2005 Toyota Highlander
Problems, recalls and owner-reported issues
Power train is the leading concern among 225 owner complaints filed for this model year. This is the 13th highest complaint count among 25 Highlander model years with reports.
Of the 2005 reports, 35 involved a crash and 4 involved a fire. 20 people were injured.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Engine and engine coolingNov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V539000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V112000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderOct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Campaign 10V499000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalJul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 06V253000 on NHTSA.gov
Representative owner complaints: power train
51 reports, newest first. Show all
Power train, Feb 4, 2010
MY 2005 TOYOTA HIGHLANDER HAS CHRONIC TRANSMISSION PROBLEMS. WHEN ACCELERATING, THE ENGINE REVS BUT THE TRANSMISSION HESITATES NOTICEABLY BEFORE GOING INTO GEAR. SOMETIMES THE HESITATION LASTS SO LONG THAT IT INTERFERES WITH MY ABILITY TO MERGE ONTO THE FREEWAY AND THOSE ARE VERY SCARY SITUATIONS. SOMETIMES THE TRANSMISSION CANNOT DECIDE WHAT GEAR TO BE IN AND WHEN IT DOES ENGAGE THE WHOLE CAR BUCKS OR SHUDDERS. EVERYONE WHO DRIVES MY CAR EXPERIENCES THE SAME PROBLEM. EVEN THE PASSENGERS NOTICE. THE TOYOTA DEALER CLAIMS THAT THERE IS NO PROBLEM WITH THE VEHICLE AND THAT THE PROBLEM IS MY DRIVING AND THAT I HAVE NOT ADJUSTED TO THE CAR'S "DRIVE BY WIRE" SYSTEM. ONE MECHANIC DID ADMIT THAT THERE WERE ISSUES WITH THE TRANSMISSION'S COMPUTER FOR THIS MODEL YEAR. OTHER THAN THAT, TOYOTA INSISTS THAT THERE IS NO PROBLEM AND THAT I HAVE TO LEARN HOW TO DRIVE THE CAR. *TR
Power train, Equipment, Jan 28, 2010
MY 2005 TOYOTA HIGHLANDER V6 4WD, WHICH I PURCHASED NEW, HAS BEEN EXPERIENCING A HESITATION/SHIFTING PROBLEM FOR NEARLY AS LONG AS I HAVE OWNED THE VEHICLE. WHILE THE PROBLEM DOES NOT ALWAYS OCCUR, IT IS QUITE PRONOUNCED WHEN IT DOES AND HAS RESULTED IN VERY DANGEROUS SITUATIONS. THE PROBLEM HAS BEEN BROUGHT TO THE DIRECT ATTENTION OF TOYOTA MOTOR SALES IN CALIFORNIA, AND THEIR RESPONSE HAS BEEN DISTURBINGLY POOR. THE TOYOTA DEALER THAT HAS BEEN SERVICING MY VEHICLE HAS BEEN VERY HELPFUL, BUT APPARENTLY CANNOT TAKE ACTION TO CORRECT THE PROBLEM WITHOUT CORPORATE