2005 Toyota Highlander
Problems, recalls and owner-reported issues
Power train is the leading concern among 225 owner complaints filed for this model year. This is the 13th highest complaint count among 25 Highlander model years with reports.
Of the 2005 reports, 35 involved a crash and 4 involved a fire. 20 people were injured.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Engine and engine coolingNov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V539000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V112000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderOct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Campaign 10V499000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalJul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 06V253000 on NHTSA.gov
Representative owner complaints
225 reports, newest first.
Visibility/wiper, Feb 6, 2016
THE DRIVER SIDE VISOR IS DROOPING MORE AND MORE. NOW IT IS PARTLY IN MY LINE OF SIGHT (I'M 6'3") AND WHEN I HIT A BUMP IT DROPS DOWN EVEN FURTHER AND BLOCKS ABOUT HALF OF MY VISION OUT THE WINDSHIELD. VERY DANGEROUS. BEFORE I START DRIVING, I CAN GENTLY RAISE IT AND SLOWLY LET IT DROP TO WHERE IT STOPS WHERE IT ONLY PARTIALLY BLOCKS MY VISION. AS LONG AS I CAN AVOID BUMPS/POTHOLES, IT WILL STAY BUT IT DOESN'T TAKE MUCH OF A BUMP TO KNOCK IT LOOSE TO WHERE IT DROPS DOWN FURTHER AND BECOMES A SAFETY HAZARD BY BLOCKING TOO MUCH OF MY VISION. THIS STARTED SOME YEARS AGO AND HAS STEADILY GOTTEN WORSE.
Power train, Nov 11, 2015
HAVE DOCUMENTED TRANSMISSION PROBLEMS SINCE THE PURCHASE OF THE VEHICLE. CONTACTED TOYOTA WITH MY CONCERNS, NO HELP WAS PROVIDED. TRANSMISSION FAILED. PROVIDED TOYOTA WITH COMPLAINT ON OCT.14,2015. AND MANY TIMES BEFORE THEN. AFRAID FOR MY LIFE TO DRIVE IT. TURNING, JERKING, HESITATION IN TAKE OFF. ETC.
Steering, Nov 9, 2015
UNABLE TO STEER CAR PROPERLY ESP WHEN MAKING A LEFT TURN. THE CAR, ON AT LEAST 3 OCCASIONS, HAD THE TENDENCY TO GO STRAIGHT (DIFFICULT TO STEER) WHEN MAKING TURNS AND THEN GOES AWAY MOST TIMES. 2ND INCIDENT, WRITER ATTEMPTED TO MERGE TO THE MAIN STREET. LAST INCIDENT TODAY.
Visibility/wiper, Nov 8, 2015
HEWLLO MY COMPLAINT IS ABOUT THE DRIVERS SIDE SUN VISOR.IT WONT STAY UP AND HASNT FOR ABOUT A YEAR. I HAVE READ THAT A LOT OF HIGHLANDER OWNERS ARE HAVING THIS PROBLEM AND IT MAKES IT VERY HARD TO SEE.A NEW COSTS ABOUT 175.00!
Exterior lighting, Oct 19, 2015
WHEN DRIVING ON THE COUNTRY SIDE, WE USED THE HIGH BEAM LIGHTS AND NOTICED WHEN WE STOP SMOKE FROM THE HEAD LAMPS. IT WAS SO HOT THAT MELTED THE LENS COVERS. THIS REPRESENT A HAZARD AND LIABILITY. IT CAN CAUSE A SEVERE BURN SKIN DAMAGE TO A PERSON AND PROBABLY IF LEFT MORE TIME A FIRE. TOYOTA HAS A SERVICE TECHNICAL BULLETIN T-SB-0036-08 (NHTSA ID NUMBER: 10024893) THAT ADDRESS A "DISCOLORATION ON THE LENS". MY VIN NUMBER IS INCLUDED ON THE LIST. TOYOTA KNOWS THERE IS A PROBLEM WITH THE MATERIAL USED, IT ABSORBS TO MUCH HEAT. THIS IS A POTENTIAL FOR FIRE AND FOR A SEVERE BURN. TOYOTA SHOULD REPLACE THEM. PICTURES ATTACHED AS WELL AS SERVICE TECHNICAL BULLETIN T-SB-0036-08. EVEN THOUGH IT WAS NOT A FIRE, THE PRESENCE OF THE SMOKE INDICATE A POTENTIAL FOR FIRE IF WE HAD USE IT LONGER.
