2021 Kia Soul

What owners report most often

1. Engine134
2. Engine and engine cooling47
3. Power train26
4. Other or unspecified26
5. Electrical system15
6. Fuel/propulsion system10
7. Service brakes10
8. Steering9

Recalls and investigations

1. Engine and engine cooling, engine, hard parts internal/mechanicalFeb 17, 2025

   Kia America, Inc. (Kia) is recalling certain 2021-2023 Seltos and Soul vehicles. The piston oil rings may have been manufactured incorrectly, which can result in engine damage.

   Engine damage can cause a vehicle stall or fire, increasing the risk of a crash or injury.

   Dealers will inspect and replace the engine as necessary, free of charge. Dealers will also install piston-ring noise sensing system (PNSS) software, free of charge. Owner notification letters were mailed April 4, 2025. Owners may contact Kia customer service at 800-333-4542. Kia's number for this recall is SC336.

   Campaign 25V099000 on NHTSA.gov

2. EngineApr 13, 2021

   Kia Motors America (Kia) is recalling certain 2020-2021 Soul, and 2021 Seltos vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which may result in engine damage.

   A damaged engine may stall, increasing the risk of a crash. In addition, oil may leak onto hot exhaust components, increasing the risk of a fire.

   Kia will notify owners, and dealers will inspect and, if necessary, replace the engine, free of charge. In addition, Kia will deploy Piston Ring Noise Sensing System (PNSS) software. The recall began June 11, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC209.

   Campaign 21V259000 on NHTSA.gov

Representative owner complaints: engine

180 reports, newest first. Show all

1. Engine, May 28, 2026

   2021 Kia Soul | VIN: [XXX] | Recall SC336 (NHTSA 25V099) | Kia America Case No. XXX DEALER: Team Kia of El Cajon, 541 N. Johnson Ave, El Cajon, CA 92020 SYMPTOMS: Rapid oil consumption, abnormal engine noise, overheating, vehicle stalling at complete stops, difficulty restarting. All symptoms are explicitly documented in SC336 TSB (Rev 6, 10/21/2025) as consequences of defective piston oil rings. DEALER CONDUCT ISSUES: 1. CHARGED $280 DIAGNOSTIC FEE TO PERFORM A RECALL. Owner confirmed open recall on VIN before arrival. Dealer required $280 diagnostic payment as condition of recall service, in violation of 49 U.S.C. 30120. 2. 24-HOUR TSB PROTOCOL VIOLATION. SC336 TSB requires engine vibration inspection no sooner than 24 hours after R/O open date. R/O opened May 16 at 7:38 AM. Inspection report also dated May 16 with no timestamp. If test ran same day, PASS result is invalid under Kia's own guidelines. 3. FAILED TO OPEN REQUIRED TECHLINE CASE. SC336 TSB Page 2 states: if engine noise is present and inspection results in PASS, dealer must open a Techline case. Owner continues to experience engine noise. Dealer has not provided a Techline case number despite two written requests. 4. DEMANDING $2,500 FOR RECALL-RELATED SYMPTOMS. Dealer is attributing stalling and oil consumption to a separate camshaft issue and demanding $2,500 more. SC336 TSB documents that piston ring damage causes cascading engine damage including timing components. 5. OWNER IS [XXX] , drives for Uber. Vehicle out of service 12+ days. Lost income and rental costs incurred. Kia America corporate (Case XXX) has been copied on correspondence but has not responded. Requesting NHTSA review of this dealer's SC336 recall compliance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2. Suspension, Power train, Engine, May 26, 2026

   Cv joint and axle causing car to stall when turunning

3. Engine and engine cooling, May 19, 2026

   The contact owns a 2021 Kia Soul. The contact stated that upon starting the vehicle, the oil pressure sensor light was illuminated. The vehicle was making an abnormal knocking sound. The contact had to add additional oil. The vehicle was taken to an independent mechanic who informed the vehicle was related to the recall. The vehicle was towed to the local dealer, where it was diagnosed that the camshaft and timing needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle was taken previously to the local dealer for NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The manufacturer was contacted, who confirmed there was no warranty coverage. The failure mileage was approximately 126,000.

4. Engine and engine cooling, May 15, 2026

   The contact owns a 2021 Kia Soul. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined that one cylinder had low pressure while the other three cylinders had pressures higher than 100%. The contact was informed that the engine needed to be replaced. The vehicle was then taken to the dealer, who performed the recall repair under NHTSA Campaign Number: 25V099000 (Engine And Engine Cooling); however, the engine was not replaced. The piston ring was tested and passed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 109,000.

