2004 Toyota Corolla
Problems, recalls and owner-reported issues
Air bags is the leading concern among 506 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Corolla model years with reports.
Of the 2004 reports, 70 involved a crash and 3 involved a fire. 57 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, passenger side, inflator moduleOct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Campaign 19V741000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleAug 28, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2003-2008 Corolla, 2005-2008 Corolla Matrix, and Pontiac Vibe vehicles equipped with a front passenger air bag assembly replaced under a prior recall. The air bag may not unfold as designed during inflation under high temperature conditions, possibly resulting in the air bag not inflating properly.
An improperly inflated air bag increases the risk of injury during a crash.
Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag assembly or sub-assembly, free of charge. Toyota owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall are K1Q and K0Q. Pontiac owners may contact GM customer service at 1-800-762-2737. GM's number for this recall is N192273760.
Campaign 19V627000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleDec 12, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2002-2005 Lexus SC and Toyota Sequoia, 2003-2005 Toyota Corolla and Tundra, and 2003-2007 Pontiac Vibe vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Toyota will notify the Toyota and Lexus owners. General Motors will notify the Pontiac Vibe owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator with an alternate inflator, or replace the air bag assembly that includes an alternate inflator, free of charge. The recall began January 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371, Lexus customer service at 1-800-255-3987 or Pontiac customer service at 1-800-762-2737. Toyota's numbers for these recalls are J0A (Zone A Toyota), J0B (Zone B Toyota), J0C (Zone C Toyota), JLI (Zone A Lexus), JLJ (Zone B Lexus), and JLK (Zone C Lexus). Note: This recall includes vehicles that have had their air bag previously replaced under an earlier air bag campaign.
Campaign 18V883000 on NHTSA.gov
Air bagsMay 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.
In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.
Campaign 15V286000 on NHTSA.gov
Air bagsMay 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.
In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.
Campaign 15V285000 on NHTSA.gov
Air bags, frontalJan 28, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2004 Toyota Corolla vehicles manufactured December 28, 2001, to May 2, 2004, 2003-2004 Toyota Corolla Matrix vehicles manufactured January 6, 2002, to April 29, 2004, 2003-2004 Avalon vehicles manufactured June 5, 2002, to December 20, 2004, and 2003-2004 Pontiac Vibe vehicles manufactured January 18, 2002, to April 27, 2004. Due to electrical noise, a component in the air bag control module may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.
Inadvertent deployment of the air bags or the seat belt pretensioners increases the risk of an injury or crash.
Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the air bag control module, free of charge. The recall began on August 24, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. GM issued an interim notification to owners on March 27, 2015. The recall began on August 24, 2015. Pontiac owners may call 1-800-620-7668. Note: This recall supersedes recalls 13V-029 and 14V-147. Vehicles that had a noise filter installed as the remedy for one of those campaigns need to have the air bag control module replaced under this campaign.
Campaign 15V043000 on NHTSA.gov
Air bagsJan 30, 2013
Toyota is recalling certain model year 2003-2004 Corolla and Corolla Matrix vehicles and 2003-2004 Pontiac Vibe vehicles. The supplemental restraint system (SRS) circuits are susceptible to internal shorting. The electrical short may create an abnormal current flow and increased heat which can damage the circuits. This could result in an inadvertent deployment of the front airbags and/or seat belt pretensioners.
Inadvertent deployment of the airbags or the seat belt pretensioners may increase the risk of injury and the possibility of a vehicle crash.
Toyota will re-notify their owners who have already had their vehicles repaired with a noise filter, but did not receive a new airbag control module, and General Motors will re-notify theirs. Dealers previously installed a supplemental harness containing an electrical filter between the airbag control module and its wire harness, free of charge. Dealers will replace the airbag control module, free of charge. The recall began on March 13, 2013. The manufacturer has not yet provided a schedule for second notices. For more information, Toyota owners may call 1-800-331-4331 and Pontiac owners may call 1-800-620-7668.
Campaign 13V029000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2008
TOYOTA IS RECALLING 662,178 MY 2003-2004 COROLLA, COROLLA MATRIX AND PONTIAC VIBE VEHICLES EQUIPPED WITH POWER WINDOWS. THE DRIVER AND FRONT PASSENGER DOOR GLASS BOLTS MAY LOOSEN AND COME OFF, CAUSING THE DOOR GLASS TO SEPARATE FROM THE WINDOW REGULATOR. DUE TO THE COMPONENTS BECOMING LOOSE AND POSSIBLY RATTLING, AN ABNORMAL NOISE MAY BE HEARD FROM THE DRIVER AND /OR FRONT PASSENGER DOOR WHEN OPERATING THE POWER WINDOWS.
