2016 Subaru Outback
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 642 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Outback model years with reports.
Of the 2016 reports, 22 involved a crash and 3 involved a fire. 13 people were injured.
What owners report most often
Recalls and investigations
Air bags, air bag/restraint control moduleDec 19, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2016-2017 Outback vehicles. A replacement air bag control module may have been installed that is not compatible with the passenger air bag module, possibly affecting air bag deployment.
In the event of a crash necessitating passenger frontal air bag deployment, the air bag may not deploy properly, increasing the risk of injury.
Subaru will notify owners, and dealers will replace the passenger air bag module, free of charge. The recall began February 3, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUX-09.
Campaign 19V910000 on NHTSA.gov
Steering, columnDo not drive until repairedMay 11, 2016
Subaru of America, Inc. (Subaru) is recalling certain model year 2016-2017 Legacy and Outback vehicles manufactured February 29, 2016, to May 6, 2016. The steering column on the affected vehicles may have been improperly machined, and as a result, turning the steering wheel may have no effect on the direction of the wheels.
The loss of steering ability would increase the risk of a crash.
Subaru will notify owners, and dealers will inspect the lot number on the steering column, replacing the steering column, as necessary, free of charge. The recall began May 13, 2016. Owners may contact Subaru customer service at 1-800-782-2783 or by visiting http://www.wtd65.service-campaign.com. Subaru's number for this recall is WTD-65. Note: Until the vehicles have been inspected, owners are advised not to drive their vehicles.
Campaign 16V292000 on NHTSA.gov
Power train, driveline, driveshaftNov 24, 2015
Subaru of America, Inc. (Subaru) is recalling certain model year 2016 Legacy vehicles manufactured October 24, 2015, to November 16, 2015, and Outback vehicles manufactured October 24, 2015, to November 17, 2015. Due to the improper tightening of the securing nuts, the drive shaft may separate from the rear differential.
If the drive shaft detaches from the rear differential, it may strike the fuel tank and result in a fuel leak, increasing the risk of a fire.
Subaru has notified owners, and dealers will inspect the fastening nuts, and tighten or replace them, as necessary, free of charge. The recall began on December 10, 2015. Owners may contact Subaru customer service at 1-856-488-8500. Subaru's number for this recall is WQV-57.
Campaign 15V794000 on NHTSA.gov
Power train, driveline, driveshaftAug 10, 2015
Subaru of America, Inc. (Subaru) is recalling certain 2015 and 2016 model year Subaru Legacy 4-Door and Outback vehicles manufactured July 3, 2015, to July 27, 2015. Transmission oil may leak from a deformed seal cap on the propeller shaft yoke.
If the transmission oil leaks onto the exhaust pipe, there is a possible risk of fire.
Subaru will notify owners, and dealers will replace the propeller shaft, free of charge. The recall began on August 28, 2015. Owners may contact 1-800-782-2783. Subaru's number for this recall is WQU-56.
Campaign 15V502000 on NHTSA.gov
Representative owner complaints: engine
54 reports, newest first. Show all
Engine, May 27, 2022
The cam tower sealant failed, allowing a leak at less than 70,000 miles driven.
Electrical system, Other or unspecified, Engine, May 1, 2022
I bought this used 2016 Subaru Outback about a year and a half ago from McCords Vancouver Dealership. I've had the battery dying problem ever since I got it. I have had to call AAA for jump starts. I took the car into my mechanic because the "change warning light" had been on when I turned off the ignition the night before, and it was still blinking the next morning when I came out to start the car. He suggested that I go to Costco to get the battery replaced because it was down to only 22% efficient. They declined for several reasons. It wasn't the battery fault, it was the car! I am 92 years old and disabled. I can't get stuck on a freeway with a dead battery. I am still looking for someone to fix it. I bought this car because I assumed that a newer car would be more dependable. Boy was I wrong! I have already spent a lot of money trying to fix it. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Engine, Feb 24, 2022
NUMBER: WUJ-95 - Exhaust Pipe Front (EPF) Bellows Cracking recall that affects cars produced as below Model Year Carline Affected Production Dates 2015-2016 Legacy 12/16/2013 - 9/30/2015 2015-2016 Outback 12/09/2013 – 9/30/2015 Affects cars outside this date. My 2016 Subaru Outback was built in March of 2016 and the exact same part broken at the exhaust bellows, requiring a $2600 repair. Instead of a issuing a recall Subaru is offering allowances to the repair. The service advisor stated that he has performed many of the same repair outside the production dates listed on recall WUJ-95 - Exhaust Pipe Front (EPF) Bellows Cracking, The production dates need to be extend to include all cars that have defective exhaust bellows and catalytic convertors. I have images and video of the inspection.
