2003 Toyota Highlander
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 270 owner complaints filed for this model year. This is the 8th highest complaint count among 25 Highlander model years with reports.
Of the 2003 reports, 34 involved a crash and 1 involved a fire. 12 people were injured.
What owners report most often
Recalls and investigations
Latches/locks/linkages, doors, latchApr 15, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 04V181000 on NHTSA.gov
WheelsDec 17, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FIVE FACTORY ALLOY WHEELS (MODEL 6934 AND 6936), WITH FACTORY LLAT, AND WITH PORT INSTALLED WR4, FOUR ALLOY WHEEL UPGRADE PROCESSED AT THE JACKSONVILLE, FLORIDA PORT AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA, WHEN THE VEHICLES WERE PROCESSED AT THE PORT, AN ALLOY TIRE/WHEEL UPGRADE WAS INSTALLED. THE UPGRADE INCLUDED 4 ALLOY WHEELS. THE ORIGINAL SPARE TIRE/ALLOY WHEEL WAS NOT CHANGED. THE SPARE TIRE REQUIRES THE USE OF A DIFFERENT STYLE OF WHEEL NUT TO ATTACH IT TO THE VEHICLE.
IF THE SPARE TIRE/WHEEL IS INSTALLED ON THE VEHICLE USING THE WHEEL NUTS PROVIDED FOR THE UPGRADE ALLOY WHEEL, DAMAGE TO THE WHEEL COULD RESULT AND COULD EVENTUALLY LEAD TO A LOOSE WHEEL.
OWNERS WILL BE PROVIDED WITH DIFFERENT STYLE LUG NUTS, A WARNING LABEL FOR THE SPARE RE/ALLOY WHEEL, AND AN OWNER'S MANUAL ADDENDUM.
Campaign 02V339000 on NHTSA.gov
Representative owner complaints
270 reports, newest first.
Engine and engine cooling, Dec 1, 2010
TL*THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. THE VEHICLE HAD A HEAD GASKET WATER LEAK. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE HEAD GASKET WAS BLOWN AND IT WOULD COST $2500 TO BE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE 126,000.
Suspension, Nov 24, 2010
TL*THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THERE WAS A DRUMMING NOISE FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS INSPECTED BY AN AUTHORIZED DEALER WHO INFORMED THE CONTACT THAT THERE WAS A LEAK IN THE VACUUM HOSE. THE VEHICLE WAS REPAIRED. AFTER LEAVING THE DEALER, THE FAILURE OCCURRED AGAIN. ANOTHER DEALER STATED THAT THE TIRES WERE WORN. THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT CALLED THE MANUFACTURER AND WAS AWAITING A RETURN CALL. THE FAILURE MILEAGE WAS APPROXIMATELY 92,000.
Engine and engine cooling, Nov 17, 2010
MY 2003 TOYOTA HIGHLANDER'S TEMP GAUGE STARTED GOING TOWARD THE H WHILE DRIVING ABOUT 30 MPH. I TURNED THE HEAT ON IN THE CAR AND THAT MADE THE GAUGE GO BACK DOWN TO NORMAL. I TOOK THE CAR TO A TOYOTA DEALERSHIP WHERE I WAS TOLD MY HEAD GASKET WAS BLOWN AND I NEEDED A NEW ENGINE FOR ABOUT $8000! I TOOK THE CAR TO AN INDEPENDENT MECHANIC THAT TOLD ME THE ENGINE ITSELF WAS FINE BUT 3 BOLTS ON THE HEAD GASKET WERE STRIPPED. THE REPAIR IS COSTING AN APPROXIMATE $2500 TO RETAP THE HOLES AND