2021 Hyundai Tucson
Problems, recalls and owner-reported issues
Engine is the leading concern among 79 owner complaints filed for this model year. This is the 17th highest complaint count among 21 Tucson model years with reports.
Of the 2021 reports, 2 involved a crash and 3 involved a fire. 7 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideSep 4, 2020
Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire.
An engine compartment fire can increase the risk of injury or crash.
Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.
Campaign 20V543000 on NHTSA.gov
Representative owner complaints: engine
42 reports, newest first. Show all
Engine, Sep 23, 2026
I took my car in to Allen Samuals Hyundai dealership to have the 9C2 recall update completed on May 15th 2026. Ever since then my vehicle has had a rough hesitation or sputtering when driving. On May 18th Hyundai released a statement stating there was an issue with the update completed on the 9C2 campaign. However no resolution at the moment and to allow the car to warm up prior to driving it. I have only had my car for a little over 2 years and maintained everything a responsible car owner should. It only has 90k miles on it and had zero issues at all prior to the 9C2 campaign. I have spoke woth dealer and corporate numerous times nobody can give me a solution nor does it seem that anyone wants to. Since then the campaign has been closed and its almost as if it never existed. I do have an active case open with Hyundai 43228380 however they act as if they dont know anything about it. They are empathetic to the situation but can't really help or give a solution. All I want it my car that had zero issues prior to this update to run properly again. I dont even drive it much anymore for fear that it will mess my engine up.
Engine, Aug 29, 2026
Engine knock sensor went off and now the engine needs replacement due to faulty cylinder rod.
Engine and engine cooling, Power train, Aug 20, 2026
See attached document for complaint.
Engine, Aug 11, 2026
The contact owns a 2021 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the engine blew. No warning lights were illuminated. There was white smoke coming from the hood of the vehicle. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 7,800.
Engine, Jul 18, 2026
I was driving down [XXX] from my house.My engine light started to flash.I tried to accelerate my car barely went 10 miles an hour.I got Home 2 minutes later.There was major knocking.I had the car towed to [XXX], Hyundai, the only code that is showing up on the diagnostics, is P1326 there is an open class action lawsuit for this exact code. For the rod bearing failure, Hyundai is denying the claim, saying there's a gap in maintenance history on a car. I didn't own yet when I bought the vehicle. It passed a 190 point inspection. There's no way there was anything wrong with this vehicle.I am under fifty thousand miles , and if I was on the highway , it could've been deadly i could not accelerate. No other lights were on in the vehicle, except for the flashing engine light.I have already reported to the better business bureau and they have sent it to arbitration. I have contacted the escalation department for Hyundai.They opened up to separate cases.The agent that was assigned to me didn't even get the code from [XXX], they just denied the claim without it.I have the emails to prove that I had to give it to her. I have.\n All my maintenance history, but as you can see from the text message from XXX Hyundai, they are requesting maintenance for a car that wasn't in my possession yet. They're asking for dates from a year before I had the car, I bought it through EchoPark. I have everyone on my side including fFdelity , as I tried to go through Fidelity and they said they couldn't approve the warranty because of the class action lawsuit against Hyundai for that exact manufacturer malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Jul 10, 2026
The contact owns a 2021 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The check engine warning light was illuminated. The vehicle was driven to the shoulder of the road before being driven to the residence. The contact’s neighbor checked the oil level and informed the contact that the oil pan was empty. The oil level was topped off. The contact stated that the vehicle was not due for an oil change for another 200 miles. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was informed that there was no oil in the oil pan. The contact was informed to provide the vehicle service records. The contact stated that the failure was a manufacturer's failure. The manufacturer was made aware of the failure, and two cases were filed. The failure mileage was approximately 44,807.
Engine, Fuel/propulsion system, Jun 9, 2026
My car is burning oil. I have returned multiple times to have it serviced and checked for leaks, but no leaks have been found. Before reaching the recommended 3,000-mile oil change interval, the oil level drops below the minimum mark on the dipstick. In addition, my engine has started making a knocking noise, which is very concerning.
Electrical system, Engine, May 12, 2026
Vehicle stalled approximately 15 times between April 17 and May 4, 2026, including once on Interstate XXX at approximately 50mph with minor children ages [XXX] and [XXX] in the vehicle. The oil and battery lights illuminated simultaneously at each stall. Diagnosed as ABS module failure first, then left front wheel speed sensor failure on the 2nd occasion, both confirmed by a Hyundai dealership. Multiple warning lights illuminated, including check blind spot and anti lock brake system messages on the dashboard BUT no error codes following the 2nd repair. The vehicle has been inspected and repaired twice by the manufacturer’s dealership with a 3rd repair currently pending as of May 11, 2026. An open case has been filed with Hyundai Motor America regarding this issue. Issue remains unresolved and the vehicle is still at the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, May 7, 2026
2 years ago I had the engine replaced. Now on this new engine which has approximately 29k. The mechanic is telling me that I need a new engine. I called Hyundai and their telling me that is not under warranty anymore. What can be done?
