2002 Nissan Altima
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,062 owner complaints filed for this model year. This is the 5th highest complaint count among 26 Altima model years with reports.
Of the 2002 reports, 30 involved a crash and 28 involved a fire. 27 people were injured.
What owners report most often
Recalls and investigations
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Engine and engine coolingNov 14, 2007
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L ENGINE, THE CRANKSHAFT POSITION SENSOR CAN OVERHEAT CAUSING A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.
IF THE INTERRUPTION IN THE SIGNAL FROM THE CRANKSHAFT POSITION SENSOR IS SO BRIEF THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WITHOUT WARNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED INCREASING THE RISK OF A CRASH.
DEALERS WILL REPROGRAM THE ECM FREE OF CHARGE. CERTAIN MY 2006 ALTIMAS WHICH HAVE BEEN PREVIOUSLY REMEDIED UNDER RECALL CAMPAIGN 06V223 (NISSAN R0606) ARE NOT INCLUDED IN THIS RECALL SINCE THE REPROGRAMMING FOR 06V223 ALSO INCLUDED THIS REPROGRAMMING. THE RECALL BEGAN ON DECEMBER 31, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Campaign 07V527000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. DS517-B001L AND DS517-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE OPTICEL SURFACE OF THE REFLECTOR IS CORRODED INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON DECEMBER 11, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E074000 on NHTSA.gov
Exterior lighting, headlightsAug 21, 2007
CERTAIN ANZO AFTERMARKET HEADLIGHTS, P/N 02-AZ-NA02-B-A, SOLD FOR USE ON 2002-2004 NISSAN ALTIMA VEHICLES. DURING PRODUCTION THE LAMP HOUSING SHAPE DEFORMED DISTORTING THE ASSEMBLY ANGLE OF THE REFLECTOR AND INFLUENCED THE AIMING POSITION. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT LAMPS. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS CAN CONTACT ANZO AT 909-628-1440.
Campaign 07E063000 on NHTSA.gov
Exterior lighting, headlightsJul 25, 2007
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 315-1145L-AS AND 315-1145R-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. DURING PRODUCTION THE LAMP REFLECTOR SHAPE DEFORMED CHANGING THE SHAPE OF THE OPTIC SURFACE. THIS WILL CHANGE THE OPPOSITE POSITION OF LOW BEAM AND HIGH BEAM OPTICSAND CHANGE THE ANGLE OF INCIDENCE AND ILLUMATED LOCATION WHICH FAILS TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 16, 2007. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 07E054000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Engine and engine coolingNov 17, 2003
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
Campaign 03V455000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyJul 14, 2003
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, CONNECTICUT, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WISCONSIN, AND WYOMING. AT EXTREMELY COLD TEMPERATURES, MOISTURE IN THE FUEL TANK COULD FREEZE AND FORM ICE CRYSTALS. THESE ICE CRYSTALS MAY OBSTRUCT THE SUCTION OPENING OF THE FUEL PUMP.
THIS CAN PREVENT THE SUPPLY OF FUEL TO THE ENGINE AND CAUSE THE ENGINE TO STOP, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL A SCREEN AT THE SUCTION OPENING OF THE FUEL PUMP TO PREVENT ICE CRYSTALS FROM BLOCKING THE OPENING. OWNER NOTIFICATION BEGAN ON AUGUST 18, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-333-0829.
Campaign 03V251000 on NHTSA.gov
Engine and engine cooling, exhaust system, manifold/header/muffler/tail pipeMar 11, 2003
ON CERTAIN VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE, THE EXHAUST PIPE HANGER PIN MAY CATCH DEBRIS FROM THE ROAD THAT COULD BE IGNITED BY CONTACT WITH THE MAIN CATALYST. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE.
EITHER OF THESE TWO CONDITIONS COULD RESULT IN A FIRE.
DEALERS WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIPE HANGER PIN. IN ADDITION TO THE CORRECTIVE ACTION, IN ORDER TO REDUCE THE RISK OF FIRE IN THE EVENT OF POOR OR IMPROPER MAINTENANCE THAT COULD RESULT IN OIL SPILLAGE, HEAT SHIELD(S) WILL BE INSTALLED ON THE PRE-CATALYST AND EXHAUST TUBE. OWNER NOTIFICATION BEGAN ON JULY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261. NISSAN RECALL NOS. R3007, R3014, R3015, R3016, R3017. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE. IF SUBSTRATE PARTICLES ENTER THE COMBUSTION CHAMBER, THEY COULD SCORE THE CYLINDER WALLS, RESULTING IN INCREASED OIL CONSUMPTION. IF THE ENGINE OIL LEVEL IS NOT CHECKED ON A PERIODIC BASIS AND DROPS BELOW THE LOW LEVEL, AND THE DRIVER CONTINUES TO OPERATE THE VEHICLE IGNORING NOTICEABLE ENGINE NOISE, ENGINE DAMAGE MAY OCCUR WHICH COULD RESULT IN A FIRE. THE PRE-CATALYST WILL BE TESTED TO ENSURE IT IS WORKING PROPERLY AND REPLACED IF NECESSARY. IF DAMAGE IS FOUND INSIDE THE PRE-CATALYST, IT WILL BE NECESSARY TO REPLACE THE ENGINE.