USE DIFFERENT BOLTS. I HAD DONE SOME RESEARCH AND I FOUND OUT THAT THIS IS A KNOWN PROBLEM WITH THE 2003 HIGHLANDERS AND TOYOTA IS NOT DOING ANYTHING ABOUT IT (I HAVE THE WEBSITE INFO AND COMPLAINTS IF NEEDED). MANY PEOPLE WHO HAVE PURCHASED THIS YEAR/MAKE/MODEL HAVE SPENT THOUSANDS OF DOLLARS REPAIRING THIS DEFECT THAT TOYOTA KNOWS ABOUT BUT WILL NOT TAKE CARE OF. I CALLED TOYOTA NATIONAL CUSTOMER SERVICE AND THEY GAVE ME THIS WEBSITE INFORMATION TO FILE A COMPLAINT (I HAVE A CLAIM NUMBER IF YOU NEED IT). I AM VERY UPSET, ACTUALLY OUTRAGED, THAT HERE WE ARE AGAIN FINDING OUT THAT TOYOTA HAS MORE ISSUES WITH THEIR VEHICLES AND WON'T DO ANYTHING ABOUT IT. I BOUGHT THIS CAR BECAUSE I THOUGHT TOYOTAS WERE RELIABLE. PLEASE DO SOMETHING ABOUT THIS AND HELP ALL OF US WHO BOUGHT THE 2003 HIGHLANDERS RECOVER THE MONEY WE HAVE SPENT ON REPAIRS TO AN OBVIOUS MANUFACTURER'S DEFECTIVE PART USAGE. THANK YOU! *TR
Vehicle speed control, Nov 3, 2010, crash
AUTO WAS STOPPED THREE FEET FROM ANOTHER AUTO. SUDDEN NON INITIATED ACCELERATION (FULL THROTTLE) WITH DAMAGE TO OTHER VEHICLE SEVERE, MINIMAL TO HIGHLANDER. *TR
Engine and engine cooling, Nov 3, 2010
TL*THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 65 MPH WITH THE AIR CONDITIONER ON SHE NOTICED HOT AIR BEGAN TO FLOW FROM THE VENTS. SHE ALSO NOTICED THAT THE TEMPERATURE GAUGE MALFUNCTIONED. THE VEHICLE WAS DRIVEN ONTO THE EMERGENCY LANE AND SHUT OFF WHILE SHE ADDED COOLANT TO THE ENGINE. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE SHE WAS INFORMED THAT THERE WAS AN ENGINE LEAK AND SOME OF THE BOLTS WERE LOOSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 109,171. THE CURRENT MILEAGE WAS 110,000.
Engine and engine cooling, Nov 3, 2010
2003 TOYOTA HIGHLANDER WITH 110,000 MILES STARTED TO OVERHEAT AND LOSE COOLANT. TOOK IT TO DEALERSHIP AND LEARNED THAT THE CYLINDER HEAD BOLTS HAD COME LOOSE DUE TO THE HOLES IN THE BLOCK BEING STRIPPED. TOYOTA ESTIMATED $3000 TO TAKE THE BLOCK OUT TO A MACHINIST TO BORE NEW HOLES, BUT IF THAT DIDN'T WORK IT WOULD COST $6000 TO REPLACE THE BLOCK. I THEN TOOK THE CAR TO A PRIVATE MECHANIC WHO SAID IT WOULD COST $9600 TO TAKE OUT THE BLOCK AND SEND TO MACHINIST OR BUY A RE-MANUFACTURED ENGINE FOR $8200. THE PRIVATE MECHANIC STATED THIS PROBLEM IS DUE TO FAULTY MANUFACTURING OF THE ENGINE AND ALSO STATED THAT HE SEES THIS PROBLEM ALL THE TIME IN THESE TYPES OF VEHICLES. ON THE INTERNET I HAVE FOUND CONSUMERS SHARING THE SAME STORIES ABOUT SIMILAR VEHICLES BY TOYOTA WITH SIMILAR ENGINES THAT HAVE THE SAME PROBLEM; SOME ONLY LASTING 70,000 MILES. I PUT IN A CALL WITH TOYOTA HEADQUARTERS AND THEY GAVE ME A REFERENCE NUMBER IN CASE ANY RECALLS SHOULD ARISE. TOYOTA SAID THAT THERE WAS NOTHING THEY COULD DO OUT OF "GOOD FAITH" SINCE IT IS PASSED THE WARRANTY MILEAGE AND SINCE I DID NOT DO ALL MY SERVICING AT TOYOTA. I CHANGED THE OIL EVERY 3,000 MILES AND TOOK VERY GOOD CARE OF THIS VEHICLE AS IT WAS MY FIRST PURCHASE OF A NEW VEHICLE AND I THOUGHT IT WOULD LAST ME A LONG TIME. *TR
