2003 Toyota Highlander
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 270 owner complaints filed for this model year. This is the 8th highest complaint count among 25 Highlander model years with reports.
Of the 2003 reports, 34 involved a crash and 1 involved a fire. 12 people were injured.
What owners report most often
Recalls and investigations
Latches/locks/linkages, doors, latchApr 15, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 04V181000 on NHTSA.gov
WheelsDec 17, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FIVE FACTORY ALLOY WHEELS (MODEL 6934 AND 6936), WITH FACTORY LLAT, AND WITH PORT INSTALLED WR4, FOUR ALLOY WHEEL UPGRADE PROCESSED AT THE JACKSONVILLE, FLORIDA PORT AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA, WHEN THE VEHICLES WERE PROCESSED AT THE PORT, AN ALLOY TIRE/WHEEL UPGRADE WAS INSTALLED. THE UPGRADE INCLUDED 4 ALLOY WHEELS. THE ORIGINAL SPARE TIRE/ALLOY WHEEL WAS NOT CHANGED. THE SPARE TIRE REQUIRES THE USE OF A DIFFERENT STYLE OF WHEEL NUT TO ATTACH IT TO THE VEHICLE.
IF THE SPARE TIRE/WHEEL IS INSTALLED ON THE VEHICLE USING THE WHEEL NUTS PROVIDED FOR THE UPGRADE ALLOY WHEEL, DAMAGE TO THE WHEEL COULD RESULT AND COULD EVENTUALLY LEAD TO A LOOSE WHEEL.
OWNERS WILL BE PROVIDED WITH DIFFERENT STYLE LUG NUTS, A WARNING LABEL FOR THE SPARE RE/ALLOY WHEEL, AND AN OWNER'S MANUAL ADDENDUM.
Campaign 02V339000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
48 reports, newest first. Show all
Engine and engine cooling, Apr 1, 2010
MY 2003 HIGHLANDER HEAT GAGE INDICATED THE ENGINE WAS STARTING TO GET HOT. I PULL INTO SERVICE STATION TO CHECK COOLANT LEVEL AND NOTICED COOLANT LEAKING ON THE GROUND. I WAITED FOR ABOUT 15 MINUTES TO ASSURE MYSELF IT WAS SAFE TO TAKE OFF THE RADIATOR CAP. I COULD NOT SEE ANY COOLANT SO, I PURCHASED A GALLON OF PRE-MIXED COOLANT AND POURED IN ABOUT 1/2 TO 3/4 GALLON TO BRING IT UP TO FULL. I MADE THE TRIP HOME WITHOUT THE CAR GETTING HOT, BUT NOTICED THE LEAK WAS STILL THERE. I HAD THE VEHICLE LOOKED AT BY A LOCAL TOYOTA DEALER AND WAS TOLD THE CAR NEEDED MAJOR REPAIRS. THERE IS A TECHNICAL SUPPORT BULLITIN ON THE ENGINE IN QUESTION. A 2.4 LITRE (4 CYLINDER) ENGINE COMMON ON CAMARYS AND HIGHLANDERS. I FEEL TOYOTA SHOULD HAVE TO REPAIR THIS VEHICLE IN LIGHT OF THE FACT TOYOTA HAS KNOWN OF THE DESIGN DEFECT ON OTHER MODELS (CAMARY AND HIGHLANDERS). WHEN I TOOK THE CAR IN FOR REPAIRS THE SERVICE SCHEDULER KNEW EXACTLY WHAT PROBLEM I WAS DESCRIBING TO HIM ABOUT MY CAR. THIS INDICATED TO ME, TOYOTA HAS INFORMED THEIR DEALERS OF THE PROBLEM OR, THEY WOULDN'T HAVE SENT A SERVICE BULLITIN ON THE VERY FIX TO MY CARS PROBLEM. THE SERVICE BULLITIN DESCRIBED (3) HEAD BOLTS AROUND THE INTAKE MANIFOLD WOULD STRETCH AND FAIL TO SEAL THE HEAD THUS, LEAK COOLANT. THE BULLITIN EVEN DESCRIBES INSTALLING HELI-COILS IN THE (3) AFFECTED BOLTS TO SOLVE THE PROBLEM. THIS APPEARS TO BE ANOTHER FAILURE OF TOYOTA TAKING RESPONSIBILITY FOR KNOWN DEFECTS IN THEIR AUTOMOBILES. I BOUGHT AND PAID FOR THIS VEHICLE IN GOOD FAITH ON THE RELIABILITY RECORD OF THE TOYOTA COMPANY'S PAST RECORD. I NOW FEEL I HAVE BEEN TREATED UNFAIRLY BY THIS COMPANY. I WOULD UNDERSTAND IF THIS WAS AN ISOLATED OCCURANCE, BUT IT IS NOT AND TOYOTA KNOWS THIS FULL WELL. SERVICE BULLITINS DON'T GET SENT TO ALL DEALERS FOR A SINGLE OCCURANCE. PLEASE HELP !
