2000 Hyundai Sonata
Problems, recalls and owner-reported issues
Structure is the leading concern among 278 owner complaints filed for this model year. This is the 15th highest complaint count among 26 Sonata model years with reports.
Of the 2000 reports, 20 involved a crash and 9 involved a fire. 15 people were injured.
What owners report most often
Recalls and investigations
SuspensionApr 16, 2009
HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUB-FRAME ON THE VEHICLES, AND MAY RESULT IN THINNING OR PERFORATION OF THE SUB-FRAME STEEL. THE CORROSION IS FREQUENTLY VISIBLE AND OFTEN DISCOVERED DURING INSPECTION OR ROUTINE MAINTENANCE, AND OWNERS MAY ALSO HEAR NOISES OR NOTICE TIRE MISALIGNMENT AND STEERING PULL. IF THESE SIGNALS ARE UNDETECTED OR UNHEEDED, THE CORROSION MAY PROGRESS AND THE FORWARD MOUNTING OF THE LOWER CONTROL ARM MAY DETACH FROM THE SUB-FRAME.
IF THAT HAPPENS, THE VEHICLE MAY LOSE DRIVE POWER TO THE WHEELS, AND THE FRONT WHEEL MAY MAKE CONTACT WITH THE FENDER OR WHEEL WELL, THEREBY INCREASING THE RISK OF A CRASH.
DEALERS WILL MEASURE THE THICKNESS OF THE FRONT SUB-FRAME AND INSPECT THE FRONT SUB-FRAME FOR CORROSION DAMAGE AND, IF NECESSARY, THE FRONT SUB-FRAME WILL BE REPLACED WITH A NEW SUB-FRAME THAT INCORPORATES ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT SUB-FRAME DOES NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE SUB-FRAME AND WILL TREAT THE SUB-FRAME WITH RUST-PROOFING MATERIAL TO STOP THE CORROSION PROCESS. THIS PROCEDURE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 09V124000 on NHTSA.gov
Air bags, side/windowApr 9, 2002
ON CERTAIN PASSENGER VEHICLES, AN INTERMITTENT CONDITION THAT LEADS TO THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT ILLUMINATION COULD RESULT FROM MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR WHICH MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE SIDE IMPACT AIR BAGS AND COULD PREVENT AIR BAG DEPLOYMENT DURING A CRASH WHERE SUCH DEPLOYMENT SHOULD OCCUR.
NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAG COULD INCREASE THE RISK OF INJURY DURING A SIDE IMPACT CRASH.
DEALERS WILL MORE SECURELY FASTEN THE SIDE IMPACT AIR BAG WIRING HARNESSES AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION BEGAN MAY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 02V105000 on NHTSA.gov
Air bagsNov 6, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT COULD ILLUMINATE DUE TO MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR THAT MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE DRIVER AND/OR PASSENGER SEAT-MOUNTED SIDE IMPACT AIR BAG(S).
THIS CONDITION COULD PREVENT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT DURING AN ACCIDENT WHERE SUCH DEPLOYMENT SHOULD OCCUR. NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAGS COULD INCREASE THE RISK OF INJURY DURING AN ACCIDENT WHERE SIDE IMPACT AIR BAG DEPLOYMENT IS INTENDED.
DEALERS WILL MORE SECURELY FASTEN THE FRONT SEAT SIDE IMPACT AIR BAG WIRING HARNESS AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION WILL OCCUR IN SIX MAILINGS ON MAY 27, JUNE 3, JUNE 10, JUNE 17, JUNE 24, AND JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 01V347000 on NHTSA.gov
Electrical system, wiringSep 11, 2000
VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS.
THIS CONDITION CAN CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH.
DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS.
Campaign 00V259001 on NHTSA.gov
Representative owner complaints
278 reports, newest first.