5. Engine and engine cooling, May 14, 2026

   The contact noticed the oil drained quickly and RPMs increased rapidly upon starting the vehicle. The approximate failure mileage was 86,100. The vehicle was taken to the dealer where the ECU was replaced twice, the piston rings were not replaced; the issue persisted. The manufacturer was notified of the issue. The approximate failure mileage was 86,100

6. Engine and engine cooling, May 6, 2026

   The contact owns a 2021 Kia Soul. The contact stated while driving at approximately 25 MPH, the vehicle stalled. All of the warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed that the alternator needed to be replaced. The vehicle was repaired however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 75,000.

7. Engine, Apr 24, 2026

   On [XXX], the check engine light illuminated. No other warning indicators activated — no low oil pressure warning, no low oil level warning, no driver alert of any kind regarding engine condition. On [XXX], at approximately 53,845 miles, the vehicle began running rough. I checked the engine oil and found the dipstick registered empty — no measurable oil in the engine. No low oil level or low oil pressure warning had been provided by the vehicle at any point prior to this discovery. I added two quarts of oil. The vehicle stalled while being driven to obtain the oil, and stalled again after the oil was added. I drove the vehicle to Jiffy Lube and had a full oil change performed. Mileage at the oil change was 53,852. I then scheduled an appointment with Gervais Kia in Lowell, Massachusetts, the nearest Kia dealer, less than one mile from my home. The earliest available appointment was approximately one week later. Because the vehicle stalled repeatedly at idle, I drove it to the dealer using both feet — keeping engine revs elevated with the accelerator while braking — to prevent stalling at stops. The vehicle is currently at Gervais Kia for diagnostic inspection. The symptoms match the failure mode documented in NHTSA recall campaign 25V-099 (Kia recall for 2021-2023 Soul and Seltos with 2.0L Nu MPI engines, piston oil ring manufacturing defect). My vehicle has the 2.0L Nu MPI engine and was manufactured at the Kia Autoland Hwaseong plant identified in the recall filing. However, my VIN does not appear in the current recall population per NHTSA VIN lookup and Kia’s recall lookup. The recall remedy includes installation of Piston-ring Noise Sensing System (PNSS) software specifically because the defect provides no driver warning before failure — consistent with my experience, in which the engine ran empty of oil with no warning whatsoever. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

8. Engine, Apr 23, 2026

   My 2021 Kia Soul experienced repeated overheating despite replacement of major cooling system components including the thermostat and water pump. The vehicle continued to overheat and was later diagnosed by a Kia dealership with engine damage requiring full engine replacement. This failure occurred around 105,000 miles. The symptoms and failure pattern are consistent with known issues affecting similar Kia engines, yet my VIN is not included in any recall. I am concerned this represents a broader defect that may not be fully captured in current recalls.

9. Engine, Fuel/propulsion system, Apr 20, 2026

   What component or system failed or malfunctioned? The engine (piston rings) and catalytic converter failed. The catalytic converter is available for inspection upon request. How was safety put at risk? The engine ran low on oil without any external leak, causing warning lights and engine rattling. Low oil pressure can lead to sudden engine seizure or fire. The failed catalytic converter can clog, causing loss of power on highways and increasing the risk of a crash. Has the problem been confirmed by a dealer or independent shop? Yes. A Kia dealer found the engine 2 quarts low, with no external leak, and recommended replacing the catalytic converter at a cost of over $6,000. An independent mechanic confirmed code P0420, which indicates catalytic converter failure. Has the vehicle been inspected by the manufacturer? The vehicle was inspected by an authorized Kia dealer, but they did not complete the required inspection for Recall SC336 (defective piston oil rings). They did add the software. Were there warning lamps or other symptoms? Yes. The oil pressure warning light and other dashboard lights came on. The engine made a rattling noise. The vehicle later felt sluggish on acceleration, fuel economy dropped, and the exhaust developed a smell. The check engine light came on and later turned off, but code P0420 was stored in the system.

10. Engine, Apr 16, 2026

    the engine is consuming a quart of oil per thousand miles.