Electrical system, Aug 12, 2015
WHEN I STARTED MY CAR I NOTICED THE ABS,BRAKE,TIRE,TRAC OFF&VSC LITES WERE ALL LIT. I COULDN'T GET A DIAGNOSIS FROM MECHANIC.THESE LIGHTS CONTINUE TO STAY LIT. I DON'T KNOW IF IT IS SAFE. I HAVE READ AT LEAST A HUNDRED OF THE SAME COMPLAINT ON BLOGS.
Steering, Electrical system, Jul 9, 2015
TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. AFTER THE VEHICLE WAS STARTED, THE ABS, TRACTION CONTROL OFF, VSC, TIRE PRESSURE, AND EMERGENCY BRAKE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN WAS NOT ABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 134,000. ...UPDATED 09/28/15 *BF THE CONSUMER STATED THE VEHICLE WOULD LOSE STEERING CONTROL AS IF THE VEHICLE WAS GOING TO LOSE POWER. THE CONSUMER STATED IT WOULD HAPPEN ON AN INTERMITTENT BASIS. UPDATED 10/06/15*JB
Steering, Suspension, Structure, Vehicle speed control, Equipment adaptive/mobility, Jun 20, 2015, crash, fire
ON SATURDAY, MAY 30TH AT APPROXIMATELY 8:30 I WAS MOVING OUR 2005 HIGHLANDER FROM THE STREET INTO OUR RESERVED PARKING SPACE WITHIN OUR COMPLEX. AS I WAS STARTING MY RIGHT HAND TURN INTO THE COMPLEX THE CAR ACCELERATOR STUCK. I HIT THE CURB ON THE DRIVER'S/LEFT SIDE CAUSING THE VEHICLE TO VEER TO THE RIGHT. AS THE CAR CONTINUED TO ACCELERATE I HIT A TREE AND KNOCKED OVER ONE OF THE COMMUNITY'S POSTED SIGNAGE. THE IMPACT MADE THE CAR BOUNCE BACKWARD PARTIALLY INTO THE DRIVE, DAMAGING THE FRONT PASSENGER'S SIDE, DRIVE SHAFT BROKE, FRONT END PART FLEW ALL OVER AND A SMALL FIRE OCCURRED. POLICE WERE CALL AND REPORT TAKEN. THEY ESTIMATED THE SPEED AT 20-30 MILES PER HOUR. THE REPORT TAKEN WAS NOT FILED SINCE THE ACCIDENT TOOK PLACE ON PRIVATE PROPERTY. THE TOW TRUCK DRIVER STARTED THE VEHICLE TO GET IT ON THE TRUCK. HE HAD A DIFFICULT TIME FOR HE COULD NOT GET THE WHEELS TO TURN. ON TUESDAY, JUNE 2, WE WERE NOTIFIED BY OUR INSURANCE COMPANY THAT THE VEHICLE WAS TOTALED. THERE WAS A RECALL REPAIR DONE ON MAY 21, 2011, AFTER WE WERE ADVISED THAT THE REPLACEMENT PARTS WERE AVAILABLE TO INSTALL THE FORWARD RETENTION CLIP USED TO SECURE THE DRIVER'S SIDE FLOOR CARPET COVER. WE WERE ADVISED THAT IF IT WAS NOT INSTALLED PROPERLY, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM. IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURNING TO THE IDLE POSITION. AN ACCELERATOR PEDAL TEMPORARILY STUCK IN A PARTIALLY DEPRESSED POSITION MAY INCREASE THE RISK OF A CRASH. THERE MUST HAVE BEEN A FAILURE OF THE REPLACEMENT PART. *TR
Other or unspecified, Fuel/propulsion system, Jun 5, 2015