Other or unspecified, Engine, Jan 31, 2022, fire
My car spontaneously burst into flames after I parked it. I had left the car parked and locked in a parking lot next to a rental house and went in to prepare dinner. 20 minutes later my friends arrived at the scene and alerted us to the fact that my car was engulfed in flames. It seems that the fire originated in the engine somehow, but exactly what started it is unclear. There was no accident or collision, and no foul play. Security cameras in the area couldn't see much, but indicate that the vehicle burst into flames pretty much just after I had left it parked and locked.
Engine, Jan 26, 2022
Issue with the vehicle's exhaust being loud - upon dealership's multi-point inspection, cracked bellows was identified. Issue that was identified and fixed is described in NHTSA ID Number: 10199936, Exhaust Pipe Front (EPF) Bellows Cracking, however the VIN of my vehicle was not included (although it is the same make and model year). Request that this issue be investigated to determine if additional VINs should be included.
Engine, Sep 16, 2021
We have experienced slight acceleration issues when at standstill. For example parking in our garage, nosing to the front and the car will lurch forward. We always been able to control it but we do have to watch out. Decided to report after reading issues by other owners.
Electrical system, Seat belts, Engine, Jul 22, 2021
My Outback lost AC/Heat and even after repair at an Outback dealership, it still goes out intermittently. My car battery seems to drain for no reason at all, without any consistency to the drainage of power either. I have it looked at, and the dealership said there isn’t a cause and there isn’t anything that can be done. Back rear door doesn’t lock and unlock with the key fob designation; sets off the alarm when we don’t pay attention to it. Hatch door only lifts about 14 inches upon designation. Has to be manually lifted the rest of the way. Has been fixed once at a dealership, but since returned to the aforementioned diagnosis.
Electrical system, Exterior lighting, Engine, May 25, 2021
My 2016 Subaru OUTBACK has experienced 6 separate incidents where my vehicle battery was inexplicably drained, and hence the entire electrical system was shut down. I was unable to start it without an external boost in each occasion. Fortunately these incidents posed no safety threat to me or others as the car was parked at my home, or in a parking lot. Unfortunately, the problem has not been reproduced or confirmed by my Subaru Dealer, Gillman, in Schertz, TX although extensive diagnostics were performed on 2 occasions by Gillman. My OUTBACK has not been inspected by manufacturer, police, or insurance representatives. There were no warning lamps illuminated because of a total electrical failure, and no other symptoms of the problem prior to the 6 failures. The dates for the 5 incidents of total electrical failure are the following: (1) 6/18/2018 at 1240 Kahili Street, Kailua, HI. AAA replaced my original Subaru battery (I do not have original AAA receipt, but other documentation) (2) 10/13/2018 at 1240 Kahili Street, Kailua, HI. AAA replaced my battery. (3) 9/16/2019 at 306 FM 621, San Marcos, TX. AAA replaced my battery. (4) 7/27/2020 at 648 Sydney Circle, New Braunfels, TX. AAA replaced my battery. (5) 9/5/2020 at 648 Sydney Circle, New Braunfels, TX. AAA replaced by battery. (6) 10/7/2020 at 648 Sydney Circle, New Braunfels, TX. Gillman Subaru removed an aftermarket device for corrosion protection installed by SERVCO Subaru, Honolulu.