Engine and engine cooling, Structure, Dec 19, 2007
TL*THE CONTACT'S DAUGHTER OWNS A 2000 HYUNDAI SONATA. WHILE THE CONTACT'S DAUGHTER WAS PULLING INTO THE DRIVEWAY, THE PASSENGER SIDE FRONT WHEEL DETACHED FROM THE VEHICLE. THE CONTACT STATED THAT THE ENGINE CRADLE RUSTED OUT WHERE THE TWO BOLTS WERE ATTACHED TO THE SUBFRAME. THE VEHICLE WAS INSPECTED BY A MECHANIC AND HE CONFIRMED THE FAILURE. THE SPEED WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 143,000. UPDATED 01/23/08 *LJ. UPDATED
Structure, Oct 10, 2007
NOTICED AT LAST OIL CHANGE, POTENTIAL STRUCTURAL FAILURE OF FRONT SUB FRAME/ENGINE CRADLE DUE TO RUST OUT CAUSED BY DESIGN THAT ALLOWS WATER TO ENTER AND BE TRAPPED IN SUB FRAME. CARS IN "SNOW BELT" AREAS (OHIO) ARE AFFECTED BY ROAD SALT. SUB FRAME HAS 2.5" RUST HOLE AND SURROUNDING AREA SHOWS FATIGUE AND CRACKING. CAR APPEARS TO BE ONE "CHUCK HOLE" AWAY FROM FAILURE. *TR
Suspension, Structure, Sep 30, 2007
WHILE DRIVING STRAIGHT DOWN A NEWLY PAVED ACCESS ROAD AT APPROXIMATELY 20MPH, THE CONTROL ARM BROKE FREE OF MY ROTTED/RUSTED OUT SUBFRAME. I HAVE RECENTLY HAD THE CAR IN FOR AN ALIGNMENT, AND BRAKE WORK AND NO PROBLEM WAS DETECTED WITH THE RUSTED SUBFRAME. THE CAR IMMEDIATELY SEIZED UP AS THE WHEEL SLAMMED INTO THE WHEEL HOUSING AND THE CAR CAME TO AN IMMEDIATE STOP AND WAS IMMOBILIZED. THE CAR IS NOW IN THE SHOP AND I AM CONTACTING HYUNDAI DIRECTLY REGARDING THE UNLIKELY FACT THAT MANY DRIVERS ARE EXPERIENCING THIS VERY DANGEROUS PROBLEM. I SUSPECT THAT THIS PROBLEM WILL BE INCREASING DRAMATICALLY IN THE NEAR FUTURE AS THE HYUNDAI SONATA'S 1999-2001 CONTINUE TO AGE. I HAVE NOTED AT LEAST A DOZEN INSTANCES OF COMPLAINTS REGARDING THIS ISSUE ONLINE AND ALMOST ALL INSTANCES APPEAR TO BE VERY DANGEROUS. *TR
Seats, Sep 27, 2007
TL*THE CONTACT OWNS A 2000 HYUNDAI SONATA. WHILE APPROACHING A STOP AT 10 MPH, THE DRIVER SEAT SLID. THE DEALER STATED THAT THE SEAT ROLLERS FAILED. THE SEAT HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 86,000.
Structure, Sep 12, 2007
I HAVE A 2000 HYUNDAI SONATA WHICH I PURCHASED USED IN 2003 FROM KOEPPEL HYUNDA IDEALER IN LONG ISLAND CITY NEW YORK. I HAVE NOT HAD ANY MAJOR PROBLEMS WITH THE CAR AT ALL. THIS WEEK I BEGAN TO NOTICE SOMETHING NOT FEELING RIGHT IN THE FRONT END, SO I BROUGHT IT TO MY MECHANIC. HE SAID THE STRUTS NEEDED TO BE REPLACED, BUT THAT I HAVE A BIGGER PROBLEM THAN THAT. IT SEEMS THAT THE ENTIRE SUBFRAME OF THE CAR IS RUSTED AND ROTTING AWAY. HE TRIED TO LOCATE A USED FRAME FROM A JUNKYARD,(BECAUSE THIS IS NOT COVERED BY THE WARRENTY), BUT WAS UNABLE TO GET ONE. EACH PERSON HE SPOKE TO AT VARIOUS JUNK YARDS KNEW EXACTLY WHAT HE NEEDED , BUT INFORMED HIM THAT A USED SUBFRAME FOR THE SONATA WAS IMPOSSIBLE TO COME BY BECAUSE ON ALL THE