2016 Subaru Outback
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 642 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Outback model years with reports.
Of the 2016 reports, 22 involved a crash and 3 involved a fire. 13 people were injured.
What owners report most often
Recalls and investigations
Air bags, air bag/restraint control moduleDec 19, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2016-2017 Outback vehicles. A replacement air bag control module may have been installed that is not compatible with the passenger air bag module, possibly affecting air bag deployment.
In the event of a crash necessitating passenger frontal air bag deployment, the air bag may not deploy properly, increasing the risk of injury.
Subaru will notify owners, and dealers will replace the passenger air bag module, free of charge. The recall began February 3, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUX-09.
Campaign 19V910000 on NHTSA.gov
Steering, columnDo not drive until repairedMay 11, 2016
Subaru of America, Inc. (Subaru) is recalling certain model year 2016-2017 Legacy and Outback vehicles manufactured February 29, 2016, to May 6, 2016. The steering column on the affected vehicles may have been improperly machined, and as a result, turning the steering wheel may have no effect on the direction of the wheels.
The loss of steering ability would increase the risk of a crash.
Subaru will notify owners, and dealers will inspect the lot number on the steering column, replacing the steering column, as necessary, free of charge. The recall began May 13, 2016. Owners may contact Subaru customer service at 1-800-782-2783 or by visiting http://www.wtd65.service-campaign.com. Subaru's number for this recall is WTD-65. Note: Until the vehicles have been inspected, owners are advised not to drive their vehicles.
Campaign 16V292000 on NHTSA.gov
Power train, driveline, driveshaftNov 24, 2015
Subaru of America, Inc. (Subaru) is recalling certain model year 2016 Legacy vehicles manufactured October 24, 2015, to November 16, 2015, and Outback vehicles manufactured October 24, 2015, to November 17, 2015. Due to the improper tightening of the securing nuts, the drive shaft may separate from the rear differential.
If the drive shaft detaches from the rear differential, it may strike the fuel tank and result in a fuel leak, increasing the risk of a fire.
Subaru has notified owners, and dealers will inspect the fastening nuts, and tighten or replace them, as necessary, free of charge. The recall began on December 10, 2015. Owners may contact Subaru customer service at 1-856-488-8500. Subaru's number for this recall is WQV-57.
Campaign 15V794000 on NHTSA.gov
Power train, driveline, driveshaftAug 10, 2015
Subaru of America, Inc. (Subaru) is recalling certain 2015 and 2016 model year Subaru Legacy 4-Door and Outback vehicles manufactured July 3, 2015, to July 27, 2015. Transmission oil may leak from a deformed seal cap on the propeller shaft yoke.
If the transmission oil leaks onto the exhaust pipe, there is a possible risk of fire.
Subaru will notify owners, and dealers will replace the propeller shaft, free of charge. The recall began on August 28, 2015. Owners may contact 1-800-782-2783. Subaru's number for this recall is WQU-56.
Campaign 15V502000 on NHTSA.gov
Representative owner complaints: other or unspecified
124 reports, newest first. Show all
Other or unspecified, Jun 1, 2026
Vehicle: 2016 Subaru Outback Recall Number: WUJ95 – Front Exhaust Pipe Bellows Crack I incurred repair expenses to address a condition that was later covered by Subaru Recall WUJ95. At the time of the repair, I was unaware that the vehicle was subject to this recall because I never received any recall notification from Subaru. The affected component was the front exhaust pipe bellows assembly covered by Recall WUJ95. The repair was completed by an independent repair facility. The condition involved a cracked exhaust bellows assembly. The failure of this component allowed exhaust gases to escape from the exhaust system into the cabin and is the condition identified by Subaru in Recall WUJ95. The issue was diagnosed and repaired by an independent repair facility. The repair addressed the same component and condition that was subsequently identified by Subaru as part of Recall WUJ95. After learning of the recall, I contacted Subaru of America seeking reimbursement because the repair was completed after the recall had been issued. Subaru denied reimbursement and stated that repairs performed at third-party facilities are not eligible. During the reimbursement review process, I requested documentation showing when and how recall notification was sent to me, including the address used, mailing date, and method of notification. Subaru declined to provide this information. Subaru also declined to provide the specific guidelines relied upon in denying reimbursement. My concern is that I never received recall notification before obtaining the repair, which prevented me from having the recall performed through an authorized Subaru retailer. I am requesting that NHTSA review whether recall notification requirements were properly satisfied in this case and whether vehicle owners are being provided sufficient information to verify recall notification when reimbursement requests are denied.
Other or unspecified, Engine, Forward collision avoidance, Oct 27, 2025
Steering wheel controls frequently fail to work properly on the cruise control system specially the speed control. Also the exhaust system bellow has cracked. The moonroof leaks into the cabin and floor area of the passenger side. Also leaking into the A pillar on the passenger side. I only have a picture of the engine valve cover that is leaking and had to be replaced. I have video of the exhaust leak coming from the crack in the bellow pipe. Do not have video of the cruise control speed issues as I can’t take a video while driving.