Power train, Exterior lighting, Engine, May 15, 2021
COMPLETE DRAINING OF BATTERY JUST SITTING THERE FOR NO REASON... WE SEE THIS IS AN ENORMOUS PROBLEM WITH OUTBACKS, AND WE HAVE ONE WITH GREAT PROBLEMS LEAVING US STRANDED !
Electrical system, Other or unspecified, Engine, Mar 30, 2021
THE CAR WAS PARKED IN THE GARAGE AND IT WAS ABOVE FREEZING. NONE OF THE LIGHTS HAD BEEN LEFT ON/DOORS OPEN... THE CAR DOESN'T HAVE A FOB KEPT TOO CLOSE... THE CAR WOULDN'T START. THIS ISN'T THE FIRST TIME THIS HAS HAPPENED AND WE'RE NOT SURE IF IT'S A BATTERY, ALTERNATOR, ELECTRICAL ISSUE OR WHAT. WE'VE HAD THE BATTERY REPLACED ONCE ALREADY. IT FIRST HAPPENED WITHIN A WEEK OF PURCHASING THE CAR IN 2017 IN THE SUMMER TIME, AND HAS HAPPENED SEVERAL TIMES SINCE WITHOUT EXCESSIVE ELECTRICAL COMPONENTS IN USE.
Power train, Engine, Feb 16, 2021
2.12 FEBRUARY 2021, VEHICLE MILAGE APPROACHING 42,000. TRAVELING FROM MAZAMA WA TO SEATTLE VIA WA HWY 20, US 97 AND I-90, TRAVELED +/- 200 MILES. TEMPERATURE RANGES FROM 10F TO 20F. TRAVELING WEST ON I-90 +/-50 MPH, LANES CLEAR, SNOW IN BETWEEN LANES. NEW MICHELIN TIRES ON ALL 4 WHEELS. HOLDING THE SPEED CONSTANT FOLLOWING 18-WHEEL RIG. SUBARU STARTED WOBBLING AS IF ONE OF THE TIRES WAS GOING FLAT. TRIED ACCELERATING AND SLOWING TO DETERMINE IF THIS WAS FRONT OR BACK TIRE. DETERMINED IT MUST BE A REAR TIRE. NO LOW-PRESSURE INDICATION ON THE INSTRUMENT GAGES (I HAVE HAD TIRE WARNING DURING SUMMER DRIVING AND FOUND A NAIL IN TIRE). NEXT OFF RAMP CHECKED ALL 4 TIRES, ALL APPEARED TO BE THE SAME IN APPEARANCE. RESUMED TRAVEL. DURING ACCELERATION AND DE-ACCELERATING NO DIFFERENTIAL SWAY. WHEN CONSTANT SPEED MAINTAINED AROUND 50 MPH SWAYING OCCURRED UN TO WE REACHED THE WEST SIDE OF SNOQUALMIE PASS AND THE TEMPERATURE WAS INTO THE 30'S. LAST YEAR WHEN HAVING VEHICLE SERVICED, I TOLD THE SERVICE CHECK-IN PERSON & A SUPERVISOR THE CAR WAS STALLING OUT WHEN HARD ACCELERATION DURING MERGING LEFT INTO HIGHWAY WHERE SPEED LIMIT WAS 50 MPH. THE CAR STALLED AND I KICKED THE ACCELERATOR. LUCKILY, THE CAR RESPONDED THE SUPERVISORS RESPONSE WAS 'THERE'S NO WAY THIS CAN HAPPEN'.
Electrical system, Engine, Jan 29, 2021
STEERING WHEEL LOCKS AND ALL LIGHTS LIGHT UP ON DASH THEN VEHICLE COMPLETELY SHUTS OFF. TRIED TO JUMP VEHICLE AND VEHICLE WILL START BUT TURNS OFF A FEW SECONDS LATER. SUBARU ADVISE IT WAS A DEFECTIVE BATTERY. SUBARU THEN REPLACE BATTERY UNDER WARRANTY ON 11/05/2020. THE BATTERY WAS NOT EVEN 1 YEAR OLD WHEN IT WAS REPLACED. TODAY ON 01/29/2021 IT HAPPENED AGAIN WHILE DRIVING. LUCKY BOTH TIMES I WAS NOT TRAVELING AT A HIGH RATE OF SPEED LIKE ON A HEY. I WAS ABLE TO PULL OFF ON THE SIDE STREET. NOW I'M WAITING FOR A TOW TRUCK TO TOW MY VEHICLE TO THE SUBARU DEALERSHIP.
