2015 Hyundai Sonata
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,144 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Sonata model years with reports.
Of the 2015 reports, 34 involved a crash and 48 involved a fire. 32 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Exterior lighting, turn signalSep 24, 2021
Hyundai Motor America (Hyundai) is recalling certain 2015-2017 Sonata, 2016-2017 Sonata Hybrid, and Sonata Plug-In Hybrid vehicles. The Smart Junction Box (SJB) software logic may not properly interpret the signals received from the multifunction switch, which could cause the turn signal to activate in the opposite direction of what the driver intended.
A turn signal that activates in the opposite direction of what was intended by the driver increases the risk of a crash.
Dealers will update the SJB software, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 210.
Campaign 21V749000 on NHTSA.gov
Parking brake, indicator lightJun 5, 2017
Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Sonata and Genesis vehicles. In the affected vehicles, the warning light to indicate that the parking brake is applied may intermittently not illuminate in the dash due to corrosion in the switch.
If the parking brake indicator is not illuminated when the parking brake is applied, the driver may operate the vehicle with the parking brake partially engaged, increasing the risk of a crash.
Hyundai will notify owners, and dealers will replace the parking brake switch, free of charge. The recall began on August 4, 2017. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 164.
Campaign 17V359000 on NHTSA.gov
Visibility, sun/moon roof assemblyOct 11, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2015-2016 Sonata Hybrid vehicles manufactured December 8, 2014, to August 18, 2015, and Hyundai Sonata vehicles manufactured May 28, 2014, to March 18, 2016, equipped with the panoramic sunroof option. Due to a bonding issue with the sunroof wind deflector, the sunroof panel on the affected vehicles may detach while driving.
If the sunroof detaches from the vehicle it could become a road hazard, increasing the risk of a crash.
Hyundai will notify owners, and dealers will repair the wind deflector anchor plate, free of charge. The recall began December 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 152.
Campaign 16V726000 on NHTSA.gov
Air bags, frontalApr 21, 2016
Hyundai Motor Company (Hyundai) is recalling certain model year 2015-2016 Sonata vehicles manufactured May 29, 2014 to February 11, 2016, 2017 Elantra vehicles manufactured January 12, 2016 to February 22, 2016, and one 2016 Sonata Hybrid vehicle manufactured October 15, 2015. In these vehicles, the driver's frontal air bag may be missing a chemical enhancer required for the second stage air bag deployment, resulting in the second stage not deploying in certain crashes. The primary stage will deploy as intended.
An air bag that does not inflate increases the risk of injury.
Hyundai will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began on May 5,2016. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 144.
Campaign 16V232000 on NHTSA.gov
Electrical system, instrument cluster/panelOct 20, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2015-2016 Sonata vehicles manufactured May 28, 2014, to August 21, 2015. The affected vehicles are equipped with an Antilock Braking System (ABS) warning light intended to warn the driver if there is an ABS malfunction. In the event of an ABS malfunction, the Brake System warning light will illuminate, but the ABS warning light will not illuminate. Since the vehicles have ABS malfunction lights that do not illuminate, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
If the driver is alerted there is a brake system malfunction, but not specifically with the ABS system, the driver may operate the vehicle unaware that the vehicle's brakes may lock up during hard braking, increasing the risk of a crash.
Hyundai will notify owners, and dealers will update the ABS control unit software, free of charge. The recall is expected began on November 30, 2015. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 134.
Campaign 15V678000 on NHTSA.gov
Seat belts, front, buckle assemblyJun 30, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2015 Sonata vehicles manufactured April 25, 2014, to December 4, 2014. The affected vehicles have a front passenger seat belt whose buckle latch assembly may prevent the front passenger from fastening the seat belt.
If the front passenger seat belt cannot be latched, an occupant sitting in the front passenger seat has an increased risk of injury in the event of a crash.
Hyundai will notify owners, and dealers will repair or replace the front passenger seat belt buckle, free of charge. The recall began on September 15, 2015. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 130.
Campaign 15V414000 on NHTSA.gov
Power train, axle assembly, axle shaftDec 9, 2014
Hyundai Motor America (Hyundai) is recalling certain 1.6 liter model year 2015 Sonata vehicles manufactured August 29, 2014, to October 28, 2014. The affected vehicles may have been assembled with an incorrect left axle shaft which may result in the shaft separating from the transaxle differential.
