2022 Hyundai Santa FE
Problems, recalls and owner-reported issues
Power train is the leading concern among 199 owner complaints filed for this model year. This is the 18th highest complaint count among 25 Santa FE model years with reports.
Of the 2022 reports, 8 involved a crash and 1 involved a fire. 4 people were injured.
What owners report most often
Recalls and investigations
Back over prevention, sensing system, cameraNov 21, 2024
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A rearview image that does not display reduces the driver's visibility and increases the risk of a crash.
Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed January 14, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 271.
Campaign 24V879000 on NHTSA.gov
Trailer hitchesPark outsideMar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Campaign 23V181000 on NHTSA.gov
Power train, automatic transmissionOct 6, 2022
Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.
Loss of drive power increases the risk of a crash.
Dealers will inspect and replace the transmission, as necessary. Dealers will also update the transmission control unit software. All repairs will be performed free of charge. Owner notification letters were mailed January 10, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 236.
Campaign 22V746000 on NHTSA.gov
Engine and engine cooling, engine, gasoline, turbo/superchargerMar 28, 2022
Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe and Santa Cruz vehicles. The oil supply pipe to the turbocharger may crack, which could result in an oil leak in the engine compartment.
An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will replace the turbocharger oil supply pipe, free of charge. Owner notification letters were mailed May 26, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall 222.
Campaign 22V197000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsJul 9, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.
A fuel leak increases the risk of a fire.
Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 207.
Campaign 21V524000 on NHTSA.gov
Representative owner complaints
199 reports, newest first.
Electrical system, Engine, Fuel/propulsion system, Apr 26, 2026
Fuel injector failed the entire engine on my 2022 Santa Fe had to be completely replaced. The dealership put in a new engine. Santa Fe is only four years old. That is highly unusual.
Lane departure, Back over prevention, Apr 23, 2026
Rearview camera has failed with a green screen instead of the camera view. This recall was covered by recall 24V87900 (Hyundai recall 271) for 2022 Santa Fe but my 2022 Santa Fe is not covered by this recall.
Other or unspecified, Apr 16, 2026
The fuel tank opener has become increasingly hard to operate. The fuel tank is supposed to unlock when the doors are unlocked. Sometimes it takes 10 or more times of unlocking the doors and checking the fuel door to successfully open the fuel door.
Other or unspecified, Apr 13, 2026
Vulnerable exposed radiator to road debris from the front and underneath my 2022 Santa Fe. It seems that this is an issue that is not covered by warranty and owners are held responsible with filing an insurance claim or pay out of pocket. Manufacturer needs to provide some type of protection for radiator or lose repeat customers.
Fuel system, Gasoline, Visibility, Mar 30, 2026
The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving approximately 50 MPH, the glass panoramic sunroof suddenly exploded, causing glass shards to fall into the cabin of the vehicle. No injuries were reported. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The contact stated that there was no impact on the panoramic sunroof glass to cause the failure. The vehicle was not yet repaired. Additionally, while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle only operated in LIMP Mode. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the fuel injector was inoperable and needed to be replaced. The fuel injectors were replaced, and the vehicle was repaired. The failure mileage was 55,000.
