2023 Toyota Highlander
Problems, recalls and owner-reported issues
Structure is the leading concern among 181 owner complaints filed for this model year. This is the 18th highest complaint count among 25 Highlander model years with reports.
Of the 2023 reports, 12 involved a crash. 12 people were injured.
What owners report most often
Recalls and investigations
Seats, mid/rear assembly, reclinerMar 5, 2026
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2021-2025 Highlander and Highlander Hybrid vehicles. The second-row seat backs may fail to lock into position during seat back adjustment.
A seat back that fails to lock may not properly restrain an occupant during a crash, increasing the risk of injury.
Dealers will replace the return springs in the seat back recliner assemblies, free of charge. Owner letters were mailed September 9, 2026. This is a phased recall. Owners may contact Toyota’s customer service at 1-800-331-4331. Toyota's numbers for this recall are 26TB06 and 26TA06.
Campaign 26V128000 on NHTSA.gov
Back over prevention, display functionOct 30, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.
Campaign 25V744000 on NHTSA.gov
Electrical system, instrument cluster/panelSep 11, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.
An instrument panel display that does not show critical information can increase the risk of a crash or injury.
Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.
Campaign 25V595000 on NHTSA.gov
Steering, columnJan 29, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Toyota Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, Lexus RX350, 2023-2024 NX250, and NX350 vehicles that may have been incorrectly repaired under previous NHTSA recall number 23V-480. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A deactivated driver's air bag will not deploy as intended, increasing the risk of injury during a crash.
Dealers will inspect and replace the spiral cable assembly as necessary, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 25TA02. Lexus' number for this recall is 25LA02.
Campaign 25V040000 on NHTSA.gov
Equipment, other, labelsJul 23, 2024
Gulf States Toyota, Inc. (GST) is recalling certain Toyota 2023 GR Supra, 2024 4 Runner, Corolla, Grand Highlander, Grand Highlander Hybrid, Land Cruiser Hybrid, Tacoma, Tacoma Hybrid, 2023-2024 BZ4X, Corolla Cross Hybrid, GR Corolla, GR86, Highlander, Highlander Hybrid, Prius, Prius Prime, Sequoia Hybrid, Tundra, Tundra Hybrid, Venza Hybrid, 2023-2025 Crown, and 2025 Camry Hybrid vehicles equipped with GST accessories. The load carrying capacity modification label may display inaccurate added weight values. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.
GST will mail new labels to owners, free of charge. Owner notification letters were mailed September 16, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R2.
Campaign 24V548000 on NHTSA.gov
TiresJun 18, 2024
Southeast Toyota Distributors, LLC (SET) is recalling certain 2021-2024 Highlander vehicles. The 20-inch accessory tires with an insufficient load rating for the vehicle's Gross Axle Weight Rating (GAWR) were installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Tires with an insufficient load rating can be overloaded and fail, increasing the risk of a crash.
SET will inspect and replace the tires and information placard, as necessary free of charge. Owner notification letters were mailed August 16, 2024. Owners may contact SET's customer service at 1-866-405-4226. SET's number for this recall is SET24A.
Campaign 24V452000 on NHTSA.gov
TiresJun 6, 2024
Gulf States Toyota, Inc. (GST) is recalling certain 2022-2024 model year Highlander L and Highlander LE vehicles equipped with the Blackout Package that includes 20" black alloy wheels and tires. The installed tires have an insufficient load rating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Tires with an insufficient load rating may be overloaded and fail, increasing the risk of a crash.
GST will inspect and replace the tires as necessary, and install a new tire information label as necessary, free of charge. Owner notification letters were mailed August 8, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R1.
Campaign 24V419000 on NHTSA.gov
Structure, body, bumpersOct 26, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2023 Highlander & Highlander Hybrid vehicles. During normal vehicle operation, minor impact to the front lower bumper cover may result in the cover coming loose or detaching.
A detached front bumper cover can become a road hazard, increasing the risk of a crash.
Dealers will repair or replace the upper and lower front bumper covers as necessary, free of charge. Owner letters were mailed April 22, 2024. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 23TB12/23TA12.
Campaign 23V720000 on NHTSA.gov
Steering, columnJul 12, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, 2023 Lexus RX350, RX350 Hybrid, RX500 Hybrid, 2023-2024 Lexus NX250, NX350, and NX350 Hybrid vehicles. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A deactivated driver's air bag that does not deploy as intended increases the risk of injury during a crash.
