2021 Hyundai Santa FE
Problems, recalls and owner-reported issues
Power train is the leading concern among 166 owner complaints filed for this model year. This is the 21st highest complaint count among 25 Santa FE model years with reports.
Of the 2021 reports, 4 involved a crash and 2 involved a fire. 2 people were injured.
What owners report most often
Recalls and investigations
Back over prevention, sensing system, cameraNov 21, 2024
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A rearview image that does not display reduces the driver's visibility and increases the risk of a crash.
Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed January 14, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 271.
Campaign 24V879000 on NHTSA.gov
Trailer hitchesPark outsideMar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Campaign 23V181000 on NHTSA.gov
Power train, automatic transmissionOct 6, 2022
Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.
Loss of drive power increases the risk of a crash.
Dealers will inspect and replace the transmission, as necessary. Dealers will also update the transmission control unit software. All repairs will be performed free of charge. Owner notification letters were mailed January 10, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 236.
Campaign 22V746000 on NHTSA.gov
Visibility, windshieldDec 28, 2021
Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.
A windshield that detaches from a vehicle during a crash can increase the risk of injury.
Dealers will remove and reinstall the front windshield panel, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 216.
Campaign 21V00M000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsJul 9, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.
A fuel leak increases the risk of a fire.
Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 207.
Campaign 21V524000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 3, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles equipped with 2.5-litre Turbo engines. The fuel pipe connecting the high pressure fuel pump to the fuel rail may not have been tightened properly.
An insufficiently tightened fuel pipe may leak fuel, increasing the risk of a fire.
Dealers inspected and tightened the fuel pipe connection, free of charge. The affected vehicles have been repaired and therefore no owner notification letters will be sent. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 206.
Campaign 21V308000 on NHTSA.gov
Air bags, air bag/restraint control moduleMar 17, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles. The Occupant Detection System (ODS) module may not deactivate the air bag upon detection of a child restraint system in the front passenger seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
In the event of a crash, deployment of the front passenger air bag, with a child in that seat, can increase the risk of injury to the child.
Hyundai will notify owners, and dealers will replace the ODS module, free of charge. All affected vehicles have been remedied as of May 12, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 202.
Campaign 21V185000 on NHTSA.gov
Representative owner complaints: forward collision avoidance
18 reports, newest first. Show all
Electrical system, Service brakes, Forward collision avoidance, Jan 14, 2026
Was coming off an exit on the interstate and started slowing down. My brakes act like they didn’t want to work. Grinding and the pedal was twitching under my foot. The car stopped thankfully, but then all Linda of lights came on the my dash and will not go off. And 3 warning come up!
Forward collision avoidance, Jan 2, 2026
On 1/1/26 while traveling on the highway with no traffic in front of or right of my vehicle the ADAS emergency brakes applied themselves and slowed the vehicle nearly causing my vehicle to be rear ended. Vehicle is available for inspection. Faulty assistance nearly caused a rear end collision along the highway. Not aware of ADAS being tested inspected although multi-point inspection was done 10/2025. No warnings prior to incident.
Forward collision avoidance, Aug 6, 2025
For a few month now the light of ABS have been turning on. At the beginning there was no diagnosis specific, cause kept turning off. Two or three months ago again turn on and gave code of back caliper on the left and was changed. An now yesterday August 5, 2025 the diagnosis its need of change of the SBS module whole.
Electrical system, Back over prevention, Forward collision avoidance, May 27, 2025
I am writing to formally express my deep concern and dissatisfaction with the ongoing quality and safety issues I have experienced with my 2021 Hyundai Santa Fe, which I purchased new in March 2021. Despite regular maintenance and careful ownership, this vehicle has presented a persistent pattern of failure—most notably involving the electrical systems, onboard cameras, and overall build quality. Specifically, the following issues have occurred: •The rear backup camera has intermittently failed for an extended period, frequently displaying a black screen or static lines, rendering it unusable. •The front camera system has now failed entirely, disabling several advanced safety features. A warning alert is permanently displayed on the dashboard and cannot be dismissed. •I was recently informed that repairing this front camera will cost approximately $2,400, a significant expense for a system that should not fail this early in the vehicle's life cycle. •The overall quality of the interior materials has proven to be poor, with excessive wear and inconsistent performance of various controls and features. •In general, the engine power and performance fall well below expectations, especially given Hyundai's advertised standards. These recurring issues have not only affected our driving experience but have also introduced serious safety concerns, particularly as critical systems such as cameras and driver-assist features are now non-functional. We have never experienced this extent of problems with any vehicle in our ownership history. At this point, we are extremely disappointed and frustrated, and we feel that Hyundai has failed to uphold the level of quality and reliability expected from a modern, family-oriented SUV.
