2005 Jeep Grand Cherokee
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 2,051 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 Grand Cherokee model years with reports.
Of the 2005 reports, 82 involved a crash and 24 involved a fire. 74 people were injured.
What owners report most often
Recalls and investigations
Electrical system, ignition, switchJul 21, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, drivers should adjust their seat to allow clearance between the driver's knee and the ignition key, and remove all items from their key ring, leaving only the vehicle key. Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2007 Jeep Grand Cherokee vehicles manufactured February 11, 2004, to July 5, 2007, and 2006-2007 Jeep Commander vehicles manufactured January 31, 2005, to July 5, 2007. In the affected vehicles, the driver may accidentally hit the ignition key with their knee, unintentionally knocking the key out of the run position, turning off the engine.
If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Chrysler will notify owners, and dealers will replace the ignition switch, free of charge. Chrysler sent interim notifications to owners in September 2014. The recall began on October 9, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P41.
Campaign 14V438000 on NHTSA.gov
Power train, transfer case (4-wheel drive)May 7, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2010 Jeep Grand Cherokee vehicles manufactured February 11, 2004, through March 9, 2010; and 2006-2010 Jeep Commander vehicles manufactured January 31, 2005, through March 10, 2010. A transfer case electrical failure may result in an unintentional shifting of the transfer case into the neutral position.
If the vehicle shifts into neutral, it may roll away increasing the risk of a crash or personal injury.
Chrysler will notify owners, and dealers will reflash the final drive controller which governs the transfer case, with new software, free of charge. The recall began on August 15, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N23.
Campaign 13V175000 on NHTSA.gov
SuspensionJun 19, 2009
ROCK KRAWLER IS RECALLING 44 PERFORMANCE SUSPENSION SYSTEMS SOLD AS AFTERMARKET EQUIPMENT FOR USE ON THE VEHICLE LISTED ABOVE. THESE SUSPENSION SYSTEMS WERE PRODUCED WITH GRADE 2 CARRIAGE BOLTS INSTEAD OF THE PROPER GRADE 5 CARRIAGE BOLTS. THE IMPROPER GRADE 2 CARRIAGE BOLTS COULD EXPERIENCE A LOSS OF CLAMPING FORCE FOR THE BOTTOM STRUT FORK.
THIS CONDITION COULD CAUSE A LOSS OF EFFECTIVE LIFT AND LOWERING OF THE AFFECTED VEHICLE, POSSIBLY CREATING THE DRIVER TO PANIC WHICH COULD POSSIBLY LEAD TO A VEHICLE CRASH.
ROCK KRAWLER WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY. THE SAFETY RECALL BEGAN ON OCTOBER 15. 2008. ALL THE AFFECTED UNTITS HAVE BEEN REMEDIED. OWNERS MAY CONTACT ROCK KRAWLER AT 1-518-270-9822.
Campaign 09E039000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Power train, automatic transmissionSep 14, 2005
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.7L ENGINES AND NAG1 AUTOMATIC TRANSMISSIONS, THE AIR CONDITIONER EVAPORATOR CONDENSATE WATER MAY ENTER THE TRANSMISSION AT THE FILL TUBE GROMMET SEAL. THIS CAN RESULT IN SHUDDER DURING TORQUE CONVERTER CLUTCH ENGAGEMENT.
IT CAN LEAD TO INCREASED TRANSMISSION OPERATING TEMPERATURES, BOILING OF THE WATER, AND A SUBSEQUENT PURGING OF TRANSMISSION FLUID INTO THE ENGINE COMPARTMENT POTENTIALLY RESULTING IN AN UNDERHOOD FIRE.
DEALERS WILL INSPECT THE TRANSMISSION FOR LEAKAGE AT THE FILL TUBE GROMMET SEAL. IF NO LEAK IS DETECTED, A NEW FILL TUBE GROMMET SEAL AND WATER DEFLECTOR SHIELD WILL BE INSTALLED, AND PROPER ALIGNMENT OF THE FILL TUBE VERIFIED. IF THE PRESENCE OF A LEAK IS DETECTED, THE VEHICLE WILL BE EVALUATED FOR SHUDDER DURING TORQUE CONVERTER ENGAGEMENT. IF NO SHUDDER IS DETECTED, THE TRANSMISSION WILL BE TRIPLE FLUSHED, AND NEW FILL TUBE GROMMET SEAL AND WATER DEFLECTOR WILL BE INSTALLED AND PROPER ALIGNMENT OF THE FILL TUBE VERIFIED. IF SHUDDER IS DETECTED, THE TORQUE CONVERTER WILL BE REPLACED, A NEW FILL TUBE GROMMET SEAL AND WATER DEFLECTOR WILL BE INSTALLED, AND PROPER ALIGNMENT OF THE FILL TUBE VERIFIED. THE RECALL BEGAN ON OCTOBER 31, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 05V396000 on NHTSA.gov
Representative owner complaints
2,051 reports, newest first.