Engine and engine cooling, Feb 27, 2010
VEHICLE SUDDENLY LEAKS ENGINE COOLANT TO THE OUTSIDE OF VEHICLE WITHOUT ANY WARNING OF OVERHEATING. LEAK IS COMING FROM A DEFECTIVE HEAD BOLT AND CANNOT BE FIXED. ENTIRE ENGINE BLOCK NEEDS REPLACEMENT. A VERY COMMON ISSUE AMONG 4 CYLINDER 2001-2006 TOYOTA ENGINES IN THE CAMRY,HIGHLANDER AND RAV 4 LEAKING HARMFUL COOLANT TO THE OUTSIDE OF VEHICLES THAT IS DEADLY TO HUMANS AND ANIMALS IF CONSUMED. NOT TO MENTION OVERHEATING OF ENGINE THAT CAN RESULT IN LOSS OF ENGINE POWER AND VACUUM THAT SUPPLIES POWER TO STEERING AND BRAKES. *TR
Engine and engine cooling, Feb 11, 2010
FAULTY ELECTRONIC COMPUTER MODULE ON 2003 TOYOTA HIGHLANDER THROWS MULTIPLE ERROR CODES TO INDICATE A NUMBER OF PROBLEMS WITH EMISSION COMPONENTS. ERROR CODES CALL OUT OXYGEN SENSORS, (THERE IS FOUR SENSORS ON 2003 (4) CYLINDER HIGHLANDERS). FIX ONE SENSOR AND ANOTHER POPS UP BAD ACCORDING TO THE ERROR CODES. ANOTHER $400 REPAIR BILL ! TOYOTA WILL REPLACE THE MODULE ON CARS WITH WARRANTY, NO PROBLEM. HOWEVER, THEY DENY THERE IS ANY PROBLEMS WITH THE MODULE WHEN NO WARRANTY IS INVOLVED. CODES AT TIMES ALSO SHOW A FAULTY CATALYTIC CONVERTER ($1000 REPAIR BILL ). IF YOU VISIT THE TOYOTA NATION WEB SITE YOU WILL SEE MANY REPORTS OF THE COMPONENT AT ISSUE. THIS IS ON THE SAME VEHICLES AS THE ONE I OWN. SOME PEOPLE HAVE REPORTED TOYOTA CHARGES UNSUSPECTING CUSTOMERS $1600 TO REPAIR THESE FOUR SENSORS. ( NOT MY WORDS, TAKEN OFF THE TOYOTA NATION FORUMS). PLEASE DEMAND TOYOTA REPLACE THE MODULES ON THESE VEHICLES. THANK YOU ! *TR
Engine and engine cooling, Jan 2, 2010
1. ENGINE OVERTEMP 2. ENGINE CONTINUALLY RUNS HOT. CANNOT USE VEHICLE 3. REPLACED HEAD GASKET, RADIATOR, THERMOSTAT. *TR
Engine and engine cooling, Dec 22, 2009
TL* THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE BEGAN TO OVERHEAT. HE PULLED TO THE SIDE OF THE ROAD, AND THE VEHICLE WAS RESTARTED TO RESUME OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE REAR HEAD BOLTS AND A BLOWN HEAD GASKET WERE STRIPPED. ALSO THE CYLINDER HEAD GASKET WAS REPLACED. THE TOTAL COST OF THE SERVICE REPAIR WAS $1,972. THE FAILURE MILEAGE WAS 120,047. THE VIN WAS UNAVAILABLE. UPDATED 05/06/10. *LJ
Engine and engine cooling, Sep 22, 2009
