2002 Jeep Grand Cherokee
Problems, recalls and owner-reported issues
Air bags is the leading concern among 1,476 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Grand Cherokee model years with reports.
Of the 2002 reports, 75 involved a crash and 20 involved a fire. 97 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Air bags, frontalJan 28, 2015
Chrysler (FCA US LLC) is recalling certain model year 2002-2003 Jeep Liberty vehicles manufactured January 9, 2001, to March 28, 2003, 2002-2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, to May 23 2003, and 2003-2004 Dodge Viper vehicles manufactured November 1, 2001, to June 30, 2004. Due to electrical noise beyond the tolerance of the air bag electronic control module (ECM), a component in the ECM may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.
Inadvertent deployment of the air bags may increase the risk of injury and the possibility of a vehicle crash.
Chrysler dealers will replace the air bag control module and side impact sensors as required, free of charge. This recall remedy was applied during earlier recall campaigns of these vehicles under safety recalls 12V527 and 13V040. All owners that have not had the recall repair performed under safety recalls 12V527 or 13V040 are strongly encouraged to have it performed and not wait for the final remedy to be deployed to the field. The recall began on December 29, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R06.
Campaign 15V046000 on NHTSA.gov
Air bagsNov 8, 2012
Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.
Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.
Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.
Campaign 12V527000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Seats, front assembly, seat heater/coolerApr 9, 2009
CHRYSLER IS RECALLING 103,409 MY 2001-2004 JEEP GRAND CHEROKEE VEHICLES WITH HEATED SEATS AND WITH CHRYSLER RECALL NO. 06V-197 COMPLETED (03-04 MY) OR SEAT HEATER ELEMENTS SERVICE REPLACEMENT (01-02 MY). THE FRONT SEAT ELECTRIC HEATER ELEMENTS COULD OVERHEAT.
OVERHEATING COULD POTENTIALLY CAUSE A FIRE OR INJURY.
DEALERS WILL REPLACE THE FRONT SEAT HEATER ELEMENTS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 23, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Campaign 09V117000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Engine and engine cooling, cooling system, fanJun 8, 2006
ON CERTAIN SPORT UTILITY VEHICLES, THE PLASTIC BLADES OF THE ELECTRIC MOTOR DRIVEN COOLING FAN MAY SEPARATE AND PENETRATE THE SHROUD.
IF THIS OCCURS WHILE THE HOOD IS OPEN, A PERSON IN THE VICINITY OF THE ENGINE COULD BE STRUCK BY THE BLADE AND INJURED.
DEALERS WILL REPLACE THE ELECTRIC COOLING FAN MODULES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 4, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 06V199000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Service brakes, hydraulicMar 13, 2006
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.
Campaign 06E022000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 1, 2006
CERTAIN AFTERMARKET AIRTEX ELECTRIC FUEL PUMPS INSTALLED FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN 1997-2004 JEEP WRANGLER; 1997-2001 JEEP CHEROKEE; 1997-2004 JEEP GRAND CHEROKEE; AND 2000-2003 DODGE DAKOTA VEHICLES. THE PLASTIC ELECTRICAL GROMMET CONNECTORS AT THE TOP OF THE FUEL PUMP MODULE ARE NOT COMPATIBLE WITH AUTOMOTIVE FUELS AND MAY DEGRADE CAUSING A POTENTIAL LEAK PATH FOR FUEL.
IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
AIRTEX WILL NOTIFY ITS CUSTOMERS AND WILL REPLACE THE AFFECTED FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 25, 2006. OWNERS MAY CONTACT AIRTEX CUSTOMER SERVICE DEPARTMENT AT 1-800-880-3056.
Campaign 06E011000 on NHTSA.gov
Fuel system, gasoline, fuel injection system, injectorsApr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
THIS COULD RESULT IN A VEHICLE FIRE.
DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 02V104000 on NHTSA.gov
Air bags, frontalMar 26, 2002
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER AIR BAG WIRING HARNESS WAS IMPROPERLY MANUFACTURED.
THIS COULD CAUSE IMPROPER AIR BAG DEPLOYMENT IN CERTAIN CRASH CONDITIONS.