Engine and engine cooling, Oct 28, 2010
THE COOLANT KEPT LEAKING ON MY HIGHLANDER 2003 4 CYLINDER FOR LAST FEW MONTHS. THE TEMPERATURE GAUGE ONE DAY SHOWED HEATING OF ENGINE. TOOK IT TO TOYOTA , THEY SAID IT IS BLOWN HEAD GASKET. DEMANDED $3500. *TR
Engine and engine cooling, Oct 6, 2010
2003 TOYOTA HIGHLANDER 2.4L 4-CYLINDER ENGINE, 108,000 MILES, DEVELOPED COOLANT LEAK ON THE BACK SIDE OF THE TOP OF THE ENGINE, ADJACENT TO AN INSULATOR PAD AT THE BACK OF THE ENGINE BLOCK. THE BACK 3 HEAD BOLTS WERE STRIPPED, ALLOWING COOLANT TO ALSO LEAK INTO THE ENGINE. THE TOYOTA DEALER SAYS THAT THE SHORT BLOCK OR ENTIRE ENGINE MUST BE REPLACED, WITH NO OTHER OPTION. THE HEAD HAD NEVER BEEN OFF SINCE ORIGINAL FACTORY MANUFACTURE/ASSEMBLY. BASED ON THE FREQUENCY OF IDENTICAL ENGINE FAILURES, FAULTY ASSEMBLY AND/OR DESIGN ASSURES EVENTUAL FAILURE OF THE ENGINE. *TR
Engine and engine cooling, Sep 20, 2010
2003 TOYOTA HIGHLANDER HAS HEAD BOLTS STRIPPED FROM BLOCK, CAUSING FLUID TO SLOWLY LEAK FROM ENGINE AND OVERHEAT. FIRST SYMPTOM IS AC BLOWS HOT AIR. MOST FOLKS WHO EXPERIENCE THIS BURN UP THE ENGINE, BUT I WAS FORTUNATE AND WAS ABLE TO HAVE IT REPAIRED AT A COST OF $2750.00 !!!!! THIS IS A CLEAR DEFECT, HEAD BOLTS DO NOT SIMPLY GET STRIPPED FROM A BLOCK. *TR
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Equipment, Electronic stability control (ESC), Sep 12, 2010
VSC (VEHICLE STABILITY CONTROL, INCLUDING ABS) & CHECK ENGINE LIGHTS HAVE BEEN TURNING ON INTERMITTENTLY ALMOST FROM THE START OF OUR OWNERSHIP OF THIS 2003 TOYOTA HIGHLANDER V6 AWD LIMITED AND AFTER COSTLY REPAIRS AT THE DEALER THEY ARE STILL ON CONTINUOUSLY. LAST TIME (MAY-JUNE 2010) DEALER REPLACED FRONT BRAKE PADS & ROTORS; REAR AXLES AND SPEED SENSORS AND NOW WANTS TO REPLACE ADDITIONAL COMPONENTS THAT DO NOT APPEAR CONNECTED. FIRST TIME CAR WAS SERVICED UNDER WARRANTY AT DEALER AND THAT TOO DID NOT LAST FOR LONG. TOYOTA CAR SATISFACTION CENTER HAS NOT BEEN HELPFULL. CASE # [XXX]. FORD HAS ISSUED A RECALL FOR SIMILAR ISSUE RECENTLY: 10S13 FOR REAR AXLE BREAKAGE IN THE SNOW BELT! TOYOTA REFUSES TO ACKNOWLEDGE ISSUE AND INTERNET HAS MANY DISCUSSIONS ON TOPIC. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Engine and engine cooling, Aug 17, 2010
TL-* THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. WHILE TRAVELING 55 MPH, THE CONTACT NOTICED THAT THE TEMPERATURE GAUGE WAS INDICATING THAT THE VEHICLE WAS RUNNING HOT. AFTER EXAMINING THE VEHICLE, THE CONTACT DISCOVERED COOLANT LEAKING FROM THE REAR OF THE CYLINDER BLOCK. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE Z TAPS WERE INSTALLED INSIDE OF THE ENGINE. THE CURRENT AND FAILURE MILEAGE WAS 155,000.
