2002 Nissan Altima
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,062 owner complaints filed for this model year. This is the 5th highest complaint count among 26 Altima model years with reports.
Of the 2002 reports, 30 involved a crash and 28 involved a fire. 27 people were injured.
What owners report most often
Recalls and investigations
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Engine and engine coolingNov 14, 2007
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L ENGINE, THE CRANKSHAFT POSITION SENSOR CAN OVERHEAT CAUSING A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.
IF THE INTERRUPTION IN THE SIGNAL FROM THE CRANKSHAFT POSITION SENSOR IS SO BRIEF THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WITHOUT WARNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED INCREASING THE RISK OF A CRASH.
DEALERS WILL REPROGRAM THE ECM FREE OF CHARGE. CERTAIN MY 2006 ALTIMAS WHICH HAVE BEEN PREVIOUSLY REMEDIED UNDER RECALL CAMPAIGN 06V223 (NISSAN R0606) ARE NOT INCLUDED IN THIS RECALL SINCE THE REPROGRAMMING FOR 06V223 ALSO INCLUDED THIS REPROGRAMMING. THE RECALL BEGAN ON DECEMBER 31, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Campaign 07V527000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. DS517-B001L AND DS517-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE OPTICEL SURFACE OF THE REFLECTOR IS CORRODED INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON DECEMBER 11, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E074000 on NHTSA.gov
Exterior lighting, headlightsAug 21, 2007
CERTAIN ANZO AFTERMARKET HEADLIGHTS, P/N 02-AZ-NA02-B-A, SOLD FOR USE ON 2002-2004 NISSAN ALTIMA VEHICLES. DURING PRODUCTION THE LAMP HOUSING SHAPE DEFORMED DISTORTING THE ASSEMBLY ANGLE OF THE REFLECTOR AND INFLUENCED THE AIMING POSITION. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT LAMPS. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS CAN CONTACT ANZO AT 909-628-1440.
Campaign 07E063000 on NHTSA.gov
Exterior lighting, headlightsJul 25, 2007
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 315-1145L-AS AND 315-1145R-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. DURING PRODUCTION THE LAMP REFLECTOR SHAPE DEFORMED CHANGING THE SHAPE OF THE OPTIC SURFACE. THIS WILL CHANGE THE OPPOSITE POSITION OF LOW BEAM AND HIGH BEAM OPTICSAND CHANGE THE ANGLE OF INCIDENCE AND ILLUMATED LOCATION WHICH FAILS TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 16, 2007. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 07E054000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Engine and engine coolingNov 17, 2003
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
Campaign 03V455000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyJul 14, 2003
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, CONNECTICUT, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WISCONSIN, AND WYOMING. AT EXTREMELY COLD TEMPERATURES, MOISTURE IN THE FUEL TANK COULD FREEZE AND FORM ICE CRYSTALS. THESE ICE CRYSTALS MAY OBSTRUCT THE SUCTION OPENING OF THE FUEL PUMP.
THIS CAN PREVENT THE SUPPLY OF FUEL TO THE ENGINE AND CAUSE THE ENGINE TO STOP, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL A SCREEN AT THE SUCTION OPENING OF THE FUEL PUMP TO PREVENT ICE CRYSTALS FROM BLOCKING THE OPENING. OWNER NOTIFICATION BEGAN ON AUGUST 18, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-333-0829.
Campaign 03V251000 on NHTSA.gov
Engine and engine cooling, exhaust system, manifold/header/muffler/tail pipeMar 11, 2003
ON CERTAIN VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE, THE EXHAUST PIPE HANGER PIN MAY CATCH DEBRIS FROM THE ROAD THAT COULD BE IGNITED BY CONTACT WITH THE MAIN CATALYST. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE.
EITHER OF THESE TWO CONDITIONS COULD RESULT IN A FIRE.
