2002 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 360 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Tacoma model years with reports.
Of the 2002 reports, 30 involved a crash and 3 involved a fire. 23 people were injured.
What owners report most often
Recalls and investigations
Tires, temporary/emergency spare tireNov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Campaign 12V542000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Suspension, front, control arm, lower ball jointMay 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V225000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 19, 2003
ON CERTAIN PICKUP TRUCKS, DURING SIDE IMPACT NCAP TEST (I.E. LINCAP TEST), A FLANGE AT THE REAR END OF THE DOUBLE CAB BODY DEFORMED AND INTERFERED WITH THE FUEL INLET HOSE THAT CONNECTS THE FUEL FILLER PIPE AND FUEL TANK, RESULTING IN DAMAGE TO THE FUEL INLET HOSE.
THIS DAMAGE COULD RESULT IN FUEL LEAKAGE, WHICH COULD RESULT IN A FIRE IF IN THE PRESENCE OF AN IGNITION SOURCE.
DEALERS WILL INSTALL A FUEL HOSE PROTECTOR ON THE BODY FLANGE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 03V189000 on NHTSA.gov
Representative owner complaints: power train
26 reports, newest first. Show all
Suspension, Power train, Jan 23, 2018
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 10 MPH, THE BALL JOINT FRACTURED AND CAME APART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS LATER TOWED TO MIKE ERDMAN TOYOTA (1545 E MERRITT ISLAND CAUSEWAY, MERRITT ISLAND, FL 32952) WHERE IT WAS DIAGNOSED THAT THE BALL JOINT SEPARATED AND DAMAGED THE AXLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. ADDITIONALLY, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 05V225000 (SUSPENSION). THE FAILURE MILEAGE WAS APPROXIMATELY 334,000. PARTS DISTRIBUTION DISCONNECT.
Suspension, Power train, Service brakes, Oct 7, 2016
THE RUST ON THE REAR END ASSEMBLY IS SO SEVERE THAT THE BRAKES ARE COMPROMISED, AND THE BACK UP EMERGENCY BRAKE SYSTEM HAS FAILED. THE RUST ON THE DIFFERENTIAL HOUSING IS SO SEVERE THAT THE FLUID HAS LEAKED OUT AND THE GEARS ARE AT RISK FOR CATASTROPHIC FAILURE. THE SPRING MOUNTS TO THE AXLES ARE ALSO RUSTING SEVERELY, CREATING A RISK OF LOST CONTROL SHOULD EITHER SIDE BREAK AWAY. IT TAKES GREAT EFFORT WHEN BRAKING, AND THE VEHICLE PULLS SEVERELY DUE TO RUST CAUSING THE LOSS OF INTEGRITY OF THE BRAKING SYSTEM. THE BRAKES, ONCE APPLIED, DO NOT RELEASE EVENLY, CREATING UNEVEN BRAKE WEAR, SHUDDERING AND SHAKING, RESULTING IN POOR CONTROL, EXCESSIVE AND UNEVEN TIRE WEAR, I.E., TIRES LOCKED AND DRAGGING, SCALLOPING. ON WET, AND I FEAR, ICEY, SURFACES, THE TRUCK HAS SLID SIDEWAYS DUE TO ONE OR MORE WHEELS NOT RELEASING.