Power train, Sep 25, 2006
2005 JEEP GRAND CHEROKEE. THE VEHICLE IS A 6 CYLINDER WITH A NAG 1 TRANSMISSION. THE VEHICLE WAS BOUGHT NEW IN NOV, 2005. IT HAS AROUND 17600 MILES ON IT. THE VEHICLE HAD BEEN SHUDDERING AT VARIOUS TIMES, WAS INCONSISTENT. USUALLY AROUND 1500 RPMS. EAGLE AUTO MALL, LOCAL JEEP DEALER STATED NOTHING WAS WRONG. COMING HOME FROM STORE TRANSMISSION STARTED TO WHINE AND THEN STOPPED SHIFTING. PULLING INTO MY DRIVEWAY ENGINE COMPARTMENT STARTED TO SMOKE BADLY, ALMOST WENT ON FIRE . TURNED VEHICLE OFF. OBSERVED TRANNY FLUID ALL OVER THE ENGINE AND ALOT OF TRANNY FLUID ON THE GROUND. VEHICLE WAS TOWED TO THE EAGLE DEALER, WHO AFTER A WEEK IN THE SHOP SAID THERE WAS WATER IN THE TRANNY FLUID AND THAT THEY WERE GOING TO HAVE TO TAKE APART THE TRANSMISSION. CONTACTED CHRYSLER TOLD THEM THAT A VIN CHECK OF MY VEHICLE SHOWED THAT IT WAS NOT UNDER THE RECALL THEY HAD ISSUED FOR THIS MODEL, BUT THERE WAS A SAFETY PROBLEM AND THAT A NEW TRANSMISSION SHOULD BE PLACED IN THE VEHICLE. *NM
Electrical system, Sep 22, 2006
2005 JEEP GRAND CHEROKEE - 07/26/2005 - VEHICLE DID NOT START, DEALER REPLACED BATTERY. 06/10/2006 - STALLED WHILE AT LIGHT, DEALER ATTEMPTED REPAIR BY TIGHTENING CONNECTION IN JUNCTION BOX. 06/28/2006 - VEHICLE STALLED WHILE DRIVING, DEALER COULD NOT DUPLICATE NO REPAIRS ATTEMPTED. 07/07/2006 - VEHICLE STALLED WHILE ON INTERSTATE, DEALER REPLACED FORWARD CONTROL MODULE. 07/26/2006 - VEHICLE WOULD NOT START - DEALER COULD NOT DUPLICATE NO REPAIRS ATTEMPTED. 09/01/2006 - VEHICLE STALLED WHILE DRIVING - DEALER DUPLICATED PROBLEM - DEALER REPLACED BATTERY. 09/15/2006 - VEHICLE STALLED WHILE DRIVING, HAS BEEN IN DEALER POSSESSION NOW FOR 7 DAYS - CANNOT DUPLICATE - NO REPAIRS ATTEMPTED. VEHICLE HAS BEEN OUT OF SERVICE FOR SAME PROBLEM FOR A TOTAL OF 39 DAYS AND COUNTING. SITUATION IS A DANGER AS THE VEHICLE WILL JUST DIE WHILE MOVING AND DRIVER CANNOT GET IT OFF ROAD. VEHICLE ONLY HAS 20,000 MILES AND HAS HAD PROBLEM SINCE 155 MILES. DAIMLER CHRYSLER'S RESPONSE IS UNACCEPTABLE - VEHICLE IS A SAFETY HAZARD AND AN ACCIDENT WAITING TO HAPPEN. WHEN IS ENOUGH - ENOUGH? LOSS OF LIFE? MAYBE THEN SOMEONE WILL REALIZE THERE IS A PROBLEM WITH SEVERAL OF THESE 05 JEEP GRAND CHEROKEES WITH SAME PROBLEM! CONTACT ME KARENHORROCKS@BELLSOUTH.NET. *NM
Electrical system, Sep 19, 2006