DEALERS WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIPE HANGER PIN. IN ADDITION TO THE CORRECTIVE ACTION, IN ORDER TO REDUCE THE RISK OF FIRE IN THE EVENT OF POOR OR IMPROPER MAINTENANCE THAT COULD RESULT IN OIL SPILLAGE, HEAT SHIELD(S) WILL BE INSTALLED ON THE PRE-CATALYST AND EXHAUST TUBE. OWNER NOTIFICATION BEGAN ON JULY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261. NISSAN RECALL NOS. R3007, R3014, R3015, R3016, R3017. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE. IF SUBSTRATE PARTICLES ENTER THE COMBUSTION CHAMBER, THEY COULD SCORE THE CYLINDER WALLS, RESULTING IN INCREASED OIL CONSUMPTION. IF THE ENGINE OIL LEVEL IS NOT CHECKED ON A PERIODIC BASIS AND DROPS BELOW THE LOW LEVEL, AND THE DRIVER CONTINUES TO OPERATE THE VEHICLE IGNORING NOTICEABLE ENGINE NOISE, ENGINE DAMAGE MAY OCCUR WHICH COULD RESULT IN A FIRE. THE PRE-CATALYST WILL BE TESTED TO ENSURE IT IS WORKING PROPERLY AND REPLACED IF NECESSARY. IF DAMAGE IS FOUND INSIDE THE PRE-CATALYST, IT WILL BE NECESSARY TO REPLACE THE ENGINE.
Campaign 03V084000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 27, 2003
ON CERTAIN VEHICLES, THE ELECTRICAL CONNECTOR FOR THE DRIVER AIR BAG MAY COME LOOSE. IF THE CONNECTOR COMES LOOSE, THE SUPPLEMENTAL AIR BAG WARNING LIGHT FLASHES INTERMITTENTLY.
THE DRIVER SIDE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
DEALERS WILL INSTALL A RETAINING CLIP ON THE CLOCK SPRING ELECTRICAL CONNECTOR. OWNER NOTIFICATION BEGAN APRIL 21, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Campaign 03V061000 on NHTSA.gov
Air bagsApr 17, 2002
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. ON CERTAIN 2002 NISSAN ALTIMA MODEL VEHICLES MANUFACTURED PRIOR TO MARCH 16, 2002, ONE OF THE SENSORS FOR THE AIR BAG SYSTEM DOES NOT WORK AS WELL AS EXPECTED IN HIGH-SPEED OFF-SET CRASH SITUATIONS.
THE AIR BAG SYSTEM DOES NOT WORK AS EXPECTED.
DEALERS WILL REPLACE THE AIR BAG SENSOR. OWNER NOTIFICATION BEGAN APRIL 15, 2002. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261, CONCERNING THE PROBLEM.
Campaign 02I001000 on NHTSA.gov
Representative owner complaints: engine
687 reports, newest first. Show all
Engine and engine cooling, Feb 4, 2009
1. EVENTS- VEHICLE CONSTANTLY MISS-FIRED. 2. FAILURE- SCREWS IN BUTTERFLY VALVE CAME OUT, WERE PASSED THROUGH PISTON, DAMAGED SPARK PLUGS AND CAME TO REST IN THE EXHAUST MANIFOLD. 3. CORRECTION- PART "AIR PLENUM GASKET". LABOR "R&R UPPER AIR PLENUM INTAKE" AND "R&R EXHAUST MANIFOLD TO REMOVE SCREW". *TR
Engine and engine cooling, Feb 3, 2009
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT WAS EXPERIENCING ENGINE FAILURE. HE NOTICED A SILENT RECALL ON THE NISSAN WEBSITE. THE MANUFACTURER STATED THAT THEY WOULD NOT TAKE LIABILITY FOR THE REPAIRS DUE TO THE FACT THAT HE WAS NOT THE ORIGINAL OWNER, ALTHOUGH HIS VIN WAS INCLUDED IN THE RECALL. THE ENGINE WAS REPLACED AT THE COST OF $3,000, BUT WITH LESS THAN 2,500 MILES, THE ENGINE FAILED AGAIN. THE CONTACT HEARD A TICKING SOUND WHEN THE VEHICLE WAS IN MOTION AND IT WAS BURNING OIL AT RAPID SPEEDS. THE MANUFACTURER PERFORMED AN OIL CONSUMPTION TEST AND FOUND THAT THE ENGINE WAS FAULTY. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 78,785 AND CURRENT MILEAGE WAS 97,000.