THE DOOR GLASS MAY SEPARATE FROM THE WINDOW REGULATOR, BIND AND SHATTER DURING OPERATION OF THE POWER WINDOWS, CAUSING DRIVER DISTRACTION AND/OR INJURY.
DEALERS WILL REPLACE THE DRIVER AND FRONT PASSENGER DOOR GLASS BOLTS WITH NEWLY DESIGNED BOLTS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 16, 2008 TO TOYOTA OWNERS. THE RECALL BEGAN ON MAY 21, 2008, FOR PONTIAC OWNERS. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371 OR PONTIAC AT 1-800-620-7668.
Campaign 08V162000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
WheelsOct 6, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH FACTORY ALUMINUM ALLOY WHEELS, THE LUG NUT(S) MAY NOT SECURE THE WHEEL PROPERLY TO THE HUB ASSEMBLY DUE TO OVER-DRILLING OF ONE OR MORE OF THE FIVE LUG NUT HOLES ON THE ALLOY WHEEL. IF THE VEHICLE IS DRIVEN FOR AN EXTENDED PERIOD IN THIS CONDITION, THE LUG NUT(S) COULD POTENTIALLY LOOSEN.
IN THE WORST CASE, THE STUD BOLT(S) MAY FRACTURE, WHICH MAY RESULT IN THE SEPARATION OF THE WHEEL FROM THE HUB ASSEMBLY AND LEAD TO A LOSS OF VEHICLE CONTROL.
DEALERS WILL INSPECT ALL FOUR FACTORY ALUMINUM ALLOY WHEELS AND, IF NECESSARY, REPLACE ANY FOUND TO BE OUT OF SPECIFICATIONS. OWNER NOTIFICATION BEGAN OCTOBER 27, 2003. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 03V366000 on NHTSA.gov
Representative owner complaints
506 reports, newest first.
Power train, Apr 14, 2007
I AM HAVING WHAT COULD BE A SERIOUS PROBLEM WITH MY ALMOST NEW COROLLA 2004 WITH ONLY 8000 MILES. IF I LEAVE THE CAR PARKED FOR SAY MORE THAN A WEEK, I THEN START IT, AND TRY TO GO INTO REVERSE THE CAR TAKES (LAGS) LIKE 5 OR 6 SECONDS TO SORT OF ENGAGE THE GEAR. AT FIRST IT SORT OF LIKE STARTS TO GO BUT NOT FULLY (SLIPS) AND AFTER THAT IT GOES SOLID IN TO REVERSE. I HOPE YOU UNDERSTAND MY EXPLANATION?? DEALER HAS PERFORMED THE HYDRAULIC TEST, RESET THE MEMORY, AND CHANGED THE OIL. *AK
Vehicle speed control, Apr 9, 2007
TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2004 TOYOTA COROLLA WITH 31000 FAILURE MILEAGE AT 15 MPH WITH FOOT ON THE GAS PEDALTHE VEHICLE RACED UP TO 35 MPH, AND THE RPMS RACED BETWEEN 4 AND 5 ON THE GAUGE. THE CONTACT IMMEDIATELY APPLIED THE BRAKE AS HARD AS HE COULD, AND PUT THE VEHICLE INTO NEUTRAL. HE ALSO APPLIED THE GAS, ALLOWING THE VEHICLE TO STOP IDLING. THE VEHICLE WAS AT THE DEALER BEING LOOKED AT CONCERNING THIS PROBLEM. THE CURRENT MILEAGE WAS 32,000.*AK UPDATED 04/30/07. *JB