AUTHORIZATION. HERE IS A SUMMARY OF THE PROBLEM: THE VEHICLE CANNOT ALWAYS DECIDE WHEN TO ACCELERATE FROM A STOP - THERE HAVE BEEN MANY INSTANCES OF INITIAL HESITATION/LACK OF ADEQUATE POWER UPON APPLYING THE GAS PEDAL. FOR EXAMPLE, I HAVE EXPERIENCED A DELAY OF A SECOND OR TWO WHEN APPLYING THE GAS PEDAL TO PROCEED. THIS HAS RESULTED IN SOME VERY CLOSE CALLS WITH ONCOMING TRAFFIC. ALSO, THERE ARE OCCURRENCES WHERE THE VEHICLE CANNOT SEEM TO DECIDE BETWEEN GEARS (IT WILL SOMETIMES JUMP UP/DOWN BETWEEN THE LOWER GEARS, SUCH AS 1ST TO 2ND GEAR AND/OR 2ND TO 3RD GEAR). FURTHERMORE, I HAVE NOTICED A GENERAL LACK OF ADEQUATE ACCELERATION/GAS PEDAL RESPONSE, ESPECIALLY DURING CITY DRIVING (IE. LOWER SPEEDS). MY LOCAL TOYOTA DEALER HAS RECORDS OF THE PROBLEM SINCE APPROXIMATELY 16,000 MILES (THE VEHICLE NOW HAS ABOUT 44,000 MILES). I BELIEVE THE ISSUE IS THE ECM, WHICH WAS REPROGRAMMED BUT THE PROBLEM RETURNED. BASED ON MY RESEARCH, I BELIEVE THE ECM MAY BE DEFECTIVE AND THAT REPLACING THE UNIT MAY SOLVE THE PROBLEM. TOYOTA WILL NOT REPLACE THE ECM. ABOUT A MONTH AGO, THE TOYOTA DEALER WAS ABLE TO VERIFY THE HESITATION PROBLEM DURING A SERVICE VISIT. HOWEVER, THEY COULD NOT DUPLICATE IT LATER WITH THE SCAN TOOL ATTACHED - THEY HAD THE VEHICLE FOR TWO DAYS TRYING TO GET A SNAP SHOT BECAUSE THE TOYOTA FIELD SERVICE TECHNICIAN TOLD THEM "NO REPAIRS ARE TO BE MADE UNTIL THE PROBLEM OCCURS MORE OFTEN." TW*
Power train, May 26, 2009
AUTOMATIC TRANSMISSION IS FORCING FLUID OUT THROUGH VENT CAUSING LOSS OF FLUID AND POSSIBLE DAMAGE TO TRANSMISSION. DEALER SAID IT IS CAUSED BY BEARING GOING BAD IN THE TRANSMISSION. VEHICLE HAS ALMOST 90,000 MILES. DEALERSHIP SAID PROBLEM IS COVERED UNDER EXTENDED WARRANTY SINCE IT WAS A CERTIFIED USED VEHICLE. *TR
Power train, Feb 21, 2008
2005 TOYOTA HIGHLANDER WITH ONLY 72000 MILES (12,000 MILES OUT OF WARRANTY), SEALS ON TRANSFER CASE OF TRANSMISSION LEAKS ONTO EXHAUST PIPE CAUSING SMOKING AND SMELL OF BURNT FLUIDS. *TR
Power train, Dec 26, 2007
I HAVE A 2005 HIGHLANDER THAT DEVELOPED A TRANSMISSION FLUID LEAK AT 62,000 MILES. TOYOTA CURRENTLY HAS A SERVICE BULLETIN OUT STATING THAT THE TRANSMISSION SEAL ON CERTAIN AWD HIGHLANDERS AND SIENNAS ARE PRONE TO PREMATURE FAILURE. THIS CAN RESULT IN LEAK OF TRANSMISSION OR FRONT DIFFERENTIAL FLUID. THE REPAIR IS NOT BEING COVERED UNDER THE WARRANTY FOR ME SINCE THE CAR IS BEYOND THE 60000 MILE POWERTRAIN WARRANTY. THE LOSS OF TRANSMISSION OR GEAR OIL CAN LEAD TO SUDDEN FREEZING OF DIVE-AXLE, WHICH SHOULD BE CONSIDERED A SERIOUS SAFETY ISSUE. *TR
