2014 Hyundai Sonata
Problems, recalls and owner-reported issues
Engine is the leading concern among 747 owner complaints filed for this model year. This is the 7th highest complaint count among 26 Sonata model years with reports.
Of the 2014 reports, 29 involved a crash and 40 involved a fire. 35 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 6, 2022
Hyundai Motor America (Hyundai) is recalling certain 2013-2014 Sonata vehicles. The low pressure fuel hose that connects the low pressure fuel pump to the direct injection fuel pump may crack over time, due to heat generated within the engine compartment.
A cracked fuel hose may leak fuel, which can increase the risk of a fire.
Dealers will replace the low pressure fuel hose, free of charge. Owner notification letters were mailed October 10, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 227. This recall replaces NHTSA recall number 20V-121. Vehicles previously repaired under recall 20V-121 that did not receive a replacement fuel hose will need to have this new recall remedy performed.
Campaign 22V312000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsFeb 28, 2020
Hyundai Motor America (Hyundai) is recalling certain 2013-2014 Sonata vehicles. The low pressure fuel hose that connects the low pressure fuel pump to the direct injection fuel pump may crack over time due to heat generated within the engine compartment.
If the fuel line cracks, a fuel leak can occur, increasing the risk of a fire.
Hyundai will notify owners, and dealers will inspect the low-pressure fuel hose for damage or leaking, replacing it as necessary. If no damage or leaking is found, heat-protective tape will be installed. Repairs will be performed free of charge. The recall began August 10, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 189. This recall has been replaced by NHTSA recall number 22V-314.
Campaign 20V121000 on NHTSA.gov
EngineDec 28, 2018
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Hyundai will notify owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began March 1, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's recall number for this recall is 180.
Campaign 18V934000 on NHTSA.gov
Seat belts, pretensionerOct 4, 2017
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
If the seat belt linkage detaches from the seat belt anchorage, it can not properly restrain the occupant in the event of a crash, increasing the risk of injury.
Hyundai will notify owners, and dealers will again verify the connection between the seat belt linkage and the pretensioner and additionally install a warning label to prevent future seat belt linkage detachment, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 169.
Campaign 17V617000 on NHTSA.gov
Engine and engine cooling, engineMar 31, 2017
Hyundai Motor America (Hyundai) is recalling certain 2013-2014 Sonata and Santa Fe Sport vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.
Bearing wear may result in the engine seizing, increasing the risk of a crash.
Hyundai will notify owners, and dealers will inspect the engine, replacing the engine short block, as necessary, free of charge. The recall began June 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 162.
Campaign 17V226000 on NHTSA.gov
Seat belts, front, anchorageMar 8, 2017
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
In the event of a crash, if the seat belts detach from the anchor pretensioners, it can increase the risk of injury.
Hyundai will notify owners and dealers will inspect the connection between the seat belt linkages and the seat belt anchor pretensioners, repairing them as necessary, free of charge. The recall is expected to begin April 7, 2017. Owner's may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for the recall is 160.
Campaign 17V152000 on NHTSA.gov
Power train, automatic transmissionJul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model year 2011-2014 Sonata vehicles manufactured December 11, 2009, through May 29, 2014. In the affected vehicles, the transmission shift cable may detach from from the shift lever pin.
If the transmission shift cable detaches, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver parks the vehicle, despite selecting the 'PARK' position, the transmission may not be in 'PARK.' If the vehicle is not in the 'PARK' position and the parking brake is not applied, there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Hyundai will notify owners, and dealers will inspect and, as necessary, repair the connection between the shift cable and shift lever, free of charge. The recall began in September 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 123.
Campaign 14V434000 on NHTSA.gov
Representative owner complaints: engine
321 reports, newest first. Show all
Engine, Jul 9, 2024
The contact owns a 2014 Hyundai Sonata. The contact stated while driving approximately 65 MPH, the vehicle lost motive power and stalled. There were no warning lights illuminated. The vehicle was not able to be restarted and the vehicle was towed to an independent mechanic where it was diagnosed with engine failure. The vehicle remained at the independent mechanic and was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.
Engine, Jul 8, 2024
Engine stopped running while driving. Taken to Hyundai for theta ii settlement. Claim denied due to exception negligence. Discoloration found on cam. Car burned 1 quart of oil every week or two which confirmed with independent mechanic can cause discoloration. Claim denied without cause.
Engine, Apr 30, 2024, fire
Hyundai Motors fails to sympathize with their customers. I bought a Hyundai Sonata 2014 which caught a fire on October 9th 2019. Hyundai finally conversated me for the car in how much it was worth $4,150.60 on March 20th 2024 and not for punitive damages. I feel they are very unfair and I need my punitive damages I lost a lot not only a car but my job as well. My livelihood and transportation on top of that. And I need help to recover my punitive damages.
