2017 Hyundai Tucson
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,086 owner complaints filed for this model year. This is the 2nd highest complaint count among 21 Tucson model years with reports.
Of the 2017 reports, 13 involved a crash and 26 involved a fire. 14 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EngineSep 17, 2021
Hyundai Motor America (Hyundai) is recalling certain 2017 Tucson and Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which can result in engine damage.
A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.
Dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. Owners were notified of the defect on November 16, 2021. Owner notification letters were mailed January 15, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 209.
Campaign 21V727000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideSep 4, 2020
Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire.
An engine compartment fire can increase the risk of injury or crash.
Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.
Campaign 20V543000 on NHTSA.gov
Electrical system, wiringNov 21, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Campaign 16V842000 on NHTSA.gov
Representative owner complaints: engine
610 reports, newest first. Show all
Vehicle speed control, Engine, Nov 27, 2023
The car does not accelerate from a stopped position and when driving it does not shift or allow acceleration. This is especially an issue on hills or when trying to increase speed on the highway.
Power train, Other or unspecified, Engine, Nov 9, 2023
When I'm stopped at a light and go to push on the gas, the vehicle doesn't move, then all of a sudden it just takes off. Next the exterior driver side door handle doesn't open I have to pull on it a few times then it opens, there's like a delay. There are tones of complaints online about this, it's like the 2017 model's were just looked over when it came to SAFETY. My car only has 70K. Thank you.
Power train, Engine, Nov 9, 2023
Cracked cylinder wall in engine, after major oil consumption issues, complaints filed with dealership, corporate offices, did oil consumption tests and further hyundai corporate recommended an engine clean out which helped for a while however last year they had to replace my catalytic converter because it was "clogged", but still maintain that it didn't have to do with the oil consumption issue. No warning lights came on engine just wouldnt accelerate properly when pulling out in traffic, made noises and would not perform as it should. I have all service records pertaining to this vehicle since we have owned it. Dealership is wanting us to pay 8k for repairs because hyundai says its not covered under the recall .
Engine, Nov 8, 2023
Engine light came on and then went off twice so I checked the dipstick and there was no oil on it. So went to Express Oil Change and they ended up performing oil change- but there was none in it. Car could have stalled. Yes. I have to keep going to having oil added to keep the car running. There isn’t a leak anywhere, yet the oil level keeps dropping. I took to a Hyundai dealership and they told me they would perform oil consumption test but then called the next day (after I left my car there) and said they would not do it because I am the second owner. No. Yes. Engine light came on but when back off two times within the same hour which prompted me to check the oil.
Engine, Nov 8, 2023
I am having to add oil on a weekly bases. My vehicle makes sudden jerks and acts as it may shut off even while driving. constantly.
Engine, Nov 1, 2023
The contact owns a 2017 Hyundai Tucson. The contact stated that while driving at highway speeds, an abnormal knocking sound was coming from the vehicle with the vehicle hesitating upon depression of the accelerator pedal. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where a code reader determined there was a defect in engine cylinder #2. The contact had the coil pack and spark plugs replaced. Several weeks later, the failure returned, and the vehicle was taken to a second independent mechanic. The mechanic determined that the engine bolts on the manifold and the turbo charger had blown. The contact was informed that a further diagnostic test was needed to determine the extent of the damage to the engine. The manufacturer was notified of the failure and the contact was referred to a local dealer. The vehicle was taken to a dealer where the mechanic confirmed the failure and informed the contact that the engine needed to be replaced. The vehicle was not repaired. The failure mileage was approximately 82,000.
Engine, Oct 30, 2023
The contact owns a 2017 Hyundai Tucson. The contact stated there was an abnormal sound coming from the vehicle during start-up. The contact stated while driving 40 MPH, the vehicle hesitated while attempting to accelerate. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the failure was due to severe damage to the rod bearings. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 63,000.