Campaign 03V084000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 27, 2003
ON CERTAIN VEHICLES, THE ELECTRICAL CONNECTOR FOR THE DRIVER AIR BAG MAY COME LOOSE. IF THE CONNECTOR COMES LOOSE, THE SUPPLEMENTAL AIR BAG WARNING LIGHT FLASHES INTERMITTENTLY.
THE DRIVER SIDE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
DEALERS WILL INSTALL A RETAINING CLIP ON THE CLOCK SPRING ELECTRICAL CONNECTOR. OWNER NOTIFICATION BEGAN APRIL 21, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Campaign 03V061000 on NHTSA.gov
Air bagsApr 17, 2002
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. ON CERTAIN 2002 NISSAN ALTIMA MODEL VEHICLES MANUFACTURED PRIOR TO MARCH 16, 2002, ONE OF THE SENSORS FOR THE AIR BAG SYSTEM DOES NOT WORK AS WELL AS EXPECTED IN HIGH-SPEED OFF-SET CRASH SITUATIONS.
THE AIR BAG SYSTEM DOES NOT WORK AS EXPECTED.
DEALERS WILL REPLACE THE AIR BAG SENSOR. OWNER NOTIFICATION BEGAN APRIL 15, 2002. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261, CONCERNING THE PROBLEM.
Campaign 02I001000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
599 reports, newest first. Show all
Engine and engine cooling, Jun 23, 2008
MY ENGINE LIGHT WILL NOT SHUT OFF!!!! *TR
Engine and engine cooling, Jun 17, 2008
2002 NISSAN ALTIMA, CASE#5865538. THE VERY PUBLIC AND WELL-DOCUMENTED PROBLEMS WITH OIL CONSUMPTION IN THE 2002 AND 2003 NISSAN ALTIMAS WARRANT YOUR IMMEDIATE ATTENTION. I HAVE SPENT OVER 26 MONTHS AND THOUSANDS OF DOLLARS TRYING TO FIX MY CAR. I FIRST NOTICED AN OIL CONSUMPTION PROBLEM AT ABOUT 75,000 MILES. I KEEP UP WITH THE REQUIRED SERVICES ON MY VEHICLE AND I MAKE OIL CHANGES AT THE RECOMMENDED INTERVALS AT A MINIMUM, SO I TRIED ADDITIONAL OIL CHANGES AND OIL REFILLS. THESE EFFORTS DID NOT SEEM TO WORK; SO I REPLACED THE CATALYTIC CONVERTER, THE TWO CRANK POSITION SENSORS, THE PCV VALVE, FOUR COIL PACKS, TWO OXYGEN SENSORS, AND THE SPARK PLUGS. MANY OF THESE ITEMS WERE ON RECALL AND NISSAN SHOULD HAVE PAID FOR THEM, BUT I PAID FOR THEM. I FOUND COUNTLESS NUMBERS OF NISSAN ALTIMA OWNERS WERE HAVING THE EXACT SAME ISSUES. IN FACT, THERE ARE NOW REPORTS OF THE 2002/2003 ALTIMA'S ENGINES CATCHING ON FIRE BECAUSE OF THIS OIL CONSUMPTION PROBLEM. THIS RISK OF ENGINE FIRE PRESENTS A RISK FOR INJURY OR DEATH TO VEHICLE OCCUPANTS, ESPECIALLY SINCE PART OF THE PROBLEM INCLUDES NO WARNING THAT THE ENGINE IS RUNNING DRY. NISSAN NORTH AMERICA HAS IT WITHIN THEIR POWER TO TURN THIS APPARENT FAILURE INTO A PUBLIC RELATIONS AND CUSTOMER SATISFACTION AND LOYALTY SUCCESS STORY. I HAVE DONE EVERYTHING THEY HAVE ASKED, WHICH INCLUDED MULTIPLE OIL CONSUMPTION TESTS. WHEN THESE TESTS WERE BEING PERFORMED, I WAS TOLD THAT IF THEY CRACKED THE ENGINE AND DID AN ENGINE INSPECTION TO PROVE THE ENGINE WAS WELL MAINTAINED, I WOULD RECEIVE A NEW ENGINE. THE LOCAL HUNTSVILLE DEALERSHIP CRACKED THE ENGINE AND STATED IT WAS THE CLEANEST THEY EVER SAW. WHEN NISSAN NORTH AMERICA WAS INFORMED OF THIS THEY DECLINED MY REQUEST FOR A NEW ENGINE OR ANY ASSISTANCE. AFTER PRESSING THE NISSAN AGENT AS TO WHY, HE SAID IT WAS A BUSINESS DECISION AND NISSAN NORTH AMERICA COULD NOT AFFORD TO REPLACE EVERYONE'S ENGINE. *TR
