2012 Hyundai Sonata
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,557 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Sonata model years with reports.
Of the 2012 reports, 51 involved a crash and 95 involved a fire. 38 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EngineDec 28, 2018
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Hyundai will notify owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began March 1, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's recall number for this recall is 180.
Campaign 18V934000 on NHTSA.gov
Seat belts, pretensionerFeb 27, 2018
Hyundai Motor America (Hyundai) is recalling certain 2011-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. On February 27, 2018, Hyundai Motor Company (Hyundai) notified NHTSA that they were recalling 154,753 model year 2011 Sonata vehicles. On April 18, 2018, Hyundai expanded the recall to include an additional 425,305 model year 2012-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying.
If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Hyundai will notify owners, and dealers will install an external wire filter kit, free of charge. The recall began October 15, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 174.
Campaign 18V137000 on NHTSA.gov
Seat belts, pretensionerOct 4, 2017
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
If the seat belt linkage detaches from the seat belt anchorage, it can not properly restrain the occupant in the event of a crash, increasing the risk of injury.
Hyundai will notify owners, and dealers will again verify the connection between the seat belt linkage and the pretensioner and additionally install a warning label to prevent future seat belt linkage detachment, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 169.
Campaign 17V617000 on NHTSA.gov
Seat belts, front, anchorageMar 8, 2017
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
In the event of a crash, if the seat belts detach from the anchor pretensioners, it can increase the risk of injury.
Hyundai will notify owners and dealers will inspect the connection between the seat belt linkages and the seat belt anchor pretensioners, repairing them as necessary, free of charge. The recall is expected to begin April 7, 2017. Owner's may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for the recall is 160.
Campaign 17V152000 on NHTSA.gov
Exterior lighting, brake lights, switchNov 16, 2015
Hyundai Motor America (Hyundai) is recalling certain model 2011-2012 Sonata vehicles. The brake pedal stopper pad can deteriorate allowing the brake light switch plunger to remain extended when the brake pedal is released.
If the brake light switch plunger does not retract as it should when the brake pedal is not being pressed, the brake lights may stay illuminated preventing accurate communication to rearward following vehicles that the vehicle is slowing or stopping. Additionally, if the brake switch plunger is not retracted, then the transmission can be shifted out of PARK without depressing the brake pedal. Either condition increases the risk of a crash.
Hyundai will notify owners, and dealers will replace the brake pedal stopper pad with an improved part, free of charge. The recall began on January 6, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 136.
Campaign 15V759000 on NHTSA.gov
EngineSep 10, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Sonata vehicles manufactured December 11, 2009, to April 12, 2012 at Hyundai Motor Manufacturing Alabama and equipped with either a 2.0 liter or 2.4 liter Gasoline Direct injection engine. In the affected vehicles, metallic debris may not have been fully removed during manufacturing of the engine crankshaft. If the debris was not completely removed, oil flow may be restricted through the connecting rod bearings, causing connecting rod damage. A worn connecting rod bearing will produce a metallic, cyclic knocking noise from the engine and possible engine failure.
Engine failure would result in a vehicle stall, increasing the risk of a crash.
Hyundai will notify owners, and dealers will inspect the vehicles and replace the engine assembly, as necessary, free of charge. Additionally, Hyundai Motor America will increase the warranty for the engine sub-assembly (short block) to 10 years/120,000 miles for both original and subsequent owners of 2011 and 2012 Sonatas manufactured at Hyundai Motor Manufacturing Alabama equipped with 2.0 liter and 2.4 liter Gasoline Direct injection engines. Interim notifications were mailed to owners starting on October 8, 2015. A second notification will be mailed when parts are available. Owners may contact Hyundai customer service at 1-855-671-3059 or by visiting www.HyundaiUSA.com/Campaign132. Hyundai's number for this recall is 132.
Campaign 15V568000 on NHTSA.gov
Power train, automatic transmissionJul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model year 2011-2014 Sonata vehicles manufactured December 11, 2009, through May 29, 2014. In the affected vehicles, the transmission shift cable may detach from from the shift lever pin.