Power train, Aug 23, 2007
2005 V6 TOYOTA HIGHLANDER - TRANSMISSION UPDATE FLASH - DOES NOT RESOLVE LAG ISSUE AS INTENDED, AND LATER MAKES TRANSMISSION STUTTER AND JERKY - NOT RESOLVED AFTER TRANSMISSION FLUID CHANGE AND INSPECTION. TWO DEALERS STATED: COULD NOT REPLICATE ISSUE. FAMILY AND FRIENDS HAVE DRIVEN AND RIDDEN IN VEHICLE AND STATE THEY FEEL IT DRIVES LIKE AN OLD CAR OR WORSE - MAKES NOISES AND IS NOT SMOOTH, ALSO CAN BE DANGEROUS IF A QUICK RESPONSE IS NECESSARY. *TR
Power train, Aug 4, 2007
THIS PROBLEM HAS BEEN HAPPENING FROM THE FIRST MONTH I BOUGHT MY 2005 TOYOTA HIGHLANDER NEW AT THE DEALERSHIP. TRANSMISSION SHIFT ERRATICALLY. JOLTING SHIFTS ALL THE TIME; ESPECIALLY WHEN ACCELERATING. LAGS IN DOWNSHIFTING, HESITATION IN SHIFTING. I'VE TAKEN IT TO THE TOYOTA DEALERSHIP MANY TIMES. THEY HAVE SAID IT IS LEARNING MY DRIVING HABITS. ONE DEALERSHIP TOLD ME TO TAKE MY FOOT OFF THE GAS AND DEPRESS IT AGAIN - THIS TELLS THE TRANSMISSION WHAT I REALLY WANT TO DO. HE ALSO SAID TO BE AGGRESSIVE WITH THE GAS. MOST OF THE TIME THE DEALERSHIPS SAY THERE DOESN'T SEEM TO BE ANYTHING WRONG WITH IT. BUT I'VE NOTED THAT THEY NEVER TYPE IN MY COMPLAINT ON THE WORK ORDERS. *JB
Power train, Apr 13, 2007
TOYOTA HILANDER LIMITED. I HAVE A HESITATION WHEN I ACCELERATE. I HAVE HAD IT BACK TO TOYOTA AT LEAST 3 TIMES CONCERNING THIS PROBLEM. THEY TELL ME THAT'S THE WAY IT'S SUPPOSED TO BE. IT'S DANGEROUS IF YOU ARE TRYING TO GET ON AN INTERSTATE AND DON'T HAVE THE ACCELERATION YOU NEED. *AK
Power train, Mar 9, 2007
PURCHASED A NEW 2005 TOYOTA HIGHLANDER 4WD. AFTER 45K MILES THE 4WD TRANSFER CASE BEGAN TO LEAK GEAR OIL AND TRANSMISSION FLUID. I NOTICED THIS SINCE I DO ALL MY OWN OIL CHANGES ON THE VEHICLE. NO HARM WAS DONE, BUT I HAVE BROUGHT THE SAME PROBLEM TO THE DEALERSHIP 5 TIMES. EACH TIME THEY STATED THAT THEY HAVE REPAIRED THE PROBLEM. HOWEVER, WITHOUT FAIL SEVERAL MONTHS LATER I AM STILL EXPERIENCING THE PROBLEM. TOYOTA'S CUSTOMER SERVICE WAS NOT VERY FRIENDLY OR HELPFUL. ONE REPRESENTATIVE STATED THAT THE DEALERSHIP REALLY DID NOT HAVE THE TOOLS TO PROPERLY FIX THE TRANSFER CASE SEALS PROPERLY. MY SAFETY ISSUE: IF THIS TRANSFER CASE FAILS AGAIN AND I DO NOT NOTICE IT, THEN I FEAR THAT THE VEHICLE COULD BE SENT INTO AN UNCONTROLLABLE SPIN OR EVEN WORSE. THUS FAR TOYOTA HAS REPLACED THE TRANSFER CASE TWICE AND THE TRANSMISSION ONCE WITH A RE-MANUFACTURED TRANSMISSION. *JB
