2001 Subaru Outback
Problems, recalls and owner-reported issues
Fuel system is the leading concern among 170 owner complaints filed for this model year. This is the 18th highest complaint count among 26 Outback model years with reports.
Of the 2001 reports, 16 involved a crash and 4 involved a fire. 7 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, delivery, fuel pumpNov 29, 2013
Airtex Products LP (Airtex) is recalling certain model E8598M, E8518M, E8600M, E8596M, and E8597M fuel pumps manufactured July 26, 2013, and July 29, 2013 and used as aftermarket replacements on Subaru Baja's, Outback's and Legacy's. The affected fuel pumps were sold or installed into the aftermarket applications on or after July 26, 2013, and may may leak fuel from the base of a fuel line connection when the gas tank is full.
A fuel leak in the presence of an ignition source increases the risk of a fire.
Airtex will notify owners, and will replace the fuel pump, free of charge. Recall is expected to begin on January 2, 2014. Customers may contact Airtex at 1-800-880-3056. The recall is expected to begin during January 2014. This recall is being conducted by Airtex, not by Subaru.
Campaign 13E065000 on NHTSA.gov
Vehicle speed control, cablesMar 16, 2004
ON CERTAIN PASSENGER SEDANS, WAGONS, AND SPORT UTILITY VEHICLES, THE CRUISE CONTROL CABLE COULD COME OUT OF ITS TRACK ON THE CRUISE CONTROL LEVER AND LODGE ON THE CONTROL LEVER TAB WHEN THE ACCELERATOR PEDAL IS RELEASED. IF THIS CONDITION OCCURS, THE THROTTLE WILL NOT RETURN TO THE IDLE POSITION AND WILL REMAIN IN AN OPEN POSITION.
IF THIS OCCURS DURING VEHICLE OPERATION, THE DRIVER COULD LOSE CONTROL OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
DEALERS WILL INSTALL A CRUISE CONTROL CABLE RETAINING CLIP TO THE CRUISE CONTROL LEVER TAB ON THE THROTTLE SHAFT IN ORDER TO PREVENT THE CRUISE CONTROL CABLE FROM COMING OUT OF ITS TRACK. OWNER NOTIFICATION BEGAN ON APRIL 12, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.
Campaign 04V128000 on NHTSA.gov
Suspension, rearApr 22, 2003
THIS RECALL APPLIES TO CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. CERTAIN REAR SUSPENSION SUBFRAME COMPONENTS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE ROAD SALTS FOR A PERIOD OF SEVERAL YEARS, COULD RESULT IN RUST-OUT OF THE COMPONENT AND POSSIBLE BREAKAGE OF THE SUBFRAME.
IF SUCH BREAKAGE OCCURS WHILE THE VEHICLE IS BEING OPERATED, CONTROL OF THE VEHICLE COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
DEALERS WILL CLEAN AND RUST-PROOF THE REAR SUSPENSION SUBFRAME. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
Campaign 03V153000 on NHTSA.gov
Power train, automatic transmissionOct 30, 2002
CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS WERE PRODUCED WITH AN IMPROPERLY MANUFACTURED TRANSMISSION PARKING ROD. WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE "P" (PARK) POSITION, THE TRANSMISSION PARK MECHANISM, THAT IS INTENDED TO HOLD YOUR VEHICLE, MAY NOT ENGAGE.
THE VEHICLE COULD THEN MOVE/ROLL WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION PARKING ROD ASSEMBLY. OWNER NOTIFICATION JANUARY 8, 2003. AN INTERIM OWNER NOTIFICATION WILL BE SENT DURING NOVEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
Campaign 02V282000 on NHTSA.gov
Representative owner complaints
170 reports, newest first.
