2016 Kia Soul
Problems, recalls and owner-reported issues
Engine is the leading concern among 821 owner complaints filed for this model year. This is the 3rd highest complaint count among 16 Soul model years with reports.
Of the 2016 reports, 29 involved a crash and 35 involved a fire. 25 people were injured.
What owners report most often
Recalls and investigations
EngineFeb 22, 2019
Kia Motors America (Kia) is recalling certain 2012-2016 Kia Soul vehicles equipped with 1.6L Gasoline Direct Injection (GDI) engines. High exhaust gas temperatures may damage the catalytic converter, possibly resulting in abnormal engine combustion and damage to one or more of the engine's pistons and possible piston connecting rod failure.
Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire.
Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. The recall began April 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC176.
Campaign 19V120000 on NHTSA.gov
SteeringSep 29, 2017
Kia Motors America (Kia) is recalling certain 2014-2016 Soul and Soul EV vehicles. The pinion plug may allow the pinion gear to separate from the steering gear assembly.
If the pinion gear separates, steering will be lost, increasing the risk of a crash.
Kia will notify owners, and dealers will inspect and secure the pinion plug or replace the steering gear assembly, as necessary, free of charge. The recall began November 16, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC155. Note: This recall supersedes campaigns 14V-332 and 15V-736. Vehicles previously remedied under those numbers are being recalled again under this campaign.
Campaign 17V608000 on NHTSA.gov
Representative owner complaints
821 reports, newest first.
Other or unspecified, Fuel/propulsion system, May 24, 2023
While driving my car it started slowing down all at once like it wasn't getting gas, to about 10 mph. I was traveling approximately 55 mph. The vehicle that was behind me almost rear ended me. Had it checked and they told me that it was related to the cadillac converter (02) system. It needed replaced.
Electrical system, Engine, Visibility/wiper, May 22, 2023
CARMAX sold a recalled vehicle in 2019 in 2020. KIA has still improperly repaired the vehicle the car is still doing the exactly same thing it was doing. That lead to the repair. After picking within the hour the engine light came back on and had been on ever since. I now have electrical issues with the window since KIA Napelton of Elmhurst repaired the vandalism the wiper is malfunctioned at pick up. I want a refund the vehicle is a safety issue mechanical and for theft.
Electrical system, Engine, Visibility/wiper, May 22, 2023
The car was recalled in 4/2019 for a repair. I purchased the car 8/2020. The repair indicated catalytic converter assessment to ensure that the engine did not need to be replaced. It was not checked or verified. The recall was insufficient done and the car should had never been sold. And the recall was not completed prior. I took the vehicle in to complete a recall on a hazardous vehicle. Kia had my car for a month and half replacing the engine and within hours of picking up my car the engine light came back on. The car is still doing the exact same thing it was doing leading up to original repair. That Kia was suppose to had fixed. The car is also a theft safety issue as targeted I already paid 2700 for theft vandalism. The car is targeted and unsafe.
Engine, May 20, 2023
My car engine blew and I contacted kia to get the engine replaced under the recall and the refused to do it.
Engine, May 18, 2023
While traveling down 20E around MM83 in South Carolina, the car suddenly lost power and throttled down to around 10-15 miles per hour. Upon having in towed to a garage for a diagnostic, I was told that the catalytic converter had overheated and stalled the vehicle. This appears to be an issue that would be covered under NHTSA Recall 19V120, dated April 12 2019, which reads in part "Under certain conditions, the catalytic converter may become damaged due to overheating caused by an excessive increase of exhaust gas temperatures." The heat scoring on the catalytic converter and the stall are consistent with this kind of behavior. When I contacted the dealer, they denied any such recall existed. I am currently waiting for a response from Kia America, Inc.
Engine, May 16, 2023
I was driving to Bend, Oregon on the highway when suddenly my car started making clunking noises and the oil light and check engine lights came on. I started to lose power and the car was slowing. I immediately managed to pull over, but it gets very dangerous since it was a busy highway. I had the car towed to a mechanic who said the engine blew and needed to be replaced. Kia has denied my warranty claims.
Other or unspecified, Fuel/propulsion system, May 10, 2023
The catalytic converter, which is a known issue for Kia Soul models from 2012-2016 has started to show signs of failure- namely code P0420. This is despite having the apparent “fix” as detailed in Kia recall SC176, which was a mere software update. Now that the converter has shown signs of failure, Kia refuses to honor the replacement as stated in the recall since the vehicle is above 80,000 miles. Clearly, the recall did not fix the issue.
