2005 Subaru Outback

What owners report most often

1. Suspension56
2. Vehicle speed control40
3. Air bags38
4. Service brakes32
5. Exterior lighting30
6. Electrical system28
7. Power train17
8. Engine and engine cooling16

Recalls and investigations

1. Air bags, frontal, passenger side, inflator moduleJan 2, 2020

   Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

   An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

   Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKC-20.

   Campaign 20V003000 on NHTSA.gov

2. Air bags, frontal, passenger side, inflator moduleJan 2, 2020

   Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

   An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

   Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKB-20.

   Campaign 20V002000 on NHTSA.gov

3. Air bags, frontal, passenger side, inflator moduleJan 2, 2020

   Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (STI included), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

   An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

   Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators with alternate inflators, free of charge. The recall began January 7, 2020. Subaru Owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKA-20.

   Campaign 20V001000 on NHTSA.gov

4. Electrical system, ignition, switchApr 11, 2019

   Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester vehicles, 2008-2011 Impreza vehicles, 2008-2014 WRX vehicles, 2005-2014 Legacy vehicles, 2005-2014 Outback vehicles and 2006-2008 Tribeca vehicles equipped with a mechanical key ignition switch installed as a replacement part. The ball spring inside the switch may break, reducing the strength of the ignition switch. If this occurs, the weight on the key ring and certain road conditions could cause the ignition switch to move out of the run position to the accessory position, turning off the engine.

   The engine turning off unexpectedly can increase the risk of a crash. If a crash occurs under this condition, the air bag may not deploy, increasing the risk of injury.

   Subaru will notify owners, and dealers will inspect the ignition switch, replacing the ignition switch, if necessary, free of charge. The recall began May 10, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUF-91.

   Campaign 19V297000 on NHTSA.gov

5. Air bags, frontal, passenger side, inflator moduleMay 28, 2015

   Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Subaru Baja vehicles manufactured January 22, 2003, to July 21, 2004, 2004-2005 Impreza vehicles manufactured January 28, 2003, to May 31, 2005, 2003-2008 Subaru Legacy vehicles manufactured January 22, 2003, to May 2, 2008, 2003-2008 Subaru Outback vehicles manufactured February 18, 2003, to May 5, 2008, and 2005 Saab 9-2x vehicles manufactured February 11, 2004, to March 17, 2005. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture upon its deployment.

   In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

   Subaru will notify their owners and General Motors will notify Saab owners. Dealers will replace the passenger air bag inflator, free of charge. The Subaru recall began on June 17, 2015. Owners may contact Subaru customer service at 1-800-782-2783. The Saab recall began on July 27, 2015. Owners of Saab vehicles may call 1-800-955-9007. Subaru's number for this recall is WQR-53. Note: The recall completely supersedes recall 14V-399 (WQL-48) and partially supersedes recall 14V-763 (WQP-51) in that model year 2004 through 2005 Subaru Impreza and model year 2005 Saab 9-2x vehicles are now only part of this campaign. Note: On December 18, 2015 Subaru informed NHTSA of an expansion of this recall to include certain model year 2003-2004 Subaru Baja, 2003-2008 Subaru Legacy and 2003-2008 Subaru Outback vehicles.

   Campaign 15V323000 on NHTSA.gov

6. Air bagsDec 1, 2014

   Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Legacy and Outback vehicles, and 2003-2005 Baja vehicles sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan, American Samoa, Florida and adjacent counties in southern Georgia, as well as the coastal areas of Alabama, Louisiana, Mississippi and Texas. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

   In the event of a crash necessitating deployment of the passenger’s frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

   Subaru will notify their owners. Dealers will replace the passenger air bag inflator, free of charge. The recall began on January 15, 2015. Owners may contact Subaru at 1-800-782-2783. Subaru's number for this recall is WQP-51. Note: This recall supersedes recall 14V-471. This recall has been partially superseded by 15V-323. All 2005 model year Subaru Legacy and Outback vehicles will now be repaired under recall 15V-323.

   Campaign 14V763000 on NHTSA.gov

7. Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsJun 10, 2014

   Subaru of America, Inc. (Subaru) is recalling certain model year 2005-2009 Outback and Legacy, 2008-2011 Impreza and 2008-2014 Impreza WRX/STI, and 2009-2013 Forester vehicles, currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines. Note that affected vehicles not currently, or formerly registered, in the salt belt states identified above are eligible for repair, at no cost to the customer, upon request.

   Brake line corrosion may result in brake fluid leakage. Fluid leakage may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.