Engine and engine cooling, Jun 14, 2008
1. ON JUNE, 8 2008, AT 65,200 MILES 2. RANDOMLY MISFIRE CODE THAT CAUSE BY VERY SMALL LEAK CYLINDER HEAD GASKET THAT CANNOT BE DETECTED EASILY. (NO OVERHEAT, NO SMOKES FROM THE MUFFLER, JUST SLOW LOWERING COOLANT FLUID LEVEL) 3. CHANGE THE CYLINDER HEAD GASKET, AND WARPED CYLINDER HEAD. *TR
Engine and engine cooling, Jun 11, 2008
I TOOK MY 2002 NISSAN ALTIMA IN FOR REPAIR. WHEN I WAS TOLD MY CATALYTIC CONVERTER WAS BAD ALSO DESTROYING MY ENGINE. I SEARCHED YOUR WEB SITE FOR RECALLS AND FOUND ONE DEALING WITH THIS EXACT PROBLEM. WHEN I BROUGHT IT UP TO MY DEALER THEY SAID THE RECALL WAS DONE IN JANUARY OF THIS YEAR, IF IT WAS ALREADY DONE WHY WOULD IT HAPPEN AGAIN AND SHOULDN'T THEY REPLACE THE ENGINE?WELL I CONTACTED NISSAN AND THEY TOLD ME THAT THEY WOULDN;T HONOR THE RECALL ! SO I WOULD LIKE TO FILE A COMPLAINT AND HOPE THAT YOU CAN PRESSURE NISSAN TO UPDATE THEIR SERVICE TO COVER THE SECOND TIME THIS SAME DEFECT HAPPENS TO OVER 250,000 CARS. *TR
Engine and engine cooling, May 30, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT THE ENGINE DOES NOT START. WHEN THE ENGINE DOES START, THE VEHICLE SHUTTERS AND THEN SHUTS OFF. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP, BUT THE ENGINE IS STILL NOT WORKING PROPERLY. THE CURRENT MILEAGE WAS 109,000 AND FAILURE MILEAGE WAS 100,000.
Engine and engine cooling, May 29, 2008
2002 NISSAN ALTIMA PRE-CAT PROBLEM. PRE-CAT COMES APART, A BACKFLOW OF DEBRIS ENTERS ENGINE VIA THE EXHAUST MANIFOLD AND CAUSES ENGINE DAMAGE. THIS CONDITION IS THE RESULT OF A DESIGN FLAW INVOLVING THE PRE CATALYTIC CONVERTER. CONTACTED NISSAN NORTH AMERICA WAS TOLD NOTHING COULD BE DONE ON THEIR PART AS THIS IS AN ISOLATED INCIDENT. APPARENTLY THERE WAS A RECALL TO REPLACE THE PRE-CAT ON THESE ENGINES WHICH ONLY SERVED IN MOST CASES TO PUT OFF THE PRE-CAT BLOW UP PAST ENGINE WARRANTY. *TR
Engine and engine cooling, May 28, 2008
WHEN I START MY CAR IN THE MORNING IT ALWAYS TAKES TWO OR THREE TIMES FOR THE CAR TO START. I FIGURED MAYBE MY ENGINE WAS JUST COLD. BUT THEN WHEN I WAS DRIVING, I SLOWED DOWN BECAUSE A RED LIGHT WAS COMING UP AND MY CAR COMPLETELY SHUT OFF!! I WAS SO SCARED BECAUSE MY I ALMOST HIT THE PERSON IN FRONT OF ME. I FIGURED THAT SOMETHING WAS WRONG SO I BETTER TAKE MY CAR TO THE DEALERSHIP SOON. THE NEXT DAY MY CAR WOULDN'T START AT ALL?? I HAD TO HAVE MY CAR TOWED TO THE DEALERSHIP BUT BEFORE I WENT, I CHECKED TO SEE IF THERE WERE ANY RECALLS ON MY CAR. THERE WAS A RECALL ON MY VEHICLE REGARDING THE REGARDING THE CRANKSHAFT SENSOR. THE WHOLE TIME MY CAR WAS