2020 Hyundai Santa FE
Problems, recalls and owner-reported issues
Engine is the leading concern among 213 owner complaints filed for this model year. This is the 14th highest complaint count among 25 Santa FE model years with reports.
Of the 2020 reports, 13 involved a crash and 9 involved a fire. 15 people were injured.
What owners report most often
Recalls and investigations
Trailer hitchesPark outsideMar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Campaign 23V181000 on NHTSA.gov
Visibility, windshieldDec 28, 2021
Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.
A windshield that detaches from a vehicle during a crash can increase the risk of injury.
Dealers will remove and reinstall the front windshield panel, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 216.
Campaign 21V00M000 on NHTSA.gov
Representative owner complaints
213 reports, newest first.
Engine, Nov 17, 2023
On 01/21/2023 after exiting thr highway and pulling into a shopping center signals started popping up on my dashboard and ny car lost speed. I tried making it down the rd to a tire discounters but ny car lost complete power and would not turn on. A tow truck toad it to the tire discounters and once on the flat bed it was a puddle of oil and a trail of oil coming from my car. Once there tire discounters states that my car needed to go to a dealership. It set at kerry hyundai Alexandria until may 2023 waiting to be diagnosed. Once diagnosed it stated that ny car was missing the drain plug and that I needed a brand new engine. I had a oil change at car x on 12/10/2023 and hyundai blamed car x stating that they didn't tighten my plug. But car x denied. I got a lawyer n began to sue car x when car x lawyer responded stating that there were other people having the same problem and hyundai was being investigated. My car is currently still sitting at hyundsi because I don't have 7800 for a engine and hyundai will not cover the engine under warranty
Other or unspecified, Nov 9, 2023
The metal cable that holds the spare tire snapped off while the car was driving out of our driveway. And the tire flew off the car nearly causing it to crash.
Engine, Nov 6, 2023, fire
After having a warranty repair for a valve cover gasket' at CENTEREACHHYUNDAI, I picked up my car. Only 8 minutes into my drive home the engine light went on and engine error code appeared. At that piont smoke was coming from the hood when I heard a pop and flames appeared at my passenger side window. I turned the car off removed my phone and exited the vehicle. No one else was in the car but within minutes the fire was totally involved. I also noted it took the fire department very long to arrive. If anyone was trapped in the car they would have peristed.
Engine, Engine and engine cooling, Nov 5, 2023
Oil leak from oil pan area. Took the car to the dealer twice to get it fix and the problem temporarily stop but now is continuing to leak again. All they did was retighten the oil plug the first time and then the second time replaced the oil plug with a new one. They said it was a bad oil plug washer and now it should stop the leak, but now it’s leaking again. Took notice of the leak when the car was parked in garage overnight and a pool of oil formed under the car again. This is scary because losing oil like this is not normal and if it continue it could seize the engine while the driver is driving it risking the safety of the driver and car.
Electrical system, Forward collision avoidance, Oct 18, 2023
Numerous different occasions since I bought the vehicle this year in March 2023 when on highway, side streets and even in parking lots with nothing, no cars no objects or humans in front or behind the vehicle my forward collision warning and rear end collision warning has came on which caused the car to break on its own and it is a safety concern. I have been to the dealer numerous times since I’ve bought the vehicle and currently have reached out to Hyundai Motors of America and pretty much got told to suck it up nothing they can do for me as the computer isn’t showing any codes or issues my car has now been at dealership where I bought it for 2 weeks now and no resolution besides come get the car and figure it out on my own and as a single mother with a child with disabilies I don’t know what else to do.
Fuel/propulsion system, Lane departure, Oct 12, 2023
Catalytic converter is failing Lane collision warning failing driver side rear view mirror
Other or unspecified, Oct 4, 2023
Sitting in parked vehicle. Opened the rarely-opened panoramic sunroof. Heard unusual sound,. Looked next day and noticed a stationary glass panel forward of the sunroof had shattered all the way around but had not collapsed (yet--have tape on it to keep it intact until repairs can be made). Hyundai does not consider this to be a warranty issue. The warranty states in the "What is not covered" section: "- Action of road elements (sand, gravel, dust or road debris) which result in stone chipping of paint and glass." Dealer documented it and basically said "too bad". Since the issue being reported was NOT caused by road debris etc., This should be a warranty coverage matter. Similar instances have happened to others (entire sunroof) and has been reported. This glass should be LAMINATED--not tempered--but is not. This could be a major safety concern.
Exterior lighting, Oct 3, 2023
Intermittently when you turn the left turn signal, it will be a delay of 2-3 seconds to actually turn on the lights. Usually it happens in the morning when cold.
Engine, Sep 20, 2023
Oil pan cracked leaking oil
Visibility/wiper, Sep 14, 2023
I had been driving my vehicle for about 5 minutes when I heard what sounded like a loud bang or gunshot followed by the sound debris falling. I realized the front piece of my panoramic sun roof had literally exploded. When I got out to look at it the glass around the hole was pointed upwards so it looked like it exploded from the inside out. The glass had no prior damage and nothing hit it before the explosion. I was on a paved road by myself.
Structure, Other or unspecified, Visibility, Aug 23, 2023
I was driving and heard a sound like an explosion. When I was able to safely pull over, I examined my 2020 Sante Fe and noticed the panel of glass right before sunroof exploded. No rock hit it, just exploded.
Tires, Aug 2, 2023
235/60R18 Tire leak & brittle texture
Power train, Jul 21, 2023
The contact owns a 2020 Hyundai Santa Fe. The contact stated while driving out of the driveway, the vehicle unintendedly accelerated at high speed without warning. Additionally, while in traffic, the vehicle started to stall with a delay while accelerating. The contact attempted to shift into reverse however, the vehicle failed to respond with the transmission warning light illuminated. The contact turned off and restarted the vehicle, but the vehicle failed to operate as designed. The vehicle was taken to the dealer who stated that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was 35,000.