Service brakes, Hydraulic, Apr 21, 2003
I HAD TO REPLACE THE BRAKES IN MY 2001 SUBARU OUTBACK AFTER 20,000 MILES. I LIVED THE LAST TWO YEARS IN ALASKA AND WAS TOLD BY THE DEALER SERVICE DEPARTMENT IN SEATTLE THE SALT FROM THE ROADS CREATED EARLY CORROSION ON THE BRAKE PADS AND DISC. THE OUTBACK IS DESIGNED FOR MORE RUGGED DRIVING AND FOR GEOGRAPHIC LOCATIONS WITH HARSHER WINTERS. SOMETHING ABOUT THE DESIGN OF THE BRAKES CAUSES THE SALT AND DIRT FROM WINTER ROADS TO CHANNEL UP THROUGH THE BRAKE SYSTEM AND CAUSE EXCESSIVE WEAR AND TEAR. I JUST PAID FOR A COMPLETE BRAKE REPLACEMENT AS THE FRONT PADS WERE NO LONGER ENGAGING CORRECTLY AND THE BRAKES ARE VERY WORN DUE TO THE SALT.*JB
Tires, Mar 14, 2003
THE RIGHT REAR TIRE BLEW OUT WITH NO WARNING. *JB THE CONSUMER EXCESSIVELY CHECKED FOR CRACKS WHICH WERE FOUND ON ALL FOUR TIRES. SCC
Power train, Vehicle speed control, Mar 11, 2003
CAR HAS SIGNIFICANT HESITATION DURING PERIODS OF ACCELERATION, USUALLY AROUND 2500-3500 RPM. POTENTIALLY DANGEROUS IN MANY DRIVING SITUATIONS. HAVE REPORTED TO DEALER MULTIPLE TIMES. RESPONSE IS ALWAYS "CANNOT REPRODUCE - COMPUTER SHOWS OPERATING AS DESIGNED". CAR ALSO HAS SPONTANEOUS ACCELERATION AT LOW SPEED, SUCH AS FIRST TAKING FOOT OFF BRAKE.*JB
Tires, Feb 27, 2003
THE FRONT PASSENGER TIRE BLEW OUT, WHICH CAUSED THE CONSUMER TO PULL OVER. *JB
Engine and engine cooling, Jan 28, 2003
WHILE IN MOTION AND DESCENDING A STEEP GRADE THE VEHICLE WILL INTERMITTENTLY ACCELERATE ON ITS OWN UP TO 4500 AND 5000 RPM'S. DEALER IS UNABLE TO DUPLICATE THE PROBLEM. *JG
Service brakes, Hydraulic, Jan 22, 2003
DURING COLD WEATHER (TODAY WAS 15 F), BRAKES DO NOT WORK ON FIRST APPLICATION FROM A COLD START. BRAKES HAVE BEEN SERVICE TWICE (PADS REPLACED, ROTORS TURNED) BUT DEALER CANNOT REPLICATE PROBLEM SINCE THE CAR HAS WARMED UP.
Electrical system, Jan 18, 2003
TWO CATASTROPHIC WIRING FAILURES IN MAIN COMPUTER WIRING LED TO VEHICLE SUDDENLY GOING DEAD. FIRST AT 3000 MILES TRACED TO SHORT IN MAIN RELAY WHICH WAS REPLACED. SECOND AT 16,000 MILES TRACED TO SHORT IN WIRE HARNESS UNDER THE PASSENGER FOOTWELL. POOR DESIGN PLACED THE ESSENTIAL COMPUTER WIRES UNDER THE PASSENGER FOOTWELL WHERE IT GETS CONSTANT PRESSURE WEAR. DEALER REPLACED WIRES INSIDE HARNESS AND ADDED CUSHIONING AROUND IT. THE SECOND FAILURE CREATES DOUBT THAT THE FIRST FAILURE WAS DUE TO A DEFECTIVE MAIN RELAY. BOTH FAILURE CAUSED THE VEHICLE TO BE DEAD. BOTH HAD NO WARNING EXCEPT THE FIRST TIME THE TEMPERATURE LIGHT CAME ON IMMEDIATELY BEFORE THE CAR WENT DEAD.
Seats, Jan 18, 2003
REAR HEADRESTS DO NOT LOCK INTO UPRIGHT AND DOWN POSITIONS BECAUSE THE METAL SLEEVE INSIDE SEAT SLIPS OVER TIME. HAPPENED EVEN AFTER BEING FIXED ONCE BY DEALER.
