2004 Toyota Highlander
Problems, recalls and owner-reported issues
Power train is the leading concern among 286 owner complaints filed for this model year. This is the 6th highest complaint count among 25 Highlander model years with reports.
Of the 2004 reports, 32 involved a crash and 3 involved a fire. 23 people were injured and 47 people died.
What owners report most often
Recalls and investigations
Engine and engine coolingNov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V539000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V112000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderOct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Campaign 10V499000 on NHTSA.gov
Vehicle speed control, accelerator pedalJul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 06V253000 on NHTSA.gov
Latches/locks/linkages, doors, latchApr 15, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 04V181000 on NHTSA.gov
Representative owner complaints
286 reports, newest first.
Air bags, Feb 17, 2010, crash
TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH AND SWERVED TO AVOID ANOTHER VEHICLE. THE VEHICLE CRASHED INTO A LARGE PILLAR ON AN OVERPASS AND BOUNCED OFF OF IT INTO ONCOMING TRAFFIC. THE VEHICLE ALSO CRASHED INTO A SECOND PILLAR. THE DRIVER SUFFERED NO INJURIES. THE AIR BAGS FAILED TO DEPLOY WITH THE MASSIVE IMPACT OF THE CRASH. THE DEALER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE AIR BAG SENSOR MUST BE STRUCK IN A SPECIFIC AREA FOR THE DEPLOYMENT TO OCCUR. THE FAILURE MILEAGE WAS 42,498.
Vehicle speed control, Feb 16, 2010
EVER SINCE I PURCHASED MY HIGHLANDER, NEW, I INFREQUENTLY EXPERIENCE AN UNEXPECTED SURGE IN ACCELERATION WHILE BEGINNING TO ACCELERATE FROM A STOP, OR AFTER SLOWING TO TURN A CORNER. THIS HAS HAPPENED SEVERAL TIMES WHILE TURNING A CORNER. I HAVE BROUGHT THIS UP TO TWO DIFFERENT TOYOTA DEALERSHIPS, IN THE PAST, AND WAS TOLD THAT THEIR ELECTRONIC TRANSMISSION WAS THEIR BIGGEST COMPLAINT, BUT THERE WAS NOTHING THEY COULD DO ABOUT IT. WHILE DESCRIBING THE PROBLEM TO A SERVICE REP AT A DEALERSHIP, A GENTLEMAN, ALSO WAITING FOR SERVICE, INDICATED THAT HE HAD THE SAME PROBLEM WITH HIS NEWER MODEL RAV 4. THIS MAY HAVE HAPPENED FEWER THAN TWO DOZEN TIMES SINCE I PURCHASED THE HIGHLANDER. HAS THIS PROBLEM BEEN BROUGHT TO YOUR ATTENTION, OR DO YOU KNOW IF TOYOTA HAS EVER DEVELOPED A "FIX" FOR THIS? *TR
Vehicle speed control, Feb 15, 2010