THIS PERTAINS TO MY WIFE'S 2003 TOYOTA HIGHLANDER SUV, 4 CYLINDER ENGINE. ON FRIDAY, AUGUST 28, 2009, WHILE DRIVING SHE NOTICED THE TEMPERATURE GAGE ON THE DASHBOARD WAS HIGH. SHE DROVE THE CAR HOME AND CHECKED THE COOLANT LEVEL. IT WAS EXTREMELY LOW. SHE REFILLED THE COOLANT AND DIDN'T DRIVE THE SUV UNTIL SHE WENT TO HER APPOINTMENT ON WEDNESDAY, SEPTEMBER 9, 2009 WITH THE HAWAII TOYOTA DEALER SERVCO'S MOTOR IMPORTS SERVICE & PARTS CENTER AT 609 SOUTH STREET, HONOLULU, HAWAII 96813. THEY TOLD HER THE ENGINE HAD A BLOWN HEAD GASKET. WE UNDERSTAND THIS IS BECAUSE THE CYLINDER HEAD BOLTS ARE STRIPPED ON THE BACK SIDE OF THE ENGINE. THIS IS WHAT CAUSED THE COOLANT LEAK IN THE FIRST PLACE. SERVCO TOLD US THAT THE SURE REPAIR (A WHOLE NEW ENGINE) WOULD EXCEED $20,000, AND THE LESS SURE REPAIR (TRYING TO FIX THE OLD ENGINE) WOULD COST $13,000. WE PICKED UP THE CAR THE NEXT DAY AND TOOK IT TO PRIAM'S AUTOMOTIVE SERVICE & REPAIR AT 2002 PAUOA ROAD. THEY DID A QUICK TEST AND SAID THAT THE HEAD GASKET WAS INDEED BLOWN, AND REFERRED US TO ROD'S AUTO SERVICE AT 972 KAWAIAHAO STREET BECAUSE PRIAM'S WAS NOT EQUIPPED TO HANDLE THAT MAGNITUDE OF REPAIR. ROD'S HAS ADVISED US THAT THE BEST SOLUTION IS REPLACING THE ENTIRE ENGINE WITH A REBUILT ENGINE FOR $5,000, BUT THIS HAS BECOME A COMMON PROBLEM WITH TOYOTA HIGHLANDERS AND LOCATING A REBUILT ENGINE ON THE MAINLAND WILL TAKE TIME. IN DOING SOME INTERNET RESEARCH, I'VE LEARNED THAT CAMRYS OF THE SAME VINTAGE HAVE ALSO DEVELOPED SIMILAR PROBLEMS, BUT IT LOOKS LIKE TOYOTA IS REFUSING TO RECALL THE VEHICLES AND FIX THE DESIGN FLAW. HTTP://WWW.CAMRYFORUMS.COM/FORUM/SHOWTHREAD.PHP?P=21539 TO DATE, THE VEHICLE REMAINS IN DISREPAIR. *TR
Engine and engine cooling, Jul 10, 2009
ENGINE OVERHEATED. SERVICE DEPT DIAGNOSED BAD HEAD GASKET. DISCOVERED STRIPPED THREADS IN THE BLOCK FOR TWO REAR HEAD BOLTS. SERVICE DEPT ATTEMPTED REPAIR WITH RETHREADED HELICOIL BUT WOULD NOT HOLD. ENGINE REPLACEMENT IS REQUIRED. *TR
Engine and engine cooling, Jul 1, 2009
I HAVE A 2003 TOYOTA HIGHLANDER WITH A @AZFE MOTOR IN IT. THERE IS A MAJOR PROBLEM WITH THESE MOTORS STRIPPING OUT THE HEADBOLTSIN THE BACK OF THE MOTOR. I AM NOW IN A PREDICAMENT AS I HAVE TO GET A BLOCK WHEN I KNOW IT WILL MESS UP AGAIN AND TOYOTA HAS AS OF YET TO DO ANYTHING ABOUT IT. *TR
Engine and engine cooling, Jun 15, 2009
I NOTICED THAT THE ENGINE NOISE CHANGED. TOOK THE SUV TO THE DEALER TO CHECK IT OUT, DEALER STATED THAT THE NOISE WAS OK AND RETURNED THE VEHICLE TO ME. AFTER DRIVING THE VEHICLE LESS THAN 10 MILES RETURNED IT TO THE DEALER AND THE ENGINE WAS BLOWN. *TR
