2006 Toyota Corolla
Problems, recalls and owner-reported issues
Air bags is the leading concern among 903 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Corolla model years with reports.
Of the 2006 reports, 120 involved a crash and 9 involved a fire. 94 people were injured.
What owners report most often
Recalls and investigations
Air bags, frontal, passenger side, inflator moduleOct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Campaign 19V741000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleAug 28, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2003-2008 Corolla, 2005-2008 Corolla Matrix, and Pontiac Vibe vehicles equipped with a front passenger air bag assembly replaced under a prior recall. The air bag may not unfold as designed during inflation under high temperature conditions, possibly resulting in the air bag not inflating properly.
An improperly inflated air bag increases the risk of injury during a crash.
Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag assembly or sub-assembly, free of charge. Toyota owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall are K1Q and K0Q. Pontiac owners may contact GM customer service at 1-800-762-2737. GM's number for this recall is N192273760.
Campaign 19V627000 on NHTSA.gov
Air bagsMay 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.
In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.
Campaign 15V286000 on NHTSA.gov
Air bagsMay 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.
In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.
Campaign 15V285000 on NHTSA.gov
Engine and engine coolingAug 26, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2008 COROLLA AND COROLLA MATRIX VEHICLES. THE ENGINE CONTROL MODULE (ECM) FOR THE SUBJECT MODELS EQUIPPED WITH THE 1ZZ-FE ENGINE AND TWO-WHEEL DRIVE MAY HAVE BEEN IMPROPERLY MANUFACTURED. THERE IS A POSSIBILITY THAT A CRACK MAY DEVELOP AT CERTAIN SOLDER POINTS OR ON VARISTORS ON THE CIRCUIT BOARD.
THERE ARE A VARIETY OF WARNINGS AND CONSEQUENCES ASSOCIATED WITH THE DEFECT. THE ENGINE WARNING LAMP COULD BE ILLUMINATED, HARSH SHIFTING COULD RESULT, THE ENGINE MAY NOT START, OR THE ENGINE COULD SHUT OFF WHILE THE VEHICLE IS BEING DRIVEN. AN ENGINE SHUTOFF WHILE THE VEHICLE IS BEING DRIVEN INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE PRODUCTION NUMBER OF THE ECM AND REPLACE THE ECM IF NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. TOYOTA WILL MAIL AN INTERIM OWNER NOTIFICATION THE MIDDLE OF SEPTEMBER 2010 TO ADVISE OWNERS OF THIS DEFECT AND RECALL. THIS INTERIM NOTIFICATION WILL INFORM OWNERS THAT THEY WILL RECEIVE A FUTURE NOTIFICATION WHEN PARTS BECOME AVAILABLE TO HAVE THE FREE REMEDY PERFORMED ON THEIR VEHICLE. THE SAFETY RECALL BEGAN ON NOVEMBER 29, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 10V384000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Representative owner complaints: service brakes
37 reports, newest first. Show all
Service brakes, Hydraulic, Vehicle speed control, Aug 26, 2010, crash
TL* THE CONTACT OWNS A 2006 TOYOTA COROLLA. THE CONTACT STATED THAT THE VEHICLE ABNORMALLY ACCELERATED CAUSING THE CONTACT TO BE INVOLVED IN A CRASH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE REPAIRS WERE MADE TO THE BODY DAMAGE HOWEVER, THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE CONTACT EXPERIENCED THE FAILURE TWO MORE TIMES AND CONTACTED THE MANUFACTURER WHO ADVISED THAT THE THROTTLE BODY WOULD NEED REPLACING. IN ADDITION, THE CONTACT STATED THAT THE TIRES EXHIBITED PREMATURE WEAR AND THE BODY PAINT BEGAN TO PEEL PREMATURELY. THE TIRES WERE REPLACED AND A COMPLAINT WAS FILED WITH THE MANUFACTURER. THE CONTACT STATED THAT THE BRAKES WERE ALSO DEFECTIVE. LATER, THE VEHICLE WAS INSPECTED BY THE MANUFACTURER'S ENGINEERS AND WAS ADVISED THAT THERE WERE NO FAILURES FOUND WITHIN THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 200 AND THE CURRENT MILEAGE WAS APPROXIMATELY 35,000.
