2021 Hyundai Santa FE
Problems, recalls and owner-reported issues
Power train is the leading concern among 166 owner complaints filed for this model year. This is the 21st highest complaint count among 25 Santa FE model years with reports.
Of the 2021 reports, 4 involved a crash and 2 involved a fire. 2 people were injured.
What owners report most often
Recalls and investigations
Back over prevention, sensing system, cameraNov 21, 2024
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A rearview image that does not display reduces the driver's visibility and increases the risk of a crash.
Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed January 14, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 271.
Campaign 24V879000 on NHTSA.gov
Trailer hitchesPark outsideMar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Campaign 23V181000 on NHTSA.gov
Power train, automatic transmissionOct 6, 2022
Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.
Loss of drive power increases the risk of a crash.
Dealers will inspect and replace the transmission, as necessary. Dealers will also update the transmission control unit software. All repairs will be performed free of charge. Owner notification letters were mailed January 10, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 236.
Campaign 22V746000 on NHTSA.gov
Visibility, windshieldDec 28, 2021
Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.
A windshield that detaches from a vehicle during a crash can increase the risk of injury.
Dealers will remove and reinstall the front windshield panel, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 216.
Campaign 21V00M000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsJul 9, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.
A fuel leak increases the risk of a fire.
Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 207.
Campaign 21V524000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 3, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles equipped with 2.5-litre Turbo engines. The fuel pipe connecting the high pressure fuel pump to the fuel rail may not have been tightened properly.
An insufficiently tightened fuel pipe may leak fuel, increasing the risk of a fire.
Dealers inspected and tightened the fuel pipe connection, free of charge. The affected vehicles have been repaired and therefore no owner notification letters will be sent. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 206.
Campaign 21V308000 on NHTSA.gov
Air bags, air bag/restraint control moduleMar 17, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles. The Occupant Detection System (ODS) module may not deactivate the air bag upon detection of a child restraint system in the front passenger seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
In the event of a crash, deployment of the front passenger air bag, with a child in that seat, can increase the risk of injury to the child.
Hyundai will notify owners, and dealers will replace the ODS module, free of charge. All affected vehicles have been remedied as of May 12, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 202.
Campaign 21V185000 on NHTSA.gov
Representative owner complaints: engine
37 reports, newest first. Show all
Electrical system, Engine, Oct 22, 2022
Car was bought approximately a year and a half ago and it was working fine until last September 2022 when it started to stall the engine when having ISG (Idle Stop and GO) ON. It has no pattern, but during the last 2 months it has shut down more than a dozen times. I've taken the car for inspection at Hyundai (2 times so far) and they can't find any faults when running a scan and said that they car is just fine. They assured that an ECM update would solve the issue but it has not improved anything in the car. The car has continued the pattern , when you stop the car it starts to shudders before stalling the engine, all without any error lights. Next November will be the third time bringing the car for the same issue without any resolution. Also, as a minor problem, it has started disconnecting the cellphone from the apple car and you can't reconnect it unless you turn off the car.
Power train, Engine, Fuel/propulsion system, Sep 26, 2022
This SUV has been plagued with issues, and yet after 5-6 visits to the dealership, they don't seem to be able to fix them all. The vehicle (2.5T AWD) currently has around 14k miles and within the past month the gas pedal suddenly became unresponsive, worst of all while carrying my kids and wife in the car. Coming to a dead stop to cross an intersection, went to accelerate to join traffic and the car wouldn't accelerate. Last time on 9/23 when I almost got into a head-on accident while making a left turn as the car barely moved into the first of three incoming lanes, would not accelerate and so forced me to quickly hit reverse, outrageous! Other three times while making a right turn. Auto engine-off has been disabled on all occasions (hate it); two times happened while driving on smart mode, another one on comfort and another one on sport mode. Car has been always using Mobil, Shell or Chevron gasoline. Which also brings me to another point, the vehicle suddenly started consuming crazy amounts of gas, currently at 16mpg for the past 4 full tanks! The vehicle was dropped off at dealership on 9/26/22 and already filed for Lemon Law in FL as this is absolutely unreliable and dangerous to carry my family on. According to manager at Rick Case Hyundai of Davie, an update for the transmission just came out this week after a recall and so they were going to reprogram. I am still getting rid of this p.o.c.