Other or unspecified, Forward collision avoidance, Dec 30, 2024
I hadn't been begging Hyundai to help remove a public safety risk for years ! Today, The service lady witnessed my car have a severe safety defect. Although initially offering a rental car, ultimately denied due to my inability to provide insurance until the 1st. My insurance is valid until tomorrow. N they REFUSED to provide the rental without the insurance being dated for 4 days from today. The man in the service office asked if I needed a ride home!? Suggesting i drive the car home. Hyundai has witnessed this cars emergency parking failing, and are aware that this car has rolled out of gear TWO TIMES, W my son in it !!?? Until today, claiming unable to "duplicate" the defect. And unable to "substantiate " my claims due to not being able to duplicate the deflect. They duplicated the defect today. The car no longer has a safety system, that safely parks the car, when the door is open. The safety system fails, at more then half of the attempts,engage and the car will roll in either direction with the car door wide open The service department duplicated the defect today. They claim to have documented the defect . i would like to believe they will finally do what is right.. The realistic fact that they have chosen to disregard the safety of the community, and refuse to offer the rental car, is extremely dangerous to the community and neglectful to the laws of the Safety Act and my Consumer rights. With now, TWO (NOT AT FAULT) Rollaway accidents , insurers are refusing n to provide coverage for the vehicle. Some only offer liabilit, or want 4 xs the quoted rate. Hyundai is aware that this car is defective.. Hyundai has a recent consent order, for over 54 millionth dollars, for untimely recalls and falsafying reports to the NHSTA . They are now, as they then, are in violation of the Safety Act and the NHSTA Consent Order with Kia in the Theta II engines Class Action The purpose of the Safety Act, is to prevent serious injuries, from known defects before
Service brakes, Forward collision avoidance, Mar 19, 2024
The Automatic Emergency Braking system activated without there being any vehicle in front.This was on a highway at 60 mph. It lightly braked for a couple of seconds with the warning light flashing and beeping as well.There was no prior indication prior. I will be taking vehicle to dealer.
Other or unspecified, Engine, Forward collision avoidance, Sep 23, 2023
April 2022 My 2020 one, Honda Santa Fe started rolling backwards in rolling to a flagpole as I was walking away from the car. I tried to to catch up with the car. It had my family inside screaming. But I was unable to stop it from slimming into the fireplace. I let Hyundaiusa know. They recommended that I take the car to the dealer. They promised to reimburse me for rental car after the diagnostic came back. they found nothing wrong with the car and never paid for the reimbursement Now September 2023. Same thing just happened again. I was in McDonald's drive through and I drop my debit card so I got out to get my debit card. I got out of the car and had to close the door and as I bend down at sensed the car start starting to pull away. The car once again started running away for me. I was outside the vehicle, but I was able to jump in the car and apply the brake before it slammed into McDonald's. I have made a police report. And I have a witness from McDonald's That saw the incident. I had already reached out to the attorney General's office About the first time the car rolled away from me in April 2022. They claim that my Hyundai found nothing wrong with the diagnostics. There was no argument I can make except for Being called a liar. The mechanic did a little demonstration showing us how the safety mechanism in the Santa Fe makes it impossible for the car to roll out of park if the doors open or. How it's impossible. Even if the door is open, it shifts back to park. If you hit the drive button with the doors open It automatically shifts to park. .. So there's supposed to be "no way. The car can shift out of park into drive or neutral." It rolled away in 2022 April, and it did it again September 2023.
Service brakes, Forward collision avoidance, Jun 15, 2023
The automatic emergency braking has engaged 6 times while backing up and there has never been anything behind the vehicle.
Other or unspecified, Engine, Forward collision avoidance, Apr 25, 2023
There were 2 instances where my vehicle stopped. Once I was driving 15mph and it said “Put car in Park”. The 2nd, I was driving 45mph and the vehicle said “Step on the Brake to start car”. I have also had 2 instances where my odometer just keeps going up and down. He 2nd instance, the car was making a ticking noise and hazard along with other lights were flashing.