11. Engine, Apr 15, 2026

    Hi my vehicle was stolen and the police found the vehicle. The car was damaged part of the damages was a broken ignition. I am unable to fix the damages until I get paid from the kia classaction lawsuit. The car still starts and stays running. I have the key for the car but I have been starting the car was butter knife bc it's easier then the key. I made an appointment to have the oil piston ring looked at. When I brought it I. They refused to look at it bc it has a broken ignition. I don't think the safety recall has anything to do w the ignition. The car is easy to turn on and shut off. I wouldn't care if my car wasn't stalling at traffic lights. My car is going thru a lot of oil. I am not working currently. This car was purchased for me by my dad. He paid cash for it. He bought it bc I had just been diagnosed w a rare autoimmune disease. He bought it so I would have something safe and reliable to drive in. We have had nothing g but problems since day 1. All I wanted was for them to look at it so im not going to be in harms way. Idk what to do the dealership said they cant look at it until I fixed the ignition. But like I said I won't have money to do that until I get the class action lawsuit.

12. Engine, Apr 15, 2026

    I am filing a complaint regarding a safety recall (NHTSA Recall 25V099) on my 2021 Kia Soul that was marked as completed, but the defect was not properly repaired. On 3/17/26, I took my vehicle to a Kia dealership to have the recall addressed. The dealership performed only a software update and diagnostic testing and marked the recall as complete. No engine repair or replacement was performed. Within approximately one week of this recall service, my engine suffered a catastrophic failure while driving, resulting in a hole in the engine block and total engine failure. This created a serious safety risk due to sudden loss of power and fire hazard. I then had the vehicle inspected by a second Kia dealership. They informed me that the engine failure was consistent with the defect described in recall 25V099 (piston oil ring failure) and that the prior recall repair did not correct the underlying issue. This indicates that the recall remedy performed on my vehicle was incomplete or ineffective, and that the vehicle was returned to me in an unsafe condition. I am concerned that other vehicles may be receiving only software updates without proper inspection or repair, which could lead to similar dangerous failures. I am requesting that this situation be investigated as a failed recall remedy and a continued safety risk. Timeline: 3/17/26: Recall repair performed (software update only) 3/29/26: Engine failed catastrophically 4/2/26: Second dealership confirmed failure related to recall defect

13. Power train, Electrical system, Engine, Apr 8, 2026

    Mi carro hay veces que prende la luz de la engine, lo lleve a checar y salió en la computadora que era un problema de Power Train system, que era secondary DTCs P1C28 Y P1C28000, lo busque en Google y salía que era un problema muy recurrente en Kias souls y sorentos. Que podría causar incendios

14. Power train, Engine, Apr 8, 2026

    The contact owns a 2021 Kia Soul. The contact stated that while driving approximately 80 MPH, the vehicle unexpectedly stalled, with the check engine warning light illuminated. The vehicle was restarted; however, the failure reoccurred. The contact stated that while driving uphill, the vehicle failed to accelerate as needed. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and case was opened. The approximate failure mileage was 41,000. The VIN was not available.

15. Engine, Mar 30, 2026

    I am writing to formally report a failure by Classic Kia of Streetsboro to provide the federally mandated safety remedy under Recall SC336 for my 2021 Kia Soul (VIN: [XXX] ). I have reason to believe the dealership has bypassed the mandatory safety protocols by intentionally omitting my documented diagnostic data—specifically Codes P0014/P0017, engine stalling, and excessive oil consumption—from the Techline Case Narrative. Evidence of Non-Compliance: 1. Improper Component Installation: Despite the documented timing failures, the dealership appears to have installed a Short Block (Part # 21102) instead of the required Long Block Assembly (Part # 21101-QQK). This leaves my oil-contaminated camshafts, valves, and VVT solenoids in the vehicle, posing a continued stalling risk. 2. Failure to Address Consequential Damage: The dealership is attempting to charge me a $99 "Customer Pay" fee for a catalytic converter back-pressure test. Under SC336, testing for consequential damage caused by a defective engine is the manufacturer's responsibility. 3. Withholding Documentation: The dealership has refused to provide the Techline Case Number or the Engine Part Number upon request, preventing me from verifying that the safety remedy was performed correctly. I will not be taking possession of the vehicle until Kia Corporate verifies that a Long Block Assembly was installed and that all diagnostic fees related to the recall symptoms are waived. This matter is currently being escalated but could definitely use your assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