Power train, Mar 17, 2026
1. Component/System: 2022 Hyundai Santa Fe 8-speed dual-clutch transmission (DCT), specifically the transmission oil pump or hydraulic pressure system. Inspection availability: The vehicle is currently at McGrath City Hyundai in Chicago and can be made available for inspection upon request. 2. The transmission exhibited slipping gears, delayed gear engagement, loud mechanical noise, and a transmission warning light. These conditions create the risk of sudden loss of drive power, unexpected stalling, or inability to control the vehicle, which could cause accidents, collisions, or injury to the driver, passengers, or others on the road. 3. A technician at McGrath City Hyundai initially informed us that the transmission oil pump had failed, which aligns with the symptoms. Later, another dealership representative claimed there was no issue, and the fluid was simply low. No written diagnostic confirmation or independent verification has been provided to date. 4. Hyundai corporate has been contacted and opened a case, but they refused to provide documentation or details of any inspection or repair, and did not assign a supervisor to provide clarification. No police, insurance, or third-party inspections have been performed. 5. Symptoms first appeared on March 9, 2026, including: Transmission warning light; Delayed gear engagement; Slipping gears; Loud mechanical noise from the transmission
Power train, Mar 17, 2026
While driving at normal roadway speeds, the vehicle experienced a sudden and unexpected loss of power during acceleration. The engine remained running, but the vehicle failed to respond appropriately to throttle input, resulting in a significant reduction in forward movement. This created a dangerous situation, particularly in traffic conditions where consistent acceleration is required. The issue appears to be related to the transmission or powertrain system, though the exact component failure is UNKNOWN at this time. This condition poses a serious safety risk, as loss of power while driving can increase the likelihood of rear-end collisions or inability to safely merge or clear intersections. The vehicle has been inspected by an authorized dealership; however, they were unable to reproduce the issue during testing and therefore did not perform a repair. Despite this, video evidence of the incident exists and clearly shows the loss of power event. There were no warning lights or messages prior to or during the incident. The failure occurred unexpectedly during normal operation. The problem has not been resolved and may occur intermittently, making it difficult to reproduce under standard inspection conditions. The vehicle remains in service and available for inspection upon request.
Power train, Mar 16, 2026
1. The transmission warning symptoms first appeared on March 9, including a transmission warning light, delayed gear engagement, slipping gears, and loud mechanical noise. 2.5-liter turbo engine use an 8-speed dual-clutch transmission (DCT). It has been in McGrath City Hyundai since March 10 for inspecton. 2. We were not harmed, but were very concerned about the safety of the car. 3. We only tried and waiting for this dealer for a ddiagnosis, but they verbally gave 2 conflicting diagnoses today. No written diagnosis report, no repair report. 4. This morning (9am), a staff informed us by phone that the vehicle has a failed transmission oil pump and that the dealership was waiting for approval for the replacement part. However, during a later call (1pm) today, another staff member stated that there is no issue for the transmission oil pump, and that the transmission fluid was simply lower than normal, with no leaks. We were told to pick up the vehicle today. We refused and waiting for them to email us a diagnosis report and a repair report. 5. The transmission warning symptoms first appeared on March 9, including a transmission warning light, delayed gear engagement, slipping gears, and loud mechanical noise. This conflicting information is extremely concerning, especially given the transmission symptoms described above. Hyundai issued Safety Recall #236 specifically for 2021–2022 Santa Fe vehicles due to the high-pressure electric oil pump in the 8-speed Dual-Clutch Transmission (DCT) potentially malfunctioning, causing a complete loss of drive power. And there is an active class action about it too.
Visibility/wiper, Mar 12, 2026
The panoramic sunroof of a 2022 Hyundai Santa Fe Hybrid Limited spontaneously shattered while in transit on the highway. A resoundingly explosive “bang” preceded large shards of falling glass — leaving a massive hole in the sunroof’s front panel. The incident seemingly occurred without direct contact of any kind…no flying debris, no overpass roads, no inclement weather.
Fuel/propulsion system, Feb 16, 2026
In November 2025, my 2022 Hyundai Santa Fe began to hesitate when accelerating and would almost "jerk" when I pressed the gas pedal. Soon after my check engine light came on and I made an appt to take it for the closest Hyundai dealership (as it's still under warranty 33k miles) Upon running a check the dealership notified me that Fuel Injector 1 has misfired and will be replaced. I receive my vehicle back and not even 100 miles later my check engine light in on again and the same issues are arising. Back to the dealership to see now Fuel Injector 3 has misfired and there is an open TSB showing all 4 Fuel Injectors need replaced. My vehicle was finally returned to me in January 2026. It is now February 16, 2026 and my check engine light in on YET AGAIN. I've been given the run around from Hyundai Corp about fixing this vehicle. Why is this acceptable treatment when a vehicle is under warranty ?