Electrical system, Engine, Jan 19, 2021
I HAVE A 2016 SUBARU OUTBACK PURCHASED SEPTEMBER 2019 LAST YEAR REPLACED THE BATTERY, YESTERDAY THE CAR WOULD NOT STRAT. JUMP IT GOT IT TO THE SHOP AND THEY SHOWED THE BATTERY, & ALTERNATOR WERE GOOD. I SREACHED AND SEEN SEVERAL COMPLAINTS THE ARE THE SAME ON 2016 TO 2020. WE NEED A RECALL.
Engine, Jan 4, 2021
THE FRONT EXHAUST PIPE BELLOWS CRACKED. WHEN THE CAR WAS COLD STARTED AND THEN DRIVEN, A RATTLE CAME FROM THE ENGINE BAY WHEN DRIVEN AT 2500 RPM. WHEN THE ENGINE WARMS UP, THE RATTLE GOES AWAY. WHEN THE CAR IS PARKED, EXHAUST FUMES CAN BE SMELLED FROM OUTSIDE THE CAR.
Engine, Jan 3, 2021
CAR DIES AND WON'T START A NEW BATTERY WILL LAST 6 MONTHS.
Engine, Oct 6, 2020
A VALVE SPRING FAILED, CAUSING THE VALVE TO BREAK AND BECOME EMBEDDED IN THE PISTON.THIS CAUSED THE VEHICLE TO BE INOPERABLE.
Electrical system, Engine, Aug 6, 2020
BATTERY DIES UNEXPECTEDLY WITHIN A FEW MINUTES OF THE VEHICLE OFF AND IN ACCESSORY MODE ONLY (I.E. CAR OFF, RADIO OR LIGHTS ON). VEHICLE WILL NOT START WITHOUT JUMP FROM BATTERY PACK OR ANOTHER VEHICLE. CAR WILL NOT EVEN CRANK BUT WILL ONLY MAKE A CLICKING NOISE. OCCASIONALLY, ENGINE TIMING WILL BE AFFECTED AFTER JUMP AND MISFIRES WILL OCCUR CAUSING VEHICLE TO RUN VERY ROUGH UNTIL RESTARTED, AT WHICH POINT ELECTRICAL SYSTEM SEEMS TO RESET ITSELF. TO DATE, DEALER HAS FOUND NO DIRECT CAUSE FOR THE PROBLEM (I.E. NO PARASITIC DRAWS) BUT HAS REPLACED THE BATTERY (WHICH ARE UNDER WARRANTY) MULTIPLE TIMES. PROBLEM HAS OCCURRED NUMEROUS TIMES SINCE IT WAS PURCHASED IN LATE 2015.
Engine, Jul 8, 2020
IN 6 MONTHS, I GOT MORE THAN 10 TIMES OF LOW LEVEL ENGINE OIL LIGHT ON. FIRST TIME, IT WAS ON JAN. 2020, IT WAS 3,000 MILES FROM THE LAST OIL CHANGE. SO I CHANGED THE ENGINE OIL WITH NEW OIL. AFTER 2 MONTHS, I GOT LIGHT ON AGAIN. I REFILLED SOME OIL THEN GOT LIGHT ON AFTER ONE MONTH. I REFILLED SEVERAL TIMES BUT THE LIGHT IS ON LATER. THERE IS DROPPED OIL ON THE FLOOR AT ALL. I COULDN'T FIND WHERE THE OIL IS GONE.