Steering, Service brakes, Engine, Apr 22, 2024
On Feb 15th 2023 my daughter was driving my 2014 Hyundai Sonata at the posted speed limit of 55 MPH on a 2 lane blacktop when the car suddenly and without any warning at all, lost all power and became unresponsive while traveling with other vehicles behind her, in front of her and in the opposing lane of travel. Without enough of an improved shoulder to pull to the right and a steep embankment on that side of the roadway as well, she was forced to veer to the left with other cars approaching. She had minimal braking, steering and no response to depressing the accelerator pedal at all. She was able to direct the car onto a paved portion of a feeder road and finally got the car stopped. The cabin filled with smoke and there was smoke all around the car but no fire was ever found. These vehicles are dangerous to the public and have a known engine defect that because of this the manufacturer has implemented a software patch known as KSDS and with this recall in place should have allowed my daughter to reach a safer place than being stranding on the side of a busy hi-way. My car had this patch installed and I was assured that this recall would allow the car to be driven a safe distance and it would be obvious when this patch was active and the engine would be put in "Limp mode" This did not happen, the engine locked up
Engine, Apr 3, 2024
This is the 3rd time in 2 years my car shuts down while driving. The dash panel started flashing "WARNING CHECK CHARGING SYSTEM. DO NOT DRIVE" and an alert starts beeping and the car shuts off. THERE WAS NO OTHER PRIOR WARNING LEADING UP TO THIS. Why isn't there any warning BEFORE it gets to this? This is an accident waiting to happen. Do you know how many accidents would happen if every car just shut off like that because of some faulty charging system. Any other car would have warned you before hand. It's by the grace of God I was not slammed into while crossing a busy street and this damn car shut off leaving me right in harms way with cross traffic. AND another time it shut off on a busy highway. COMPLETELY DEAD. No functioning hazards. It's not right. This last time, The dealership told me there is a recall on the car for the safety plug and that was replaced. I was also told I needed a new battery and new power relay assembly. Those parts are related to the safety plug and the operation of the charging system. Why are those parts not also part of the recall? The dealership charges a diagnostic fee when they already know what the issue is. Must be nice. Everyone involved is building their own karma. I'm very displeased with this Brand. I will never buy another one and I will tell everyone I know hyundai does not stand by their product in making sure it's safe and operational. And they leave the consumer stuck with a bill that was their fault. FYI I had a prior complaint case with consumer affairs. (The mileage I stated was when it first happened. Now it's at 90k)
Engine, Mar 18, 2024
The contact owns a 2014 Hyundai Sonata. The contact stated that while at an intersection, the vehicle stalled. There was smoke coming from the engine compartment. The contact stated that several unknown warning lights were illuminated after the failure. The vehicle was towed to a tow lot, and the contact was informed that the failure was because the engine had seized. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 89,814.
Engine and engine cooling, Feb 29, 2024
The contact owns a 2014 Hyundai Sonata. The contact stated while driving approximately 15 MPH and slowing to enter the driveway, he heard an abnormal sound coming from the engine compartment. The contact stated that the sound was like a loud clicking sound and then the vehicle stalled. The contact stated that there were no warning lights illuminated. The contact shifted the vehicle into park(P) and attempted to restart the vehicle; however, the instrument cluster illuminated with several warning lights illuminated and the vehicle failed to start. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 17V226000 (Engine and Engine Cooling). The failure mileage was approximately 150,000.
Engine, Feb 26, 2024
This car burns oil at the rate of a quart every 300 miles.I have had it at the dealer several times and Hyundai has been no help at all. Their final recommendation was to replace the engine and I would have to pay for this repair.
Engine, Feb 22, 2024
Engine was loosing power and know dosent start at all
Electrical system, Service brakes, Engine, Jan 31, 2024
I am filing a complaint due to the lack of timely fix of this recall. It has been more than four months since the recall was issued (NHTSA Recall Number 23V651000) with no repair available.
Engine, Jan 29, 2024
I have a 2014 Hyundai Sonata that had its engine replaced as part of the recall. The car was taken to Hyundai of Central FL in January 2022 and repairs were completed in May 2022. Since that time the car has had several repairs that I feel are a cause of the faulty engine and or engine related to the replacement. These repairs include oxygen sensors both front and rear replaced, additional sensors, catalytic converter, transmission flush. Just in this month the car has been taken to Greenway Hyundai in Orlando weekly for a check engine light. The car was taken last week after the check engine light came on again and oxygen sensors needed to be replaced again. After the car was picked up last Wed, the check engine light on again and is currently sitting at Greenway Hyundai in Orlando for additional diagnostics. I may have to pay for diagnostic fee again and additional repairs again. So far, the repair costs exceed $3,000. The car displays show that it is one notch from overheating, runs a little sluggish, knocking noise at times and are experiencing similar issues when prior to when the engine was replaced initially back in May 2022. I am afraid of the car seizing up while I'm driving potentially causing an accident or fire as several consumers have noted the same. I have corresponded with Hyundai Corporate on several occasions asking for assistance as I quite frankly do not feel safe Hyundai or Kia vehicles. I had also asked for some type of assistance with my repair costs again that I feel are engine related otherwise why else would the check ENGINE light be displayed. In all instances Hyundai Corporate has simply skirted the greater issue and provided me with a staged response. Now I’m being told that possibly the injectors need to be replaced on a car whose engine was replaced less than 2 years ago. I’ve asked Hyundai several times to replace the car in like kind and quality because they are allowing a car to be unsafe to be operating .