Power train, Dec 1, 2006
I OWN A 2005 TOYOTA HIGHLANDER V6. I'M EXPERIENCING A PAUSE OR HESITATION SHIFTING INTO LOW AT VERY LOW SPEEDS (2 TO 4 MPH). THE HESITATION CAUSES THE VEHICLE TO LUNGE BECAUSE THE GAS PEDDLE IS DEPRESSED BEFORE THE LOW GEAR ENGAGES. I FEEL IT IS AN UNSAFE DESIGN BECAUSE IN SLOW TRAFFIC OR NEAR PEDESTRIANS I NEED TO KEEP MY LEFT FOOT ON THE BRAKE TO PREVENT THE CAR FROM LUNGING. TOYOTA HAS INFORMED ME THAT THE VEHICLE IS "OPERATING AS DESIGNED". *NM
Power train, Sep 20, 2006
LONG HESITATION WHEN TRYING TO ACCELERATE FROM A STOP OR LOW SPEEDS. *JB
Power train, Jul 15, 2006
SUMMARY: 2005 TOYOTA HIGHLANDER HAS SIGNIFICATION HESITATION WHEN ACCELERATING. 1.) EVENTS LEADING TO FAILURE: FAILURE IS CONSTANT SINCE IT IS PRESENT DURING NORMAL OPERATION OF VEHICLE; 2. FAILURE AND ITS CONSEQUENCES: IF I ACCELERATE (STEP ON THE GAS PEDAL), THE VEHICLE HESITATES/LAGS/DIES FOR A FEW SECONDS BEFORE VEHICLE WILL BEGIN MOVING. THE CONSEQUENCES OF THIS FAILURE IS THAT THERE IS CONSTANT DANGER WHEN MAKING A LEFT TURN DURING GAPS IN ONCOMING TRAFFIC. ALTHOUGH A MARGIN OF SAFETY IS ALWAYS USED, I AM AFRAID THAT ONE DAY, SOMETHING MAY HAPPEN TO REDUCE THIS MARGIN, E.G. ONCOMING CAR IS ACCELERATING VERY QUICKLY OR THE HESITATION WORSENS FROM A FEW SECONDS TO SEVERAL SECONDS; 3.) WHAT WAS DONE TO CORRECT THE FAILURE: NOTHING. CONTACTED TWO TOYOTA DEALERS, DON DAVIS TOYOTA AND FREEMAN TOYOTA, AND WAS TOLD BY JOHN AND TIM, SERVICE DEPT ADVISORS, THAT THIS IS NORMAL FOR TOYOTAS SINCE ADOPTING FLY-BY OR DRIVE-BY WIRE. BOTH AUTHORIZED TOYOTA SERVICE DEPARTMENT EMPLOYEES SAY THAT TOYOTA IS AWARE OF THIS COMPLAINT BUT THAT THERE IS NOTHING TO BE DONE; THIS IS NORMAL OPERATING PROCEDURE AND FALLS WITHIN THEIR DESIGN PARAMETERS. NO PARTS WILL BE REPAIRED OR REPLACED. THIS SEEMS TO BE A DANGEROUS DESIGN FLAW BY TOYOTA. WHILE THEY ACKNOWLEDGE THE EXISTENCE OF THE PROBLEM, THEY DO NOT FEEL THEY NEED TO RESOLVE AND OFFER NO SOLUTION. *JB
Power train, Jul 13, 2006