Engine and engine cooling, Aug 8, 2010
2003 4 CYLINDER TOYOTA HIGHLANDER. COOLANT LEAK AND SUBSEQUENT NEED FOR A NEW REPLACEMENT ENGINE DUE TO THE DEFECT OF 3 REAR ENGINE SHORT BLOCK SCREWS/THREADS. HAD LESS THAN 85K MILES ON VEHICLE, WHEN FOUND A COOLANT LEAK UNDERNEATH ENGINE BLOCK OF VEHICLE IN GARAGE AFTER HAVING NO ISSUES PRIOR WITH ENGINE, RADIATOR OR ANY ASSOCIATED ACCESSORIES TO THE COOLANT SYSTEM/ENGINE SYSTEM OF VEHICLE. TOOK TO A TOYOTA DEALER PRIOR TO ANY OVERHEATING OR VEHICLE OPERATION FAILURES OR RADIATOR FAILURE. TOYOTA DEALER PULLED ENGINE MANIFOLD AND COVER OFF TO INVESTIGATE AND FOUND THAT WHEN THEY PULLED THE THREE SCREWS THAT CONNECT THE ENGINE COVER THAT COVER THE HEADS/CYLINDERS, THE THREADS ASSOCIATED WITH THE SCREWS CAME WITH THEM. THE ONLY FIX PER DEALERSHIP DETERMINED TO BE A BRAND NEW SHORT ENGINE BLOCK AND ACCESSORY REPLACEMENT FOR $6,470. DATE ON THIS IS AUGUST/2010. HAVE ALL PAST SERVICE HISTORY OIL CHANGES/TRANSMISSION CHANGES, RADIATOR CHANGES, WATER PUMP SERVICE, ETC FROM 0 MILES TO CURRENT. TOLD THAT THE SCREWS WERE NEVER SPRAYED AND SEALED CORRECTLY, THUS CORRODED INTO THE THREADS AND CAUSED FAILURE WITH BOTH ITEMS. VERY UNHAPPY THAT AN ENGINE IS GOING TO BE PAID FOR AND REPLACED BY CONSUMER ON AN OBVIOUS MANUFACTURER ERROR. MORE AND MORE OF THESE SPECIFIC ISSUES WILL ARISE WITH TIME ON THESE 4 CYLINDER EARLY 2000 TOYOTA HIGHLANDERS. THEY WILL NEED TO RELIEVE THE CONSUMER OF A FULL PAYMENT OF A NEW ENGINE OR BURDEN THEMSELVES ON LOSING EVEN MORE LOYAL TOYOTA CONSUMERS. ----TOYOTA ONLY CONSUMER SINCE 1994.....TILL NOW!!!! *TR
Visibility, Aug 5, 2010
SUNDAY 8/1/10 THE DRIVERS' SIDE VISOR IN OUR 2003 TOYOTA HIGHLANDER WAS FINE. MONDAY 8/2/10 WHEN ATTEMPTING TO POSITION THE VISOR IT WOULD FLOP DOWN AND HANG IN A VERTICAL POSITION OBSTRUCTING THE DRIVERS VIEW OF THE ROAD, YOU COULD NOT BEND IT BACK AGAINST THE WINDSHIELD. IT BLOCKS THE DRIVER'S VIEW MAKING IT UNUSABLE AND UNSAFE. I WENT TO THE TOYOTA DEALER TO HAVE IT REPAIRED. THE DEALER CLAIMED THAT IT COULD NOT BE REPAIRED AND THAT A REPLACEMENT WOULD COST OVER $700 DOLLARS. THE ATTACHMENT IS WHERE THE PROBLEM IS. THEY CLAIMED THEY COULDN'T FIX IT. THIS IS A CLEAR SAFETY ISSUE AND I FEEL THAT TOYOTA SHOULD BE RESPONSIBLE FOR ITS REPAIR. *TR
Vehicle speed control, Jul 29, 2010, crash
TL* THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. WHILE ATTEMPTING A RIGHT TURN AT APPROXIMATELY 5 MPH, THE VEHICLE ABNORMALLY ACCELERATED AND CRASHED INTO ANOTHER VEHICLE. THERE WERE NO INJURIES. A POLICE REPORT WAS AVAILABLE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 95,000.