I WAS LEAVING A PARKING LOT AND WAS GOING TO ENTER A ROAD. I WAS COASTING THROUGH THE PARKING LOT AT ABOUT 10 MPH BECAUSE I HAD TO STOP BEFORE ENTERING THE CROSS ROAD. WHEN I STEPPED ON THE BRAKE TO STOP, THE CAR STARTED TO ACCELERATE. I PRESSED ON THE BRAKE HARD AND IT SOUNDED LIKE THE ANTI-LOCK BRAKING SYSTEM KICKED IN WHILE THE ENGINE REVVED UP AND KEPT PUSHING THE CAR. THE ACCELERATION PUSHED ME INTO THE CROSS ROAD WHILE THE BRAKING SYSTEM WAS MAKING LOTS OF NOISE,. LUCKILY NO ONE WAS IN THE CROSS ROAD AT THAT TIME. I PUT THE CAR INTO NEUTRAL, WHILE MY FOOT WAS STILL ON THE BREAK, AND THE ENGINE RPM'S DROPPED DOWN TO IDLE. I THEN PUT THE CAR INTO REVERSE ( BECAUSE CARS WERE NOW COMING ON THE ROAD I WANTED TO ENTER). AND I BACKED UP NORMALLY ( NO MORE ENGINE REVVING) . I PUT THE CAR BACK INTO DRIVE AND EVERYTHING ACTED NORMAL. IT WAS VERY SCARY, BECAUSE IF CARS WERE CROSSING IN FRONT OF ME WHEN IT HAPPENED, I WOULD HAVE GONE INTO THE ROADWAY UNABLE TO STOP AND I WOULD HAVE HIT SOME ONE.
Electrical system, May 20, 2015
AIR CONDITIONER, CAN BE ON THE COLDEST SEATING AND THEN TURN EXTREMELY HOT. SEEMS LIKE WHEN A BUMP IS HIT, IT EFFECTS WHEN THIS HAPPENS.
Visibility, Equipment, Apr 4, 2015
I HAVE A TOYOTA HIGHLANDER 2005 .THE DRIV ERR S SIDE SUN VISOR WILL NOT STAY UP.IT IS A SAFETY HAZARD WE HOLE DRIVING.TOYOTA, THOUGH THIS IS A PROBLEM FOR MANY HIGHLAND ERR OWN ERR 3RD WILL NOT FIX OR REPLACE IT. *TR
Electrical system, Wheels, Service brakes, Mar 25, 2015
DRIVING DOWN THE FREEWAY THE REAR PASSENGER WHEEL LOCKED UP. HAD TO CUT ACROSS TWO LANES OF TRAFFIC TO THE SIDE. THE WHEEL STILL TOTALLY LOCKED WHEN IT HAD TO BE DRAGGED ONTO A FLAT BED. LUCKILY THERE WAS NO INJURIES. STILL NOT 100% SURE OR WHAT'S WRONG BUT GUESSING IT HAS SOMETHING TO DO WITH THE TRACTION/ABS CONTROL SYSTEM. THEY REALLY SHOULD LOOK INTO A RECALL BECAUSE THIS SEEMS TO BE A COMMON ISSUE. *TR
Steering, Electronic stability control (ESC), Mar 11, 2015
WHILE DRIVING THE POWER STEERING STOP WORKING. VERY HARD TO TURN THE STEERING WHEEL TO PARK IN SAFE PLACE. CAR RUNS BUT IS VERY DIFFICULT TO STEER. SAFETY HAZARD. *TR
Visibility/wiper, Mar 10, 2015
DRIVER'S SIDE SUN VISOR FALLS DOWN, OBSTRUCTING VIEW, UNPREDICTABLY, DESPITE HAVING NOTHING ON IT. *TR
Visibility/wiper, Mar 9, 2015
TL*THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE ENTIRE SUNROOF SEPARATED FROM THE VEHICLE. THE CONTACT MENTIONED THAT THE AREA WAS COMPLETELY RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 197,000.