Service brakes, Hydraulic, Air bags, Aug 16, 2010, crash, fire
TL* THE CONTACT OWNS A 2006 TOYOTA COROLLA. THE CONTACT WAS DRIVING 55 MPH WHEN THE BRAKES FAILED. THE CONTACT CRASHED INTO THE VEHICLE AHEAD OF HER. THE CONTACT STATED SHE DEPRESSED THE BRAKE PEDAL TO THE FLOOR BUT THE BRAKES FAILED TO OPERATE. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE AHEAD OF HER WAS FLIPPED AND LANDED UPSIDE DOWN. THERE WAS SMOKE COMING FROM THE FRONT OF THE CONTACT'S VEHICLE. A POLICE REPORT WAS AVAILABLE. THE CONTACT WAS REMOVED FROM THE VEHICLE WITH THE ASSISTANCE OF THE FIRE DEPARTMENT. SHE SUSTAINED INJURIES TO THE NECK AND BACK WITH ADDITIONAL BRUISING. THE VEHICLE WAS DESTROYED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Service brakes, Hydraulic, Structure, Vehicle speed control, Tires, Jun 29, 2010, crash
TL* THE CONTACT OWNS A 2006 TOYOTA COROLLA EQUIPPED WITH GOODYEAR ALL SEASON TIRES. THE CONTACT STATED WHILE SITTING IDLE WITH THE BRAKES DEPRESSED, THE VEHICLE ABNORMALLY ACCELERATED RESULTING IN A CRASH. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT WAS NOT EXAMINED FOR THE CAUSE OF FAILURE. REPAIRS WERE MADE TO THE BODY DAMAGE ONLY. THE FAILURE CONTINUED TO RECUR INTERMITTENTLY AND THE VEHICLE WAS TAKEN BACK TO THE DEALER APPROXIMATELY THREE TIMES WHERE AN UNKNOWN SERVICE WAS PERFORMED ON THE THROTTLE. THE FAILURE DID NOT RECUR SINCE THE THROTTLE REPAIR. IN ADDITION, THE CONTACT STATED THAT THE TIRES WERE WEARING PREMATURELY. THE DEALER CONFIRMED THAT THE TIRES EXHIBITED PREMATURE WEAR. THE TIRES WERE REPLACED AND THE FAILURE DID NOT RECUR. THE CONTACT ALSO STATED THERE WAS AN UNUSUAL INCREASE IN BRAKING DISTANCE AND IN ORDER TO STOP THE VEHICLE, HE WOULD HAVE TO APPLY STEADY, REPEATED PRESSURE ON THE BRAKES BEFORE THEY WOULD ENGAGE. THE FAILURE MILEAGE WAS 200 AND THE CURRENT MILEAGE WAS 34,000.
Service brakes, Hydraulic, Jun 16, 2010
ABS SYSTEM ON 2006 TOYOTA COROLLA TRIGGERS TOO EASILY AND WHEN IT DOES ACTIVATE PROVIDES LITTLE OR NO BRAKING FORCE. PROBLEM CAN BE REPRODUCED ON COBBLESTONE OR BROKEN PAVEMENT AS WELL AS ON SNOW COVERED SURFACES. OTHER CARS WITH ABS DRIVEN OVER SAME SURFACE DO NOT TRIGGER ABS. I'VE DRIVEN MANY CARS WITH ABS AND BEHAVIOR OF THIS CAR DOES MATCH ANY OF THOSE. TWO PROBLEMS HERE 1- ABS TRIGGERING TOO EASILY AND 2- NO BRAKING FORCE WHEN IT DOES. ONLY REMEDY IS TO PUMP BRAKES IN THIS SCENARIO TO RESET BRAKES AND GET SOME BRAKING BACK. COWORKER HAS ;08 COROLLA WITH SAME PROBLEM. DEALER TOLD THEM, MAYBE HE DROVE THROUGH A PUDDLE. REALLY? AREN'T CARS TO BE DRIVEN IN THE RAIN ANYMORE? INTERNET IS LITTERED WITH SIMILAR REPORTS. NEED SOME FOCUS BY NHTSA AND TOYOTA ON THIS PROBLEM. NO BRAKING POWER IS A SERIOUS SAFETY PROBLEM. *TR