Engine, May 4, 2026
My 2021 Hyundai Tucson has experienced repeated engine-related failures associated with a knock sensor (P1326) fault that causes the vehicle to enter limp mode and lose power while driving. This issue has occurred multiple times at approximately 15,000, 17,000, 41,000, and 90,000 miles and has resulted in four separate incidents requiring towing. During these events, the vehicle suddenly loses power and cannot maintain normal driving speed, creating a hazardous condition while in traffic. The vehicle has undergone multiple repair attempts, including an ECM update and three knock sensor replacements. Despite these repairs, the issue continues to recur and no root cause has been identified. Hyundai has not provided a permanent fix and has advised continued operation of the vehicle unless the issue occurs again. This ongoing condition presents a safety concern due to the risk of sudden loss of power while driving.
Engine, Mar 26, 2026
I already replaced 3 catalytic converters and I am at 31000 miles. They finally decided to do an oil consumption test but it passed. The other day my car started shaking and my ignition coil and spark plugs were also bad which somehow is related to my engine issues.
Engine and engine cooling, Mar 23, 2026
The contact owns a 2021 Hyundai Tucson. The contact stated that while driving at various speeds, the check engine warning light was frequently illuminated on the instrument panel. The contact had taken the vehicle to various independent mechanics and was informed that the engine was consuming an excessive amount of engine oil. The contact had taken the vehicle to a dealer for service, and upon inspection, the contact was informed that the engine needed to be replaced. The contact was provided with an estimate for the engine replacement. The manufacturer was notified of the failure but offered no assistance. The contact was initially informed that the vehicle was covered under warranty; however, the contact was later informed that there was no warranty on the vehicle. The vehicle was not yet repaired. The failure mileage was approximately 89,000.
Engine, Mar 13, 2026
While driving on the freeway, my 2021 Hyundai Tucson SE (72,021 miles) suddenly and without warning lost power and entered limp mode. I was able to safely maneuver to the shoulder and exit the freeway. The check engine light came on and is currently flashing. I took the vehicle to AutoZone where code P1326 was retrieved. I then took it to Pep Boys for a full diagnostic where P1326 was the only code present. The Pep Boys report states the vehicle requires immediate attention. The vehicle remains in limp mode and the check engine light is flashing. The vehicle is not being driven as it cannot safely reach freeway speeds. I contacted Hyundai Customer Care and was assigned Case # XXX. I also contacted a Hyundai dealership who attempted to charge a 225 diagnostic fee despite P1326 being a known Hyundai defect covered under recall/service campaign. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Engine, Fuel/propulsion system, Feb 9, 2026
The vehicle experienced a catalytic converter efficiency failure that was confirmed by an authorized dealership in January 2025. The dealer indicated the catalytic converter required replacement; however, the replacement was not performed, and the vehicle was returned to service with an unresolved emissions defect. Less than one year later, the vehicle developed recurring emissions system failure, loss of power, drivability issues, and repeated warning indicators. The vehicle is currently out of service while additional components, including oxygen sensors and spark plugs, are reported to be affected. The manufacturer is declining to replace the catalytic converter and is attributing the condition to oil consumption despite the prior unresolved emissions failure. The issue has been confirmed by dealership diagnostics and has resulted in prolonged loss of use of the vehicle. This appears to be a continuing engine and exhaust/emissions system defect that was not properly remedied when first identified and may affect safe operation of the vehicle.
Engine, Feb 5, 2026, fire
The contact owned a 2021 Hyundai Tucson. The contact stated that while driving at 10 MPH, an abnormal clicking sound was coming from under the hood. No warning lights illuminated. In addition, the contact managed to pull over to the shoulder of the road, where white smoke was noticed leaking from under the hood, and the intensity was increasing while the smoke turned black. The local fire department arrived on scene to extinguish the fire. The source of the fire was not identified. It was unknown if a Fire report was filed. A police report was filed. No injuries were sustained, and medical attention was not sought. The vehicle was towed to the contact's residence. The vehicle was deemed a total loss as it was majoily consumed by the fire. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,000.
