2006 Toyota Highlander
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 277 owner complaints filed for this model year. This is the 7th highest complaint count among 25 Highlander model years with reports.
Of the 2006 reports, 29 involved a crash and 4 involved a fire. 30 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V112000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderOct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Campaign 10V499000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
277 reports, newest first.
Vehicle speed control, Mar 1, 2018
2006 TOYOTA HIGHLANDER. CONSUMER WRITES IN REGARDS TO VEHICLE SUDDEN ACCELERATION ACCIDENT. *SMD THE CONSUMER STATED THE VEHICLE ACCELERATED AND JUMPED A CURB AND HIT A BUILDING WHILE THE BRAKES WERE BEING DEPRESSED. *JS
Electronic stability control (ESC), Engine, Feb 5, 2018
TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. ON SEVERAL OCCASIONS, WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND LOST POWER. THE CONTACT STATED THAT ALL OF THE WARNING INDICATORS ILLUMINATED ON AND OFF. THE CONTACT CALLED STEVENS CREEK TOYOTA SAN JOSE AT (408) 984-1234 (LOCATED AT 4202 STEVENS CREEK BLVD, SAN JOSE, CA 95129) WHERE IT WAS CONFIRMED THAT NO RECALLS WERE ASSOCIATED WITH THE VIN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
Other or unspecified, Visibility/wiper, Nov 4, 2017
THE DRIVERS SIDE SUN VISOR FALLS DOWN WHETHER IN MOTION OR STOPPED, IT CAUSES A BLOCKED VISION WHICH CAN CAUSE COLLISIONS.
Power train, Aug 19, 2017
THE VEHICLE WILL OCCASIONALLY SURGE IN SPEED MOMENTARILY, MOSTLY NOTICED WHEN OPERATING BELOW 50 MPH. IT IS MORE PREVALENT AT LOWER SPEEDS. WE ARE THE ORIGINAL OWNER.THIS HAS BEEN AN ONGOING SITUATION SINCE THE VEHICLE WAS NEW. HYBRID MODEL. IT HAS BEEN INSPECTED BY THE DEALER WITH NO ISSUES FOUND.
Service brakes, Jun 14, 2017
PLEASE DISREGARD COMPLAIN NUMBER 10994017. THE AGENT DIDN'T PUT CORRECT DESCRIPTION. THE VEHICLE'S BRAKE WARNING LIGHT WAS SUDDENLY ON ON 6/4/2017. THE BRAKE FLUID WAS LOW. THE VEHICLE HAD BRAKE WORK DONE IN LATE APRIL WITH TOYOTA OF NASHUA AND REPLACED THE BRAKE FLUID. THE NEXT MORNING THE BRAKE WAS NOT EFFECTIVE (MAKING NOISE WHEN PRESSING BRAKE PADDLE AND DID NOT EFFECTIVELY STOP). BROUGHT TO THE TOYOTA DEALER AND WAS TOLD THE SEAL BROKE, CAUSED BRAKE FLUID GET TO MASTER CYLINDER, THUS FAILURE, AND THE BRAKE FLUID ALSO LEAKED TO THE BRAKE BOOSTER AND BOTH PARTS NEEDS TO BE REPLACED. WE FOUND TOYOTA HAD A RECALL ON OCT 21 2010, WHICH DESCRIBED THE EXACTLY THE SAME CAUSE AS HAPPENED TO THIS CAR. FILE A CASE WITH TOYOTA CORP AND THE RESPONSE WAS ANY PART CAN FAIL AT ANY TIME. THE VEHICLE PASSED 1 YEAR WARRANTY OF RECALL WORK. SO TOYOTA IS NOT RESPONSIBLE FOR THE REPAIR. NOTE, IN THE ORIGINAL RECALL, WHICH WAS 2010 FOR HIGHLANDER MANUFACTURED IN 2004-2006, WHICH IS AS LONG AS 6 YEARS LATER, TOYOTA MADE THIS RECALL AND STATED THAT THEY REIMBURSED THE REPAIR COST OF MASTER CYLINDER AND BRAKE BOOSTER IF DAMAGED. THERE WAS NO MILEAGE RESTRICTION. WITH TOYOTA'S RESPONSE, WHY EVEN BOTHER RECALL? THIS RAISED