Engine and engine cooling, May 15, 2009
WHILE DRIVING ON THE HIGHWAY, MY ENGINE TEMP IN MY 4 CYL, 4WD 2003 HIGHLANDER SUDDENLY SPIKED HIGH. I HAD TO PULL OF THE ROAD. TOWED TO DEALER. DEALER SAID BOLTS ON SHORT BLOCK OF ENGINE WERE STRIPPED AND ALLOWED COOLANT TO LEAK OUT AND ENGINE OVERHEATED. I WAS AT 68,000 MILES, SO OVER THE WARRANTY PERIOD. I TOOK IT TO MY LOCAL DEALER AND THEY SAID I HAD A BAD WATER PUMP...I PAID TO HAVE THAT FIXED, BUT THE CAR STILL OVERHEATED. I TOOK IT BACK TO THE DEALER AND THEY THEN SAID IT WAS THE ENGINE ITSELF..THE SHORT BLOCK, SOMETHING ABOUT THE SCREWS WERE STRIPPED, THAT I HAD GOTTEN A BAD ENGINE WITH STRIPPED SCREWS. DEALERS SERVICE MANAGER TOLD ME THIS WAS A KNOWN ISSUE ON SOME 4CYL 2003 HIGHLANDER BUT COULDN'T HELP ME AS IT WAS OUT OF WARRANTY!!! THE SERVICE MANAGER CALLED ME BACK LATER AND SAID THAT TOYOTA WOULD HELP OUT...I ENDED UP PAYING A TOTAL OF ALMOST $1000 FOR THE REPLACEMENT SHORT BLOCK, WITH TOYOTA PAYING THE REST OF THE COST FOR THE SHORT BLOCK REPLACEMENT. THIS WAS ON TOP OF THE COST I PAID JUST A FEW DAYS PRIOR FOR A WATER PUMP THAT TURNED OUT TO NOT BE THE ISSUE. VERY FRUSTRATING...I HAVE ALL MY RECEIPTS FOR MAINTENANCE AND FOR THESE REPAIRS. *TR I AM FILLING OUT THIS COMPLAINT OVER A YEAR AFTER THE INCIDENT, BECAUSE I HAVE SEEN THE SAME THING IN THE COMPLAINTS AND WANTED TO ADD MINE. I DO HAVE ALL THE DOCUMENTATION FOR MY REPAIRS FOR THIS AND AM MORE THAN WILLING TO ANSWER ANY QUESTIONS, THANK YOU.
Engine and engine cooling, May 1, 2009
THE SUV WAS OUT OF COOLANT & WATER AND MY HUSBAND TAKE THE CAR TO THE DEALER TO CHECK THIS PROBLEM AND FOR REGULAR MAINTENANCE (THE CAR ONLY HAS RECEIVED SERVICE AT THE DEALER, EXCEPT FOR TIRES). THE DIAGNOSTIC WAS THAT THE SHOCK BLOCK HAS IT THREADS SEPARATED FROM THE SCREWS (OR BOLTS). THE ENGINE HAS TO BE REMOVED IN ORDER TO CHANGE THE SHOCK BLOCK. THE REPAIR HAS COST $4701.31, BECAUSE IT WAS ALSO RECOMMENDED TO CHANGE THE OIL PUMP. PREVIOUS TO THIS REPAIR, THE SUV WAS TAKEN TO THE DEALER BECAUSE THERE WAS A RECALL TO REPROGRAM ITS COMPUTER BECAUSE THE CHECK ENGINE LIGHT TURNED ON (THIS HAPPENED TWICE). WE HAVE A FULL RECORD IN THE DEALER OF ALL MAINTENANCE CHECKS AND REPAIRS THE SUV HAD. *TR
Engine and engine cooling, Apr 5, 2009