Dealers will inspect and replace the spiral cable assembly, if necessary, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA08. Lexus' number for this recall is 23LA02.
Campaign 23V480000 on NHTSA.gov
Representative owner complaints
181 reports, newest first.
Seats, Jun 3, 2026
The driver’s seat lower cushion in my 2023 Toyota Highlander provided inadequate support during normal driving, particularly on the left side of the seat cushion where support for my left leg and hip area appeared insufficient. This caused uneven seating posture, increased discomfort, pressure, and difficulty maintaining a proper driving position during extended periods of driving. The seat became increasingly uncomfortable during prolonged use and caused pain, numbness, and difficulty maintaining a proper driving position. I am a professional driver and spend many hours operating the vehicle. Over time, the lack of support contributed to left-sided sciatica symptoms that required medical evaluation and physical therapy. Medical records document that prolonged sitting in the vehicle aggravated my condition and limited my ability to sit and drive comfortably. An independent upholstery specialist inspected the seat and determined that additional foam had to be added to the driver’s seat lower cushion to improve support and comfort. After the modification, the seat became significantly more comfortable. This indicates that the original seat cushion support may be inadequate. I believe this condition may affect other vehicles of the same model and should be investigated as a potential safety concern because it can affect driver posture, comfort, concentration, and safe vehicle operation during extended driving.
Power train, Jun 2, 2026
My 2023 Toyota Highlander was experiencing a high pitch whiny noise when accelerating. I looked up on line and saw that this could be a failing transmission issue. I took it into the Toyota Dealership , 6321 West Canal Drive, Kennewick, WA 99336. They confirmed my concerns. They said the transmission was toast and I could not drive it until repaired. They informed me they would have to order a replacement transmission under warranty. They further informed me that there is a backlog of requests for replacement transmissions because this is a major problem with Toyota. They have no idea how long it will be. It could be weeks or it could be months. In looking online, it appears that Toyota has been aware of this issue with the 8 speed transmission and has not been addressing the problem. My question, why isn't Toyota addressing this problem? Why does it take weeks or months to building a replacement transmission? Something needs to be done about this.
Service brakes, May 22, 2026
The brakes on this vehicle disengage and re-engage at will during braking. There are no indications of when it will occur. Brakes will disengage during low and high-speed braking, braking while going uphill, downhill, on flat roadway or during turns. This has resulted in several near miss accidents as well as debris was struck in the roadway due to being unable to stop. This vehicle was purchased new from the dealership in NM and was reported to them starting at 18,000 miles. Vehicle has been taken to numerous dealerships and reported with them as well. Toyota's answer is this is normal. Brakes disengaging and resulting in near accidents is not normal. It is now pending formal inspection from Toyota corporate by dealerships dismiss the problem as unable to replicate. This is to the point where we only drive when absolutely needed due to fear of an accident as this is the only vehicle.
Seats, May 14, 2026
Rear back seat unproper locking system. I have got rear ended while my kids were at back and I found out the rear seat slide a bit about couple inches. Dealership can't do anything of the recall at the moment.
Power train, May 14, 2026
Right after vehicle passed 60k miles mark (manufacturer warranty ended) I noticed a whining noise under load. During acceleration the noise is most noticeable between 30-50 mph speed range. If a gas pedal released the noise is gone and if pressed again the noise is coming back. The pitch increases with a speed increase. I took the car to dealership (current odometer reading 61,037 miles) and they diagnosed transmission failure. Apparently it is a very common issue with the current transmission family (UA80/UA81).
Structure, May 10, 2026
The lift gate will not close, especially during temperatures below 35 degrees. The litigate will go down a few inches, beep, then go back up. In colder temperatures below 25 degrees the lift gate will not open.
Vehicle speed control, Engine, May 6, 2026, crash
The contact owns a 2023 Toyota Highlander. The contact stated that while driving at lower speeds, pulling into an uphill driveway, the vehicle had independently accelerated while the accelerator pedal was depressed. In addition, the contact stated that she was not able to depressed in time and had crashed into the left side of the house, causing damage to the front driver-side bumper and quarter panel. The contact stated that the accident caused property damage to the garage of the house, which was covered by the insurance provider. A police report file. No injuries were sustained, and no medical attention. The vehicle was taken to a local independent mechanic, where it was diagnosed that the accelerator pedal was depressed throughout the accident; however, the brake pedal was depressed after the crash had occurred, according to the electronic data. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 59,000.