If the transmission shift cable detaches, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver parks the vehicle, despite selecting the 'PARK' position, the transmission may not be in 'PARK.' If the vehicle is not in the 'PARK' position and the parking brake is not applied, there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Hyundai will notify owners, and dealers will inspect and, as necessary, repair the connection between the shift cable and shift lever, free of charge. The recall began in September 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 123.
Campaign 14V434000 on NHTSA.gov
Air bags, side/windowJul 24, 2012
Hyundai is recalling certain model year 2012-2013 Hyundai Sonata passenger cars, manufactured from January 24, 2012, through June 21, 2012. The curtain side airbags on these vehicles may inflate without deployment command due to an error during manufacturing.
The curtain airbag may inflate without deployment command and increase the risk of injury to occupants of the vehicle. Additionally, an unexpected deployment would be a significant driver distraction and would limit the driver's visibility, increasing the risk of a crash.
Hyundai dealers will notify owners, and dealers will replace the curtain side airbags free of charge. This recall began on August 31, 2012. Owners may contact Hyundai at 1-800-633-5151.
Campaign 12V352000 on NHTSA.gov
Representative owner complaints
1,557 reports, newest first.
Steering, Electrical system, Jan 18, 2026
Unknown, my ESP KEEPS Coming trying to see if it’s recall
Engine and engine cooling, Dec 29, 2025
The contact owns a 2012 Hyundai Sonata. The contact stated that the vehicle was experiencing excessive oil consumption, which required the oil reservoir to be refilled after 3-4 weeks. Additionally, there was no warning light illuminated. The contact stated that upon taking the vehicle to Jiffy Lube for a top off, the mechanic would inform the contact that the oil reservoir was empty and needed to be refilled. The vehicle was not taken to the dealer. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 158,000.
Other or unspecified, Dec 4, 2025
The vehicle dashboard is severely cracked. It doesn’t appear to be from wear and tear.
Engine, Dec 3, 2025, fire
The contact owned a 2012 Hyundai Sonata. The contact stated that while driving to her residence at unknown speeds, the vehicle suddenly caught fire while making a U-turn. The brakes and emergency brake were inoperable. The seatbelt was inoperable. The driver jumped out of the window. A pedestrian attempted to alert her of the fire. The vehicle exploded after exiting the vehicle. The contact sustained an injury to her leg, but no medical attention was provided. The fire department extinguished the fire. A police report was filed. There was no report of a crash or airbag deployment. The vehicle was towed to a tow lot. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 136,000. The vehicle was auctioned off by the towing company.
Steering, Electrical system, Service brakes, Nov 29, 2025, fire
Based on what I experienced, the fire appears to have resulted from an internal mechanical or electrical failure that occurred without warning while the vehicle was in motion. No prior issues or dashboard alerts were present at the time, and there was no external impact or damage that could explain the fire.
Air bags, Structure, Other or unspecified, Nov 23, 2025
Noticed there’s a crack on the passenger side dashboard of the car that’s about 12 inches long. From what I read this could cause issues with any possible airbag deployment.