ON 9/1/06 WHILE ON VACATION DRIVING IN STOP AND GO TRAFFIC ON CALIFORNIA FREEWAY, VEHICLE LOST BRAKES AND STEERING WHILE VEHICLE IN MOTION. I WAS ABLE TO PULL OFF TO SIDE OF FREEWAY. TURNED CAR OFF AND RESTARTED AND TOOK TO CLOSEST DEALERSHIP. THEY HOOKED UP TO COMPUTER AND FOUND 3 ERROR CODES THAT THEY DID NO RECOGNIZE. BECAUSE OF HOLIDAY WEEKEND NO ONE WAS AVAILABLE TO LOOK AT THE CAR UNTIL TUESDAY 9/5/06. THIS LEFT ME WITH EXTRA EXPENSE BECAUSE I HAD TO RENT A CAR FOR THE DURATION OF MY VACATION AND HAD TO STAY AN EXTRA DAY FOR CAR. DEALERSHIP CONTACTED CHRYSLER AND THEY INSTRUCTED THEM TO REPROGRAM COMPUTER AND DRIVE AND RE-TEST. NO ERROR CODES REAPPEARED AND GAVE ME MY CAR BACK. WHILE DRIVING BACK HOME FROM CALIFORNIA ON 9/5/06 CAR ENGINE SHUT OFF WHILE AT STOP LIGHT. AGAIN HAD TO TURN OFF TO GET RESTARTED. TOOK INTO LOCAL DEALERSHIP IN HOMETOWN NEXT DAY AND THEY COULD NOT FIND ANYTHING WRONG AFTER HAVING CAR FOR A DAY. AGAIN ON 9/18/06 WHILE DRIVING OUT OF PARKING STRUCTURE, CAR ENGINE AGAIN SHUT OFF. LUCKILY, I DID NOT HIT ANYONE OR ANYTHING. TAKING BACK TO DEALERSHIP AGAIN. *JB
Power train, Sep 8, 2006
VEHICLE HAS TRANSMISSION ISSUES AND BEGAN AT 641 MILES AFTER PURCHASING BRAND NEW. TRANSMISSION HESITATION, VEHICLE DOES NOT SEEM TO KNOW HOW TO SHIFT PROPERLY AND HESITATES WHEN ACCELERATING OR PULLING IN TO TRAFFIC. HAS CAUSED SEVERAL NEAR MISSES WHEN TRYING TO PULL IN TO TRAFFIC, PASS ON THE INTERSTATE OR SAFELY GET OUT OF SOMEONE'S WAY. VEHICLE HAS HAD NUMEROUS PARTS REPLACED NOT RELATION DIRECTLY TO THIS ISSUE. VEHICLE HAS ACCELERATED ON ITS OWN WHEN APPROACHING A STOP LIGHT AND HAS TRIED TO LURCH FORWARD WITHOUT MY FOOT ON FROM THE ACCELERATOR AND FIRMLY APPLIED TO THE BRAKE. VEHICLE HAS BEEN IN FOR THIS ISSUE ON NUMEROUS OCCASIONS AND MANUFACTURER CANNOT LOCATE ISSUE. AIRBAG INDICATOR LIGHT IS SUPPOSED TO COME ON TO INDICATE AIRBAG SYSTEM IS DISABLED WHEN THERE IS NOT ENOUGH WEIGHT IN THE PASSENGER CHAIR. IT NOT ONLY DOES THIS, IT COMES ON AND STAYS ON WITH OR WITHOUT PASSENGERS IN THE CHAIR. IT TRIGGERS THE DRIVERS INSTRUMENT PANEL LIGHT TO COME AND CHIME REPEATEDLY. THIS HAS BEEN IN FOR REPAIR 4 TIMES NOW AND CANNOT SEEM TO BE RECTIFIED. I EXPECT MORE THAN THIS FROM A BRAND NEW VEHICLE AND FEEL I HAVE NOT BEEN TREATED FAIRLY BY CHRYSLER WHEN TRYING TO ADDRESS THIS ISSUE. *JB
Power train, Sep 8, 2006
