2018 Hyundai Tucson
Problems, recalls and owner-reported issues
Engine is the leading concern among 396 owner complaints filed for this model year. This is the 3rd highest complaint count among 21 Tucson model years with reports.
Of the 2018 reports, 13 involved a crash and 9 involved a fire. 10 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideSep 4, 2020
Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire.
An engine compartment fire can increase the risk of injury or crash.
Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.
Campaign 20V543000 on NHTSA.gov
Representative owner complaints: engine
249 reports, newest first. Show all
Engine, Feb 15, 2026
I am writing this letter to formally document a series of catastrophic safety failures and gross negligence regarding my 2018 Hyundai Tucson. On two separate occasions, including as recently as Wednesday, February 11, 2026, I narrowly escaped a fatal high-speed collision because this vehicle entered "Engine Protection Mode" while traveling at highway speeds. Incident Timeline: Previous Service: I have visited Courtesy Hyundai of Tampa twice for engine-related symptoms and code P0087. They replaced the knock sensor and assured me the vehicle was safe. Safety Incident (Feb 11, 2026): While driving on the highway, the vehicle suddenly lost power, dropping to 60mph and 2000 RPM (Limp Mode) in heavy traffic. This sudden deceleration nearly caused a high-speed rear-end collision. Current Status: The vehicle is currently at Brandon Hyundai (as of Feb 13, 2026). I have been told a review will take 3-5 business days, leaving me without safe transportation or a loaner vehicle. Negligence and Liability: Courtesy Hyundai of Tampa was aware of the recurring P0087 code and engine performance issues. By clearing codes or replacing minor sensors (knock sensor) without addressing the underlying high-pressure fuel or internal engine failure, they released a dangerous, defective product onto the road. This vehicle is clearly covered under the Theta II GDI Engine Settlement and Service Campaign 966. The local dealerships are willfully avoiding a necessary engine replacement to save on internal costs, despite knowing the vehicle is prone to sudden failure. Demand for Action: Immediate Loaner Vehicle: I require a safe rental/loaner vehicle immediately, paid for by Hyundai, while my car is being inspected. Full Engine Replacement: I am demanding a full engine replacement as previously indicated by technicians should the light return. Expedited Review: I am extremely unsatisfied to be told again I have to wait "3-5 business days" for a safety-critical evaluation of a vehicle that has alre
Engine, Feb 11, 2026
My 2018 Hyundai Tucson experienced sudden catastrophic engine failure when a connecting rod threw while driving. The engine burned through its oil and the vehicle became inoperable. Hyundai denied warranty coverage for this engine failure because I had not completed the 2021 KSDS (Knock Sensor Detection System) recall. I was never notified of this recall. The KSDS recall is a software update intended to detect engine knock. It does not prevent mechanical engine failure. Denying warranty coverage due to a software update that I was unaware of raises safety concerns, as engine failure can occur suddenly while driving and creates risk of crash or injury. This appears related to known engine issues in Hyundai vehicles. I am concerned this is a broader safety defect affecting other consumers.
Engine and engine cooling, Feb 11, 2026
The contact owns a 2018 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. The vehicle was pulled over to the shoulder lane, engine oil was added, and the contact waited for several minutes for the vehicle to return to normal operation. There was no warning light illuminated. The vehicle was taken to be diagnosed; however, the dealer was unable to determine the cause of the failure. The dealer suggested that the contact occasionally add oil to the vehicle. The vehicle was not repaired. The contact stated that while the accelerator pedal was depressed, there was an abnormal sound coming from the engine compartment. The vehicle was taken back to the dealer, where it was diagnosed, and it was determined that the catalytic converter needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic, where it was diagnosed, and it was determined that the catalytic converter needed to be replaced and that an oil change was needed. The vehicle was repaired; however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 99,400.
Steering, Electrical system, Engine, Feb 6, 2026
While driving on a public road, the vehicle experienced multiple simultaneous, dangerous malfunctions: Dashboard Warnings: All lights illuminated, including engine (flashing), ABS, traction control, airbag, TPMS, and parking brake, which stayed on though disengaged. Engine & Transmission: Tachometer fluctuated wildly in park; engine revved without accelerator input. Shifting to drive/reverse caused unexpected “kicks.” Vehicle sometimes failed to move when pressing gas, requiring engine restart. Driving Issues: Speedometer read 0 or jumped inconsistently. RPM continued erratically while maintaining speed without accelerator. Steering became extremely difficult. I immediately determined the vehicle was unsafe to drive and returned home with it, which was only a couple miles away. Follow-Up: Hyundai advised dealership diagnosis; they suggested a backup camera module will resolve the issues I experienced in entirety, but also in the same email stated that they could not guarantee it would resolve all of the issues I experienced. This is the second major engine/powertrain failure: first approximately ~70,000 miles (full engine replacement), current approximately ~95,000 miles (approximately ~25,000 miles post-replacement). Recurrence indicates a serious, unresolved safety defect. I am deeply concerned for passenger safety, including children. Other owners report similar issues; the attorney general’s office advised reporting to NHTSA. Summary of Safety Risks: sudden loss of control/power, erratic acceleration, dashboard failures, steering resistance, unpredictable handling, recurrence of major defect. I am submitting this report to NHTSA to request investigation of these recurring defects. I do have video documentation of all of this, as well as ALL written communication with Hyundai National Consumer Affairs and the dealership. I am having a hard time uploading them because of the file limits. Please let me know if any of this will be helpful to you.