Engine, Nov 18, 2025
The engine in my Hyundai Sonata (replacement engine VIN [XXX] ) experienced a complete internal failure. The component that failed is the 2.4L Theta II GDI engine, which is known for issues related to metal debris, oil restriction, rod bearing wear, and resulting piston and compression failure. The failed engine is currently at the dealership (Carolina Hyundai) and is available for inspection upon request. My safety was put at risk because the engine lost power unexpectedly, ran extremely rough, and became inoperable. A sudden loss of power while driving could have caused a crash, especially in traffic situations. The problem has been reproduced and confirmed by the dealership. They performed a compression test and found all cylinders at extremely low PSI (35–45 psi). The dealer stated the engine cannot perform the required bearing clearance test due to the level of internal damage. Hyundai Corporate initially declined assistance, calling it a piston failure, but the symptoms and damage are consistent with the known Theta II recall issues. The vehicle has been inspected by the dealership, and all diagnostic information has been submitted to Hyundai under PA Reference #XXX. Hyundai Corporate has not yet responded to me with a case manager. Before the engine failure, the vehicle had rough running and loss of power, but no warning lights or messages illuminated on the dashboard. Symptoms appeared shortly before the engine became undriveable. Based on the dealer’s findings and the engine’s known defect history, it is my assessment that the failure is related to the same issues described in Hyundai’s Theta II engine recall (Campaign 132). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Air bags, Seat belts, Engine, Oct 26, 2025
My 2012 Hyundai Sonata (VIN: [XXX] ) experienced complete engine failure at 241,433 miles on August 7, 2025. The failure aligns with known safety defect symptoms described under NHTSA Recall Campaign 15V568000 and 17V226000, which cite premature bearing wear due to metal debris during engine manufacturing. My vehicle had previously received the knock sensor update under Campaign T3G and failed the BCT (bearing clearance test), confirming bearing damage. Despite this, Hyundai denied my engine replacement claim, stating the issue was related to a fuel pipe and not a rod bearing issue—this is contrary to their own recall documentation and dealer diagnosis. Hyundai continues to deny engine replacement, in violation of their federal recall obligations under 49 U.S.C. §30120. Their refusal endangers public safety by ignoring engine failures that can lead to stalling and crashes. I request NHTSA intervention to compel Hyundai Motor America to comply with federal law and perform the necessary recall repairs on my vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Oct 24, 2025
My 2012 Hyundai Sonata cut off and stopped working! The vehicle locked up in the middle of a main street and would not start back up causing a very unsafe situation. There were no check engine lights on or anything at the time of the incident I immediately had the vehicle towed and inspected it has been determined that the engine is failing! Upon research I found out that these engines have had recalls in the past. Carfax shows that the vehicle has been taken in for routine maintenance and oil changes when needed. I am looking to see if the engine replacement could be covered for this vehicle.
Engine, Oct 23, 2025, crash
My engine seized on the highway on my way home from work. The service department has been horrid. They lied about who the manager is. They lied about the reason behind not wanting to honor the recall. They are rude - threatened to tow my car today after I waited 6 days to hear back from them about the issue with my car and determination. Was extremely rude. Stated that they were not honoring the recall because there was obvious signs of my engine being tampered with or certain parts on my engine, but could not provide a name of the part or a serial or model number so that this could be verified. I need this addressed immediately.
Other or unspecified, Oct 21, 2025
No incident to report. Vehicle not regularly driven in about 5 years, other than to keep battery charged. But charge not hold. Have to charge battery again the next day. This is to reporting a crack in the passenger side dashboard where airbag is located.
Air bags, Other or unspecified, Oct 17, 2025
This is the 2nd Hyundai I've owned, same year make and model. The first one was totaled due to the air bag deployment. The accident did not warrant the air bag deploying. I should have reported it at the time. I didn't realize that I could and now it's too late. The claim has already been submitted. Now, we have the same exact car and a crack has appeared on the passenger dash. My concern is the airbag. The crack just appeared from nowhere. I do not feel that we should have to pay for a replacement dash. Is this something that can be repaired by Hyundai, as it poses a risk to my 18 year old student driver. My number is [XXX] , [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Oct 9, 2025
Vehicle loses power while driving making it unsafe to drive, it can cause an accident in certain conditions like when passing another vehicle or crossing a street. There is a recall for this issue.
Exterior lighting, Oct 9, 2025
My car has a problem whith the break lamps, the sockets that hold the bulbs are melting and they have deformed making it hard to replace the fused bulbs. Also the brake light stay on even after the engine is off draining the Battery and causing a short circuit.
Service brakes, Engine, Oct 5, 2025, fire
Driving came to a stop ,light turned green made a U-turn to go to the gas station heard a pop noise smoke came from inside the car tried stopping it but the brake pedal sunk into the ground pressed my emergency brake it was seized wouldn’t go down (never had that issue my brakes always work ) I smelled brake fluid and seen the abs light on the dash then the power started to go out and my girlfriend almost got trapped in the car
Service brakes, Hydraulic, Fuel system, Gasoline, Engine, Oct 1, 2025
The contact owns a 2012 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 18V934000 (Engine, Fuel System, Gasoline). The contact stated that while driving 20 MPH, the vehicle stalled. There was an abnormal knocking sound coming from the vehicle. While driving at an undisclosed speed, the vehicle stalled after five minutes. The engine and the ABS warning lights were illuminated. The vehicle was towed to the residence. The contact called the local dealer and was informed that the maintenance records were needed. The contact was using an independent mechanic for maintenance and did not have the records. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 100,000.