   Subaru will notify owners, and dealers will test the brake system by depressing the brake pedal and inspecting for brake fluid leaks. If no brake fluid seepage is observed, the affected areas will be rustproofed with anti-corrosion wax. If brake fluid seepage is observed, the brake lines will be replaced followed by rustproofing with anti-corrosion wax. These services will be performed free of charge. The recall began July 2014 and second notifications will run through November 2014. Owners may contact Subaru at 1-800-782-2783. Subaru's recall campaign number is WQK-47. Note: This recall supersedes recall 13V-110 which applied to certain 2005-2009 Legacy/Outback vehicles. Vehicles that were remedied under the previous campaign still need additional areas rust-proofed.

   Campaign 14V311000 on NHTSA.gov

8. Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 27, 2013

   Subaru is recalling certain model year 2005-2009 Outback and Legacy vehicles manufactured from December 2003, through April 2009 and currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines.

   Brake line corrosion may result in brake fluid leakage. Fluid leakage may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.

   Subaru will notify owners, and dealers will inspect the vehicles. If no brake fluid seepage is observed, the affected area will be rustproofed with anti-corrosion wax. If brake fluid seepage is observed, the brake lines will be replaced followed by rustproofing with anti-corrosion wax. These services will be performed free of charge. The recall began on May 30, 2013. Owners may contact Subaru at 1-800-782-2783. Subaru's recall campaign number is WQG-43.

   Campaign 13V110000 on NHTSA.gov

9. Air bags, side/windowJun 9, 2004

   THE LEFT AND RIGHT SIDE CURTAIN AIR BAGS IN CERTAIN VEHICLES INVOLVED IN THIS CAMPAIGN MAY NOT FULLY DEPLOY RAPIDLY ENOUGH WHEN ACTIVATED IN A SIDE IMPACT COLLISION. DURING A SIDE IMPACT TEST CONDUCTED BY THE INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS), THE TEST RESULTS INDICATED THAT THERE WAS A DIFFERENCE BETWEEN THE IIHS TEST RESULTS AND THE RESULT OF SIDE IMPACT TESTS CONDUCTED BY FHI.

   THIS MAY RESULT IN FAILURE TO PROVIDE THE INTENDED HEAD PROTECTION, INCREASING THE RISK OF INJURY TO A SEAT OCCUPANT.

   DEALERS WILL REPLACE THE LEFT AND RIGHT SIDE CURTAIN AIR BAG MODULES. THE RECALL BEGAN ON JUNE 11, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783. .

   Campaign 04V274000 on NHTSA.gov

Representative owner complaints

273 reports, newest first.

1. Steering, Suspension, Sep 18, 2012

   PURCHASED 2005 OUTBACK IN APRIL 2012 WITH APPROXIMATELY 190000 MILES. CAR FELT VERY UNSTABLE WHEN GOING OVER ANY UNEVEN ROAD SURFACE. REPLACED REAR STRUTS WITH NO IMPROVEMENT. TRIED DIFFERENT TIRES WITH NO NOTICEABLE CHANGE. DECIDED IT MUST BE AN ODD BUT NORMAL CONDITION FOR THE VEHICLE. TODAY, 9/18/12, DROVE CAR IN LIGHT RAIN ALONG A 2-LANE ROAD AT APPROXIMATELY 50-55 MPH AND CAR WAS VERY UNSTABLE IN THE REAR. THE REAR "STEERED" LEFT/RIGHT AND FELT VERY UNSTABLE. THERE WAS A SENSE THE VEHICLE WAS GOING TO ABRUPTLY CROSS INTO THE OTHER LANE. I HAVE OVER 40 YEARS OF DRIVING EXPERIENCE AND REALIZE THIS IS NOT NORMAL VEHICLE PERFORMANCE. I LIVE IN A CENTRAL NY AND PURCHASED THIS VEHICLE FOR THE SAFETY OF ALL WHEEL DRIVE AFTER OWNING A 1995 SUBARU IMPREZA AND A 1997 SUBARU OUTBACK. GIVEN THE SITUATION I HAD TODAY, I AM AFRAID OF WHAT WILL HAPPEN IN ICE/SNOW CONDITIONS COMMON IN NY. I BEGAN TO RESEARCH THE ISSUE ONLINE IN AN ATTEMPT TO CORRECT MY SITUATION BEFORE WINTER ARRIVES. I FOUND MANY ONLINE CONCERNS REGARDING THIS ISSUE. WHILE I HAVE NOT YET APPROACHED SUBARU DIRECTLY, I GET AN OVERWHELMING SENSE FROM ONLINE COMMENTS THAT SUBARU WILL NOT BE VERY HELPFUL. I AM MAKING THIS SAFETY COMPLAINT IN HOPES THAT MULTIPLE COMPLAINTS COMBINED WILL EXPOSE WHAT I FEEL IS A VERY SERIOUS/DANGEROUS HANDLING ISSUE WITH A 2005 SUBARU OUTBACK. *TR