Engine, Feb 5, 2026
Purchased 9/5/25 at 76,280 and oil change light shown by 10/1/25 when i received an oil change at Valvoline and was told of my engine issues at 77,733 miles. Car then looked at by Elizabeth Auto Sales [XXX] and confirmed oil consumption at no fault of my own and metal shavings in oil. Car then towed to #1 Cochran Hyundai Monroeville [XXX] and looked at by Dale. Oil change and oil consumption test started and confirmed of burning more than 1 qt per 1k miles. 2/4/2026 engine test cleaning requested and denied. Car stalls at random times can possible cause an accident. yes the problem was produced to the dealership purchased from which was Kenny Ross Subaru Irwin pa 15642. Yes the problem was confirmed by Hyundai on 11/7/25. Only warning was the oil change light flashing which forced me to get an oil change less than a month of purchasing on 10/1/25 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Jan 31, 2026
DRIVING ON FREEWAY NO WARNING LAMPS ON DASHBOARD. EXIT FREEWAY TO GET GAS AND THERE IS MINIMAL ENGINE PERFORMANCE AND CHECK ENGINE LIGHT ILLUMINATES. CYLINDERS ARE NOT FIRING, NO COMPRESSION. ENGINE FAILURE CONFIRMED BY HYUNDAI SERVICE DEPT AND INDEPENDENT MECHANIC.
Engine, Jan 28, 2026
My 2018 Hyundai Tucson experienced repeated no-start conditions. The vehicle was initially diagnosed by Randy Wise Hyundai in Flint, Michigan, and I paid approximately $776 for tune-up services that did not resolve the issue. Shortly afterward, the vehicle continued to fail to start. The dealership later determined the starter had failed and provided an estimate of approximately $985 for replacement. Hyundai Motor America denied goodwill assistance and reimbursement for the prior misdiagnosed repair and stated the starter replacement is customer-pay. The vehicle’s inability to start caused loss of reliable transportation and safety concerns due to being stranded. I am submitting this complaint to document starter failure and potential diagnostic issues affecting vehicle safety.
Engine, Jan 20, 2026
The car began making a knocking sound on my 5.8 mile drive. On my drive home from work, the knocking was louder, and the car barely accelerated on the highway and over-revved trying to hit at least 50 mph to keep up with the flow of traffic. I took the car to the Hyundai Service Center immediately using city streets rather than the highway. I had a family member follow me to make sure I made it to the service center as well as give me a ride home after I dropped off the vehicle. As I was driving there, the car had a hard time accelerating from a stop and barely maintaining speed of the flow of traffic and the “Check Engine” light came on and flashed as I got closer to the dealer service center. The dealer service center confirmed that the engine needs to be replaced due to the connecting rod bearing failure, a common issue with the 2.0L I4 F DOHC 16 V engine in my 2018 Hyundai Tucson. The Hyundai Service Manager has repeatedly confirmed that the engine issues presented in my car are consistent with a recall for the same model engine found in my car.
Engine, Jan 19, 2026
There is oil that leaks on a couple spark plugs.....when I remove the plug there is oil on the plug cover and inside where the plug goes in.........disturbing.....can you help....supposed to be a recall but I don't know what to do.....I would like to get that straightened out..... I want to keep it .....also like to buy my wife a new one......can you help on this problem.... They were supposed to fix recall..... Hundai Uniontown Pa. Can you help.... [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Vehicle speed control, Engine, Jan 14, 2026
The engine and engine management system of my 2018 Hyundai Tucson experienced repeated failures resulting in loss of propulsion and unsafe drivability. In November 2025, while traveling approximately 75 mph on a freeway, the vehicle suddenly entered limp mode without any prior warning, causing an abrupt loss of power in active highway traffic. No warning lamps or messages appeared before the failure. After the loss of propulsion occurred, the check engine light, battery light, and oil light illuminated sequentially. Diagnostic trouble codes P1326 and P0326 were recorded. Initial inspection indicated severe oil consumption despite a recent oil change less than 2,000 miles earlier. A Hyundai dealership replaced knock sensors under warranty. Shortly after release (30 miles), the vehicle again exhibited severe drivability issues, including a flashing check engine light, and required immediate towing. A second Hyundai dealership replaced the short engine block under warranty. Approximately 180 miles after the engine replacement, the vehicle again developed unsafe drivability symptoms, including delayed throttle response, failure to accelerate unless the accelerator was fully depressed multiple times, jerking or lugging when slowing or stopped, and a faint whining noise. The check engine light illuminated again. These failures represent repeated loss of propulsion and unsafe operation following manufacturer-approved repairs, including full engine replacement. The vehicle has been out of service for approximately 57 days and remains in the custody of a Hyundai dealership awaiting diagnostics. The vehicle is available for inspection upon request. The sudden and unpredictable loss of power at highway speed created a significant risk of collision and serious injury to the driver and surrounding motorists.