Service brakes, Sep 26, 2025
The part of hand break assembly that’s inside the disk break (the drum assembly) fell off when the dealer ( [XXX] Hyundai, Schaumburg, IL) tried to adjusted. I went to the dealer because the hand break stop to function. I suspect very bad design of the whole assembly disk and drum break. Also the dealer stated that all assembly was rusted. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Engine, Sep 26, 2025
came off the highway to a stop sign went turn and the engine just seized and would not start no matter what I did. had to have it towed to my house. safety risk was just off the road so i did not get hit. police stop and told me to get a tow truck. and no warning signs at all
Engine, Sep 18, 2025
My 2012 Hyundai Sonata originally had its engine replaced under Hyundai’s recall (NHTSA Recall #17V226000) due to the Theta II GDI engine defect. The replacement engine was installed by the dealership as part of the recall. However, the replacement engine has now failed after only ~50,000 miles, exhibiting the same issues (engine knocking, stalling, and eventual failure). This occurred despite proper maintenance and care. The dealership contacted Hyundai, and I also contacted Hyundai Consumer Affairs directly. Both refused to replace or assist with the failed replacement engine. It is unacceptable that a recall replacement engine would fail so soon and that Hyundai will not stand behind the part they used to correct a safety defect. The issue remains a serious safety concern, especially since engine failure can lead to fire. I request that NHTSA investigate the durability and safety of replacement engines and Hyundai’s refusal to support affected owners when these replacement engines fail prematurely. I have case number with Hyundai 41436693
Air bags, Service brakes, Engine, Sep 5, 2025
With no warning my car left me sit on the side of the road and when started the engine made an awful knocking noise. Hyundai denied to replace the engine despite there being at least 2 engine recalls. When I asked why they said it was due to no maintenance records so I provided them with maintenance records like they requested and then they deny it again and say they aren’t replacing the engine because the problem with my engine had nothing to do with the 2 engine recalls my vehicle IS affected by.
Air bags, Sep 2, 2025, crash
Airbags failed to deploy. I was involved in a hit and run accident. Vehicle has not been inspected. I had a recall done on it with paperwork confirming it was fixed. I have 4 herniated discs in my back and neck.
Engine, Aug 22, 2025
This is the first time I have an engine failure. I drove my car 3 min before merging into the route 1 highway. In approximately 800 feet, my car went haywire, all lights in the dashboard went ON, the steering wheel got stiff, and the car speed dropped off, I almost got rear-ended. I made an effort to pull over to the break lane. The car shut off and I could not get it to start. I opened the hood, a light smoke was coming out of the engine. I left it open to make sure it doesn't get worse. After 10 min, a State trooper stopped by to check on my safety, I informed him that I called the insurance to report the incident and request a tow truck. After the tow truck dropped off my car in front of my house, I called a mechanic to check it, he informed me that the engine is seized.
Engine, Aug 20, 2025
I bought car octv230th little after month as driving engine failure occurred had towed to dealership and they sent to authorized hyndai dealership for the extended warranty campaign. That garage acknowledged problems with the cars engine stating rod bearing clearance and the engine had to be replaced then charged me denied the extended warranty they initially said would classify for. I couldn't keep up with traffic and was very busy almost cause a crash.
Electrical system, Service brakes, Engine, Aug 15, 2025, fire
I was driving I seen smoke then full flames on my windshield and I tried to stop and put my car in park to get out but my brakes stopped working and I couldn’t get the gear in park so I opened the driver door and had to jump out of the car .I had an engine replacement a year before for it being recalled and police and firefighters were on scene after incident
Engine, Jul 30, 2025
Engine seized due to extremely low oil despite more than regular oil changes.