SONATAS THAT WERE JUNKED, THE SUBFRAMES WERE ROTTED THROUGH FROM RUST. I'M BETTING THAT SOME OF THESE CARS WERE JUNKED FOR THAT VERY REASON. APPARENTLY THERE'S A PROBLEM HERE, BUT HYUNDAI IS UNWILLING TO ACKNOWLEDGE IT. WHEN I CALL THEY TELL ME THEY'VE NEVER HEARD OF THIS PROBLEM BEFORE. HARD TO BELIEVE. I WAS TOLD A NEW FRAME WOULD COST ME1300 DOLLARS. THE ONLY THING THE MECHANIC CAN OFFER TO DO FOR ME IS TO WELD STEEL TO THE PARTS OF THE FRAME THAT ARE STILL SOLID AND TRY TO REINFORCE THE FRAME. AT THIS POINT I AM VERY FRUSTRATED, BECAUSE I WORK AT NIGHT AND NEED A CAR TO GET BACK AND FORTH. I HAVE BEEN PAYING FOR A RENTAL FOR THE PAST 3 DAYS AND IT'S GETTING EXPENSIVE. HYUNDAI NEEDS TO ADDRESS THIS PROBLEM BEFORE SOMEBODY GETS SERIOUSLY HURT.
Structure, Sep 5, 2007
TL*THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT STATED THAT THE FRONT SUBFRAME OF THE VEHICLE IS COMPLETELY RUSTED FROM THE INSIDE. THE DEALER SUGGESTED THAT HE CALL THE HYUNDAI DEALER. HYUNDAI HAS BEEN UNABLE TO CORRECT THE FAILURE. THE VIN WAS INVALID. THE CURRENT MILEAGE WAS 112,000 AND THE FAILURE MILEAGE WAS UNKNOWN.
Structure, Aug 30, 2007
CAR HAS NEVER BEEN IN AN ACCIDENT ,AND HAS HAD 1 OWNER.VECHICLE IS HOUSED IN CENTRAL N.J. ,VECHICLE HAS BEEN SERVICED AS TO HYUNDAI'S SERVICE MANUAL RECOMENDATIONS.ALSO VECHICLE HAS RECENTLY BEEN SERVICED JUST BEFORE MANUFACTURERS WARRANTY EXPIRED FOR DEFECTIVE TRANSMISSION SERVOS (CAR WAS ON LIFT AT TIME OF SERVICE ).ALSO THIS VECHICLE STILL HAS ORGINAL EXHAUST SYSTEM INCLUDING MUFFLER.ON AUGUST30,2007 MY SELF MY CHILD AND MY NEPHEWS WERE DRIVING ON THE PARKWAY AT 65 MPH AT APPROXIMATLY 9 PM WHEN THE TRANSMISSION EXPLODED AND LEFT ME STRANDED IN TRAFFIC LANE WITH VECHICLES APPROACHING AT HIGH RATES OF SPEED AND SWERVING AROUND ME THERE WAS NO WAY TO GET OUT OF HARMS WAY I WAS TRAPPED IN CAR WITH CHILDREN WE CALLED 911 AND THE STATE POLICE HAD TO PUSH VECHICLE TO A SAFE ZONE WHERE WE WAITED FOR A TOW TRUCK.UPONFURTHER INSPECTION OF VECHICLE IT WAS FOUND TO BE CAUSED BY A SEVERLY ROTTED SUBFRAME WHICH CAUSED THE MOTOR AND TRANSMISSION TO DROP CAUSING THE AXLE TO BE TORN THROUGH TRANSMISSION HOUSING AND THE LOWER CONTROL ARM TO BREAK AWAY FROM ROTTED SUBFRAME ALSO(AS STATED EARLIER THE VECHICLE WAS NEVER INVLOVED IN AN ACCIDENT AND HAS NO BODY OR UNDERCARRRIAGE RUST INCLUDING THE EXHAUST SYSTEM. THIS IS A SERIOUS STRUCTUAL PROBLEM AS SUBFRAME CARRIES ENTIRE DRIVETRAIN (MOTOR AND TRANSMISSION AND ALL STERING COMPONENTS).AT THIS TIME NOTHING HAS BEEN DONE BY HYUNDAI TO RECTIFY THIS SITUATION WE WERE TOLD ITS NOT COVERED BY WARRANTY WE WERE NERER MADE AWARE OF ANY PROBLEM AT TIME OF SERVICE AT AUTHORIZED HYUNDAI DEALER. STILL WAITING TO HEAR FROM A SUPERVISOR FROM HYUNDAI CONSUMER AFFAIRS.