Vehicle speed control, Engine, May 16, 2020
WHILE SITTING STILL AT A RED LIGHT WITH MY FOOT ON THE BRAKE AND THE GEAR IN DRIVE, THE CAR WILL SUDDENLY LURCH FORWARD SEVERAL FEET. IT HAPPENS WITH SUCH FORCE THAT IT FEELS LIKE I WAS REAR-ENDED. THIS HAS HAPPENED OCCASIONALLY SINCE I PURCHASED THE CAR IN JANUARY 2016. ALWAYS WHEN AT A FULL STOP ON FLAT AND SLOPED SURFACES. AT FIRST I THOUGHT IT ONLY HAPPENED WHEN THE AC WAS ON, BUT IT HAS HAPPENED WITH THE AC OFF. *TR
Engine, Mar 15, 2020
TWICE SINCE NOVEMBER,'19 AND MOST RECENTLY ON 3/14/2020, WHEN STOPPED AT AN INTERSECTION, WITH FOOT ON BRAKE, THE ENGINE REVVED UP WILDLY. THEN, IN BOTH INCIDENTS I ATTEMPTED TO PUT CAR IN NEUTRAL. GEARSHIFT WOULD NOT MOVE. I HAD TO TURN ENGINE OFF. AFTER SEVERAL ATTEMPT I WAS ABLE TO RESTART THE CAR. I THOUGHT THE FIRST INCIDENT WAS A FLUKE. BUT AFTER YESTERDAY'S (MARCH 14 '20) INCIDENT, IN WHICH I NARROWLY AVOIDED A CRASH, I BELIEVE SUBARU AND, IF NEED BE, THE GOVERNMENT, SHOULD ADDRESS THIS SAFETY ISSUE. PLEASE DO NOT EXCUSE THESE INCIDENTS WITH "YOUR FOOT WAS ON THE ACCELERATOR AND BRAKE AT THE SAME TIME. THIS NOT WHAT HAPPENED.
Engine, Mar 30, 2019
COMING TO A STOP AT CURBSIDE. APPLYING LIGHT PRESSURE TO THE BRAKE. VEHICLE STARTED TO PULL FORWARD. WAS ABLE TO STOP BY INCREASING PRESSURE ON THE BRAKE. ENGINE SPEED INCREASED QUICKLY AFTER I SHIFTED TO PARK. ENGINE SOUND WAS LOUD ENOUGH TO BE NOTICED BY PEOPLE IN THE AREA. I RESPONDED BY TURNING OFF THE ENGINE. CRUISE CONTROL WAS ENABLED AT THE TIME.
Engine, Fuel/propulsion system, Jan 2, 2019
ON TWO OCCASIONS WHILE DRIVING ON THE INTERSTATE AT 65-75 MPH WITH NO WARNING THE GAS PEDAL STOPPED RESPONDING TO INPUTS. WHILE MANEUVERING THE VEHICLE TO THE SHOULDER OF THE ROAD THROUGH TRAFFIC THE ENGINE SHUTOFF. ON ONE OCCASION I WAS ABLE TO RESTART THE VEHICLE AND ON THE SECOND OCCASION IT WOULD NOT RESTART. AFTER TOWING THE VEHICLE TO A REPAIR SHOP THE VEHICLE STARTED UP AND RAN WITH NO ISSUES. NO CHECK ENGINE LIGHTS WERE EVER DISPLAYED. THE BATTERY WAS WORKING FINE AND FULLY CHARGED. THE CAR IS IN PERFECT MECHANICAL SHAPE WITH ALL REGULAR SERVICE PERFORMED. THE GAS REMAINING AT TIME OF INCIDENT WAS APPROXIMATELY 1/4 TANK FULL. THE CAUSE IS UNKNOWN TO ME.