Engine, Jan 27, 2024
Engine started making a weird knocking noise & was smoking from oil lid. Was driving & the noise got louder & then started to making a squealing noise. Started heading towards the dealership & it slowly started loosing power. Got to the turning lane to turn into the dealership parking lot, car immediately died in middle of road causing me to almost be hit by another vehicle . It started up long enough for me to make it into the parking lot. Car is now currently sitting at dealership waiting till Monday for Hyundai Service center to look at it. I originally had an appt scheduled for Tuesday to get it looked at but it didn’t last that long. speed limit was 35, I couldn’t even drive over 20 mph & had my emergency hazards on.
Engine, Jan 20, 2024
In May 2022 the engine was replaced as part of the Theta engine recall. Since that time the vehicle has been taken back to the authorized Hyundai dealership for oxygen sensors and a catalytic converter to be replaced. The check engine light is still on and out of pocket expenses are in excess of $3000 and growing. Hyundai corporate is refusing to cover any of these expenses stating that it is not engine related. In the meantime the car check engine is still on and by not taking responsibility for this has caused a safety issues as it is a known fact that their cars have a history of catching fire and I’m fearful that this may occur unless Hyundai takes responsibility and reimburses for these repairs and/or replace the car with one in like,kind and quality. It is my firm belief that Hyundai is well aware that when the engine was recalled it created issues with other parts such as oxygen sensors, catalytic converter , etc to fail and by not taking fiscal responsibility has created a safety issue for millions of Americans. I am begging the NHTSA at demanding Hyundai replace the vehicle and /or reimburse for additional expenses mentioned above as I am not the only American having to deal with Hyundai’s negligence. Simply saying it is not part of the warranty is not an inclusive defensive when millions of American lives are at stake.
Engine, Jan 19, 2024
As I was driving on the interstate, 25 or so miles away from, my car started to shake and the service lights appeared on the dashboard. I pulled to the shoulder of the road, and shut it off, i turned it back on and it ran for maybe about 10 more miles until it happened again. This time, I turn it back on to get it to run and it doesn’t even begin to shift into drive. It started making a grinding/knocking noise from the engine & shaking, so I shut it off. I had to get it towed home and it has just been sitting in the drive way for a couple weeks now because it’s undrivable. I had no knowledge prior to this incident of an engine recall issued on the car, the dealer I bought it from didn’t inform me and neither did my lien holder. I contacted Hyundai of Slidell and they said since these open safety recalls have not been addressed that they will just reject them. There are about 2 from before I even bought the car that were issued in 2017 I believe that have not been completed. I bought the car in October of 2021 and was not informed of these safety recalls. Prior to this incident, no warning service lights had appeared and I was never told that I need to get my engine inspected as it ran fine.
Engine, Dec 24, 2023
My engine is burning through oil and also smoking while driving and has a burn smell coming through air vent. I scheduled to have it repaired and have a screenshot of the recall but when I took it to get repaired they stated there are no recalls on my vehicle and I would have to pay. I then called Hyundai customer service and was told they see the recall in one system but not the other and that they will give me a call back. I then never received a call back so I called again and was told that they cannot fix the engine recall and that I would need to get a diagnostic and pay for it myself.
Engine, Dec 12, 2023, fire
With the 2014 Hyundai Sonata GLS off and onto a tow truck, it spontaneously burst into flames and the eventual total loss of the vehicle. The 2014 Hyundai Sonata GLS need to be added to the notice to Hyundai consumers in the Hyundai 251 recall.
Electrical system, Engine, Dec 11, 2023
The car warning lights turn on and the car shuts down. The problem is with the Hybrid battery that is malfunctioning. This is a serious life and death problem. After the vehicle stops it goes in neutral and rolls .