Tires, Jan 22, 2007
SIDE WALL FAILURE (BULGE) EVIDENCED ON BRIDGESTONE INSIGNIA TIRE, P19565R15. ORIGINAL TIRES ON NEW VEHICLE. SECOND INCIDENT FIRST, WAS AT ONLY 12,000 MILES. THIS IS DANGEROUS CONDITION. TWO FAILURES REQUIRE SOME AWARENESS BY MANUFACTURER. TIRE REPLACED PRIOR TO COMPLETE FAILURE.*JB
Fuel system, Gasoline, Dec 16, 2006
2004 TOYOTA COROLLA FUEL FILLER FAILED ON 12/14/06 NEW FUEL FILLER HAD TO BE INSTALLED. *JB
Service brakes, Hydraulic, Nov 24, 2006, fire
I HAVE TWO CLAIMS ON TOYOTA COROLLA'S. EACH VEHICLE HAD A FIRE START IN THE WHEEL WELL AREA. THE DEALER IS BLAMING BRAKE FAILURE. THE FIRST VEHICLE IS AN 06 COROLLA AND THE OTHER IS AN 04 COROLLA. NEITHER VEHICLE HAS EVER HAD ANY BRAKE WORK DONE AND BOTH HAVE VERY LOW MILES. CERTAINLY THE 06 COROLLA SHOULD BE HANDLED BY TOYOTA UNDER WARRANTY BUT SO FAR THEY ARE NOT WANTING TO HANDLE THIS LOSS. *JB
Engine and engine cooling, Oct 27, 2006
I OWN A 2004 TOYOTA COROLLA (45,000 MILES) AND THE CHECK ENGINE LIGHT ILLUMINATED, (READ CODE P0456, EMISSION CONTROL EVAP SMALL LEAK). MY INVESTIGATION REVEALED THAT THERE WERE MANY OTHER VEHICLES WITH THE SAME ISSUE AND TOYOTA HAS CORRECTED THIS PROBLEM WITH REPLACING THE FUEL FILLER TUBE AT THE OWNERS EXPENSE (APPROX. $300.00). SHOULD THIS NOT BE A RECALL DUE TO THE VEHICLE BEING ONLY 2YRS OLD AND A EMISSION PROBLEM, THAT HAS HAPPENED TO MANY OTHER CONSUMERS? I FEEL TOYOTA SHOULD STEP UP AND REPLACE PART AT NO COST TO OWNER, THE CAR IS TOO NEW TO HAVE PROBLEMS. *NM
Air bags, Oct 26, 2006, crash
DT*: THE CONTACT STATED WHILE DRIVING 45 MPH TOWARD AN INTERSECTION, THE CONTACT FELT LIGHTHEADED, AND COLLIDED WITH AN IMMOBILE VEHICLE AT THE STOP SIGN. THE CONTACT DEPRESSED THE BRAKES, PRIOR TO THE COLLISION, BUT WAS UNABLE TO AVOID THE ACCIDENT. THE AIR BAGS DID NOT DEPLOY, HOWEVER THE SEAT BELT RESTRAINED THE CONTACT. THERE WERE NO WARNING LIGHTS ILLUMINATED PRIOR TO THE ACCIDENT. THE CONTACT SUFFERED A STRAINED NECK. THE POLICE AND FIRE DEPARTMENT WERE PRESENT BUT THE CONTACT REFUSED TO BE TAKEN TO A HOSPITAL. A POLICE REPORT WAS TAKEN. THE OWNER'S MANUAL STATED THE AIR BAGS SHOULD DEPLOY AT A MINIMUM OF 25 MPH. THE POLICE OFFICER ORDERED THE VEHICLE NOT TO BE DRIVEN BECAUSE THE AIR BAGS COULD SUDDENLY DEPLOY. THE VEHICLE WAS TOWED TO A BODY SHOP TO BE LATER BE INSPECTED BY THE INSURANCE COMPANY. THE DEALERSHIP AND THE MANUFACTURER WOULD BE CONTACTED.