Tires, Jan 10, 2003
WHILE TRAVELING AT 65 MPH, CONSUMER STATES RIGHT REAR TIRE BLEW 2 1/2 INCHES FROM THE RIM, AND THERE WERE SPLITS GOING ALL THE WAY AROUND TIRE. PLEASE PROVIDE ANY FURTHER INFORMATION.*JB
Wheels, Dec 31, 2002
CONSUMER STATES WHILE DRIVING AND NO WARNING THE FRONT AND REAR WHEELS WOULD GET STUCK. DO TO DRIVING IN THE SNOW. CONSUMER STATES THE RIM SIZE ON THE VEHICLE IS 16". DEALER NOTIFIED. TS
Service brakes, Hydraulic, Dec 17, 2002
WHILE DRIVING THE VEHICLE AT ANY SPEED AND APPLIED THE BRAKES, THE VEHICLE CAN EXPERIENCE EXTENDED STOPPING DISTANCE, VEHICLE SUFFERED SUDDEN ACCELERATION. DEALER HAS INSPECTED THE VEHICLE AND COULD NOT DUPLICATE OR CORRECT THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. TS
Visibility, Nov 13, 2002
VEHICLE IS LEAKING FROM THE SUNROOF ASSEMBLY (HINGES). DEALER REPAIR AN CONSUMER STATES THE PROBLEM IS REOCURRING. PLEASE PROVIDE FURTHER INFORMATION. WE DON'T HAVE NO RECALL LIKE THIS PROBLEM. MR
Vehicle speed control, Aug 21, 2002
THE VEHICLE BEGAN ACCELERATING ON ITS OWN WHILE DESCENDING A 1.5 MILE GRADE. THE PROBLEM REOCCURRED SEVERAL TIMES, BUT THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. THE CONSUMER BELIEVES THE VEHICLE IS DEFECTIVE. *YH
Power train, Aug 13, 2002
THERE IS A DANGEROUS CLUTCH SHUDDER WHEN SHIFTING IN LOW GEARS. CAR CAN STALL IN BAD INTERSECTIONS. THIS IS DANGEROUS. THERE IS A LOT OF PUBLIC DISCUSSION ABOUT THIS PROBLEM HERE: HTTP://PUB1.EZBOARD.COM/FULTIMATESUBARUMESSAGEBOARDSTHENEWGENERATIONOFSUBARUS.SHOWMESSAGE?TOPICID=3533.TOPIC
Equipment, Jul 23, 2002
ORIGINAL JACK COLLAPSED WHILE JACKING UP FRONT END DRIVER SIDE. THE JACK WAS REPLACED AND AGAIN COLLAPSED WHILE JACKING UP THE DRIVER SIDE. IT APPEARS THE SHANK IS TOO LONG TO SUPPORT THE WEIGHT OF THE CAR.*AK
Service brakes, Hydraulic, Vehicle speed control, Jul 19, 2002
CAR ATTEMPTS TO ACCELERATE WHEN APPLYING BRAKES TO COME TO A STOP. ENGINE ROARS AND IT IS DIFFICULT TO STOP CAR. PROBLEM HAPPENS INTERMITTENTLY AND USUALLY WHEN THE CAR IS GOING 5 MILES PER HOUR OR LESS. BRAKE PEDAL GOES ALL THE WAY DOWN WHEN ATTEMPTING TO STOP CAR.*AK
Engine and engine cooling, Electrical system, Jul 16, 2002
THERE IS SEVERE HESITATION WHEN PRESSING ON GAS PEDAL. CONSUMER IS AFRAID OF BEING REAR ENDED. *AK CONSUMER STATED THAT VEHICLE HAD A BAD HESITATION ON ACCELERATION FROM A STOP. ALSO BATTERY WAS DEAD. *YH
Parking brake, Jun 11, 2002
PARKING BRAKE LOSES HOLD OVERNIGHT AND CAR ROLLS DOWN HILL IF NOT IN GEAR. (5 SPD). *AK
Service brakes, Hydraulic, Jun 6, 2002