SERIOUS SAFETY ISSUE. IT'S VERY LIKELY TO CRASH WITH SUCH DAMAGE DUE TO THE SEAL LEAK. IF THIS CONTINUED TO BE A SAFETY ISSUE, TOYOTA SHOULD PUT THIS CHECK INTO THEIR REGULAR MAINTENANCE CHECK AND REPLACEMENT. THERE ARE QUITE A FEW REPORTED PROBLEMS WITH THIS ISSUE: HTTP://WWW.CARPROBLEMZOO.COM/TOYOTA/HIGHLANDER/BRAKE-MASTER-CYLINDER-PROBLEMS.PHP. TOYOTA'S RESPONSE SHOWS INDIFFERENCE TO THE CONSUMERS AND SAFETY OF THEIR LIVES. I HOPE THIS BRINGS TOYOTA MORE ATTENTION TO BE RESPONSIBLE TO THE DEFECT AS APPARENTLY THIS IS NOT THE SINGLE OCCURRENCE. WITH SUCH CONDITION OF THE BRAKE, IT IS HIGHLY LIKELY TO CAUSE CRASH. I HOPE SOMEONE CAN DO FURTHER INVESTIGATION.
Service brakes, Jun 8, 2017
TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, THE BRAKES FAILED TO WORK AND THE BRAKE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (TOYOTA OF NASHUA; 10 MARMON DR, NASHUA, NH 03060; (603) 689-1500) WHERE IT WAS DIAGNOSED THAT THE BRAKE FLUID NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AT 800-331-4331 AND STATED THAT THEY WERE NOT RESPONSIBLE FOR THE FAILURE. THE MANUFACTURER PROVIDED CASE NUMBER: [XXX]. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 08/03/17*LJ INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Electronic stability control (ESC), Engine, May 24, 2017
TAKATA RECALL. CHECK ENGINE LIGHT WON'T GO OFF ALONG VSC LIGHT. ON THE STREET WHEN THE CAR STOP RUNNING.
Steering, Vehicle speed control, Apr 5, 2017
STEERING RECALL: I HAVE A 2006 TOYOTA HIGHLANDER HY WITH THE P/S (POWERS STEERING) LIGHT ON. I'VE BEEN TO TOYOTA TWICE IN THE PAST WEEK AND ONLY OWNED THE VEHICLE FOR 2 WEEKS. THEY SAY THEY CANNOT DO ANYTHING WITHOUT KNOWING THE PROBLEM AND I'VE TOLD THEM THE PROBLEM. THE VEHICLE ALSO TRIES TO ACCELERATE ON ITS ON WHEN AT A COMPLETE STOP.
Service brakes, Sep 27, 2016
THE BRAKES ON OUR TOYOTA HIGHLANDER HYBRID RANDOMLY GET MUSHY (SLIP) AND DON'T ENGAGE FOR A SECOND, THEN WILL ENGAGE. THIS CREATES A DANGEROUS SITUATION AS THE VEHICLE WILL NOT STOP AS INTENDED AND WHEN NEEDED. ALSO, THE VEHICLE AT OTHER TIMES WILL SURGE WHEN THE BRAKES HAVE BEEN APPLIED AND YOU ATTEMPTING TO COME TO A STOP. THIS HAS BEEN HAPPENING FOR QUITE SOME TIME. THESE PROBLEMS HAVE BEEN WELL-DOCUMENTED AT THE FOLLOWING SITE. WE ARE EXPERIENCING THE EXACT SAME ISSUES AS NOTED BY OTHERS WITH OUR VEHICLE. HTTP://FORUMS.EDMUNDS.COM/DISCUSSION/5357/TOYOTA/HIGHLANDER-HYBRID/HIGHLANDER-HYBRID-BRAKE-PROBLEMS
Service brakes, Jun 28, 2016
VEHICLE IS LEAKING BRAKE FLUID THROUGH THE VACUUM LINE FROM THE MASTER CYLINDER TO THE INTAKE AND THEN OUT THE EXHAUST. BRAKES ARE NOW SPONGY AND DO NOT OPERATE AS REQUIRED FOR SAFE DRIVING. TOYOTA REFUSES TO ACKNOWLEDGE THIS RECALL STATING MY VEHICLE DOES NOT FALL UNDER THE RECALL NOTICE. THE BRAKE FLUID SLOW LEAK HAPPENS BOTH WHEN STATIONARY AND IN USE. THE RECALL WAS ISSUED ON OCTOBER 21, 2010. BRAKE FLUID TRAVELLING DOWN THIS PATH ALSO AFFECTS OTHER COMPONENTS OF THE ENGINE; SUCH AS, VACUUM LINES, FUEL AIR SENSORS BOTH PRIOR TO AND AFTER THE CATALYTIC CONVERTER, AND THE CATALYTIC CONVERTER ITSELF.