2005 TOYOTA HIGHLANDER. ISSUES WITH AUTOMATIC TRANSMISSION SHIFTING PROPERLY. SHIFT LAGS SEVERELY WHEN GAS PEDAL IS ENGAGED CAUSING VEHICLE TO LAG BEHIND AND NOT CATCH UP TO THE PROPER SPEED. VEHICLES BEHIND IT ARE IN A POSITION TO SEVERELY IMPACT THE REAR BUMPER BECAUSE VEHICLE IS NOT MOVING. HAVE HAD CAR TO DEALER AND THEY CLAIM THERE'S NOTHING THEY CAN DO. HAVE ASKED THEM TO CHECK SERVICE BULLETINS AND SEE ABOUT RESETTING THE COMPUTER WHICH TOYOTA CLAIMS IS THE PROBLEM. RESETTING THE COMPUTER DOESN'T WORK. *JB
Power train, Vehicle speed control, Jul 4, 2006, crash
UNEXPLAINED VEHICLE ACCELERATION WITH INABILITY TO STOP BEFORE HITTING VEHICLE IN FRONT OF ME. PULLED OFF OF ROAD BEHIND TRUCK TO PARK. LIFTED FOOT FROM GAS PEDAL TO PUT ON BRAKE SO AS TO PUT VEHICLE INTO PARK. THERE WAS THEN AN EXTREME VEHICLE ACCELERATION WHICH WAS UNCONTROLLABLE WITH BRAKE. SLAMMED INTO TRUCK. TOYOTA CORP CLAIMS NO ERRORS LOGGED IN COMPUTER SYSTEM, AND THAT IF FOOT WOULD HAVE BEEN ON BRAKE PEDAL, THE FILAMENT WOULD HAVE BROKEN. I CAN'T BE CERTAIN THE BRAKING HAPPENED BEFORE THE ACCIDENT-IT WAS VERY FAST. I AM CERTAIN FOOT WAS ON BRAKE AND NOT ON GAS!! THERE HAS BEEN A PREVIOUS DENIAL OF A PETITION TO INVESTIGATE NUMEROUS INSTANCES OF THIS IDENTICAL SITUATION WITH OTHER TOYOTA'S-(NHTSA ACTION # DP05002). NHTSA PLEASE INVESTIGATE THIS!! THERE ARE TOO MANY COMPLAINTS OF THIS HAPPENING-DO SOMETHING BEFORE THERE ARE DEATHS! IS TOYOTA IMMUNE FROM SAFETY RECALLS? I'M SORRY YOU COULDN'T FIND EVIDENCE OF A DEFECT, BUT THERE IS SOMETHING SERIOUSLY WRONG. SEVERE HESITATION, SUDDEN ACCELERATION=POSSIBLE DEATHS. I'VE RECEIVED MY REPAIRED VEHICLE, AND WHEN I WENT TO TRADE IT IN, I WAS OFFERED THOUSANDS LESS THAN TRADE IN IS SUPPOSED TO BE! IF TOYOTA REALLY BELIEVES THERE'S NOTHING WRONG WITH THEIR CAR, WHAT'S THE PROBLEM? AGAIN THEY'RE NOT BEING HELD ACCOUNTABLE! *NM
Power train, May 4, 2006
I HAVE MADE NUMEROUS COMPLAINTS ABOUT THE FUNCTIONING OF THE TRANSMISSION IN MY 2005 TOYOTA HIGHLANDER. IT BEGAN ONE MONTH AFTER I PURCHASED THE NEW CAR. THE PROBLEMS HAVE PROGRESSIVELY GROWN WORSE AND ARE MORE FREQUENT. THE DEALERSHIP INDICATES THAT THE HESITATION AND JERKING OF THE TRANSMISSION IS NORMAL AND A RESULT OF THE ELECTRONIC CONTROLLING OF THE TRANSMISSION. EVEN AFTER THE DEALERSHIP UPDATED THE SOFTWARE, THE TRANSMISSION CONTINUES TO HAVE PROBLEMS. THE DEALERSHIP NOR TOYOTA HAVE NOT OFFERED ANY SOLUTIONS. *JB
Power train, Feb 21, 2006
