2001 Subaru Outback
Problems, recalls and owner-reported issues
Fuel system is the leading concern among 170 owner complaints filed for this model year. This is the 18th highest complaint count among 26 Outback model years with reports.
Of the 2001 reports, 16 involved a crash and 4 involved a fire. 7 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, delivery, fuel pumpNov 29, 2013
Airtex Products LP (Airtex) is recalling certain model E8598M, E8518M, E8600M, E8596M, and E8597M fuel pumps manufactured July 26, 2013, and July 29, 2013 and used as aftermarket replacements on Subaru Baja's, Outback's and Legacy's. The affected fuel pumps were sold or installed into the aftermarket applications on or after July 26, 2013, and may may leak fuel from the base of a fuel line connection when the gas tank is full.
A fuel leak in the presence of an ignition source increases the risk of a fire.
Airtex will notify owners, and will replace the fuel pump, free of charge. Recall is expected to begin on January 2, 2014. Customers may contact Airtex at 1-800-880-3056. The recall is expected to begin during January 2014. This recall is being conducted by Airtex, not by Subaru.
Campaign 13E065000 on NHTSA.gov
Vehicle speed control, cablesMar 16, 2004
ON CERTAIN PASSENGER SEDANS, WAGONS, AND SPORT UTILITY VEHICLES, THE CRUISE CONTROL CABLE COULD COME OUT OF ITS TRACK ON THE CRUISE CONTROL LEVER AND LODGE ON THE CONTROL LEVER TAB WHEN THE ACCELERATOR PEDAL IS RELEASED. IF THIS CONDITION OCCURS, THE THROTTLE WILL NOT RETURN TO THE IDLE POSITION AND WILL REMAIN IN AN OPEN POSITION.
IF THIS OCCURS DURING VEHICLE OPERATION, THE DRIVER COULD LOSE CONTROL OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
DEALERS WILL INSTALL A CRUISE CONTROL CABLE RETAINING CLIP TO THE CRUISE CONTROL LEVER TAB ON THE THROTTLE SHAFT IN ORDER TO PREVENT THE CRUISE CONTROL CABLE FROM COMING OUT OF ITS TRACK. OWNER NOTIFICATION BEGAN ON APRIL 12, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.
Campaign 04V128000 on NHTSA.gov
Suspension, rearApr 22, 2003
THIS RECALL APPLIES TO CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. CERTAIN REAR SUSPENSION SUBFRAME COMPONENTS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE ROAD SALTS FOR A PERIOD OF SEVERAL YEARS, COULD RESULT IN RUST-OUT OF THE COMPONENT AND POSSIBLE BREAKAGE OF THE SUBFRAME.
IF SUCH BREAKAGE OCCURS WHILE THE VEHICLE IS BEING OPERATED, CONTROL OF THE VEHICLE COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
DEALERS WILL CLEAN AND RUST-PROOF THE REAR SUSPENSION SUBFRAME. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
Campaign 03V153000 on NHTSA.gov
Power train, automatic transmissionOct 30, 2002
CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS WERE PRODUCED WITH AN IMPROPERLY MANUFACTURED TRANSMISSION PARKING ROD. WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE "P" (PARK) POSITION, THE TRANSMISSION PARK MECHANISM, THAT IS INTENDED TO HOLD YOUR VEHICLE, MAY NOT ENGAGE.
THE VEHICLE COULD THEN MOVE/ROLL WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION PARKING ROD ASSEMBLY. OWNER NOTIFICATION JANUARY 8, 2003. AN INTERIM OWNER NOTIFICATION WILL BE SENT DURING NOVEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
Campaign 02V282000 on NHTSA.gov
Representative owner complaints: power train
23 reports, newest first. Show all
Power train, Sep 9, 2008
TL*THE CONTACT OWNS A 2001 SUBARU OUTBACK. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT HEARD A LOUD CLICKING NOISE AND THEN THE VEHICLE STALLED. HE NOTICED THAT THE TRANSMISSION HAD FALLEN OUT OF THE VEHICLE ONTO THE ROAD. THE VEHICLE WAS TOWED TO HIS RESIDENCE. HE IS IN THE PROCESS OF NOTIFYING THE DEALER TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 75,000.