Power train, Vehicle speed control, Engine, Nov 26, 2014
I'M THE ORIGINAL OWNER & SOLE DRIVER OF THE VEHICLE & EVER SINCE I TEST DROVE IT THE DAY I PURCHASED IT THIS CAR'S HAD ISSUES WITH "JERKY/DELAYED" ACCELERATION. DURING THE TEST DRIVE I WAS TOLD THAT THE CAR ADJUSTS TO HOW I DRIVE & IT'LL GET BETTER. THIS HAPPENS PRETTY MUCH EVERY TIME I ACCELERATE THE VEHICLE AFTER IT'S BEEN STOPPED OR THE SPEED SLOWED SUBSTANTIALLY. EACH & EVERY TIME I TRY TO GENTLY ACCELERATE THE VEHICLE FROM A STOP, THERE'S A TINY DELAY IN VEHICLE RESPONSE FROM WHAT I AM INPUTTING TO THE ACCELERATOR PEDAL. THEN AFTER THE DELAY, IT'S LIKE THE VEHICLE TRIES TO SUDDENLY CATCH UP WITH WHERE IT WAS SUPPOSED TO BE IN THE ACCELERATION PROCESS & SUDDENLY JERKS FORWARD WITH A LOT OF ACCELERATION. THIS POSES A SAFETY PROBLEM WHEN TRYING TO PULL OUT INTO TRAFFIC & NEEDING THE VEHICLE TO RESPOND TO THE GAS PEDAL INPUTS THAT I'M GIVING IT IMMEDIATELY AS I'M GIVING THEM & NOT WITH EVEN A SMALL DELAY. THAT DELAY IN RESPONSE BY THE VEHICLE'S ACCELERATION HAS CAUSED SEVERAL NEAR-MISSES WITH OTHER TRAFFIC. I HAVE TRIED TAKING IT INTO MY DEALER AT LEAST A COUPLE TIMES TO HAVE THE ISSUE ADDRESSED BUT THE TECHNICIANS JUST WANTED TO BRUSH IT OFF SAYING THEY DIDN'T NOTICE IT OR BLAME IT ON THE TRANSMISSION & WHEN I TOLD THEM THIS ISN'T A TRANSMISSION PROBLEM THEY JUST BLEW ME OFF TREATING ME LIKE A DUMB FEMALE WHO DIDN'T KNOW ANYTHING ABOUT CARS, NOT KNOWING THAT I'M AN ENGINEER. BOTH OF THESE TIMES WERE WITHIN MY WARRANTY PERIOD, BUT IT'S OBVIOUS THEY DIDN'T WANT TO SPEND THE TIME & EFFORT TO DIAGNOSE THIS ISSUE. MY SAFETY WAS CLEARLY NOT IMPORTANT TO THE PEOPLE AT MY LOCAL TOYOTA DEALERSHIP. SO I CONTINUE TO HAVE THIS PROBLEM EVERY SINGLE TIME I ACCELERATE FROM A STOP AND MOST TIMES I RE-ACCELERATE AFTER HAVING SLOWED DOWN SUBSTANTIALLY. AFTER HAVING THIS ISSUE FOR THE PAST 9 YEARS, THE JERKINESS OF THE ACCELERATION PROBABLY HAS CAUSED OTHER PROBLEMS WITH THE VEHICLE. *TR
Visibility, Nov 19, 2014
TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE FRONT HEADLIGHT LENSES WERE DETERIORATING. THERE WAS A PRESENCE OF A SPOT THAT WAS SPREADING ACROSS THE PLASTIC, WHICH MAY BE INTERMITTENTLY MELTING. THE CONTACT INDICATED THAT THE SPOT WAS INCREASING ON THE FRONT HEADLIGHT LENSE AND COULD IMPACT THE CONTACT'S VISIBILITY UPON THE USE OF THE LOW OR HIGH BEAMS. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER WHO DIAGNOSED THAT BOTH HEADLIGHT LENSES NEEDED TO BE REPLACED. THE VEHICLE WAS TO BE REPAIRED BY AN AUTHORIZED DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.
Wheels, Nov 7, 2014
TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. THE CONTACT STATED THE FRONT DRIVER AND PASSENGER SIDE WHEELS BECAME ABNORMALLY BENT AND ALL FOUR WHEELS WERE CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN RECOMMENDED FOR THE WHEELS TO BE ROTATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,915.
