2005 Jeep Grand Cherokee
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 2,051 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 Grand Cherokee model years with reports.
Of the 2005 reports, 82 involved a crash and 24 involved a fire. 74 people were injured.
What owners report most often
Recalls and investigations
Electrical system, ignition, switchJul 21, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, drivers should adjust their seat to allow clearance between the driver's knee and the ignition key, and remove all items from their key ring, leaving only the vehicle key. Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2007 Jeep Grand Cherokee vehicles manufactured February 11, 2004, to July 5, 2007, and 2006-2007 Jeep Commander vehicles manufactured January 31, 2005, to July 5, 2007. In the affected vehicles, the driver may accidentally hit the ignition key with their knee, unintentionally knocking the key out of the run position, turning off the engine.
If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Chrysler will notify owners, and dealers will replace the ignition switch, free of charge. Chrysler sent interim notifications to owners in September 2014. The recall began on October 9, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P41.
Campaign 14V438000 on NHTSA.gov
Power train, transfer case (4-wheel drive)May 7, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2010 Jeep Grand Cherokee vehicles manufactured February 11, 2004, through March 9, 2010; and 2006-2010 Jeep Commander vehicles manufactured January 31, 2005, through March 10, 2010. A transfer case electrical failure may result in an unintentional shifting of the transfer case into the neutral position.
If the vehicle shifts into neutral, it may roll away increasing the risk of a crash or personal injury.
Chrysler will notify owners, and dealers will reflash the final drive controller which governs the transfer case, with new software, free of charge. The recall began on August 15, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N23.
Campaign 13V175000 on NHTSA.gov
SuspensionJun 19, 2009
ROCK KRAWLER IS RECALLING 44 PERFORMANCE SUSPENSION SYSTEMS SOLD AS AFTERMARKET EQUIPMENT FOR USE ON THE VEHICLE LISTED ABOVE. THESE SUSPENSION SYSTEMS WERE PRODUCED WITH GRADE 2 CARRIAGE BOLTS INSTEAD OF THE PROPER GRADE 5 CARRIAGE BOLTS. THE IMPROPER GRADE 2 CARRIAGE BOLTS COULD EXPERIENCE A LOSS OF CLAMPING FORCE FOR THE BOTTOM STRUT FORK.
THIS CONDITION COULD CAUSE A LOSS OF EFFECTIVE LIFT AND LOWERING OF THE AFFECTED VEHICLE, POSSIBLY CREATING THE DRIVER TO PANIC WHICH COULD POSSIBLY LEAD TO A VEHICLE CRASH.
ROCK KRAWLER WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY. THE SAFETY RECALL BEGAN ON OCTOBER 15. 2008. ALL THE AFFECTED UNTITS HAVE BEEN REMEDIED. OWNERS MAY CONTACT ROCK KRAWLER AT 1-518-270-9822.
Campaign 09E039000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Power train, automatic transmissionSep 14, 2005
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.7L ENGINES AND NAG1 AUTOMATIC TRANSMISSIONS, THE AIR CONDITIONER EVAPORATOR CONDENSATE WATER MAY ENTER THE TRANSMISSION AT THE FILL TUBE GROMMET SEAL. THIS CAN RESULT IN SHUDDER DURING TORQUE CONVERTER CLUTCH ENGAGEMENT.
IT CAN LEAD TO INCREASED TRANSMISSION OPERATING TEMPERATURES, BOILING OF THE WATER, AND A SUBSEQUENT PURGING OF TRANSMISSION FLUID INTO THE ENGINE COMPARTMENT POTENTIALLY RESULTING IN AN UNDERHOOD FIRE.