Other or unspecified, Feb 12, 2026
On my vehicle I’ve had to have the horn replaced at least three times. Paying about $500 for the last two instances. While there is no formal federal recall for the 2022 Hyundai Santa Fe horn specifically, it is affected by a widespread, known issue where water intrusion corrodes the horn's electrical contacts, leading to failure. Hyundai has addressed this with an extended warranty or service campaign in some regions to replace the horn. Saying this my vin # is not included in this but I can’t understand why.
Other or unspecified, Visibility/wiper, Feb 3, 2026
My Windshield is the problem. My granddaughter drives with me often and afraid the glass will shatter. Yes, the corporate office for Hyundai. No, this was done while driving, all occasions.
Other or unspecified, Jan 30, 2026
The car was purchased new on June 30, 2021. On January 25, 2024 at 38,347 miles the horns failed to work and were replaced under warranty. About a week ago (c. January 24,2026) the horns again failed. The dealer was called and I was told that there was no recall on the horns and I would have to pay around $91 for the horns plus labor. The service manager told me that this is a common problem that has to do with where the horns are mounted on the vehicle. They are behind the front bumper and exposed to the elements. I feel that this is a serious design flaw and a safety issue that should be addressed by the manufacturer. There should be a recall instead of customers buying new horns every two years. Had the horns failure occurred during an emergency situation it could have resulted in an accident and possible loss of life.
Electrical system, Engine, Jan 28, 2026
Took my 22 Sante fe to the Hyundai dealership to have the blower motor checked since I have no air flow in my car. Dealership informed me that the engine harness needs replaced and that it melted the fuse box under the hood. So, I am not able to replace my blower motor at this time due to the melted fuse box. Dealership also advised that they have seen the same problem in multiple 22 Sante Fe. and that there is likely more with the same issue within the United States. I have been noticing a melting/hot smell in the car before the airflow quit and I took it to the dealership to be diagnosed.
Air bags, Jan 23, 2026
The air bags sensor is on which means none of the air bags will deploy if I am in an accident. The dealership stated it is not covered by the warranty. The sensors were not tampered with but the sensor is not working
Other or unspecified, Jan 9, 2026
My horn has been having problems on and off for the last year. It’s a 22 Hyundai Santa Fe. It is currently not working. Which is a safety hazard?
Other or unspecified, Dec 28, 2025
THE CARS HORN HAS BEEN REPLACED 3 TIMES IN THE LAST 3 YEARS AND IT STOPPED WORKING AGAIN.THE HORN LAST ABOUT 1 YEAR, THIS IS 2022 SANTA FE,
Electrical system, Other or unspecified, Engine, Dec 23, 2025
Engine control harness with under fuse box due to melted fuse box. This caused my blower motor and relay to go bad. No air flow currently in car due to control harness. Dealership stated that there has been several Sante Fe that has came in this year with the same issue.
Other or unspecified, Dec 22, 2025
I HAVE HAD THE HORN IN MY 2022 SANTA FE REPLACED 3 TIMES OVER THE COURSE OF 3 YEARS, and now it doesn't work again. I realized the newest horn is not working when a truck almost backed into me yesterday and I had no way to warn them to stop backing up.
Power train, Dec 18, 2025
The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving approximately 20 MPH, the vehicle failed to properly accelerate, as if the transmission was stuck in high gear. The vehicle was taken to an independent mechanic, where it was diagnosed with transmission failure. The contact believed that the failure was associated with Manufacturer Recall: 236. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 98,300.
Power train, Electrical system, Dec 18, 2025
The contact owns a 2022 Hyundai Santa Fe. The contact stated that intermittently, the gear shifter was inoperable, and the message "Gear Shift Malfunction" was displayed. The contact stated that the failure required that the vehicle be turned, which automatically engaged the parking brake. The contact stated that upon pressing the Start button, and then depressing the brake pedal, the contact was able to move the gear shifter to park(P) and to the other gears. The vehicle was taken to the dealer, where it was diagnosed that the wiring was open between the transaxle, the rain switch, and the shift control unit. The dealer replaced the wiring. Upon test-driving the vehicle, the dealer noticed that the vehicle was still experiencing abnormal vibrations. The dealer recommended that the transmission be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 98,000.