Power train, Vehicle speed control, Engine, Oct 17, 2014
I AM THE ORIGINAL OWNER OF THE VEHICLE AND THROUGHOUT MY OWNERSHIP SINCE 2/2005 WHEN IT WAS BOUGHT THIS CAR HAS ISSUES WITH ACCELERATION. IT USUALLY OCCURS WHEN YOU ARE SITTING AT A STOP AND TRY TO ACCELERATE THE VEHICLE. THE CAR DOES NOT RECOGNIZE WHEN YOU ARE PUSHING THE ACCELERATION PEDAL AND HAS A DELAY WHEN IT FINALLY RESPONDS. THERE HAVE BEEN NUMEROUS INCIDENTS WHERE I HAVE TRIED TO CROSS A BUSY INTERSECTION OR PULL OUT INTO TRAFFIC AND THE VEHICLE HESITATES WHEN TRYING TO ACCELERATE, ENDING WITH A JERK OF THE VEHICLE. I HAVE ALMOST BEEN T-BONED A FEW TIMES TRYING TO CROSS BUSY INTERSECTIONS AND THE CAR DOESN'T WANT TO MOVE. I HAVE BROUGHT THIS TO THE DEALERSHIP NUMEROUS TIMES AND THE ONLY RESPONSE THEY HAVE IS THAT THE CAR ADJUSTS TO DIFFERENT DRIVERS AND IT THEN PROGRAMS ITSELF BASED OFF YOUR DRIVING HABITS, SO THEY RESET THE CODING ON IT. STILL HAVE THE ISSUE, DIDN'T FIX ANYTHING AND NOW I AM READING WHERE OTHERS HAVE HAD ISSUES, I JUST THINK THEY BRUSHED IT UNDER THE RUG TO NOT HAVE TO HONOR MY WARRANTY THAT WAS IN PLACE ON THE VEHICLE. I HAVE ALSO HAVE HAD ISSUES FROM DAY 1 ON THIS CAR WITH THE TRANSMISSION PAN LEAKING, THEY HAVE HAD TO REPLACE THE TRANSMISSION PAN GASKET NUMEROUS TIMES ON THE VEHICLE; CLAIMING IT JUST WENT BAD. REALLY, THAT MANY TIMES IT JUST GOES BAD, I DON'T THINK SO. *TR
Vehicle speed control, Sep 24, 2014, crash
BACKING UP OUT OF DRIVEWAY PUT THE CAR INTO REVERSE WENT FROM BRAKE PEDAL TO GAS PEDAL TAPING THE GAS PEDAL LIGHTLY TO INCH OUT OF DRIVEWAY SLOWLY. AFTER ONE TAP ON THE GAS PEDAL THE CAR ACCELERATED AT A VERY HIGH RATE OF SPEED CAUSING DRIVER TO LOOSE CONTROL. VEHICLE CRASHED INTO CHAIN LINK FENCE WHICH IN TURN CRASHED INTO A PARKED VEHICLE. *TR
Visibility, Latches/locks/linkages, Aug 9, 2014
THERE ARE 2 MALFUNCTIONS HAPPENING ON THIS VEHICLE:1) THE DOOR LOCK ON THE DRIVERS SIDE STOP WORKING WITH KEYLESS ABOUT 4 MONTHS AGO, IT WORKS IF YOU DO IT MANUALLY. 2) BOTH VISORS-DRIVER'S AND PASSENGERS VISOR HAS GOTTEN PROGRESSIVELY LOOSER, THERE ARE NO ADJUSTMENT SCREWS, WHAT MAKES THIS SUCH A HAZARD, IF YOU HIT A BUMP AND YOU'RE IN SPEEDING TRAFFIC SOMETIMES THE VISOR JUST DROPS DOWN AND BLOCKS YOUR LINE OF SIGHT. *TR
Power train, Jul 6, 2014
TRAVELING AT APPROX 35MPH THE VEHICLE SUDDENLY AND WITHOUT WARNING DECELERATED RAPIDLY TO ZERO MPH AND A LOUD GEAR - LIKE CRUNCHING AND GRINDING SOUND WAS HEARD UNDER THE ENGINE COMPARTMENT. THE VEHICLE WOULD ONLY MOVE AT 1 MPH TO PULL OFF THE ROAD AND WAS TOTALLY DISABLED. VEHICLE HAD TO BE TOWED. MECHANICS CONCLUDED THE FRONT DRIVE DIFFERENTIAL SUFFERED A MAJOR FAILURE AND THEN RUINED THE AUTOMATIC TRANSMISSION. *JS