VEHICLE HAS TRANSMISSION ISSUES AND BEGAN AT 641 MILES AFTER PURCHASING BRAND NEW. TRANSMISSION HESITATION, VEHICLE DOES NOT SEEM TO KNOW HOW TO SHIFT PROPERLY AND HESITATED WHEN ACCELERATING OR PULLING IN TO TRAFFIC. HAS CAUSED SEVERAL NEAR MISSES WHEN TRYING TO PULL IN TO TRAFFIC, PASS ON THE INTERSTATE OR SAFELY GET OUT OF SOMEONE'S WAY. VEHICLE HAS HAD NUMEROUS PARTS REPLACED NOT RELATION DIRECTLY TO THIS ISSUE. VEHICLE HAS ACCELERATED ON ITS OWN WHEN APPROACHING A STOP LIGHT AND HAS TRIED TO LURCH FORWARD WITHOUT MY FOOT ON FROM THE ACCELERATOR AND FIRMLY APPLIED TO THE BRAKE. VEHICLE HAS BEEN IN FOR THIS ISSUE ON NUMEROUS OCCASIONS AND MANUFACTURER CANNOT LOCATE ISSUE. AIRBAG INDICATOR LIGHT IS SUPPOSED TO COME ON TO INDICATE AIRBAG SYSTEM IS DISABLED WHEN THERE IS NOT ENOUGH WEIGHT IN THE PASSENGER CHAIR. IT NOT ONLY DOES THIS, IT COMES ON AND STAYS ON WITH OR WITHOUT PASSENGERS IN THE CHAIR. IT TRIGGERS THE DRIVERS INSTRUMENT PANEL LIGHT TO COME AND CHIME REPEATEDLY. THIS HAS BEEN IN FOR REPAIR 4 TIMES NOW AND CANNOT SEEM TO BE RECTIFIED. I EXPECT MORE THAN THIS FROM A BRAND NEW VEHICLE AND FEEL I HAVE NOT BEEN TREATED FAIRLY BY CHRYSLER WHEN TRYING TO ADDRESS THIS ISSUE. *JB
Vehicle speed control, Sep 7, 2006
DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT VARIOUS SPEEDS, THE ENGINE INTERMITTENTLY REVVED AND LURCHED FORWARD WITHOUT WARNING. THE VEHICLE WAS INSPECTED BY A DEALER WHO PERFORMED A DIAGNOSTIC TEST. THE DIAGNOSTIC TEST DID NOT PRODUCE A FAILURE CODE. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS ALERTED.
Steering, Power train, Structure, Equipment, Sep 4, 2006
***SEVERAL PROBLEMS WITH 2005 JEEP CHEROKEE LAREDO 3.7*** JUST AFTER PURCHASING THIS VEHICLE IN FEB 2006 DEALER HAD TO REPLACE THE AIR CONDITIONER BECAUSE IT WOULD ONLY WORK AT ONE SPEED. AFTER THAT THE TRANSFER CASE AND SHIFTER HAD TO BE REPLACED, NEXT THE WINDSHIELD BEGAN TO LEAK MOLDING THE CARPETS, NEXT THE STEERING WHEEL BEGAN MAKING LOUD CLICKING NOISE WHEN MAKING DEEP TURNS, VEHICLE ALSO HAS SEVERE HESITATION WHEN GOING UP HILLS, NOW MY MECHANIC SAYS THERE IS TRANSMISSION FLUID ALL UNDER THE VEHICLE. HAVE ALSO BUMPED MY KNEE AGAINST THE KEY RESULTING IN STALLING. WORST OF ALL ONLY GETTING 12-14 MPG!!!!!!HAVE OWNED JEEPS IN THE PAST, VERY UNHAPPY WITH THIS ONE. *JB
Electrical system, Aug 29, 2006
I LEASED A 2005 JEEP CHEROKEE IN JUNE OF 05. WHILE TRAVELING ON I-69 TO INDIANAPOLIS IN AUGUST OF 05 MY JEEP SHUT OFF FOR NO APPARENT REASON. I CALLED THE DEALERSHIP AND TOLD THEM OF THE SITUATION. THEY TOLD ME IF IT HAPPENED AGAIN TO LET THEM KNOW. EVERYTHING WAS FINE UNTIL JUNE OF 06 WHEN WE WERE AGAIN TRAVEL ON I-69 AND THE VEHICLE SHUT OFF AGAIN. I CALLED THE DEALERSHIP AGAIN AND THEY TOOK THE VEHICLE IN FOR SERVICE BUT COULD FIND NOTHING WRONG WITH IT. WE GOT THE VEHICLE BACK AND THREE WEEKS LATER MY