Engine, Dec 7, 2023
UNKNOWN: my wife took the car to go to the store by our apartment. She was going through a roundabout at 10 maybe 7 mph when the car just shut off. We took it to AAA. AAA told us that it was an engine failure, and that there was an engine recall on our vehicle. We still thought it was the Ater. We took it to a shop called Gulich. They saw the engine factory recall and informed Chapman Hyundai in Scottsdale to repair the vehicle. Spoke with a Nick who told us that he would give us a free loaner as they fix our vehicle, and that it was under the recall. Got a call two days later from Nick stating that there was sludge in the car and it was from the previous owner, that is why they’re not fixing it. The previous owner only had the car for two years as we receive the car in 2016 with 36,000 miles on it. Every oil change, tuneup, air conditioning, etc., we were told that the car was a queen puff, and that there should be nothing wrong with it. This is just an unfortunate misunderstanding, I would like to have my car fixed they are pressing me to return the loaner and my wife is in the hospital. Trying to leave me stranded. Please help .
Power train, Service brakes, Engine, Nov 11, 2023, crash
Incident date 07/04/2023 Incident place I-405 exit WA-522 Incident total engine, car system completely off, brakes won't work Traveling with whole family complete car system failure, had to drive to side road hitting bushes and trees in order to get the car stopped State patrol arrived at the scene, assisted getting towing Everything turned off while on freeway to direction to the two/three lane bridge had to quickly take any exit in order to avoid the freeway bridge I repeat again Total Engine & System failure, Brakes won't work at all while system is dead
Engine, Oct 25, 2023
The contact owns a 2014 Hyundai Sonata. The contact stated that while the vehicle was at an independent mechanic for an oil change, the contact was informed that the engine oil level was low and there were metal shavings in the engine oil. The independent mechanic referred the contact to the dealer for assistance. The vehicle was taken to the dealer, where a second oil change was performed. The dealer also performed three oil consumption tests every 1,000 miles. In the first oil consumption test, the engine oil level was 2 1/2 quarts less. In the second oil consumption test, the engine oil level was 1 quart lower, and in the third oil consumption test, the engine oil level was 1 1/2 quart lower. The dealer informed the contact to return for the fourth oil consumption test after another 1,000 miles. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 17V226000 (Engine and Engine Cooling); however, the failure recurred. The failure mileage was approximately 110,000.
Engine, Firerelated, Oct 3, 2023, fire
The contact owned a 2014 Hyundai Sonata. The contact stated that while in an undisclosed store, she was notified by the store P.A. giving a description that her vehicle was on fire. The contact stated that after she exited the store, she noticed that her vehicle was inflamed from the front end of the vehicle to the rear of the vehicle. No injuries were sustained. No medical attention was required. The fire department was notified, and the fire was extinguished. The contact stated that she was informed by the fire department that the origin of the fire was engine-related. A police and fire report was filed. The vehicle was towed to a tow lot and deemed a total loss by the insurance company. Additionally, the contact stated that a year ago she had received the NHTSA Campaign Number: 17V226000 (Engine and Engine Cooling). The contact stated that the vehicle was taken to the dealer where the engine was replaced, and the recall was completed. The dealer nor the manufacturer were notified of the failure. The failure mileage was unavailable.
Power train, Electrical system, Engine, Sep 2, 2023
Lost power to vehicle while driving on the freeway, hybrid system warning was displayed as well as several lights to include engine, brake, and skid control. Had the dealer replace the knock sensor, 3 months later the exact same thing happened, in the same way. All the same obd2 codes were pulled both times.
Other or unspecified, Engine, Fuel/propulsion system, Jul 29, 2023
o2 sensors
Engine, Jul 19, 2023, crash, fire
The contact owned a 2014 Hyundai Sonata. The contact stated while driving 70 MPH, the contact noticed smoke coming from the front and the rear of the vehicle followed by flames. The contact was not able to stop the vehicle and had to jump out to exit. The vehicle drove off to the side of the road where it came to a complete stop and burned bushes that were on the side of the road. The fire department was able to extinguish the fire. A police report was filed. The contact suffered a fractured left arm and bruising on the left rib which required medical attention. The vehicle was towed to the contact's home and was deemed totally destroyed by the insurance company. The contact stated that the engine of the vehicle was replaced due to a recall under the VIN. The manufacturer was not notified of the failure. The failure mileage was 119.000. The VIN was not available.
Engine and engine cooling, Engine, Jul 17, 2023
The contact owns a 2014 Hyundai Sonata Hybrid. The contact stated while driving 60 MPH, the coolant temperature warning light illuminated, and the vehicle began to stall. The contact veered to the side of the road and noticed smoke coming from under the hood. The contact opened the hood and noticed a significant amount of smoke. The vehicle was towed to the Subaru dealer it was purchased from. The Subaru dealer diagnosed that the engine was blown and needed to be replaced. The vehicle was towed to the local Hyundai dealer and the diagnosis was confirmed. The vehicle was not repaired. The contact stated that she had received a class-action lawsuit settlement notice related to the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.