16. Engine, Mar 29, 2026

    NHTSA SAFETY COMPLAINT: RECALL SC336 (CAMPAIGN 21V-301) NON-COMPLIANCE VIN: [XXX] I. PATTERN OF RECALL EVASION Vehicle (2021 Kia Soul) was towed to Classic Kia [XXX] ) on 3/13 with documented engine stalling, knocking, and codes P0014/P0017 (VVT/Timing failure). The dealership withheld this data from Kia Techline for 13 days (3/13–3/26), delaying the safety remedy until state authorities intervened. II. MECHANICAL IMPOSSIBILITY & REMEDY VIOLATION On Saturday 3/28, the dealer claimed a full engine swap was "installed and tested" in only 6.5 hours (7:30 AM–2:15 PM). Per the SC336 mandate, a compliant Long Block assembly (Part # ending in QQK) requires extensive fluid flushes, software reflashing, and safety recalibrations that cannot be performed correctly in this window. I suspect a "Short Block" shortcut was taken, reusing contaminated components in violation of the federal safety remedy. III. FRAUD BY OMISSION & UNIFIED SAFETY HAZARD The dealership is demanding a $99 "diagnostic fee" for an exhaust back-pressure test. Under SC336, testing for "consequential damage" (clogged catalytic converter) caused by the recall defect must be covered by the manufacturer. By omitting the stalling/timing symptoms from the initial Techline report, the dealer bypassed the mandatory exhaust safety testing. Reusing oil-contaminated VVT solenoids, camshafts, and valves from the failed engine poses an immediate fire and safety hazard. IV. DEMAND FOR INVESTIGATION I request NHTSA oversight to ensure Classic Kia provides: 1. Proof of Long Block (21101-QQK) installation vs. unauthorized Short Block (21102). 2. Time-stamped DEVT and GDS Full System Scan logs from 3/28. 3. Verification that all contaminated components were replaced, as a partial remedy leaves the vehicle in a hazardous state. Reusing oil-soaked VVT/cams & skipping exhaust tests creates a fire risk. An incomplete remedy violates SC336, leaving the car a high-risk liability for fire & stalling. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

17. Engine and engine cooling, Mar 23, 2026

    The contact owns a 2021 Kia Soul. The contact stated that while driving approximately 40 MPH, the vehicle started losing automotive power. The message that the engine was overheating warning was flashing on the instrument panel with an audible chime. The contact pulled over but was unable to restart the vehicle. The vehicle was towed to a local dealer and was diagnosed with engine failure. The contact stated that the VIN was included in NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling); and was advised by the dealer that the engine failure was not related to the recall, and the dealer refused to perform the recall repair. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was unknown.

18. Engine and engine cooling, Mar 23, 2026

    The contact owns a 2021 Kia Soul. The contact stated that while driving at an undisclosed speed, there was an abnormally loud sound coming from the vehicle with the check engine warning light illuminated. The vehicle idled abnormally rough, and the engine was pulsing. The oil level was checked and was noticeably low. The contact added oil to the engine. The vehicle was taken to Precision Auto Care for an oil change. The contact was informed that the oil level was low. The contact informed the technician that the oil had been recently topped off. The contact was informed of the excessive oil consumption. The contact was provided with information on NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The vehicle was taken to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced or repaired before the recall repair could be performed. The vehicle was not yet repaired. The manufacturer was made aware of the failure, and a case was filed. In addition, the contact was informed that the vehicle had to be repaired before the recall repair was performed. The failure mileage was approximately 134,431.

19. Engine, Mar 17, 2026

    My car experienced engine stall, fire risk, and piston ring failure while returning from a family road trip. Myself, my son, [XXX] old, and [XXX] pup was left in a ditch on a very busy road as the car stalled while driving. My VIN is excluded, however car experienced exact symptoms of recall SC2091. Codes P0300 P0304 P0302 P219D P0303 with no pressure in cylinder 2 and 4.This happened in 0ct 2025 and dealership and corporate do not want to exend goodwill to replace the engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

20. Engine, Mar 17, 2026

    DEALER ADMISSION OF NON-COMPLIANCE: I am updating my complaint to document that Kia of Streetsboro is officially refusing to perform the mandatory mechanical inspection required by Recall SC336. Despite the vehicle suffering from "Loss of Motive Power" (stalling in traffic) and "Abnormal Engine Noise," the dealership’s service department stated via text on March 17: "I asked my manager and he said as of right now since your vehicle passed the tablet we cannot do anything else." The dealer further stated: "I suggest calling consumer affairs since you have an open case and letting them know what's going on and seeing if they can help." TECHNICAL VIOLATION: The dealer’s refusal based on a "tablet pass" is a direct violation of TSB SC336, Step 18c, which states that if a vehicle exhibits mechanical symptoms that "contradict a PASS result," the dealer MUST open a Techline Case for further instructions. By their own admission, the dealer is choosing to follow a "manager’s" opinion rather than the Federal Recall Protocol. They are attempting to release a vehicle that is actively stalling at intersections, which they define as an "Early Warning" system success, while ignoring the actual mechanical failure (the stalling). SAFETY RISK: This is a documented Ineffective Remedy. The dealer is punting the safety diagnosis to a "Consumer Affairs" call center rather than performing the borescope and Techline escalation required by the NHTSA. I am reporting this dealer for knowingly attempting to return a stalling, unsafe vehicle to a consumer while claiming the recall is complete.