If the left axle shaft separates from the transaxle, the vehicle may stop moving, increasing the risk of a crash. Additionally, a separated axle shaft may allow the vehicle to roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Hyundai will notify owners, dealers will inspect and replace the axle shaft, as necessary, free of charge. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 126.
Campaign 14V784000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperDo not drive until repairedJun 24, 2014
Hyundai Motor Company (Hyundai) is recalling certain model year 2015 Sonata vehicles manufactured April 25, 2014, through June 16, 2014. Due to a manufacturing error, one or both of the front brake calipers may fracture.
If a brake caliper fractures, brake effectiveness would be reduced, lengthening to distance required to stop the vehicle, increasing the risk of a crash.
Hyundai contacted the affected owners on June 19, 2014 and instructed them not to drive their vehicles. Hyundai dealers will replace the affected brake calipers, free of charge. The recall began on September 12, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 120.
Campaign 14V368000 on NHTSA.gov
SteeringDo not drive until repairedJun 12, 2014
Hyundai Motor Company (Hyundai) is recalling certain model year 2015 Sonata vehicles manufactured May 2, 2014, through May 23, 2014. A poor connection within the vehicle's wiring harness may result in a reduction of steering assist from the vehicle's motor driven power steering system or the inability to move the vehicle's shifter from the Park position.
The reduction of power steering assist can increase the steering effort needed, increasing the risk of a crash.
Hyundai notified dealers to suspend sales of affected Sonata vehicles and has published recall bulletin 14-01-024 providing a service procedure to repair the affected vehicles. On June 7, 2014 Hyundai began to contact the affected retail customers. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 119.
Campaign 14V325000 on NHTSA.gov
Representative owner complaints: engine
642 reports, newest first. Show all
Engine, Sep 23, 2025
Vehicle lost power leaving me stranded. All lights on dash came on, lost power, and barely able to steer to get off the road. We had to have it towed. The vehicle was towed to our mechanic, who states the motor seized up. Mechanic states there is no repair for this issue. Car has just been paid off. Now we have nothing!
Engine, Sep 22, 2025
I started taking my car to the dealer in 2023 for engine problems, including high oil consumption and stalling. The dealer kept telling me to return in 1,000 miles instead of fixing it. The issue was officially documented again in March 2024 (RO #131797) with ‘Cause: high oil consumption.’ Despite paying \$356.46 for repairs, the problem was never resolved and now the engine has failed
Electrical system, Vehicle speed control, Engine, Sep 22, 2025
The engine light started to come on and go off and when I got the codes ran, it said something along the line of misfire. I had the spark plugs changed and I kept regular maintenance done on oil changes and tune ups. Now my engine is knocking and the vehicle is in limp mode.
Engine, Sep 16, 2025
Dear NHTSA Investigations Team, We are the owners of a 2015 Hyundai Sonata, purchased in 2016 and still in use today. This vehicle is suffering from severe engine issues linked to the Theta II engine defect, which has been the subject of recalls and class action lawsuits. For nearly a year, we have been forced to add approximately 2 quarts of oil every week due to extreme oil consumption. This is unsustainable, unsafe, and clearly linked to the known recall defect. The most serious incident occurred when my wife was driving on [XXX] in North Carolina, and the vehicle suddenly lost power. It could not maintain safe highway speed and had to be pulled off the interstate, requiring a tow more than an hour back to our home. This was a frightening event that could easily have caused a crash. We later discovered that our vehicle was included in the Theta II engine recall, but we never received notice due to a change of address. Despite this, Hyundai Motor America has refused to help, citing that the recall was “closed.” Shockingly, one representative even told us to “keep putting oil in it until the engine blows,” at which point they might reconsider. This is an unsafe and negligent response to a well-documented safety defect. To make matters worse, when reviewing our VIN for other recalls, we found that the panoramic roof air dam recall was falsely listed as “repaired.” We never received notification of that recall, and the repair was never performed. The air dam detached years ago, and we have avoided using the sunroof since then due to noise and safety concerns. We have contacted Hyundai corporate multiple times, and we also filed a formal complaint with the North Carolina Attorney General’s office. To date, we have received no resolution and no meaningful response to our case from either Hyundai or their representatives. Summary of Issues: 1. Failure to notify us of the Theta II engine defect recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Sep 9, 2025
The contact owns a 2015 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle failed to accelerate above 10 MPH. The vehicle was driven to the shoulder of the road. In addition, the check engine warning light was illuminated. The vehicle was towed to the dealer, where it was diagnosed with a failed knock sensor. The contact was informed that the engine needed to be cleaned. The vehicle was not repaired. The contact referenced an unknown extended warranty for the knock sensor; however, the contact was informed that the repair was not covered under warranty or recall. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 103,500.
