2022 Thor Motor Coach Windsport
Problems, recalls and owner-reported issues
Structure is the leading concern among 5 owner complaints filed for this model year. This is the 4th highest complaint count among 8 Windsport model years with reports.
What owners report most often
Recalls and investigations
Structure, body, step/ladderFeb 10, 2022
Thor Motor Coach (TMC) is recalling certain 2022 ACE, Freedom Traveler, Hurricane, and Windsport motorhomes. The rear ladder may have been installed on the wrong side of the motorhome.
An incorrectly installed ladder may break while in use, increasing the risk of injury.
Dealers will inspect the location of the rear ladder, and reinforce or relocate the ladder as needed, free of charge. Owner notification letters were mailed March 24, 2022. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000255.
Campaign 22V076000 on NHTSA.gov
Representative owner complaints: other or unspecified
3 reports, newest first. Show all
Equipment, Other or unspecified, Jun 9, 2026
I’m concerned about the bbq propane compartment getting hairline cracks and the brass shut off valve that’s made of brass and dropping down to the road and getting road rash till it grinds through the shut off valve. I just read on a Thor Facebook forum that this happened to a 2016 Thor Windsport 34P. I have the pictures he posted. I asked AI Gemini, apparently this is a known and well documented safety issue. I can forward the link to the AI report. Will link here if this works. The pictures are mine (intact) and the other two are his 2016 motorhome. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Other or unspecified, May 27, 2024
The propane heater on our motorhome has been cycling on the high limit switch since new. This is due to insufficient airflow across the heat exchanger. It is also the source of intermittent carbon monoxide alarms being activated. We have had this unsuccessfully repaired under warranty. The cycling continues. If other units of this model series were built the same way, I suspect this is a problem common to all. This also creates a fire risk should the high limit switch be operated enough times for it to fail. I am now using an electric heater, but this requires I be hooked up to electric service.
Other or unspecified, Mar 9, 2024
Main propane heater in my Thor Windsport 29M motorhome was coming on and goings on off before the desired temperature was reached. I realized it was cycling on the high limit switch, which is.generally caused by insufficient air flow over the heat exchanger. Took it in for warranty service which identified the cause as a kinked heater hose, which had to have been done at the factory during installation. Had the high limit switch failed, the motorhome would have been lost to a fire. Due to the high heat caused by the kinked duct, the blower wheel had partially melted.