2022 Hyundai Santa FE
Problems, recalls and owner-reported issues
Power train is the leading concern among 199 owner complaints filed for this model year. This is the 18th highest complaint count among 25 Santa FE model years with reports.
Of the 2022 reports, 8 involved a crash and 1 involved a fire. 4 people were injured.
What owners report most often
Recalls and investigations
Back over prevention, sensing system, cameraNov 21, 2024
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A rearview image that does not display reduces the driver's visibility and increases the risk of a crash.
Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed January 14, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 271.
Campaign 24V879000 on NHTSA.gov
Trailer hitchesPark outsideMar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Campaign 23V181000 on NHTSA.gov
Power train, automatic transmissionOct 6, 2022
Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.
Loss of drive power increases the risk of a crash.
Dealers will inspect and replace the transmission, as necessary. Dealers will also update the transmission control unit software. All repairs will be performed free of charge. Owner notification letters were mailed January 10, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 236.
Campaign 22V746000 on NHTSA.gov
Engine and engine cooling, engine, gasoline, turbo/superchargerMar 28, 2022
Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe and Santa Cruz vehicles. The oil supply pipe to the turbocharger may crack, which could result in an oil leak in the engine compartment.
An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will replace the turbocharger oil supply pipe, free of charge. Owner notification letters were mailed May 26, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall 222.
Campaign 22V197000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsJul 9, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.
A fuel leak increases the risk of a fire.
Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 207.
Campaign 21V524000 on NHTSA.gov
Representative owner complaints: other or unspecified
45 reports, newest first. Show all
Electrical system, Other or unspecified, Dec 13, 2024
I have a 2022 santa fe xrt within the 1st yr of owing in 2022 the horn stopped working in the winter. Went to dealership told it was known issue they replaced it. A few months later into following year still winter went out again they fixed again stating my car has 2 horns and both failed. So far 2022 and 2023 2 times. Fast forward to earlier in 2024 beginning of year horn failed again took to dealer expressed my concern of this is a safety and inconvenience issue they apologized but no recall yet. Now it's almost 2025 and I will be taking my car back to the dealership this weekend for yet another time due to the horn not working at all. I've found out my horn has not worked due to driving and a vehicle almost colliding into my lane and went to honk horn and nothing. A separate time a person has cut out in front of me almost causing an accident and all I could do is to lock up my breaks and swerve hope they see me and don't get hit could not beep to warn them. I bought the car brand new in 2022 feb and I have had the horn replaced 4 to 5 times and they still are staying no recall this is ridiculous.
Power train, Other or unspecified, Engine, Aug 12, 2024
When you go from drive to park it doesn't go into park. If you try to go to park to reverse it won't go into reverse. Has happened 3 times. Have take it in to dealership and found nothing.
Other or unspecified, Engine, Jul 23, 2024
On November 28 2023, I was pulling onto a small highway when an alarm went off, car stopped (engine off) as other cars were coming towards me. The message displayed was "autostop is off. Shift to P or N and start engine manually". Because the alarm was so loud and I was concerned, I snapped a picture which will be attached. I immediately pushed start button and was able to get out of the way. I had not turned the Idle Start Stop (ISS) button to off - so supposedly it was on. (You have to push this button to turn ISS off. This happened twice until I was able to get to service department. After much time (and using a loaner car) Hyundai agreed to provide a new battery because of its health. This happened again. I took the car back and the manager showed me a technical service bulletin - regarding my car - "Rough Shift and Hesitation Improved Logic". This didn't sound like Idle Start Stop bulletin but I was assured it was (attached). Though the stall has not occurred since, the ISS icon at times just isn't there. My dealer is communicating with Hyundai to try to keep my car again and provide a loaner. I am reporting this because many others on Hyundai Forums are describing the same incidents. Yet I haven't seen anyone mention the Technical Service Bulletin, even though many have taken this problem to their dealer. To me this needs to be considered for a recall. I had a daughter and grand daughter in my car and had no idea what to do with cars approaching. Fortunately, just pushing start worked. I have read the manual and know what is required for ISS to work. All requirements were net. It is possible the TSB has fixed stall issue so I am mainly reporting for other drivers.