WE HAVE A 2004 TOYOTA HIGHLANDER, AND WE HAVE HAD SURGES ON THE GAS SINCE WE BOUGHT IT IN 2004. IT USUALLY IS SOMETHING THAT WE CAN CONTROL, AS YOU WILL BE DRIVING ALONG, AND IT WILL SURGE FORWARD A BIT, BUT WE HAVE ALWAYS BEEN ABLE TO APPLY BRAKE AND CONTROL IT. THERE HAS ONLY BEEN ONE INSTANCE WHERE IT SURGED STRONGLY, AND I HAD TO SLAM ON THE BRAKES TO AVOID HITTING THE CAR IN FRONT OF ME. WE TRIED TO SELL THE CAR A COUPLE OF YEARS AGO, BUT THE BUYER TEST DROVE IT, AND NOTICED THE SURGING, ASKED ABOUT IT, AND THEN DECIDED NOT TO BUY IT - SO WE KEPT IT AFTER THAT. WE WERE THINKING IT IS A SOFTWARE PROBLEM, OR SOMETHING.... WE HAVE NEVER TAKEN IT INTO A SHOP TO HAVE IT DIAGNOSED, BUT THOUGHT MAYBE IT WAS IMPORTANT TO MENTION IT, IN CASE OTHER HIGHLANDERS HAVE HAD THE SAME ISSUE. I DIDN'T THINK IT WAS THE GAS PEDAL STICKING, BUT JUST THE GAS SURGING SOMEHOW, BUT MAYBE IT IS RELATED. *TR
Service brakes, Electric, Feb 9, 2010
2004 TOYOTA HIGHLANDER HAS 57,000 MILES, SINCE I OWNED THE CAR THE FOLLOWING OCCURS; ON SLIPPERY CONDITIONS THE VCS LIGHT WOULD COME ON AND IT WOULD TAKE A SECOND OR SO FOR BRAKES TO ENGAGE. TODAY ON A DRY PAVEMENT SURFACE (NO RAIN OR SNOW) THE VCS LIGHT SUDDENLY CAME ON WHEN TRAVELING 20 MILES AN HOUR LOCKING MY BRAKES FOR NO APPARENT REASON MAKING IT DIFFICULT TO STEER. I IMMEDIATELY PULLED CAR OVER TO THE SIDE OF THE ROAD TRIED DRIVING AGAIN BUT BREAKS IMMEDIATELY LOCKED UP ONCE I HIT 10-15 MILES AN HOUR AND STEERING WHEEL WAS ALSO LOOSE CAUSING DANGEROUS SITUATION. I HAD CAR TOWED TO TOYOTA DEALERSHIP AND IT IS CURRENTLY BEING DIAGNOSED, TECHNICIAN SAID THE STEERING ANGLE SENSOR IS FAULTY AND NEEDS TO BE REPLACED $500. NOT SURE IF THIS WILL CORRECT THE 1 SECOND GAP IN BREAK ENGAGEMENT ON SLIPPERY SURFACES WHICH HAS BEEN AN ISSUE SINCE I FIRST BOUGHT THE CAR IN 2004. *TR
Power train, Feb 7, 2010
MY 2004 TOYOTA HIGHLANDER LIMITED V6 DEVELOPED SUBSTANTIAL TRANSMISSION/ TRANSAXLE LEAK AT 56,000 MILES. TRANSMISSION FLUID WAS ABLE TO LEAK INTO THE FRONT TRANSAXLES AND THEN ONTO THE GROUND. TOYOTA IS AWARE THAT THE #2 AXEL SEAL IS AT FAULT AS IT IS WELL REPORTED. THE REPAIR WAS OVER $2,000. I FIXED MINE, BUT AM CONCERNED ABOUT THOSE THAT WON'T BE FIXED. I AM CONCERNED THAT IF THE TRANSMISSION LEAKS OUT IN TOTAL WOULD THE RESULTING TRANSMISSION FAILURE RESULT IN INJURY.*TW
Power train, Feb 6, 2010
HAVE A 2004 TOYOTA 3.3L 2WD HIGHLANDER THAT HAS HAD A SURGING PROBLEM WHEN TAKING OFF FROM A START SINCE I HAD IT NEW....DEALER RECALIBRATED COMPUTER BUT DIDNT FIX THE PROBLEM....THEY TOLD ME THIS IS NORMAL.....IT IS NOT NORMAL AND IS VERY DANGEROUS....BEING THEY DONT WANT TO FIX IT, I GUESS IT WILL COME DOWN TO A LAW SUIT IF SOMETHING HAPPENS.....THERE ARE ALL KINDS OF POST ON THIS PROBLEM AND TOYOTA SHOULD BE RECALLING AND FIXING......WONT NEVER BUY TOYOTA AGAIN IF SOMETHING ISNT DONE BECAUSE THEY STILL SEEM TO BE HAVING THIS PROBLEM IN OTHER MAKES AND MODELS IN TOYOTA LINE....AND LEXUS........*CN