Seat belts, Jun 23, 2014
SEAT BELT ON FRONT DRIVERS SEAT CONTINUES TO FOLD OVER, AND WILL NOT RETRACT. *TR
Vehicle speed control, May 21, 2014, crash
MY CAR WAS DECELERATING IN THE FAR RIGHT TURN LANE OF A BUSY INTERSECTION. THE BRAKE HAD BEEN APPLIED APPROXIMATELY 1000 FT FROM THE INTERSECTION AS THERE WERE 3 VEHICLES STOPPED AHEAD OF ME. I WAS TRAVELING AT 10 MPH AND I INCREASED THE PRESSURE TO THE BRAKE PEDAL AS THE CAR APPROACHED A STOPPED VEHICLE APPROXIMATELY 100 FEET AHEAD OF MY VEHICLE. THE ENGINE REVVED TO THE HIGHEST RPM READING AND LURCHED FORWARD AS I CONTINUED TO APPLY FULL PRESSURE TO THE BRAKE PEDAL BY ADDING MY LEFT FOOT TO THE ALREADY STATIONARY RIGHT FOOT. I STEERED THE VEHICLE TO THE RIGHT AND DROVE ON THE SIDEWALK AND GRASS BETWEEN A BURGER KING AND AUTOZONE PARKING LOTS TO AVOID HITTING THE CARS IN FRONT OF ME. I SHIFTED THE GEAR SHIFT TO NEUTRAL AND THE ACCELERATOR DID NOT DISENGAGE. I WAS NEARLY STANDING ON BRAKE AS THE CAR CONTINUED TO ACCELERATE WITH THE ENGINE SCREAMING FROM THE HIGH RPMS. I STRAIGHTENED THE CAR'S PATH TO AVOID A PARKED VEHICLE IN THE AUTOZONE PARKING LOT. I JUMPED A CURB ONTO GRASS AND CONTINUED TO ACCELERATE UNTIL CRASHING THROUGH A CINDER BLOCK WALL SUPPORTING THE AUTOZONE SIGN. THE DRIVER SIDE AIRBAG DEPLOYED UPON IMPACT WHICH ENGAGED THE ENGINE KILL SWITCH. WHILE STILL STANDING ON THE BRAKES, MY CAR TRAVELED ANOTHER 25-30 FEET BEFORE COMING TO REST. THE DRIVER BEHIND ME CAN CONFIRM THAT I WAS DECELERATING AND THE BRAKE LIGHTS ON AS THE CAR "TOOK OFF" ON ITS PATH TOWARD THE AUTOZONE SIGN. THE CAR WAS TOTALED AND I RECEIVED NECK, SHOULDER AND CHEST INJURIES FROM THE IMPACT. I WAS ABLE TO EXIT THE CAR ON MY OWN. *TR
Visibility, Structure, Apr 21, 2014
BOTH POWER REAR WINDOWS CAME OUT OF THEIR PWR WINDOW TRACKS. THIS ALLOWS THE WINDOW TO FALL TO THE FULLY OPEN POSITION. WHEN THIS HAPPENED IT CAUSED SEVERE AIR BUFFETING INSIDE THE VEHICLE. IT'S SO SEVERE THAT IT FEELS LIKE THE VEHICLE IS VIBRATING APART. THIS EXTREMELY LOUD PAINFUL SOUND CAUSES PANIC AS TO WHAT HAPPENED AND SEVER EAR PAIN. THE ONLY WAY TO STOP THE BUFFETING IS TO QUICKLY PULL OFF THE ROAD AND STOP. THE OPEN WINDOW ALSO EXPOSED OCCUPANTS AND PETS IN THE REAR SEAT AREA TO FALLING OUT. ACCORDING TO THE DEALER THIS IS A COMMON DEFECT AS THE TRACK ON THE BOTTOM OF THE WINDOW THAT CONNECTS TO THE POWER WINDOW MOTOR ARM MIGRATES SLOWLY ALONG THE BOTTOM OF THE WINDOW EACH TIME THE WINDOW IS OPERATED UNTIL THE MOTOR ARM FALLS OUT OF THE TRACK. THEN THE WINDOW IS FREE TO FALL DOWN AND CANNOT BE CLOSED UNTIL THE VEHICLE IS STOPPED. THERE IS NO SERVICE BULLETIN COVERING THIS. I RECEIVED A CHUCKLE FROM THE DEALER AS HE TOLD ME ABOUT THIS COMMON $250 PER WINDOW FIX. *TR