BEHAVING THIS WAY THE SERVICE LIGHT NEVER APPEARED. WHEN THE I GOT TO THE CERTIFIED NISSAN DEALERSHIP THEY EXPLAINED THAT YES THERE IS A RECALL BUT THAT MY VEHICLE NEEDED "A NEW CRANKSHAFT SENSOR BECAUSE MY SENOR WAS NO LONGER GOOD." I SAID THE RECALL CLEARLY STATES THAT THE CRANKSHAFT SENSOR IS KNOWN TO OVERHEAT WHICH CAUSED MY CRANKSHAFT SENOR TO NOW BE REPLACED. SO, I SHOULD BE ABLE TO GET MY CRANKSHAFT SENOR UNDER THIS RECALL. THEY INSISTED NO AND IF I HAVE ANY PROBLEMS I NEED TO CONTACT THE MANUFACTURER. PLEASE HELP!!! *TR
Engine and engine cooling, Power train, May 27, 2008
I HAVE 2002 NISSAN ALTIMA 2.5 S,MY CAR BURN OIL LIKE CRAZY, COULD MAKE A FIRE IF I DIDN'T KEEP CHECKING ON THE OIL LEVEL, I SPENT 5 QUART JUST FROM IOWA TO MINNEAPOLIS AND FOR THE LOCAL DRIVE I NEED TO REFILL 1 QUART OF OIL EVERY 5-6 DAYS (BETWEEN OFFICE AND HOME WHICH IS JUST 4 MINUTES DRIVING). *TR
Service brakes, Hydraulic, Engine and engine cooling, May 27, 2008
2002 NISSAN ALTIMA. 1)REAR PADS + ROTORS WORN AT 35,000 MILES: REPLACED AT OWNERS COST. NOW 83000 MILES(MAY '08): DEALER HAS TOLD ROTORS AND PAD NEED REPLACEMENT AND POSSIBLY CALIPERS NEED TO BE EVALUATED. AT 75000 MILE CHECK EVERYTHING WAS OK. (PER THE SERVICE RECORD). IN JAN'08 I HAD SPECIFICALLY ASKED THE BREAKS TO BE INSPECTED. TOLD OK. NOW SUDDENLY THE ROTORS ARE SHOT. OTHER THAN A SQUEAL SOUND FOR 2 DAYS NO OTHER SYMPTOMS. CONCERNED ABOUT HOW BRAKES GO FROM FINE TO SHOT IN 3 MONTHS. I THINK IT IS A BIG SAFETY CONCERN IF THE TIME IT TAKES BREAKS TO DISINTEGRATE IS LESS THAN A 3 MONTH PERIOD. 2) ENGINE NOT STARTING AFTER PARKED IN THE COLD. HAPPENED TWICE ONCE AT 48000 MILES. (LOWER BILL. ) 2ND TIME AT 78000 MILES. (HUGE BILL ~$1000). MULTIPLE PARTS REPLACED AND SERVICED. HIGHLIGHTED AS PROBLEM ON VARIOUS FORUMS WITH THIS PARTICULAR NISSAN MODEL. EVALUATE POSSIBILITY RELATED TO ECM TIMINGS ETC. *TR
Engine and engine cooling, May 21, 2008
LOSING OIL AND COOLANT WHICH LED TO COMPLETE ENGINE FAILURE IN MARCH 2006. REPLACED ENGINE AND 50K MILES LATER LOSING COOLANT AND MISFIRE ON CYLINDER 3. SUSPECT HEAD GASKET PROBLEM. *TR
Engine and engine cooling, May 20, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT IGNITION DOES NOT IMMEDIATELY TURNOVER WHEN ATTEMPTING TO START THE VEHICLE. THE IGNITION HESITATES REGULARLY IN ALL TEMPERATURES. PRIOR TO THE FAILURE, THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. SHE TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC AND WAS INFORMED THAT THE FUEL PRESSURE WAS IN GOOD CONDITION AND THE COOLING LEVEL WAS LOW. THERE WAS MAINTENANCE WORK PERFORMED ON THE COOLING SYSTEM. THE MECHANIC ALSO OBSERVED THAT THE HEAD GASKET WAS LEAKING INTERNALLY AND ADVISED THAT IT BE REPLACED. THE HEATER HAS BEEN REPLACED TWICE ON THE VEHICLE. THE HEAD GASKET HAS NOT YET BEEN REPAIRED. THE FAILURE MILEAGE WAS 65,000 AND CURRENT MILEAGE WAS 66,783.
