2019 Hyundai Santa FE
Problems, recalls and owner-reported issues
Engine is the leading concern among 200 owner complaints filed for this model year. This is the 17th highest complaint count among 25 Santa FE model years with reports.
Of the 2019 reports, 16 involved a crash and 12 involved a fire. 10 people were injured.
What owners report most often
Recalls and investigations
Trailer hitchesPark outsideMar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Campaign 23V181000 on NHTSA.gov
Air bags, side/windowOct 11, 2018
Hyundai Motor America (Hyundai) is recalling certain 2019 Hyundai Santa Fe vehicles. The Side Curtain Air Bag (SCAB) mounting bolts may interfere with and damage the air bags during deployment.
In the event of a crash, if the air bags become damaged during deployment they may not inflate properly, increasing the risk of injury.
Hyundai will notify owners, and dealers will install a protective cover over the SCAB installation bolts, free of charge. The recall began December 3, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 177.
Campaign 18V715000 on NHTSA.gov
Representative owner complaints: forward collision avoidance
13 reports, newest first. Show all
Service brakes, Engine, Forward collision avoidance, Nov 25, 2025
Overly excessive oil consumption 2 Quarts every 3 or 4 days.no leaks. Engine gets so hot I don't have to turn on heater In winter. On going issue since 100,000 miles. EBS light stays on electronic parking brake switch does not work. Parking brake will randomly engage after vehicle is turned off. Dealership cannot duplicate issue. If cruse control is turned on the vehicles warning lights all of them will suddenly illuminate and the vehicle shuts off. alternator and battery replaced. Have not used cruse control since. Airbags never inflated in a front end crash at 45mph Most recently I started experiencing I intermittent trouble staring the car. Then one day it didn't start at all and smoke was coming from under the hood. Towed to mechanic , starter burnt up 155,000. $ 900 to replace then a couple days later I lost power on the freeway and the car started jerking and vibrating. Stopped Vehicle cut off and would not start. After 1hr I started and limped home. Vibration under 2000 RPMs and when stopped. Knocking noise under hood. Brand new spark plugs. Mechanic stated Cylinder 3;missfire was identified as a hole in a valve due to weak material now I have to replace engine. Oil consumption and excessive friction and heat is to blame. My car has been cared for like a baby it's all I have. I should not have to be responsible for this very cheaply made engine that was doomed to fail.
Service brakes, Forward collision avoidance, Apr 26, 2025
Was at a complete stop at a light with a car in front me, I had plenty of space when I started accelerating and then suddenly the automatic system braked hard. Like there was literally NO REASON for what the car did. It took a few seconds to get out of that issue but then was able to proceed as normal. There have been at least 2 other times where a side sensor was triggered while on the freeway violently jerking me to the left, nearly putting into another lane.
Other or unspecified, Forward collision avoidance, Mar 16, 2025
Car turns off at lights /stop signs. Automatic break system activates. Have to wait at least five minutes to be able to restart car z same happens after driving and parking. Turbo and battery were replaced. I make sure not to use the automatic on/off feature which make issue worse. This is my fourth attempt to contact you. I cannot trade car in bc of mileage and still owing $. I love me vehicle and just want issue recognized and taken care off.
Forward collision avoidance, Jan 11, 2025
Issue with idle on-off. After idling at light etc. car will stall. First time would not re-start , I was towed. Mechanic replaced turbo feature but problem persists and I am not using the on -off feature in an attempt to not have this happen, yet it does.
Steering, Lane departure, Forward collision avoidance, Oct 12, 2024
The Forward Collision Assist would intermittently disable during driving. The Lane Keeping Assist light illuminated and would not allow me to disable it causing the vehicle to drive straight only and to make left or right turns extremely hard to turn the vehicle. This incident occurred on [XXX] and was dropped off at Johnson Hyundai in Wake Forest on that date. After a week of no contact of a diagnosis, I had to visit the dealer and was told the steering column was the issue and needed to be replaced. I contacted Hyundai America to report this issue and currently waiting on a response from their warranty to see if they will cover all or a percentage of the replacement of the steering column since my mileage is over their 100k (113k to be exact) coverage. While I appreciate their efforts, I also feel this could have resulted in a very serious incident had my daughter been driving on the highway when this occurred. Thankfully, she was picking me from home and it happened as we drove off from our house in our neighborhood. A steering column should outlast any other part(s) of a vehicle. If not, this is a huge safety concern. My [XXX] was also in the car at the time and I cannot even imagine how I would recover if something worse were to happen while he's on board. Hopefully this reporting will keep something bad from happening to others who own this type of vehicle but failed to report it. Thank you for your time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Forward collision avoidance, Jun 3, 2024
enciende la alerta de choque y para sin tener vehiculos cerca.