Vehicle speed control, Jul 12, 2010
TL*THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. WHILE DRIVING 50 MPH, THE ACCELERATOR PEDAL BECAME STUCK TO THE FLOORBOARD IN THE OPEN THROTTLE POSITION. THE VEHICLE PROCEEDED TO ACCELERATE WITHOUT DRIVER INTENT. THE CONTACT WAS ABLE TO STOP THE VEHICLE BY TURNING IT OFF. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CURRENT AND FAILURE MILEAGES WERE 86,000.
Engine and engine cooling, Jul 8, 2010
I HAVE A 2003 TOYOTA HIGHLANDER WITH ONLY 97,000 MILES THAT KEEPS "OVER HEATING". I HAVE REPLACED EVERYTHING UNDER THE HOOD EXCEPT THE ENGINE. THIS PROBLEM STARTED AROUND NOV. 2009. I HAVE READ OTHER BLOGS THAT HAVE THE SAME COMPLAINT AND IT APPEARS TO BE THE "BOLTS ON THE ENGINE ARE STRIPPED/DEFECTED" AND ALLOWS THE COOLANT TO LEAK OUT CAUSING OVERHEATING. ONE BLOG I READ STATED HE HAD THE "BLOTS" REPLACED AND THE NEW BOLTS ARE EXPANDING AND DOING THE SAME THING (OVER HEATING) AGAIN! I HAVE CALLED SEVERAL DEALERS AND SO FAR NO RECALL FROM TOYOTA TO FIX THIS PROBLEM, ALTHOUGH ONE DEALER SAID THERE IS A MEMO FROM TOYOTA REGARDING THIS PROBLEM, BUT NO RECALL! PLEASE HELP, I AM A SENIOR ON A FIX INCOME AND CAN NOT AFFORD THE COST OF A NEW ENGINE. I HOPE YOU CAN HELP ALL OF US WITH THIS PROBLEM.....THANK YOU. *TR
Visibility, Jul 6, 2010
HAVE AN 2003 TOYOTA HIGHLANDER THAT I BOUGHT NEW. HAVE USED SUN VISORS ON A REGULAR BASIS, AS THEY WERE INTENDED TO BE USED. THE DRIVER SIDE SUN VISOR KEEPS FALLING DOWN AND BLOCKING MY VIEW. THIS PARTICULARLY HAPPENS WHEN ANY BUMP IN THE ROAD IS RUN OVER. THIS CREATES A HAZARD DUE TO LIMITING MY SIGHT. I HAVE ATTEMPTED TO FIX BY TIGHTENING THE BOLTS THAT HOLD THE VISOR TO THE CEILING AND BY USING VELCRO TO HOLD THE VISOR TO THE ROOF. NEITHER OF THESE WORKED...THE VELCRO WILL NOT STICK TO THE CEILING ROOF. *TR
Engine and engine cooling, Jul 2, 2010
TL*THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED IN HIS GARAGE WHEN HE NOTICED COOLANT LEAKING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE TECHNICIAN STATED THAT THE FAILURE WAS CONTRIBUTED TO A DEFECTIVE ENGINE BLOCK. THE CONTACT NOTIFIED THE MANUFACTURER WHO CONFIRMED THAT THE WARRANTY HAD EXPIRED. THE MANUFACTURER WAS UNABLE TO PROVIDE ASSISTANCE AND INFORMED THE CONTACT THAT THERE WERE NO RELATED COMPLAINTS PERTAINING TO THE VEHICLE. THE VEHICLE HAD NOT BEEN REPAIRED WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 118,000. UPDATED 01/24/11 *CN UPDATED 04/18/11
Service brakes, Hydraulic, Jun 29, 2010