21. Engine, Mar 17, 2026

    My 2021 Kia Soul is exhibiting a severe safety defect documented in Recall SC336: frequent, unpredictable stalling in traffic ("Loss of Motive Power") and audible engine knocking. These symptoms create a high risk of a rear-end collision or being stranded in a dangerous traffic situation. The vehicle is currently at Kia of Streetsboro. Despite being provided with evidence of these active mechanical failures, the dealership is attempting to "remedy" the safety recall based solely on a "Pass" result from the Piston Ring Noise Sensing System (PNSS) software diagnostic. As the TSB SC336 notes that the root cause is physical damage to cylinder walls caused by defective piston oil rings, a software diagnostic "Pass" is not a physical repair and does not address the existing mechanical stalling. I have not received any status updates or communication from the dealership service department since Friday. The dealership is refusing to perform a borescope inspection or open a Kia Techline case to investigate the stalling, effectively denying a proper safety remedy. I am reporting this as a failure of the manufacturer and dealership to provide a safe and effective remedy for a known life-safety defect. The car remains unsafe to drive.

22. Steering, Engine, Mar 16, 2026

    1. Component or System Malfunction Engine (internal piston/piston ring system) is malfunctioning. The vehicle exhibits clanking noises (“marbles in a can”) and cuts off or stalls unexpectedly while driving. The car is available for inspection by a Kia dealer or independent mechanic. 2. Safety Risk Vehicle loses power while driving, which is extremely dangerous, particularly on highways or in traffic. Stalling while moving poses a risk of collision, loss of steering or braking control, and endangers both driver and others. This makes the vehicle unsafe to drive long distances. 3. Reproduction of Problem Symptoms have been observed consistently during normal driving and acceleration. Not yet confirmed by a dealer, but the stalling is reproducible during operation. 4. Vehicle Inspection The vehicle has not yet been inspected by the manufacturer, dealer, police, or insurance representatives. Immediate inspection is recommended due to engine stall risk. 5. Warning Lamps / Symptoms Clanking engine noise noted prior to stalling. Engine cutting off/stalling occurs while driving. No warning lights illuminated prior to stalling. Symptoms first appeared during recent driving prior to planning transport or repair. 6. Additional Notes The vehicle is a candidate for Kia engine piston/piston ring recall (SC209 / SC336). Owner recommends urgent inspection and repair to prevent potential engine failure and safety risks.

23. Engine, Mar 10, 2026

    Vehicle consistently stalls at complete stops in traffic. After the engine stalls, it requires a manual restart to resume operation. This creates a severe safety hazard, as the vehicle becomes immobile at intersections and in stop-and-go traffic, increasing the risk of a rear-end collision. The dealership is refusing to perform the necessary diagnostic for the engine stalling issue under the Havis v. Kia Settlement/KSDS recall protocols, claiming maintenance gaps, despite the vehicle having 0 open campaigns and the KSDS software update previously installed. This stalling issue is a known defect currently under NHTSA investigation (Audit Query AQ23-001) for this specific model and engine.

24. Engine, Mar 6, 2026

    Check engine light on due to catalytic converter, took it to Kia motors in Bakersfield, California due to recall let them know that there was a check engine light on after buying the vehicle and only having it for one month and I thought it was due to the recall, which was on oil, piston rings, the dealership stated I could give all my paperwork that I had in regards to that, and if the engine failed, they would take care of it. After the test for the recall was done the engine failed and then a few days later a new updated recall, came out where the engine had to be running hot for the test to be done and then my recall passed so nothing was ever fixed with my vehicle. I believe that the catalytic converter is bad due to oil running into or around the catalytic converter. I also believe due to the malfunction of the oil, piston rings being bad/malfunction or whatever the recall was on is a determination of why my check engine light is on stating it’s a catalytic converter I believe if I continue driving my vehicle in the condition that it’s in it eventually will catch fire due to the issue.

25. Engine, Mar 4, 2026

    My 2021 Kia Soul is having the same piston issues leading to engine failure as other previously recalled Kia Soul vehicles but for some reason my VIN is not part of any recall. Now it has been determined there is heavy scoring in my engine and I will need a new engine. My car is only 5 years old and there should be no reason for such major engine damage. My car has stalled on me while driving and other very similar issues as described on previous recalls. How does NHTSA determine when a certain model/year of car needs to be part of a national recall?