MULTIPLE TIMES, I HAVE TRIED TO ACCELERATE THE VEHICLE AND THERE HAS BEEN "HESITATION" WHEN I DEPRESSED THE GAS PEDAL--THE CAR SEEMED TO BE IN NEUTRAL, THERE WAS NO RESPONSE. THIS HAS HAPPENED MANY TIMES AT DIFFERENT SPEEDS/GEARS--IT IS NOT PREDICTABLE. I HAVE ALMOST BEEN REAR ENDED ONCE; IN THAT INSTANCE THE CAR ACTUALLY "BUCKED" AND STOPPED. I HAD TO TURN OFF THE ENGINE, RESTART, AND DRIVE A SHORT DISTANCE TO A SAFE PLACE TO STOP. AT OTHER TIMES, I HAVE BEEN ON A RELATIVELY EMPTY STREET AND IT HAS NOT BEEN AS MUCH OF A PROBLEM SINCE NO ONE WAS BEHIND ME. HOWEVER, THIS IS AN ACCIDENT WAITING TO HAPPEN AS I HAVE A LONG COMMUTE TO WORK (AND BOUGHT THIS CAR BECAUSE OF WHAT I THOUGHT WAS ITS SAFETY AND RELIABILITY). ON MY FIRST VISIT TO THE DEALER, TOYOTA MADE A FIX ACCORDING TO A TECHNICAL BULLETIN. ON THE SECOND VISIT, THEY DID NOTHING BECAUSE THEY COULD NOT REPLICATE THE PROBLEM--EVEN THOUGH THEY WERE TOLD THAT THE PROBLEM HAPPENS INTERMITTENTLY. ON THIS SECOND VISIT, THEY MERELY TEST DROVE THE VEHICLE AND WE WERE TOLD WE COULD RENT A LOANER VEHICLE FROM THEM AT THEIR COST BECAUSE THERE WAS NO PROBLEM WITH THE VEHICLE. *JB
Power train, Dec 14, 2005
RECURRING ISSUE: WHILE TRAVELING AT BOTH HIGHWAY AND CITY STREET SPEEDS, THE DRIVER ATTEMPTED TO PASS BY FULLY DEPRESSING THE ACCELERATOR AND THE VEHICLE FAILED TO ACCELERATE FOR APPROXIMATELY 1-2 SECONDS. THIS HAS RESULTED IN NEAR-MISS ACCIDENT/INJURY INCIDENTS. THE DEALER WAS CONTACTED AND STATED THIS WAS A ROUTINE COMPLAINT FOR THIS VEHICLE AND THE LEXUS RX-330. THE MANUFACTURER, TOYOTA CORPORATE, WAS CONTACTED AND THE INDIVIDUAL STATED THIS WAS NOT A KNOWN ISSUE. NO MEDIATION WAS PROVIDED FROM EITHER CONTACT. THIS ISSUE SEEMS TO BE RELATED TO EXISTING ODI ID NUMBERS: 10113278, 10114325, 10115243, 10120592, 10128880, 10129705, 10131894, 10132578, 10137651, 10145021. *JB
Power train, Dec 12, 2005
CAR IS A 2005 TOYOTA HIGHLANDER LTD. V-6 4WD WITH 5-SP AUTO. ENGINE HESITATES SEVERELY WHEN ASKED TO ACCELERATE HARD AT SPEEDS SEEMINGLY BETWEEN 15 AND 70 MPH. (THESE ARE SPEEDS I'VE NOTICED IT) WHEN YOU "FLOOR" THE THROTTLE TO QUICKY MERGE WITH TRAFFIC OR TURN ACROSS A LINE OF ONCOMING TRAFFIC, THERE IS A RATHER LONG DELAY BEFORE VEHICLE BEGINS TO ACCELERATE. THIS BEHAVIOR ALSO OCCURS EXACTLY THE SAME WAY IN MY WIFE'S 2004 LEXUS RX-330, WHICH HAS THE SAME POWERTRAIN. I COMPLAINED TO LEXUS SHORTLY AFTER THE PURCHASE (BOUGHT NEW) AND THEY SAID THEY FOUND NOTHING WRONG. I'VE BEEN ON SEVERAL TOYOTA HIGHLANDER NEWSGROUPS AND THIS PROBLEM IS BEING WIDELY REPORTED. I HAVE HAD SEVERAL "CLOSE CALLS" BECAUSE OF THIS DELAYED ACCELERATION. IN THE TIME THAT THE CAR DECIDES TO DOWNSHIFT AND ACCELERATE, TRAFFIC HAS CLOSED IN ON YOU ENOUGH THAT SEVERAL ACCIDENTS HAVE BEEN NARROWLY AVOIDED. I HAVE NOT REPORTED THIS TO TOYOTA AS YET, BUT FEEL THAT THEY WILL SAY THE SAME AS LEXUS DID. *NM