Electrical system, Engine, Forward collision avoidance, Dec 12, 2022
I was accelerating after being at a stop sign onto a major two lane road when all of the warning systems came on and the car stalled while the front of the car was partially on the major two lane road. The alarms, including the collision warning were going off, and it took me several minutes to restart the engine. I was very lucky that I was not hit by oncoming traffic. This was immediately reported to our local Hyundai dealer. They took two weeks to schedule our appointment and then told us nothing was wrong and that everything "checks out". Today, I receive the recall notice telling me the loss of power "could increase the risk of a crash" and yet they do not yet have a fix for it. This means I am paying for a car that is unsafe to use with no remedy in sight. Had this occurred on the highway, I would have been killed.
Steering, Electrical system, Forward collision avoidance, Nov 13, 2022
While driving the crash avoidance emergency braking came on out of nowhere, and the steering locked up. I was driving on a straight and level roadway with no vehicles in front of me when suddenly the whole dash lit up with warning lights and the car, a 2021 Hyundai Santa Fe, came to a emergency stop, the steering wheel was shaking and wouldn't turn. This was the second time this happened. The first time on 09/29/22 I called the car dealer and was told that "They knew of the problem and that there was no remedy". This is extremely dangerous, both times it happened while I was driving on a highway at a steady speed, thankfully the roadway was dry if it had been raining I would have probably crashed.
Seat belts, Forward collision avoidance, Aug 25, 2022
Emergency braking comes on with no vehicles in front for 1/4 mile. Passenger front seat belt is no working properly. Caution Collision comes on sporadically. Clock does not show correct time. Stop-Start System works sporadically. A/C fan blows out defrost sometimes. Remote start does not always work or shuts off too soon. Case Manager does not return calls. Changed Case Manager but NO BETTER. Hyundai DOES NOT CARE.
Electrical system, Forward collision avoidance, Nov 3, 2021
While driving in the fast lane on the freeway at speed limit the car suddenly began to slow/stop, after which a warning flashed on the display that said Danger, collision imminent, or something like that. There was no one close in front of me when that happened. This exact scenario has happened three times now in this car, in the same way! I felt my life was endangered every time by the sudden and unnecessary braking of my car.
Forward collision avoidance, Sep 28, 2021
Smart Cruise Control relies on the inconsistent and consequently unreliable performance of the of the front-mounted radar. Otherwise-reasonable operation of the Cruise Control would abruptly terminate 1/3 to 1/2 of the intended use-time, illuminating the master warning light (the amber triangle with internal ‘!’) that was accompanied by either a ‘1’ or ‘2’ encircled by red and may or may not have included the Collision-Avoidance warning light. Subsequent examination of the rectangular shield in the center of the grill very rarely revealed more than 2 bug remnants. When the Smart Cruise Control was in operation it would abruptly apply the brakes when approaching or passing a truck in the lane to taffiche right. There appeared to be no similar conditions to the size or shape of the truck or trailer when these events would occur. None of these events applied to congested tr conditions, just otherwise open road. The ’21 Hyundai Santa Fe does not appear to accommodate any mechanism to revert to conventional cruise control, omitting the influence of the erratic front radar system. Trips to two dealerships have yielded no redress to this malfunction.