Other or unspecified, Apr 30, 2024, crash
Someone ran a red light at low speeds and t-boned my and I flipped over. The damage to the back passenger was minimal that should not have caused my car to flipped which in turn made me sustain multiple injuries including a broken rib for such a minor incident. The safely of this vehicle flipping so easily for such an accident has me very concerned. I have also retained a lawyer for this accident as well.
Power train, Other or unspecified, Feb 18, 2024
3 different times in last 3 weeks the car seems to lose power while I’m driving. It will not go above 35-40mph even though I’m trying to accelerate. No warning messages. I had to go slow with my hazards on until it eventually slowly returns to speed. Very scary on the highway.
Other or unspecified, Electrical system, Oct 31, 2023
The horn is not working. I looked on google and it says that the manufacturer does not know about the problem and other cars are not working.
Other or unspecified, Visibility, Oct 30, 2023
While driving on the freeway yesterday, my sunroof exploded above me. There was no rock or any evidence of anything hitting my car roof to make it explode it just happened out of no where.
Electrical system, Other or unspecified, Engine, Aug 14, 2023
I was driving the vehicle my pregnant wife and 1 year old baby were in the car with me. Car started shaking and i was loosing speed right before getting off the freeway. There was a very strong smell of gas as if it was leaking but it was not. I have an appointment to be checked at the dealership Wednesday August 16th. This is the second time something like this happens while driving in the freeway.
Other or unspecified, Visibility/wiper, Aug 2, 2023
This is the second time my windshield has received a small chip and it spreads to the nearest end of the windshield then within 24 hours spreads across windshield
Other or unspecified, Jul 24, 2023
The rubber seal around the windshield is pulling apart and does not remain in the track. When I am driving greater than 30 miles per hour, the rubber seal comes out and flaps in the wind. Regarding my safety or the safety of others: I believe it exposes the security of the windshield which could become loose, crack or fall out. In addition, when it rains water could seep through and cause electrical issues. April 10, 2023 brought vehicle and showed issue, rubber secured. Advised normal. Issue continued. Brought vehicle to South Shore Hyundai dealer on 29/06/2023 and was advised it was fixed, on my way home the same issue resurfaced. Returned vehicle to dealership on Saturday 22 July 2023 for further analysis. Currently awaiting outcome of analysis from certified technician. I am seeking your help to investigate this issue of the broken seal, as I am concerned that maybe my vehicle may not be an isolated case and may require you to contact Hyundai America to investigate and resolve the problem.
Other or unspecified, Jul 19, 2023
While driving on highway on July 17, 2023, 2022 Sante Fe with less than 12,000 miles driven , suddenly lost power, RPM racing back and forth, and would not exceed 40 mph despite gas peddle to floor. Eventually was able to reach 60 mph, until reaching a slight incline where it dropped to 40 mph. I was seriously concerned I was going to cause an accident with several large trucks being forced to rapidly slow down behind me as lft lane was occupied by other vehicles. This is the second such incident. In October 2022, less than I month after I purchased vehicle new from dealership, vehicle suddenly lost power climbing a hill on a two-lane hiway with multiple vehicles not far behind me. I was terrified for fear of being hit from behind as this highway is curvy, heavily traveled, and bordered on one side with drops between 75-100 feet to the river below. The vehicle slowed to 30 mph despite trying to downshift/upshift pressing accelerator. There was no room to pull off road so I continued at 30 mph, trailing numerous vehicles until reaching top of hill where vehicle seemed to recover. Since I only owned vehicle for a few weeks I thought it was something I had done until I received a recall notice. Second incident above ocurred after vehicle had been serviced for recall.