Power train, Dec 2, 2005
AUTOMATIC TRANSMISSION HESITATION - WHEN NEEDING TO ACCELERATE QUICKLY (AS WHEN ENTERING A FREEWAY) AFTER SLOWING DOWN OR COASTING, THE TRANSMISSION HAS DOWNSHIFTED TO A TOO-LOW GEAR OR NEUTRAL. THE ENGINE SPEEDS UP TO APPROXIMATELY 5000 RPM WITHOUT INCREASING THE CAR SPEED. LETTING UP ON THE GAS AND ACCELERATING MORE EASILY ALLOWS THE VEHICLE SPEED TO INCREASE. SO FAR, THIS HESITATION HAS NOT CAUSED ME TO BE REAR-ENDED. THE DEALER SAYS THIS OPERATION IS "NORMAL." *NM
Power train, Nov 14, 2005
ON OUR 2005 TOYOTA HIGHLANDER WITH A 4 CYLINDER ENGINE, AND ELECTRONIC TRANSMISSION. ON SEVERAL OCCASIONS, WHEN TAKING OFF FROM A STOP, LETTING OFF ON THE ACCELERATOR, AND IMMEDIATELY PUSHING THE ACCELERATOR RATHER HARD TO ATTEMPT TO MERGE INTO TRAFFIC, THE VEHICLE'S ENGINE INCREASES RPM'S, BUT NO POWER GOES TO THE WHEELS. IT IS AS IF THE TRANSMISSION COMPUTER CANNOT DETERMINE WHAT GEAR TO SHIFT INTO. YOU HAVE TO LET OFF THE ACCELERATOR, AND LET THE RPM'S COME BACK DOWN, AND THEN THE VEHICLE FINALLY DETERMINES WHAT GEAR TO SHIFT INTO, AND YOU CAN THEN PRESS DOWN ON THE ACCELERATOR TO REGAIN FORWARD MOMENTUM. WHEN YOU ARE TRYING TO MERGE INTO TRAFFIC, YOU NEED TO KNOW THAT WHEN YOU STEP ON THE ACCELERATOR, THE CAR IS GOING TO SHIFT INTO THE PROPER GEAR, AND MOVE FORWARD ACCORDINGLY. VERY DANGEROUS SITUATION IN MY OPINION. TOYOTA DEALERSHIP SAID THERE IS NOTHING WRONG WITH THE TRANSMISSION. THIS LOSS OF TRANSMISSION ACCELERATION HAS HAPPENED ON NUMEROUS OCCASIONS, NOT JUST ONCE. *NM
Power train, Vehicle speed control, Sep 8, 2005
DT: 2005 TOYOTA HIGHLANDER V6- THE CONSUMER DROVE OFF THE LOT ON JUNE 3, 2005; THE CRUISE CONTROL BEHAVED ERRATICALLY AND IT OFTEN FELT AS IF IT WAS ACCELERATING A COUPLE OF MILES BEHIND THE DESIRED SPEED. THE CONSUMER REQUESTED TO PASS THIS TURKEY WHICH YIELDED DIFFERENT RESULTS. THERE IS SOMETIMES AWKWARD DOWN SHIFTING AND RAPID ACCELERATION WHICH IS PRECEDED BY HESITATION. THE CONSUMER APPROACHED A VILLAGE INTERSECTION, DOWNHILL WITH HIS FOOT ON THE BRAKE. THE CONSUMER TOOK HIS FOOT OFF OF THE BRAKE AND BEGAN TO MAKE A