Engine, May 9, 2023
No warning lights/codes. Veh lost power. Was catalytic converter. Veh VIN did not fall under recall. Had to replace converter at our cost. Safety concern? Car had potential fire from overheated converter and could have killed my 19 y/o daughter who drove the car as primary veh. The car is barely 6 years old and just paid it off. Got the high end adult version w/ sunroof, leather seats, lights, all bells & whistles. Paid 29k & engine failed due to driving car without knowing converter was bad. Never rec'd notice because our VIN was not included. Dealer wants to charge us 9000$ to replace engine at OUR cost. DO NOT BUY THIS VEHICLE EVER. THEY REFUSE TO FIX IT UNLESS WE PAY FOR IT. Filed a case w/ Kia Consumer Center, but since engine failure is not covered under warranty, they will not replace engine. We now have a car that is useless. We can't afford another car. This was our mid life car that we thought would last a long time that we passed down to our daughter. She drove it about 6 months before this happened. Literally, as soon as it was paid off, it broke. Horrible car and horrible manufacturer. NEVER EVER NEVER UNDER ANY CIRCUMSTANCES, BUY A KIA!!!!
Vehicle speed control, Service brakes, Engine, May 6, 2023
Engine and brake lights have come on. Engine knocks bad. Vehicles stall when pressing gas. Dangerous driving soecialy going through stop sign. Low power while pressing gas.
Engine and engine cooling, Engine, May 3, 2023
The contact's girlfriend owns a 2016 Kia Soul. The contact stated while his girlfriend was driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to respond and would not exceed 55 MPH. Additionally, the vehicle began to decelerate unintendedly. The vehicle was taken to the contact's location. The contact then took the vehicle to an independent mechanic, where it was diagnosed that the catalytic converter was clogged, which created back pressure in the engine and loss of power. The mechanic related the failure to NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The dealer was notified of the failure and informed the contact that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 154,000.
Engine, Apr 29, 2023
This vehicle, Kia Soul 2016, uses excessive oil, no matter what the manufacturer or dealers say. There is no reason to put 1 to 1/2 quarts of synthetic oil in this vehicle every week to make sure the engine doesn't seize. Severe manufacturer flaw and/or design with this engine.
Engine, Apr 22, 2023
Previous NHTSA 11498487 for the same issue reported on 12/22. After 8 months of changing the catalytic converter the Kia Soul 2016 de-accelerated in the highway from 60mph to barely 30Mph with a burning smell the check engine light come up and the code once again for the catalytic converter. The catalytic converter was replaced under the warranty from the repair shop on 1/23. Now on 4/23 the check engine light is on again for the catalytic converter again. The repair shop won't change it again. Instead they suggested to bring it to the dealership. Kia dealership stated that my VIN is not included in the recall and they only did theE PI2002A ECU update the rest is not covered by the manufacturer warranty. I've changed 3 times the catalytic converter and the light is code is asking for another one. It's not normal. Major safety hazard for the vehicle to stall in the highway suddenly. Proper maintenance and oil changes are done on time as suggested by Kia. However it burns oil after a new change before hitting the 3,000 miles driven short distances and engine is less than a quart with no leeks at all. Another safety hazard because there's no warning light of low engine oil that could possibly cause the engine to stop and hazard to driver and others.
Engine, Apr 18, 2023
As we were driving on the highway, the check engine light started flashing on my car and it proceeded to go into limp mode. This proved to be a danger to me and everyone driving around me. The car would not accelerate and would shake violently. I had to pull over on the side of the highway. The only light that ever appeared was the CEL, when it was already too late. Upon taking it to a mechanic we were told that the 1st and 3rd cylinders were complete garbage and a whole engine replacement was necessary.
Engine, Apr 17, 2023
The contact owns a 2016 Kia Soul. The contact stated while driving approximately 65 MPH, the vehicle stalled and failed to restart. The check engine warning light was illuminated prior to the failure. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the previous owner repaired the vehicle under NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling) and 17V608000 (Steering); however, the failure recurred. The manufacturer was notified of the failure. The failure mileage was approximately 150,000.
Electrical system, Other or unspecified, Engine, Apr 15, 2023
Car cuts off when idling. I took it to the mechanic several times and they produced the issue once but could not diagnose and would give it back to me at no charge. When it cuts off the RPMs will sometimes stay at 0 even when I start the car again. Sometimes the check engine light will come on along with the traction light. Mechanic said it shows catalytic codes but said nothing is wrong with catalytic converter. They said they can’t find anything wrong to warrant repair. The check engine and traction control lights stay on and then go off randomly. The car cuts off at stop lights and today it cut off when I was turning right at a stop sign. I was already out in the road and someone was behind me. Thankfully no one was coming down the road at full speed. I am afraid to drive the car but no one knows what is wrong with it or how to fix it.
Engine, Apr 15, 2023, fire
Was idling at a red light, the engine warning light came on, and my engine set on fire. No reason. I jumped out of the car. Thankfully someone came over and threw water on it. Engine to be completely rebuilt (under warranty). Took 3 weeks.
Engine and engine cooling, Engine, Apr 14, 2023
The contact owns a 2016 Kia Soul. The contact stated that the vehicle was previously included in NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling) regarding the heat shield for the catalytic converter, which, was replaced under the recall. The contact stated that the vehicle began to malfunction after the repair. The vehicle would jump and shift into gear roughly while driving at various speeds. The RPM was revving abnormally. The contact stated that it seemed as if the vacuum seal had detached underneath the vehicle, and the vehicle was making a whistling sound while accelerating. The check engine warning light was illuminated. The vehicle was taken to the dealer who informed the contact that the catalytic converter replaced since the recall was closed. The manufacturer was made aware of the failure. The approximate failure mileage was 99,000.
