2023 Hyundai Santa FE
Problems, recalls and owner-reported issues
Power train is the leading concern among 210 owner complaints filed for this model year. This is the 15th highest complaint count among 25 Santa FE model years with reports.
Of the 2023 reports, 11 involved a crash and 3 involved a fire. 15 people were injured.
What owners report most often
Recalls and investigations
Trailer hitchesPark outsideMar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Campaign 23V181000 on NHTSA.gov
Representative owner complaints: engine
37 reports, newest first. Show all
Engine, Sep 4, 2024
Driving at a low speed and blind spot warning light comes on, then all warnings light up and car loses all power and goes into limp mode. Engine light stays on, but will start back up after it is shut off, open and shut car door and restart. Engine light stays on. Has happened to me three or four times. In the past, the engine light will eventually go off before I can get it to the dealership. Hyundai said they couldn’t duplicate the problem last time it was taken in, so nothing could be done. Gives error code P063512 each time and says EMS which I assume means emissions.
Electrical system, Wheels, Engine, Jul 21, 2024
Driving up steep hill to my mom’s house car would not drive up, as it hesitated I pressed gas pedal to no avail. I turned off car, got out & nothing was blocking me. Turned car back on & accelerated, this time it went forward.
Power train, Engine, Fuel/propulsion system, Jul 6, 2024
There is an extreme amount of hesitation/delay from when you depress the accelerator and when the vehicle accelerates. I have had multiple incidences (both from a complete stop and while already moving) where I depress the accelerator and there is a concerning amount of lag time before the vehicle initiates movement. This has almost led to multiple accidents. This defect happens in all drive modes. This issue appears to have gotten worse over the time we have owned the vehicle. We did not notice this issue earlier on. We bought the vehicle brand new in Dec. 23.
Power train, Engine, Fuel/propulsion system, Jun 24, 2024
Several times lately of extended crank. Saturday evening, car had been parked for 4 hours, did remote start and had extended crank of about 2 seconds. Car ran for about 3 minutes before we left. We left home and hit main road, tried to accelerate and vehicle seemed to go into limp mode. Would keep cutting the fuel out if tried to accelerate even above 40 mph. No check engine light came on. Put in neutral, could not get above about 3500 rpm. Vehicle was in smart mode where decides which mode to be in (normal, fuel economy or sport), when would try to accelerate it would try to change to sport as it knew power was not there. Was on a 6 lane highway and could not get up to speed. Finally was able to pull to side of road, shut engine off, waited a few seconds, restarted and issue went away, still no check engine light. I have contacted my local dealer, they said they have seen on another vehicle, was not sure of outcome, having service manager call me. Lots of complaints online forums of similar issues.
Engine and engine cooling, Structure, May 7, 2024
The contact owns a 2023 Hyundai Santa Fe. The contact stated that the vehicle was overheating while driving. Additionally, the contact stated that upon noticing that coolant was leaking onto the ground, he opened the hood and discovered that coolant was leaking from the radiator. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that a foreign object had struck the radiator, causing coolant to leak into the engine compartment. The dealer informed the contact that a failure caused by a foreign object was not covered under warranty. The vehicle was not repaired. The contact stated that upon examining pictures of the failure provided by the dealer, he noticed that there were rocks stuck in and near the radiator. The contact determined that the large gaps of the front grill were allowing foreign objects to strike the radiator. The manufacturer was notified of the failure and a case was opened; however, the case was later closed. The failure mileage was approximately 11,591.
Engine, Feb 29, 2024
The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving on three occasions, at approximately 60 MPH, the cruise control was engaged, and the contact attempted to accelerate using the toggle and the vehicle accelerated to over 110 MPH. The brake pedal was depressed, and the cruise control was deactivated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 140.
Power train, Vehicle speed control, Engine, Feb 26, 2024
The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving 50-65 MPH, the vehicle stalled and decelerated to a complete stop with several unknown warning lights flashing on the instrument panel. The vehicle was restarted and operated normally. The contact drove the vehicle to the dealer where several fault codes were reset. The contact continued to experience the failure and returned to the dealer where the dealer replaced the throttle assembly and later replaced a front camera with a hard code. However, the contact stated the failure persisted. The vehicle was with the dealer but was not repaired. The manufacturer was also notified of the failure and provided the contact with a case number and a case manager to assist with the failure. The approximate failure mileage was 1,700.
Power train, Engine, Feb 2, 2024
While merging into the highway at approximately 49 to 52 mph, acceleration was applied to merge into the highway between moving vehicles. The vehicle responded by greatly increasing the rpm but not applying the power to the wheels. The engine revved up with very little acceleration. After 5 to 8 seconds, the power was finally transferred to the wheels and the vehicle sped up. The vehicle behind me had to apply the brakes since I basically cut them off. This was the second incident of this type.
Engine, Jan 1, 2024
Throttle randomly cuts off or hesitates. It has done it about 15 times Dealer says no problem found. There is a lot of reports on the internet of the same problem.
Engine, Engine and engine cooling, Oct 16, 2023
The contact owns a 2023 Hyundai Santa Fe. The contact stated that on two separate occasions while driving at approximately 65 MPH, the vehicle decelerated. The check engine warning light illuminated, and a message displayed on the infotainment screen indicating “Engine System Emergency, Take Vehicle to the Nearest Dealer”. The contact was able to veer the vehicle into a parking lot where it was idled. The vehicle was then taken to the dealer where the contact was informed that no appointments were available; however, the technician used a code reader that retrieved message: “5 Volts drop to the ECM”. The contact stated that the technician then pressed the START/STOP button to restart the vehicle and reset the check engine warning light. The contact stated that he was able to drive the vehicle back to his location where he parked the vehicle. The following day he restarted the vehicle however, the failure recurred. The dealer was notified of the failure and the contact was advised that if the check engine warning light was not illuminated there was no need to have the vehicle diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure, but no further assistance was provided. The failure mileage was approximately 1,108.
Steering, Electrical system, Engine, Aug 11, 2023
May 5th 2023 my car was broken in to.The back passenger window was broken out and the steering column was tour out .The car was undrivable. The car was towed May 18th to Nalley Hyundai.I just got my car back today Aug 11. I understand Hyundai is suing TikTok I was given a number.She said when they go to court.When .
Steering, Electrical system, Engine, Jul 19, 2023
Driving at 25 mph and the vehicle alerted "shift to neutral" and came to a complete stop and stalled. Had no warning, couldn't even pull to side of road. Could not start again and had to be towed.