Engine and engine cooling, Feb 2, 2009
I HAVE AN 02 NISSAN ALTIMA. IT IS CONSUMING MY OIL AND ANITFREEZE. I WAS TOLD THAT I NEEDED A NEW ENGINE AND A NEW CAT. MY CAR RANDOMLY DIES AND WILL NOT START MOST OF THE TIME. *TR
Engine and engine cooling, Equipment, Jan 31, 2009
POWER VALVE SCREWS FELL INTO THE INTAKE MANIFOLD PLATE ON 2002 NISSAN ALTIMA 2002 NISSIAN ALTIMA 2.5 STALLED ON THE HIGHWAY. CAR HAD BEEN IDLING VERY ROUGH AND ENGINE VIBRATION AS WELL AS INTERMITTENT POWER LOSS 24 HOURS PRIOR TO ISSUE. TOOK IT TO TWO INDEPENDENT MECHANICS. BOTH CONFIRMED THAT THE PVC VALUE SCREW FELL INTAKE MANIFOLD. THIS WAS ALSO CONFIRMED BY NISSAN. HOWEVER IT WAS ONLY RECALLED ON THE 2004-2006 MODELS. IT JUST SO HAPPENS THAT NISSAN HAD TO REPLACE MY ENGINE ON MY VEHICLE IN 2004, THEREFORE MY CAR SHOULD BE INCLUDED IN THE RECALL BUT BECAUSE MY CALL IS 02 NISSAN WILL NOT COVER THE PROBLEM. 2002 MODELS NEED TO BE INCLUDED IN THE RECALL. *TR
Engine and engine cooling, Fuel system, Gasoline, Jan 30, 2009
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR WOULD CONTINUOUSLY ILLUMINATE. THE DEALER COULD NOT DETERMINE WHY THE INDICATOR CONTINUED TO ILLUMINATE AND STATED THAT THERE WAS RUST AROUND THE FUEL TANK. ON A SEPARATE OCCASION, THE ENGINE BEGAN TO MAKE A KNOCKING SOUND AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. IT WAS DETERMINED THAT THE KNOCKING NOISE ORIGINATED FROM THE OVERHEAD CAM COMPONENT OF THE ENGINE. THERE WAS NO OIL IN THE VEHICLE, ALTHOUGH THE CONTACT MAINTAINED REGULAR MAINTENANCE AND OIL CHANGES EVERY 3,000 MILES. HIS VIN WAS NOT INCLUDED IN ANY OF THE RECALLS THAT DESCRIBED THE SAME FAILURES HE EXPERIENCED (NHTSA CAMPAIGN ID NUMBERS 03V455000 AND 03V455000). THE FAILURE MILEAGE WAS 32,500 AND CURRENT MILEAGE WAS 86,600.
Engine and engine cooling, Jan 30, 2009
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE SUDDENLY LOST POWER. THE CONTACT MANAGED TO PULL THE VEHICLE OVER AND WAS UNABLE TO RESTART THE ENGINE. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE CATALYTIC CONVERTER OVERHEATED AND SHATTERED. THE SHATTERED PIECES ENTERED INTO THE MOTOR, WHICH CAUSED THE ENGINE TO COMPLETELY FAIL. THE ONLY REMEDY WOULD BE TO INSTALL A NEW ENGINE AND A NEW EXHAUST. THE CONTACT WAS INFORMED THAT THE REASON FOR THE DEFECT WAS DUE TO THE SIZE OF THE CATALYTIC CONVERTER THAT WAS MANUFACTURED INTO THE VEHICLE BY NISSAN. SHE BELIEVES THAT A RECALL SHOULD BE ISSUED FOR THE FAILURE. THE VEHICLE IS CURRENTLY AT THE DEALER AND HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 100,000.