Engine and engine cooling, Power train, Electrical system, Equipment, Jul 19, 2007
TL*THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT HAS BEEN EXPERIENCING FAILURE WITH THE SENSOR PLUG ON HER VEHICLE. SHE HAS HAD TO PAY $200 EACH TIME THE VEHICLE HAS BEEN REPAIRED. SHE STATED THAT SHE IS ALSO EXPERIENCING FAILURE WITH THE POWERTRAIN AUTOMATIC TRANSMISSION, WHICH CAUSED HER VEHICLE TO STALL. SHE HAS HAD TO REPLACE HER ENGINE AND THE BATTERY APPROXIMATELY TWO TO THREE TIMES. THE POWERTRAIN WAS UNKNOWN. THE CURRENT MILEAGE IS 118,000 AND FAILURE MILEAGE WAS 67,000. THE CONSUMER STATED REPLACED THE ENGINE 1 TIME AND THE BATTERY TWICE. THE DEALER STATED RADIO JUMPING CHANNELS. UPDATED 09/05/07 *TR
Electrical system, May 29, 2007
TL*THE CONTACT OWNS A 2000 HYUNDAI SONATA. WHILE DRIVING 60 MPH, THE VEHICLE SUDDENLY STOPPED AND LOST POWER. THE CONTACT EVENTUALLY COASTED OFF THE ROAD AND APPROXIMATELY THREE TO FOUR MINUTES LATER, THE VEHICLE RESTARTED. THE DEALER DIAGNOSED THE CAUSE OF FAILURE AS THE CRANK POSITION SENSOR. THE CURRENT AND FAILURE MILEAGES WERE 31,000. UPDATED 02-01-08. *KB
Engine and engine cooling, Apr 20, 2007
THE CRANKSHAFT POSITION SENSOR IS FAULTY. I DON'T UNDERSTAND HOW HYUNDAI CAN HAVE A RECALL FOR THIS ITEM IN THEIR KIA OPTIMAS AND SANTA FE 2.5L V-6 ENGINES, BUT NOT IN THE 2.5L V-6 SONATAS. THE LEAST OF THE PROBLEMS IS DIFFICULTY STARTING, WHICH SEEMS TO BE THE CULMINATION OF THE PROBLEM. THE BEGINNING OF THE PROBLEM IS THE LOSS OF POWER AND STALLING, INCREDIBLY DANGEROUS WHILE ON THE HIGHWAY TRAVELING AT 60 MPH AND WITHOUT WARNING THE CAR LOSES POWER. LAST YEAR I SPENT OVER $500 FOR A TUNE UP AND SPARK PLUG WIRES. THE CHECK ENGINE JUST CAME ON TODAY AFTER HAVING TROUBLE GETTING STARTED AND HAD IT DIAGNOSED AS A P0335 CRANKSHAFT POSITION SENSOR A CIRCUIT MALFUNCTION. I CALLED SEVERAL DEALERSHIPS AND THE REPAIR IS IN EXCESS OF $400 FOR LABOR PLUS PARTS. *JB
Electrical system, Apr 18, 2007, fire
TL*- THE CONTACT OWNS A 2000 HYUNDAI SONATA GLS, WITH A CURRENT MILEAGE OF 134,000 MILES. SHE STATED THAT THE VEHICLE LOST POWER WHILE DRIVING AT A LOW SPEED. WHENEVER THE VEHICLE LOST POWER SHE PULLED THE VEHICLE TO THE SIDE OF THE ROAD TO RESTART IT. AFTER RESTARTING THE VEHICLE IT WOULD ACCELERATE AT A LOW SPEED. THE FAILURE MILEAGE WAS 102,000. THE DEALER PERFORMED A TUNE UP, AND INFORMED HER THAT THE SPARK PLUG WIRES WERE BURNED. THERE IS A RECALL FOR THE ELECTRICAL SYSTEM WIRING RECALL # 00V259001. AS OF 4-18-07 THE FAILURE OCCURRED 25 TIMES .