Power train, Other or unspecified, Engine, Aug 29, 2018, fire
I HAD A MAJOR ISSUE WITH THIS VEHICLE ON JUNE 24. WE WERE DRIVING BACK FROM OUR FAMILY VACATION WHEN I WAS PASSING A SEMI TRUCK ON A TWO LANE ROAD THE VEHICLE SUDDENLY LOST POWER TO THE WHEELS AND WOULD NOT ACCELERATE. AS I STEPPED ON THE GAS THE ENGINE REVVED UP BUT THE VEHICLE WAS NOT ACCELERATING. I THOUGHT IT SLIPPED OUT OF GEAR. I PUT IT IN NEUTRAL THEN BACK INTO DRIVE AND STILL HAD THE SAME PROBLEM. I PUT MY FLASHERS ON TO ALERT THE TRUCK THAT I WAS HAVING ISSUES. I PULLED ONTO THE SHOULDER AND HE PASSED ME. I NOTICED THE TACHOMETER READ BETWEEN THE 3 AND 4 MARK WHEN I PUT MY FOOT ON THE ACCELERATOR TRYING TO SPEED UP. HOWEVER, THE VEHICLE DID NOT SPEED UP AT ALL. I WAS ABLE TO PULL OFF THE ROAD ONTO A TURNOUT AREA. THE PASSENGER IN THE FRONT SEAT ASKED IF ANY WARNING LIGHT CAME ON. NO LIGHTS OF ANY SORT CAME ON. THE TEMPERATURE GAUGE WAS IN THE NORMAL OPERATING RANGE. AFTER THE CAR STOPPED I TURNED OFF THE IGNITION AND OPENED MY DOOR AND NOTICED FLAMES COMING FROM THE BOTTOM OF THE CAR. I IMMEDIATELY INSTRUCTED THE OTHER THREE (3) PASSENGERS TO IMMEDIATELY EXIT THE CAR BECAUSE OF THE FLAMES. LUCKILY WE WERE ABLE TO EXIT THE VEHICLE AND GET A SAFE DISTANCE AWAY TO CALL 911 FOR ASSISTANCE. UNFORTUNATELY THE FIRE CONTINUED TO BURN AND ENGULFED THE CAR. BLACK SMOKE STARTED TO APPEAR. THE FIRE DEPARTMENT SHOWED UP AND EXTINGUISHED THE FIRE. WE WATCHED HELPLESSLY WHILE OUR CAR AND POSSESSIONS WENT UP IN SMOKE. WE CONTACTED SUBARU AND FILED A COMPLIANT. THEY TOOK THEIR TIME AND EVENTUALLY SENT THEIR QA TEAM TO INSPECT WHAT WAS LEFT OF THE VEHICLE. THEY FINALLY SENT US AN EMAIL STATING THEY COULD NOT FIND THE ROOT CAUSE OF THE FIRE BECAUSE THE FIRE DAMAGE WAS TOO INTENSE. WE BOUGHT THIS VEHICLE NEW JUST TWO YEARS PRIOR AND IT ONLY HAD ABOUT 30K MILES AND HAD ALL THE FACTORY RECOMMENDED SERVICES AT THE DEALERSHIP. THE VEHICLE IS UNDER WARRANTY.
Engine, Aug 27, 2018
THE 3.6R ENGINE IMMEDIATELY AFTER COLD START DOES ABOUT 5 CYCLING SURGES OF ABOUT 300 RPM WITH TRANSMISSION IN FORWARD OR REVERSE WITH BRAKES APPLIED. THIS EVENT DOES NOT HAPPEN UNLESS STARTING WHEN ENGINE IS COLD AND TRANSMISSION IS PUT IN GEAR WITH BRAKES APPLIED. THE SURGE DOES NOT HAPPEN AFTER A SHORT WARM UP. THIS COULD BE A SAFETY ISSUE WITH A TIGHT PARKING SITUATION OR WHEN DEPARTING A GARAGE.
Engine, Aug 9, 2018
MY WIFE WAS DRIVING CAR ON HIGHWAY AND WAS WAITING IN TRAFFIC TO TAKE A RAMP EXIT. OUR SUBARU OUTBACK'S ENGINE SUDDENLY STOPPED. CAR HAD TO BE PUT IN PARK GEAR AND THEN RESTARTED BEFORE IT WAS DRIVE-ABLE. THIS SUDDEN STOPPING OF CAR IS HIGHLY WORRISOME.