Service brakes, Hydraulic, Mar 3, 2010
I DROVE MY 2006 TOYOTA COROLLA AND THE BRAKE NOT WORKING WHEN I TRIED TO MAKE A TURN ON A SNOWY AND ICY ROAD AND ALMOST HIT BY INCOMING CARS. WE FOUND OUT THE BRAKES MAY HAVE ISSUES ESP IN THE WINTER AFTER WE BOUGHT IT BRAND NEW IN 2006. IT IS SAD TO SEE ALL THE RECALLS ARE FOR NEWER MODELS, BUT I WOULD BELIEVE SIMILAR ISSUES DO EXIST IN THE EARLIER MODELS SINCE THEY FOLLOW THE SIMILAR IF NOT SAME DESIGN IN BRAKES. ONE BIG REASON THEY DON'T PUSH FOR THOSE OLDER CARS WILL BE THE COST, BUT HOW ABOUT THE COST OF LIVES? WE WILL NEED HELP TO FIX THE ISSUE. *TR
Steering, Service brakes, Hydraulic, Electrical system, Air bags, Vehicle speed control, Feb 23, 2010, crash
TL*THE CONTACT OWNS A 2006 TOYOTA COROLLA. THE CONTACT STATED WHILE DRIVING 35 MPH THE VEHICLE SUDDENLY ACCELERATED AND CRASHED INTO ANOTHER VEHICLE. THE CONTACT SUFFERED MINOR INJURIES. THE CONTACT STATED THAT THE ACCELERATOR PEDAL BECAME STUCK AND CAUSED THE VEHICLE TO SUDDENLY ACCELERATE. THE FAILURE MILEAGE WAS 59,276. UPDATED 05/20/10. *LJ THE CONSUMER ALSO STATED THE AIR BAGS FAILED TO DEPLOY. UPDATED EVOQ 05/27/10 THE CONSUMER STATED THE ENGINE CONTROL MODULE WAS REPLACED IN 2008 DUE TO THE CHECK ENGINE LIGHT ILLUMINATING. UPDATED 06/01/10. *JB UPDATED 09/29/10 THE CONSUMER ALSO STATED THE STEERING MECHANISM AND BRAKE FAILED ON THE VEHICLE. UPDATED 12/06/10 UPDATED 12/28/10.*JB
Service brakes, Hydraulic, Feb 15, 2010
MY 2006 TOYOTA COROLLA DOES THE FOLLOWING WHEN BRAKING, IF A POTHOLE(S) OR BUMP(S) IN THE ROAD IS HIT (WHILE BRAKING AT THE SAME TIME), THE CAR FAILS TO SLOW DOWN OR STOP UNTIL THE AREA OF THE POTHOLES OR BUMPS IS PASSED. THE BRAKE PEDAL JERKS FORWARD AS IT APPEARS THAT THE BRAKES ARE FAILING TO ENGAGE OR DOES ITS JOB OF SLOWING OR STOPPING THE VEHICLE. I HAVE EXPERIENCED THIS PROBLEM MANY TIMES SINCE DAY ONE, BUT I THOUGHT THAT IT'S A SUSPENSION PROBLEM. *TR
Service brakes, Hydraulic, Feb 10, 2010, crash
THE FOLLOWING DESCRIPTION IS FROM A NARRATIVE WRITTEN WITHIN 3 HOURS AFTER THE ACCIDENT. AROUND 5:30PM ON 12/10/2008 I WAS DRIVING HOME AROUND 2-3 MILES PER HOUR DUE TO TRAFFIC CONGESTION. THE SKY WAS DARK AND IT WAS LIGHTLY RAINING. THE TEMPERATURE WAS AROUND 60-65 DEGREES FAHRENHEIT, SO ICE WAS NOT PRESENT ON THE ROAD. THE LARGE SEMI TRUCK DIRECTLY AHEAD OF ME SLOWED DOWN TO A STOP, SO I ATTEMPTED TO BRAKE. MY BRAKES DID NOT SEEM TO HAVE AN EFFECT, SO I PUSHED ON THE BRAKES HARDER. THE BRAKES STILL HAD NO EFFECT. I IMMEDIATELY SHIFTED THE CAR INTO THE 'PARK' GEAR AND APPLIED THE EMERGENCY BRAKE. NEITHER THE SHIFTING THE GEARS NOR THE EMERGENCY BRAKE HAD ANY EFFECT ON THE CAR'S MOTION, MY CAR