Engine, Aug 30, 2025
P1326
Engine, Fuel/propulsion system, Aug 19, 2025, fire
I had a standard oil change done on my car and it was running fine afterwards. Later that evening, my car started smoking and spontaneously burst into flames from the hood. The fire originated in the hood of the car and melted the entire front of my car as well as the entire inside. It burned a lot of fuel and oil, which leaked onto the ground and continued burning on the ground. My car was overtaken by flames in a matter of a few minutes. It burned so fast that there was nothing I could do to stop it. I was not aware of anything wrong with my engine or fuel lines, or anything like that. However, something was very wrong for the engine area to catch fire like that spontaneously.
Engine and engine cooling, Aug 19, 2025
The contact owns a 2015 Hyundai Sonata. The contact stated that she checked the engine oil every Sunday and became aware that the oil level was low. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact was adding one quart of engine oil every ten days. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 84,000.
Electrical system, Other or unspecified, Engine, Aug 11, 2025
I have contacted the guy that sold me the car he Refused to fix the recall which is my motor I need Something done , Hyundai won’t Honor their Recall .
Engine, Aug 5, 2025, fire
My car 2015 (Hyundai Sonata)started leaking oil, it only had 50,000 miles. my mechanic said the motor had too much pressure and kept pushing oil out. He advised me to take it to the dealership for a motor recall. The dealership gave it back with a list of things to fix. replaced the valve cover gasket but still leaked oil. I found out these cars have an oil leak problems that are not being addressed. My car went up in flames 2 weeks later. I have done everything I could to save this car but nothing saved it. My grandkids were in the car and it had traumatized them.
Engine, Aug 2, 2025
I bought this sonata one month ago. Driving down [XXX] in bonita springs Fla the car shut down. No noise all dash lights came on I got to a safe place. Sat in the parking lot of fresh market for at least 30 minutes went to start it and nothing happened. No crank nothing. AAA came towed it to my house. The filling day I checked the battery it is good. So had it towed to Scotty’s automotive. They called me Friday morning and said the motor was locked up. According to Carfax the car was at brand ton Hyundai in May of 25. I called after I bought the car Carfax said they found the alignment was off. I called to see if they did the alignment they said they did not do it. The wholesale it. My thinking is they did service it according to Carfax report and knew there was signs something and wholesale it. I did not buy it from Brandon Hyundai I bought it from a guy in Leigh acres Fla. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Jul 30, 2025
We were informed by our mechanic that the engine needed replacement due to a timing chain issue. The engine warning light was blinking continuously, and the RPM would not rise above 1.9 even under acceleration. Upon further inspection, the mechanic found that the issue extended beyond the timing chain - the entire engine appeared to be failing. When we changed the engine oil, it became dirty almost immediately, and visible metal shavings were present in the oil, indicating internal damage. These symptoms suggest potential engine failure, which is consistent with known issues in some Hyundai Sonata models. We believe this may be related to broader engine defects and request that this be investigated for potential recall eligibility.
Engine, Jul 23, 2025
Using 5 quarts of oil in 3 days.
Engine, Jul 18, 2025
The car was on a major highway, went to pass another car and the engine stopped working. While trying to get the car off the road there was almost an accident involving on coming traffic.
Service brakes, Engine, Jul 11, 2025
The turning signal gives the opposite signals sometimes.
Engine, Jun 27, 2025
The car burns oil. I have to put oil in it every few weeks. Also will start shaking while acceleration. I replaced engine coils several times. Main issue is burning oil, don't know why.