Electrical system, Lane departure, Forward collision avoidance, Aug 1, 2023
the systems forward collision and lane departure warning are randomly turned off. Dealership is not aware of how to fix
Electrical system, Lane departure, Forward collision avoidance, Jun 26, 2023
Adaptive Cruise Control Automatic Emergency Braking Blind Spot Warning Forward Collision Warning Lane Departure Warning Lane Keeping Assistance Parking Collision Warning Rear Cross Traffic Warning Every one of these lights are going off in the car. I’ve taken it twice to the Hyundai dealership. Both times they have not been able to figure out what is wrong with it even with the OPD it’s not showing any issues or fault codes a technician has even had the car for one week went through every single sensor, cable, battery, alternator fuses and didn’t come up with any results. He returned the car back to me completely baffled and unable to fix the issue. Please email at[ XXX] For photos and video which I cannot add here on this website through mobile. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Electrical system, Vehicle speed control, Forward collision avoidance, May 9, 2023
The forward collision avoidance system is malfunctioning and shuts down the traction and stability control systems making the vehicle more vulnerable to collisions. Multiple attempts to repair this system have been unsuccessful
Service brakes, Forward collision avoidance, Oct 9, 2022
For the duration of the vehicle's ownership, it has underperformed and operated unpredictably under hard braking, specifically with relation to the vehicle's ABS system. The conditions have caused meto never drive the car in snow, as this weather condition in particular exacerbates the braking issues and makes the car unsafe. Issues with the braking/ABS include: The ABS activating at slow speeds in all conditions, even on dry roads The ABS activating and preventing the vehicle from being emergency stopped in adverse conditions The ABS activating and exponentially extending the braking distance until it disnegages The ABS, once activated, does not stop unless the brake pedal is lifted from its initial activation position The vehicle doesn't appear to have any mechancial braking issues. Everything seems to be related to the ABS system, wheel-speed sensors and/or vehicle-management systems. The overall braking experience in this vehicle with the ABS on is that it simply will not stop within a safe braking distance window. The only way to stop this vehicle is without ABS. There is no other way to safely stop this vehicle with ABS. I have reached out to my Hyundai dealer and Hyndai corporate directly, both times being dismissed without anyone attempting to recreate the braking issues. I have a life's worth of experience driving in snow and multiple ABS activations in a range of vehicles. This is abnormal based on all of the experiential knowledge I possess, as well as a lifelong interest in cars. While I am not an engineer, I possess enough firsthand and academic vehicle experience to recognize the abnormality of this vehicle braking operation.
Forward collision avoidance, Sep 7, 2022
The contact owns a 2019 Hyundai Santa Fe. The contact stated that the check Forward Collision Avoidance warning light was illuminated. While driving at various speeds, the vehicle veered into oncoming traffic. The vehicle was taken to the local dealer where it was diagnosed that the sensor in the windshield had malfunctioned. The vehicle was not repaired. The vehicle was taken to an independent mechanic who stated the windshield sensors were working as designed. The manufacturer was notified of the failure and referred the contact to the local dealer for assistance. The failure mileage was approximately 69,550.
Forward collision avoidance, Feb 10, 2022
12/26/2021 Driving on I40 E between Santa Rosa and Tucumcari using adaptive cruise control (SCC) at approx 68 m.p.h the brakes were harshly applied which resulted in the vehicle rapidly de-accelerating from approximately 68 m.p.h to approximately 5 m.p.h. (There was a warning displayed on the odometer panel). no vehicle or other obstacle within eyesight to the front, side of rear of our vehicle. Vehicle resumed driving on cruise. No warning prior to the event. Vehicle was taken to the local Hyundai dealership on 12/30/2021 for diagnosis, the mileage was 21066. The technician reported no DTC's found and suggested it might have been caused by the windshield mounted "dash cam", the "dashcam" was not in a position where it could possibly interfere with the vehicle camera, (it has been in the same position since vehicle purchase and remains in the same position today), possibly some critter that ran out in front of us and we did not notice it or maybe a big bug flew into the vehicle. also there was no obstruction to the forward vehicle radar. The vehicle was not road tested. This fault since the first instance has not happened again. this fault has been noted by other owners on various Hyundai owners blogs. This vehicle has FCA + Pedestrian, SCC, LKA.
Forward collision avoidance, Dec 15, 2021
"FCA" system disabled radar blocked" error came on while test driving on 3 separate occasions but no diagnostic code recorded, prior to taking possession they replaced a camera they thought to be the cause 11 days later during a snowy morning I got the same error again. Again it didn't register a code and I was told by the dealership no code, no problem. Spoke with Hyundai customer relations and was told I have to take it back to the dealership for them to diagnose it, and the condition has to be reproduced for them to note the error but We have not had snow since that morning therefore the system error has not reappeared. The likelihood of being able to reproduce the circumstance during business hours and be able to get it to them to witness the situation is minuscule at best. If this safety feature is deactivated when something as simple as a snowflake blocks the sensor then it isn't really a safety feature. The safety features contributed to my decision to purchase this vehicle (Nov 1st) but all I am told was the radar was blocked and therefore caused the deactivation, but again how can something as simple as a snowflake cause this error and the manufacturer not address this as a safety concern.