2. Power train, Equipment, Aug 25, 2012, crash

   2005 SUBARU IS OUR FAMILY HAS HAD TO HAVE THE FRONT AXLES AS ONE BROKE GOING DOWN THE HIGHWAY HE AS NOT HURT, BUT THE CAR WAS ONLY STOPPED AFTER I PLOWED UP SN OPEN FIELD. SINCE VEHICLE WAS NOT UNDER WARRANTY WE FOOTED A $1,200 BIL. THEN WEEKS LATER THE AXLE ON MY 2004 BROKE AS I WAS DRIVING OUT OF MY DRIVEWAY. THAT REPAIR ALSO NOT UNDER WARRANTY COST ANOTHER 1,200 DOLLARS. WE HAVE HAD TO HAVE THE WHEEL BEARINGS REPLACED ALL THE WAY AROUND ON BOTH VEHICLES AND THE ECM REPLACED ON BOTH CARS THIS YEAR. THESE VEHICLES HAVE ALSO EXPERIENCED CONVERTER PROBLEMS AND CONVERTERS WERE REPLACED BY SUBARU ONLY AFTER I KEPT UP A RUNNING BATTLE AND INSISTED THAT THEY WERE UNDER WARRANTY. *TR

3. Suspension, Jan 22, 2012

   I HAVE EXPERIENCED WHAT IS REFERRED TO AS "GHOSTWALKING" IN MY 2005 SUBARU OUTBACK. WHILE DRIVING IN WINTER CONDITIONS SUCH AS SLUSH, SNOW AND ICE MIX, AND BLACK ICE THE CAR FISHTAILS IN THE REAR WHEELS MAKING IT IMPOSSIBLE TO SAFELY DRIVE THIS CAR. HOWEVER DRIVING ON HARDPACK SNOW AND HARDPACK POWDER THE CAR HANDLES FINE. THE CAR FISHTAILS MUCH WORSE WHEN EVEN A LITTLE WEIGHT IS LOADED IN THE REAR. I DO HAVE DEDICATED SNOW TIRES, WITH STUDS. I AM A VERY EXPERIENCED DRIVER IN WINTER CONDITIONS, I DO NOT DRIVE TOO FAST IN POOR ROAD CONDITIONS. THIS IS A SERIOUS PROBLEM THAT APPARENTLY MANY PEOPLE HAVE EXPERIENCED. I HAVE MULTIPLE FRIENDS WHO DRIVE OLDER SUBARU'S WHO HAVE NEVER EXPERIENCED SUCH AN ENCOUNTER WITH THEIR CARS. BOTTOM LINE THIS CAR IS NOT SAFE TO DRIVE ON WINTER ROADS, I HAVE LITERALLY FEARED FOR MY LIFE ON SEVERAL OCCASIONS. PLEASE DO SOMETHING ABOUT THIS. *TR

4. Steering, Suspension, Jan 16, 2012

   I RESIDE IN THE SIERRA NEVADA MOUNTAINS IN CALIFORNIA AND EXPERIENCE SNOWY/ICY DRIVING CONDITIONS REGULARLY THROUGHOUT THE WINTER. THE OUTBACK WAS PURCHASED FOR ITS PERFORMANCE IN THESE CONDITIONS AND IS EQUIPPED WITH BLIZZAK STUDLESS SNOW TIRES. ON SEVERAL OCCASIONS, IN BOTH CA AND CO, WHILE DRIVING ON PACKED SNOW AT APPROXIMATELY 40 MPH, THE REAR END BEGAN TO FISHTALE OUT OF CONTROL. THIS SITUATION CONTINUED TO WORSEN UNTIL THE SPEED WAS REDUCED TO BELOW 30 MPH. I HAVE SPOKEN TO THE DEALER AND OF COURSE, "THEY HAVE NEVER HEARD OF SUCH AN EVENT" AND DID NOT HAVE ANY IDEA AS TO WHAT MAY HAVE CAUSED THIS CONDITION NOR HOW TO CORRECT. THERE ARE TOO MANY REPORTS OF THIS IDENTICAL OUT OF CONTROL CONDITION FOR IT TO BE COINCIDENTAL, SUBARU NEEDS TO ADDRESS THIS ISSUE BEFORE SOMEONE IS SERIOUSLY INJURED OR KILLED. *TR