Vehicle speed control, Forward collision avoidance, Aug 20, 2021
This vehicle is the first Santa Fe that only comes with adaptive cruise control and there is no way to disable it and set regular cruise control. Here are just a few examples of the safety risk. We were on State Highway 29 which is a rural 4 lane highway. There were 4 cars near us. Our cruise was set for 70mph. A vehicle came in front of us to pass which it did. There was no issue. However, our vehicle saw this as a threat and our vehicle slowed from 70mph to 50mph until the other vehicle was out of the set car length distance. Meanwhile the other cars around us had no indication or warning why we would have slowed down this much and we were nearly rear ended. There was screeching of tires and brakes suddenly applied by the other vehicles. All for nothing. I am on the highway with the cruise set at 75mph when again vehicles will come in front of me and my vehicle slows from 75 mph to 54mph, causing the surrounding vehicles to not know what is going on and I hope they are paying attention because there is nothing really going on other than normal driving. It is terrifying to have your vehicle control itself and you don’t know when it will start to accelerate again so for the most part, I am shutting the cruise control off and on constantly. At our most recent Hyundai service appointment for this problem, we were told by Hyundai Care Manager that this is exactly how it’s designed and there is no problem. And we’ve been told just simply don’t use the cruise control at all. That is not a solution. We feel like all these “safety” features are creating a sense of driver coma on our roads. Instead of the left lane being used for faster cars as a passing lane, the adaptive cruises are creating a chain of vehicles that are well under the speed limit
Forward collision avoidance, Aug 4, 2021
Unnecessary emergency brake activation has occured 3 times. Vehicle lease new 3/31/2021. 1. First incident late April, early May at approximately 1,000 miles. Cruise control was not on and car abruptly stopped when there were no other vehicles in front of mine. Traveling at about 35 miles a hour on local two lane road. (Activation setting on normal) 2. Brakes activated at highway speed of about 60 mph. Car was passing on right side. No threat in front of vehicle. Cruise control was off. (Activation setting on normal) 3. Was following well behind the car in front of me at approximately 30-35 mph. Other vehicle turned right into parking lot and was completely off the road when brake warning appeared on dash. (Activation setting on "late" warning) We are concerned we will be unnecessarily rear ended and causing a multi car accident. Vehicle was in for service 8/2-8/3/2021. Dealer did all they could including 62 mi test drive. Per Hyundai, no parts were replaced due to the inability to dupicate the problem.
Forward collision avoidance, Jul 13, 2021, crash
Message: I own a 2021 Hyundai Santa Fe with the Forward Collision-Avoidance Assist feature installed and activated. The Forward Collision-Avoidance Assist did not function properly to stop my car to avoid a low speed impact. I applied the brakes to stop. I could not avoid impacting another vehicle. The damage was minor. Hyundai did inspect my vehicle braking system on June 8 at Hyundai of Cool Springs. I was not provided full report on findings/corrective action. Hyundai America was supposed to provide a follow up report. I was called today and the Hyundai representative had no details on the brake inspection to share with me. I am suspicious. I think Hyundai is hiding a safety issue. I am reporting this event so the NTSB can contact Hyundai to determine if this is a safety defect needing corrective action. The Hyundai Forward Collision-Avoidance Assist is designed to help detect and monitor the vehicle ahead or help detect a pedestrian or cyclist in the roadway and warn the driver that a collision is imminent with a warning message and an audible warning, and if necessary, apply emergency braking. Ref: Hyundai owner's manual, chapter 7, page 7-2 On page 7-6 the system operation is described: System operation Basic function System warning and control The basic function for Forward Collision- Avoidance Assist is to help warn and control the vehicle depending on the collision level: ‘Collision Warning’, ‘Emergency Braking’ and ‘Stopping vehicle and ending brake control’. OTM070143N Collision Warning • To warn the driver of a collision, the ‘Collision Warning’ warning message will appear on the cluster and an audible warning will sound. • If a vehicle is detected in front, the system will operate when your vehicle speed is between approximately 6~112 mph (10~180 km/h). • If a pedestrian or cyclist is detected in front, the system will operate when your vehicle speed is between approximately 6~53 mph (10~85 k
Forward collision avoidance, May 11, 2021
THE FORWARD COLLISION SYSTEM IS AUTOMATICALLY BEING ACTIVATED WITHOUT ANY CAR OR OBJECT NEAR THE FRONT OF THE VEHICLE. IT HAPPENED 3 TIMES WHILE ON THE FREEWAY AND HIGHWAY. THE SYSTEM AUTOMATICALLY SLAMS ON THE BRAKES, THE VEHICLE SWERVES A LITTLE TO LEFT AND RIGHT DUE TO THE SUDDEN APPLICATION OF THE BRAKES, AND A LARGE RED WARING INDICATOR APPEARS ON THE DASH. WE WERE NEARLY REAR ENDED WHILE TRAVELLING ABOUT 65 MILES/HR BECAUSE OF THIS. WE TURNED OFF THE SYSTEM, BUT EVERY TIME THE CAR IS STARTED, IT AUTOMATICALLY TURNS THIS FEATURE ON!! SO YOU ALWAYS MUST REMEMBER TO TURN IT OFF. WE JUST BOUGHT THE VEHICLE BRAND NEW. IF THIS ISNT FIXED, WE FEAR WE WILL BE REAR ENDED ON THE FREEWAY, OR MAKE TAIL GATERS VERY ANGRY.