2021 Hyundai Santa FE
Problems, recalls and owner-reported issues
Power train is the leading concern among 166 owner complaints filed for this model year. This is the 21st highest complaint count among 25 Santa FE model years with reports.
Of the 2021 reports, 4 involved a crash and 2 involved a fire. 2 people were injured.
What owners report most often
Recalls and investigations
Back over prevention, sensing system, cameraNov 21, 2024
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A rearview image that does not display reduces the driver's visibility and increases the risk of a crash.
Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed January 14, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 271.
Campaign 24V879000 on NHTSA.gov
Trailer hitchesPark outsideMar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Campaign 23V181000 on NHTSA.gov
Power train, automatic transmissionOct 6, 2022
Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.
Loss of drive power increases the risk of a crash.
Dealers will inspect and replace the transmission, as necessary. Dealers will also update the transmission control unit software. All repairs will be performed free of charge. Owner notification letters were mailed January 10, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 236.
Campaign 22V746000 on NHTSA.gov
Visibility, windshieldDec 28, 2021
Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.
A windshield that detaches from a vehicle during a crash can increase the risk of injury.
Dealers will remove and reinstall the front windshield panel, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 216.
Campaign 21V00M000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsJul 9, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.
A fuel leak increases the risk of a fire.
Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 207.
Campaign 21V524000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 3, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles equipped with 2.5-litre Turbo engines. The fuel pipe connecting the high pressure fuel pump to the fuel rail may not have been tightened properly.
An insufficiently tightened fuel pipe may leak fuel, increasing the risk of a fire.
Dealers inspected and tightened the fuel pipe connection, free of charge. The affected vehicles have been repaired and therefore no owner notification letters will be sent. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 206.
Campaign 21V308000 on NHTSA.gov
Air bags, air bag/restraint control moduleMar 17, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles. The Occupant Detection System (ODS) module may not deactivate the air bag upon detection of a child restraint system in the front passenger seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
In the event of a crash, deployment of the front passenger air bag, with a child in that seat, can increase the risk of injury to the child.
Hyundai will notify owners, and dealers will replace the ODS module, free of charge. All affected vehicles have been remedied as of May 12, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 202.
Campaign 21V185000 on NHTSA.gov
Representative owner complaints: fuel/propulsion system
9 reports, newest first. Show all
Fuel/propulsion system, Aug 27, 2026
The door to the gas tank is a push door which is temperamental. I can be at the pump and push the door to pop it open and it won't. I'm at the point where I have to pop my gas tank open before I even get to the gas station because to pull up to the pump and not be able to put gas in the tank is a waste of time. There is no lever to flip along side the driver seat because it is a push to open door.. it is available for inspection, however, it is temperamental. I will video it so I have proof as it works and it doesn't work. It has not been inspected by anyone only because if it is a defect in the motor for the door, I want Hyundai to recall it. I have gone on YouTube to see if there are remedies and yes, there are videos on how to open the door in case you cannot push it open. I cannot do this because I'm not ruining the back of my car as there is no compartment to open as shown in the YT video. I am not one to let my tank get down to less than 1/2 tank, especially not now. But why am I worrying about popping the door open when I'm not even at the gas station yet??
Engine, Fuel/propulsion system, May 11, 2026
My 2021 Hyundai Santa Fe (VIN [XXX] ) is experiencing severe engine instability, including rough idling, hesitation upon acceleration, and intermittent stalling. These symptoms align with TSB 26-FL-001H regarding defective GDI fuel injectors. The vehicle has stalled in traffic, creating an immediate risk of a rear-end collision. Despite being within the 100,000-mile Powertrain Warranty, the manufacturer is refusing to perform the required diagnostic tests (GDS Fuel Pressure Drop Test) to identify the leaking injectors. This failure to diagnose a known fuel system defect poses a significant safety risk to the driver and other motorists. The primary safety risk is unexpected engine stalling while the vehicle is in motion or stopped at intersections. Additionally, the loss of power during acceleration prevents the vehicle from safely merging into high-speed traffic, significantly increasing the likelihood of a collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Fuel/propulsion system, Mar 6, 2026
When I try to open the fuel cover it wont' open. I have to lock and unlock my car, sometimes up to 10 times, to get the fuel fill door to open. This eventually is going to leave me stranded somewhere stranded. Some of my same year and model are covered under recall for this issue by when I call Hyundai my VIN is not covered. I would like it to be covered and repaired.