DEALERS WILL ADD A WIRING JUMPER TO THE EXISTING CIRCUITRY TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN APRIL 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 02V099000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsJan 31, 2002
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A FUEL TANK BRUSH GUARD FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) CONTROL VALVE CAN BECOME DETACHED DURING A CRASH, ALLOWING FUEL LEAKAGE.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
DEALERS WILL EITHER REPLACE THE FUEL TANK BRUSH GUARD WITH A SKID PLATE OR REINFORCE THE EXISTING FUEL TANK BRUSH GUARD WITH A REINFORCEMENT BRACKET. OWNER NOTIFICATION WILL BEGIN MARCH 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 02V032000 on NHTSA.gov
Fuel system, gasoline, deliveryDec 5, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FUEL INLET CHECK VALVE COULD STICK IN THE PARTIALLY OPEN POSITION. THIS CONDITION COULD CAUSE FUEL TO SPILL OUT OF THE FILLER TUBE DURING REFUELING.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSPECT THE FUEL INLET CHECK VALVE. VEHICLES FOUND TO HAVE A STICKING FUEL INLET CHECK VALVE WILL HAVE THE FUEL TANK ASSEMBLY REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 01V374000 on NHTSA.gov
Engine and engine cooling, exhaust system, emission controlNov 13, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE ONBOARD VAPOR RECOVERY SYSTEM VENT HOSE MAY HAVE BEEN MISROUTED. THIS COULD ALLOW WATER TO ENTER THE CANISTER WHICH CAN CAUSE FUEL TO SPILL OUT OF THE FILLER TUBE WHEN REFUELING THE TANK.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSPECT (AND REPOSITION AS NECESSARY) THE VENT HOSE. IF THE VENT HOSE IS FOUND IN THE BENT DOWN POSITION, AND THE VEHICLE HAS BEEN DRIVEN MORE THAN 20 MILES, THE CANISTER ASSEMBLY WILL BE REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 01V348000 on NHTSA.gov
Electrical system, wiring, interior/under dashSep 10, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES ARE BEING RECALLED FOR A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER MICROPROCESSOR. UNDER CERTAIN CONDITIONS, THE CLUSTER, WITH THE MAJORITY OF ITS GAUGES, ILLUMINATION, AND WARNING LAMPS, COULD BECOME INOPERATIVE.
DRIVING THE VEHICLE WITH AN INOPERATIVE CLUSTER COULD CAUSE A DISTRACTION, INCREASING THE RISK OF A CRASH.
DEALERS WILL RE-FLASH THE CLUSTER SOFTWARE TO CORRECT THE CONDITION. OWNER NOTIFICATION BEGAN OCTOBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 01V288000 on NHTSA.gov
Representative owner complaints: hydraulic
153 reports, newest first. Show all
Service brakes, Hydraulic, Fuel system, Gasoline, Air bags, Aug 18, 2014
TL* THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. THE CONTACT RECEIVED RECALL NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBERS: 06E011000 (FUEL SYSTEM, GASOLINE), 06E022000 (SERVICE BRAKES, HYDRAULIC), AND 12V527000 (AIR BAGS). THE DEALER STATED THAT THE PARTS NEEDED TO COMPLETE THE REPAIRS WERE NOT AVAILABLE. THE CONTACT RECEIVED THE RECALL NOTICES MONTHS AGO. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Service brakes, Hydraulic, Engine and engine cooling, Power train, Electrical system, Nov 1, 2011