Vehicle speed control, Feb 2, 2010
2004 TOYOTA HIGHLANDER, AWD AND A V6. THE VEHICLE HESITATES WHEN ACCELARATING AFTER BRAKING. CAN BE UP TO 3 SECONDS BEFORE POWER IS RESTORED. I BROUGHT THE VEHICLE BACK TO THE DEALER AND WAS TOLD THAT IS NORMAL. *TR
Vehicle speed control, Feb 1, 2010, crash
ON AUGUST 18TH 2007 I SENT A LETTER TO TOYOTA MOTOR SALES WRITING CONCERNING A PROBLEM WITH MY TOYOTA HIGHLANDER WHICH HAD SURGED IN A PARALLEL PARKING SITUATION HITTING THE CAR BEHIND AND DAMAGING IT AND MY VEHICLE. . HER HEADLIGHT AND BUMPER WERE DAMAGED. . THE REPAIR ON THE OTHER CAR CAME TO $1800.00. AND MORE. I REPORTED IT TO THE TOYOTA DEALER IN SPIRIT LAKE, IA. AND ALSO TO THE TOYOTA MOTOR SALES IN TOLEDO , OHIO 43699-0024. THE SPIRIT LAKE DEALER TOLD ME IT MUST HAVE BEEN CAUSED BY BAD GAS. *TR
Vehicle speed control, Jan 22, 2010
I JUST THOUGHT YOU SHOULD KNOW, LAST YEAR MY GAS PEDAL GOT STUCK. I HAVE A 2004 TOYOTA HIGHLANDER. WHEN I INVESTIGATED IT, I FOUND THAT THE PLASTIC PANEL TO THE RIGHT OF THE PEDAL HAD BROKEN LOOSE CAUSING THE PANEL TO LIFT UP SO THAT THE PEDAL COULD GET STUCK UNDER IT. THE PLASTIC SCREW HAD COMPLETELY SHEARED OFF. I WENT TO TOYOTA HERE IN BOULDER AND THEY REPLACE THE SCREW. WHY MANUFACTURERS USE PLASTIC SCREWS IS BEYOND ME. I WAS A LITTLE DISAPPOINTED THAT TOYOTA WOULD HAVE USED PLASTIC SCREWS FOR WHAT IS APPARENTLY A STRESSED AREA. I'M JUST GLAD I DID NOT HAVE AN ACCIDENT. IT WAS PRETTY SCARY! *TR
Vehicle speed control, Dec 9, 2009, crash
UNLOADING ITEMS FROM THE TRUNK OF THE 2004 TOYOTA HIGHLANDER AT THE BACK (BASEMENT) OF A NEW RESIDENCE. DROVE FROM THE BACK OF THE HOUSE TO THE FRONT WITH INTENTIONS OF BACKING UP TO THE GARAGE TO UNLOAD THE REMAINDER OF THE BOXES. I ENDED UP CROSSING THE ROAD DIRECTLY IN FRONT OF THE DRIVEWAY HITTING A TELEPHONE POLE HEAD ON; SMASHING MY HEAD AGAINST AND BREAKING THE WINDSHIELD. I HAVE INCURRED THOUSANDS OF DOLLARS IN MEDICAL BILLS, APPROXIMATELY $7,000 IN DAMAGE TO MY CAR AND A WEEK OFF OF WORK. *TR
Engine and engine cooling, Dec 6, 2009
COOLANT LOSS DUE TO STRIPPED HEAD BOLTS IN THE ENGINE BLOCK. ENGINE OVER HEATED. *TR
Electrical system, Exterior lighting, Nov 16, 2009
LENS PLATE COVERS OVER FOG LIGHTS ARE MELTING. THIS COULD RESULT IN A FIRE. *TR
Exterior lighting, Oct 7, 2009
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE PLASTIC ON THE HEADLIGHTS HAVE PEELED, SUBSEQUENTLY CAUSING THE LIGHTS TO APPEAR VERY DIM. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN CONCLUDED THAT BUFFING WOULD REMEDY THE FAILURE. THE FAILURE MILEAGE WAS 40000. THE CURRENT MILEAGE WAS 51400, UPDATED 10/19/09 *CN UPDATED 10/19/09
