2004 Mazda MAZDA3
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 170 owner complaints filed for this model year. This is the 5th highest complaint count among 22 MAZDA3 model years with reports.
Of the 2004 reports, 24 involved a crash and 2 involved a fire. 19 people were injured.
What owners report most often
Recalls and investigations
Air bags, frontalJul 1, 2021
Mazda North American Operations (Mazda) is recalling certain 2004-2007 Mazda3 vehicles. During air bag deployment, the plastic emblem on the steering wheel air bag module cover may shatter, and project plastic fragments into the vehicle.
Plastic fragments can hit occupants during air bag deployment, increasing the risk of injury.
Dealers will replace the air bag module cover, free of charge. Owner letters were mailed between August 28, 2021 and October 28, 2021. Owners may contact Mazda customer service at 1-800-222-5500 Option 4. Mazda's number for this recall is 4921G.
Campaign 21V494000 on NHTSA.gov
EquipmentApr 2, 2009
THULE, INC. IS RECALLING 2,323 OWNER-INSTALLED ROOF-MOUNTED FIT KITS, MODELS 3068 AND 3069, MANUFACTURED BETWEEN JANUARY 1, 2008 AND FEBRUARY 28, 2009 THAT ARE USED WITH THULE PODIUM FOOT PACKS, MODELS 460 AND 460R. THESE FIT KITS WERE SOLD AS AFTERMARKET EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE BOLT(S) USED TO SECURE THE FOOT TO THE VEHICLE WAS MANUFACTURED TO A HARDNESS THAT MAY CAUSE THE BOLT(S) TO BE BRITTLE AND POTENTIALLY BREAK UNDER STRESS.
THIS MAY RESULT IN THE BOLT(S) SNAPPING OFF DURING USE OR WITHOUT A LOAD. THE UNSECURED RACK AND LOAD CAN THEN COME LOOSE WHILE DRIVING CREATING A POTENTIAL ROAD HAZARD, POSSIBLY RESULTING IN A VEHICLE CRASH.
THULE WILL MAIL A RETRO FIT KIT ALONG WITH REPAIR INSTRUCTIONS TO OWNERS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 13, 2009. OWNERS MAY CONTACT THULE TOLL-FREE AT 1-800-238-2388.
Campaign 09E011000 on NHTSA.gov
Air bags, frontal, sensor/control module-inactiveSep 24, 2004
ON CERTAIN PASSENGER VEHICLES, A CRACK IN THE AIR BAG CRASH ZONE SENSOR HOUSING CAN ALLOW WATER TO ENTER THE SENSOR, CAUSING A SHORT CIRCUIT AND ILLUMINATING THE AIR BAG WARNING LIGHT.
IF THIS PROBLEM EXISTS, THE AIR WILL NOT DEPLOY AS DESIGNED IN CERTAIN TYPES OF FRONTAL CRASHES, INCREASING THE RISK OF DEATH OR SERIOUS INJURY TO THE DRIVER AND FRONT SEAT PASSENGER.
DEALERS WILL INSPECT THE CRASH ZONE SENSOR AND REPLACE IT, IF NECESSARY. THE RECALL BEGAN ON OCTOBER 28, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.
Campaign 04V468000 on NHTSA.gov
Representative owner complaints: electrical system
10 reports, newest first. Show all
Power train, Electrical system, Engine, Jun 1, 2015, fire
CLUTCH SLIPPING, HIGH RPMS, NOT RED LINING. TRANSMISSION EXPLODED CAUSING ENGINE FIRE AND BURNING MOTOR AND ELECTRICAL COMPONENTS.