2002 JEEP GRAND CHEROKEE. CONSUMER WRITES IN REGARDS TO SEVERAL EXPENSES RELATED TO VEHICLE AND REQUESTS REIMBURSEMENT *TGW THE CONSUMER STATED THE FRONT BRAKES WHICH INCLUDED THE ROTORS MASTER CYLINDER, LEFT REAR SEAL AXLE, BEARING, SNAP RING HAD TO BE REPLACED MORE THAN ONCE ON DIFFERENT OCCASIONS. ALSO, THE VEHICLE BROKE DOWN ON SEVERAL OCCASIONS AND SMOKE WAS EMITTING FROM THE VEHICLE ON ONE OF THOSE OCCASIONS. IT WAS DISCOVERED THE RELAY FAN RADIATOR FAN NEEDED TO BE REPLACED. THE TRANSDUCE PRESSURE SENSOR, SOLENOID, TRANSMISSION GOV AND GASKET WERE REPLACED AT A COST OF $ 530.50. *JB THE CONSUMER STATED THE HORN BEGAN BLARING FOR NO APPARENT REASON AND THEN STOPPED WORKING/ TWO DAYS LATER, ALL THE GAUGES IN THE VEHICLE WENT TO ZERO AND ALL THE INTERIOR LIGHTS ILLUMINATED AND THE WINDOWS DID NOT WORK. THE VEHICLE WAS TOWED TO THE DEALER AND A DIAGNOSTICS TEST REVEALED AN ELECTRICAL PROBLEM. UPDATED 11/10/11*JB UPDATED 11/22/11. *JB
Service brakes, Hydraulic, Feb 25, 2011
TL* THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL YET THE VEHICLE WOULD NOT STOP. THE CONTACT WAS ABLE TO CHANGE LANES TO AVOID A CRASH AND THE VEHICLE CAME TO A STOP AFTER HE CONTINUOUSLY APPLIED PRESSURE TO THE BRAKE PEDAL. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE A FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 44,000. UPDATED 3/21/11 *CN UPDATED 03/31/11
Service brakes, Hydraulic, Jun 26, 2010
POTENTIAL BRAKE FAILURE. THE REAR BRAKE LINE & HOSE ARE SEVERELY RUSTED. WHY AREN'T THEY DESIGNED NOT TO COMPROMISE SAFETY. *TR
Service brakes, Hydraulic, Mar 9, 2009
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. WHILE DRIVING APPROXIMATELY 60 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE VIBRATED EXCESSIVELY WHEN THE BRAKE PEDAL WAS DEPRESSED. THE FAILURE WAS CONTINUOUS AND OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY REPLACED BOTH FRONT BRAKE PADS UNDER WARRANTY. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER AND INDEPENDENT MECHANIC ON SEPARATE OCCASIONS FOR REPLACEMENT OF BOTH FRONT BRAKE PADS AND ROTORS AT THE CONTACT'S EXPENSE. THERE HAS BEEN NO RESOLUTION AND THE VEHICLE HAS NOT BEEN PROPERLY REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 12,000 AND CURRENT MILEAGE WAS 55,000.
Service brakes, Hydraulic, Electrical system, Mar 3, 2009
TL*THE CONTACTS OWNS A 2002 JEEP GRAND CHEROKEE. EVER SINCE THE VEHICLE WAS PURCHASED, THE CONTACT HAS EXPERIENCED BRAKE FAILURE. WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE PEDAL WILL EXTEND TO THE FLOOR AS IF THERE WERE PRESSURE LOSS. THE CONTACT MUST LITERALLY STAND ON THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. ALSO, THE WIRING ON THE INSTRUMENT PANEL THAT CONTROLS THE AIR CONDITIONING FAN HAS FAILED. THE DEALER STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS UNKNOWN.
Service brakes, Hydraulic, Aug 8, 2008
FRONT BRAKE ROTORS WARE CONSTANTLY. *TR
Service brakes, Hydraulic, Jul 26, 2008
DISC BRAKES TENDS TO LOCK UP EVER SINCE WE BOUGHT THE CAR. *TR
Service brakes, Hydraulic, Apr 17, 2008
CAR SHUTTERS WHEN APPLYING BRAKES. JEEP HAS KNOW ABOUT THIS PROBLEM SINCE THE MIDDLE OF 2002 AND EVEN SENT OUT TSB'S TO IT'S DEALERS. THE CALIPERS WERE DEFECTIVE CAUSING THE PADS TO WEAR UNEVEN THUS CAUSING THE ROTORS TO WARP. CHRYSLER SAYS YOUR PROBLEM NOT OURS , PAY TO HAVE IT FIXED. *TR
Service brakes, Hydraulic, Apr 10, 2008
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. WHEN THE CONTACT DEPRESSES THE BRAKE PEDAL TO STOP THE VEHICLE, THE FRONT END SHAKES. WHILE DRIVING DURING THE WINTER MONTHS AND DEPRESSING THE BRAKE PEDAL, THE FRONT END SHAKING CAUSES THE CONTACT TO LOSE CONTROL OF THE VEHICLE. HE EXAMINED THE BRAKES AND NOTICED THAT THE ROTORS WERE WARPED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT SERVICED. THE FAILURE OCCURRED AT VARIOUS SPEEDS. THE CURRENT MILEAGE WAS 42,340 AND FAILURE MILEAGE WAS 15,000.