HUSBAND WAS DRIVING ALONE ON I-69 AND THE VEHICLE AGAIN SHUT OFF ALMOST CAUSING AN ACCIDENT. I CALLED THE DEALERSHIP AND THEY HAVE HAD IT FOR ABOUT THREE WEEKS WITH VARIOUS PEOPLE DRIVING IT WITH AN AUTO-PILOT HOOKED UP TO IT, BUT NOTHING HAS HAPPENED. SO I NOW HAVE A VEHICLE THAT I DO NOT FEEL SAFE DRIVING WITH MY 16 MONTH OLD IN THE CAR FOR FEAR THAT IT WILL JUST SHUT OFF AND CAUSE AN ACCIDENT. SOMETHING NEEDS TO BE DONE ABOUT THIS PROBLEM BEFORE SOMEONE GETS SERIOUSLY HURT.*JB
Other or unspecified, Aug 28, 2006
CONSUMER COMPLAINT CONCERNING 2005 JEEP GRAND CHEROKEE CONTINUES TO FAIL AND DEALER REFUSES TO BUY BACK VEHICLE. *KB *JB
Tires, Aug 15, 2006
THE GOODYEAR WRANGLER HP'S ON MY 2005 JEEP GRAND CHEROKEE ARE WEARING TERRIBLY! THERE ARE ONLY 6400 MILES ON THE SUV AND THE TIRES ARE FEATHERING SOMETHING AWFUL! THE VEHICLE WAS IN FOR SERVICE AND TIRE ROTATION JULY 31, 2006. I ALSO ASKED THE DEALER TO INSPECT THE TREAD WEAR ON THE TIRES. THE DEALER STATED THAT IT WAS NORMAL. I HAVE SINCE HAD THE VEHICLE EXAMINED BY A SERVICE/PARTS REPRESENTATIVE AT A DIFFERENT LOCAL DEALERSHIP. HE STATED THAT IN NO WAY WAS THE TIRE WEAR NORMAL. HE ADDED THAT THE WEAR ON MY TIRES RESEMBLES THAT OF A VEHICLE WITH NEARLY 20,000 MILES ON IT. THIS IS UNACCEPTABLE IN MY EYES. *NM
Tires, Aug 9, 2006
MY WIFE HAD A FLAT TIRE THIS DATE AND WHEN THE TIRE SHOP SHE TOOK IT TO, PULLED THE TIRE FROM THE WHEEL AND NOTICED BUBBLES ON THE WALLS ON THE INSIDE OF THE TIRE. THEY TOLD HER THE TIRE WAS DEFECTIVE, BUT SHE PROBABLY CAUSED THE DEFECT BY DRAINING IT 15 MINUTES WITH SLIGHTLY LOW TIRE PRESSURE. TIRE PRESSURES ARE MONITORED CLOSELY AND CHECKED AT LEAST MONTHLY WITH VERY LITTLE VARIATIONS EVER DETECTED. *JB
Steering, Aug 8, 2006
2005 GRAND CHEROKEE STEERING RACK LEAKED FLUID FROM BOOT. *TS THE DEALER DISCOVERED THE POWER STEERING RESERVOIR WAS DRY.*JB
Engine and engine cooling, Aug 7, 2006
MY 2005 JEEP GRAND CHEROKEE, PURCHASED MAY 12, HAS ENCOUNTERED NUMEROUS PROBLEMS WITH POWER. THE CAR SHUTS OFF WHILE DRIVING IN ANY CONDITION, AND HAS DONE SO AT LEAST 10 TIMES. MY CONCERN IS THAT SOMEBODY BEHIND ME WILL PLOW INTO ME WHEN MY CAR SHUTS OFF ON A HIGHWAY, WHICH ALMOST HAPPENED LAST WEEK. THE DEALERSHIP DOES NOT KNOW HOW TO CORRECT THIS PROBLEM, AND I WOULD LIKE TO FORMALLY FILE A COMPLAINT. *JB
Air bags, Tires, Aug 5, 2006
RED AIR BAG LIGHT ON DASH COMES ON INTERMITTENTLY THEN STAYS ON. AIR PRESSURE LIGHT COMES ON AND TIRES ARE AT NORMAL PSI. SOME DAYS BOTH LIGHTS COME ON TOGETHER. I HAVE TAKEN JEEP IN FOUR TIMES FOR SAME PROBLEM IN 17 MONTHS AND ITS DOING IT AGAIN WITHIN 3 MONTHS OF LAST SERVICE. *JB