Power train, Apr 9, 2008
THE AUTOMATIC TRANSMISSION PARK MECHANISM DOES NOT ENGAGE PROPERLY. WITH SELECTOR LEVER IN "PARK " AND CAR TURNED OFF AND IGNITION KEY REMOVED, THE CAR ROLLS. IN THE EARLY YEARS, THE CAR ROLLED ONLY SLIGHTLY AND FINALLY "ENGAGED": NOW, THE CAR ROLLS SEVERAL FEET AND DOES NOT ALWAYS ENGAGE, REQUIRING USE OF THE EMERGENCY BRAKE FOR ALL PARKING. BECAUSE THE PROBLEM IS GETTING WORSE, WE SEARCHED FOR REPAIR & RECALL INFORMATION. WE FOUND THAT ALTHOUGH OUR MODEL & YEAR ARE ON THE RECALL LIST FOR THIS PARK MECHANISM, OUR VIN# IS NOT. *TR
Power train, Feb 12, 2008
STARTING AROUND 62K MILES, I HEARD A WHINING NOISE FROM THE FRONT OF THE CAR. THE NOISE GOT LOUDER AND HIGHER WITH WHEEL SPEED. WHEN I TOOK IT TO A MECHANIC, THEY DIAGNOSED A BAD DIFFERENTIAL BEARING, AND INFORMED ME THAT THE RECOMMENDED FIX WAS REPLACEMENT OF THE ENTIRE TRANSMISSION, INCLUDING BOTH DIFFERENTIALS. WHEN I WENT TO THE DEALER TO CONFIRM THIS, THEY QUOTED ME $6,000-$8,000 FOR THE REPAIR. I TRIED TO GET SOME RELIEF FROM SUBARU OF AMERICA, SINCE THE POWERTRAIN WARRANTY GOES FOR 60K MILES, BUT THEY WERE UNWILLING. THIS CAUSED THE VALUE OF MY CAR TO GO TO ZERO, SINCE IT'S WORTH ABOUT $8,000 WITHOUT THE TRANSMISSION PROBLEM. *TR
Power train, Jul 12, 2005
I OWN A 2001 SUBARU OUTBACK. AFTER HEARING A WHINING NOISE IN THE FRONT OF THE CAR, I TOOK MY CAR INTO MY MECHANIC. HE INFORMED ME THAT I PROBABLY NEEDED TO HAVE THE FRONT DIFFERENTIAL REPLACED AND REFERRED ME TO THE DEALERSHIP. THE DEALERSHIP TOLD ME I NEEDED THE ENTIRE TRANSMISSION REPLACED. BECAUSE THE MILAGE ON MY CAR WAS AT 62,000 MILES, THE DEALERSHIP WOULD NOT HONOR MY WARRANTY BECAUSE IT ONLY EXTENDED TO 60K. ASTOUNDED THAT ANY CAR WITH ONLY 62K MILES ON IT WOULD NEED ITS ENTIRE TRANSMISSION REPLACED, I APPEALED TO SUBARU CUSTOMER SERVICES AND ASKED THEM TO OWN UP TO THE DEFECT. THEY DECLINED MY REQUEST.
Power train, Jun 27, 2005
CLUTCH CHATTER: MY CLUTCH IS CHATTERING OR SHUTTERING WHEN THE CAR IS COLD OR I AM DRIVING IT FOR THE FIRST TIME IN THE DAY. THIS HAS BEEN A PROBLEM SINCE I PURCHASED THE VEHICLE 2 YEARS AGO.