I PURCHASED MY 2001 OUTBACK SEDAN IN SEPT OF 2000 AND HAVE HAD IT INTO THE DEALER FOR REPAIR 7 TIMES NOW FOR FRONT BRAKE ROTOR WARPAGE, THEY HAVE TURNED THE ROTORS TILL THEY COULDNT BE TURNED ANYMORE, THEN SUBARU OF AMERICA AUTHORIZED A NEW SET OF ROTORS AND THEY TOO HAVE WARPED AND CAUSE SEVERE SIDE TO SIDE SHAKING OF THE STEEERING WHEEL IN ALL BRAKING.AFTER SPEAKING WITH ALL SUBARU OF AMERICA REPS THEY HAVE SAID THEY WILL DO NO MORE TO THE CAR, AND AGREED THAT THEY ARE SEEING IT OTHER IDENTICAL OUTBACKS AND IT IS A PROBLEM BUT THEY REFUSE TO ACCEPT RESPONSIBILITY THAT THE ROTORS ARE NOT ADEQUET FOR THE STOPPING POWER OF THE CAR. THEY HAVE TOLD ME THAT I NEED TO NOT DRIVE IN THE CITY WITH IT, AND WHEN I DO TO RELEASE MY FOOT FROM THE PEDAL WHEN AT STOP LIGHTS, TRAFFIC ETC SO AS NOT TO HEAT THE ROTORS UP. NUMEROUSE OUTBACKS HAVE BEEN HAVING THE SAME PROBLEM AND THIS IS A MAJOR SAFTEY ISSUE SINCE THIS CAR WAS DESIGNED PARITICULARY FOR THE WINTER ELEMENTS, SNOW DRIVING ETC. WHEN YOU GO TO BRAKE IN ANY ELEMENT THE CAR SHAKES EXTREMLY BAD AND THEY HAVE BEEN IN THE CAR AND SEEN WHAT IT DOES, BUT CONTINUE TO BLAME THE PROBLEM ON THE DRIVERS.THE BRAKE ROTORS I AM TOLD ARE BEING MANUFACTURED SMALLER AND THINNER THEREFORE DO NOT DISAPATE HEAT AND THEN WARP. THIS PROBLEM BEGAN AT 4000 MILES AND IT HAS BEEN A MAJOR SAFTEY ISSUE AS I DO EXTREME MOUNTAIN PASS DRIVING IN ALL CONDITIONS. I AM ASKING FOR HELP NOT ONLY FOR MYSELF BUT FOR THE OTHER OWNERS OF SUBARUS WITH THE SAME DEFECT.THEY REFUSE TO HONOR THE WARRANTY WORK AND SAY THAT THE ROTORS ARE NOT DEFECTIVE, EVEN THOUGH THEY HAVE REPLACED THEM UNDER WARRANTY ONCE, AND HAVE TURNED THEM UNDER WARRANTY TIME AND TIME AGAIN AND NOW THEY WILL NOT DO ANYTHING. THERE ARE REPORTS OF OWNERS MODIFYING THE FRONT ENDS TO ALLOW MORE AIR TO COOL THE ROTORS. THIS I FIND UNACCEPTABLE. IS THERE ANY HELP OUT THERE IF SO PLEASE HELP US.*AK
Power train, May 9, 2002
VEHICLE SUDDENLY ACCELERATES WHILE DESCENDING STEEP HILL IN 1ST GEAR USING ENGINE AS BRAKE
Power train, May 8, 2002
THE CLUTCH-SHUDDER PROBLEM HAS BEEN GOING ON SINCE THIS WINTER. IT HAPPENS MOST OFTEN IN THE MORNING, COLD SEEMS TO BE A FACTOR MOST OF THE TIME, AND IT SHUDDERS WHEN YOU GO FROM STOP TO GO. FIRST GEAR IS ALMOST IMPOSSIBLE TO GET OUT OF SMOOTHLY WITHOUT THE SHUDDERING. THE DEALER CANT SEEM TO REPLICATE THE PROBLEM, BUT I HAVE READ THE OTHER SUBARU OWNERS COMPLAINTS OF THE SAME PROBLEM ON THE SUBARU MESSAGE BOARD, SO I KNOW ITS MORE OF A PROBLEM THAN JUST OUR CAR. *TS ***DIMSII IVOQ ENTRY POSTED AFTER 12-12-02 CUT OVER TO ARTEMIS***761667
