2005 Toyota Highlander
Problems, recalls and owner-reported issues
Power train is the leading concern among 225 owner complaints filed for this model year. This is the 13th highest complaint count among 25 Highlander model years with reports.
Of the 2005 reports, 35 involved a crash and 4 involved a fire. 20 people were injured.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Engine and engine coolingNov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V539000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V112000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderOct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Campaign 10V499000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalJul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 06V253000 on NHTSA.gov
Representative owner complaints: air bags
9 reports, newest first. Show all
Air bags, Apr 5, 2018, crash, fire
INVOLVED IN THEE CAR T-BONE COLLISION THAT CAUSED SEVERAL INJURIES TO UPPER AND LOWER EXTREMITIES. THE AIR-BAG FAILED TO INFLATE. VEHICLE WAS IN MOTION AT A CONTROLLED INTERSECTION ON A RURAL ROAD AND TURNING LEFT.
Electrical system, Air bags, Structure, Oct 25, 2017, crash
ON 7/23/2011 I WAS AT A COMPLETE STOP IN MY VEHICLE. I WAS HIT FROM BEHIND BY A CAR TRAVELING 70MPH+ AND PUSHED INTO A CAR IN FRONT OF ME. THE AIR BAG LIGHT WENT OFF, BUT AIR BAGS DID NOT DEPLOY.
Air bags, Seat belts, Service brakes, Nov 4, 2013, crash
TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 10 MPH FROM A COMPLETE STOP, THE BRAKE PEDAL TRAVELED TO THE FLOOR UPON ENGAGING. THE VEHICLE FAILED TO SLOW DOWN AND CRASHED INTO ANOTHER VEHICLE. THE DRIVER'S SIDE AIR BAG PARTIALLY DEPLOYED. THE CONTACT SUFFERED BRUISES AND MINOR PAIN TO THE CHEST AS A RESULT OF THE DRIVER'S SIDE SEAT BELT FAULTY WEBBING. IN ADDITION, THE SEAT BELT RETRACTOR WOULD NOT FUNCTION DURING THE CRASH. THE FRONT HOOD AND BUMPER WERE DAMAGED. THE VEHICLE WAS TOWED TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 37,804.
Air bags, Oct 27, 2011, crash
WE WERE INVOLVED IN A HORRIBLE ACCIDENT. A MOTORCYCLE WAS SPEEDING AND CRASHED INTO THE DRIVER'S SIDE OF THE VEHICLE. THE DOOR WAS SEVERELY BASHED IN, THE STEEL FRAME OF THE VEHICLE WAS BENT, AND THE FLOOR WAS COMING UP. I CALLED TOYOTA TO ASK WHY THE SIDE CURTAIN AIRBAG DID NOT DEPLOY. TWO DIFFERENT PEOPLE TOOK REPORTS. TODAY THEY CALLED ME AND TOLD ME THAT THEY WOULD ONLY DEPLOY IF THERE WAS A SEVERE INTRUSION, ENOUGH FOR PEOPLE TO BE HURT. I WAS HURT (BACK AND HEAD) AND MY LITTLE COUSIN SUFFERED A NOSEBLEED. HE ALSO SAID THE MOST IMPORTANT SAFETY FEATURE IS SEATBELTS. I SAID THERE WAS A SEVERE INTRUSION, BAD ENOUGH THE CAR WAS TOTALED. I TOLD HIM THAT I WAS VERY DISAPPOINTED IN HIM AND TOYOTA AND THAT I WAS ONLY CALLING BECAUSE THEY NEED TO KNOW THESE THINGS SO THEY CAN MAKE THEIR CARS SAFER. I HAD FOUR LITTLE CHILDREN IN MY CAR THAT DAY AND I ALWAYS THOUGHT WE WERE IN THE SAFEST CAR. NO MORE TOYOTAS FOR ME. *TT
Service brakes, Hydraulic, Air bags, Vehicle speed control, Mar 8, 2011, crash
TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. WHILE DRIVING 2-3 MPH IN REVERSE, THE VEHICLE ABNORMALLY ACCELERATED. THE CONTACT ATTEMPTED TO BRAKE BUT TO NO AVAIL AS THE VEHICLE CRASHED INTO HER GARAGE. THE AIR BAGS DID NOT DEPLOY BUT THE CONTACT WAS NOT INJURED AND THERE WAS MINIMAL DAMAGE TO THE VEHICLE AND MODERATE DAMAGE TO THE CONTACTS HOME. THE VEHICLE WAS TAKEN TO THE DEALER YET THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THERE WERE THREE ADDITIONAL OCCURRENCES OF THE FAILURE AND THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE REPAIRS WERE MADE TO THE FLOOR MAT AND THE BRAKE COVERS. THE CONTACT STATED THAT SHE WAS STILL AFRAID TO DRIVE THE VEHICLE. SHE LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V112000 (VEHICLE SPEED CONTROL:ACCELERATOR PEDAL) AND THE RECALL REPAIR WAS PERFORMED ON THE VEHICLE. THE FAILURE MILEAGE WAS 2,000 AND THE CURRENT MILEAGE WAS 20,000.