5. Suspension, Jan 12, 2012

   I HAVE OWNED AND DRIVEN THIS SUBARU SINCE JULY 06 AND HAVE DRIVEN IT THROUGH 5 NORTHERN ILLINOIS WINTERS. TODAY WAS OUR FIRST SNOWFALL THIS SEASON AND FOR THE FIRST TIME I HAVE NOTICED THAT THE CAR EXHIBITS VERY "UN-NERVING" HANDLING QUALITIES IN VERY LIGHT SNOW ROAD CONDITIONS. SOMETHING HAS CHANGED TO MAKE ME FEEL LIKE I WILL LOOSE CONTROL OF THE VEHICLE. THE CAR FEELS LIKE IT WANTS TO FISHTAIL OUT OF CONTROL AT ANY SPEED OVER 30 MPH. STRANGE "WANDERING" BEST DESCRIBES IT.IT FEELS LIKE I'M DRIVING IN DEEP RUTS OF HEAVY ROAD SNOW THAT WANTS TO PULL THE CAR INTO THE RUTS BUT THE ROAD IS BARELY COVERED. ON TWO LANE ROADS IT FEELS LIKE THE CAR COULD EASILY CROSS THE CENTER LINE BECAUSE OF THIS ODD STEERING FEEDBACK I FEEL ON SLICK SNOW COVERED ROAD CONDITIONS. I DON'T FEEL IT IN RAIN CONDITIONS. IT HAS "NEVER" FELT LIKE THIS BEFORE. THE REAR STRUTS WERE REPLACE LAST SUMMER WITH OEM STRUTS. THE CAR HAS NEVER HAD AN ALIGNMENT BUT HAS ALWAYS TRACKED DOWN THE ROAD VERY STRAIGHT. TIRE WEAR IS EVEN AND TIRES HAVE BEEN ROTATED MULTIPLE TIMES. TIRES ARE BRIDGESTONE TURANZA SERENITY WITH 66K AND BEEN THROUGH 3 WINTERS BEFORE WITH NO HANDLING ISSUE. ONCE I NOTICED ON THIS SITE THAT MANY OUTBACK OWNERS ARE EXPERIENCING THE SAME SYMPTOM, I KNEW I NEEDED TO GET THIS POSTED IN CASE OF AN ACCIDENT. I'M NOW AT LEAST ON RECORD WITH MY "HANDLING CONCERN COMPLAINT" AND SUBARU OF AMERICA CAN'T SAY MY CONCERN WAS NEVER ADDRESSED WITH THE NHTSA. A CAR SHOULD NEVER DISPLAY THE KIND OF HANDLING ISSUES THAT MAKES IT FEEL UNSAFE TO DRIVE IN LIGHT WINTER CONDITIONS. P.S. I TOOK MY SON'S HONDA CRV WITH 198 K FOR A TEST DRIVE IN THE SAME CONDITIONS TODAY,ON THE SAME ROADS AND FOUND ITS HANDLING VERY PREDICTABLE. WHAT IS GOING ON WITH THESE OUTBACKS ? *TR

6. Steering, Suspension, Jan 7, 2012

   I AM A VERY EXPERIENCED DRIVER IN SNOWY AND ICY CONDITIONS. MY OUTBACK 2005 2.5I STARTED WIGGLING OUT OF CONTROL (ESPECIALLY FELT THE BACK END WIGGLE LEFT TO RIGHT) ON A STRAIGHT ROAD WITH APPROX 1/2 INCH ICE AND PACKED SNOW CAUSING ME TO SLOW DOWN FROM APPROXIMATELY 40 MPH TO 20 MPH . OTHER 2 WD VEHICLES PASSED US AT MUCH HIGHER SPEEDS WITH NO APPARENT PROBLEM TO KEEP STRAIGHT. OUR CAR HAD 2 ADULTS AND 2 SMALL CHILDREN IN IT WITH SKIING GEAR. CHANGED OUR WINTER TIRES IMMEDIATELY AFTER. THE PROBLEM OCCURRED AGAIN ON A FEW OTHER SIMILAR OCCASIONS, FOR WHICH I WENT TO THE DEALER TO GET ALIGNED, TIRE CHANGED AGAIN. WENT TO DEALER IN 2010 AFTER THIS OCCURRED AGAIN ON THE HIGHWAY WITH ONLY SLUSH AND WATER. I HAD TO SLOW FROM 55 MPH TO 30 MPH TO KEEP CAR IN CONTROL. REMEMBER THIS IS ON THE HIGHWAY!! WENT TO DEALER AGAIN TO RE-ALIGN THE CAR WHICH ACCORDING TO THEM WAS NOT ALIGNED. THE PROBLEM RE-OCCURRED AGAIN THIS WINTER. I AM NOW FED UP, THIS IS A DANGEROUS CAR AND I AM TURNING IT IN TO BUY A NEW CAR. I CAN'T UNDERSTAND WHY SUBARU IS NOT RECALLING TO FIX THE REAR SUSPENSION. *TR