Engine, Jun 27, 2016
THE VEHICLE ONLY HAS 103,000 MILES AND HAS FUNCTIONED FLAWLESSLY TILL RECENTLY WHEN IT STARTED USING OIL EXCESSIVELY. THAT IS ONE QUART IN 500 MILES AT FREEWAY SPEEDS.
Service brakes, Jun 6, 2016
THE "BRAKE ACTUATOR" BECAME DEFECTIVE, AND WAS NOT ABLE TO BE REPAIRED. THE PART WAS VERY EXPENSIVE AND SEEMS TO BE A PROBLEM THAT COULD BE CONSIDERED WIDE SPREAD ENOUGH THAT IT SHOULD BE "RECALLED".
Fuel/propulsion system, Apr 16, 2016, crash
SUDDEN ACCELERATION. VEHICLE WAS STOPPED, WITH FOOT ON BRAKE, WHEN SUDDEN ACCELERATION OCCURRED VERY RAPIDLY. BRAKE PRESSURE COULD NOT KEEP VEHICLE FROM LURCHING FOWARD AND HITTING THE REAR A OF STOPPED VEHICLE. I NEVER USE MY LEFT FOOT ON THE BRAKE, SO I CAN NEVER HIT THE BRAKE AND ACCELERATOR SIMULTANEOUSLY.
Electrical system, Service brakes, Engine, Apr 11, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHEN THE VEHICLE WAS STARTED, THE BRAKE LIGHT, ANTILOCK BRAKE LIGHT, AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE DID NOT ACCELERATE AND THE ANTILOCK BRAKES DID NOT WORK. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE COMPUTER CORE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. ..UPDATED 05/02/16 *BF *TR
Suspension, Power train, Apr 7, 2016
I HAVE HAD AXLES BREAK WHILE DRIVING AFTER THEY WHERE REPLACE AND THEY SAY THERE IS NOTHING A MATTER WITH THE FRONT END. AND THE FRAME IS RUSTED AFTER A YEAR AND IT IS BREAKING.
Engine, Mar 8, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE VEHICLE STALLED AS ALL THE DASHBOARD WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
Exterior lighting, Jan 30, 2016
I HAVE A 2006 TOYOTA HIGHLANDER LIMITED V6. THE CAR IS 66.000MILES, I NOTICED THAT THE DAY LIGHTS HAS BEEN OVERHEATED AS A RESULT 1 WHITE SPOT MELTED IN EACH HEADLIGHT LENSE. IT MIGHT BE A HAZARD FIRE ISSUE AND DO NOT FEEL SAFE DRIVING THIS CAR. TOYOTA SHOULD RESOLVE THIS ISSUE AND REPLACE THE HEADLIGHTS.