Service brakes, Hydraulic, Apr 2, 2008
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. THE CONTACT STATED THAT THE STEERING WHEEL, FLOOR, SEAT, AND INSTRUMENT PANEL VIBRATED. THERE WAS ALSO A MINOR PEDAL PULSATION (BRAKE ROUGHNESS) UNDER LIGHT TO MODERATE PEDAL APPLICATION. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE BRAKE CALIPERS WERE COVERED UNDER WARRANTY; HOWEVER, THE ROTORS AND PADS WOULD HAVE TO BE REPLACED AT HIS OWN EXPENSE. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE POWERTRAIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 44,700.
Service brakes, Hydraulic, Engine and engine cooling, Dec 7, 2007
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. SINCE THE DAY THE VEHICLE WAS PURCHASED, THE CONTACT FEELS A VIBRATION WHEN DRIVING 30-45 MPH. THE FAILURE OCCURS WHEN THE BRAKES ARE APPLIED. THE DEALER STATED THAT THE BRAKES WERE 50% WORN. THE MANUFACTURER STATED THAT NOTHING COULD BE DONE. THE VEHICLE HAS YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 2 AND CURRENT MILEAGE WAS 20,000. UPDATED 01-15-08. *KB THE DEALER STATED INSTALLED INTAKE DEBRE SHIELD. UPDATED 01/15/08 *TR
Service brakes, Hydraulic, Nov 2, 2007
2002 JEEP GRAND CHEROKEE WITH DEFECTIVE BRAKE ROTORS. CUSTOMER STATES THAT SHE HAS HAD THE BRAKES REPAIRED AND REPLACED ON 2 SEPARATE OCCASIONS. CONSUMER WANTS REIMBURSEMENT FOR THE REPAIRS. *KB
Service brakes, Hydraulic, Sep 19, 2007
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. WHILE DRIVING 40 MPH, THE BRAKE PEDAL AND STEERING WHEEL PULSATED WHEN THE BRAKES WERE APPLIED. THE ROTORS WERE PREVIOUSLY REGROUNDED AT THE DEALER, HOWEVER, THE FAILURE CONTINUED. THE DEALER REPLACED THE BRAKE PADS AND ROTORS. THE FAILURE MILEAGE WAS 14,131 AND CURRENT MILEAGE IS 32,899. UPDATED 01-15-08. *KB UPDATED 12/12/07. *JB
Service brakes, Hydraulic, Sep 7, 2007
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. WHILE DRIVING 60 MPH, THE STEERING WHEEL WOULD VIBRATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE DEALER STATED THAT THE ROTORS WERE WARPED AND THEY REPLACED THE ROTORS AND BRAKE PADS. APPROXIMATELY EIGHT MONTHS LATER, THE FAILURE RECURRED. THE DEALER STATED AGAIN THAT THE ROTORS WERE WARPED. THE CONTACT STATED THAT THE FAILURE OCCURRED EVERY EIGHT MONTHS. THE VIN WAS UNKNOWN. THE FAILURE WAS MILEAGE 12,000 AND CURRENT MILEAGE WAS 25,000.