ENGINE HEAD BOLTS ON 2003 TOYOTA HIGHLANDER BECAME LOOSE; THREADS HAD WORN OFF ON 2 OR 3 BOLTS THAT HOLD THE TOP OF THE ENGINE TO THE MAIN ENGINE BLOCK. VEHICLE HAS BEEN WELL-MAINTAINED; 87,000 MILES. REPAIR REQUIRES NEW ENGINE BLOCK AT COST OF $6,400. APPEARS TO BE MANUFACTURING DEFECT - ENGINE BOLTS SHOULD NOT COME LOOSE. TOYOTA REFUSES TO PROVIDE ANY ASSISTANCE IN REPAIR. VEHICLE OVERHEATED AND WAS TOWED TO REPAIR SHOP. *TR
Engine and engine cooling, Fuel system, Gasoline, Jul 23, 2008
REPLACEMENT OF A CHARCOAL CANISTER ON A 2003 TOYOTA HIGHLANDER. NO ACCIDENTS OCCURRED AS A RESULT OF THE REPLACEMENT OF THIS PART; HOWEVER, I AM CONCERNED ABOUT THE NUMBER OF REPORTS OF HAVING TO REPLACE THIS VERY EXPENSIVE PART. ALSO IF THE PART IS A SAFETY HAZARD (MAY CAUSE AN ENGINE FIRE) IT SHOULD NOT BE AT THE EXPENSE OF THE OWNER. THE PART IS AN EMISSION CONTROL DEVICE THAT IS SURELY REQUIRED BY THE GOVERNMENT. THIS ACTION IS TAKEN BECAUSE I NOTICED, WHILE RESEARCHING CHARCOAL CANISTERS THAT TOYOTAS COME UP FREQUENTLY AS HAVING TO HAVE THIS TYPE REPAIR. AT THIS WRITING I AM UNABLE TO CONFIRM THE PART IS DEFECTIVE AS IT IS THE ORIGINAL PART THAT CAME WITH THE VEHICLE WHEN I PURCHASED IT BRAND NEW. THIS IS NOT A PRE-OWNED VEHICLE. *TR
Engine and engine cooling, Jan 17, 2008
MY CAR ENGINE IS FILLED WITH SLUDGE AND THE MANUFACTURER (TOYOTA MOTOR CORP.) WILL NOT HONOR THE WARRANTY. *TR
Engine and engine cooling, Nov 5, 2007
TL*THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. WHILE DRIVING AT AN UNKNOWN SPEED, THE CHECK ENGINE LIGHT ILLUMINATED. TWO TO THREE MONTHS LATER, THE CONTACT RECEIVED A RECALL NOTICE REGARDING THE ENGINE. TOYOTA REPAIRED THE VEHICLE. THE CURRENT MILEAGE WAS 50,000 AND FAILURE MILEAGE WAS 40,000.
Engine and engine cooling, Sep 28, 2007
SUDDEN RAPID INCREASE IN ENGINE TEMPERATURE. MECHANIC FOUND LEAK AT BACK OF HEAD GASKET. TWO BOLTS TO ENGINE BLOCK WERE LOOSE ENOUGH TO BE REMOVED BY HAND AND NEW BOLTS COULD NOT BE REINSTALLED DUE TO DEFECT IN THREADS. ONLY REPAIR SAID TO BE NEW ENGINE. VEHICLE WAS PREVIOUSLY WELL MAINTAINED AND HAD 73,000 MILES. *JB
Engine and engine cooling, Sep 26, 2007
TL*THE CONTACT OWNS A 2003 TOYOTA CAMRY. THE CONTACT HEARD A LOUD TICKING AND RATTLING NOISE COMING FROM UNDER THE HOOD WHEN THE VEHICLE WAS STARTED. SHE IMMEDIATELY TOOK THE VEHICLE TO A DEALER AND THEY PERFORMED A DIAGNOSTIC TEST. THE TEST INDICATED THAT THE INTAKE MANIFOLD WAS SEPARATING FROM THE INSIDE. THE DEALER STATED THAT THE VEHICLE HAD TOO MANY MILES TO BE COVERED UNDER WARRANTY. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 62,000.