Steering, Aug 25, 2009
STEERING WHEEL MAKE A NOISE LIKE A BOLT IS MISSING. *TR
Steering, Power train, Electrical system, Wheels, Jun 8, 2009
2004 HIGHLANDER, HAVING SAME PROBLEMS AS ALL OTHER REPORTED PROBLEMS FOR THIS VEHICLE. HESITATION, STEERING SHAFT REPLACEMENT, 2 WHEEL BEARING REPLACEMENTS, LOUSY ORIGINAL TIRES, BAD SODERING OF HEAT/AIR BOARD LEADING TO NOT WORKING PROPERLY, CAN NOT HAVE BACK WINDOWS DOWN DUE TO NOISE AND VEHICLE SHAKING, HAD REAR WIPER MOTOR REPLACED WITHIN 1ST MONTH OF OWNERSHIP. WHILE I DID PURCHASE THE EXTENDED WARRANTY, WHICH DID COVER THE COST OF THE WHEEL BEARING REPLACEMENT, IT DID NOT COVER THE COST OF HAVING TO REPLACE THE TIRES DAMAGED BY THE BAD BEARING - AND TOYOTA DOES NOT CARE. IN THEIR RACE TO BECOME THE NUMBER ONE CAR MAKER, THEY HAVE GIVEN UP ON BEING THE SAFEST, MOST RELIABLE CAR MAKER - AND THEY HAVE CERTAINLY GIVEN UP ON BEING CUSTOMER FRIENDLY. ACCORDING TO SEVERAL TOYOTA DEALERS, THEY DON'T HAVE TO, SINCE THEY CONTINUE TO BE POPULAR SELLING VEHICLES. I AM GETTING NERVOUS AS THE TIME FOR MY WARRANTY COMES DUE TO EXPIRE - AND FOR THE FIRST TIME AM SERIOUSLY CONSIDERING TRADING IT IN BEFORE THAT HAPPENS. THAT WAS NOT THE INTENT WHEN I BOUGHT THE VEHICLE, BUT AFTER READING ALL THE PEOPLE HAVING ALL THE SAME PROBLEMS, I AM VERY CONCERNED. *TR
Steering, May 19, 2009
STEERING. LOOSENESS WHEN TURNING LEFT OR RIGHT. DEALER REPLACED PART (45220-48150 SHAFT ASSY) @ A COST OF $387.93 (THIS WITH A 15% DISCOUNT). IN READING YOUR COMPLAINTS FILED, I NOTE THIS WASN'T T/1ST TIME THIS HAS BEEN REPORTED & AS STATED, THERE IS A DEALER SERVICE ADVISORY ON IT. I ALSO TOOK NOTE THAT THERE APPARENTLY HASN'T BEEN ANY ACTION 2 RESOLVE THE MATTER (IE, THE OWNER CONTINUES 2 PAY 4 REPAIRS). SHOULD NOT TOYOTA B REQUIRED 2 COVER THIS TYPE OF REPAIR ? LIKE WE'RE TALKING STEERING HERE. IS IT GOING TO TAKE SOMEONE WHO JUST LET'S THE PROBLEM GO TO THE POINT WHERE HE/SHE LOOSES CONTROL OF THE VEHICLE & THERE IS PHYSICAL INJURY OR DEATH? I WAS HESITANT TO WRITE THIS UP BECAUSE I DON'T SEE WHERE N INVESTIGATION HAS BEEN CONDUCTED (DID I JUST MISS IT?). MY VEHICLE HAS JUST UNDER 55K MILES ON IT (ALL OF THEM ONROAD) &S BEEN MAINTAINED BY THE DEALER. TO ME IT LOOKS LIKE A $$$ MAKER 4 THE DEALER & A CALCULATED DECISION BY TOYOTA THAT ENOUGH OF THOSE REQUIRING THE REPAIR WOULDN'T COMPLAIN; LOOKS LIKE TOYOTA WINS. *TR
Electronic stability control (ESC), Apr 23, 2009