Engine and engine cooling, May 19, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. WHILE DRIVING AT ANY SPEED, THE VEHICLE WOULD SHUT OFF AND TAKE 5-10 MINUTES TO RESTART. THE FAILURE WORSENED OVER THE COURSE OF A FEW DAYS. THE DEALER STATED THAT THE CRANK SHAFT POSITIONING SENSOR NEEDED TO BE REPLACED. THERE ARE TWO NHTSA CAMPAIGN ID NUMBERS (03V455000 AND 07V527000), BOTH FOR ENGINE AND ENGINE COOLING; HOWEVER, THE CONTACT WAS INFORMED THAT THERE WERE NO RECALLS ON HER VEHICLE AND SHE WOULD HAVE TO PAY FOR THE REPAIR. THE CURRENT AND FAILURE MILEAGES WERE 114,000.
Engine and engine cooling, May 16, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 03V455000 (ENGINE AND ENGINE COOLING). HE CALLED THE DEALER AND HAD THE VEHICLE REPAIRED. SEVERAL YEARS LATER, WHILE DRIVING 25 MPH, THE VEHICLE FAILED WITHOUT WARNING. HE TOOK THE VEHICLE BACK TO THE DEALER AND A REPRESENTATIVE INFORMED HIM THAT BECAUSE THE VEHICLE HAD PREVIOUSLY BEEN REPAIRED UNDER THE RECALL, HE WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE VEHICLE HAS BEEN REPAIRED. IN ADDITION, THE REPRESENTATIVE AT THE DEALER ADVISED HIM THAT WHEN THE VEHICLE WAS REPAIRED IN 2004, THE TECHNICIAN USED THE SAME EXACT PART THAT THEY REMOVED TO REPAIR THE VEHICLE. THE CONTACT CALLED THE DEALER, BUT THEY DID NOT PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 49,555. UPDATED 06/09/2008. *LJ THE CRANK POSITION SENSOR WAS REPLACED. UPDATED 06/09/08. *JB
Service brakes, Hydraulic, Engine and engine cooling, May 14, 2008, fire
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. WHILE DRIVING 75 MPH, THE CONTACT HEARD A BUMPING SOUND FROM OUTSIDE THE VEHICLE AND NOTICED THAT THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE LOST POWER AND THE BRAKES FAILED. THE CONTACT HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. ONCE THE VEHICLE WAS STOPPED, SHE WAS UNABLE TO PLACE THE VEHICLE INTO PARK. THE CONTACT EXITED THE VEHICLE AND NOTICED THAT THE FRONT END CAUGHT FIRE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 143,000.
Engine and engine cooling, May 13, 2008
WHILE DRIVING ON THE INTERSTATE MY CAR STALLED AROUND 70 MPH CAUSING ME TO HAVE TO PULL OFF THE ROAD WHILE IN A THUNDER STORM. SINCE THAT MY CAR IS ALSO BURNING ABOUT A QUART OF OIL EVERY 2 WEEKS. *TR
Engine and engine cooling, Equipment, May 12, 2008
2002 NISSAN ALTIMA CATALYTIC CONVERTER FAILURES THAT ARE INCREASING ACCORDING TO REPORTS WIDELY PUBLICIZED ON THE INTERNET. THERE IS A RECALL IN CANADA FOR THE PROBLEM, BUT NOT IN US. IN SPEAKING WITH A REPRESENTATIVE FROM NISSAN CONSUMER AFFAIRS, I HAVE BEEN ADVISED THAT THE REASON FOR THE RECALL BEING RECOGNIZED IN CANADA BUT NOT IN THE U.S. IS DUE TO THE FACTORY IN WHICH VEHICLES WERE PRODUCED. SEEMS TO ME THIS REASON IS RIDICULOUS IF THIS PROBLEM IS HAPPENING IN THE U.S. TOO! SEE INFO BELOW: TRANSPORT CANADA RECALL NUMBER 2003060. UNITS AFFECTED: 30589. 