Power train, May 4, 2005
SINCE DAY ONE, THE CLUTCH HAS SHUDDERED AT ENGAGEMENT WHEN ENGINE/DRIVETRAIN IS COLD. THE TREMORS ARE VIOLENT ENOUGH TO SHAKE THE ENTIRE VEHICLE DISTURBINGLY. THIS HAS BEEN A NUISANCE AND SOMEWHAT OF A SAFETY ISSUE AS YOU CANNOT ACCELERATE QUICKLY IF NECESSARY. OVER THE LAST 10000 MILES OR SO, I'VE NOTICED A BURNING SMELL WHEN ENGAGING THE CLUTCH ON AN UPHILL START. DEALERSHIP SAYS THE CLUTCH IS SLIPPING AND WILL NEED REPLACEMENT SOON AND I ONLY HAVE 61500 HIGHWAY MILES ON THE CAR! I'VE HAD PLENTY OF CARS GO OVER 150000 MILES WITH NO CLUTCH PROBLEMS. SUBARU HAS A DEFINITE DESIGN FLAW IN THESE HYDRAULIC CLUTCHES THAT THEY ARE REFUSING TO OWN UP TO! REGRETTABLY, I MAY HAVE PURCHASED MY LAST SUBARU.
Power train, Sep 21, 2004, crash
CONSUMERS CHILD ACCIDENTALLY BUMPED THE SHIFT MECHANISM CAUSING VEHICLE TO ROLL BACKWARDS. THE KEYS WERE NOT IN THE IGNITION WHEN THE CONSUMERS SON BUMPED INTO THE SHIFT. IT WAS VERIFIED THAT THE SAFETY INTERLOCK WAS NOT OPERATING AS DESIGNED. (A PIN HAD COME DISCONNECTED) *SC *JB
Power train, May 11, 2004
MY CLUTCH SHUDDERS WHEN COLD AND SOMETIMES WHEN WARMED UP. BEEN HAPPENING SINCE AROUND 20K MILES. TOOK TO DEALER AT 25K MILES BUT THEY COULDN'T DUPLICATE PROBLEM. THEY SAID BRING IT BACK WHEN PROBLEM WORSENS. BROUGHT BACK TO DEALER AT 56K MILES, AND DEALER SAID CLUTCH WAS BAD. WOULDN'T COVER IT UNDER WARRANTY SINCE THEY SAID IT WAS "USER WEAR". YEAH, RIGHT! I HAD TO PAY FULL COST TO REPLACE THE CLUTCH!! I THINK THIS SHOULD BE INVESTIGATED SINCE MANY PEOPLE WITH OUTBACK CLUTCHES HAVE SIMILAR PROBLEMS. I'VE LOOK AT OUTBACK MODEL YEARS 2000-2003 ON THE NHTSA COMPLAINT WEB SITE AND THERE ARE MANY INCIDENCES ABOUT THE DEFECTIVE CLUTCHES.
Power train, May 3, 2004
WHILE DRIVING 50 MPH THERE WAS VIBRATION IN THE CENTER OF THE VEHICLE. CONSUMER TOOK VEHICLE TO THE DEALERSHIP, AND TECHNICIAN DETERMINED REAR DIFFERENTIAL UNIT NEEDED TO BE REPLACED. *AK
Power train, Apr 23, 2004
MY 2001 SUBARU OUTBACK HAS A CLUTCH SHUDDER ( JUTTER ) THAT IS REPORTED TO OCCUR IN ALL SUBARU MODELS WITH THE 2.5 LTR ENGINE. THERE ARE INUMERABLE CONSUMER COMPLAINTS ABOUT THE PROBLEM AND YET SUBARU BURRIES ITS HEAD IN THE SAND AND PRETENDS THERE IS NO PROBLEM.*AK
Power train, Apr 13, 2004
SINCE ABOUT 10,000 MILES THE CLUTCH SHUDDERS WHEN TRYING TO ACCELERATE. USUALLY ONLY WHEN ENGINE IS COLD BUT NOT 100% OF THE TIME. HAVE COMPLAINED TO SUBARU DEALER BUT THEY COULD NOT DUPLICATE THE PROBLEM. APPARENTLY A KNOWN PROBLEM WITH SOME SUBARUS BUT NOT ALL DEALERS ADDRESS IT.