Electrical system, Apr 13, 2007
TL*- THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CURRENT MILEAGE WAS 98,140. WHILE DRIVING 60 MPH ON THE FREEWAY DURING DRY WEATHER CONDITIONS, THE VEHICLE LOST POWER WITHOUT WARNING. SHE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO DEALER, WHO STATED THAT IT WAS THE MASS AIR FLOW SENSOR THAT CAUSED THE ENGINE TO FAIL. THE DEALER STATED THAT THERE WAS RECALL 00V259001 FOR THE MASS AIR FLOW, BUT THAT THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO THE VIN. THE CONTACT COULD NOT RECALL THE NAME OF THE DEALER WHERE SHE PURCHASED THE VEHICLE. *AK
Air bags, Mar 21, 2007, crash
VEHICLE OWNER WAS DRIVING HER 2000 HYUNDAI SONANA GLS WHEN VEHICLE HIT A POLE. THERE IS EXTENSIVE FRONT END DAMAGE AND SHE HIT THE STEERING WHEEL HARD CAUSING INTERNAL INJURIES. THE CAR IS EQUIPPED WITH FRONT AIRBAGS AND SIDE IMPACT AIRBAGS BUT NONE DEPLOYED. *AKOWNER QUESTIONED WHY AIRBAG (S) DID NOT DEPLOY. *AK
Engine and engine cooling, Structure, Jan 11, 2007
FRAME OF 2000 HYUNDAI SONATA WAS FOUND DURING OIL CHANGE TO BE SEVERELY RUSTED TO THE POINT WHERE VEHICLE WAS UNSAFE TO DRIVE. WENT TO DEALERSHIP WHERE WE WERE TOLD TO CONTACT HYUNDAI CORP. AFTER 2 WEEK PERIOD WE WERE TOLD HYUNDAI WOULD DO NOTHING TO CORRECT PROBLEM. WENT BACK TO DEALERSHIP AND AFTER 3 DAYS WERE AGAIN TOLD NOTHING WOULD BE DONE TO FIX PROBLEM. THE CAR ONLY HAD 88,000 MILES ON IT WHEN PROBLEM WAS DISCOVERED AND STILL HAD ORIGINAL MUFFLER. DOES FRAME USUALLY RUST OUT BEFORE MUFFLER? EVENTUALLY BECAUSE OF NEED FOR VEHICLE WERE FORCED TO HAVE VEHICLE FIXED OUT OF POCKET. REPAIR SHOP TOLD US THEY HAD REPAIRED SEVERAL HYUNDAI SONATAS OVER THE LAST YEAR WITH RUST ALL IN THE SAME SPOT ON THE FRAME AND THAT SOME COULDN'T EVEN MAKE IT TO THE SHOP WITHOUT A TOW. WE PAID TO HAVE A REFURBISHED FRAME PUT ON THE CAR, AT THE COST OF $1150, NOT TO MENTION THE INCONVENIENCE CAUSED OVER THE COURSE OF 3 MONTHS IT TOOK TO GET IT FIXED. WE HAD PICTURES TAKEN OF THE FRAME ON THE CAR AND AS IT CAME OFF. *JB
Suspension, Dec 5, 2006
WHILE DRIVING APPROX 30 MPH MY FRONT RIGHT WHEEL FOLDED BACK AGAINST THE FENDER, BRING ME TO AN ABRUPT STOP. ONCE I HAD THE VEHICLE TOWED TO A LOCAL SHOP WE FOUND THAT THE SUB FRAME HAD RUSTED THROUGH AND THAT THE CONTROL ARM HAD COMPLETELY BROKEN OFF OF THE SUB FRAME. I HAD TO REPLACE THE COMPLETE SUBFRAME ON THIS 6 YEAR OLD VEHICLE WITH ONLY 77000 MILES ON IT. *JB
Structure, Oct 9, 2006