2002-2003: ON CERTAIN VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE, THE EXHAUST PIPE HANGER PIN MAY CATCH DEBRIS FROM THE ROAD WHICH COULD BE IGNITED BY CONTACT WITH THE MAIN CATALYST. CORRECTION: DEALER WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIPE HANGER PIN. ALSO, CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE. IF SUBSTRATE PARTICLES ENTER THE COMBUSTION CHAMBER, THEY MAY SCORE THE CYLINDER WALLS, RESULTING IN INCREASED OIL CONSUMPTION. CORRECTION: DEALER WILL REPROGRAM THE ENGINE CONTROL UNIT TO PREVENT THE POSSIBILITY OF THE PRE-CATALYST OVERHEATING. IF THE CONVERSION EFFICIENCY OF THE PRE-CATALYST HAS DETERIORATED, THEN THE CATALYST WILL BE REPLACED. THE ORIGINAL PRE-CATALYST WILL THEN BE INSPECTED FOR EVIDENCE OF DAMAGE TO THE CATALYST SUBSTRATE. IF DAMAGE IS PRESENT, THE VEHICLE ENGINE WILL BE REPLACED. WHILE I HAVE BEEN OBSESSIVE ABOUT ENSURING MY VEHICLE IS SERVICED ROUTINELY, I HAVE RECENTLY EXPERIENCED ENGINE FAILURE WHICH WILL RESULT IN HAVING TO REPLACE MY ENGINE. I DO NOT HAVE THE FINANCES TO JUST DROP $2000 ON A NEW ENGINE! MY CASE IS CURRENTLY IN THE HANDS OF A REGIONAL SPECIALIST (FILE # 6149122), BUT I HAVE NOT GOTTEN THE OUTCOME OF THE REVIEW TO DATE. I AM RESPECTFULLY REQUESTING REVIEW OF THIS PROBLEM. THANK YOU. *TR
Engine and engine cooling, May 8, 2008
I HAVE A NISSAN ALTIMA (2002) WITH UNDER 75,000 MILES. I HAVE BEEN EXPERIENCING PROBLEMS WITH THE COOLANT SYSTEM FOR ROUGHLY 10,000 MILES. THE COOLANT TANK DRAINS EVERY 2-3 DAYS. I REFILL IT, AND IT IS EMPTY 2 -3 DAYS LATER. I HAVE HAD 3 OR 4 SEPARATE TESTS DONE ON THE COOLANT SYSTEM, AND NO PROBLEMS WERE FOUND. YET, THE PROBLEMS CONTINUE. RECENTLY, GRAY SMOKE FLOWS OUT OF THE TAIL PIPE UPON STARTING THE CAR. ALSO, WHEN STARTING THE CAR, THE WHOLE VEHICLE SHUTTERS, AND SOMETIMES DOES NOT TURN RIGHT OVER (REQUIRING 2 OR 3 TURNS OF THE IGNITION KEY). I WAS TOLD THAT PERHAPS IT IS A BLOWN HEAD GASKET, WARPED HEAD, OR SOMETHING OF THE SORT. EITHER WAY, IT WAS DETERMINED THAT THE COOLANT IS SOMEHOW LEAKING INTO THE ENGINE (BECAUSE NO SIGNS OF LEAKS ANYWHERE ELSE HAVE BEEN DETECTED). WITH ONLY 75,000 MILES ON THE CAR, THIS SHOULD BE CONSIDERED A MANUFACTURERS PROBLEM. THE COOLANT TANK IS EMPTIED EVERY 2-3 DAYS, THE GRAY SMOKE BLOWING OUT OF THE TAIL PIPE HAPPENS AT LEAST 3 TIMES A WEEK, AND THE SHUTTERING (AND INABILITY TO START INITIALLY) HAPPENS 1-2 TIMES A WEEK, WITH INCREASING FREQUENCY. NOTHING WAS DONE TO CORRECT THE PROBLEM. ONE DEALERSHIP SAID THAT THERE WAS NOTHING WRONG WITH THE VEHICLE, WHICH OBVIOUSLY IS NOT THE CASE. I WAS TOLD BY 2 MECHANICS (ONE AT THAT SAME DEALERSHIP, AND ONE INDEPENDENT) THAT THE PROBLEM IS INTERNAL, AND THAT THE ENTIRE MOTOR WOULD PROBABLY HAVE TO BE REPLACED. AT THE VERY MINIMUM, THE HEAD GASKET AND / OR HEADER. RESEARCHING THE INTERNET, I FOUND HUNDREDS OF SIMILAR COMPLAINTS BY OWNERS OF NISSAN'S OF THE SAME OF SIMILAR MODEL AND YEAR. THIS PROBLEM SHOULD BE LOOKED INTO, AND SHOULD BE SERIOUSLY CONSIDERED FOR A RECALL! *TR
Engine and engine cooling, Power train, Visibility, May 7, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE SERVICE ENGINE LIGHT BEGAN ILLUMINATING INTERMITTENTLY AND THEN REMAINED LIT. WHEN STARTING THE VEHICLE AND TAKING OFF, THE VEHICLE MADE A STRANGE NOISE AND JERKED AS IF SOMETHING WERE SLIPPING. ONCE THE VEHICLE GAINED SPEED, THE NOISE STOPPED. THE DEALER STATED THAT THE FOLLOWING COMPONENTS NEEDED TO BE REPLACED: THE CATALYTIC CONVERTER, TWO MAJOR SENSORS, AND THE HEATING AND AIR CONDITIONING SYSTEMS. THE VEHICLE WAS BURNING OIL ON THE INSIDE OF THE ENGINE, WHICH CAUSED IT TO FAIL. THE VEHICLE COULD HAVE AN OIL CHANGE