Power train, Electrical system, Engine, Sep 23, 2022
Car was without power after 16 months and 7500 miles. Got it jump started. Two days after that, car would not start again. Second time jump started. Taken to the dealership (Alexandria Hyundai) where two days after that they found "nothing wrong with the car" and returned it to me. Before that, I asked them to change the battery, they denied my request and I paid out of pocket for a new battery as maybe that was the problem. One month approximately after that, car would not even open. Got it jump started again. Drove to blocks and completely and suddenly shut off in the middle of a busy intersection posing a major safety concern for myself and third parties. Involved 911 and towing. Had to spend 40 minutes depressing the brake for the car not to roll down and avoid an accident. Taken to the dealership again. 5 days after that, dealership found "nothing wrong with the car". 7500 miles inspection done in parallel "supposedly" put the tires at 35 psi per report issued but dashboard shows tires at 30 psi. Do not trust dealership, car poses significant driving and safety concern for me and third parties.
Engine, Aug 17, 2022
This car since 6/7/22 has been plagued with issues where is starts cutting out and stalling followed by the check engine light coming on flashing. This has happened many times and just happens while driving down the road. It is a very dangerous condition as you can not predict when it's going to stall out. The car has been in the dealership 3X for this problem and spent over 40 days there. Hyundai replaced the fuel injectors claiming that was the problem. It was over 35 days to get the back ordered parts. They were replaced and the car seemed to be running OK. I drove it for about 150 miles and it ran like new. Then on 8/13/22 while driving in traffic on NH Highway US1, it started doing it again. I went into the Hyundai dealership since was right there. I brought the technician out and showing him my running car with the running car with blinking CEL. They pulled into into the shop and ran a scan on it. They said there was no active codes. I asked to leave the car with hem so it could be investigated and there response we "we don;t have a car for you until next Tuesday". I was forced to drive off in a confirmed dangerous car. I pulled out into traffic on US1 and the car immediately lost power and started cutting out and the CEL was back on and blinking. I turned around on the very next street, turned the car off and back on and the CEL cleared. I pulled back onto US 1 and the car immediately lost power and started cutting out and the CEL was back on and blinking again. This very nearly caused a 2nd accident as ad zero power to accelerate. My concern is Hyundai has no idea what the problem is. They know there is a dangerous problem. The service manager drove the car/confirmed himself there is a serious issue. My other concern is the Hyundai dealership knowingly sent me away in a car they had confirmed for themselves was unsafe nearly causing a accident on the highway. I had to speak with the General manager to get a loaner to leave my defective car.
Power train, Electrical system, Engine, Aug 1, 2022
I took my car to the dealer because it hesitates when accelerating. I was told since no lights are on there's nothing they can do. This can be very dangerous as it jerks when accelerating
Engine, Jul 19, 2022
When ISG (Idle Stop and Go) is ON, vehicle will completely turn off when pressing brake to stop. Vehicle shut off on me yesterday yielding to turn onto a busy highway. It took 5+ mins for vehicle to crank back up. Very dangerous! No warning lamps, messages, or symptoms other than vehicle completely shutting off. An appointment has been made at Hyundai dealership next month which is the first available time. Please look into this issue before someone is seriously hurt or killed!
Engine, Jun 10, 2022
Problem first started on 3/31/22, car starting showing engine light as well as forward safety system off. Car would not accelerate and was shaking spuddering when foot was off the brake. Pulled into a safe location and called Towne Hyundai Genesis of Denville (Rt. 10, NJ) to schedule a service appointment and was told that there were NO appointments or availability until May. I expressed my concern that I did not feel safe driving the vehicle and the response was that I could drop off the car for 4-6 weeks and they would look at it when they had a chance. I asked if there was a loaner car available and they said no that 100's of other people have problems. I took my car to a local shop to see if they could diagnose the issue and they ran a diagnostic test and the error P2127 (Throttle/ Pedal Position Sensor/ Switch E Circuit Low). The Hyundai BlueLink shows 2 alerts for Chassis on 3/31/22 as well. After this date I felt unsafe driving my car and have drove the vehicle a handful of times in 2 1/2 months unable to get an appointment. The alert would come on as soon as you turned the vehicle on until 6/4/22 when it occured while driving on a highway and the car stopped accelerating. I took the vehicle to Hyundai and they updated the system and stated that it was fixed. Within 15 minutes of driving it the issue came back, and I called them and they once again stated that I could leave it there for 4-6 weeks without a loaner. This car is extremely unsafe as it will just stop accelerating without any warning.