Engine, Oct 26, 2023
Since I was notified of this recall on November 16, 2021, I have diligently followed the instructions provided, and my vehicle has been taken to a Hyundai service center for inspection and necessary repairs. However, I am deeply disappointed and concerned that despite the recall and subsequent corrective actions, my vehicle has continued to experience persistent issues related to the engine. I have experienced several engine problems, including repeated transmission replacements (twice) and dual-clutch replacements (three times), which have had a significant impact on the overall performance and safety of my vehicle. The frequency of these issues and the potential consequences, including engine stalling and increased risk of accidents, are alarming. I understand that Hyundai has taken measures to address the recall issue, but it appears that the corrective actions have not resolved the problem in my vehicle. Given the seriousness of the engine-related concerns outlined in the recall, I strongly believe that my vehicle's issues should be thoroughly investigated, and the necessary steps should be taken to ensure my safety and reliability.
Other or unspecified, Engine, Oct 23, 2023
THE CAR STARTED TO HAVE PROBLEMS WITH ACCELERATION DO NOT ACCELERATE MORE THAN 60 miles per hour and turned on the signal the engine and to get to 60 mph it goes slow little by little without strength since it only reaches 2000 rpm it does not go higher than there. In addition, all the lights on the blackboard came on, which means that I can't tell if there is something wrong with the car or not because everything is on. The proximity sensors don't work, and I get the code for engine is P1326 and the anti-Lock Brake System the computer show the code C1211-02, C1207-02, C1210-02, C1208-02 Y C1209-01.I took it to the Hyundai agency in Miami Lake where I bought it and where they told me that the car had 10 years or 100,000 miles of warranty and when I arrived the person who received me without passing the car to diagnosis or anything told me that repair costs you $700,00 and tells me that to my warranty covers the engine, the engine has to be completely damaged; I explained to her the engine was in bad shape that it was better to do the repair than to change an entire engine if it was still being used, but she was still in the same negative until she left. I need to make this report because I didn't have any help from the Hyundai that sold me the car and which is still under a factory warranty. I consider this a violation and abuse of consumer rights by deceiving the American people with a guarantee that they then do not want to fulfill
Engine, Oct 11, 2023
I had my engine replaced in match 2023 due to stalled vehicle. After several trips to hyundai. Now just 6 months later and as off present my check engine light is back on . I took my car in to get the immobilizer installed from another recall. The dealership is giving me run around. I am confused why if they replaced my engine with a new one why do I have the check engine on again just some time later. I keep all maintenance up on my vehicle. Additionally now my heat is not blowing hot it's blowing cool and consuming large sum of anti freeze. I have yet another appointment with dealership and have to leave my truck they don't have any loamers available so I have to figure out how to get to work and my son to school on my own all while paying car note for a vehicle I've really lost trust in. Unfortunately because of the thefts and recalls my truck is more debt than value at this point
Engine, Oct 7, 2023
Near miss accidents due to engine failing as a way KT of rapid oil consumption. Occurred twice causing near miss accidents at high speeds on expressway. Vehicle is currently undergoing oil consumption tests with dealer
Engine, Oct 4, 2023
The 2017 Hyundai Tucson is unsafe to drive. Purchased the vehicle with 62000 miles and have had issues with the vehicle since shortly after purchase. Vehicle consumes oil at a rapid pace - in between 3000 mile oil changes additional oil is needing to be added within 600 miles, while driving the vehicle on the freeway at 70 miles an hour vehicle stalls and goes into limp mode - huge safety issue. Vehicle has been at Hyundai three times now - first time Hyundai covered all of the diagnostics and repairs, mainly electrical for the engine. Second time vehicle was stalling again and diagnosis was catalytic converter needed to be replaced, caused due to manufacturing error that is causing oil consumption - Hyundai would not cover, out of pocket cost $3600. A month later vehicle stalled and was going into limp mode again, check engine light on and flashing. Took to Hyundai again, now the diagnosis is engine needs to be replaced. Hyundai is denying replacement coverage, these engine failures are due to many manufacturing errors on the engine, I have a case open with Hyundai however they are highly unresponsive, dishonest, and continue to deny coverage for an engine replacement due to me being the second vehicle owner - the vehicle only has 83000 miles on it at this time and should be considered as a warranty coverage due to manufacturing errors in this engine and the low mileage along with the regular maintenance always maintained on the vehicle. Hyundai is also being dishonest about costs for an engine replacement, I have asked for quotes multiple times and have been unable to get any assistance or answers from Hyundai. Hyundai and any dealership getting these vehicles as trade ins are selling unsafe and defective vehicles, these defective engines need to be covered by Hyundai to provide safe roadways for all.