DEALERS WILL INSPECT THE TRANSMISSION FOR LEAKAGE AT THE FILL TUBE GROMMET SEAL. IF NO LEAK IS DETECTED, A NEW FILL TUBE GROMMET SEAL AND WATER DEFLECTOR SHIELD WILL BE INSTALLED, AND PROPER ALIGNMENT OF THE FILL TUBE VERIFIED. IF THE PRESENCE OF A LEAK IS DETECTED, THE VEHICLE WILL BE EVALUATED FOR SHUDDER DURING TORQUE CONVERTER ENGAGEMENT. IF NO SHUDDER IS DETECTED, THE TRANSMISSION WILL BE TRIPLE FLUSHED, AND NEW FILL TUBE GROMMET SEAL AND WATER DEFLECTOR WILL BE INSTALLED AND PROPER ALIGNMENT OF THE FILL TUBE VERIFIED. IF SHUDDER IS DETECTED, THE TORQUE CONVERTER WILL BE REPLACED, A NEW FILL TUBE GROMMET SEAL AND WATER DEFLECTOR WILL BE INSTALLED, AND PROPER ALIGNMENT OF THE FILL TUBE VERIFIED. THE RECALL BEGAN ON OCTOBER 31, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 05V396000 on NHTSA.gov
Representative owner complaints: power train
253 reports, newest first. Show all
Power train, May 4, 2005
I WAS PERFORMING AN OIL CHANGE ON THE VEHICLE. AS SOON AS I CRAWLED UNDER IT TO START, I NOTICED THE RIGHT SIDE OF THE FRONT DIFFERENTIAL WHERE THE AXLE TUBE MATES, WAS COVERED IN DIFF OIL. I TOOK THE VEHICLE TO THE DEALER AND WAS TOLD IT WAS "NORMAL SEEPAGE". I FIND IT HARD TO BELIEVE A GASKET CAN ONLY HOLD FLUID FOR LESS THAN 6000 MILES BEFORE LEAKING. DEALER REFUSED TO CORRECT IT.
Power train, Jan 12, 2005
THE VEHICLE'S SHIFT LEVER BECAME STUCK IN PARK. *NM A NEW MODULE WAS ORDERED AND INSTALLED ALONG WITH THE BROKEN SHIFTER CABLE AND SHIFTER. *SC
Power train, Dec 20, 2004
FROM THE FIRST DAY TOOK DELIVER OF 2005 JEEP GRAND CHEROKEE LTD. 5.7 LT HEMI ENGINE, FIRST IN WHEN PRESSING ACCELERATOR IN LOW RPM, THEN WHEN REACHED 80 MPH. ON FLAT FREEWAY (WITH 400 MILES ON THE ODOMETER), ECESSIVE GROAN AND NOISE FROM THE ENGINE. SAME NOISE WAS NOT PRESENT ON IDENTICALLY EQUIPED TEST-DRIVE VEHICLE. APPARENT HIGH FREQUENCY VIBARTION, ESPECIALLY IN LOW CRUISING SPPEDS ON PERFECTLY FLAT PAVEMENT. VIBRATION STRENGTH INCREASING IN HIGHER RPM. HESITANT ENGINE IN LOW RPM AND WHILE ACCELERATING. APPARENT UNDERPOWERED OPERATION, COMPARED TO TEST-DRIVEN VEHICLE. TWO JEEP DEALER SERVICE TECHNICIANS TEST DROVE THE VEHICLE FOR 50 MILES. PROBLEM CONFIRMED BY SERVICE. FIRST ATTEMPT, FAILED TO FIX MALFUNCTION. ADIVSED TO BRING BACK FOR A LONGER STAY. SECOND ATTEMPT - AFTER 50 MILES OF OPERATION - (VEHICLE STAYED IN DEALERHIP SERVICE FOR 4 BUSINESS DAYS) UNSUCCESSFUL ATTEMPT TO FIX AQAIN. VEHICLE ASSESSED AS SAFE TO DRIVE UNTIL DAIMLER CHRYSLER ADVISES ON ANOTHER SOLUTION. CURRENTLY VEHICLE WITH APPROX. 600 MILES. *AK