THE ALIGNMENT APPEARED TO BE OFF ON MY 2000 HYUNDAI SONATA. ON OCT. 1, 2006, THE VEHICLE WAS INSPECTED AT A LOCAL FIRESTONE STATION. THE MANAGER SHOWED ME THE CAUSE OF THE MIS-ALIGNMENT: THE ORIGINAL ENGINE CRADLE HAD NEARLY RUSTED THROUGH ON THE PASSENGER SIDE OF THE CAR. THERE WAS A RUSTED OUT HOLE IN THE ENGINE CRADLE THAT MY HAND COULD HAVE FIT THROUGH. THE VEHICLE WAS SUBSEQUENTLY TOWED TO A HYUNDAI DEALER'S SERVICE CENTER. DUE TO THE PRICE OF THE REPAIRS COMPARED TO THE VALUE OF THE CAR, I ELECTED TO FORGO REPAIRS. THE CAR WILL BE SOLD TO A SALVAGE YARD FOR PARTS. THE CAR HAD BEEN AT A HYUNDAI DEALER FOR REPAIRS IN OHIO IN MARCH AND MAY 2006. AT NEITHER TIME WAS RUST IDENTIFIED AS A THREAT TO THE INTEGRITY OF THE VEHICLE. THANKFULLY, THE DEFECT WAS DISCOVERED BEFORE ACCIDENTS OR INJURIES OCCURRED.
Engine and engine cooling, Sep 18, 2006
2000 HYUNDAI SONATA - MASS AIR FLOW SENSOR FAILED AT 45,000 MILES - WAS THIS ITEM REPLACED IN 2000 RECALL? *NM
Air bags, Aug 29, 2006
DT*: THE CONTACT STATED THE AIRBAG WARNING ILLUMINATED CONSTANTLY. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER FOR RECALL #01V347000 BUT THE AIRBAG WARNING LIGHT CONTINUED TO ILLUMINATE.
Engine and engine cooling, Jul 31, 2006
I WAS TRAVELING DOWN THE HIGHWAY WHEN WITHOUT WARNING MY ENGINE SIMPLY SHUT OFF, AND THE POWER ASSIST TO THE BRAKES AND STEERING WAS STOPPED. I TRIED MOVING FROM THE CENTER LANE OVER TO THE SHOULDER AND WAS ALMOST REAR-ENDED BY A VEHICLE IN THE RIGHT LANE. I WAS ABLE TO PULL THE CAR OFF ON THE RIGHT SHOULDER AND STOP. THE VEHICLE WOULD NOT RESTART AND I HAD TO HAVE IT TOWED TO THE NEAREST DEALER IN THE AREA, PUGI HYUNDAI IN DOWNERS GROVE, IL. THEY TOOK THE VEHICLE IN FOR SERVICE AND LATER IN THE MORNING INFORMED ME THAT THE CRANKSHAFT POSITION SENSOR HAD FAILED. THE COST OF REPAIR WILL BE A MINIMUM OF $600, AND POSSIBLY MORE, DEPENDING IF THEY DETERMINE THE ENGINE NEEDS ADDITIONAL REPAIR PARTS. *NM
Power train, May 22, 2006
DT*: THE CONTACT STATED INTERMITTENTLY, THE VEHICLE WOULD NOT SHIFT OUT OF FIRST GEAR. THE VEHICLE HAD TO BE TURNED OFF AND THE CLUTCH PUMPED FOR THE VEHICLE TO SHIFT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CLUTCH ASSEMBLY WAS REPLACED. THE PROBLEM PERSISTED AND THE REPAIR SHOP SUGGESTED THE TRANSMISSION BE INSPECTED BY THE DEALERSHIP. *AK
Power train, Electrical system, Feb 28, 2006