Power train, Apr 7, 2004
THE CLUTCH ON OUR 2001 SUBARU OUTBACK LIMITED SHUDDERS WHEN THE CAR AND/OR TEMPERATURE IS COLD. IT HAS DONE THIS FOR THE LAST 30-40,000 MILES.*AK
Power train, Dec 4, 2003
CLUTCH SHUDDER PROBLEM SINCE 20K MILES. HAPPENS WHEN COLD OR DAMP OUT, HESITATES WHEN ACCELERATING IN FIRST GEAR, FROM STOPPED POSITION. THE VEHICLE WAS TAKEN TO THE DEALER 3 TIMES, INCLUDING TEST DRIVE W/ MECHANIC,CAN'T FIND THE PROBLEM. *NLM
Power train, Oct 7, 2003
MY SUBARU OUTBACK UNLIMITED 2001 NEEDS A TRANSMISSION REPLACED AFTER ONLY 74,000. ALL THE REPAIRS AND SERVICE WERE PERFORMED AT THE DEALERSHIP INCLUDING THE 60,00 MILE MAJOR TUNE-UP. ALL THE SERVICE WAS DONE TIMELY AND AS RECOMMENDED. THE DEALER FIRST SAID THE NOISE WAS THE ALTERNATOR AND REPLACED THE ALTERNATOR, BUT THE NOISE CONTINUED. I TOOK THE CAR TO ANOTHER SUBARU DEALER WHO SAID THE PROBLEM WAS THE TRANSMISSION AND SUSPECTED IT WAS NOT SERVICED APPROPRIATELY. I RETURNED THE CAR TO THE ORIGINAL DEALER AT THEIR REQUEST. THEY THEN REMOVED THE REPLACED ALTERNATOR AND RETURNED MY ORIGINAL ALTERNATOR, BUT REFUSED ANY RESPONSIBILITY FOR MY TRANSMISSION FAILURE. *JB
Power train, Sep 25, 2003
THE VEHICLE WAS PARKED AND OFF. PLEASE PROVIDE ANY FURTHER INFORMATION. *NLM THE VEHICLE MOVED FORWARD TOWARDS THE FENCE. *LA
Power train, Sep 10, 2003
2001 SUBARU OUTBACK, 22000 MILES. CLUTCH NEEDED REPLACEMENT. *JB
Power train, Vehicle speed control, Mar 11, 2003
CAR HAS SIGNIFICANT HESITATION DURING PERIODS OF ACCELERATION, USUALLY AROUND 2500-3500 RPM. POTENTIALLY DANGEROUS IN MANY DRIVING SITUATIONS. HAVE REPORTED TO DEALER MULTIPLE TIMES. RESPONSE IS ALWAYS "CANNOT REPRODUCE - COMPUTER SHOWS OPERATING AS DESIGNED". CAR ALSO HAS SPONTANEOUS ACCELERATION AT LOW SPEED, SUCH AS FIRST TAKING FOOT OFF BRAKE.*JB
Power train, Aug 13, 2002
THERE IS A DANGEROUS CLUTCH SHUDDER WHEN SHIFTING IN LOW GEARS. CAR CAN STALL IN BAD INTERSECTIONS. THIS IS DANGEROUS. THERE IS A LOT OF PUBLIC DISCUSSION ABOUT THIS PROBLEM HERE: HTTP://PUB1.EZBOARD.COM/FULTIMATESUBARUMESSAGEBOARDSTHENEWGENERATIONOFSUBARUS.SHOWMESSAGE?TOPICID=3533.TOPIC
Power train, May 9, 2002
VEHICLE SUDDENLY ACCELERATES WHILE DESCENDING STEEP HILL IN 1ST GEAR USING ENGINE AS BRAKE
Power train, May 8, 2002