Fuel/propulsion system, Dec 11, 2025
The fuel injectors have repeatedly failed. I am on my third replacement
Service brakes, Forward collision avoidance, Dec 8, 2025, crash
Vehicle purchased 9/1/24 from Courtesy Hyundai of Tampa. Dealership failed to file registration/tags until 10/4/24. 7/12/25: Vehicle experienced involuntary acceleration and braking, resulting in impact with my mother’s home. 7/16/25: Dealer issued written report stating vehicle was operating normally and documented a recall-related display/audio/camera software update. 8/14/25: Hyundai engineering inspection performed without my knowledge. No report has ever been released. 8/27/25: Hyundai issued corporate denial, blaming driver error and stating braking/acceleration systems were normal. 12/5/25: Second involuntary braking incident at highway speed on I-275. Five uncommanded braking events over ~20 miles. Service Manager stated failure was due to sensor/camera malfunction and instructed that the vehicle should not be driven and to tow immediately. Despite this, the vehicle had been released into roadway operation. VIN lookup shows an open, unrepaired federal recall (24V879000 / Recall 271) for the rearview camera system, marked Recall Incomplete, despite the dealer’s documentation that recall-related camera/software work was completed on 7/16/25. BBB Auto Line denied my claim only because the vehicle was outside Florida Lemon Law eligibility. No safety determination was made. Hyundai released no engineering, sensor, or camera data despite an engineering inspection. This vehicle has experienced repeated involuntary braking and acceleration at highway speed, involving braking, camera, and automatic emergency braking systems, creating a serious risk of loss of control, collision, injury, or death. Despite repeated failures, contradictory diagnostics, withheld engineering data, and an open federal recall, the vehicle was released back into public roadway operation. I request that NHTSA formally investigate this safety defect.
Forward collision avoidance, Dec 3, 2025
The vehicle has activated it emergency breaking feature several times now on the last couple of months witouth any reason to do so. Presenting a major risk for the occupants and to other vehicles on the roads.
Wheels, Service brakes, Engine, Dec 1, 2025
Ever since I bought by car in 2022 brand new the car has been shaking when I press on the brakes going around 70 mph. I took the car multiple times to the dealership and all they do is resurface the rotos. One time they refused to even look at the car so I called corporate and they got the dealership to do the same thing as before. But still the car shakes. I called corporate and they said to take to dealership to once again get the rotos resurfaced (how many times are they planning to resurface the damn rotors?) I took to dealership because the car was saying it was overheating. They ended up changing the thermostat or something related to it. And I asked them to once again look at the rotors because of the issue. The guy came back and said “we didn’t look at your rotors but you need brakes and that’s $500”. They refused to guarantee me if doing the break job will fix my issue. And I’m fed up. I looked online and as it turns out, the Santa Fe’s have a lot of possible manufacture defects. Such as: -Breaking System (Shudder / Vibration Common Issue) -Cooling System (Common Failures) - Suspension & Steering Components -AWD / Drivetrain (If AWD) -Electronics & Software - TSB (Technical Service Bulletin) Audit - Turbo oil-supply pipe crack / oil leak risk -Fuel-system pipe / fuel-rail hose leak (on certain turbo models -Transmission oil-pump / transmission-system recall (power-train issues) -Rear-view / backup-camera defect (visibility / electronics issue) (this actually did happen to me and they fixed it, but they denied it was a recall when I asked if this was common. So they lied) -Trailer-hitch wiring harness fire-risk recall And possibly more issues I’ve yet to come across other owners having. These are pretty serious issues. Some causing even the car to catch fire. This is extremely worrisome and I need peace of mind. Please help me out Thank you for your time