Power train, Other or unspecified, Engine, Jun 26, 2025
Our 2015 Sonata has experiencing Engine failure several times due to excessive and irregular oil consumption. Our family’s safety and the safety of others on the roadway were put at risk as the engine slows, shudders and stalls without prior warning and the check engine light does not come on until the vehicle slows and stalls. The vehicle was inspected at a local Hyundai dealership, and they indicated that this is not covered under warranty. Summary of Engine Issues and Failures: 1.May 3, 2022 – 68,671 miles (local Hyundai dealer) Check engine light on, shudder; oil change performed. No cause identified. Paid out-of-pocket. 2.August 23, 2022 – 75,527 miles (retail shop) Car engines failed on highway, towed to service shop. Valve cover gaskets replaced. Paid out-of-pocket in part and extended warranty paid part of the invoice. 3.April 29, 2024 – 109,229 miles (local Hyundai dealer) Excessive oil consumption noted; valve cover gasket replaced again. Paid out-of-pocket. 4.January 22, 2025 – 118,341 miles (local Hyundai dealer) Vehicle stalled en route to airport, towed to dealership; dealership advised oil change. Paid out-of-pocket. 5.May 20, 2025 – 122,000 miles (local Hyundai dealer) Engine codes P0300, P0302, P0303 identified. Dealer diagnosed excessive oil consumption likely due to ring wear or sticking rings, contributing to spark plug misfires. Recommendation: Engine replacement. Despite consistent and timely service, including multiple visits to the Hyundai dealership, the root issue has not been properly addressed. The current diagnosis of internal engine failure is a clear continuation of a pattern of unresolved engine problems (stalling in motion, oil leaks and oil consumption) all of which originated well within Hyundai’s original warranty. The vehicle has been well maintained, and all recalls have been addressed in a timely manner. Hyundai’s failure to acknowledge and take responsibility for this widely documented engine issue is a safety concern.
Electrical system, Service brakes, Engine, Jun 20, 2025
The car has had an electrical issue ever since taking to to get a recall around may of 2023. It will randomly brake and shift the transmission badly while downshifting. I feel as if my make and model falls under the theta II campaign they had to replace certain engines for having a knocking rod be fault and release shaving into the engine causing it to misfire. Not only that but the electrical issue is completely random it happens atleast once or twice a week. It had began ever since I took it for a recall, and when I took it back they found no issue and left food in the back of my car and the chairs leaned back. This was the Fontana Hyundai dealership
Engine and engine cooling, Jun 6, 2025, fire
The contact owned a 2015 Hyundai Sonata. The contact stated that after the daughter reached the destination and parked the vehicle, a popping noise suddenly occurred from the engine compartment. After exiting the vehicle, flames were present coming from under the engine hood. The fire department was called to the scene and extinguished the flames. The vehicle was later towed to an impound lot. During the incident, the vehicle was destroyed. The cause of the failure was not determined. No injuries were reported. The local dealer was notified of the failure. The manufacturer was not contacted. The contact indicated that the engine had been previously replaced as part of a recall repair. The failure mileage was 155,000.
Seat belts, Engine, May 8, 2025
Multifunction box is in the steering column that controls your lights, signals, I put my turn signal on right or left at night and my lights go out,but they come back on.also I have zero warning lights on my dashboard for when something happens it let's you know,well I have none. Hyundai of California says it's not unsafe.it should be a recall because it's a thousand dollars for update..
Engine, May 5, 2025
I've been in communication with Hyundai Henderson, Nevada and Hyundai Corporate as result of engine problems with my 2015 Hyundai Sonata. Corporate instructed Hyundai Henderson to submit a "Goodwill Warranty Repair order. However Hyundai Henderson, who has already determined that the vehicle has total engine failure, is requiring that I complete the thousand mile oil consumption test. My car has already proven to be unable to drive a couple hundred miles before losing acceleration. This is a huge safety issue to ask a consumer to drive this vehicle or to put this vehicle on the road as it is. Please advise on how I may move forward with Hyundai Henderson and Hyundai Corporate. * I have my entire battery/oil/repair/tire history - will scan and submit if needed/ upon request - unable to attach here. Sincerely, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Apr 28, 2025
I was driving down the road the engine started making a loud knocking noise and as I pulled over it lost power and shut down it would not crank back up I had to have it towed to my house. There was no warning sign.
Other or unspecified, Engine, Apr 26, 2025
The car just stopped while driving.
Engine and engine cooling, Apr 21, 2025
The contact owns a 2015 Hyundai Sonata. The contact stated that while operating the vehicle, the check engine warning light illuminated, and the vehicle was shaking and vibrating abnormally. Additionally, the vehicle failed to accelerate above 40 MPH. The cause of the failure was not yet determined, and the vehicle was not yet repaired. The manufacturer and local dealer were not yet notified of the failure. The failure mileage was 136,000.
Engine, Apr 21, 2025
As we were driving on the highway at 65 mph, the car completely cut off. Fortunately, we were able to immediately steer it off the road to avoid an accident. We had it towed and the mechanic at the auto repair shop said the engine was completely shot. He advised us to have it towed to a Hyundai dealership because he had seen this same situation with other Hyundais with limited mileage and said there may be a safety recall or a class action lawsuit. My car has 60,000 miles and is well maintained.