Power train, Aug 4, 2006
I TOOK POSSESSION OF A NEW JEEP GRAND CHEROKEE ON 29 JUNE 2005. THAT AFTERNOON, WHEN FIRST DRIVEN ABOVE 60 MPH, A FRONT-END VIBRATION (OSCILLATION) WAS IMMEDIATELY EVIDENT. ACTUALLY THE VIBRATION IS PRESENT AT ALL SPEEDS. I ARRANGED FOR A SERVICE APPOINTMENT AT STEVE CHRISTY CHRYSLER JEEP HERE IN TUCSON. MY FIRST WARRANTY VISIT FOR THE VIBRATION PROBLEM WAS MADE ON 18 JULY 2005. THE DIAGNOSIS THERE WAS A BAD TIRE, WHICH I HAD REPLACED AT A GOODYEAR TIRE SHOP PER INSTRUCTIONS FROM THIS DEALERSHIP. IT HAD NO EFFECT ON THE VIBRATION. I HAVE SINCE BEEN IN TO JIM CLICK CHRYSLER JEEP IN TUCSON ON THREE OCCASIONS FOR A TOTAL OF EIGHT FULL DAYS. THE VIBRATION PERSISTS. I WAS INFORMED THAT I WOULD BE UNABLE TO HAVE FURTHER REPAIR ATTEMPTS WITHOUT DIRECTION FROM CHRYSLER ENGINEERING. THE LATEST REPAIR ATTEMPT RESULTED IN A MODIFICATION TO THE DRIVE SHAFT BY ADDING SIX WEIGHTS AT POSITIONS ON THE DRIVE SHAFT. AFTER THIS ACTIVITY, WHICH DID NOT FIX THE VIBRATION, I WAS TOLD THAT THE REMAINING VIBRATION WAS " IN THE DESIGN". I HAD A LOCAL RESPECTED AUTOMOTIVE SHOP EVALUATE THE VIBRATION AND THEY CONCLUDED IT HAD A PROBLEM. I ASKED THREE FELLOW ENGINEERS TO EVALUATE THE VIBRATION AND ALL CONCLUDED THERE WAS A PROBLEM. (NOTE, ONE OF THE ENGINEERS HAS FIVE YEARS EXPERIENCE DRIVING AND TESTING VEHICLES PROFESSIONALLY.) CHRYSLER STILL CLAIMS THE VIBRATION IS " IN THE DESIGN". THE VIBRATION IS BAD ENOUGH THAT I AM AFRAID TO TAKE THE VEHICLE ON A ROAD TRIP OR TOW A TRAILER. THE VIBRATION IS AT TIMES VIOLENT AND I DO NOT KNOW IF SOMETHING COULD BREAK OR IF THE OSCILLATION COULD CAUSE LOSS OF CONTROL. I WAS INFORMED BY A MAINTENANCE SUPERVISOR THAT THERE WERE TWO REASONS FOR CHRYSLER TO TAKE THE "IN THE DESIGN" POSITION. 1) THERE ARE THOUSANDS OF VEHICLES THAT MADE IT OUT OF THE FACTORY WITH THIS PROBLEM AND 2) THE PROBLEM IS A CHASSIS ALIGNMENT FLAW AND CAN NOT BE REPAIRED. *NM
Power train, Jul 28, 2006
DT*: THE CONTACT STATED THAT THE AUTOMATIC BRAKE MODULE LIGHT ON THE DASHBOARD ILLUMINATED CAUSING THE VEHICLE TO BE LOCKED IN PARK. THE VEHICLE WAS TOWED TO THE DEALER WHO CAN NOT FIND THE CAUSE OF THE PROBLEM
Structure, Jul 27, 2006
WITHIN WEEKS OF THE PURCHASE OF THIS VEHICLE ON 1/06, PAINT ON BUMPER BEGAN TO HAVE SMALL CHIP MARKS. AS OF 7/06 I HAVE NOTICED MORE CHIP MARKS AND ALSO A RUB MARK WHERE THE PAINT HAS JUST RUBBED OFF EASILY, WITH NO STRUCTURE DAMAGE TO THE BUMPER. ALSO PAINT NUBS ( BUBBLING) AROUND DOOR HANDLES AND PAINT IS COMING OFF OF DRIVER DOOR HANDLE AT CREASES. IT SEEMS AS IF PAINT IS POORLY APPLIED. *NM