Engine and engine cooling, Jul 11, 2007
2003 TOYOTA HIGHLANDER V6 4WD 45000 MILES. IT WA S ALREADY MORE THAN 2 YEARS I HAVE BEEN EXPERIENCING EXACTLY THE SAME PROBLEM AS 'DESCRIBED IN NHTSA RECALL 100I0160 000- CONCERNING ACCESSORY DRIVE BELT SQUEAL/ BELT TENSIONER RATTLES. DEALERSHIP RESPONSE WAS THAT NHTSA ITEM NUMBER 100I0160 DIDN'T APPLY TO V6 HIGHLANDERS. *AK
Engine and engine cooling, Apr 17, 2007
1) NOTICED RADIATOR FLUID SLOWLY LEAKING UNDER BOTTOM (TOWARDS BACK OF ENGINE). HAD MECHANIC CHECK ENGINE, - WAS LEAKING AT BACK OF HEAD GASKET, TOOK APART ENGINE AND NOTICED 3 BACK BOLTS TO ENGINE BLOCK (HEADS) COULD BE REMOVED BY HAND. WHEN HEADS WERE FIXED COULD NOT INSTALL NEW BOLTS (WOULD NOT TIGHTEN) - MECHANIC SAID THERE IS A MANUFACTURER DEFECT - NO THREADS. 2) CANNOT FIX ENGINE - NEED NEW ENGINE 3) TRYING TO GET TOYOTA TO PAY FOR REPAIR - IN PROGRESS WITH THEM NOW - NO RESOLUTION YET. *JB
Engine and engine cooling, Apr 3, 2004
A FEW MONTHS AFTER THE PURCHASE OF MY NEW 2003 TOYOTA HIGHLANDER, IT HAS DEVELOPED A PRONOUNCED "TICKING" SOUND WITHIN THE ENGINE. I AM CONCERNED THAT THIS COULD MEAN THAT A PROBLEM IS DEVELOPING, AND IT IS ALSO AN ANNOYING SOUND IN AN OTHERWISE QUIET VEHICLE. I AM GOING TO REPORT THIS TO TOYOTA VIA THEIR WEB SITE. THIS VEHICLE COST ME ALMOST $35K AND I DO NOT FEEL THAT THIS PROBLEM IS INSIGNIFICANT NOR SHOULD BE IGNORED BY THE DEALER. SHOULD I CHOOSE TO SELL THE VEHICLE, I WOULD SUSPECT THIS WILL SIGNIFICANTLY LOWER THE PRICE I COULD ASK AND MAY EVEN PREVENT ME FROM UNLOADING IT ALTOGETHER. *NM
Engine and engine cooling, Apr 1, 2004
MY 2003 HIGHLANDER LIMITED 6-CYL. 4WD VEHICLE HAS A LOUD AUDIBLE CLICKING NOISE (SOUNDS LIKE VALVE LIFTERS TICKING) EMINATING FROM THE ENGINE SINCE I PURCHASED THE VEHICLE NEW FROM PAGE TOYOTA IN JAN '2003. THE CLICKING NOISE IS ONLY PRESENT WHEN THE ENGINE IS RUNNING. THE CLICKING NOISE IS ALWAYS AUDIBLE BUT THE VOLUME DECREASES AS THE VEHICLE REACHES NORMAL OPERATING TEMPERATURE.THE CLICKING NOISE IS VERY LOUD WHEN THE VEHICLE IS COLD. THE CLICKING NOISE FREQUENCY INCREASES WITH INCREASING ENGINE RPM AND DECREASES WITH DECREASING ENGINE RPM. THE TOYOTA RED HOLMAN CUSTOMER SERVICE REPRESENTATIVE STATED THAT THE CLICKING NOISE IS NORMAL AND CAN NOT BE REDUCED OR ELIMINATED. *AK
Engine and engine cooling, Dec 29, 2003
TWO MONTHS AFTER BUYING MY NEW 2003 HIGHLANDER IT DEVELOPED A LOUD TICKING IN THE ENGINE. TOYOTA TOLD ME THAT THIS WAS COMMON AFTER 3000 MILES OR SO BUT THAT THERE WAS NOTHING WRONG WITH IT, NOR COULD IT BE FIXED. I THINK THIS SIGNIFICANTLY REDUCES THE VALUE OF THE VEHICLE SINCE I HAVE HAD PASSENGERS ASK ME WHAT WAS WRONG WITH MY CAR.*AK
Engine and engine cooling, Feb 5, 2003
CONSUMER IS LOOSING ENGINE POWER. DEALER WAS CONTACTED. PH