7. Suspension, Jan 6, 2012

   FAILURE OF 2 REAR WHEEL BEARINGS AND RIGHT FRONT WHEEL BEARING. *TR

8. Vehicle speed control, Dec 29, 2011

   TL* THE CONTACT OWNS A 2005 SUBARU OUTBACK. THE CONTACT STATED THAT THE ACCELERATOR PEDAL WOULD INTERMITTENTLY BECOME UNRESPONSIVE. THE DEALER REPAIRED THE DEFECT, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 65,696 AND THE CURRENT MILEAGE WAS 75,000.

9. Power train, Vehicle speed control, Dec 29, 2011

   INTERMITTENT THROTTLE DISABLED. CAR BECOMES UNRESPONSIVE TO THE GAS PEDAL. ENGINE CONTINUES TO RUN BUT GAS PEDAL HAS NO RESPONSE. *KB

10. Engine and engine cooling, Electrical system, Vehicle speed control, Nov 14, 2011

    I HAVE BEEN HAVING A PROBLEM WITH MY CAR FOR THE 2-YEARS AND HAS BEEN GETTING WORSE. THE THROTTLE PEDAL AT TIMES WILL BECOME NON-RESPONSIVE AND THE ENGINE IDLE CANNOT BE CONTROLLED. AT THIS TIME THE CHECK ENGINE LIGHT IS ON WITH A CODE. P2138. I HAVE TAKEN THE CAR TO THE DEALER WITH NO LUCK THEY COULD NOT FIND ANYTHING WRONG. THE CAR HAS LEFT ME STRANDED SEVERAL TIMES AND I HAD TO LIMP OR BE TOWED HOME. THE RPM CAN BE ANYWHERE FROM IDLE TO 3000 RPM AND AS I SAID THE PEDAL HAS NO CONTROL. I HAVE REPLACED THE ACCELERATOR PEDAL ASSEMBLY AND THE PROBLEM WAS GONE FOR THE PAST SIX MONTHS. IT HAS NOW FAILED AGAIN. *TR

11. Fuel system, Gasoline, Electrical system, Nov 14, 2011

    SITTING AT STOP LIGHT - LIGHT CHANGES GREEN - NO ACCELERATION. CAR WILL MOVE AT IDLE SPEED CREEP THROUGH INTERSECTION. PULL OVER STOP TURN CAR OFF. RESTART W ACCELERATOR WORKING BUT CRUISE CONTROL INDICATOR FLASHING AND CHECK ENGINE LIGHT ON. ERROR CODE INDICATES PEDAL POSITION SENSOR AND DEALER SAYS ENTIRE PEDAL ASSEMBLY NEEDS REPLACED. NEW 'DRIVE-BY-WIRE' ACCELERATOR SYSTEM FOR SUBARU IN 2005. REPAIR: ~$200 WITH NO CHANGE IN ASSEMBLY FROM WHAT THE SERVICE DEPT. REPORTS. *TR

12. Suspension, Other or unspecified, Nov 8, 2011

    CAR IS NOT SAFE ON PACKED SNOW OR ICY ROADS. ALL ROAD FEEL IS GONE AND IT FEELS AS IF THE CAR COULD SPIN OUT OF CONTROL AT ANY MOMENT. MOST OTHER CARS SEEM TO PASS WITHOUT ISSUE. FOR A AWD CAR THIS IS UNACCEPTABLE. YOU MUST SLOW DOWN TO 40 AND BELOW TO HAVE ANY HOPES OF KEEPING THE CAR IN A STRAIGHT LINE. I HAVE PUT NOKIA SNOW TIRES ON THE AND CAR DRIVES PERFECT IN FRESH SNOW BUT STILL CANNOT DRIVE IN SLIPPERY CONDITIONS. I HAVE NOT NOTICED THIS ON WET PAVEMENT. SUBARU FEELS LIKE AN ALIGNMENT WILL CORRECT THE PROBLEM. GOING IN FOR ONE IN A WEEK. IF IT DOES NOT FIX THE ISSUE I WILL SELL THE CAR. I FOUND MANY OWNERS WITH THE SAME ISSUE ON SUBARUOUTBACK.ORG. *TR