Power train, Latches/locks/linkages, Equipment, Jul 26, 2006
PURCHASED VEHICLE ON 7-31-06. UPON TEST DRIVE THE DOOR LOCKS WOULD NT LOCK OR UNLOCK WHEN USING DOOR KEY (ANY DR IN THE CAR). THE REMOTE DID WORK. SALESMAN TOLD US 2 BRING IT IN IF IT CONT'D. TAKEN IN 5 TIMES SINCE THE 1ST TIME IN OCTOBER 05', DEALERSHIPS CANNOT DUPT THE ISSUE. LAST DEALERSHIP SAID THAT IF HE TOGGLED SWITCH ABOUT 10 TIMES IT HAPPENED, BUT THAT WAS JUST "OVERHEATING THE BUTTON & THAT IS NORMAL". PROBLEM IS I WORK IN A BUILDING W/A PRKG GARAGE & WORK ALL HRS. WHEN I GET INTO MY CAR, 4 SAFETY I LOCK THE DRS IMMED. THERE HAVE BEEN SEVERAL OCCASIONS WHERE I CAN'T DO THAT & HAVE 2 WAIT 2 GET THE CAR MOVING OVER THE 15MI AN HOUR 2 LOCK THE DRS. NEXT ISSUE IS THE DELAYED ENGAGEMENT IN THE TRANSMISSION GOING 2 REV OR DRV. THE CAR HAS BEEN IN ON 3 OCCASIONS FOR THIS ITEM OF WHICH THE DEALERSHIP CLEARS CODES OR CANNOT DUPT THE ISSUE. THIS ISSUE BECAME A AN ISSUE IN A CONSTRUCTION ZONE AT A RR TRACK NEAR OUR HOME. GATES WERE DOWN WHEN I DROVE UP & I WAS 3RD CAR BACK, THE GATES WENT UP, 2 CARS WENT THROUGH & I WAS ALMOST AT THE TRACKS WHEN THE RAILROAD ARMS STARTED COMING DOWN AGAIN. I PUT ON THE BRAKES & SHIFTED TO REVERSE 2 BACK UP & THE DELAY NEARLY CAUSED THE RR ARM 2 HIT THE CAR. I BACKED UP JUST ENOUGH TO CLEAR THE RR ARM BY LESS THAN 6 INCHES. THE LAST ITEM IS THE A/C. SINCE LATE MARCH OF 06' WE HAVE BEEN EXPERIENCING THE A/C BLOWING COLD, THEN THE AIR TURNS 2 WARM OR HOT AIR BLOWING FROM 3 SEC 2 MINUTES OF BLOWING HUMID AIR BEFORE THE SYSTEM WILL KICK IN AGAIN WITH COLD AIR. THIS HAS BEEN INTERMITTENTLY LIKE THE OTHER 2 ITEMS ABOVE. 3 TIMES INTO THE DEALERSHIPS & AGAIN IT WAS STATED THEY FIXED IT WHEN IT WASN'T OR "IT'S 114 DEGREES OUT, IT IS GOING 2 BLOW WARM AIR". "USING OUTSIDE AIR WILL MAKE THE A/C BLOW WARM AIR'. THE INCIDENT DATE IS HARD SINCE THERE ARE 3 ISSUES SO I PUT THE DAY OF PURCHASE. THE FAILURES ARE ALSO HARD TO CALCULATE, BUT SINCE THESE ITEMS HAPPEN INTERMITTENTLY & OR EVERYDAY (A/C) I COUNTED 3 MO WORTH. *NM
Steering, Jul 25, 2006
DT*: THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE STEERING EMITTED A GROWLING NOISE, AND BECAME DIFFICULT DURING LOW SPEED TURNS. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE IT WAS DETERMINED THAT ALL THE POWER STEERING FLUID LEAKED INTO THE STEERING BOOTS.
