myself and other drivers. Reproduction or Confirmation of the Problem: The issue has been confirmed by an independent automotive technician, who diagnosed the problem as a blown engine caused by a lack of oil. The vehicle is now with Hyundai for further inspection. Inspection by Others: The vehicle has been inspected by an independent service center and is currently being inspected by Hyundai. No other parties, such as the police or insurance representatives, have been involved. Warning Lamps or Messages Prior to Failure: The only warning sign prior to the incident was the check engine light blinking at the time of the failure. There were no other warning lamps, messages, or symptoms before the engine seized. The vehicle was within the oil range limit of 7,500 miles at the time of the incident. Additional Notes: The incident occurred suddenly, without prior warning or indication of an issue. Based on the diagnosis and known issues with the oil plug, I believe this failure was caused by a defect.
Engine, Fuel/propulsion system, Nov 25, 2024
I have Hyudai Santafe 2017 Sport, bought it from dealership in 2020 with 46,000 Miles and in around past 4/5 years added 30,000 miles. Which is not much, in the past one year i have noticed that engine oil is burning faster than usual. On every oil change after driving between 1200 and 1500 miles the oil engine sign blinks and upon checking needed 2 Quarts of oil. I spoke the dealership and they are not very helpfull. Also they did the oil combustion test which i was charged. Later i was advised to do. ("Good morning, Just got off the phone with you sir warranty won't cover it due to the vehicle being out of manufacture warranty and mileage. My technician recommended starting with combustion chamber cleaning which would be around 1200 before taxes and shop supplies. Combustion chamber cleaning is the process of removing carbon buildup from the combustion chamber and intake valves of a fuel-injection engine. to see if that fixes the problem that you are having with the car burning oil. If that step doesn't work we we would submit a warranty pa again, to see if they would cover a new engine." Please advise what should be my next step, as per my mechanic the only solultion right now i have is keep adding oil carefully.
Engine, Nov 24, 2024
I was driving my 2017 Hyundai Santa Fe and suddenly I heard the knock sound from the engine and when I pulled over, I saw the oil came down from the engine. I towed my vehicle to Hyundai dealership and they diagnosed the issue is vertical square and potential rod bearing failure. My vehicle has only 91k miles. I want to find out if there is any recall on this issue that happened to my car. Please let me know.
Engine, Nov 21, 2024
Excessive oil consumption greater that 1 quart per 1000 miles.
Engine, Nov 17, 2024
After a perfect dealership maintenance history and being babied since bought new, the 3.3L V6 engine in our 2017 Hyundai Santa Fe seized at 101,800 miles without any warning other than a slight knock on startup the day this occurred. The engine seized while being driven on a side road without any warning lights, causing loss of steering and braking power. Hyundai has extended the warranty on the 4 cyl engines for this model year vehicle, but based on online forums there is clearly a manufacturing defect with the V6 engines as well. We were forced to pay ($1,541) for 20% of the cost to repair the engine with rebuilt components after Hyundai kept the car for nearly four months. I feel this payment should be reimbursed given the warranty on the V6 engines also needs to be extended.
Power train, Engine, Fuel/propulsion system, Nov 14, 2024
While driving on rural side road, two lanes, my check engine light (yellow, steady) came on. I pulled into a safe spot and did a quick survey, checked the owner manual, but could not identify any problem, and continued on my way. The check engine light was still on. About 15 minutes later the car would not accelerate past 25 mph (limp mode?). I was on a two-lane mountain road, speed limit 45 (but most cars were faster), visibility limited by terrain, trees, etc. Again, there was little traffic around me and I found a safe place to pull over. in neutral the engine revved normally. I turned the ignition off, checked oil level, (normal), turned the engine back on and started driving to find a safe place to pull over and summon help, but the car drove normally. I drove directly to my repair shop and had the codes pulled, (0436, 0021) which indicate a problem with timing. When a qualified tech examined it he recommended taking to the dealer. Unwilling to drive in traffic, I had it towed to the dealership. Their inspection revealed damage to CVVT components and the timing chain, and recommend an (expensive) engine rebuild.