AND THEN FOUR DAYS LATER, THE OIL WOULD HAVE BURNED OUT COMPLETELY. NHTSA CAMPAIGN ID NUMBERS 03V084000 (ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/ HEADER/MUFFLER/TAIL PIPE), 07V527000 (ENGINE AND ENGINE COOLING), AND 03V455000 (ENGINE AND ENGINE COOLING WERE REFERENCED. THE CURRENT MILEAGE WAS 116,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 06/05/08 *BF THE DRIVER SIDE POWER MIRROR WAS REPLACED, THE GEAR SELECTOR WAS STICKING. THE CYLINDER HEAD, GASKET RADIATOR AND THERMOSTAT WERE REPLACED. WERE REPLACED. UPDATED 06/04/08
Engine and engine cooling, Equipment, May 7, 2008
2002 NISSAN ALTIMA FAULTY ENGINE AND CATALYTIC CONVERTER. *TR
Engine and engine cooling, May 5, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V527000 (ENGINE AND ENGINE COOLING). NISSAN REFUSED TO PERFORM THE RECALL REPAIR BECAUSE THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE DOES NOT ALWAYS START, IT IS LOSING COOLANT, AND THE OIL AND CHECK ENGINE LIGHTS ILLUMINATE INTERMITTENTLY. THE FAILURE MILEAGE WAS 94,400.
Engine and engine cooling, May 3, 2008
2002 NISSAN ALTIMA BEGAN OVERHEATING, LOSING COOLANT RAPIDLY AND GAUGES INDICATED RAPID TEMPERATURE FLUCTUATIONS. UPON TAKING VEHICLE TO DEALER, VISUAL DIAGNOSTIC SUGGESTED A REPLACEMENT OF VALVE COVER GASKET. GASKET WAS REPLACED FOR APPROXIMATELY $300. OVERHEATING RESUMED AFTER REPAIRS IN ADDITION TO OVERHEATING, VEHICLE BEGAN PRODUCING WHITE SMOKE AS WELL AS MISFIRING UPON START-UP. COMPUTERIZED DIAGNOSTIC WAS THEN COMPLETED. DIAGNOSIS WAS A BLOWN HEAD GASKET. REPAIR COST WAS QUOTED AT $2100 PLUS TAXES. I DID RESEARCH ONLINE AND INVESTIGATION REVEALED THAT THE BLOWN HEAD GASKET WASN'T ISOLATED TO ME ALONE AND THAT THERE ARE MANY 2002 NISSAN ALTIMAS THAT BLOW THE HEAD GASKET AROUND 70,000 TO 90,000 MILES. MANY CUSTOMERS APPEAR TO HAVE TRIED TO CONTACT NISSAN BUT COMPANY WILL NOT OWN UP TO APPARENT DEFECT WITH THE MODEL. IT IS QUITE DIFFICULT TO BLOW A VEHICLE'S HEAD GASKET AND IT IS UNFAIR FOR A MODEL TO HAVE SUCH A MAJOR DEFECT AND THE CONSUMERS HAVE TO ASSUME RESPONSIBILITY AND COST OF REPAIRING THE PROBLEM - A MAJOR ENGINE OVERHAUL. TO PRESENT, NO INJURIES OR CRASHES HAVE RESULTED, HOWEVER, DEALER HAS WARNED THAT WITHOUT REPAIR, ENGINE PARTS MAY CONTINUE TO WARP AND MAY RESULT IN COMPLETE ENGINE FAILURE. *TR
Engine and engine cooling, Apr 29, 2008
2002 NISSAN ALTIMA 2.5 L ENGINE EXCESSIVE ENGINE OIL CONSUMPTION, BURNING OIL NO LEAKS. BLACK SMOKE FROM EXHAUST PIPE WANTS TO STALL AND SHAKES MOST OF THE TIME. CHECK ENGINE LIGHT COMES ON AND OFF. *TR
Engine and engine cooling, Apr 28, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE FEELS AS IF IT WILL SHUT OFF, BUT IT REMAINS RUNNING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC, WHO STATED THAT THERE MAY BE RECALLS ON HER VEHICLE. THE MANUFACTURER STATED THAT THERE WERE FOUR OPEN RECALLS ON HER VEHICLE AND ADVISED HER TO GO TO A DEALER FOR THE RECALL REPAIR. THE REPAIR WAS MADE, BUT THE FAILURE CONTINUED. THE CONTACT RETURNED TO HER LOCAL MECHANIC AND THE OXYGEN SENSOR WAS REMOVED. THE MECHANIC DISCOVERED THAT THE CATALYTIC CONVERTER HAD SHATTERED INTO PIECES AS EXPLAINED IN NHTSA CAMPAIGN ID NUMBER 03V084000 (ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE). THE FAILURE MILEAGE WAS 149,000.