Suspension, Mar 15, 2002
WHILE TURNING STEERING WHEEL AND WITHOUT WARNING VEHICLE VIBRATED VIOLENTLY. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. THEY STATED THAT THEY WERE AWARE OF MALFUNCTION ON STEERING COLUMN; HOWEVER, HAVE NOT FOUND OUT WHAT THE CAUSE WAS.*AK
Tires, Mar 6, 2002
WHEN THE ORIGINAL RECALLS OF THE WILDERNESS TIRES OCCURRED WE WERE TOLD BY SUBARU AND FIRESTONE THAT OUR SIZE TIRE WAS NOT EFFECTED. THESE TIRES WERE THE ORIGINAL EQUIPMENT ON THE CAR. LAST NIGHT WE WERE DRIVING HOME AT ABOUT 11:00 AND COMING DOWN THE EXIT RAMP FROM ROUTE 270 ONTO MIDDLEBROOK ROAD IN GERMANTOWN. MY HUSBAND HEARD A HISSING SOUND AND AT FIRST WE DISMISSED IT. ABOUT A HALF MILE LATER AT A LIGHT WE HEARD AN ADDITIONAL SOUND AND REALIZED THE REAR PASSENGER SIDE TIRE HAD GONE FLAT. MY HUSBAND PULLED OFF THE ROAD AND GOT OUT TO DISCOVER THE SIDEWALL HAD SEPARATED AND THE TIRE WAS EXTREMELY HOT. IT DID NOT SEPARATE TO THE POINT OF RIPPING THE TIRE ALL THE WAY THROUGH, BUT ENOUGH OF A GAP YOU COULD PUT YOUR FINGER IN. IT LOOKS LIKE THE SEPARATION GOES AT LEAST HALF WAY AROUND THE SIDE WALL (180 DEGREES) AND PROBABLY MORE. WE ROAD ON THE FLAT (AT A SNAIL'S PACE) THE MILE TO OUR HOME SINCE WE STILL HAD RUBBER BETWEEN THE RIM AND ROAD. THE SCAREY PART IS THAT IT WAS LATE, DARK AND IF WE'D GOTTEN STUCK ON ROUTE 270 IT WOULD NOT HAVE BEEN PLEASANT FOR MY HUSBAND TO CHANGE A TIRE UNDER THOSE CONDITIONS--IN FACT IT WOULD HAVE BEEN DOWNRIGHT DANGEROUS. ISN'T THIS THE SAME THING THAT HAPPENED TO ALL THOSE OTHER WILDERNESS TIRES--THAT THE SIDEWALL SEPARATED, RIPPED AND THE TIRE WRAPPED AROUND THE AXLE AND FLIPPED VEHICLES?! LUCKILY, BY THE GRACE OF GOD, OURS DIDN'T GO THAT FAR, BUT IT COULD HAVE. OUR OUTBACK IS A WONDERFUL CAR AND WE LOVE EVERY MINUTE OF DRIVING IT, BUT FOR A STATIONWAGON ITS CENTER OF GRAVITY IS A LITTLE HIGHER THAN AVERAGE. JUST LIKE THOSE SUVS WE COULD HAVE FLIPPED OUR BEAUTIFUL CAR IF THINGS DIDN'T TURN OUT THE WAY THEY DID. NEEDLESS TO SAY, MY HUSBAND IS PISSED OFF. HE CALLED THE FITZGERALD SUBARU IN GAITHERSBURG FOR ADVICE AND THEY SAID WE'LL HAVE TO DEAL WITH FIRESTONE. DO I NEED TO FEAR THE THREE OTHER TIRES ON MY CAR NOW? THANKS! JOYCE MCDONALD. *AK
Suspension, Feb 26, 2002
STEERING WHEEL VIBRATION AT HIGHWAY SPEED (50-70 MPH) (TIRESIZE: 225/60/R16)
Engine and engine cooling, Other or unspecified, Feb 11, 2002
ENGINE CHECK LIGHT ILLUMINATED AND STAYED ON. TOOK VEHICLE TO DEALER, AND STATED THAT OXYGEN SENSOR WAS BAD. *AK