Electrical system, Exterior lighting, Sep 18, 2014
I HAD MY MECHANIC WORKING ON REPLACING A BURNT OUT LICENSE PLATE LIGHT WHEN HE DISCOVERED THAT THE TAIL LIGHTS WERE NOT WORKING. HE TURNED THE LIGHTS OFF AND BACK ON, AND THE TAIL LIGHTS STARTED WORKING AGAIN, TURNED THE LIGHTS BACK OFF AND ON AGAIN, AND THE TAIL LIGHTS WERE BACK TO NOT WORKING AGAIN. HE IDENTIFIED THE FUSE BOX TO BE THE CAUSE OF THIS ISSUE, AS WHEN THE TAIL LIGHTS WERE OUT, HE WOULD HIT THE FUSE BOX WHICH WOULD THEN CAUSE THE LIGHTS TO COME BACK ON, AND HE DEMONSTRATED THIS FOR ME. THIS IS A SERIOUS SAFETY CONCERN TO ME AND AFTER ONLY A FEW MINUTES OF INTERNET RESEARCH I FOUND OTHERS WERE HAVING THE EXACT SAME ISSUE. I FEEL VERY FORTUNATE THAT I'VE NOT BEEN HIT FROM BEHIND. I'VE CALLED MAZDA AND THEY SAID THEY WERE NOT AWARE OF A KNOWN ISSUE AND THERE WERE NO RECALLS ON THE PART, BUT I'VE ALSO LEARNED THAT THIS PART HAS BEEN REISSUED 6 TIMES. THIS MAKES ME THINK IT HAS TO BE A KNOWN ISSUE, OTHERWISE WHY KEEP MODIFYING THE PART? *TR
Electrical system, Exterior lighting, Sep 22, 2013
WHILE DRIVING ON THE FREEWAY AT 65 MPH AT NIGHT, MY LOWER DASH (RADIO, HVAC) AND STEERING WHEEL CONTROLS LIGHTING WENT OUT FOR ABOUT TEN MINUTES, AND THEN CAME BACK ON. THIS STARTED HAPPENING INTERMITTENTLY FROM THAT POINT ON, SHUTTING OFF AND COMING BACK ON RANDOMLY, WITH THE LIGHTS BEING OUT CONTINUOUSLY ONCE FOR ABOUT 30 MINUTES WHILE DRIVING AT NIGHT IN TRAFFIC. THE SAFETY CONCERN IS THAT I JUST DISCOVERED THE TAIL LIGHTS WERE ALSO GOING OUT AT THE SAME TIME. INDICATIONS ARE THAT THE CAUSE IS A DEFECTIVE PASSENGER JUNCTION BOX (PJB). THIS IS A SERIOUS SAFETY ISSUE AND AN UNACCEPTABLE ENGINEERING FLAW WHICH APPEARS TO AFFECT OTHER DRIVERS OF THIS VEHICLE MODEL AS WELL. DUE TO PROHIBITIVE COST OF JSB REPLACEMENT AND UNCERTAINTY OF THE INTEGRITY OF THAT PART ITSELF, IT MAY BE NECESSARY TO INSTALL A FAILSAFE INDEPENDENT WIRING SOLUTION FOR THE BRAKE LIGHTS TO ENSURE REQUIRED RELIABILITY
Steering, Electrical system, Apr 25, 2013
ISSUE: ALL ELECTRICAL COMPONENTS ALONG WITH POWER STEERING SHUTTING OFF INTERMITTENTLY WHILE DRIVING. THE FIRST INSTANCE OF THIS ISSUE HAPPENED WHILE TURNING INTO A PARKING LOT. AS I WAS MAKING A RIGHT TURN ALL THE ELECTRICAL COMPONENTS IN MY VEHICLE SHUT OFF, ALONG WITH THE POWER STEERING. ABOUT A SECOND LATER EVERYTHING CAME BACK ON AND OPERATING NORMALLY. THIS SAME ISSUE WOULD HAPPEN INTERMITTENTLY, USUALLY WHEN MAKING RIGHT TURNS. THERE WAS NEVER ENOUGH OF A PATTERN TO SAY THAT IT WAS HAPPENING EVERY WEEK OR MONTH, ETC. I TOOK