Service brakes, Hydraulic, Electrical system, Aug 3, 2007
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT WAS NOTIFIED BY ANOTHER DRIVER THAT HIS BRAKE LIGHTS WERE OUT. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT WHEN HE DEPRESSED THE BRAKE PEDAL, THE BRAKE LIGHTS AND PARKING LIGHTS FAILED. THE FAILURE WAS CAUSED BY AN ELECTRICAL DEFECT. THE MANUFACTURER STATED THAT THEY CANNOT HELP WITH THE BRAKE FAILURE. THE CURRENT MILEAGE WAS 185,000 AND FAILURE MILEAGE WAS 184,000. UPDATED 02/01/08. *LJ UPDATED 02/01/08 *TR
Service brakes, Hydraulic, Aug 2, 2007, crash
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. THE CONTACT DEPRESSED THE BRAKE PEDAL, BUT THE VEHICLE FAILED TO STOP. THE VEHICLE CRASHED INTO SOME BENCHES. THIS FAILURE HAS OCCURRED TWICE. THE DEALER HAS NOT BEEN NOTIFIED. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE FAILURE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 55,000 AND FAILURE MILEAGE WAS 45,000.
Service brakes, Hydraulic, Jun 1, 2007
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. WHILE DRIVING APPROXIMATELY 45 MPH, THE FRONT END OF THE VEHICLE SHOOK WHEN THE BRAKES WERE DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE FRONT ROTORS WERE WARPED DUE TO EXCESSIVE HEAT. THIS FAILURE HAS OCCURRED PREVIOUSLY. THE CORRECT VIN, # OF CYLINDERS, AND ENGINE SIZE WERE UNKNOWN. THE CURRENT MILEAGE IS 55,000 AND FAILURE MILEAGE WAS 45,239.
Service brakes, Hydraulic, May 18, 2007
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. THE CONTACT CALLED PERTAINING TO THE CLASS ACTION SUIT AGAINST JEEP FOR THE BRAKES. SHE HAS BEEN EXPERIENCING SEVERE BRAKE AND ROTOR FAILURE. SHE STATED THAT WHEN SHE DEPRESSES THE BRAKES, THE VEHICLE PULSATES HORRIBLY AND OUT OF CONTROL, CAUSING THE STEERING WHEEL TO SHAKE. EVERY TIME THE VEHICLE WAS TAKEN TO THE DEALER, THEY STATED THAT SHE NEEDED A FRONT END ALIGNMENT. THE CONTACT HAS HAD THE ALIGNMENT PERFORMED THREE TIMES AND THE FAILURE STILL OCCURS. SHE HAS CONTACTED THE MANUFACTURER WHO STATED THAT SHE DOES NOT QUALIFY FOR THE CLASS ACTION SUIT BECAUSE HER VEHICLE IS AN OLDER MODEL. THE CONTACT STATED THAT THE MECHANICS HAVE CONTINUED TO PLACE THE FAULTY PART ON HER VEHICLE DUE TO THE DATE OF THE CLASS ACTION SUIT. NEW TIRES WERE ALSO INSTALLED AS SUGGESTED BY THE MECHANIC. APPROXIMATELY 10,000 MILES LATER, THE BRAKES ARE NEEDING TO BE REPLACED. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 80,655 AND THE FAILURE MILEAGE WAS UNKNOWN.
Service brakes, Hydraulic, May 7, 2007
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE LIMITED. WHILE DRIVING 5 MPH, THE CONTACT ATTEMPTED TO BRAKE BUT THE VEHICLE LUNGED FORWARD. THE GEAR WAS SHIFTED INTO NEUTRAL IN ORDER TO STOP THE VEHICLE. WHILE DRIVING IN REVERSE, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE LUNGED BACKWARDS. THE DRIVING CONDITIONS WERE FAVORABLE DURING BOTH FAILURES. PRIOR TO THESE FAILURES, THE VEHICLE OPERATED NORMALLY AND HAD NO PREVIOUS REPAIR WORK. THE CURRENT AND FAILURE MILEAGES WERE 77,000.