13. Engine and engine cooling, Electrical system, Oct 30, 2011

    SECOND TIME THIS HAS HAPPENED. WHEN IN A STOPPED POSITION AND INTEND TO PULL OUT, MOTOR RUNNING, BUT GAS PEDAL DOES NOT ENGAGE. PUSH ALL THE WAY TO FLOOR - STILL NOTHING. IN ORDER TO CORRECT, MUST TURN OFF ENGINE AND DISCONNECT BATTERY CABLE SO VEHICLE CAN RESET ITSELF. ALSO HAD PROBLEM WHEN SITTING STILL WHERE VEHICLE BEGAN IDLING AS IF ACCELERATOR BEING PRESSED DOWN - LASTED 5-10 SECONDS THEN BACKED OFF. WHEN PURCHASED CAR USED, HAD PROBLEMS WITH CRUISE CONTROL NOT WORKING AND LIGHT FLASHING CONTINUOUSLY. FOUND THAT INJECTOR HAD TO BE REPLACED - APPARENTLY TIED TO CRUISE MECHANISM. THIS CORRECTED THE PROBLEM BUT QUITE EXPENSIVE TO REPAIR. *TR

14. Fuel system, Gasoline, Oct 25, 2011

    TL* THE CONTACT OWNS A 2005 SUBARU OUTBACK. THE CONTACT STATED THAT WHEN DRIVING THE VEHICLE HE NOTICED AN OVERPOWERING SMELL OF GAS. ONCE HE INSPECTED THE VEHICLE, HE NOTICED THAT THERE WAS A LEAK NEAR THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THE FUEL TANK WAS FRACTURED DUE TO CORROSION. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 126,000.

15. Fuel system, Gasoline, Oct 22, 2011

    FUEL IS LEAKING FROM THE WELDED SEAM ON THE PASSENGER SIDE OF THE FUEL TANK WHEN THE TANK IS FULL. I PARKED THE CAR IN THE GARAGE AFTER FILLING THE TANK, WENT INTO THE HOUSE, AND THE NEXT MORNING FOUND A SMALL PUDDLE OF GAS JUST FORWARD AND INBOARD OF THE RIGHT REAR TIRE, AND A VERY STRONG SMELL OF GASOLINE . I COULD SEE A DRIP APPROXIMATELY EVERY 10 SECONDS. MY NEIGHBORHOOD MECHANIC EXAMINED THE CAR AND DIAGNOSED THE LEAK AT THE WELDED SEAM, NOT AT THE FUEL FILLER TUBE CONNECTION AT THE TANK, AND RECOMMENDED IT BE FIXED AT THE DEALER. IT IS AT MINOOKA SUBARU IN MINOOKA, PA. RIGHT NOW. *TR

16. Suspension, Jul 13, 2011

    DRIVING ON ICY/SNOWY ROADS, THE BACK END SWAYS/"GHOST WALKS" EXTREMELY DANGEROUSLY PROBABLY 2-3" EACH WAY REGARDLESS OF BRAKING/TURNING/STRAIGHTAWAY/ACCELERATING. WE WERE DRIVING ALONG WITH A 2WD VEHICLE FROM WI TO MT WHICH HANDLED SIGNIFICANTLY BETTER THAN THE OUTBACK (WHICH IS SUPPOSED TO BE THE TOP OF THE LINE WINTER CAR). HAD BRAND NEW (300 MILES) QUALITY ALL WEATHER TIRES AND AN ALIGNMENT. THE CAR ACTUALLY APPEARS TO BE DOING THIS NOW IN DRY CONDITIONS AS WELL WHEN I ENCOUNTER BUMPS AT HIGHWAY SPEEDS. THE FEELING OF SAFETY IS SEVERELY LACKING. *TR

17. Engine and engine cooling, Jun 19, 2011

    2005 OUTBACK X LIMITED WITH 67,000 MILES. CHECK ENGINE LIGHT COMES ON FOLLOWED BY A WHINING SOUND FROM ENGINE COMPARTMENT AND THEN RATTLING NOISES ACCOMPANIED BY LOSS OF POWER. CAR WAS TRANSPORTED TO GARAGE AND DIAGNOSED WITH BLOWN TURBO. METAL SHAVINGS DISCOVERED IN OIL FILTER. TOTAL ENGINE LOSS. SUBARU DENIES COVERAGE AND WILL NOT ACCEPT RESPONSIBILITY FOR DESIGN FLAW. *TR