I AM THE OWNER OF A 2004 TOYOTA HIGHLANDER 2WD. THIS VEHICLE IS IN EXCELLENT CONDITION, LOW MILEAGE (ABOUT 40,000) AND HAS NEVER BEEN IN AN ACCIDENT. ON APRIL 19, THE VEHICLE STABILITY CONTROL/ANTI-SLIP BUZZER SOUNDED. THE ICON LIT ON THE DASHBOARD, AND THE VEHICLE STARTED TO BREAK AS IF THE CAR WAS SLIPPING. THE ROAD WAS DRY, OUR SPEED WAS EXTREMELY LOW (ABOUT 15MPH), AND THERE WAS NO REASON FOR THIS TO HAPPEN. THANKFULLY, WE WERE JUST OUT OF OUR DRIVEWAY AND COULD TURN SAFELY AROUND THOUGH THE PROBLEM PERSISTED. ON APRIL 20TH, WE PHONED TOYOTA OF KEENE TO MAKE AN APPOINTMENT TO BRING IN OUR VEHICLE. WE WEREN'T THRILLED WITH THE PROSPECT OF DRIVING UNDER THESE CONDITIONS, BUT FIGURED IF WE KEPT TO LOW SPEEDS WE SHOULD BE ABLE TO MAKE IT SAFELY. WE TOOK DOWN THE TOW COMPANY'S NUMBER JUST IN CASE. ON APRIL 21ST, MY HUSBAND SET OUT FOR THE APPOINTMENT FOR REPAIR IN KEENE. ABOUT 10 MILES FROM HOME, THE PROBLEM SUDDENLY WENT AWAY. THE SKID WARNING LIGHT WENT OUT AND THE VEHICLE STOPPED BREAKING AUTOMATICALLY. MY HUSBAND MADE IT THE REST OF THE WAY TO TOYOTA OF KEENE WITHOUT ANY ISSUES. AFTER A TEST DRIVE, THE TECHNICIAN STATED, 'THAT WAS THE SCARIEST TEST I'VE EVER EXPERIENCED,' AS THE PROBLEM HAD RETURNED WHILE HE WAS ON THE ROAD. BUT BY THE TIME HE RETURNED TO THE SHOP AND HOOKED UP THE CAR TO DIAGNOSTIC COMPUTERS, THE PROBLEM HAD AGAIN CEASED. TOYOTA OF KEENE HAS HAD MY VEHICLE SINCE APRIL 21ST, AND HAS BEEN UNABLE TO REPAIR IT OR OFFER ANY SOLUTION TO THIS ISSUE. THEY CLAIM THAT THEY CAN'T REPAIR IT IF THEY CAN'T REPLICATE THE PROBLEM WHILE THE VEHICLE IS HOOKED UP TO COMPUTERS. THOUGH I UNDERSTAND THIS EXPLANATION, IT DOES NOTHING FOR THE SAFETY OF MY FAMILY, AS WELL AS ANYONE ELSE ON THE ROAD. I CONTACTED THE TOYOTA COMPLAINT CENTER AND THEY OPENED UP A CASE NUMBER BUT WERE ESSENTIALLY USELESS IN ASSISTING ME. I DID SOME RESEARCH ON LINE AND FOUND A TECHNICAL SERVICE BULLETIN AS WELL AS CUSTOMER COMPLAINTS ABOUT THIS VERY ISSUE. *TR
Steering, Electronic stability control (ESC), Feb 25, 2009
WIFE WAS DRIVING ON CLEAN DRY ROAD. SUDDENLY, THE VCS LIGHT AND TRACTION LIGHTS CAME ON THE DASHBOARD WHILE ALARM SOUNDING CAME ON AS WELL. CAR SUDDENLY BRAKED, BRAKES MADE A GRINDING SOUND, AND CAR JERKED TO THE RIGHT. TRIED TO DRIVE FORWARD AND IT WOULD NOT GO OVER 10MPH. IF THE CAR DID, THE ABOVE HAPPENED AGAIN. CAR WAS NOT DRIVABLE, AND WAS TOWED TO THE NEAREST TOYOTA DEALERSHIP. THE SITUATION WAS VERY DANGEROUS, AS THE BEHAVIOR OF THE CAR, NOT CONTROLLED BY MY WIFE, THE DRIVER, COULD HAVE EASILY CAUSED AN ACCIDENT. TURNS OUT, THE DEALERSHIP STATED THE STEERING ANGLE SENSOR WENT ON THE CAR. FIRST...THE CAR ONLY HAS 53K MILES ON IT. THIS IS NOT A 'WEAR AND TEAR' PART. THIS PART SHOULD NEVER GO WITH ONLY THIS MANY MILES ON IT. GARBAGE. SECOND, THE FAILURE OF THIS PART CAUSES