Engine and engine cooling, Jan 27, 2009
MANY PROBLEMS WITH THE CATALYTIC CONVERTER, CHECK ENGINE LIGHT REMAINS ON ALTHOUGH VEHICLE HAS BEEN SERVICED AT THE DEALER PROPERLY. ENGINE RATTLES. THERE HAVE BEEN MANY COMPLAINTS REGARDING THE 2002 NISSAN ALTIMA CATALYTIC CONVERTER. ALTHOUGH PREVIOUS RECALLS WITH THE ENGINE COOLANT SYSTEM HAVE BEEN HONORED NISSAN FAILS TO RECOGNIZE THERE IS A PROBLEM WITH THE CATALYTIC CONVERTER. MANY CONSUMERS HAVE COMPLAINED. *TR
Engine and engine cooling, Jan 24, 2009
WELL MAINTAINED 2002 NISSAN ALTIMA.... FOLLOWED ALL MAINTENANCE SCHEDULES, HAD ALL RECALLS PERFORMED ALL WORK PERFORMED AT NISSAN DEALERSHIPS. HAS HAD CONTINUAL OIL CONSUMPTION ISSUES, HAD HEAT ISSUES, CATALYTIC CONVERTER FAILURE LEADING TO FULL ENGINE FAILURE. NISSAN DENIES ANY WRONG DOING AND WILL NOT HELP DUE TO MILEAGE ON THE CAR. HOWEVER THIS PROBLEM STARTED WELL WITHIN THE WARRANTY PERIOD AND THE DEALERSHIP(S) DID NOT DO LET US KNOW ABOUT A KNOWN PROBLEM WITH THE DESIGN (CATALYTIC CONVERTER IN FRONT OF THE EXHAUST). THERE ARE 1000 OF CONSUMERS ON THE INTERNET WITH THE EXACT SAME PROBLEM. *TR
Engine and engine cooling, Jan 16, 2009
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT HER VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 03V084000 (ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE). SEVERAL MONTHS LATER, SHE NOTICED THAT HER VEHICLE BEGAN CONSUMING AN ABNORMAL AMOUNT OF OIL AND THE ENGINE WARNING INDICATOR WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER STATED THAT THE CATALYTIC CONVERTER WOULD NEED TO BE REPLACED AT THE COST OF $900. THE VEHICLE HAS NOT BEEN REPAIRED AND THE MANUFACTURER DID NOT ASSIST. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 85,000. UPDATED 02-11-09 *BF THE CONSUMER STATED THE CATALYTIC CONVERTER WAS PLACED TOO CLOSE TO THE EXHAUST. UPDATED 02/12/09. *JB
Engine and engine cooling, Jan 15, 2009
I HAVE A 2002 ALTIMA 2.5 STANDARD. I BOUGHT THE CAR IN JULY 2007 WITH 72,000 MILES AND HAD A MISFIRE READING FROM THE TIME I BOUGHT IT TILL I REPLACED THE HEAD GASKET AND GOT SOME HEAD WORK DONE ON THE CAR. MILEAGE NOW TOTALS AT NEARLY AROUND 110,000 MILES. NISSAN LOOKED AT MY CAR ALL THE WAY FOR ANY PROBLEMS AND I HAD A FEW RECALLS DONE ON IT INCLUDING REPLACING THE HEADLAMPS. LITTLE DID I KNOW WHEN I HAD MY MECHANIC (NON-NISSAN MECHANIC LATER ON FROM MY DEALER VISIT) REPLACE THE HEAD GASKET ( W/VALVE GUIDES AND OIL RINGS) FOR $1600 THAT MY FRONT ENGINE FAN WAS UNPLUGGED NEAR THE HEADLAMPS WHICH HAD CAUSED SOME REALLY BAD OVERHEATING ISSUES. MY CAT IS BAD (VIA A ENGINE CODE) WHICH I HAVE YET TO REPLACE AS I SEE NO NEED TO AT THIS POINT... ALSO MY CAR HAS BEEN EATING UP MORE THAN 1 QUART OF OIL PER WEEK AS I DRIVE OVER 460 MILES A WEEK AS A COMMUTER TO DALLAS, TX. AT THIS POINT THE OPTION WOULD BE TO EITHER RE..RE-BUILD THE ENGINE OR REPLACE WITH A NEW VERY EXPENSIVE ENGINE NOTHING THAT I HAVE ALREADY SPENT TOO MUCH MONEY ON THIS CAR. *TR
Engine and engine cooling, Jan 15, 2009
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT THE VEHICLE WOULD STALL AND HESITATE TO START. SHE REPLACED THE ALTERNATOR AND BATTERY, BUT THE FAILURE CONTINUED. ON A SEPARATE OCCASION, THE HEAD GASKET BLEW AND WAS REPLACED BY AN INDEPENDENT MECHANIC. HOWEVER, THE VEHICLE CONTINUED TO STALL AND HESITATE. THE CONTACT FOUND HUNDREDS OF COMPLAINTS FOR THE SAME YEAR, MAKE, AND MODEL VEHICLE AND WAS CONCERNED THAT IT WAS UNSAFE TO DRIVE. THE MANUFACTURER REFERRED HER TO NHTSA. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 85,000.