THE CLUTCH-SHUDDER PROBLEM HAS BEEN GOING ON SINCE THIS WINTER. IT HAPPENS MOST OFTEN IN THE MORNING, COLD SEEMS TO BE A FACTOR MOST OF THE TIME, AND IT SHUDDERS WHEN YOU GO FROM STOP TO GO. FIRST GEAR IS ALMOST IMPOSSIBLE TO GET OUT OF SMOOTHLY WITHOUT THE SHUDDERING. THE DEALER CANT SEEM TO REPLICATE THE PROBLEM, BUT I HAVE READ THE OTHER SUBARU OWNERS COMPLAINTS OF THE SAME PROBLEM ON THE SUBARU MESSAGE BOARD, SO I KNOW ITS MORE OF A PROBLEM THAN JUST OUR CAR. *TS ***DIMSII IVOQ ENTRY POSTED AFTER 12-12-02 CUT OVER TO ARTEMIS***761667
Power train, Feb 11, 2002
OVERDRIVE LIGHT ILLUMINATED. DRIVER HAD VEHICLE TOWED TO MECHANIC. MECHANIC STATED THAT TRANSMISSION NEEDED TO BE REPLACED. *AK
Power train, Jan 28, 2002
SINCE NEW, THE CLUTCH IN THIS CAR HAS HAD A BAD SHUDDER WHEN COLD OUTSIDE -- BAD ENOUGH TO SHAKE THE ENTIRE CAR AS THE CLUTCH ENGAGES. IT ONLY HAPPENS WHEN IT'S COLD, BUT NOT ALL THE TIME WHEN IT'S COLD, MAKING IT NIGH IMPOSSIBLE FOR THE DEALER TO DO ANYTHING ABOUT IT. 20K MILES LATER, THE PROBLEM STILL EXISTS FOR ME AND APPARENTLY MANY, MANY OTHER OUTBACK DRIVERS. INTERNET POSTS CONFIRM THAT THIS IS A "COMMON" SUBARU PROBLEM, ALTHOUGH A FIX IS NOT READILY AVAILABLE. THE DEALER ACKNOWLEDGES THAT THERE ARE KNOWN PROBLEMS WITH SOME LEGACY/OUTBACK CLUTCHES, BUT UNTIL THE CLUTCH WILL RELIABLY FAIL WHILE THEY HAVE IT, THEY CANNOT DO ANYTHING ABOUT IT. MOST PEOPLE, LIKE ME, JUST DEAL WITH THE HORRIBLE SHAKING, BUT I CAN CERTAINLY SEE HOW THIS COULD LEAD TO A HAZARDOUS SITUATION WHEN SOMEONE TRIES TO PULL INTO TRAFFIC AND BECOMES STARTLED BY THE SHUDDERING CAR, BACKING OFF THE GAS AND POSSIBLY GETTING HIT.
Power train, Jan 26, 2002
THE CLUTCH OR FLYWHEEL APPEARS DEFECTIVE. THE CLUTCH SHUDDERS OR CHATTERS WHEN ENGAGED WHICH CAUSES THE CAR TO HESITATE UPON ACCELERATION. THIS PROBLEM STARTED AROUND 9,000 MILES AND HAS CONTINUED INTERMITTENTLY TILL NOW AT 18,000 MILES. SUBARU HAS AGREED TO REPLACE MY CLUTCH AND FLYWHEEL, BUT I AM CONCERNED REGARDING THIS PROBLEM. THIS PROBLEM IS WIDESPREAD AMONG OTHER SUBARU DRIVERS AND THE SERVICE TECHS REPORT THAT THIS PROBLEM IS COMMEN AND NORMAL FOR SUABRUS. I BELIEVE THIS IS A SAFETY ISSUE AND DEFECT IN THE DESIGN OR MANUFACTORING OF THE CLUTCH AND FLYWHEEL ASSEMBLY. PLEASE LOOK INTO THIS PROBLEM. I WOULD BE HAPPY TO SPEAK TO ANYONE REGARDING THIS ISSUE. WHEN YOU ENGAGE THE CLUTCH UPON ACCELERATION THE CAR JERKS AND TREMBLES, CHATTERS, SHUDDERS BEFORE ENGAGING. THIS SHOULD NOT BE ACCEPTED AS NORMAL OPERATION. THANK YOU.*AK