2022 Hyundai Tucson
Problems, recalls and owner-reported issues
Fuel/propulsion system is the leading concern among 382 owner complaints filed for this model year. This is the 4th highest complaint count among 21 Tucson model years with reports.
Of the 2022 reports, 25 involved a crash and 4 involved a fire. 54 people were injured.
What owners report most often
Recalls and investigations
Trailer hitchesPark outsideDec 19, 2025
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 Tucson vehicles equipped with an optional Mobis tow hitch wiring harness. The wiring harness may have been installed incorrectly, allowing water into the control module. Moisture accumulation may cause the trailer lighting to fail or an electrical short circuit.
Nonfunctioning trailer lights can increase the risk of a crash. A short circuit can increase the risk of a fire.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will remove the trailer wiring harness and install a dust cap over the wiring receptacle, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 290. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 20, 2025.
Campaign 25V893000 on NHTSA.gov
Structure, body, roof and pillarsJan 31, 2023
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
A detached roof molding could become a road hazard, increasing the risk of a crash.
Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Campaign 23V038000 on NHTSA.gov
Electrical system, softwareDec 2, 2021
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Campaign 21V938000 on NHTSA.gov
Representative owner complaints: engine
116 reports, newest first. Show all
Other or unspecified, Engine, Oct 25, 2022
I was driving when the car stopped accelerating. Then I smelled something burning. I was able to pull over and saw smoke coming from my tailpipe. After that, the engine light came on. A warning came up on the display that said, multiple possible conditions have occurred with your vehicle.
Electrical system, Engine, Back over prevention, Oct 24, 2022
What component or system failed or malfunctioned, and is it available for inspection upon request? Since February of this year, a few weeks after I purchased this car the center console has to be replaced...it is on order to be replaced since April due to rear camera malfunction (Hyundai of Bowie, submitted BBB complaint). A few weeks ago the emergency brake initiates randomly. And yesterday the Engine light is on. Yes available upon request How was your safety or the safety of others put at risk? I'm unable to see cars or people when in reverse. While taking off from a parked position, the emergency brake comes on and can cause me to crash or stop suddenly forcing someone to crash into the back of me. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, took the truck for repair back in April, still unresolved (center console), no response from them after they supposedly ordered the replacement part. The emergency brake issue just started. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes, the rear camera would show previous images on the camera or green screen with lines. When the emergency brake comes on without being initiated by me, other lights come on as well. Now (10/24/22) the engine light is on!
Engine, Oct 6, 2022
1. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine will not start despite having the key fob with live battery on my person. 2. How was your safety or the safety of others put at risk? I was stranded 3 times in a week in dark public parking lots with limited cell reception. I had to abandon the vehicle to get to a warm, safe location, and as a single woman, did not feel comfortable staying with the car while other cars were loitering at night. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? The car has been with the dealer for 6 days now and they have not been able to replicate the issue and it has happened to me 3 times in one week. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there doesn't seem to be any rhyme or reason why the car won't start. After a few hours, the alarm sometimes goes off, and the system resets, allowing me to restart the car. Given this car has a push button start ignition, there is no mechanical way to crank the ignition to start the car, so I am left with no recourse. The last time this happened, I had it towed to the dealership because even after waiting 3 hours, the system did not restart and I had no recourse.
Electrical system, Wheels, Engine, Sep 15, 2022
I purchased the vehicle 3/31/2022, & it left with recalls. I brought it BacK with 48hr, as the check engine light turn on, also the tires, dashboard, and overall the screen. Its been left at the dealer and no results. Also it has affected my life as a disabled handicap person as I'm unable to get to and from doctor appointment etc including to transport my scooter or wheel chair. its a nightmare. I came to purchase a car and was given a "lemon". with only 12miles purchased. I was directed by finance department to proceed with this matter for a resolution as we resolve this matter. The vehicle has been a problematic problem from the start. Definitely not standing firm on the customer Hyundai core value & warranty. The car is at the dealer and I'm temporally with a loaner on which I need to know all my option before we proceed. This is a very serious matter on which Hyundai is fully aware & infant they directed me to this process. My life was at risk as I was told to keep a car that is unreliable with a donut tire without repair. I felt as if I could've die if something was to happen to me within a week until service still count fix the tires as I was placed in jeopardy of my life & kids during Labor Day weekend.. Driving an unsafe vehicle. I was in concern since day 1!
Engine, Fuel/propulsion system, Aug 30, 2022
My wife was driving on the parkway north in New Jersey at approximately 65 miles an hour at about 3:45 pm. The car began to lose power, was shaking, and sputtering. Luckily, she was able to pull onto the shoulder and did not get hit by another car or truck. Once she pulled over, she let the car rest for about 10 minutes and started it up again. It hesitated, but started. Once she put it in gear, it stalled. she tried this two other times and it stalled each time. she waited for a tow truck and the care was towed to the dealer. The dealer invoice with repairs is attached.
Engine, Aug 16, 2022
3rd time Engine Control System code has appeared with complete engine loss the 3rd time. Dealership reset the other times I had called AAA to have it towed to dealership. Car was undrive able. Shaking with no RPM. Dealer ship won’t look at it till the 24th of August 2022
Engine, Power train, Other or unspecified, Jul 28, 2022
The engine will suddenly turn off several times while driving There has not been a turn-off at high speeds yet and the engine is turned off while driving at a low speed of approximately 20 to 40 miles.