Engine, Oct 2, 2023
Car engine needs to be replaced. As soon as it hit 100k miles the turbo super charge something is faulty or defected. Smoke comes out the back pipe, car always jerked but now it’s not accelerating at all. We kept up with maintenance care such as oil changes. Hyundai will not cover because it’s over the 100k warranty
Engine, Sep 28, 2023
The contact owns a 2017 Hyundai Tucson. The contact stated that while starting and while driving the vehicle, there was an abnormal knocking sound coming from the vehicle. The check engine warning light was flashing. The vehicle was towed to the local dealer, where it was diagnosed that the spark plugs were dead, and the mechanic turned off the check engine warning light. The vehicle was repaired, but the failure recurred. The contact took possession of the vehicle, but after driving for approximately 90 miles, the check engine warning light started flashing. The contact stated that the engine continued knocking. The vehicle was taken back to the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 101,000.
Engine, Sep 27, 2023
Purchased the 2017 Hyundai Tucson used (2nd owner) with 62000 miles, before the vehicle was driven 10000 miles the vehicle stalled on the freeway, when it started back up wouldn’t go over 40 miles -took to the nearest dealership where they replaced the entire electrical mainframe for the engine, covered by Hyundai. Vehicle stalled again and check engine light came on around 81000 miles, took to the dealership again and they diagnosed as catalytic converter needed to be replaced - out of pocket expense. A month later check engine light on again, back at the Hyundai dealership and diagnosed as engine failure. Hyundai is trying not to cover the engine, currently have an active case with Hyundai due to engine manufacturing errors/problems and problems with oil consumption - we were supposed to start the oil consumption test right around when the engine failed too.
Engine, Sep 21, 2023
Vehicle stalled on highway without any warning. It was towed to the local dealership. After inspection, determined there was no oil even though the car has been maintained on a regular basis with oil changes. Dealer does not want to replace engine but instead do another oil consumption test which will put us at risk for another stall in the middle of the road.
Other or unspecified, Engine, Sep 20, 2023
Makes a noise and oil was low with no leaks
Engine, Sep 20, 2023
My 2017 Hyundai Tuscon excessively consumed oil. I took it into Hyundai of Kirkland. I was informed an Oil Consumption test would be completed by the Service Advisor, Chris Z. First I had my oil changed, then I was told to bring the car back in around 1000 miles. the first time I brought the car in, I was over 1000 miles. Chris informed me he would rather me bring the car back in under 1000 miles than over 1000 miles. DATEMILESOIL CHANGE OR ADDEDMILAGE DIFFERENCEPASS or Fail per TSB 8/4/2272645OIL CHANGE 9/6/22745691.15 QUARTS ADDED1924 MILES>1000 miles1,673 PASS 9/19/23754370.75 QUARTS ADDED868 MILES<1000 milesGuidelines not met. 10/7/23764401.25 QUARTS ADDED1003 MILES>1,000 miles802 FAIL 10/29/23773901.0 QUART ADDED950 MILES<1,000 milesGuidelines not met. 11/10/2277816OIL CHANGED/5 quartsN/A 1/16/2380564EMPTY2,748 Miles549.6 FAIL November 2022 Chris told me my car passed. January 2023 my engine failed to start. [XXX] TSB Guidelines were not followed per HMA TSB Guideline 21-EM-003H March 2021: "f) From this point, vehicle must accumulate at least 1,000 miles of driving prior to next steps." Driving Distance(miles) / Engine Oil Amount Added After Mileage Accumulation (Quart) =Oil Consumption Amount (Miles / Quart ) If the oil consumption amount is above 1,000 Miles/Quart, then vehicle passes the oil consumption inspection test and repair is complete. If the oil consumption amount is under 1,000 Miles/Quart, then replace the engine according applicable part number listed under the Part Information section of this TSB. For repairs covered under warranty, submit PA with the completed Engine Diagnostic Hyundai of Kirkland, WA Service Advisor failed to follow HMA guidelines outlined in the TSB. The service manager and even the GM were informed of this and they have failed to address the issue. Hyundai Consumer Affairs have been notified and they have failed to address. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Other or unspecified, Engine, Sep 20, 2023