VEHICLE TO MAZDA DEALERSHIP AND THEY DIAGNOSED IT AS BATTERY CABLES NEEDING TO BE REPLACED, AFTER IT STARTED HAPPENING MORE FREQUENTLY A FEW MONTHS LATER. THE ISSUE STOPPED FOR A COUPLE MONTHS, BUT THEN BEGAN AGAIN. THIS TIME IT STARTED HAPPENING JUST BY TAPPING ON THE BRAKES AS WELL AS MAKING A TURN. ALL THE ELECTRICAL ON THE VEHICLE WOULD SHUT OFF, ALONG WITH THE POWER STEERING AGAIN; AND THEN IT WOULD COME BACK AFTER A SECOND BEING OFF. THIS TIME IT BEGAN HAPPENING MUCH MORE FREQUENTLY, AT LEAST A COUPLE OF TIMES A WEEK; MOST RECENTLY IT HAPPENED AGAIN AND THIS TIME MY POWER STEERING WAS OFF FOR MY ENTIRE 30 MILE DRIVE HOME FROM WORK. I TOOK IT AGAIN TO A DIFFERENT MAZDA DEALERSHIP TO HAVE IT DIAGNOSED, AND THIS TIME I WAS TOLD THEY NEEDED TO CHANGE THE BATTERY, ALTERNATOR AND POWER STEERING PUMP FOR STARTERS; BUT WAS NOT GUARANTEED THAT WOULD RESOLVE THE ISSUE AS THE TECHS HAD NEVER SEEN THIS ISSUE BEFORE AT THEIR SITE; THEY SAY THEY CALLED THEIR CORPORATE TECH LINE AND WERE ADVISED TO REPLACE THOSE ITEMS FIRST. I EVEN SHOWED THEM A VIDEO I HAD TAKEN OF THIS HAPPENING IN MY CAR ONE NIGHT AS I DROVE AROUND MY BLOCK IN ORDER TO DOCUMENT THE ISSUE. THERE IS NO PATTERN WITH REGARDS TO SPEED OF VEHICLE, OR WHETHER THE ENGINE IS COLD OR HAS BEEN RUNNING FOR A WHILE, AS THE ISSUE CAN HAPPEN REGARDLESS OF ANY OF THESE CONDITIONS. *TR
Electrical system, Apr 18, 2012
THE INTERIOR LIGHTS AROUND THE AIR CONDITIONER CONTROLS WERE NOT ON, THOUGHT IT WAS A SHORT OR A BLOWN FUSE, PLANNED ON CHECKING ONCE RETURNING HOME THAT NIGHT. HOWEVER WAS PULLED OVER BY LOCAL POLICE DEPT AND TOLD I DIDN'T HAVE ANY TAIL LIGHTS. CHECKED ALL FUSES RIGHT THEN, ALL FUSES WERE GOOD. DROVE HOME WITH EMERGENCY FLASHERS ON TO AVOID BEING HIT. TOOK THE CAR TO THE MECHANIC THE NEXT DAY THEY CHECKED ALL FUSES AND FOUND THE FUSES WERE GOOD BUT FOUND THE REAR TAIL LIGHTS HAD BLOWN. TWO WEEKS LATER THE SAME THING, NO LIGHTS AROUND AIR CONDITIONER CONTROLS SO I IMMEDIATELY GOT OUT OF THE CAR AND DISCOVERED NO TAIL LIGHTS. TOOK CAR BACK TO SAME MECHANIC AND UPON RESEARCHING HE FOUND THAT THIS MODEL HAS PROBLEMS WITH THE PASSENGER JUNCTION BOX (FUSE BOX) HAVING SHORTS. WILL HAVE TO REPLACE THE ENTIRE JUNCTION BOX AND THE REPLACEMENT BOX IS APPROXIMATELY $800. WITH THIS BEING A KNOWN PROBLEM THERE SHOULD BE A RECALL TO REPLACE ALL PASSENGER JUNCTION BOXES! I COULD HAVE HAD AN ACCIDENT FROM NOT HAVING TAIL LIGHTS AND NOT KNOWING IT!!!!! *JS
Engine and engine cooling, Power train, Electrical system, Jul 20, 2010