Suspension, Oct 16, 2006
DT*: THE CONTACT STATED HAVING PROBLEMS WITH THE VEHICLE'S REAR RIGHT AXLE WHILE DRIVING 55 MPH. PRIOR TO THE INCIDENT, THE REAR RIGHT TIRE WAS WEARING OUT ABNORMALLY AND WAS REPLACED AND ALIGNED FOUR TIMES. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR A DIAGNOSIS TO REPAIR THE REAR RIGHT AXLE. AFTER THE REPAIRS WERE MADE, THE PROBLEM PERSISTED. THE CONTACT AFFIRMED THAT WHEN THE BRAKES WERE FULLY DEPRESSED, VEHICLE CONTROL COULD NOT BE COMPLETELY MAINTAINED, AND THERE WAS NOT SUFFICIENT STABILITY POWER.*AK
Engine and engine cooling, Oct 2, 2006
2004 TOYOTA COROLLA DRIVE BELT CRACKED AT ABOUT 5K MILES I HAVE A 2004 COROLLA WHICH IS MAINTAINED REGULARLY AT DARCARS TOYOTA OF SILVER SPRING, MARYLAND. WHEN I HAD MY CAR OIL CHANGED AT MILEAGE 53200, THE SERVICE REPRESENTATIVE TOLD AND SHOWED ME THAT MY CAR'S DRIVE BELT HAS MANY, MANY CRACKS ON IT. THEY TOLD ME I NEED TO REPLACE IT WITH A NEW BELT AND WILL BE CHARGED $210. TOYOTA OFFICIALLY RECOMMENDS AN INITIAL INSPECTION OF DRIVE BELT AT 60K/72 MONTHS, 15K THEREAFTER. IT MEANS BEFORE 60K MILES THERE SHOULD BE FINE. I SENT AN EMAIL TO TOYOTA AND ASKED THEM IF MY CAR HAS A QUALITY PROBLEM. IN THEIR REPLY, THEY REFUSED TO ANSWER MY QUESTION. TOYOTA IS FAMOUS FOR THEIR VEHICLE EXCELLENT QUALITY, BUT IT LOOKS NOT IN MY CASE. *NM
Power train, Sep 25, 2006
MY DAUGHTER WAS DRIVING HER 2004 TOYOTA COROLLA FROM SAN DIEGO TO DALLAS. ABOUT 60 MILES EAST OF YUMA, AZ THE MANUAL TRANSMISSION WENT OUT IN THIS CAR. HAD TO HAVE IT TOWED BACK TO YUMA AND A WHOLE NEW TRANSMISSION REPLACED BECAUSE THE TRANSMISSION HAD GROUND ITSELF TO PIECES AND THERE WERE PIECES OF THIS IN THE TRANSMISSION PAN. WE HAD TO PAY $3000 FOR A NEW TRANSMISSION. WE DO NOT BELIEVE A 3 YEAR OLD TOYOTA WITH A MANUAL TRANSMISSION SHOULD GO OUT AT 75,000 MILES. *NM
Engine and engine cooling, Electrical system, Aug 13, 2006
MY CAR ON AN INTERMITTENT BASIS WILL NOT START AS WELL.....THERE IS NO CRANKING WHATSOEVER. ALTHOUGH UPON TURNING THE KEY ALL THE LIGHTS ON THE DASHBOARD LIGHT UP IN A NORMAL MANNER, THERE IS ABSOLUTELY NO SOUND FROM THE ENGINE. AFTER EITHER A FEW TRIES OR ROLL STARTING THE VEHICLE (MANUAL TRANSMISSION)....IT WILL START. I BROUGHT IT TO THE DEALER ONCE AND THEY ORIGINALLY THOUGHT IT WAS THE BATTERY, THEN THE STARTER *WHICH THEY PROCEEDED TO REPLACE, THEN AFTER A FEW DAYS THE SAME PROBLEM OCCURRED AGAIN....I AM BRINGING IT BACK TO THE DEALER. *JB
Equipment, Aug 9, 2006
A/C FAILED, STOPPED COOLING, THE CLUTCH IS INOPERATIVE, A/C CLUTCH DOES NOT ENGAGE. *NM
Fuel system, Gasoline, Jul 31, 2006
DT*: THE CONTACT STATED THAT THE GAS FILLER TUBE HAD RUST DUE TO DEFECTIVE MATERIAL. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO COATED THE FILLER TUBE WITHOUT REMOVING THE RUST. THE CONTACT EXPRESSED CONCERN ABOUT THE REPAIR PERFORMED BECAUSE THE RUST COULD DETERIORATE THE TUBE WHICH COULD RESULT IN A GAS LEAK.
Air bags, Jul 30, 2006, crash
I WAS DRIVING MY 2004 TOYOTA COROLLA AND WAS INVOLVED IN A FRONT END COLLISION AND THE AIRBAG DID NOT DEPLOY. *JB
Tires, Jun 26, 2006
DT*: THE CONTACT STATED WHILE DRIVING ON NORMAL ROAD CONDITIONS THE TIRE WALL BECAME TOTALLY DETROYED PRESENTING SLASHES THREE INCHES LONG IN THE SIDE WALLS. THE TIRE WAS BEYOND REPAIR. THE SAME INCIDENT OCCURRED ONE YEAR PRIOR.