A VERY DANGEROUS SITUATION ON THE ROAD, AS ONCE IT GOES, THE DRIVER BASICALLY HAS NO CONTROL OVER THE CAR UNTIL IT SLOWS DOWN TO UNDER 10 MILES AN HOUR. TOYOTA NEEDS TO STAND BEHIND THEIR PRODUCT, FOCUS ON THE SAFETY OF THE PUBLIC, AND ISSUE A RECALL FOR THIS PROBLEM. I'VE RESEARCHED THIS ON THE INTERNET AND THERE ARE MANY, MANY COMPLAINTS AND DOCUMENTED CASES OF THIS SAME PROBLEM HAPPENING ON TOYOTA VEHICLES. THE DEALERSHIP FIXED THE PART FOR $700. RIP OFF. *TR
Visibility, Feb 16, 2009
VEHICLE BLOWS HOT AIR WHEN VENTILATION SYSTEM IS TURNED ON, EVEN WHILE A/C IS ON. *TR
Visibility, Feb 16, 2009
THE VEHICLE'S HEATING AND AIR SYSTEM CAUSES ME TO HAVE TO "JOGGLE" THE KNOB SEVERAL TIMES PRIOR TO IT BEGINNING TO PERFORM THE SPECIFIED NEED. *TR
Electrical system, Feb 16, 2009
THE HEAT WOULD NOT ALWAYS WORK. IT WOULD BLOW COLD AIR. SOMETIMES I COULD MOVE THE KNOB AROUND AND IT WOULD COME BACK ON BUT IT DIDN'T ALWAYS WORK LIKE THAT. I GOOGLED THE PROBLEM AND CAME UP WITH MORE THAN A DOZEN PEOPLE WITH THE SAME PROBLEM. THEY DEALER SAID THE PART WAS OVER $600 TO REPLACE, THEN ON TOP OF THAT, THE DECAL WAS GOING TO COST ANOTHER $30. ONE OF THE GOOGLE SEARCHES HAD A FIX FOR IT. IT INVOLVED REMOVING THE GLOVEBOX AND PULLING THE CIRCUIT BOARD OUT. THEY SAID THERE WOULD PROBABLY BE A WIRE THAT WAS BROKEN OFF AND SURE ENOUGH THERE WAS. MY HUSBAND SOLDERED IT BACK ON, PUT THE BOAR BACK IN, AND IT WORKS LIKE A CHARM NOW. *TR
Equipment, Jan 22, 2009
TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE HEAT DOES NOT ALWAYS WORK IN THE VEHICLE. SHE MUST TOGGLE WITH THE KNOBS IN ORDER FOR THE HEAT TO FUNCTION PROPERLY. OFTENTIMES WHEN THE HEATING SYSTEM WAS ACTIVATED, IT WOULD BLOW COLD AIR. IN ADDITION, WHEN THE COOLING SYSTEM WAS ACTIVATED, IT WOULD PRODUCE WARM AIR. THE DEALER STATED THAT THIS WAS A CONSISTENT FAILURE WITH THE HIGHLANDER, BUT NO REPAIRS COULD BE MADE DUE TO WARRANTY STIPULATIONS. THE MANUFACTURER STATED THAT THEY DID NOT HAVE ANY INFORMATION OR COMPLAINTS PERTAINING TO THIS TYPE OF FAILURE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 57,000.
Visibility, Jan 19, 2009
THE PASSENGER WINDOWS ON MY TOYOTA HIGHLANDER HAVE COME OFF THE TRACKS FOR THE SECOND TIME IN TWO YEARS. *TR
Air bags, Jan 19, 2009
2004 TOYOTA HIGHLANDER AIRBAGS NOT WORKING. *TR
Visibility, Jan 13, 2009
THE HEATER INSIDE MY CAR WON'T TURN OFF. I HAVE HOT AIR BLOWING CONTINUOUSLY, EVEN WHEN THE AIR SYSTEM IS TURNED OFF! THIS MAKES THE CAR DANGEROUS TO DRIVE FOR VERY LONG. (T>100 MOST OF TIME) THERE WAS NO ACCIDENT OR INCIDENT, IT JUST STARTED. THE PROBLEM IS WELL DOCUMENTED ON VARIOUS CAR FORUMS ONLINE DUE TO WIRE DEFECT. *TR