Engine and engine cooling, Jan 9, 2009
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. HE TOOK THE VEHICLE TO THE GAS STATION FROM WHERE THE VEHICLE WAS PURCHASED AND THEY REFERRED HIM TO A DEALER. THE DEALER PERFORMED AN OIL CONSUMPTION TEST AND DISCOVERED THAT THE VEHICLE LOST THREE QUARTS OF OIL AFTER 630 MILES. THE DEALER STATED THAT THE VEHICLE WAS OUTSIDE OF THE WARRANTY; THEREFORE, THEY COULD NOT ASSIST. THE MANUFACTURER STATED THAT THEY COULD NOT ASSIST DUE TO THE EXPIRED WARRANTY. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 103,000. UPDATED 3/19/09 *CN THE CONSUMER STATED THE PROBLEM WAS DUE TO A DEFECTIVE CATALYTIC CONVERTER INSTALLED AS ORIGINAL EQUIPMENT. MATERIAL FROM THE DEFECTIVE CATALYTIC CONVERTER HAS DAMAGED THE ENGINE CAUSING EXCESSIVE OIL CONSUMPTION. UPDATED 03/26/09.*JB
Engine and engine cooling, Jan 7, 2009
WE OWN A 2002 NISSAN ALTIMA S 2.5 LITER ENGINE. WE HAD A RECALL DUE TO THE EXHAUST PIPE HANGER PIN POSSIBLY IGNITING WITH THE MAIN CATALYST. AFTER THAT WAS DEALT WITH, THE DEALER CHARGING ME $80.81, SAID THE ENGINE NOISE AND CHECK ENGINE LIGHT IS DUE TO FAULTY CATALYTIC CONVERTER. THE CONVERSION EFFICIENCY OF THE PRE-CATALYST HAS DETERIORATED AND NOW THE CATALYST HAS TO BE REPLACED. THERE IS NO HEAT WHEN THE CAR IS AT IDLE AND NOW HAVE INCREASED OIL CONSUMPTION, 5 QUARTS EVERY 2 WEEKS. BECAUSE OF THE AMOUNT OF DAMAGE A NEW ENGINE MAY BE IN THE PICTURE. THERE ARE ONLY 85000 MILES ON THE CAR. WE DO NOT HAVE THE MONEY FOR A NEW ENGINE OR EVEN CATALYTIC CONVERTER. WHAT SHOULD WE DO TO GET NISSAN TO FIX THEIR FAULTY CATALYTIC CONVERTER/ENGINE PROBLEM? NISSAN IS NOT STANDING BEHIND THEIR PRODUCT! WE AREN'T TALKING ABOUT BUYING A GALLON OF MILK! WE ARE DRIVING A CAR THAT COULD POSSIBLY START ON FIRE WHILE WE ARE IN IT! SEARCH "NISSAN CATALYTIC CONVERTER"; CAR AND DRIVER ALTIMA CATALYTIC CONVERTER FAILURE AND WWW.CANADIANDRIVER.COM/ARTICLES/CC/02-06ALTIMA.HTM THE COMPLAINTS ARE NUMEROUS PLEASE REPLY WITH WHAT RECOURSE WE HAVE. *TR
Engine and engine cooling, Equipment, Jan 1, 2009
I OWN A 2002 NISSAN ALTIMA , I HAVE TO PUT A QUART OF OIL IN THIS CAR EVERY 50 MILES, FROM WHA T I HAVE FOUND ON THE INTERNET THIS IS A VERY COMMON PROBLEM , THAT NISSAN KNOWS ABOUT AND REFUSES TO ADMIT TO THE PUBLIC THIS IS A DEFECT IN THE MOTOR, THAT THE RECALL WILL COST THE COMPANY TO MUCH IN REPAIRS. WE ARE A FAMILY ON A FIXED INCOME AND CAN'T AFFORD THE $6000.00 FOR REPAIRS ON THIS CAR. NISSAN ASKS SO MUCH FOR THESE CARS THEY SHOULD STAND BEHIND THEIR PRODUCTS AND REPAIR THIS DEFECT!!!! *TR
Engine and engine cooling, Dec 30, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. WHEN THE IGNITION KEY WAS ACTIVATED, THE CONTACT HEARD A LOUD NOISE COMING FROM OUTSIDE OF THE VEHICLE. THE NOISE OCCURRED INTERMITTENTLY AND WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION AND THEY STATED THAT THE FAILURE WAS RELATED TO THE CATALYTIC CONVERTER. THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER. THE DEALER REPLACED THE FRONT EXHAUST ASSEMBLY, FRONT 02 SENSOR, AND CLEARED THE SYSTEM CODES. THE REPAIRS WERE PERFORMED UNDER WARRANTY. THE FAILURE RECURRED AND THE ENGINE AND CATALYTIC CONVERTER WERE REPLACED. THE FAILURE MILEAGE WAS 77,065 AND CURRENT MILEAGE WAS 120,000.