Engine, Jan 3, 2026
The engine is burning excessive oil. Down 3 quarts over approx. 3,000 miles. Mechanic verified there are no leaks - it is burning the oil.
Engine, Dec 18, 2025
My 2018 Hyundai Tucson has been experiencing oil consumption issues for over a year. It began at around 80k miles, when it should have been covered by warranty but they made me pay out of pocket for an oil consumption test only to ultimately recommend a top end cleaning, which I also paid for and it did not solve the problem. This is a known issue with Hyundai, and they have settled many lawsuits but have consistently denied any repair or solution for me. I am burning about 5 quarts of oil every week, and this is a problem they refuse to help solve.
Engine, Dec 11, 2025
Oil consumption, will change oil and within weeks i will be down 23 Quarts of oil
Engine, Dec 8, 2025
The engine on this vehicle burns oil quickly which is a known defect. I took the vehicle to the dealership and both times I was told everything was working fine. On 12/5/2025 the vehicle just lost power while driving. After getting the vehicle towed to a mechanic they said I needed a new engine.
Electrical system, Engine, Dec 3, 2025
My 2018 Hyundai Tucson experienced complete engine failure at around 118,000 miles. The motor suddenly blew without warning. This vehicle uses an engine type known for widespread engine defects, including bearing wear and internal failure. I bought the vehicle used in 2023, maintained it regularly, and there were no warning lights or overheating before the failure. I had to put oil in my vehicle every week. I had to use 5qts of oil. It smelled like fumes coming through the vents. It then stalled on the highway while we had our son in the vehicle and shaked profusely. Mind you we had our son in the vehicle. How unsafe is that. I then did my research and found out Hyundai engines of this generation have a history of stalling, seizing, and internal damage. I am filing this complaint because this appears to be part of a known safety defect that can cause sudden loss of power while driving. We took it to shop and confirmed the motor blew. It was faulty. Also, sometimes the electrical components would turn off in vehicle such as radio and would go black. Also the turn signal would be on and then turn off. It would also shake while driving. This needs to be taken care of ASAP as it almost caused danger to my family and also caused financial strain on my family too as I now had to roll over my vehicle loan into a new safe vehicle. I would like to be contacted in regards to this. Thank you.
Power train, Engine, Fuel/propulsion system, Nov 7, 2025
My car on the expressway wouldn't go over 40 and this was happening intermittently so my car was unsafe. No check engine light but it was just at the dealership for an oil change. Has. been an ongoing problem since I bought the car! Smells, gets hot!
Engine, Nov 5, 2025
The contact owns a 2018 Hyundai Tucson. The contact stated that while driving at various speeds, the vehicle almost stalled. The contact stated that the check engine warning light illuminated and was flashing off and on. The accelerator pedal was depressed; however, the vehicle failed to respond as needed. The contact pulled over to the side of the road, and the vehicle remained running. The contact waited for a while and then shifted to drive(D) and was unable to accelerate above 30 MPH. The contact stated that the failure was a recurring failure. The vehicle was taken to a Parts Store and was scanned, and DTC: P1326 was retrieved. The contact had not taken the vehicle to a dealer or to an independent mechanic. The vehicle was not diagnosed or repaired. The contact was no longer driving the vehicle. The manufacturer was not informed of the failure. The failure mileage was approximately 102,000.
Engine, Nov 5, 2025
Excessive oil consumption (failed 3 tests) now adding two quarts a week.... Transmission shifting issues (already had a replacement at 65,000 miles. Hesitation with acceleration. AWD and can barely make it up my driveway. Rpms rev when trying to go slow. Already needed a moonroof replaced because the motor died. USB randomly disconnects and reconnects for GPS.