Other or unspecified, Sep 23, 2025
Catalytic converter is cracked. This is confirmed by an independent service center. Apparently there is a recall for this issue for 2015 and 2016 Subaru Outbacks manufactured up until September 2015. My 2016 Subaru Outback has the same issue and was manufactured in April 2016. The recall should include all 2016 Subaru Outbacks, not just those manufactured in 2015.
Other or unspecified, Sep 8, 2025
I reached under the steering well to the foot well because it seemed that my AC was not putting out any air. I touched something and received a burn on my hand. I reached out to the SOA but was told to take it to the dealer. Then they asked me to call back and discuss further. When I called back I was told to take it to the dealer. I'm not sure I want to take it to the dealer to be charged a diagnosis fee. It seems the "kick panel" should cover this hot part to not allow access.
Other or unspecified, Aug 31, 2025
Horn quit working
Electrical system, Other or unspecified, May 24, 2025
Known battery drain likely from DCM and also they designed the alternator not to completely charge battery causing frequent dead battery without warning and for no operator error and causing frequent need to replace car batteries over the years.There was a class action lawsuit but no recall for these issues so has not been addressed properly.
Other or unspecified, Engine, May 16, 2025
Exhaust gas smells in the driver cabin and the exhaust shield and the pipe is breaking off.
Other or unspecified, Apr 5, 2025
There’s an open recall on an exhaust leak for similar models and years and my car needs the same work done but it’s not covered under the recall
Other or unspecified, Feb 26, 2025
The 8 month old battery on my 2016 Subaru Outback just died. I understand that the warranty on the DCM was extended by a year, but the dealership said that if it turned out the DCM was not defective, I would have to pay for the test ($185) . The warranty only covers having the battery recharged or replaced. If the DCM is the cause of the battery drain, than the warranty should pay for replacing the DCM, in addition to replacing the battery. Otherwise the problem will continue to reoccur. There should be a recall on the DCM!
Other or unspecified, Sep 27, 2024
My 2016 Subaru Outback, manufactured 23 business days after the end date of recall WUJ-95, has the same exhaust system and now the same exhaust system failure as the cars covered under the recall. My car is available for inspection. This exhaust failure poses a risk of carbon monoxide poisioning. The problem in my car was identified by an independent mechanic who works exclusively on Subarus and has seen this failure in other clients' vehicles. He referred me to Subaru for repairs and recommended I look into why I hadn't received a recall notice. I contacted Subaru, opened a case, then didn't recieve a response in the timeframe they defined. After waiting a few days, I called back to learned my case had been closed. Their customer advocacy representative responded the next week and said my car was not recalled because it was manufactured on 11/3/2015, after the end date of the recall on 9/30/2015. She also cited a lack of service history with a Subaru retailer (I offered to provide records) and being out of warranty by time and miles (I mentioned 2017-18 Foresters received warranty extensions to 15 years or 150K miles for this failure.) I asked what their escalation process is for making exceptions and was told the representative was the only customer-facing person I would be able to speak with about this and she declined to offer any assistance, but did offer a loyalty discount on a new vehicle. My car has not been inspected by anyone else. I'm willing to take it to anyone who should look at it. There were no warning lights or messages related to the issue. It was diagnosed when I took the car in for regular maintenance and it explains the more noticable smell of exhaust in the car, that I had attributed to other traffic, when I'm sitting at stop lights.
Other or unspecified, Sep 25, 2024
The catalytic converter on my vehicle has an air leak causing my engine light to come on and almost all features such as cruise control become disabled. There is a recall that was issued in 2020 for the exact same problem my vehicle is having and the recall covers the same year, make and model of my vehicle. I was told that my vehicle isn’t under the recall but the representative was unable to specify why. I am trying to get the part replaced as the vehicle is polluting the air and causing my vehicle to not perform as expected.
Other or unspecified, Aug 20, 2024
The lock on the side of the door that turns on the child lock so kids cannot open the door from the inside is stuck in the lock position and will not disengage.
Other or unspecified, Jun 26, 2024
Can not take the key out of ignition.
Other or unspecified, Jun 20, 2024
I have a vehicle built in 11/15. I had an issue with cracked pipes associated with the catalytic converter that appear to match an existing nhsta recall for vehicles built between 12/09/2013 – 9/30/2015. It appears that the previous recall was not expansive enough.