Engine and engine cooling, Dec 19, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE CHECK ENGINE INDICATOR ILLUMINATED AND THE DEALER STATED THAT IT NEEDED TO BE REPLACED. THE ENGINE WAS DAMAGED; HOWEVER, THE DEALER DID NOT KNOW THE SEVERITY. THE NISSAN MANUFACTURER STATED THAT THERE WAS A RECALL FOR THE CATALYTIC CONVERTER, BUT THE VEHICLE WAS NEVER REPAIRED ACCORDING TO THE RECALL. THE RECALL WAS ACTUALLY FROM 2003, AND THAT THE DEALER SAID THAT THERE WAS ENGINE DAMAGE AND THAT THE ENGINE WOULD HAVE TO BE REPLACED. THIS SYPTOM WAS ALSO STATED ON THE RECALL NOTICE (THE CATALYTIC CONVERTOR AND THE ENGINE WOULD NEED TO BE REPLACED). THE CONTACT STATED THAT THERE WAS NO FAILURE WITH THE CATALYTIC CONVERTER, WHICH IS WHY HE NEVER TOOK IT IN FOR REPAIR. HE ALSO COMPLETED A CLAIM WITH NISSAN, BUT HE RECEIVED A DENIAL LETTER FOR THE REPAIRS. THE FAILURE MILEAGE WAS 87,000. UPDATED 02/10/09 *BF UPDATED 02/11/09. *JB
Engine and engine cooling, Dec 16, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT THE DEALER REPAIRED THE VEHICLE ACCORDING TO NHTSA CAMPAIGN ID NUMBERS 07V527000 (ENGINE AND ENGINE COOLING) AND 03V084000 (ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE). TWO WEEKS LATER, THE CATALYTIC CONVERTER FAILED AND WENT INTO THE WALL OF THE ENGINE, WHICH CAUSED THE ENGINE TO CRACK. THE DEALER STATED THAT THE REPAIR WOULD COST $6,000. THE CONTACT WAS UNSURE IF THE RECALL WAS THE CAUSE OF THE FAILURE AND IF ASSISTANCE COULD BE PROVIDED. THE FAILURE MILEAGE WAS 119,197.
Engine and engine cooling, Dec 5, 2008
1.THE YEAR 2004 THANKSGIVING I WAS DRIVING HOME FROM LA, BATON ROUGE WHEN MY HEAT WOULDN'T COME ON. I GOT IT FIXED BUT WAS THE KNOB TO THE CONTROL WOULD ONLY TURN 3/4 OF THE WAY OR IT WOULDN'T WORK. THEN WHEN THE SPRING CAME AND I USED MY A/C IT DIDN'T WORK. I TOOK IT IN AND WHEN I WENT TO PICK IT UP THEY SAID I WOULD HAVE TO HAVE IT ON MAX IN ORDER FOR IT TO WORK PROPERLY. 2. AS OF 2006 TO CURRENT MY CAR JERKS AND RUNS OUT OF OIL OFTEN AND NOW I NEED TO PUT AT LEAST 4 QUARTS EVERY WEEK. THE CHECK ENGINE LIGHT COMES ON AT LEASE ONCE A WEEK. 3. I TAKE IT INTO MY MECHANIC TO CHECK TO SEE WHAT THE PROBLEM COULD BE AND DOESN'T SEE A LEAK, BURNING OIL IT JUST CONSUMES IT. I GET ALL THE NECESSARY CAR "MEDICAL" CHECK UP'S AND THE CAR STILL EATS OIL, JERKS AND CONTINUES TO GIVE ME PANIC ATTACKS AS I DRIVE TO AND FROM WORK. MY MECHANIC AND I HAVE DETAILED LOGS OF HOW MANY TIMES THEY'VE PUT IN OIL OR I HAVE PURCHASED AND PUT IT IN MYSELF ALONG WITH ANY ADDITIONAL WORK. *TR
Engine and engine cooling, Nov 30, 2008