Service brakes, Hydraulic, Feb 25, 2007
THE BRAKES ON 2002 GRAND CHEROKEE ARE VERY SUSPECT. THE DEALER REPLACED THEM UNDER WARRANTY AT 24,000 MILES DUE TO WARPAGE OF ROTORS. AT 54,000 MILES THE ROTORS WERE TURNED BECAUSE OF WARPAGE AND NOW AT 62,000 THEY EXHIBIT SYMPTOMS OF BEING WARPED AGAIN - WORSE THAN BEFORE THEY WERE LAST TURNED. JEEP HAS OBVIOUSLY ONLY REPLACED DEFECTIVE PARTS WITH DEFECTIVE PARTS. THIS CREATES COST, INCONVENIENCE AND POTENTIAL SAFETY HAZARD TO THE CONSUMER.*JB
Service brakes, Hydraulic, Feb 18, 2007
I EXPERIENCED BRAKE FAILURE ON MY 2002 JEEP GRAND CHEROKEE (59,000 MILES). AFTER BRAKING TO TURN A CORNER THE BRAKES WOULD NOT WORK. THIS OCCURRED OVER SEVERAL INSTANCES AND BECAME VERY UN-NERVING NOT KNOWING WHEN THE BRAKES WOULD WORK. I TOOK IT TO THE JEEP DEALER AND HE STATED THAT HE REPLACED THE MASTER CYLINDER. HE ALSO SAID IT WAS NOT COVERED BY THE BRAKE RECALL SO I HAD TO PAY SEVERAL HUNDRED DOLLARS TO GET IT REPAIRED OUT OF MY OWN POCKET. I CONTACTED JEEP AND THEY WERE NO HELP AND WOULDN'T AGREE TO PAY ANYTHING. *JB
Service brakes, Hydraulic, Visibility, Feb 2, 2007
TL*- THE CONTACT RECEIVED A SAFETY RECALL NOTICE ABOUT THE FAN IN HER 2002 JEEP GRAND CHEROKEE IN NOVEMBER AND CALLED THE DEALER AND THEY HAVE NOT YET COMPLETED THE REPAIRS. THE VEHICLE HAS BEEN PLACED ON A WAITING LIST. ALSO, THERE WAS A BRAKE FAILURE WHILE DRIVING OVER 40 MPH. THE STEERING WHEEL WOULD VIBRATE SO MUCH THAT IT FELT AS IF IT WERE ABOUT TO COME OFF. THIS INCIDENT HAPPENED OVER 300 TIMES. THE BRAKES WERE FAULTY SINCE SHE BOUGHT THE VEHICLE, BUT THE DEALER ALWAYS TOLD HER THAT NOTHING WAS WRONG, EVEN THOUGH THERE WAS A SAFETY BULLETIN IN PLACE. AFTER THE WARRANTY EXPIRED THE FAILURE WAS DIAGNOSED AND THE COST OF THE REPAIR WAS $1500. THE CONTACT WAS CHARGED FOR SEVERAL FRONT END ALIGNMENTS THAT NEVER SEEM TO ALLEVIATE THE FAILURE. ALSO, THERE WAS RECURRING PROBLEM WITH THE MOTOR OF THE REAR WINDOWS. THE CONTACT HAD ONE MOTOR REPLACED AT A COST OF $300 AND WILL NEED TO REPLACE THE SECOND MOTOR. *AK
Service brakes, Hydraulic, Jan 17, 2007
SUB STANDARD MATERIALS USED IN FRONT ROTORS FOR 2002 JEEP GRAND CHEROKEE. I BELIEVE IT AFFECTS ALL FROM 1999 TO 2004. *JB
Service brakes, Hydraulic, Equipment, Jan 16, 2007
THE FRONT BRAKE ROTORS HAVE WARPED FOR THE SECOND TIME IN 42,000 MILES. DRIVING WITH THESE WARPED ROTORS CAUSES THE STEERING WHEEL TO SHAKE VIOLENTLY AND BRAKE APPLICATION AT THE WHEELS TO BE UNEVEN. THE SHAKING IS MORE PRONOUNCED WHEN BRAKING FROM SPEEDS ABOVE 40 MPH. THIS IS A VERY UNSAFE CONDITION ESPECIALLY ON WET OR ICY SURFACES. THE DEALER REFUSES TO REPLACE THE ROTORS UNDER WARRANTY. *JB