Other or unspecified, Engine, Jul 22, 2022
When the car is warm, after driving. While the car is turned off and parked, for a time frame of 10 minutes or more re-entering the vehicle and pressing the push to start creates a false start. The vehicle turns over and the dash activates but the motor stalls. While the motor is stalled, it still displays that the engine is running.
Engine, Power train, Other or unspecified, Jul 21, 2022
When turning left or accelerating from 20 mph there is a really bad hesitation. The car has a hard time accelerating. It didn’t have this problem when we bought it. This poses a safety issue because you really have to give your self a lot of space or you will get hit for not accelerating. Every other time the car is quick and responsive.
Engine, Jun 1, 2022
I have owned the car for 5 months. But have had the ability to drive it for four and a half of them. This vehicle has put me and my family at serious risk multiple time. The first incident my car would not accelerate when I drove onto the highway and it would constantly stutter when I would attempt to accelerate again causing a truck to almost rear end us. The following day my vehicle had a hot engine temp. I pulled over on the highway to an empty antifreeze tank. Refilled it multiple times to only have it empty out and completely shut off while we were driving! Took it to the dealership where it took them 2 weeks to return it. When I asked what the problem was they said they don't know they just replaced it. 3 weeks later ( 5/28/22) while driving back from an event the car starts making a clunking sound and shuts off on me 3 times on my way home with my 9 and 7 year old in the back. Thank goodness it wasn't on the highway! It's now 6/1/22 and I still haven't heard anything about my vehicle! This death box has put my family at risk 5 times. I would strongly advise against buying it! The manufacturer could care less. Luckily the lemon law protects them against people who's lives are constantly put at risk while driving there vehicle!
Service brakes, Engine, Mar 2, 2022
I was in a turning lane & a driver swerved in front of me. My car is equipped with auto start stop and it was on. I slammed on my brakes and the engine turned off. When I tried to start restart the car there was a fluttering/grinding noise. Turned off the key and restarted the car. Dangerous in the intersection with a stalled car. At the dealer now but not optimistic. Annoying to have to turn off feature each time.
Power train, Other or unspecified, Engine, Feb 25, 2022
The car will accelerate, but not beyond a speed of 20 - 30 MPH. The issue is intermittent, one happens in January 2022 and another one happens in Feb 2022. The issue happens after parking overnight, and the issue will go away after restarting the car. No-fault light shows up. The problem has not been reproduced by a dealer since it is intermittent. The issue is reported to the manufacturer, but no actions from the manufacturer have been taken. The issue does pose a safety risk to me and other road traffics since the problem may happen anytime on driving.
Engine, Feb 5, 2022
At highway speed engine began stumbling and shaking car and stalled the car within 5 seconds bring car to halt. Engine would not restart properly, would not settle at idle rpm with rapidly inconsistent rpm shaking the car and then stall within 5 seconds. Any attempt to place car in drive immediately stalls car. After attempting 50-60 bump starts to get car off road the check engine light and error message about engine control system error eventually showed. Hyundai towing refused to take inoperable car to dealership for warranty repair of 1000mi car, instead left it at our apt parking lot. The engine failure left the driver and other motorists in danger as unable to move stranded car off 50mph busy main road on cold dark snowy evening. Dealer reports they are “swamped” with repairs and cannot see an inoperable car for at least 2-3 weeks and no loaners or rental could be provided. There were no warning lights or warning during initial stall or subsequent restarts. Error message and check engine light did not light until attempting 50-60 bump starts trying to get car off road and a hazard to occupants and other motorists.
Air bags, Engine, Nov 1, 2021, crash, fire
The contact owns a 2022 Hyundai Tucson. The contact stated that while driving approximately 55 mph, she collided with an Elk. The engine caught fire and the vehicle was engulfed in the flames. The driver was able to exit the vehicle safely. The contact stated that prior to the crash, the check engine warning indicator light was illuminated. The air bags failed to deploy. There were no reported injuries. A police report was filed. The fire department extinguished the fire. The vehicle was towed to an independent lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The approximate failure mileage was 1,000.
Engine, Sep 10, 2021
Before even reaching 3,000 miles, the engine in this brand new vehicle overheated in very normal driving conditions (under 80 mph on straight, flat interstate in 60-70 degree sunny weather). The dealership technician determined that the engine overheated and the water pump was severely damaged due to the compressor bolts not being tightened correctly during the manufacturing process at the factory.
Engine, Aug 4, 2021
Dear all, I bought the 2022 Hyundai Tusan SUV on June 16th, 2021. Since then, the car engine has been turn off more than 20 times, causing problems that require restarting. When I stop at the traffic light while driving and start, the car will turn off and I have to take off my car key and wait in 30 seconds and turn on the car again. Nowadays, The brakes were not applied because the engine was turned off while driving. At that time, my driving speed was around 15mph because I exited from a HWY. I think the engine issue is occurred when the engine rpm is low. I took a video of the engine turn off issue. Thank you,