Electrical system, Apr 17, 2006
MY CAR ON AN INTERMITTENT BASIS WILL NOT START AFTER TURNING THE KEY IN THE IGNITION. THERE IS NO CRANKING WHATSOEVER. AFTER SEVERAL ATTEMPTS OF TURNING THE KEY, THE CAR FINALLY STARTED. I TOOK THE CAR TO THE DEALERSHIP ON THE FIRST INCIDENT AND THE NOTHING WRONG COULD BE DETECTED. IN APRIL 2006, IT HAS OCCURRED AGAIN AS THE CAR WILL NOT START UNTIL SEVERAL ATTEMPTS OF TURNING THE KEY IN THE IGNITION. I AM TAKING THE CAR TO DEALERSHIP AGAIN ON MONDAY, APRIL 17TH, 2006 TO FIND OUT WHAT IS THE MATTER WITH THE CAR. *NM
Vehicle speed control, Mar 27, 2006, crash
DT*: THE CONTACT STATED WHILE PLACING THE ENGINE INTO DRIVE, THE ENGINE REVVED HIGH AND THE VEHICLE SUDDENLY ACCELERATED. THE BRAKE PEDAL WAS DEPRESSED WHEN THE VEHICLE CRASHED INTO A BRICK GARAGE WITH NO PRIOR WARNING. THE VEHICLE SUSTAINED DAMAGE TO THE FRONT WITH ADDITIONAL DAMAGE TO THE GARAGE. THE POLICE WERE NOT CONTACTED SINCE THIS HAPPENED ON PRIVATE PROPERTY. THE VEHICLE REMAINS AT THE SCENE OF THE INCIDENT AND HAS NOT BEEN INSPECTED.
Vehicle speed control, Mar 9, 2006, crash
DROVE CAR TO WORK ON DAY OF ACCIDENT WITH NO INCIDENTS. PARKED VEHICLE FOR ABOUT 5 HOURS THEN DROVE IT AGAIN FOR ABOUT 1 HALF HOUR THEN PARK. AT 5:00 P.M. LEFT THE OFFICE TO GO HOME. ON THE WAY HOME I MADE TOW STOPS, ONE AT THE POST OFFICE AND ANOTHER AT MY SISTER'S HOUSE. UPON LEAVING MY SISTER'S, I PROCEED TO GO UP HILL. WHEN I GOT TO THE TOP OF THE HILL WITH MY FOOT ON THE BRAKE PEDAL I PROCEEDED TO PUT THE VEHICLE IN LOW GEAR AS I AM ACCOUSTOMED TO WHEN GOING DOWN A HILL WHICH I WAS ABOUT TO DO. AS I PUT THE VEHICLE IN GEAR, IT ACCELERATED TO TOP SPEED GOING DOWN THE HILL. I LOOKED DOWN TO MAKE SURE MY FOOT WAS ON THE BRAKE PEDAL...IT WAS. THE VEHICLE BEGAN RACING DOWN HILL. I APPLIED THE EMERGENCY BRAKES BUT IT DID NOT HOLD. I DECIDED TO TRY TO STEADY THE VEHICLE WITH BOTH HANDS ON THE STEERING WHEEL AS I LOST CONTROL OF THE VEHICLE TO NO AVAIL. I CRASHED INTO A PARKED VEHICLE BOUNCED FROM SIDE TO SIDE THEN HIT A BUMP IN THE ROAD AND BECOME AIRBORNE. THE VEHICLE DROPPED IN A DITCH BOUNCED AGAIN THEN CRASHED INTO A DIRT EMBANKMENT ON THE OTHER SIDE OF THE STREET AT WHICH TIME BOTH THE DRIVER'S AND PASSENGER'S AIRBAGS DEPLOYED. ON JANUARY 6, 2006 I TOOK THE VEHICLE TO THE TOYOTA DEALER HERE ON ISLAND FOR FULL SERVICE. THE FRONT BRAKES WERE CHANGED AS INDICATED ON MY WORK ORDER AND THE BACK BRAKES WERE CLEANED AND ADJUSTED. ON MARCH 6, 2006, I WENT IN TO THE SERVICE DEPARTMENT TO REPORT THE ACCIDENT DESCRIBING WHAT HAPPENED. I WAS TOLD THAT THE BRAKES WERE NOT THE PROBLEM. WHEN I ASKED WHAT WOULD CAUSE THE VEHICLE TO DO SOMETHING LIKE THAT, THEY TOLD ME THEY DID NOT KNOW AND THAT THEY WOULD HAVE A SPECIALIST FROM PUERTO RICO FLY IN TO LOOK AT THE VEHICLE. I AM WAITING TO HEAR FROM THEM. *NM