18. Steering, May 24, 2011

    2005 SUBARU OUTBACK WAGON EXTREMELY UNSTABLE ON SLIPPERY ROADS. UNSAFE TO DRIVE AT ANY SPEED UNDER CERTAIN CONDITIONS. HAS BEEN TERMED 'GHOST WALKING'. THIS PROBLEM CAN BE FIXED / HELPED WITH WHEEL ALIGNMENT, BUT SHOULD NOT BE SUCH A DANGEROUS VEHICLE BECAUSE OF AN ALIGNMENT PROBLEM. SOME OTHER FACTORS HAVE TO BE CONTRIBUTING TO THE HORRIFIC HANDLING OF THIS VEHICLE ON SLIPPERY ROADS. IT IS NOT A MATTER OF JUST SLOWING DOWN. *TR

19. Engine and engine cooling, May 20, 2011

    TL*THE CONTACT OWNS A 2005 SUBARU OUTBACK. THE CONTACT STATED WHILE DRIVING ON AN INCLINE THE VEHICLE RESPONDED SLOWLY. THE CRUISE CONTROL AND CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALERSHIP DIAGNOSIS DETERMINED THAT THE TURBO CHARGER FILTER WAS CLOGGED AND THE SHAFT IN THE TURBO CHARGER WAS BROKEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS 67,446.

20. Engine and engine cooling, May 17, 2011

    SUBARU OUTBACK 2005 PZEV - HEAD GASKET FAILURE. THE CYLINDER HEAD GASKETS ON THIS VEHICLE HAVE FAILED SUCH THAT ENGINE OIL DRIPS ONTO THE HOT EXHAUST SYSTEM, AND PRODUCES VISIBLE, FOUL SMELLING SMOKE WHENEVER THE CAR IS DRIVEN. MANUFACTURER HAS REFUSED TO REPAIR UNDER WARRANTY, OR RECOGNIZE A PROBLEM, IN SPITE OF SIMILAR FAILURES IN EARLIER MODELS, AND PREVIOUS CLASS ACTION LAWSUIT SETTLEMENT BECAUSE OF THOSE FAILURES. THE CAR IS STILL UNDER AN EMISSIONS WARRANTY THAT WILL EXPIRE AT 157,500 MILES. THE CAR WAS SOLD AS A PARTIAL ZERO-EMISSIONS VEHICLE, BUT CLEARLY THE SMOKE FROM THE DRIPPING OIL EXCEEDS ANY EMISSION STANDARD. MY FEELING IS THAT THE MANUFACTURER SHOULD REPAIR THE CAR UNDER THE EMISSIONS WARRANTY, AS WELL AS PRIOR FAILURE HISTORY. *TR

21. Engine and engine cooling, May 9, 2011

    AT APPROXIMATELY 85,000 MILES, THE CHECK ENGINE LIGHT ON OUR 2005 SUBARU OUTBACK XT WENT ON AND WE TOOK THE VEHICLE IN TO OUR LOCAL REPAIR SHOP TO CHECK THE LIGHT AND THEY RECOMMENDED HAVING THE VEHICLE TOWED TO OUR SUBARU DEALER. THE VEHICLE WAS TOWED IN AND THE DEALER SERVICE PERSON CALLED STATING THAT TIMTHE TURBO HAD FAILED (ALONG WITH THE CV BOOT & ALTERNATOR BELT). I PROVIDED THE INFORMATION REGARDING OUR OFFICIAL SUBARU 100,000 MILE GOLD PLUS "EXTENDED SERVICE CONTRACT" WHICH WE PURCHASED FOR $1975. THE SERVICE REPRESENTATIVE WOULD NOT CONFIRM WHETHER OR NOT THESE COMPONENTS WOULD BE COVERED UNDER OUR SERVICE CONTRACT AND THEN CALLED ME AND SAID SUBARU DENIED THE CLAIM PENDING RECEIPT OF SERVICE RECORDS. MY HUSBAND AND MY FATHER HAVE CHANGED THE OIL, AIR FILTERS AND PERFORMED GENERAL SERVICE IN COMBINATION WITH SERVICE BY VARIOUS SERVICE SHOPS. MY RECORDS ARE NOT COMPLETE AND I EXPECT THAT SUBARU WILL TRY TO DENY COVERAGE OF THE TURBO DUE TO THIS. THERE ARE AMPLE REPORTS ON SUBARU FORUMS REPORTING THE SAME FAILURE AND I FEEL THAT THIS PROBLEM IS NOT DUE TO OWNER NEGLIGENCE, BUT BY FAULTY DESIGN. THIS TYPE OF FAILURE SHOULD BE THE RESPONSIBILITY OF THE MANUFACTURER AND THEY SHOULD SERVICE THE VEHICLE PER THE SERVICE CONTRACT WITHOUT CAUSING UNDUE STRESS TO THE OWNER OF THE VEHICLE. *TR