I HAVE A 2002 NISSAN ALTIMA THAT I PURCHASED WITH 57,000 MILES (2ND OWNER). IN DECEMBER 2006 WITH ABOUT 68,000 MILES ON VEHICLE, THE CATALYTIC CONVERTER BLEW UP. I HAD THIS REPLACED AND AT 76,000 MILES I TOOK THE VEHICLE IN TO COMPLAIN ABOUT THE OIL/COOLANT AND METALLIC NOISE FROM ENGINE. THE DEALER SAID THEY COULD NOT FIND A PROBLEM, AT 86,000 THE DEALER SAID I NEEDED A NEW MOTOR SINCE THERE WERE PARTICLES THAT HAD BEEN SUCKED IN FROM THE CAT, THEY WANTED $5,900 TO REPLACE. I CALLED AND SPOKE TO REPRESENTATIVES OF NISSAN NORTH AMERICA AND LODGED A COMPLAINT, AFTER ABOUT A WEEK I RECEIVED A CALL FROM THEM STATING THAT THEY WOULD NOT REPAIR OR HELP WITH COSTS. I WAS FORCED TO FIND AN ALTERNATE REPAIR OPTION AND PURCHASED A REBUILT MOTOR, THE PROBLEM WITH THIS WAS AFTER A FEW WEEKS THE "SERVICE ENGINE" LIGHT CAME ON. I TRIED SMOGGING THE VEHICLE AND WAS UNABLE TO, I FINALLY FOUND OUT THAT THE CAUSE OF THE PROBLEM WAS THE CATALYTIC CONVERTER AGAIN, I HAD THE CAT REPLACED AGAIN ($750) AND I WAS ABLE TO GET IT SMOGGED. THIS WAS ONLY 3-4 WEEKS AGO AND ABOUT 1 WEEK AGO I TOOK THE CAR BACK TO THE SHOP AND WAS INFORMED THAT THE RATTLING/GRINDING NOISE IS COMING FROM THE ENGINE AGAIN!! PLEASE HELP ME WITH THIS, I HAVE NOTHING BUT PROBLEMS WITH THIS VEHICLE SINCE I PURCHASED IT WITH ONLY 57,000 MILES ON IT. THE PROBLEM WITH THE CATALYTIC CONVERTER ON THE 2002-06 ALTIMA/SENTRA WITH THE 2.5L MOTORS IS A "FACTORY DEFECT"!! THERE ARE THOUSANDS OF THE SAME EXACT COMPLAINTS ON NUMEROUS SITES. NISSAN SHOULD BE HELD RESPONSIBLE FOR THIS DEFECT. I NOW HAVE A VEHICLE THAT I PAY $300 A MONTH FOR THAT I HAVE PUT AN ENGINE & 2 CAT'S IN, AND NOW IT NEEDS ANOTHER MOTOR. THIS IS RIDICULOUS FOR A CAR COMPANY TO SELL VEHICLES AND NOT STAND BEHIND WHAT THEY MAKE. *TR
Engine and engine cooling, Nov 30, 2008
NISSAN NA MADE SOME PREVENTIVE CHANGES TO THE 2002 NISSAN ALTIMA AS REQUESTED TO BY LAW. HOWEVER THE CHANGES NISSAN NA MADE WERE NOT SUFFICIENT NOR SUCCESSFUL. IT APPEARS THAT THE PREVENTIVE SERVICE NISSAN PROVIDED HAS ONLY PROLONGED THE OUTCOME. THOUSANDS OF 2002 NISSAN ALTIMA OWNERS ARE CURRENTLY EXPERIENCING OIL CONSUMPTION PROBLEMS WITH A DIRECT RELATION TO A FAILURE IN THE CATALYST CONVERTER. AFTER INSPECTION OF THE CATALYST CONVERTER NOTICEABLE CHUCKS OF THE CATALYST CONVERTER ARE MISSING. NISSAN NA IS VERY AWARE OF THE PROBLEM AND THEY ARE SELECTIVELY FIXING SOME CONSUMERS VEHICLES. IF THE CONSUMERS VEHICLE IS OUTSIDE THEIR POWER TRAIN WARRANTY NISSAN NA REFUSES TO ASSIST THE CONSUMER WITH FIXING THE PROBLEM. SAFETY SHOULD NOT BE LIMITED TO A PERCENTAGE OF MILES OR TO A PERIOD OF TIME. *TR
Engine and engine cooling, Nov 28, 2008
ON TUESDAY 11/25/08 I WAS DRIVING MY 2002 NISSAN ALTIMA TO WORK AND THE CAR TURNED OFF IN MID DRIVE ON A MAJOR HIGHWAY. I DID SOME RESEARCH AND FOUND OUT ABOUT A RECALL (#03V455000) ON THIS WEBSITE. IT MATCHED EXACTLY WHAT HAPPENED TO MY VEHICLE. I TOOK THE CAR TO THE DEALERSHIP AND TOLD THEM OF THE RECALL. THEY TOLD ME THAT THE SAME PARTS NEEDED TO BE REPLACED (CRANK POSITION SENSORS, AND CAMSHAFT POSITION SENSORS) BUT MY CAR WAS NOT A PART OF THE RECALL AND THEREFORE I HAD TO PAY OUT OF POCKET FOR THE REPAIR. MY VEHICLE MATCHES THE RECALL ON YOUR WEBSITE 100% IE: " 2002 NISSAN ALTIMA...ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS...THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH WOULD RESULT IN CRASH...DEALERS WILL REPLACE THE CRANK POSITION SENSORS, CAMSHAFT POSITION SENSORS, AND IN SOME CASES THE VARIABLE TIMING CONTROL SENSORS." AGAIN, THE DEALERSHIP HAS NEGLECTED TO RECOGNIZE THIS AS A VALID RECALL. I WANT TO BE REIMBURSED FOR THE REPAIR COSTS. *TR
Engine and engine cooling, Nov 17, 2008, crash
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. WHILE DRIVING 50 MPH, THE VEHICLE SHUT OFF AND STRUCK A GUARDRAIL. THERE WERE NO INJURIES. THE VEHICLE WAS ABLE TO BE RESTARTED; HOWEVER, IT STALLED AGAIN APPROXIMATELY FOUR TIMES. THE VEHICLE WAS TAKEN TO THE DEALER AND IS CURRENTLY BEING REPAIRED. THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE AND CURRENT MILEAGES WERE 119,000.
Engine and engine cooling, Nov 13, 2008
NISSAN ALTIMA - CHECK ENGINE LIGHT CAME ON NOVEMBER 2006. NISSAN DEALERSHIP STATED THAT THE CATALYTIC CONVERTER SENSOR COULD BE BAD AND NOT NECESSARILY THE PART. THEY SHUT THE LIGHT OFF AND SENT ME ON MY WAY. THE LIGHT CONTINUED TO GO OFF AND ON OVER THE COURSE OF THE NEXT YEAR YET PASSED A STATE EMISSIONS TEST. NO OTHER ENGINE PROBLEMS OCCURRED. NOVEMBER, 2008 VEHICLE FAILED STATE EMISSIONS TEST - TOLD IT WAS THE CATALYTIC CONVERTER. NISSAN DEALERSHIP STATES THE WARRANTY RAN OUT AT 80K MILES - THE CAR HAS 83K MILES. HAVE NOT HAD THE CAR LOOKED AT BY DEALERSHIP MECHANIC YET FOR FEAR THE ESTIMATED $1000 REPAIR COULD TURN INTO AN ENGINE REPLACEMENT AT A MUCH HIGHER COST. *TR
Engine and engine cooling, Nov 13, 2008
2002 ALTIMA BEGAN STALLING DURING LOW SPEEDS TRIGGERING CHECK ENGINE LIGHT AND ACCOMPANIED BY REDUCED ENGINE POWER. DIAGNOSTICS INDICATED PROBLEM WITH CRANK SHAFT POSITION SENSOR WHICH WAS CLEARLY LISTED UNDER RECALL. NISSAN WOULD NOT ACKNOWLEDGE RECALL STATING THAT I NEEDED TO HAVE TO ECM REPROGRAMMED WHICH WOULD NOT FIX STALLING PROBLEM BUT WOULD MAKE THE ECM MORE SENSITIVE TO THE PROBLEM WITH THE CSP SENSOR. NISSAN WOULD NOT PERFORM THE ECM REPROGRAM WITH THE CHECK ENGINE LIGHT ON. NISSAN WANTED TO RUN A $90 DIAGNOSTICS TEST FIRST. I TOOK CAR TO A PRIVATE MECHANIC THE HAVE CRANKSHAFT POSITION SENSOR REPLACED WITH UPDATED FACTORY MODEL. THE SENSOR THAT WAS REMOVED WAS CLEARLY THE OLDER FLAWED MODEL WHICH WAS UNDER RECALL. *TR
Engine and engine cooling, Nov 12, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. WHILE DRIVING 30 MPH, THE VEHICLE WOULD NOT STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE EVENTUALLY CAME TO A SLOW STOP AND THE STEERING WHEEL STIFFENED. THE CONTACT TURNED OFF THE VEHICLE, BUT IT FAILED TO RESTART. THE FAILURE WAS DIAGNOSED AS THE CATALYTIC CONVERTER, WHICH NEEDED TO BE REPLACED AS WELL AS THE ENGINE. THE FAILURE AND CURRENT MILEAGES WERE 81,000.