LETTER FROM CONGRESSMAN VAN HOLLEN ON BEHALF OF CONSTITUENT RE SAFETY PROBLEMS (RANDOM STALLING) WITH HIS 2004 MAZDA3 *TGW THE CONSUMER WENT TO SEARS TO PURCHASE A BATTERY THINKING THAT WAS THE CAUSE OF THE RANDOM STALLING, BUT WAS TOLD THE BATTERY WAS FINE AND IT APPEARED THERE WAS AN ELECTRICAL PROBLEM, BUT THEY WERE UNABLE TO FIGURE OUT WHAT IT WAS. THE CONSUMER THEN WENT TO THE DEALER AND WAS TOLD DIFFERENT THINGS WERE WRONG WITH THE VEHICLE, WHICH WAS CAUSING IT TO STALL. THE CONSUMER PAID FOR THE REPAIRS, BUT WEEKS LATER THE VEHICLE STALLED AGAIN. THE CONSUMER ALSO STATED THE CLUTCH AND TRANSMISSION WAS REPLACED. *JB
Electrical system, Apr 23, 2008
MY 2004 MAZDA 3 OFTEN STALLS WHILE I'M DRIVING ON THE FREEWAY, I TOOK IT TO DEALER AND THEY ARE NOT ABLE TO RE-CREATE THE PROBLEM AND THEY WON'T FIX IT. I THINK MAZDA CORPORATION HAS TO DO SOMETHING ABOUT IT CAUSE IT IS A KNOWN ISSUE TO MANY MAZDA 3 OUT THERE AND IT ALWAYS SCARE ME WHENEVER MY CAR STALLS ON THE FREEWAY AS IT IS VERY DANGEROUS. *TR
Electrical system, Exterior lighting, Oct 1, 2005
ELECTRICAL SYSTEM FAILURE VEHICLE, MAZDA 3 MANUAL, WAS RETURNED TO DEALER AFTER AIRBAG RECALL MAINTENANCE WAS PERFORMED. VEHICLE'S ELECTRICAL SYSTEM SUFFERED FROM MANY COMPLAINTS. SERVICE DEALERSHIP STATED THAT A LOOSE GROUND WIRE AT ONE OF THE FUSE PANELS WAS THE FAULT. VEHICLE'S ELECTRICAL SYSTEM RAN AS PROMISED FOR MONTHS UNTIL BOTH LOW-BEAM HEADLAMPS BLEW AT THE SAME TIME. THE DEALERSHIP HAS BEEN NOTIFIED AND ACTION WILL TAKE PLACE. I HAVE EXPERIENCED SEVERAL ELECTRICAL FAULTS IN THE VEHICLE AND ASSUME MANY MORE ARE TO COME. SAFETY WAS SEVERELY COMPROMISED. NO HEADLAMPS AT NIGHT IN A CONSTRUCTION ZONE IS VERY MUCH A PROBLEM. *JB
Electrical system, Aug 22, 2005
DT: THE ENGINE JUST TURNED OFF. THE VEHICLE CUT OFF TWICE WHEN TRYING TO GO UP HILL AT 20 MPH. THIS HAPPENED ON JULY 20TH, 2005. THE EVOLUTION WAS ROUGHLY AT 10,000 FEET. THE VEHICLE IS CURRENTLY AT THE DEALER. *AK *SC
Electrical system, Aug 10, 2005
DT: THE CONSUMER STATED 2004 MAZDA RX 8 STALLED WHILE DRIVING AT SPEEDS OF 20-35 MPH. THERE WERE NO LIGHTS ON THE DASHBOARD BEFORE THIS HAPPENED. , BUT AFTERWARDS ALL THE LIGHTS CAME ON, AND THE VEHICLE DIED. THE CONSUMER REPORTED THIS TO THE DEALER ,AND THEY DID THE DIAGNOSTIC TEST, AND FOUND NOTHING BUT SUGGESTED THAT HE DO A TUNE UP ON THE CAR. THE CAR HAS HAD NO OTHER PROBLEMS AND HAS DRIVEN FINE BEFORE THIS INCIDENT. THE OWNER NOTICED BEFORE THIS HAPPENED THAT HE HAD DRIVEN ABOUT 100 MILES WHEN THE CAR STALLED. THIS WAS ON BOTH OCCASIONS. THE DEALER DID DO A COMPUTER UPDATE. *AK