Engine and engine cooling, Apr 13, 2023
The contact owns a 2016 Kia Soul. The contact stated while starting the vehicle, the check engine warning light illuminated. The vehicle was taken to the dealer for a diagnostic test and the dealer stated that the catalytic convertor needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but provided no assistance. The failure mileage was 88,520.
Firerelated, Apr 10, 2023, fire
The contact was an administrator of a probate trust who was filing a complaint on behalf of the deceased owner of a 2016 Kia Soul. The contact stated that while a relative of the deceased was driving at an undisclosed speed, the vehicle was shaking. No warning lights were illuminated. The deceased relative pulled over into a parking lot and noticed there was smoke coming from the engine compartment before the vehicle caught fire. The fire department arrived on the scene and extinguished the fire. No injury was sustained. Police and fire department reports were filed. The vehicle was towed to a tow lot. The vehicle did not have insurance coverage. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Engine and engine cooling, Engine, Apr 6, 2023
The contact owns a 2016 Kia Soul. The contact stated while her daughter was driving approximately 35 MPH and ascending a slight grade in the road, the vehicle stalled. The check engine and oil pressure warning lights were illuminated. The contact stated that her daughter was able to restart the vehicle. The contact stated that the oil pressure warning light had been illuminated intermittently even after routine oil changes. The vehicle was taken to the local dealer, where it was diagnosed that the gas cap needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the dealer. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The manufacturer was not notified of the failure. The failure mileage was approximately 75,000.
Steering, Apr 4, 2023
Driving around curves my car slows dramatically and traction control light comes on. I have no ability to steer at this point until the car “breaks free” and allows acceleration again. It’s as if the ABS system kicks on all on its own. The sound it makes is as though the brakes are kicking in to slow the vehicle. It almost comes to a stop on curves. Steering intermittently loosens on its own while driving and I lose controlled steering as there is a lot of play in the steering wheel. Then it will tighten up again as if it’s a brand new car. There is an occasional pop noise but it’s not constant and doesn’t make the sound when driving at speeds greater than 40mph. No other sounds are present. I contacted Kia as they placed a set screw in the steering for a pinion plug recall repair to keep a nut from backing out and this was not properly documented by the previous service department per the new management. There were no images of the repair that was done and no notes in the repair log according to the young lady I spoke with. No evidence of a repair other than being marked in the system.
Engine, Apr 4, 2023
The contact owns a 2016 Kia Soul. The contact stated that while driving approximately 70 MPH, the engine seized without warning. The vehicle was towed to the local dealer where it was diagnosed that the rod bearing had failed. The vehicle was not repaired. The manufacturer was contacted but provided no additional assistance due to the vehicle not meeting the Warranty Extension requirements. The failure mileage was approximately 100,000.
Other or unspecified, Engine, Apr 3, 2023
2/17/23 Car was disabled on highway lost speed in the middle of traffic and could not go over 20MPH at dealership- it was confirmed that catalytic convertor went out. 2/23/23 Car CC was replaced picked it up and noticed weird sound from engine 2/24/23 Car returned to dealership 3/3/23 Dealership stated the engine was bad 3/13/23 We were informed that KIA would not cover the repairs and we had to pay $5700 4/3/23 Dealership called and said car was ready to be picked up Car has 78,000 miles on it and has been well maintained - we have all of the service records We understand there is a class action lawsuit where high exhaust gas temperatures may damage the catalytic convertor, resulting in abnormal engine combustion damaging the engine. We have been told that our engine did not qualify under the VIN number that we had. KIA has had known engine problems for over 12 years and we feel that the CC damaged the engine and this is what caused the failure. There were no warning signs, no smoke out of the exhaust etc We just keep getting the run around saying that our VIN was not part of the recall even though our engine had only 78,000 miles and it was very well maintained. Please let us know if we can get any help in paying for this huge expense
Engine, Mar 31, 2023
Catalytic converter issues. I've had to get it replaced several times already and still issues. car burns oil like crazy as well and I have had to add oil throughout the week. it's been this way since I bought it in 2018. 2016 Kia Soul +
Engine, Mar 29, 2023
Horne Kia in Gilbert Arizona tore down our engine and found it damaged beyond repair. We were told by the aforementioned dealership that the engine would need to be replaced. Kia has given our engine a 15 year / 150,000 mile warranty due to this nation wide Kia / Hyundai engine defect situation. Our vehicle has around 79,000 miles and is a 2016 model. Still Kia refuses to replace the engine. The safety problem that comes into play is that Kia is telling us to continue driving our vehicle until the engine completely freezes up. Kia is sending ours and many others vehicles back out on the road in this condition. These vehicles can break down at any time and create a possible incident that could be detrimental to the safety of the driver and others in the area.