Engine, Nov 11, 2024
Engine blew due to excessive oil consumption (at time of incident I had not a drop of oil left) with no warning. My safety was put at risk by my car stalling in the middle of driving with my kids in the car. My vehicle is now at a service shop, mechanic informing me I need a whole new engine. My dashboard never showed low oil light or service engine light, I never had black smoke or smell.
Engine, Oct 28, 2024
I went for an oil engine and they told me that my engine didn't have any oil. I checked for oil leaks and the vehicle does not have any oil leaks. My car has 100,480 mileage and have never been in any sort of accident.
Engine, Oct 27, 2024
My car has 81,000 miles on it, I have had regular oil changes and after reading many recalls on here I see I am definitely not alone. My check engine light stays on, after paying $100. for dealer to check the codes I was told nothing in particular showed a problem even though I have to put oil in my car between oil changes and there are no leaks on drive. Apparently the 100K mile warranty is not being honored from the other reports I have read on here. Why ??? The price of new cars is beyond reach and if dealer is claiming there is a warranty there be should be way to make them honor it!!!
Engine, Oct 26, 2024
The engine seized. Driving at 55 mph on a 4 lane highway outside of city limits, the vehicle went into limp mode. Luckily, it was later in the evening with less traffic and I was fortunate enough to be able to turn into a left turn lane and coast into an office building parking lot. There was no shoulder available if I had been in the right lane and somewhat of a rural area. There were no sensors that alerted me prior to this happening. But, when it did happen the dash board lit up like a Christmas tree! It was 6:30 pm, I coasted into a parking spot in the lot and turned the car off. It would not start and I contacted a tow service. I had it towed to an automotive shop near my home. They confirmed the next morning, that there was no oil on the dip stick and the engine seized. They alerted me to the fact that this has become a common problem with this Hyundai engine. I then had the vehicle towed the Hyundai dealership where we purchased the vehicle. We are the original owner. The vehicle is sitting at Rosen Hyundai in Algonquin, IL and should be available for inspection. Monica at the dealership called me after the inspection and confirmed that this is a common issue with this vehicle. She at first used the word recall...and when I asked if there was a recall, she said not a recall, but Hyundai has issued a BULLETIN about this problem. At first, she stated that my maintenance records were in order and being the original owner I qualified to file a claim with Hyundai for engine replacement. 3 days later, she called and stated that Hyundai needed more proof of maintenance than what they could pull off Carfax or my claim was going to be denied. She sent me a picture of the engine and stated that the valves show neglect. I replied of course they do....the engine seized! There was never ever any low oil warning light, check engine or or any warning lights what so ever prior to the event! Hyundai admitted that there is no low oil sensor warning.
Engine and engine cooling, Oct 23, 2024
The contact owns a 2017 Hyundai Santa Fe. The contact stated while starting the vehicle, there was an abnormal ticking noise detected. There were no warning lights illuminated. The contact stated the noise was coming from cylinder #3 and the lifters. The vehicle was taken to the dealer, who was unable to duplicate the failure while starting the vehicle. The vehicle was not diagnosed or repaired. The vehicle was taken to another local dealer Service Center at Gurley Leep Hyundai (5302 Grape Rd Suite #3, Mishawaka, IN 46545); which determined that the cam shaft and pump electronic body sensor, ABS, and harness needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 97,000.
Power train, Other or unspecified, Engine, Oct 15, 2024
While driving a 1/2 second squeal came from engine compartment. Motor immediately stopped. No power steering or brakes. Vehicle is available for inspection. We were on an interstate We coasted to shoulder. There issue is frequent on Internet forums. A trusted mechanic old us the engine was totally seized. Could be turned manually. No oil in crankcase. At this time only aforementioned mechanic has inspected the vehicle. No warning sounds or performance changes prior to incident. No warning lights or notice warnings were seen prior coincident.