Forward collision avoidance, Jul 19, 2023
I was pulling out of a sidestreet and realized a car was coming and used the brake. The Automatic Braking system activated and VIOLENTLY stopped the car. I was only going about 5 miles an hour but the tremendous force from the Braking system caused my rotator cuff and my bicep to tear. It cost me thousands to pay for surgery and physical therapy. I am very worried about all the injuries that this system causes. I have since had the dealership turn it off. I can not risk being injured like that because the car thinks that there will be a collision when I know that my manual braking was sufficient. There was no chance of any accident. I had Hyundai (case # 20962390) inspect the car & they claim (after 4 different inspections) that there is no issue with the system. They also claimed that it wouldn't activate at 5mph but I know that is not true. So if it works correctly, how many people are injured? Before you mandate that the car stop at 65mph, you need to gather more info on how many injuries have occurred.
Electrical system, Jun 27, 2023
******* DELETE VOQ ******* THIS COMPLAINT IS BEING MARKED FOR DELETION BECAUSE IT IS REQUESTED BY THE CONSUMER THAT THEY WISH TO HAVE IT REMOVED*DJR ******* DELETE VOQ *******
Vehicle speed control, Forward collision avoidance, Jun 24, 2023
I was driving on an interstate highway at approximately 75 mph. I had cruise control activated. Suddenly the car dramatically slowed down, accompanied by rapid beeping noise. Luckily, there was no one close behind me.
Engine, Jun 21, 2023
The contact owns a 2020 Hyundai Santa Fe. The contact state that while driving into the driveway, the engine seized without warning. The vehicle was towed to the dealer where it was diagnosed that the oil drain plug had failed, and the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 43,000. The VIN was unavailable The vehicle was repaired at the owner's expense with no assistance provided from the manufacturer.
Engine, Jun 19, 2023
The vehicles oil was changed on 3/22/23 at 22,395 miles. Almost 3 months and 1500 miles later when driving the engine seized. No lights came on. Vehicle was towed to Hyundai dealership who said it is the fault of whoever did the last oil change as the drain plug came loose. After doing research it appears that this is a known issue with Hyundai. Also, fresh oil was all over the driveway which was not noticed when car was leaving the driveway.
Power train, Engine, Fuel/propulsion system, Jun 7, 2023
Car stalling and don't move when it's in a complete stop
Trailer hitches, Jun 6, 2023
The contact owns a 2020 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number:23V181000 (Trailer Hitches) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Forward collision avoidance, Jun 1, 2023
This vehicle has the Accident Avoidance system which is great until it snows or there's a heavy rain then you get lights on the dash and the Accident Avoidance system and cruise control turn off because the sensor gets covered with snow or heavy rain. I spoke with a service technician who said it's a know issue but there are no fixes at this time. What the sense in having a safety system that shuts off when you need it the most in bad weather. Once you clean the snow or ice off the sensor area the lights go out. It happens any speed.
Electrical system, Service brakes, Engine, May 18, 2023, crash
On Thursday, May 11, 11:45 am, I experienced a distressing incident at Moulton Elementary School in Laguna Niguel, CA, 92677. my car was parked near the school building, with the engine turned off and the gear set to park. I was there to pick up my children, and at that time, nobody was inside the vehicle. Unexpectedly, my car started moving backward as if in neutral gear, despite being in park mode. I estimate I was approximately 10 feet from the vehicle in front of the school building. The situation was alarming because numerous children were nearby, which could have resulted in a tragedy. Thankfully, no one was injured or hit by the moving vehicle. Instinctively, I attempted to stop the car by using my entire body to push against it. Unfortunately, my efforts were unsuccessful, and as a result, I sustained severe back pain. I have been on bed rest for the past five days due to the discomfort caused by the incident. Subsequently, the vehicle collided with another car, which belonged to a teacher. The incident shocked everyone, and the reason behind the car's unexpected movement remains unclear. Later, I discovered through online research that my car was actually on the recall list, but I had not been informed of this beforehand. As a result of the incident, we contacted the police, and they arrived at the scene can confirm that the car was indeed in park gear during the incident. It is vital to investigate this matter thoroughly to determine the cause of the vehicle's accidental movement and prevent future accidents. I hope that this statement provides a clear account of the accident that occurred at Moulton Elementary School. I strongly urge authorities and the involved parties to take immediate action to address the issues surrounding my car's movement and prevent any similar incidents from happening again.
Power train, Apr 19, 2023
Purchased my 2020 Santa Fe august 1st 2020. Mother’s Day of 2021 I was driving to Menards for a plant. I was going 40 mph on a street and braked too slow down to go on a ramp that was 25mph. Traffic appeared and I was stopped completely. I have the “auto” stop on and it would not start back up. I had to put my car in park, turn it off and turn it back on in the middle of traffic. So scary. And this happens monthly now, since august 2021.
Engine, Engine and engine cooling, Mar 27, 2023
Driving down the road I heard a loud noise when I stopped I noticed oil under my car. When I was 0.1 mile from my house the oil light came on. I arrived home called Hyundai and they towed the vehicle and reported that the oil plug had was missing and I need to contact the place that changed my oil last.
Structure, Mar 26, 2023
Large sections of paint peeling from vehicle. Paint starts to bubble and then crack in large pieces. One section has peeled and flew onto the windshield while driving. Hyundai has recently had issues with this white color paint and it is continuing to be a problem. Report has been made to Hyundai with no resolution.