Air bags, Vehicle speed control, Oct 28, 2010, crash
TL*THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK, THE VEHICLE SUDDENLY ACCELERATED AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY WOULD INSPECT THE VEHICLE. AFTER THE FAILURE, THE CONTACT RECEIVED A RECALL NOTICE FOR RECALL 06V253000 (VEHICLE SPEED CONTROL: ACCELERATOR PEDAL). THE FAILURE MILEAGE WAS 44,200. UPDATED 01/31/11/ *BF UPDATED 04/20/11
Air bags, Feb 20, 2010, crash
THE SIDE AIRBAGS FAILED TO DEPLOY. THE TOYOTA HIGHLANDER WAS INITIALLY STRUCK ON THE FRONT PASSENGER SIDE NEAR THE FRONT END OF VEHICLE. THE VEHICLE WAS THEN STRUCK (T-ED) ON THE DRIVER'S SIDE BY A LARGE PICKUP TRUCK (APPROX SPEED 60 MPH). THE IMPACT DENTED THE DOORS TO THE SEATS AND BOTH DRIVER'S SIDE DOORS WOULD NOT OPEN DUE TO THE IMPACT. VSC, ABS WERE ENGAGED AS EVIDENCED BY THE PANEL LIGHTS ON AT THE END OF THEE CRASH, HOWEVER NO AIRBAGS DEPLOYED RESULTING IN TRAUMATIC BRAIN INJURY (CLOSED HEAD INJURY), POST CONCUSSIVE SYNDROME, GRAND MAL SEIZURE, RETROGRADE AMNESIA FOR DRIVER. VEHICLE ALSO HAD A THIRD IMPACT AS IT WAS PUSHED INTO BARRIER WALL. *TR
Air bags, May 28, 2008, crash
TL*THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. WHILE STOPPED IN TRAFFIC, THE CONTACT'S VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE TRAVELING 40 MPH. THE CONTACT'S AIR BAGS FAILED TO DEPLOY AND SHE SUSTAINED INJURIES TO HER HEAD, BACK, CHEST, AND LEGS. THE OTHER DRIVER WAS UNINJURED AND A POLICE REPORT WAS FILED. THE VEHICLE IS CURRENTLY BEING DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 32,000.
Air bags, Jan 2, 2006, crash
WHO DO I NEED TO SPEAK WITH REFERENCE EASE OF ROLLOVER OF THE TOYOTA HIGHLANDER AND THE FACT THAT THE AIR BAGS DID NOT OPEN AT ALL WHEN I WAS FLIPPED OVER THREE TIMES? THE SPEED WAS NOT A FACTOR I WAS DOING 25 MILES WHEN BROADSIDED BY A 87 FORD RANGER GOING 25, WHICH HIT THE DRIVER DOOR LOW IMPACT ON THE HIGHLANDER SENT MY HIGHLANDER AIRBORN FLIPPING AND SPINNING. THE PRINCE WILLIAM POLICE HAVE THE REPORTS ON THE ACCIDENT. THE HIGHLANDER IS IN STATE FARM HANDS NOW. THE ACCIDENT HAPPENED ON MAY 14TH IN PRINCE WILLIAM COUNTY ON ROUTE 1. *NM