2003 TOYOTA HIGHLANDER. CONSUMER STATES PROBLEM WITH BRAKES *TGW THE CONSUMER STATED AFTER HE PICKED HIS VEHICLE UP FROM THE DEALER AFTER HAVING THE 60,000 MILE SERVICE DONE, HE HEARD A CLICKING NOISE COMING FROM THE FRONT WHEELS WHEN DRIVING OVER UNEVEN PAVEMENT OR SPEED BUMPS AT LOW SPEEDS. THE VEHICLE WAS TAKEN BACK TO THE DEALER WITHIN DAYS. THE VEHICLE WAS RETURNED TO THE DEALER AND THE CLICKING NOISE FROM THE BRAKES HAD BEEN REMEDIED. IN MARCH 2010, WHILE DRIVING ON THE HIGHWAY, THE CONSUMER DETECTED A SHIMMY COMING FROM THE FRONT END AND TRANSMITTING THROUGH THE STEERING WHEEL WHEN THE BRAKE WAS APPLIED. THE SHIMMY CONTINUED WITH INCREASED INTENSITY OVER TIME DURING HIS TRIP AND THERE WAS AN ODOR OF SMOKE COMING FROM THE PASSENGER SIDE OF THE VEHICLE. A CLOSER INSPECTION REVEALED, THE RIGHT FRONT WHEEL HAD EXCESSIVE BRAKE DUST AND IT SEEMED TO BE HOTTER THAN THE OTHER SIDE ALONG WITH A BURNING SMELL COMING FROM THE SAME LOCATION. THE CONSUMER RETURNED TO THE DEALER. THE CONSUMER WAS INFORMED THE ROTORS NEEDED TO BE REPLACED AND THE RIGHT FRONT CALIPER HAD SEIZED AND NEEDED TO BE REPLACED AS WELL. THE CONSUMER STATED ACCORDING TO THE INVOICE, THE ROTORS WERE REPLACED DUE TO EXCESSIVE HEAT, ALONG WITH THE BRAKE PADS AND CALIPER. *JB
Service brakes, Electric, Jun 26, 2010
TOYOTA HIGHLANDERS SUV BRAKE LIGHTS FOR YEARS 2002-2003 HAS A SERIOUS ISSUE WITH EITHER THE LEFT OR RIGHT BRAKE LIGHTING. MY WIFE'S 2003 TOYOTA LIMITED EDITION HIGHLANDER RIGHT REAR BRAKE LIGHT STOP WORKING ON 25 JUNE 2010. AFTER READING AND LEARNING MANY OTHER TOYOTA HIGHLANDERS OWNERS ARE HAVING THE SAME ISSUE, I HAD TO SUBMIT THIS, SINCE TOYOTA HAS NOT ANNOUNCED A RECALL FOR THIS PROBLEM. PLEASE CLICK HERE FOR OTHER COMMENTS FROM TOYOTA HIGHLANDER'S OWNER: HTTP://WWW.TOPIX.COM/FORUM/AUTOS/TOYOTA-HIGHLANDER/T7H7LD934GSQLC6BE. I WORRY ABOUT THIS ISSUE SINCE SO MANY OWNERS HAVE PAID A GREAT DEAL OF MONEY TRYING TO HAVE THIS IS RESOLVED, AND THE ONLY REPLY/RESPOND THEY RECEIVE FROM THE DEALERSHIP TECH'S ARE MORE MONEY AND A STATEMENT INFORMING THEM THAT THERE IS NOT A RECALL. I ALSO WORRY ABOUT THIS BECAUSE WHAT WOULD MY WIFE SAY TO A POLICE OFFICER IF SHE IS CITED REPEATEDLY? PLEASE ASSIST IN SERIOUS MATTER. *TR
Engine and engine cooling, Jun 1, 2010
MY WIFE'S TRUCK BEGAN LEAKING COOLANT. I WAS TOLD THE HEAD GASKET WAS BLOWN. I PAID NEARLY $1600 FOR THE REPAIRS. A YEAR LATER, THE COOLANT IS LEAKING. WHEN THE HEAD WAS PULLED, THE THREAD STRIPPED OUT ON 3 BOLTS. I FOUND THE SAME COMPLAINT NUMEROUS TIMES ON THIS WEBSITE AND ON OTHERS. AT THIS POINT, THE OPTIONS ARE THREAD INSERTS THAT MAY WORK OR A NEW ENGINE! AT THIS POINT, I HAVE BEEN ATTEMPTING TO GET HELP FROM TOYOTA. THERE HAS BEEN NOTHING TO DATE. *TR