Vehicle speed control, Other or unspecified, Engine, Jul 17, 2023
I had previously filed a complaint and received an issue number 11494975 I have not been able to retrieve any information related to this number. In any event I am constantly having problems with acceleration, stalling, the car puts itself in Neutral, and on occasion has completely turned itself off at a light or while driving. I do have a video of the acceleration problem and revived an email back from Laura Nelson. This is a very serious safety issue. Hyundai is not responding to following up. I also took it to an outside mechanic to put in the computer and got a general code so there is a problem somewhere. Thank you Susan Piller
Other or unspecified, Jun 2, 2023
Took the vehicle in for a recall of the trailer tow hitch and was told it would be fixed free of charge. I also got an oil change. Once the work was complete, I was informed that they are unable to fix it and there is no remedy available currently. The consultant told me that the vehicle is at risk of catching on fire while driving and/or parked so I should not park it in my garage. I now have a vehicle that can catch on fire at anytime which is dangerous for myself, any passengers and anyone in the vicinity of the car when it is parked. There is no warning light that came on in the car notifying me of the recall problem and I fear there will also be no warning light when/if it catches on fire. There is not estimated time that a remedy will be available and I believe this to be unacceptable.
Other or unspecified, Engine, Apr 10, 2023
On Friday the 7th of April while driving about 40 miles/hr my car lost power in traffic. I pushed gas pedal all way to floor to no avail. Then I was able to get it to move at about 20m/hr for short distance and it cut out and engine lite on as well as a horrible smell like something was burning. It had to be towed into dealer.
Electrical system, Other or unspecified, Engine, Nov 26, 2022
My car has stalled and shut down and locked up completely while I was driving the vehicle for the 4 th time Thanksgiving Day. I was petrified! I called service at the dealership and they wanted to charge me. The car isn’t even a year old! What is Hyundai going to do about this?
Other or unspecified, Nov 13, 2022
When I was driving the moonroof exploded without any incident and we didn’t have any car near us.
Power train, Vehicle speed control, Other or unspecified, Oct 23, 2022
3rd and worse instance where had loss of power. While trying to accelerate onto the highway my vehicle would not do over 30mph (highway is 60mph zone). No lights illuminated on dash that there was any issue. Impeded traffic until I could pull over. This was VERY dangerous, I was lucky to not be rearended while trying to merge on highway. Dealer has had my vehicle for a week not being able to reproduce event. No codes in computer and unable to locate any recalls.
Other or unspecified, Aug 14, 2022
I was traveling along with no other traffic near me. All of a sudden I heard what sounded like a gun going off. I was traveling approximately 50 MPH. My New Santa Fe is less than 2 months old with 1700 miles on it. When I reached my destination about 20 miles further I got out and looked at the roof. The glass "eye brow" that sits in front of the moon roof was shattered. I am positive that nothing hit it as I was not among trees nor were there any other vehicles near me. I feel that this is a safety issue in that the mere noise of the explosion could have been so distracting that is could cause a major accident.
Visibility, Other or unspecified, Nov 1, 2021
We purchased my 2022 Hyundai Sante Fe in July of 2021. I had about 5000 miles on the vehicle at the time. On October 15th I was driving down a 2 lane road and heard a pop, I didn't think much of it, thought it might have been an acorn that fell on my roof as the area I live in is very treesy. Later that evening when we got back in the car to leave, we noticed the windshield was cracked, probably about a six inch area. I told my husband earlier that day I heard the popping noise but did not see anything actually fly up and hit the windshield. So we proceeded to call the insurance company who told us the entire windshield would need to be replaced. We were responsible for our $500 deductible. The repair shop contacted every Hyundai dealership in the southeast region only to find out the windshields were on backorder until Oct. 31st. (red flag) In the meantime the crack has spread all the way across the windshield. We found it odd that windshields would be on backorder so we googled "Hyundai Sante Fe cracked windshields" and we were floored at the amount of stories out there with the same exact problem, not only with the Sante Fe but other Hyundai SUV models as well. I just wanted to bring this to your attention because I feel the windshields are defective and unsafe. I don't know how many people this has to happen to before Hyundai acknowledges the issue. Even if it were an acorn that fell, it should not have done the damage that it did. I still feel it was spontaneous as I did not see anything actually hit or bounce off the windshield. So here we are still waiting on the windshield to arrive at the repair shop and out $500.
Other or unspecified, Sep 1, 2021
When using WAZE via wireless car play, the connection would be disconnected and prompted me to use cable. Haven't use cable yet so not sure if cable will work.