Other or unspecified, Fuel/propulsion system, Jun 20, 2025
I am writing to formally report an issue with my vehicle that I believe may warrant a recall investigation. The issue involves the fuel door, which is failing to open after the car has been turned off. This has occurred repeatedly and is preventing me from refueling the vehicle, posing a significant inconvenience and potential safety concern. Despite ensuring that the vehicle is unlocked and powered down as instructed, the fuel door remains stuck and will not release. This malfunction requires manual intervention or technical assistance each time I need to access the fuel tank, which is not only frustrating but could also become hazardous in certain situations. I would appreciate it if this matter could be reviewed for possible recall consideration or guidance on next steps. Please let me know if additional documentation, including my VIN or service history, is needed.
Other or unspecified, Engine, Fuel/propulsion system, Mar 8, 2024
While driving and must stop due to traffic light, stop sign or intersection and the auto start is on as soon I lift the foot foot from the brake pedal to continue driving the vehicle stumble and it completely stop the engine while the vehicle transmission is still in drive. In order to start again I have to switch transmission to park and turn key ignition switch to start vehicle, it start again and I can continue. While driving and must stop due to traffic light, stop sign or intersection and the auto start is on as soon as I lift the foot from the brake pedal to continue driving the vehicle stumble and it completely stop the engine while the vehicle transmission is still in drive. When I take the vehicle to the dealership the Service writer writes on the computer but they do not allow me to see a copy of what I am reporting. I like my vehicle, I just want it to be fixed and me and my two daughters be safe when needed after a mandatory stop due to traffic signs, intersection driving through or any other emergency stop and go due tragic and or road condition.
Engine, Fuel/propulsion system, Sep 14, 2023
During low speeds the car stalls out which could cause a safety issue for my family
Power train, Engine, Fuel/propulsion system, Dec 7, 2022
There were two warning (?) "bings" from the instrument cluster and then vehicle completely lost power and would not exceed maybe 2 MPH. Vehicle had forward drive, but no willingness for engine to speed up beyond idle speed. Was like this for several city blocks until I was able to restart at a traffic light and then it resumed normal operation. Did not notice any warning lights and no messages popped up in the instrument or vehicle display. Just the two "bings" before power loss. This is actually the second time this has happened. Last time was while accelerating on a freeway onramp, but vehicle corrected itself more quickly and without need for restart.
Power train, Engine, Fuel/propulsion system, Sep 26, 2022
This SUV has been plagued with issues, and yet after 5-6 visits to the dealership, they don't seem to be able to fix them all. The vehicle (2.5T AWD) currently has around 14k miles and within the past month the gas pedal suddenly became unresponsive, worst of all while carrying my kids and wife in the car. Coming to a dead stop to cross an intersection, went to accelerate to join traffic and the car wouldn't accelerate. Last time on 9/23 when I almost got into a head-on accident while making a left turn as the car barely moved into the first of three incoming lanes, would not accelerate and so forced me to quickly hit reverse, outrageous! Other three times while making a right turn. Auto engine-off has been disabled on all occasions (hate it); two times happened while driving on smart mode, another one on comfort and another one on sport mode. Car has been always using Mobil, Shell or Chevron gasoline. Which also brings me to another point, the vehicle suddenly started consuming crazy amounts of gas, currently at 16mpg for the past 4 full tanks! The vehicle was dropped off at dealership on 9/26/22 and already filed for Lemon Law in FL as this is absolutely unreliable and dangerous to carry my family on. According to manager at Rick Case Hyundai of Davie, an update for the transmission just came out this week after a recall and so they were going to reprogram. I am still getting rid of this p.o.c.
Electrical system, Engine, Fuel/propulsion system, Sep 28, 2021
Car would not start; battery was too low to activate lights or locks, let alone starter. An attempted jumper cable connection to an older car was insufficient to make the motor turn, even after just running the assist car while connected for 20+ minutes. A subsequent jump from the AAA 2000 Ah jump pack did work although their ‘test’ indicated battery state-of-charge and state-of-health to be less than 30%. Their obvious recommendation was battery replacement and, with the vehicle now running, a drive to the dealership was attempted. At the first intersection a full vehicle stop engaged the engine Stop-Start function, but without sufficient battery for the ‘Start’ part. Not only would the vehicle not restart but there was insufficient battery power to put the transmission into PARK nor engage the emergency brake to prevent the vehicle from rolling into busy cross-traffic; only the service brake worked. Fortunately, a nearby motorist recognized the emergency and placed rocks under the tires to prevent the vehicle from rolling forward. The vehicle was towed to the dealership where the battery was replaced without significant comment on the total failure of nearly all systems in the event of battery failure. The outcome of this major battery failure could have been catastrophic as the ONLY system even marginally functional was the non-power-assisted service brake.