Visibility, Jan 6, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE SUN ROOF EXPLODED. THE VEHICLE WAS TAKEN TO A DEALER TO BE REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 66,000. UPDATED 03/15/16*LJ *TR
Steering, Nov 20, 2015
TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. WHILE MAKING A RIGHT TURN AT APPROXIMATELY 5 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER AND THE INSTRUMENT PANEL ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 142,085. UPDATED 04/06/16*LJ,UPDATED 4/25/18*JB *TR
Engine, Oct 13, 2015
DRIVING CAR AND IT STALLED THEN MESAGE CAME ON WHICH STATED CHECK HYBRID ENGINE. TOOK IT TO SHOP AND WAS TOLD WOULD COST $9,000 AS IT WAS THE INVERTER. THEY SAID MY VIN WAS NOT ON THE RECALL LIST FOR THE RECALL OF 2006 HIGHLANDER HYBRIDS. HAD THE POWER MODULE REPLACED AS RECALL IN 2012 BUT WHY WASNT MY CAR ON RECALL LIST FOR THE INVERTER?
Electronic stability control (ESC), Engine, Sep 29, 2015
TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. AS SOON AS THE VEHICLE WAS STARTED, THE VSC LIGHT AND CHECK ENGINE WARNING INDICATOR ILLUMINATED SIMULTANEOUSLY AND REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT COULD NOT BE DIAGNOSED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 240,000.
Service brakes, Sep 14, 2015
WHEN APPLYING THE BRAKES THERE IS A NOISE THAT COMES FROM THE BRAKES AND IT FEELS LIKE THE BRAKES ARE FAILING SO I WENT TO THE TOYOTA DEALERSHIP TO FIND OUT THE PROBLEM AND THEY SAID THAT THE BRAKE ACTUATOR WAS BAD AND HAD TO BE REPLACED. THE COST OF THE REPLACEMENT WAS QUOTED AT $3200.00. I SEARCHED THE WEB AND FOUND THAT THIS HAS OCCURRED NOT JUST ONCE BUT MANY TIMES ON NUMEROUS TOYOTA VEHICLES OVER MANY YEARS. I ALSO DETERMINED THAT EVEN IF I WERE TO PAY TO REPAIR THIS CONDITION THAT IT WOULD REOCCUR DO TO THE DEFECT IN THE DESIGN OF THIS PART OF THE BRAKING SYSTEM. WHY HASN'T THIS BEEN ADDRESSED AND A RECALL ISSUED?
Electronic stability control (ESC), Service brakes, Sep 9, 2015
DRIVING VEHICLE WHEN WARNING LIGHTS FOR ABS AND SKID CONTROL CAME ON. CHECK VSC SYSTEM IN DASH. WHEN BRAKE IS APPLIED RIGHT FRONT TIRE LOCKS AND CAUSES VEHICLE TO SPIN. SLOW SPEED IS THE ONLY REASON FOR NO ACCIDENT. TOOK VEHICLE TO DEALER AND WAS TOLD "BRAKE ACCUATOR " ELECTRONICS HAD FAILED AND NEEDED TO BE REPLACED FOR $3800. RESEARCH SHOWS THIS IS AN ISSUE ON THE HIGHLANDER, THE LEXUS AND THE CAMRY SO WHY HAVE THE HIGHLANDERS NOT BEEN INCLUDED IN THE RECALL?
Service brakes, Sep 8, 2015
WHILE DRIVING ON THE FREEWAY AND THE TRAFFIC CAME TO A SLOW AS I WAS BRAKING TO SLOW DOWN I NOTICED ALL THE LIGHTS ON MY DASHBOARD SUDDENLY LIT UP, ALL THE FOLLOWING ENGINE, ABS, BRAKES AND CHECK VSC LIGHTS CAME ON. I TOOK TO A DEALERSHIP, PIERCEY TOYOTA AND THEY DID A DIAGNOSTIC AND CAME BACK WITH CODES C1391 AND B1281.
Service brakes, Sep 3, 2015
TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHILE DRIVING AT ANY SPEED, THE INSTRUMENT PANEL DISPLAYED A "VEHICLE STABILITY CONTROL" ERROR MESSAGE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ANTI-LOCK BRAKE SYSTEM ACCUMULATOR PUMP REMAINED ACTIVATED AND DRAINED THE BATTERY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 122,000.