Service brakes, Hydraulic, Jul 19, 2006
I HAVE A 2005 4X4 GRAND CHEROKEE (HEMI) WITH 26,000 MILES AND HAD TO HAVE NEW ROTORS AND BRAKE PADS....1054.00 (MAJORITY OF MY DRIVING IS HIGHWAY MILES). I HAVE HAD MY JEEP IN TO THE DEALERSHIP A FEW TIMES TO ALSO CHECK OUT A VERY LOUD NOISE IN THE REAR END OF THE JEEP ( HAPPENS 2-3 TIMES A DAY) USUALLY WHEN I PUT IT IN REVERSE. THE DEALERSHIP SAID THEY CAN NOT FIND ANYTHING WRONG. *NM
Power train, Jul 17, 2006, crash
2005 JEEP GRAND CHEROKEE TRANSMISSION FAILED. *TS THE CONSUMER WAS STILL HAVING PROBLEMS WITH THE TRANSMISSION AFTER THE RECALL WAS PERFORMED. WHEN THE CONSUMER ATTEMPTED TO PULL OVER, BECAUSE THE TRANSMISSION WOULD JUMPED FROM 4TH TO FIRST AND BACK TO 4TH GEAR. THE CONSUMER SUBSEQUENTLY CRASHED INTO A POLE. *JB
Engine and engine cooling, Jul 17, 2006, fire
WHILE DRIVING 2005 JEEP GRAND CHEEROKE LAREDO THERE WAS A FIRE IN THE ENGINE. *JB
Power train, Jul 15, 2006
I HAVE A 2005 JEEP CHEROKEE WITH 3,000 MILES. I TOOK IT IN FOR A TRANSMISSION SEAL RECALL, E13. TWO DAYS AFTER IT WAS SERVICED, I WAS ON THE HIGHWAY AND THE TRANSMISSION BURNED UP, LEAVING ME STRANDED. CAR HAD TO BE TOWED 150 MILES TO DEALER WHO HANDLED RECALL. MY CAR HAS BEEN IN THE SHOP A MONTH. I AM HAVING TO PAY DAILY CAR RENTAL WHICH HAS NOW COST ME OVER $1,200 IN ADDITION TO HAVING TO MAKE A CAR PAYMENT FOR A CAR I DON'T HAVE. I KEEP GETTING DIFFERENT ANSWERS FROM DEALER, SAID TRANSMISSION ORDERED DAYS AGO FROM NEW JERSEY, NOW SAYS IT WAS ORDERED YESTERDAY, JULY 14, HE SAYS HE CAN'T TELL ME ANYTHING, WHEN, IF IT IS NEW OR REBUILT, OR HOW MUCH LONGER I HAVE TO WAIT. I HAVE NEVER BEEN TREATED SO RUDELY BY A DEALERSHIP, MANAGER, AND SERVICE MANAGER. I WILL NEVER PURCHASE A VEHICLE FROM THAT DEALER AGAIN AND I AM INCLINED TO NEVER BUY ANOTHER JEEP PRODUCT. I AM AT THE POINT OF TURNING THE CAR BACK AND SEEKING LEGAL ACTION IF SOMETHING ISN'T DONE ABOUT THIS OUTRAGEOUS SITUATION. *JB
Air bags, Jul 9, 2006
CAR'S SIDE AIRBAG KEPT SWITCHING ON AND OFF ONE DAY WHILE DRIVING THE JEEP. *JB
Electrical system, Vehicle speed control, Jul 7, 2006
AFTER FILLING THE GAS TANK OF MY 2005 JEEP GRAND CHEROKEE 5.7 LITER HEMI I ACCELERATED ONTO THE INTERSTATE AND THE CAR BEGAN TO DECELERATE AND ALL THE INFORMATION LIGHTS CAME ON AND BEGAN TO FLICKER ON AND OFF AS WELL AS THE HEADLIGHTS. VEHICLE THEN PROCEEDED TO DRIVE NORMALLY WITH CHECK ENGINE LIGHT ON BUT NOT PULSATING. DEALER NEXT DAY COULD NOT LOOK AT IT AS I DID NOT HAVE AN APPOINTMENT. AFTER SEVERAL STOPS AND TURNING ENGINE OFF THE CHECK ENGINE LIGHT WENT OUT. SEVERAL DAYS LATE THE INFORMATION GAUGE LIGHTS FLASHED AND RECEIVED A CODE MESSAGE TO SERVICE ELECTRIC BRAKE SYSTEM. THEN THEY RECYCLED AND HAS BEEN CLEAR SINCE. *NM