2001 Toyota Highlander
Problems, recalls and owner-reported issues
Visibility is the leading concern among 136 owner complaints filed for this model year. This is the 20th highest complaint count among 25 Highlander model years with reports.
Of the 2001 reports, 19 involved a crash and 2 involved a fire. 11 people were injured.
What owners report most often
Recalls and investigations
Latches/locks/linkages, doors, latchApr 15, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 04V181000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingJul 30, 2002
ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE UNDERSIDE OF THE BODY DUE TO MOVEMENT OF THE FUEL TANK, CAUSING THE NOZZLE TO BREAK.
IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.
DEALERS WILL ROTATE THE SPECIFIED CLAMP. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 02V208000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderJul 5, 2001
VEHICLE DESCRIPTION: SPORT UTIITY VEHICLES. THE RESERVOIR FILLER CAP OF THE BRAKE MASTER CYLINDER MAY INDUCE A VACUUM, INTRODUCING SOME AIR INTO THE BRAKE MASTER CYLINDER RESERVOIR. THIS COULD CAUSE ABNORMAL BRAKE NOISE AND INCREASED PEDAL STROKE WHEN THE BRAKES ARE APPLIED.
THE INCREASED PEDAL STROKE WILL LENGTHEN THE STOPPING DISTANCE OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
DEALERS WILL BLEED THE AIR FROM THE BRAKE LINES AND REPLACE THE RESERVOIR FILLER CAP. OWNER NOTIFICATION BEGAN JULY 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 01V228000 on NHTSA.gov
Representative owner complaints: air bags
10 reports, newest first. Show all
Air bags, Jan 27, 2015
TL* THE CONTACT OWNS A 2001 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE SPIRAL CABLE NEEDED TO BE REPLACED; HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.
Air bags, Oct 26, 2014, crash
ANOTHER VEHICLE CROSSED THE LINE AND I SWERVED TO AVOID A HEAD ON COLLISION. HOWEVER POINT OF IMPACT WAS DRIVERS SIDE DOOR AND SIDE TO REAR. NO AIRBAG DEPLOYED. *TR
Air bags, Dec 7, 2013
ANYTIME CAR IS KEPT OUTSIDE IN TEMPERATURE BELOW FREEZING, THE AIRBAG LIGHT ILLUMINATES AND STAYS ON AFTER CAR IS STARTED. IT CONTINUES TO STAY ON UNTIL TEMPERATURE WARMS UP AND CAR IS SUBSEQUENTLY RESTARTED. THERE ARE REPORTS OF A TSB ON THIS KNOWN PROBLEM STATING THE AIRBAG IS NON-OPERABLE WHILE LIGHT FLASHES, BUT TOYOTA HAS NOT ISSUED A RECALL OR IS WILLING TO REPAIR UNDER WARRANTY. NOTE: THIS IS A SAFETY DRIVE ABILITY ISSUE THAT SHOULD BE TREATED AS A RECALL. *TR
Air bags, Dec 18, 2010
WHEN 2001 TOYOTA HIGHLANDER IS STARTED WHEN COLD, BELOW 30 DEGREES F, AIR BAG LIGHT BLINKS UNTIL 1) CAR WARMS UP 2) CAR IS RESTARTED. I HAVE BEEN TOLD BY DEALER THAT WHEN LIGHT IS BLINKING, AIR BAGS ARE INOPERABLE. ORDINARILY THIS CAR IS KEPT IN A GARAGE SO IT IS NOT VERY OFTEN STARTED WHEN BELOW 30 F. I BELIEVE THIS PROBLEM HAS BEEN WITH THE CAR SINCE NEW. I BELIEVE THIS PROBLEM IS ON MANY OTHER TOYOTA HIGHLANDERS OF THIS ERA BECAUSE A GOOGLE SEARCH FOR "TOYOTA HIGHLANDER AIR BAG LIGHT BLINKS COLD WEATHER" BRINGS UP DISCUSSIONS OF PEOPLE TALKING ABOUT THIS PROBLEM FOR THE FIRST GENERATION HIGHLANDERS 2001 - 2007. *TR