Engine, Oct 15, 2024
Since this vehicle reached about 75,000 miles, it has been burning oil like crazy. We have to add a quart every 7-10 days. It drives fine, there’s no oil leaks, no smoke from the tailpipe. We took the car to Hyundai and they did their oil consumption tests. They came to the conclusion that this was within the normal range and would do nothing for us. This needs to be fixed, Hyundai!
Engine, Oct 15, 2024
The engine consumed all of the oil and now has to be replaced
Engine, Oct 9, 2024
Like many others, car consumed a quart of oil each 500-1,000 miles driven. Car received synthetic oil changes every other month along with additional quarts of oil in between oil changes. All service records maintained with receipts of additional oil quarts purchased. Car NEVER displayed any warning lights for low oil pressure or check engine lights. While driving on the highway at 65 MPH, engine seized. Was able to pull over safely and had car towed to the dealership. Service manager at dealer claims it will be over $20k to fix but Hyundai is only willing to cover 70% because it’s no longer covered under warranty and isn’t backed by their extended warranty offer. What a way to admit fault but gaslighting the consumer into believing it’s the consumer’s fault for a faulty product. Hyundai does not allow outside mechanics to look at vehicle or make repairs if you want them to take responsibility. So stuck with paying inflated dealer fees for repair and labor.
Engine, Oct 8, 2024
The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the engine was making an abnormal sound and the RPM increased. In addition, the contact stated that every 2,000 miles engine oil needed to be added to the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed with a cracked valve cover and excessive oil consumption. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the repair was not covered under warranty due to the codes received per the diagnostic test. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 142,500.
Engine, Oct 7, 2024
We purchased a 2017 Hyundai Santa Fe SE ULTIMATE from Hampton Hyundai in December of 2019. The vehicle has the V6 3.3 Liter Lambda II motor. At the time of purchase it had 44,969 miles on it and we paid roughly $27,000 for the vehicle and associated service package. We routinely had the vehicle serviced according to the recommended service schedule. In early 2022 we realized that the engine began burning oil at an alarming rate. We were adding roughly 1.5 quarts every 1,000 miles to maintain a safe level. This was done at a certified mechanic. After inquiring with Hampton Hyundai we were informed that this is considered normal operation and to be expected. Based on that information, we proceeded to routinely check oil levels and maintain them accordingly. On December 23rd, 2022, with roughly 81,000 miles on the vehicle, we experienced a knocking noise coming from the engine. I immediately pulled the vehicle to the side of the road to investigate the possible cause. I checked the oil and inspected the engine for anything that seemed to be out of place. There was nothing that seemed uncommon to the layman eye, with this, we immediately returned home with the vehicle. From here we had it towed to Certified Automotive Repairs and Service (C.A.R.S) and then to Hampton Hyundai. Both locations told us we needed a full engine replacement. We have requested assistance from Hampton Hyundai and Hyundai Motor America to assist with the cost of replacement and have been denied. The quote for a new motor and labor to install is nearly $20,000 and we were told that the cost is so high because Hyundai does not make the motor anymore and each individual part would need to be ordered and assembled. Our vehicle is currently at Hampton Hyundai and we are planning on having it towed back to our home.
Engine, Oct 6, 2024
* Engine seized . No warning . No check engine light until i pulled over on the highway. *My safety , my child's safety and everyone behind me on the interstate had to avoid my rapid deceleration/ * vehicle has not been towed in yet, it will be as soon as the dealer lets me know they will see it *No lamps or bulbs. car seized and lost power
Engine, Sep 28, 2024
Engine suddenly stopped working on the highway, we towed the car to the garage and they mentioned that the crankshaft was misaligned and that the engine must be replaced. We were good with our oil changes over the life of our ownership of the car. It only has 119K miles.