Electrical system, Engine, Jun 7, 2022
The vehicle sporadically turns off its engine by itself, mostly stopped when placing the transmission in park gear. One time the engine went out in the middle of the avenue. After these events when starting the engine it makes a noise for a few seconds. I have taken the vehicle to the dealer and they say that there is no type of technical bulletin on this type of problem.
Power train, Other or unspecified, Engine, May 30, 2022
Problem #1 - At least 4 quarts of oil spewed from the oil tank and covered most of the engine for an unknown period time. There were no notifications, alerts, or any other indication concerning the oil tank having 1 or less quart of oil. Ultimately, there are at least three (3) questions that need to be addressed 1.In a 2021 Santa Fe, what would cause both the timing and valve covers to leak out at least four (4) quarts of oil out of the oil tank onto the engine. 2.Why was there no notification, alerts, or indication that the oil tank only had less than one (1) quart of oil. 3.What other damage could there have been to the engine beyond the several parts identified as needing to be replaced, that was not identified. A Chronological Order of Events is available.
Engine, May 9, 2022
My Santa Fe has less than 14k miles. In many instances, the car has stalled when turning on. The engine would tremble and then shut the engine off while the dash lighting/symbols stay on. It will idle for a quick second and then drop to zero. Another instance is when driving into a parking spot and driveway and we applied the brakes. At that moment the engine shut off while the dash lights/radio and everything else stayed on. In all instances, if we apply the brake and then hit the start button, the car will typically turn on and act like nothing ever happened. In 2 instances, the blind side detection would turn off while driving and all the warning lights would come on the dash. After turning it off and letting it sit for a few minutes it would disappear. One time the front detection would go off and there was no car in front of me for about 8ft. The beeping continued after we drove off and it eventually reset itself and never happened again. I’ve notified the Hyundai dealer but they claim if they can’t recreate it then they can’t fix anything. My previous Santa Fe did the same thing and they had it for 2 weeks with no results. Although my blue link app showed the car was never moved from the parking spot which made me wonder if they even tried anything. I have videos of the Santa Fe stalling.
Electrical system, Engine, Fuel/propulsion system, Sep 28, 2021
Car would not start; battery was too low to activate lights or locks, let alone starter. An attempted jumper cable connection to an older car was insufficient to make the motor turn, even after just running the assist car while connected for 20+ minutes. A subsequent jump from the AAA 2000 Ah jump pack did work although their ‘test’ indicated battery state-of-charge and state-of-health to be less than 30%. Their obvious recommendation was battery replacement and, with the vehicle now running, a drive to the dealership was attempted. At the first intersection a full vehicle stop engaged the engine Stop-Start function, but without sufficient battery for the ‘Start’ part. Not only would the vehicle not restart but there was insufficient battery power to put the transmission into PARK nor engage the emergency brake to prevent the vehicle from rolling into busy cross-traffic; only the service brake worked. Fortunately, a nearby motorist recognized the emergency and placed rocks under the tires to prevent the vehicle from rolling forward. The vehicle was towed to the dealership where the battery was replaced without significant comment on the total failure of nearly all systems in the event of battery failure. The outcome of this major battery failure could have been catastrophic as the ONLY system even marginally functional was the non-power-assisted service brake.
Engine, May 21, 2021
It's only been less than a month, since I bought this car and I've driven ~500 miles. Now when I was driving the car yesterday it just stopped in the middle of the road all of a sudden for no reason. After getting the car towed to the service center, they are reporting that there is an issue with the car's transmission and they are going to replace it.