Seats, May 5, 2026
The contact owns a 2023 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 26V128000 (Seats) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the remedy was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Seats, May 1, 2026
Received a safety recall stating "Seat Back Reclinging Assembly May Not Securely Lock". Based on this information, it goes on to state that "a seat back that has not been secured in a locked position may fail to properly restrain occupants, increasing the risk of injury in the event of a crash at certain speeds." Currently there are no remedies available but it is advised that "no one sit in or use the second-row seats while the vehicle is moving until the remedy is performed on the vehicle." In speaking to headquarters as well as mutliple dealerships, the only "solution" is to provide a rental car in the amount of $42/day and they would reimburse in 6-8 weeks. There is no current remedy date. That would mean there is an out of pocket cost of $1200+ a month, in which these funds are not available to our family. I am the primary caretaker for two small children who are in car seats and required to utilize the back seat/2nd row. Since I have been advised not to use it, my car is currently unsafe to use for its intended purpose. I have been given no other solutions at this time.
Electrical system, May 1, 2026
The contact owns a 2023 Toyota Highlander. The contact stated that the instrument panel had been inoperable for approximately 5 months. The contact received notification of NHTSA Campaign Number: 25V595000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 149,000.
Seats, Apr 24, 2026
The contact owns a 2023 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 26V128000 (Seats); however, the part to do the recall repair was not yet available. The local dealer was contacted, but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Wheels, Apr 24, 2026
I was at a gas station and enter car wash, the machine didnt wash my car and distriy my front right tire
Air bags, Apr 22, 2026, crash
The contact owns a 2023 Toyota Highlander. The contact stated that while driving at 60–65 MPH, the contact's vehicle crashed into the passenger's side of an oncoming vehicle. The air bags did not deploy. In addition, the contact stated that it was a very hard impact on an older model vehicle. The contact stated that the older model vehicle was made of steel. The vehicle was towed to a local tow yard. The contact was transported to the local medical center. The contact sustained severe sternum bruising, full spine whiplash, severe pain in the neck, both shoulders, and the upper back area. A Police report was filed. The vehicle was not inspected by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 34,125.
Air bags, Forward collision avoidance, Apr 21, 2026, crash
I was in an accident today in this vehicle . Upon impact, traffic was suddenly stopped on the highway. The air bags didn’t deploy and the automatic emergency breaks didn’t engage. Impact was so hard three vehicles were Involved.
Seats, Apr 2, 2026
The contact owns a 2023 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 26V128000 (Seats); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.
Service brakes, Mar 31, 2026
2023 Highlander Hybrid braking suddenly changes at low speeds when coming to a stop. Vehicle's brakes work properly (Regenerative and hydraulic combined) until it slows to make a stop or slows in heavy traffic. Suddenly the brake pressure changes and the vehicle "lunges" forward and brake pedal must be pressed extremely hard to stop or slow the vehicle. Problem happens most often when on a hill approaching a stop. Toyota dealer initially said that they never heard of such a problem until I presented them with T-SB-0059-23 Hybrid Regenerative Brake Transition Feeling Improvement for Model years 2020 thru 2022 from Toyota's website. I had reported the issue 3 times before (twice while in warranty and documented by them once while in warranty) but they claim that there is no fix available and when and if one comes available it will only apply to vehicles with 36,000 miles or less. LOOKS like Toyota and this dealer could care less about SAFETY and its customers.
Seat belts, Mar 27, 2026
The contact owns a 2023 Toyota Highlander. The contact stated that while starting the vehicle, and driving at an undisclosed speed, the seat belt alarm chimed while the seat belts were properly buckled. The contact turned off and restarted the vehicle, and released and fastened the seat belt securely however, the failure persisted. The vehicle was taken to the dealer twice, but the dealer was unable to duplicate the failure. The failure recurred, and the vehicle was taken back to the dealer a third time; however, the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 21,000.