Air bags, Seat belts, Nov 9, 2010, crash
I WAS IN A CAR ACCIDENT IN AUGUST 2010 IN MY TOYOTA HIGHLANDER. THE AIRBAGS DID NOT DEPLOY ON IMPACT EVEN THOUGH I WAS GOING 45-50 MPH. MY SEAT BELT DID NOT RESTRAIN ME FROM HITTING MY STEERING WHEEL WAS A HARD IMPACT TO MY CHEST. I SENT PICS TO TOYOTA AND SPOKE TO THEM SEVERAL TIMES ABOUT MY COMPLAINT OF THE FAILING AIRBAGS AND SEATBELT. THEY SAID THAT THE CAR DID WHAT IT WAS DESIGNED TO DO ON IMPACT AND THEREFORE I HAD NO COMPLAINT. MY CAR WAS TOTALED IN THE COLLISION. *TR
Air bags, Jun 13, 2008
SHIRENE DUHANEY JUNE 13, 2008 ATTN: RECALLS/COMPLAINTS & INVESTIGATIONS DEAR SIR/MADAM: I AM WRITING BECAUSE I NEED ASSISTANCE WITH A DANGEROUS MATTER. MY VEHICLE IS A 2001 TOYOTA HIGHLANDER. I HAVE CONTACTED & VISITED THE DEALER. I HAVE HAD AN ATTORNEY WRITE TOYOTA MOTOR SALES USA, INC. AND NO RESOLVE. I HAVE PICTURES IF YOU'D LIKE TO SEE THEM. FOR DETAILS PLEASE SEE BELOW: I WANT THEM TO BE AWARE OF THE FACT THAT I TOOK MY VEHICLE TO PLAZA AUTO MALL ON 3/22/07. I SPOKE WITH ADVISOR LONNIE. THE REASON I BROUGHT MY CAR IN TO HAVE THEIR TECHNICIANS CHECK OUT MY VEHICLE BECAUSE I WAS CONCERNED ABOUT A LUMP IN MY STEERING WHEEL. IN ADDITION I WAS HAVING A RECALL TAKEN CARE OF. ACCORDING TO THE ADVISOR LONNIE 'HE SAID IT WAS NOT A PROBLEM AND IT WAS OK. HOWEVER, THE PRINT OUT THAT HE WANTED ME TO SIGN SAID 'LUMP IN STEERING WHEEL 'TECH FOUND AIR BAG DISTORTED 'NEEDS TO BE REPLACED. CUSTOMER DECLINED REPAIR.' THAT WAS NOT TRUE I WAS NEVER TOLD IT NEEDED REPAIR. I REFUSED TO SIGN THAT AND NOTED THAT ON THEIR COPY . THAT WAS UNSETTLING TO ME I RETURNED SHORTLY TO THE DEALERSHIP ON 4/5/07 AND DEALT WITH YET ANOTHER ADVISOR. HE RE-EXAMINED MY VEHICLE AND DETERMINED THAT IT WAS OK. HE GAVE ME A NEW FORM THAT SAID THAT THE CAR WAS OK. (ATTACHED ARE 2 COPIES OF TOYOTA PRINT OUTS BOTH OF WHICH SHOW A DISCREPANCY IN THE INFORMATION.) HOWEVER, IT IS STILL NOT SITTING WELL WITH ME. TOYOTA AS A CORPORATION NEEDS TO BE AWARE OF THIS. THIS MAY BE A DEFECT IN THEIR VEHICLE. THIS VEHICLE WAS PURCHASED BRAND NEW AND THERE HAVE BEEN SO MANY RECALLS. THIS MAY ALSO BE A RECALL THAT THE CORPORATION IS NOT AWARE OF. I WOULD LIKE TO HAVE THIS LOOKED INTO BY THE CORPORATION TO MAKE SURE THAT THE MY AIR BAG IS NOT MALFUNCTIONING. I NEED TO HAVE THIS FIXED. ASAP THIS IS A DANGEROUS SITUATION! SINCERELY, SHIRENE DUHANEY *TR
Air bags, May 18, 2004, crash
DRIVER WAS HIT ON LEFT FRONT SIDE OF VEHICLE BY ONCOMING CAR IN EXCESS OF 40 MPH AND AIRBAGS DID NOT DEPLY.*AK
Service brakes, Hydraulic, Air bags, Jun 30, 2003, crash
CONSUMER STATES WHILE TRAVELING 2-3 MPH AND APPLYING THE BRAKES VEHICLE WENT INTO EXTENDED STOPPING DISTANCE, RUNNING INTO GARAGE DOOR. UPON IMPACT, AIR BAGS DID NOT DEPLOY. *AK
Air bags, Jun 30, 2003, crash
CONSUMER STATES WHILE TRAVELING 10 MPH REAR ENDED ANOTHER VEHICLE, AND AIR BAGS DID NOT DEPLOY. *AK
Air bags, Jan 25, 2002, crash
WHILE AT A STOP ANOTHER VEHICLE TRAVELING ABOUT 45 MPH, HIT CONSUMER'S VEHICLE IN THE REAR. IMPACT FORCED CONSUMER INTO A DITCH. VEHICLE WAS TOTALLED. UPON IMPACT, AIRBAGS FAILED TO DEPLOY, AND DRIVER SUSTAINED SOME INJURIES.*AK