CAR HAD A RECALL FOR THE OXYGEN SENSORS AND WAS TAKEN CARE OF. HOWEVER, IT HAS BEEN IN THE SHOP 3 OTHER TIMES TO HAVE THE OXYGEN SENSORS REPLACED AND I JUST HAD ANOTHER GO OUT PAST THE WARRANTY PERIOD. I HAVE ALSO HAD THE CAR 'SLAM' INTO A LOWER GEAR WHILE ON THE EXPRESSWAY AND THE CHECK ENGINE LIGHT CAME ON. WHEN I TAKE IT THEY SAY IT IS A TRANSMISSION SENSOR AND REPLACE IT. THIS HAS DONE IT FIVE TIMES!! IT IS VERY SCARY WHEN IT DOES THIS. THE CAR IS ON IT'S FOURTH BATTERY AND IT HAS 80,000 ON THE ODOMETER. I HAVE HAD NUMEROUS OTHER PROBLEMS TOO. NOW IT JUST WILL NOT START, IT IS GOING TO AN INDEPENDENT SHOP THIS TIME. THIS CAR HAS BEEN ONE BIG HEADACHE!!! *NM
Air bags, Nov 17, 2005, crash
DT: THE CONTACT'S DAUGHTER WAS INVOLVED IN AN ACCIDENT. THE ACCIDENT OCCURRED DURING RAINY CONDITIONS. THE CONTACT'S DAUGHTER HYDRO PLANED AND HIT ANOTHER VEHICLE. UPON IMPACT THE FRONT AIR BAGS FAILED TO DEPLOY. THE VEHICLE RECEIVED DAMAGE TO BOTH FRONT DOORS AND THE FRONT END. INJURIES WERE SUSTAINED BY BOTH THE CONTACT AND A PASSENGER IN THE REAR OF THE VEHICLE. THE AIR BAG LIGHT ILLUMINATED AFTER THE IMPACT. A POLICE REPORT WAS TAKEN AT THE SCENE. THE VEHICLE WAS INSPECTED BY THE INSURANCE COMPANY AND DEEMED A TOTAL LOSS.*AK
Air bags, Nov 10, 2005
DT: THE CONTACT STATED THE SIDE /CURTAIN AIRBAG ON THE DRIVER'S SIDE DEPLOYED WITHOUT ANY ACCIDENT. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, AND THEY STATE THE COMPUTER READ THERE HAD BEEN AN ACCIDENT. THE MANUFACTURER OFFERED TO REPAIR THE VEHICLE AT THEIR EXPENSE, BUT THE CONTACT COULD NOT FIND A DEALERSHIP TO DO THE WORK. THERE HAVE BEEN NO CORRECTIONS MADE TO THE VEHICLE AT THIS TIME. *AK
Electrical system, Air bags, Oct 27, 2005
DT: THE CONTACT STATED THAT ONCE A YEAR THE AIR BAG WARNING LIGHT CAME ON. HE TOOK THE VEHICLE TO DEALERSHIP, AND THEY ADJUSTED THE HARNESS AND THE LIGHT WENT OFF. THE DEALERSHIP TOLD THE CONTACT THAT SOMETHING WAS NOT CORRECT WITH THE WIRING HARNESS WHERE IT CONNECTS TO THE SEAT, CAUSING THE LIGHT TO COME ON. *AK
Air bags, Oct 10, 2005
NEW HYUNDAI SONATA PURCHASED IN 2000. MOTOR VEHICLE RECALL NOTICE RECEIVED REGARDING AIR BAG WIRING HARNESS. CAR WAS TAKEN IN FOR RECALL. THE RECALL WAS "FIXED" ACCORDING TO THE DEALER. THE AIR BAG WIRING HARNESS CONNECTOR HAS NOT BEEN FIXED CORRECTLY. THE AIR BAG LIGHT STILL GOES OFF, BECAUSE THE CONNECTOR MUST BE LOOSE AND DISCONNECTS. DEALER STATES THAT OWNER MUST BE DISCONNECTING THE WIRING BY PLACING OBJECTS UNDER THE SEAT. THE OWNER DOES NOT PUT OBJECTS UNDER THE SEAT. THE RECALL ISSUE HAS NOT BEEN FIXED SO THAT THE WIRING HARNESS IS SECURELY FASTENED. *JB