Engine and engine cooling, Apr 28, 2010
TOYOTA HIGHLANDER 2003 2.4 LITER, BLOWN HEAD GASKET DUE TO STRIPPED THREADS ON THE SHORT BLOCK ENGINE. *TR
Vehicle speed control, Apr 15, 2010, crash
2003 TOYOTA 4DR. CONSUMER STATES UNINTENDED ACCELERATION. *TGW THE CONSUMER STATED SHE WAS ATTEMPTING TO PARK WHEN THE VEHICLE SUDDENLY ACCELERATED AND STRUCK A FENCE. THE CONSUMER BELIEVED THE ACCELERATOR WAS STUCK. *JB
Engine and engine cooling, Apr 1, 2010
MY 2003 HIGHLANDER HEAT GAGE INDICATED THE ENGINE WAS STARTING TO GET HOT. I PULL INTO SERVICE STATION TO CHECK COOLANT LEVEL AND NOTICED COOLANT LEAKING ON THE GROUND. I WAITED FOR ABOUT 15 MINUTES TO ASSURE MYSELF IT WAS SAFE TO TAKE OFF THE RADIATOR CAP. I COULD NOT SEE ANY COOLANT SO, I PURCHASED A GALLON OF PRE-MIXED COOLANT AND POURED IN ABOUT 1/2 TO 3/4 GALLON TO BRING IT UP TO FULL. I MADE THE TRIP HOME WITHOUT THE CAR GETTING HOT, BUT NOTICED THE LEAK WAS STILL THERE. I HAD THE VEHICLE LOOKED AT BY A LOCAL TOYOTA DEALER AND WAS TOLD THE CAR NEEDED MAJOR REPAIRS. THERE IS A TECHNICAL SUPPORT BULLITIN ON THE ENGINE IN QUESTION. A 2.4 LITRE (4 CYLINDER) ENGINE COMMON ON CAMARYS AND HIGHLANDERS. I FEEL TOYOTA SHOULD HAVE TO REPAIR THIS VEHICLE IN LIGHT OF THE FACT TOYOTA HAS KNOWN OF THE DESIGN DEFECT ON OTHER MODELS (CAMARY AND HIGHLANDERS). WHEN I TOOK THE CAR IN FOR REPAIRS THE SERVICE SCHEDULER KNEW EXACTLY WHAT PROBLEM I WAS DESCRIBING TO HIM ABOUT MY CAR. THIS INDICATED TO ME, TOYOTA HAS INFORMED THEIR DEALERS OF THE PROBLEM OR, THEY WOULDN'T HAVE SENT A SERVICE BULLITIN ON THE VERY FIX TO MY CARS PROBLEM. THE SERVICE BULLITIN DESCRIBED (3) HEAD BOLTS AROUND THE INTAKE MANIFOLD WOULD STRETCH AND FAIL TO SEAL THE HEAD THUS, LEAK COOLANT. THE BULLITIN EVEN DESCRIBES INSTALLING HELI-COILS IN THE (3) AFFECTED BOLTS TO SOLVE THE PROBLEM. THIS APPEARS TO BE ANOTHER FAILURE OF TOYOTA TAKING RESPONSIBILITY FOR KNOWN DEFECTS IN THEIR AUTOMOBILES. I BOUGHT AND PAID FOR THIS VEHICLE IN GOOD FAITH ON THE RELIABILITY RECORD OF THE TOYOTA COMPANY'S PAST RECORD. I NOW FEEL I HAVE BEEN TREATED UNFAIRLY BY THIS COMPANY. I WOULD UNDERSTAND IF THIS WAS AN ISOLATED OCCURANCE, BUT IT IS NOT AND TOYOTA KNOWS THIS FULL WELL. SERVICE BULLITINS DON'T GET SENT TO ALL DEALERS FOR A SINGLE OCCURANCE. PLEASE HELP !
Visibility, Mar 30, 2010
DRIVER SIDE SUN VISOR WILL NOT STAY IN PLACE. FLOPS DOWN TO OBSCURE VISION.