Other or unspecified, Mar 7, 2006
I HAVE HAD MY CAR FOR 2 YEARS NOW, EVERY TIME I TAKE THE CAR INTO THE DEALER I SHOW THEM THE GAP AND THE WARPING UP OF THE CONSOLE ABOVE THE RADIO. STILL UNTIL THIS DAY, THEY SAY THERE IS NOTHING THAT CAN BE DONE. IT HAS BEEN GETTING WORSE AND MORE OF THE TOP CONSOLE IS POPPING UP CAUSING A RATTLING NOISE. I ALSO SMELL THAT BAD EGG/ SULFUR SMELLING ORDER WHEN I USE THE AC OR THE HEAT. I AM SURE THIS CANT BE GOOD FOR ANYONE'S HEALTH. SOMETHING NEEDS TO BE DONE WITH BOTH OF THESE COMPLAINTS. FACTORY RECALL? *JB
Air bags, Jan 30, 2006, crash
I WAS DRIVING MY 2004 COROLLA THROUGH AN INTERSECTION, WHEN ANOTHER VEHICLE TURNED IN FRONT OF ME. WE COLLIDED. I WAS TRAVELING APPROXIMATELY 40 MPH BEFORE I STARTED BRAKING A COUPLE MOMENTS BEFORE IMPACT, SO I IMAGINE I WAS GOING AT LEAST 30-35 AT THE TIME OF IMPACT. SEVERE DAMAGE TO THE FRONT LEFT CORNER OF MY VEHICLE; IT WAS UNDRIVEABLE AFTER. COMPLAINT: NO AIRBAGS DEPLOYED IN MY COROLLA! THE OTHER CAR WAS GOING LESS THAN 10 MPH WHEN OUR CARS COLLIDED, BUT HER AIRBAGS DEPLOYED. THE TOYOTA WEBSITE SAYS THAT AIRBAGS WON'T DEPLOY UNLESS IT IS A "SEVERE FRONTAL COLLISION". WHAT QUALIFIES AS "SEVERE"? NO RESPONSE YET FROM TOYOTA DEALER.
Suspension, Wheels, Jan 22, 2006
MY CAR HAS BEEN MAKING A LOUD NOISE, ESPECIALLY WHEN DRIVING OVER 40 MPH. I TOOK IT TO THE DEALERSHIP AND I WAS TOLD THE CAR NEEDS A REPLACED REAR WHEEL, BEARING, AND HUB. MY CAR IS A 2004 WITH ONLY 40,000 MILES. I'VE SEEN THAT THERE WAS A RECALL FOR 2002 COROLLAS WITH A SIMILAR PROBLEM. *JB
Fuel system, Gasoline, Vehicle speed control, Jan 11, 2006
WHEN PARKING THE CAR THE CAR ATTEMPTED TO ACCELERATE ON ITS OWN. I LOOKED DOWN TO MAKE SURE MY FOOT WAS NOT ON THE GAS - MY FOOT WAS PLANTED ON THE BRAKE. I HAD TO BRAKE AS HARD AS A I COULD TO KEEP THE CAR FROM REAR ENDING THE VEHICLE IN FRONT AS THE ENGINE ALL ON ITS OWN DRAGGED THE CAR FORWARD. THE CAR WAS MOVING AT ABOUT TWO MILES AN HOUR WHEN THIS TOOK PLACE. THE ENGINE REVVED UP TO 4000 RPMS WITHOUT ANY PRESSURE ON THE GAS AND SIMPLY DRAGGED THE CAR FORWARD. *JB
Vehicle speed control, Dec 14, 2005
MY HUSBAND WAS DRIVING MY 2004 COROLLA-S. HE HAD THE CRUISE CONTROL SET FOR 75 MPH. I LOOKED DOWN AT THE SPEEDOMETER BECAUSE IT SEEMED HE WAS SPEEDING UP AND NOTICED THE SPEED AT 90 MPH. HE COULDN'T TAKE IT OFF CRUISE CONTROL SO HE HIT THE BRAKES AND A SHORTLY AFTER THE CRUISE CONTROL LIGHT CAME OFF. WE DID START SLOWING DOWN WHEN HE USED THE BRAKES. *JB