Other or unspecified, Visibility/wiper, Jun 10, 2024
Travelling on I-95 southbound at approx. 70 mph in the right lane at least 8-10 car lengths behind another vehicle in front of me. Clear skies, 78* F, calm weather. I heard a loud, sudden noise followed by wind and what sounded like glass on my roof, thought it was fireworks or a gunshot. Pulled over to make sure my dogs are OK (all good, just spooked!) and see what happened to the car when I observed a large hole and continued cracking noise in the sunroof - glass was pushed outwards/ convex rather than concave as if an object had struck the glass from above or in front of my vehicle. Notified insurance then carefully drove home the remaining 20 or so miles, called dealership and started researching the issue. There are nearly 40 reports of spontaneous sunroof explosions on NHTSA website for Subaru Outbacks. Dealing with Subaru Corporate and a local dealership for repairs.
Other or unspecified, Apr 11, 2024
The child lock of right side is stuck its on on position we can't open the door from inside nd now the button is broken.
Other or unspecified, Dec 10, 2023
My Subaru Key is Stuck in Ignition. Two to three times a week the key can not be removed from the key switch . The vehicle will shut off, but the key remains.
Other or unspecified, Oct 31, 2023
Right rear door will not open from inside, child door lock will not shift although child lock not engaged. InCase of crash or fire cannot exit vehicle. confirmed by repair shop. No insurance inspection. No warning lights associated with this visible
Other or unspecified, Sep 6, 2023, fire
I bought this vehicle used. I was the 2nd owner. I purchased it on the evening of August 18, 2023. On the morning of August 19, 2023, I drove the vehicle for about 45 miles. I reached my destination, got out of the car, and saw what looked like either smoke or dust from under my car. I worried it might be overheating. A bystander told me the car was on fire. I walked forward to see flames coming from the front passenger side below the grill, possibly in the axle. The fire grew aggressively despite attempts to extinguish it. When the fire department arrived within 5 minutes the car was fully engulfed. The damage is so severe that it may be impossible to determine the source and cause of the fire. The dealer and my mechanic performed inspections on the vehicle before I bought it and found everything to be in good working condition.
Electrical system, Other or unspecified, Aug 22, 2023
My key keeps getting stuck in the ignition, and forced me to have to leave the key in the car while I went in to a store, when i got back someone was in my car. I realize that this is a different type of safety issue, but it truly is a safety issue. I am having to leave my key in my car everywhere i do because it doesn't come out,, eventually it will come out randomly but not everytime I shut the car off. this should be a recall issue for Subaru's that have this problem. I have read many complaints about Subaru owners with this issue happpening to them. I am not the only one. Thank You!
Other or unspecified, Jul 25, 2023
Key intermittently stuck in ignition. Unable to lock car doors with key stuck in the ignition. Problem started early on occasionally and now happens nearly every other time and requires a few tries up to 10 minutes of trying to get it out. This is a known issue among my model - Service Bulletin 16-112-18R
Vehicle speed control, Other or unspecified, Jul 10, 2023
While driving on the highway at about 60mph my 2016 Outback suddenly accelerated much faster. The only way to avoid collision with another car or cars or end up in a ditch was to drive around them. The brake did not work! After a minute or more(?) I eventually was able to stop using the brake.
Other or unspecified, Jul 7, 2023
Motorized power liftgate is failing (diagnosed by dealer on 7/7/23) apparently because motor is undersized or 2 motors should have instead been used/designed to deal with load. Safety issue if motor failure causes trunk not to open. Newer models have been redesigned.
Other or unspecified, Engine, Fuel/propulsion system, Jan 27, 2023, crash
I was in a parking lot at a near-complete stop. I needed to nose the car about 18 inches to move it all the way into the spot. I lightly touched the accelerator to inch the car forward, and it shot forward as if some outside force had stomped on the accelerator. The car jumped the sidewalk and slammed into the wall of the building. The car inner body bent and the car is totaled. The airbags did not inflate. The passenger in the passenger seat sustained a fractured sternum and two broken ribs from going into the seatbelt. The driver sustained a sore neck and dizziness.
Electrical system, Other or unspecified, Jan 20, 2023
THE BATTERY is completely unreliable - I have had 3 batteries since I purchased the car in 2015 - REPEATED RECURRENT DISCHARGE WITHOUT APPARENT CAUSE - SUCH AS LIGHTS LEFT ON - PARASITIC DRAIN IT SEEMS In recent research have discovered this is not a new issue and there is a class action lawsuit settlement - I did not exclude myself and somewhat now wish that I had, in order to attempt to get some buy back incentive from Subaru. Beginning in 2019 - and maybe prior though I had not recognized it as a chronic issue then - I have encountered recurrent issues of complete battery discharge after time periods ranging from 5 to 24 hours. Estimate at least 1 to 2 discharges per month requiring cable jump, and many more times when the car was very difficult to start (almost fully discharged) To minimize risk as consumer I have bought a HALO Bolt - but Subaru should be held accountable to fixing primary cause of this chronic issue for so many of us.