KEPT MOVING FORWARD. I EVENTUALLY STOPPED WHEN I SMASHED INTO THE BACK OF THE TRUCK, WHICH CAUSED ABOUT $5K OF FRONT END DAMAGE FOR MY CAR AND NO APPARENT DAMAGE TO THE TRUCK. THE TIME BETWEEN WHEN I NOTICED THE CAR WAS NOT STOPPING TO WHEN MY CAR HIT THE TRUCK WAS AROUND 2-3 SECONDS. AFTER THINKING ABOUT THESE EVENTS AFTERWARD, I DIDN'T REMEMBER HEARING THE TRANSMISSION GRIND DUE TO THE FACT THE CAR WAS IN THE 'PARK', BUT CONTINUED TO MOVE FORWARD. AFTER THE COLLISION, THE TRUCK AHEAD OF ME LEFT AS IF NOTHING HAD HAPPENED. MY CAR STAYED STATIONARY NOW THAT ITS MOMENTUM WAS LOST. I SHIFTED THE CAR BACK INTO 'DRIVE' AND SLOWLY DROVE HOME (AROUND 20-25 MPH). THE BRAKES WORKED LIKE NORMAL AND I DIDN'T HEAR ANY NOISE WHEN I APPLIED THE BRAKES. I TOOK THE CAR INTO THE DEALERSHIP ON 01/10/2009. THE MECHANIC INSPECTED THE CAR AND FOUND THE BRAKES WERE IN 'NORMAL WORKING CONDITION'. THE MECHANIC HYPOTHESIZED THAT THE CAUSE FOR THE BRAKE FAILURE WAS EITHER THE BRAKE FLUID OVERHEATED OR DRIVER ERROR. HOWEVER, THERE WAS NO EVIDENCE TO SUPPORT EITHER HYPOTHESIS. NO REPAIR WAS RECOMMENDED AND NO PARTS WERE REPLACED. I AM CONFIDENT I DEPRESSED THE BRAKES AND NOT THE ACCELERATOR, SO I SUSPECT THERE MIGHT BE SOME OTHER PROBLEM WITH MY BRAKES. THE BRAKES HAVE NOT FAILED SINCE THIS INCIDENT. *TR
Service brakes, Hydraulic, Jun 8, 2007
DAUGHTER DRIVING, SMELLED AND SAW SMOKE, RIGHT FRONT TIRE AREA. TWO DAYS LATER, SAME PROBLEM, RIGHT SIDE BRAKE DRAG. TOWED TO DEALER. TOLD ME NOT COVERED UNDER WARRANTY BECAUSE SOME ONE PUT MOTOR OIL IN THE BRAKE FLUID. WENT THERE. TECH PUT FINGER IN RESERVOIR, MOTOR IS IN IT, SYSTEM IS CONTAMINATED. THE COST IS 1,300 OR MORE TO REPLACE EVERYTHING. IT DOESN'T LOOK CONTAMINATED TO ME. I GOT SAMPLES, TOP, BOTTOM OF RESERVOIR, FRONT RIGHT BLEEDER, LEFT REAR BLEEDER. OTHER THAN THE TOP SAMPLE FROM RESERVOIR WHICH WAS TAKEN USING A DIRTY BATTERY TESTER, ALL OTHER SAMPLES LOOK GOOD. TOOK SAMPLE FROM ANOTHER CAR IN SERVICE AREA WITH BATTER TESTER WHICH HAD BLACK SPECKS COMING OUT PROBABLY BECAUSE BRAKE FLUID ATE AT RUBBER. AFTER TAKING 3 OR 4 TUBE FULL AND THROWING THEM AWAY THE BLACK SPECKS WENT AWAY AND GOT THE SAMPLE. THIS SAMPLE WAS TAKEN BY THE OPERATION MANAGER. SAMPLES OF FRONT/RIGHT, REAR/LEFT, BOTTOM OF M/C WHERE DONE BY TECH AS I HELD BOTTLE. ALL DONE IN FRONT OF THE MANAGER. SAID IT WAS THE M/C THAT WAS CAUSING THE BRAKE TO HOLD PRESSURE. I ASK HOW CAN IT BE ONLY ON ONE SIDE? IF THE PRESSURE IS AT M/C WHY AREN'T BOTH WHEELS DRAGGING OR LOCKING UP? I TOOK SAMPLE TO TECH AT ANOTHER DEALER (NOT A TOYOTA DEALER) HE SAID THERE IS NOTHING WRONG WITH BRAKE FLUID AND TOOK TEST FOR CONTAMINATION WITH FAST STRIP TESTING. ALL WERE GOOD. HE