22. Service brakes, Hydraulic, May 2, 2011

    BRAKES ARE VERY WEAK FOR THE FIRST COUPLE OF STOPS AFTER THE CAR HAS BEEN SITTING FOR A WHILE (ABOUT EIGHT HOURS OR MORE). BRAKES WORK FINE AFTER WARMING UP. THIS IS VERY DANGEROUS WHEN FIRST BACKING OUT OF DRIVING; WOULD NOT BE ABLE TO STOP FAST ENOUGH IF A CHILD OR PERSON WAS SUDDENLY IN THE WAY AND YOU NEEDED TO STOP. THIS IS THE CASE WITH OEM BRAKE PADS AND AFTER-MARKET PADS. *TR

23. Engine and engine cooling, Apr 25, 2011

    TL* THE CONTACT OWNS A 2005 SUBARU OUTBACK. THE CONTACT STATED THAT THE ENGINE FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY WERE TOLD THAT THE BANJO FILTERS SCREEN FAILED AND SENT SHARDS OF METAL THROUGH THE ENGINE. THE DEALER TOLD THE CONTACT THAT IN 2007, THE VEHICLE WAS SERVICED BECAUSE OF THE FAILURE AND THE ENGINE WAS PREVIOUSLY REBUILT. THE CONTACT STATED THAT THE INFORMATION WAS NOT LISTED ON THE VEHICLE HISTORY REPORT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS 62,000.

24. Suspension, Feb 18, 2011

    2005 SUBARU OUTBACK EXHIBITS A SERIOUS OF STABILITY WHEN DRIVING AT A STEADY SPEED ON THE HIGHWAY WHEN THERE IS THE SLIGHTEST DEGRADATION OF TRACTION. THE REAR OF THE VEHICLE WILL BEGIN TO SWAY FROM SIDE TO SIDE ON FLAT AND STRAIGHT ROAD SURFACES IF THE ROADS ARE WET FROM RAIN OR EVEN WITH A LIGHT DUSTING OF SNOW. ON DECEMBER 3 2010 I WAS DRIVING NORTH ON I-75 NORTH OF FLINT MICHIGAN, THERE WAS OCCASIONAL LIGHT SNOW FLURRIES THAT WERE BARELY COATING THE ROAD SURFACE. I WAS DRIVING AT THE POSTED SPEED LIMIT (70 MPH) WHEN THE SNOW STARTED TO LIGHTLY COAT THE ROAD THE VEHICLES REAR END STARTED TO SWAY FROM SIDE TO SIDE IN A VIOLENT MANNER. I HAD TO SLOW DOWN TO 50 MPH TO REGAIN CONTROL OF THE VEHICLE, ALL THE WHILE I WAS BEING PASSED BY 2WD PICK UPS AND 2WD DRIVE VEHICLES. THE VEHICLE HAS EXHIBITED THE SAME BEHAVIORS ON WET ROAD SURFACES DURING AND FOLLOWING RAIN. IT'S TIME FOR SUBARU TO CORRECT THIS PROBLEM. I'M NOT FEELING THE LOVE. *LN

25. Air bags, Feb 4, 2011

    TL*THE CONTACT OWNS A 2005 SUBARU OUTBACK. WHILE THE VEHICLE WAS PARKED THE CONTACT NOTICED THAT THE AIR BAG LIGHT ILLUMINATED ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIANS STATED THAT THE AIR BAG SENSOR AND MODULE NEEDED TO BE REPLACED. THE TECHNICIANS INFORMED THE CONTACT OF NHTSA RECALL CAMPAIGN ID NUMBER 04V274000 (COMPONENT: AIR BAGS:SIDE/WINDOW) FOR THE AIR BAGS. THE MANUFACTURER WAS CONTACTED AND STATED THAT THERE WAS NO RECALL. THE FAILURE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.