Visibility, Oct 8, 2005
I WAS DRIVING A TOYOTA 2004 COROLLA ON THE HIGHWAY @ 60 MPH. ALL THE CAR WINDOWS WERE OPEN. THERE WERE NO OTHER CARS/TRUCKS NEAR THE CAR. I PUSHED THE BUTTON TO CLOSE THE WINDOWS. THE DRIVER SIDE WINDOW WENT UP TO APPROX. 6" FROM THE TOP OF THE WINDOW AND STOPPED. I PUSHED THE BUTTON TO TURN IT DOWN. THE WINDOW RETURNED DOWN. I AGAIN PUSHED THE BUTTON TO CLOSE THE WINDOW. AS THE WINDOW WAS RAISED TO APPRROX 6" FROM THE TOP, THE GLASS EXPLODED. I DROVE DIRECTLY TO THE TOYOTA DEALER WHO SAID SOMETIMES THIS HAPPENS AND WAS NOT ABLE TO GIVE A REASON FOR THE OCCURRENCE. THE WINDOW WAS REPLACED. I AM AFRAID TO TOUCH THE WINDOW AS WHEN THE GLASS EXPLODED, MY HAND WAS CUT, SOME OF THE GLASS WAS IN MY LAP. I WAS WEARING SUNGLASSES WHICH I THINK PROVIDED SOME PROTECTION. WHEN I SAW THE BACK OF THE CAR THERE WAS GLASS ON THE FLOOR AND BACK SEAT. FORTUNATELY, I DIDN'T PANIC WHEN THE GLASS EXPLODED. I AM FRIGHTENED TO THINK OF THE SERIOUS CONSEQUENCES IF I DID. ARE THERE ANY REASONS FOR THIS TYPE OF OCCURRENCE? THERE WASN'T ANY UNUSUAL SOUND WHEN I PUSHED THE WINDOW BUTTONS. IS THERE A PROBLEM W THE TOYOTA 2004 COROLLA? THANK YOU FOR YOUR HELP. *JB
Steering, Sep 13, 2005
I WAS DRIVING DOWN THE HIGHWAY AND MY CAR SUDDENLY SWERVED/VEERED AND I HAD TO FIGHT FOR CONTROL OF THE VEHICLE. I BARELY AVOIDED HAVING AN ACCIDENT. IT HAD RAINED THE NIGHT BEFORE BUT WAS NOT RAINING WHEN THIS OCCURRED. THIS IS THE THIRD TIME THAT THIS HAS HAPPENED SINCE I BOUGHT THE CAR IN JANUARY 2004. THE SECOND TIME THIS HAPPENED, IT WAS A SUNNY DAY THIS SUMMER. I WAS ON A CITY STREET AND AGAIN DRIVING STRAIGHT WHEN THE CAR SUDDENLY SWERVED. I HAD A PASSENGER IN THE CAR WITH ME. THE FIRST TIME WAS IN THE SPRING OF 2004, A COUPLE OF MONTHS AFTER I BOUGHT THE CAR. I WAS ON THE FREEWAY. I HAD JUST COMPLETED A LANE SWITCH AND WAS GOING STRAIGHT WHEN THE CAR SWERVED/VEERED. I ALMOST COLLIDED WITH THE MEDIAN. AFTER THIS THIRD OCCURRENCE, I KNEW THERE WAS SOMETHING WRONG WITH THE CAR. I MADE AN APPOINTMENT WITH THE DEALERSHIP I BOUGHT THE CAR FROM AND BROUGHT IT IN. AFTER A 5 MINUTE ROAD TEST, THE DEALER SAID THAT THEY COULDN'T REPLICATE THE PROBLEM I WAS DESCRIBING. THE DEALER TOLD ME IF I WANTED TO PAY FOR AN INSPECTION, THEY CAN FURTHER INSPECT THE CAR TO SEE WHAT WAS WRONG WITH IT. I ASKED THEM TO GO AHEAD BECAUSE I DIDN'T WANT TO GET INTO AN ACCIDENT AS A RESULT OF THIS PROBLEM. THE DEALER JUST CALLED AND INFORMED ME THAT AFTER A 15 MINUTE INSPECTION, THEY DID NOT SEE ANYTHING OUT OF THE ORDINARY. MY PROBLEM IS SIMILAR TO THAT IN COMPLAINT #10127778. PLEASE LOOK INTO THE PROBLEM. *JB