We are getting a Knock sensor ERROR & Oil consumption issue. So last year I had a few recalls on my car, I took it to the dealer for then to do the updates. One of the recalls was the knock sensor. Also last year, the check engine light come on and Tires plus said it was my Knock sensor. Tires Plus cleared the code and it was fine until I had an oil change due this month I still had 3000 miles before it was due and the check engine light came on again, But this time I couldn't drive over 20 mph. I had to get it towed to a mechanic in Collegeville. His diagnostics was it was the knock sensor, He told me that Hyundai knows this is a problem but won’t fix it until it presents a problem. That being said The Collegeville Mechanic said its called a quiet recall. When I called Hyundai corp. recall center they told me that they don’t recognize quiet recalls. I had an appointment with the Springfield Hyundai Aug. 3, 2023 They would even look at it because the code was cleared but I called them first when it happened to get it towed there and they push the appointment back 3 weeks. I couldn't wait I need to get to work. I Also Recently 9/18/2023 Conicelli Hyundai and the guy told me when I got there that they have a whole lot full of Hyundai's that need Oil consumption test and would be able to look at my care un till March of 2024 That I have to take it back to where I bought it. Hyundai and Kia know of this issue but wont fix. WHY? I hope you can help me because I'm at a loss here and I have only had this car for 2 yrs I should be having this issue. I take good care if my car.
Engine, Sep 18, 2023
The contact owns a 2017 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that the vehicle was previously repaired under TSB: 21-01-073H (Engine). The vehicle was taken to an independent mechanic, who informed the contact that the engine was misfiring. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.
Power train, Engine, Fuel/propulsion system, Sep 15, 2023
When proceeding to move forward, the vehicle will sputter. Almost as if the vehicle is out of gas or not getting enough power to smoothly accelerate. This presents a very hazardous condition when leaving a red light or crossing an intersection. The vehicle jerks and sputters for about 2-4 seconds and then responds to the gas pedal and accelerates. Took it to the dealer and explained the problem and they said it's a known problem but there hasn't been a recommended fix and to drive the vehicle with the Turbo mode on. Even with Turbo mode on, the issue still persists.
Engine and engine cooling, Sep 13, 2023
Not to long after I purchased the car I have to put oil in the car every 4 to 5 weeks.Sometimes the motor sounds like it’s going to blow.The car slows down and sounds loud.Never once has a oil light turned on.When I checked the oil it doesn’t appear on the stick.
Engine, Sep 13, 2023
Engine was experiencing issues as described in the existing safety recall for 2017 Hyundai Tucsons (failed knock test at Hyundai dealer). Hyundai is only covering one half of the cost as they say it is not covered by the existing recall.
Engine, Sep 5, 2023
The contact owns a 2017 Hyundai Tucson. The contact stated that while driving approximately 40 MPH, the vehicle stalled but restarted. The check engine warning light was illuminated. While having an oil change at an independent mechanic, the contact was informed that the oil level was extremely low. The mechanic suggested to the contact to check the oil level regularly. The contact added approximately a 1/2 quart per month but had to add more oil over time. The vehicle was taken to the local dealer, where the spark plugs, and ignition coil were replaced. The dealer performed two oil consumption tests however, the failure persisted. The vehicle was not repaired. The vehicle was taken to an independent mechanic, who informed her that there was no compression in the engine. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 81,091.
Engine, Sep 4, 2023
6 Mar 2023 check engine light comes on. Took to my mechanic (they were closest to me) to put on machine to find out what the problem was; they state that it was the knock sensor and said to take it to the dealership and also let them know that it was down one quart of oil since the last oil change Jan 2023). Dealership took possession of vehicle on 8 March 23. Didn't begin repairs until 5 Apr. Then they state there was still noise from engine and found scoring on the cylinder walls and may be why it's consuming oil. Then they wanted oil change records. Finally, after providing records, "Hyundai approved replacement of engine". Legal battle ensued because they were charging for parts (lifters) that were no longer on my vehicle. Ended up having to pay for the full invoice after bullying and terroristic tactics only to have the check engine light come on again (picked up the evening of 15 Aug 23, CEL came on at 06:00 on 18 Aug 23). Eminent engine failure, limp mode and/or fire potential make me afraid to keep my vehicle but financially, I must keep it a while longer.