Other or unspecified, Mar 9, 2026
Some times when I request the rear hatch to open is does nothing but most of the time when I depress the close button, it moves less than an inch and then beeps. I have had to depress the button up to 6 times before the hatch closes. The car is only 3 years old as of this month and the problems stated more than 6 months ago but my mileage was over 36,000 6 months ago so it was out of warranty. This is a joke since my 12 year old suv has no issues with its powered hatch. There are a lot of online complaints on the power hatches. It is a safety issue of the hatches don’t close. This is almost a daily challenge (it not closing when I ask it to be closed (fob, rear hatch button as well as dash hatch button).
Other or unspecified, Mar 7, 2026
While driving down the highway I went over a bridge joint and my sunroof suddenly exploded sending glass both into and off the back of the vehicle. I was able to find the moment of the explosion on my rear dashcam (saw the falling glass) and checked the front dashcam for any evidence of an object that would have impacted and did not find any. Neither I or my two passengers saw an object hit. The front dashcam also confirmed rough pavement near the bridge joint that would have caused some vibration in the vehicle.
Other or unspecified, Mar 6, 2026
I bought this vehicle new in March 2024. I normally use Apple CarPlay for music and more importantly maps. Approximately 1 year after purchase, I was driving along and all of a sudden a new screen appeared with a keyboard requesting that I sign in with my email address. To clear the screen, I had to hit the small "X" in the upper right hand corner of the screen. That cleared and then a new screen appeared in blue saying "Experience Drive Connect" and asking me to subscribe to their software service for navigation and other services. To get back to the map on Apple CarPlay I had to hit another button on the upper left of the screen. I will upload screenshots. This is a safety issue not only in losing the map but more importantly it takes my eyes off the road to resolve (the buttons are small and not easily pushed while driving.) This happens multiple times a day in short around town drives. I googled this on line and noted many complaints by Toyota owners for the same problem. So I asked the mechanic yesterday when I had the car serviced if he could disable the Experience Drive Connect so i wouldn't have the problem. He laughed and said it's a common complaint by customers and that it's "hard wired" in and cannot be disabled unless you call Toyota and purchase their monthly plan for $15/month or $20/mo for the premium version. This is not only a scam but it's an unsafe feature that could be disabled if Toyota chose to make a software change. I urge you to use your influence to correct this unsafe and unethical feature of their otherwise excellent vehicles.
Vehicle speed control, Mar 6, 2026
It takes time to accelerate. The car jerks and shakes before moving
Power train, Mar 1, 2026
Delayed acceleration, jerking shifting between gears and whining noise
Visibility/wiper, Feb 26, 2026
The rear window on my car spontaneously shattered as I was driving. This was in light rain on the freeway. I had turned the rear-window defrost on at the beginning of my 20 minute drive to work in the dark at 5:30AM . When I was almost at my destination, I heard a noise and looked in the rear view mirror to see my rear window had shattered. My car is just three years old with about 30,100 miles on it. I drove to the dealer, waited until they opened, and they evaluated - saying it would take $1300 and three days to fix. They said it would not be covered by my bumper to bumper warranty as that had expired in the prior week. They said it would not be covered by my Toyota extended care warranty. As much rain was expected later in the day, I fixed paying for the repair myself as I found a third party installer who could do it for a fraction of the dealer's asking price on the same day. There were no warnings, messages or other symptoms. I had only turned on the rear defroster one other times in the three years I owned the vehicle. This happened without warning.
Electrical system, Feb 17, 2026
My Toyota Highlander 12.3 inch display of the instrument panel may be blank at startup. Operating the vehicle with this display blank reduces the ability to see certain malfunction indicators. This Safety Recall that has been active since September 11, 2025. The problem been acknowledged and confirmed by Millers Toyota, in Anaheim, California and Toyota in Bueno Park, California dealers. Their answers, Toyota currently does not have a remedy as of to date, February 17, 2026. The screen goes blank every time I start my car, while driving, or trying to access the applications on my screen. I would greatly appreciate help regarding this recall.
Other or unspecified, Feb 16, 2026
The vehicle's tailgate motor has started to malfunction and is failing prematurely. When opening the tailgate it makes a loud squealing noise. When attempting to close utilizing all automatic features it will stop and beep twice. After multiple attempts the tailgate remains open is unable to be closed via automatic means. This is a safety issue as it compromises the closing an opening functionality if the tailgate itself and could lead to unsecured tailgates or vehicles with an inability to close their tailgates.