Engine, Oct 28, 2025
Shortly after purchase, I had an oil change and vehicle inspection performed. I was informed that my engine may have an internal defect causing it to burn oil excessively. I later took the vehicle to a AAA-approved Hyundai service center, where they confirmed that the engine is burning oil due to a known manufacturer issue and that it is not the result of owner misuse or neglect. I have been quoted approximately $11,000 for a replacement engine, which is an extreme and unexpected cost for a recently purchased vehicle in otherwise good condition.
Service brakes, Engine, Oct 27, 2025
I purchased this car [XXX] as a CPO vehicle from a Ford dealership. By [XXX] the oil pressure light would flicker and it was clear the car was burning a lot of oil between changes. On 8/22 an oil change was completed at dealer. On [XXX] the oil pressure light flickered and it was three quarts down. An oil consumption test was started at 112,000. On Sat [XXX] while driving to dealer for oil check, the car began shuddering violently and the check engine light came on, and went into limp mode. I was on a dangerous mountain pass at the time and it could have been a major issue. The day before a tractor trailer had almost run me off the road, if my car had stalled then I might not be here. Hyundais have a known issue with oil burning and engine damage. Right now I am stuck in a 14K loan with a car that is unsafe to drive. I am not sure what the dealer plans to do, or what the diagnosis is, but its clear these engines are not safe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Oct 25, 2025
My 2018 Hyundai Tucson SEL PLUS limited showed a flashing check engine light on 10/14/2025 and basically gave up acerating pass 60mph while I was driving , I pulled over and called the dealership where I bought it from they told me to drive it in, I did and they did an oil change and filled up, we then began the oil consumption test which I brought it back yesterday 10/24/2025 and was told the whole engine needed to be replaced due to a major oil consumption problem, they advised me to bring it the Hyundai dealership to get it fixed they rudely told me no we can't fix this, we would have to wait for it to flash the check engine light again and it would have to fail a bearings test before it can be fixed and still have a possibly of it not fixing. only confirmed by the lot I bought it from since Hyundai refused to look at it.
Engine and engine cooling, Engine, Oct 24, 2025
The contact's sister owns a 2018 Hyundai Tucson. The contact stated that while his sister was driving at an undisclosed speed, the vehicle briefly jerked and jolted, prompting her to pull over to the shoulder of the roadway to turn off the vehicle. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed failures with all four fuel injectors and the injector assembly. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who then diagnosed a failure with the catalytic converter. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 78,563.
Engine, Oct 22, 2025
2018 Hyundai Tucson has excessive oil consumption. Burns multiple quarts of oil per 1000 miles. Hyundai refuses to remedy the oil consumption. Oil consumption has also led to having to replace the catalytic converter due to oil burn off.
Engine, Oct 22, 2025
My 2018 Hyundai Tucson 1.6 Turbo (VIN [XXX] , 113,000 miles) burns oil excessively and was deemed to need full engine and turbo replacement ($15,382.95). Hyundai refuses responsibility (case #XXX). This is a widespread defect that causes potential loss of power while driving. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Exterior lighting, Engine, Oct 1, 2025
I am filing a complaint under the NC Unfair and Deceptive Trade Practices Act (N.C. Gen. Stat. § 75-1.1) regarding Hyundai’s handling of my 2018 Hyundai Tucson (purchased new May 2018). Since 2019, the vehicle has had repeated headlight failures (at least 12 bulb replacements), persistent “bulb out” warnings, and eventually melted wiring requiring headlamp assembly replacement in 2025. These issues were first reported in April 2023 under warranty but dismissed as “could not duplicate.” Hyundai later attempted to deny coverage, only replacing the assembly after escalation to Corporate. At the April 2023 visit, I also reported a rear noise that Hyundai dismissed. After warranty expiration, it was attributed to a leaking shock. Shocks were covered under warranty; failure to act while coverage was active left me unprotected. In May 2023, the engine failed due to oil loss and lock-up. Hyundai retained my vehicle from 5/15–6/30/23 for engine replacement. From Aug–Sep 2025, the car was held an additional 24 days, with no permanent fix for the electrical defect. Overall, my Tucson has been out of service for 60+ days between 2023–2025. Examples of unfair/deceptive conduct: Dismissing documented defects under warranty, only acknowledging later after expiration. Attempting to shift labor costs onto me in Jan 2025 despite warranty obligations. Returning my vehicle with only ~39 miles of gas after requiring me to return a loaner full. Repeated misdiagnoses and delays despite video and documentation provided. These actions are deceptive and unfair, leaving me with an unsafe, unreliable vehicle and causing financial loss and hardship to my work as a self-employed pet sitter and dog groomer. I request the Attorney General investigate Hyundai’s conduct and enforce consumer protections under UDTPA. Service records, receipts, and communications are available upon request.