Engine and engine cooling, Apr 23, 2008
CATASTROPHIC ENGINE FAILURE FOR NISSAN ALTIMA RELATED TO POWER VALVE/BUTTERFLY VALVE INTAKE MANIFOLD DESIGN. THIRD GENERATION ALTIMA'S QR25DE 4-CYLINDER AND VQ35DE 6-CYLINDER ENGINES HAVE UNFORTUNATELY BEEN AFFECTED BY A RECALL RELATED TO THE INTAKE MANIFOLD AND THE POWER VALVES, ALSO KNOWN AS THE BUTTERFLY VALVE. THE TECHNICAL SERVICE BULLETIN P5202 - DOES NOT MENTION ALL AFFECTED VEHICLES FOR PRODUCTION YEARS W SAME DESIGN. THIS HAS LEFT SOME OWNERS AFFECTED BY THE PROBLEM WITH NO RECOURSE/REMEDY FOR WHAT IN SOME CASES HAS AMOUNTED TO CATASTROPHIC ENGINE FAILURE. THE POWER VALVE IS A SERIES OF FOUR PLATES IN THE QR25DE 4-CYLINDER AND 6 PLATES IN THE VQ35DE 6-CYLINDER ENGINES, ONE PER CYLINDER. THE PLATES OPEN AND CLOSE SIMULTANEOUSLY TO ALLOW MORE AIR INTO THE COMBUSTION CHAMBER FOR INCREASED POWER. EACH PLATE IS HELD IN PLACE BY TWO SCREWS. THE SCREWS HAVE BEEN KNOWN TO COME LOOSE AS WELL AS THE PLATES AND ARE THEN INGESTED INTO THE ENGINE VIA THE INTAKE PORTS. PROBLEM IS INITIALLY EXHIBITED BY SES(SERVICE ENGINE SOON) LIGHT COMING ON AND/OR BLINKING. UPON OBD METER READING, CODE WILL BE P0304, OR SIMILAR WHICH IS RANDOM CYLINDER MISFIRE OR CYLINDER 4 MISFIRE. ELECTRODE ON SPARK PLUG HAS BEEN BENT CLOSED AS A RESULT OF THE POWER VALVE RETAINING SCREW VIBRATING LOOSE AND BEING INGESTED INTO THE ENGINE. THE SCREW THEN BOUNCES AROUND IN THE COMBUSTION CHAMBER, HITTING THE SPARK PLUG AND BENDING THE ELECTRODE SHUT, PREVENTING SPARK IN THAT CYLINDER. ADDITIONALLY, THE SCREW(S) AND PART OF THE BROKEN PLATES, IN SOME CASES HAVE MADE THEIR WAY THROUGH THE ENGINE AND INTO THE EXHAUST MANIFOLD AND THE CATALYTIC CONVERTER, THUS CAUSING THE CATALYTIC CONVERTER TO PREMATURELY DISINTEGRATE AS WELL AS BECOME INGESTED INTO THE ENGINE. FOR SOME REASON, NISSAN NORTH AMERICA HAS DECIDED TO NOT REMEDY ALL VEHICLES AFFECTED BY THIS ADMITTED FLAW OBVIOUSLY, THIS COULD CAUSE ENGINE FAILURE AT THE WRONG PLACE AND THE WRONG TIME, RESULTING IN SERIOUS BODILY HARM AND/OR FATALITY. *TR
Engine and engine cooling, Apr 23, 2008
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT THE VEHICLE SHUT OFF AFTER THE ELECTRONIC CONTROL MODULE (ECM) WAS REPLACED UNDER NHTSA CAMPAIGN ID NUMBER 07V527000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR A DIAGNOSIS, BUT NO FAILURE WAS IDENTIFIED. THE CURRENT MILEAGE IS 109,000 AND FAILURE MILEAGE WAS 108,000. UPDATED 05/13/08. *LJUPDATED 05/13/08. *JB