2006 Toyota Highlander
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 277 owner complaints filed for this model year. This is the 7th highest complaint count among 25 Highlander model years with reports.
Of the 2006 reports, 29 involved a crash and 4 involved a fire. 30 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V112000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderOct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Campaign 10V499000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: engine
40 reports, newest first. Show all
Engine and engine cooling, Mar 29, 2011
TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHILE THE VEHICLE WAS BEING INSPECTED THE INSPECTOR INFORMED THE CONTACT THE CATALYTIC CONVERTER WAS CLOGGED UP AND THAT IT WOULD NOT PASS INSPECTION. THE DEALER STATED THAT THE REPAIR COST WOULD NOT BE COVERED BY WARRANTY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIANS STATED THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE CONTACT STATED THAT PRIOR TO HAVING THE VEHICLE INSPECTED THAT THE OXYGEN SENSOR WAS REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 53,000.
Engine and engine cooling, Jan 24, 2011
TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID (NA). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS UNABLE TO RESTART SO IT WAS TOWED TO A DEALER. THEY INFORMED THE CONTACT THAT SHE NEEDED TO REPLACE THE INVERTER INSIDE THE ENGINE WHICH WAS DEFECTIVE. THE MANUFACTURER WAS CONTACTED AND OFFERED TO PAY A PORTION OF THE REPAIR. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 108,000. THE VIN WAS UNAVAILABLE.
Engine and engine cooling, Electrical system, Dec 7, 2010
TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH WHEN THE BEGAN VEHICLE LOOSING POWER. THE HYBRID WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE THEN STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED AS A FAILURE IN THE BATTERY CELL. THE DEALER ADVISED THE CONTACT THAT THE INVERTER WOULD NEED TO BE REPLACED. THE CONTACT STATED THAT THE DEALER HAD REPLACED THE BATTERY A FEW MONTHS PRIOR TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ENGINEER INSPECTED THE VEHICLE AND ADVISED THAT THE TOWING COMPANY CAUSED MORE DAMAGED TO THE VEHICLE BATTERY WHILE ATTEMPTING TO GET THE VEHICLE STARTED. THE FAILURE AND THE CURRENT MILEAGE WAS 29,500.
Engine and engine cooling, Oct 22, 2010
TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. THE CONTACT STATED THAT SINCE THE VEHICLE WAS PURCHASED IT HAS STALLED WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE DIAGNOSTIC TEST DID NOT DETERMINE WHAT CAUSED THE FAILURE TO OCCUR; HOWEVER, THE COOLING PUMP WAS REPLACED. THE REPAIR DID NOT CORRECT THE FAILURE. ON OCTOBER 14, 2010, WHILE DRIVING 65 MPH THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE INVERTER COOLING SYSTEM FAILED. THE DEALER STATED THAT THE WARRANTY HAD EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER FILED REPORT 1010191147 AND ADVISED THE CONTACT THAT THEY WOULD CALL HER. THE FAILURE MILEAGE WAS 59,000 AND THE CURRENT MILEAGE WAS 108,000.
Engine and engine cooling, Oct 21, 2010
I WENT THROUGH A TOLL BOOTH, CAR BEGAN TO LURCH, LIGHTS ALL WENT UP, AND THE CAR STALLED, HIGHLY DANGEROUS, BUT MANAGED TO GET TO SIDE OF ROAD, APPARENTLY THE INVERTER IN MY 2006 TOYOTA HIGHLANDER, 102,000 MILES ON IT, WAS DEFECTIVE, IT WAS REPLACED FREE, BUT HAD TO PAY LABOR AND FOR RENTAL.. BUT I REALLY COULD HAVE BEEN INJURED SEVERELY. *TR
Engine and engine cooling, Oct 12, 2010
TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID (NA). WHILE THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH ATTEMPTING TO MAKE A LEFT TURN, THERE WAS A COMPLETE LOSS OF THE ENGINE POWER. THE VEHICLE WAS COASTED SAFELY TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A DEALER FOR DIAGNOSIS. THE TECHNICIAN INFORMED THAT THE FAILURE WAS ATTRIBUTED TO THE POWER INVERTER. THE VEHICLE WAS NOT REPAIRED. THE CONTACT EXPRESSED CONCERN OF THE POTENTIAL SAFETY HAZARD. THE FAILURE MILEAGE WAS 101,128.
Engine and engine cooling, Sep 30, 2010, fire
TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID (N/A). WHILE THE VEHICLE WAS PARKED, THE ENGINE COMPARTMENT SUDDENLY CAUGHT FIRE. THE CONTACT STATED THAT THE VEHICLE WAS ROUTINELY MAINTENANCED. THE VEHICLE WAS DESTROYED. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 37,000. UPDATED 02/17/11*LJ UPDATED 05/02/11
Engine and engine cooling, Aug 9, 2010
TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. WHILE DRIVING THE VEHICLE STALLED AND ALL LIGHTS ON THE INSTRUMENTAL PANEL REMAINED ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE FAILURE WAS CAUSED BY THE INVERTER. THE DEALER REPLACED THE INVERTER. THE VIN INFORMATION WASN'T AVAILABLE. THE FAILURE MILEAGE WAS 75, 000 AND THE CURRENT MILEAGE WAS 83,000.
Engine and engine cooling, Aug 3, 2010
TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE INVERTER WAS DEFECTIVE AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 104,000. UPDATED 11/03/10. *LJ
Engine and engine cooling, Jul 9, 2010
TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID . WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING . SHE WAS ABLE TO COAST THE VEHICLE ONTO THE EMERGENCY LANE. THE VEHICLE WAS TOWED TO A DEALER WHO DIAGNOSED THE FAILURE AND STATED THAT THE HYBRID INVERTER MALFUNCTIONED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 128,648.