Engine, Jan 22, 2026
I have been adding oil to this engine excessively for more than 3 years..I have had appointments with the dealer where they flat out told me bring it back when the engine fails.i finally got N appointment and was told the engine needed to be replaced.that was 2 weeks ago..they are now denying the claim...have had my car for 2 weeks..no loaner..and decided to deny what they told me
Engine and engine cooling, Jan 22, 2026
The contact owned a 2021 Hyundai Tucson. The contact stated that immediately after purchasing the certified vehicle, the vehicle went into LIMP Mode while her grandson was driving approximately 65 MPH, and the vehicle decelerated to 7 MPH. The vehicle was towed to the local dealer who diagnosed that the NOX sensor had failed and needed to be replaced. The vehicle was repaired but while leaving the dealer, the failure reoccurred. The vehicle was towed back to the dealer who replaced a second NOX sensor and the catalytic converter. The contact stated that days after retrieving the vehicle, the failure reoccurred, and the vehicle was towed back to the dealer who diagnosed that the NOX sensor had failed for a third time, within several days of owning the vehicle. The vehicle was traded in. The manufacturer was notified of the failure. The failure mileage was 28,944.
Engine, Jan 9, 2026
I am the original owner of this car and in June 2025 I brought my car to Hyundai from noises and they told me it had no oil despite me being up to date with oil changes on the vehicle. They told me they were going to do an oil consumption test and once they did that the engine was denied. 6 months later 3 days after an oil change and no check engine light on, the engine fails while I’m on the side of the highway. This car is not safe. Check engine light was not on and I am always up to date with my cars maintenance.
Engine, Jan 9, 2026
Oil Consumption problems
Engine, Dec 23, 2025
Oil light comes on between changes at about 1500 miles before needing one, oil does not show on dipstick and have to repeatedly put on in engine. Chance of engine seizing or jumping time.
Engine, Nov 14, 2025
We were driving and the engine light started flashing and buckling. The vehicle had been properly maintained with oil changes. We have oil changes receipts from our mechanic. Hyundai refuses to cover it under their warranty even though there are documented issues with the make and models of 2021 Hyundai Tuscons.
Engine, Nov 4, 2025
Engine started making a knocking sound, then the oil light came on followed by the check engine light. Accelerates and decelerates on its own. Was forced to immediately pull over across three lanes on Interstate 95. It’s been over two weeks and I’ve yet to hear if Hyundai is going to cover a replacement engine. However, what happened is exactly what they have listed on their website ️ What to look out for check-engine Check Engine oil-light Engine Oil Pressure A knocking noise from the engine that increases in frequency as the engine rpm increases. Reduced power and/or hesitation and vibration. Illumination of the “check engine” light in the instrument cluster. Illumination of the “engine oil pressure” warning lamp.
Engine, Nov 3, 2025
My family’s safety is at serious risk with my 2021 Hyundai Tucson, which I’ve owned only 55 days. This vehicle has stalled three times while driving, putting me and my two young children in immediate danger. Each time, the car operated normally until a flashing engine light appeared, RPMs spiked, and the vehicle suddenly lost all power—entering “limp mode” and unable to exceed 3,000 RPM or 50 MPH. The first failure occurred 9/14/25 while merging onto the interstate, forcing me to lose power mid-acceleration as surrounding vehicles slammed their brakes to avoid collision. 13 days later, it happened again in stop-and-go traffic, leaving me stranded on the shoulder. Both incidents occurred without warning or prior check-engine lights. The third—and most terrifying—incident was on October 17, 2025, when the engine completely died 300 miles from home on a busy highway. My children, ages 4 and 6, were terrified as cars sped by. We were extremely fortunate not to have been hit. I am urgently requesting assistance for the immediate replacement of this vehicle’s engine. It is covered by Hyundai’s 15-year/150,000-mile extended warranty, clear evidence the company was aware of these issues. Service records from the previous owner-that I was told about by Hyundai show ongoing engine problems and recalls since 2022 further proof this vehicle should have been retired from service As a parent, I’m very alarmed that Hyundai refuses to act until “catastrophic damage” occurs. This policy is irresponsible and endangers entire families. There’s at least 50 NHTSA complaints describing identical issues; stalling, power loss, and bearing failure linked to defective connecting rod bearings. Yet, Hyundai has denied a replacement, insisting on waiting for further damage and failures in operation. I beg you to intervene and prioritize my family’s safety before tragedy inevitably strikes. My children should not be put at risk due to corporate negligence, greed and absence of accountability.
Other or unspecified, Engine, Oct 17, 2025
Engine started making a knocking sound, light came on. Accelerates and decelerates on it's own. Dealership will not provide a diagnosis in any way, but says complete engine replacement is the answer. Car has been at dealership for almost a month.
Vehicle speed control, Other or unspecified, Engine, Sep 13, 2025
While driving on a major highway, my car went into limp mode topping out at 60 mph then decreasing before going back to 60. My check engine light was also blinking, not solid.