ALSO SAID THAT M/C NOT PROBLEM. THIS IS A NON ABS SYSTEM AND WORKS PRETTY SIMPLE. CALLED TOYOTA CUSTOMER EXPERIENCE 3 TIMES TO TALK TO TOYOTA REP, DEALER AND TOYOTA REFUSED ACCESS TO REP. THE DEALER GAVE ME THIS CHOICE... WE WILL DO YOU A FAVOR AND REPLACE THE M/C AT NO COST, HOWEVER IF ANY OTHER PROBLEMS IT WILL BE CONSIDERED CONTAMINATED AND YOU WILL HAVE TO PAY. WE ALREADY KNOW THE FRONT RIGHT WAS HEATED BEYOND A SAFE HEAT TEMPERATURE WHICH WILL CAUSE PROBLEMS. THIS PUTS ME IN A NO WIN SITUATION WITH THE DEALER AND TOYOTA! IF ANYONE ELSE HAS THIS PROBLEM PLEASE REPORT
Service brakes, Hydraulic, Electrical system, Equipment, Mar 14, 2007
I PURCHASED A 2006 TOYOTA COROLLA CE ON 06-26-06. ON 02-05-07 VEHICLE WOULD NOT START. AFTER SEVERAL ATTEMPTS IT STILL DIDN'T START. I CALLED THE LOCAL TOYOTA DEALERSHIP AND HE TOLD ME TO GET A JUMP OFF BECAUSE IT WAS THE BATTERY DUE TO THE COLD WEATHER. I GOT A JUMP OFF AND IT STILL WOULD START. I CALLED THE DEALERSHIP BACK AND HE TOLD ME TO CALL A TOW TRUCK. I DID THAT AND IT WAS TOWED TO THE DEALERSHIP. WE NEEDED ALL KEYS TO SEE IF IT WAS THE KEYS AND IT WASN'T. HE THOUGHT IT WAS BAD GAS AND IT WASN'T. THEN HE SAID IT WAS THE COMPUTER. THE COMPUTER WAS REPLACED AND I STILL HAVE TROUBLE CRANKING IT NOW. I WOULD TURN THE KEY AND IT WOULDN'T DO ANYTHING. AFTER SEVERAL ATTEMPTS, IT WOULD CRANK. BEFORE THIS INCIDENCE, IN JULY 2006, NOT EVEN A MONTH AFTER GETTING THE VEHICLE, MY BRAKES STARTED SQUEALING AND THEY STILL DO NOW. THE ROTOR WAS DEFECTIVE AND REPLACED. EACH TIME I TAKE IT FOR SERVICING, I'M TOLD THERE'S NOTHING WRONG WITH THE BRAKES. I FILED A COMPLAINT WITH TOYOTA CUSTOMER RELATIONS WITH NO RESPONSE. NOW I'VE FILED A COMPLAINT WITH THE NATIONAL CENTER FOR DISPUTE SETTLEMENT. *JB
Service brakes, Hydraulic, Jan 18, 2007
TL*- THE CONTACT STATED THAT WHILE DRIVING HER 2006 TOYOTA COROLLA (200 FAILURE MILEAGE) AT 25 MPH SHE CAME TO RED LIGHT. THE CONTACT APPLIED THE BRAKES WHICH SLOWED THE VEHICLE DOWN, BUT DID NOT COME TO A COMPLETE STOP. THE CONTACT ALSO STATED THAT ON ANOTHER OCCASION SHE HAD TO SWERVE TO KEEP FROM HITTING ANOTHER VEHICLE IN THE REAR, BECAUSE OF THE SAME FAILURE. THE DEALER INFORMED HER THAT THERE WAS NOTHING WRONG WITH THE BRAKES. *JB
Service brakes, Hydraulic, Electrical system, Vehicle speed control, Nov 1, 2006
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS AND RELEASING THE ACCELERATOR PEDAL THE VEHICLE ONLY SLOWED TO 30 MPH. ALSO, WHEN DEPRESSING THE BRAKE PEDAL THERE WAS A EXTENDED STOPPING DISTANCE. FURTHERMORE, THE ODOMETER HAD BECOME INOPERABLE. THE VEHICLE WAS DRIVEN TO THE DEALER WHERE THE CAUSE OF THE PROBLEMS COULD NOT BE DETERMINED. UPDATED 11/30/2006 - *NM