Engine and engine cooling, Jun 30, 2010
WHILE ATTEMPTING TO PASS A VEHICLE ON INTERSTATE 85 NB, MY TOYOTA CERTIFIED PRE-OWNED 2006 HIGHLANDER HYBRID COMPLETELY SHUTDOWN RESULTING IN THE LOSS OF POWER STEERING, POWER BRAKING, AND ALL ENGINE POWER. I WAS ABLE TO MAINTAIN CONTROL OF MY VEHICLE DESPITE THE FAILURE AND COAST TO THE SHOULDER OF THE HIGHWAY FROM AN INITIAL SPEED OF APPROXIMATELY 70 MPH. MY VEHICLE WAS TOWED TO MY LOCAL TOYOTA DEALERSHIP WHERE I WAS INFORMED THAT MY "POWER INVERTER" HAD FAILED AND WOULD SUBSEQUENTLY NEED TO BE REPLACED. I WAS ALSO TOLD THAT THIS WAS THE SECOND INSTANCE THAT DAY OF A 2006 TOYOTA HIGHLANDER HYBRID HAVING A FAILURE OF THE POWER INVERTER. UPON FURTHER RESEARCH VIA MULTIPLE ONLINE FORUMS SUCH AS EDMUNDS I DISCOVERED THAT THIS PROBLEM HAD OCCURRED TO SEVERAL OTHERS IN THE PAST YEAR RESULTING IN SIMILAR CONSEQUENCES (LOSS OF CONTROL, POWER STEERING, POWER BRAKING, ETC.). MY POWER INVERTER WAS COVERED UNDER THE TOYOTA WARRANTY AND IS CURRENTLY BEING REPLACED FREE OF CHARGE. NONETHELESS, GIVEN THE COMPLETE FAILURE OF THE SYSTEM AND SUBSEQUENT LOSS OF ALL POWER BRAKING, STEERING, AND ENGINE USE WHILE AT SPEED ON AN INTERSTATE AND MULTIPLE TOYOTA OWNERS EXPERIENCING THE SAME SITUATION I BELIEVE THE NHTSA SHOULD INVESTIGATE FURTHER. *TR
Engine and engine cooling, Feb 23, 2010
TL- THE CALLER HAS A 20006 TOYOTA HIGHLANDER. THE CONTACTED THAT WHILE TRAVELING DONE THE DOWN THE HIGHWAY THE VEHICLE LOST POWER. THE VEHICLE WAS TRAVELING 55MPH AND THE VEHICLE COMPLEYELY SHUT DOWN. NO WARNING LIGHTS CAME ON BEFORE THE VEHICLE SHUT DOWN. THE DEALER STATED THAT NO PROBLEMS WERE FOUND WHEN A DIOGNOSTIC PERFORMED ON THE VEHICLE. THE VEHICLE HAD 63000 MILES AT THE TIME OF THE FAILURE AND THOSE ARE ALSO THE CURRENT MILEAGE. RL
Engine and engine cooling, Mar 18, 2009
FROM A PARKED POSITION, I STARTED ENGINE ON 2006 TOYOTA HIGHLANDER. THE CAR MOVED FORWARD FOR A FEW SECONDS AT SLOW SPEED, THEN VERY RAPIDLY ACCELERATED SO THAT I COULD NOT STOP THE CAR. SERIOUS INJURIES OCCURRED. CAR FLEW THROUGH AIR AND ONLOOKERS HEARD ENGINE REV UP.WE LANDED IN A WATER CANAL. *TR
Engine and engine cooling, May 31, 2006
WHEN I USE THE A/C AND TURN IT OFF A BAD ODOR COMES FROM THE VENT . THIS IS A NEW 2006 HIGHLANDER, THE NEXT DAY I BROUGHT IT TO THE DEALER HE SAID TAKE FOR SERVICE , THEY TOLD ME TO DRIVE IT FOR A FEW MORE DAYS . I PUT 1500 MILES AND THE ODOR IS STILL THERE . I TOOK IT FOR SERVICE AGAIN . THE MECHANIC SAID TO USE A DEODORIZER ON THE VENT. I AM NOT A SATISFIED CUSTOMER. I WANT THIS ISSUE RESOLVED. I PAID FOR THE HIGHLANDER NOT THE SMELL THAT CAME WITH IT. *NM
Steering, Electronic stability control, Engine and engine cooling, Oct 15, 2005
TOYOTA HIGHLANDER HYBRID-I HAVE LOST ABS BRAKES, STABILITY CONTROL AND POWER STEERING ALONG WITH THE HYBRID ENGINE ON TWO OCCASIONS WITH MY 2 WEEK OLD 2006 HIGHLANDER. I HAVE BROUGHT IT TO THE DEALER TWICE-THE FIRST TIME THEY FOUND "MALFUNCTION CODES" AND "REBOOTED" THE COMPUTER AND TOLD ME IT WAS OPERATING AS "DESIGNED," ONLY TO HAPPEN AGAIN 2 DAYS LATER. CURRENTLY, THEY ARE REPLACING A COMPUTER. DATE OF INCIDENT AND PURCHASE OF VEHICLE IS ACTUALLY 2006 BUT IS NOT AN OPTION BELOW. I AM CONCERNED IT WILL HAPPEN AGAIN AND RESULT IN AN ACCIDENT IN THE FUTURE. *JB