LEFT TURN ONTO DESIRED STREET. THE CONSUMER TRIED TO APPLY A BIT OF GAS AND NOTHING HAPPENED. THE CONSUMER TRIED TO APPLY A BIT MORE GAS AND AGAIN NOTHING HAPPENED. THE THIRD TIME THE CONSUMER ADDED A BIT MORE GAS AND THE VEHICLE ACCELERATED TOO FAST CAUSING THE DRIVER'S AND PASSENGER'S HEADS TO TIP BACK. THIS WAS A NARROW MAIN STREET IN A MAIN VILLAGE. THERE WERE LOTS OF POSSIBLE TARGETS, CARS/ KIDS BIKES, AND OTHERS. THEN THERE WAS THE UNANTICIPATED DOWN SHIFTING FOR BRAKING EFFECT THAT TIPPED HEADS FORWARD, BUT THAT WAS ANOTHER STORY FOR ANOTHER DAY, AND NOT QUITE AS ANNOYING OR NEARLY OF THE SAME CONCERN. THE DEALER'S SERVICE MANAGER FIRST ASSERTED THAT THERE WERE NO ADJUSTMENTS ACCESSIBLE FOR THE MECHANICS. INABILITY TO DO SOMETHING. AFTER APPLYING MORE GAS AND VEHICLE HESITATION CONSUMER SEARCHED FOR A TECHNICAL SERVICE BULLETIN (TSB) AND FOUND NONE. BUT FOUND ONE FROM JUNE 3, 2005 THAT RELATED TO RECALIBRATING OF THE TRANSMISSION. ABSOLUTELY NO MENTION OF EXPRESSIONS OF CONCERN OR EARLIER TSBS. *AK *MR
Power train, Aug 12, 2005
HESITATION WHEN ACCELERATING. COMPLAINT FILED WITH DEALER ON 8/10/05. I WAS ADVISED THAT THIS IS NORMAL. THIS IS A CONSTANT CONDITION AND NOT SAFE. *NM
Power train, Aug 8, 2005
MY 2005 HIGHLANDER OFTEN HESITATES RIGHT WHEN I NEED THE MOST ACCELERATION. *NM
Power train, Jul 15, 2005
1-MERGING INTO TRAFFIC ON INTERSTATE, AND MAKING A TURN AND MERGING INOT TRAFFIC 2-ENGINE HESITATION FOR A FEW SECONDS, THEN VEHICLE RESPONDS WITH SURGE IN SPEED. CARS COMING BEHIND ME HAD TO BRAKE/CHANGE LANES TO KEEP FROM HITTING ME. 3-I DIDN'T TRY TO HAVE THE PROBLEM FIXED, BECAUSE I UNDRSTAND THAT TOYOTA IS SAYING THIS IS NORMAL, AND NOT A PORBLEM.
Power train, Apr 13, 2005
TOYOTA, HIGHLANDER 2005. GOING DOWN A MOUNTAIN AT APPROXIMATEKY 50 MPH AND THE VEHICLE STOPPED SUDDENLY, BACK END FLIPPED UP, AND THE VEHICLE STARTED TO FISH TAIL. THE VEHICLE SLID INTO A BUSY ITERSECTION THEN STALLED. HAD THE VEHICLE TOWED TO TOYOTA, WHERE IT WAS DIAGNOSED WITH A DEFECTIVE TRANSMISSION. WHILE WORKING ON THE VEHICLE I DISCUSSED THE PROBLEM W/A CUSTOMER SERVICE REPRESENTATIVE ABOUT GETTING A NEW VEHICLE. (THIS VEHICLE WAS ONLY 3 MONTHS OLD). AND WAS TOLD THAT IF I TOOK THE VEHICLE INTO ARBITRATION THEY WOULD IMMEDIATLY CEASE WORKING ON THE VEHICLE AND WOULD TAKE AWAY MY FREE RENTAL CAR LEAVING ME STRANDED W/NO TRANSPORTATION. TOYOTA BLACKMAILED ME. *AK