Power train, Jul 29, 2014
I TOOK IN MY 2002 TACOMA FOR AN OIL CHANGE AND WAS TOLD THAT THEY COULD NOT PUT IT UP ON THE LIFT DUE TO EXCESSIVE CORROSION ON THE FRAME. I ONLY RECENTLY BOUGHT THE TRUCK IN OCT. 2013 WITH 65K MILES ON IT. ALL ELSE WORKS FINE. AFTER EXPLAINING THE ISSUE TO TOYOTA THEY ADVISED ME TO TAKE IT TO THE DEALERSHIP FOR INSPECTION. THE DEALERSHIP THEN TOLD ME THAT THEY WERE ONLY COVERING THE RUSTED SPARE WHEEL CASING IN THE RECALL, NOT THE ENTIRE FRAME, AND ADVISED ME TO TAKE IT UP WITH TOYOTA CORPORATE. THE MODEL BEFORE THE '02 WAS RECALLED DUE TO EXCESSIVE CORROSION ON THE FRAME (IN COLD WEATHER STATES) HOWEVER THE PROBLEM SEEMS TO PERSIST IN LATER MODELS. HAS ANYONE HAD LUCK CALLING TOYOTA ABOUT THIS? I'M IN A TOUGH SPOT AS I PURCHASED THE TRUCK RECENTLY (ALTHOUGH THE RUST DAMAGE DID NOT APPEAR AS BAD THEN AND I'M WONDERING IF SOME COATING WAS APPLIED AT THE DEALER) AND WOULD HAVE MISSED ANY RECALL ON THE FRAME IF THERE HAD BEEN ONE. *JS
Power train, Structure, Feb 19, 2014
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME STARTED TO DETERIORATE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN APPLIED AN UNDER COATING TO THE FRAME. THE CONTACT STATED THAT THE COATING EVENTUALLY WORE OFF. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. UPDATED 04/21/14*LJ THE CONSUMER STATED HE MADE AN APPOINTMENT FOR THE CORROSION FRAME RECALL. BEFORE THE APPOINTMENT, HE NOTICED A LOT OF OIL DROPLETS ON THE TAIL GATE OF THE TRUCK, AS HE DROVE OFF, HE NOTICED A PUDDLE OF OIL. AN INSPECTION REVEALED, THE DIFFERENTIAL CASE WAS LEAKING AND IT NEEDED TO BE REPLACED BECAUSE IT WAS EXTREMELY RUSTY. ALSO, THE FRAME WAS RUSTED, AND IT NEEDED TO BE REPLACED. UPDATED 04/24/14
Suspension, Power train, Jul 27, 2011
2002 TOYOTA TACOMA. CONSUMER STATES IN 2010 WHILE BACKING OUT OF THE BACKYARD, THE LEFT WHEEL AXLE BROKE *TGW THE CONSUMER STATED THE EXACT SAME THING HAPPENED ON JULY 1, 2011, ONLY IT HAPPENED ON THE OPPOSITE SIDE. THE CONSUMER STATED THE TIRE TWISTED AND THE TRUCK SKIDDED INTO ONCOMING TRAFFIC. *JB
Power train, May 7, 2011
RUSTED OUT REAR DIFFERENTIAL - 2002 TOYOTA TACOMA. *TR
Power train, Feb 15, 2010
MY EXPERIENCE WITH MANUAL TRANSMISSION ON MY CURRENT AND PREVIOUS TOYOTA PICK-UP TRUCKS WAS NOT VERY GOOD. FIRST MY PREVIOUS, EARLIER MODEL 98 TOYOTA TACOMA 2WD MANUAL TRANSMISSION HAD FAILED AT ABOUT 55,000 MILES JUST PRIOR TO THE 60,000 MILE POWERTRAIN WARRANTY LIMIT. THE FAILURE HAPPENED AT THE SYNCHRONIZER FROM 4TH TO 5TH GEAR WHEN SHIFTING FROM NEUTRAL ACCORDING TO TOYOTA TECHNICIAN AT THE TIME. THE SAFETY ISSUE ON THIS IS THAT WHILE DRIVING AND ONE NEEDS TO SHIFT TO 5TH GEAR FROM NEUTRAL, ONE MAY HAVE DIFFICULTY SHIFTING AND THE TRANSMISSION COULD HAVE A CATASTROPHIC FAILURE AND AT SUCH FREEWAY SPEED THE VEHICLE COULD SUDDENLY STALL, STOP AND MAY GO IN A TAILSPIN. PREVIOUS DEALER WHERE I BOUGHT THE VEHICLE FROM REPAIRED THE TRANSMISSION PER THE WARRANTY. NOW I HAVE ANOTHER TOYOTA TACOMA PICK-UP 4X4 HAVING THE SAME PROBLEM. I TOOK IT TO THE A TOYOTA DEALER PREVIOUSLY SINCE IT WAS STILL UNDER WARRANTY FOR POWERTRAIN AND AROUND 55,000 MILES BUT DEALER REFUSED TO TAKE A LOOK AT THE PROBLEM EVEN AFTER REPEATED ATTEMPTS TO GET THE PROBLEM CORRECTED. I INFORMED THEM THAT I HAVE A SIMILAR PROBLEM BEFORE AND THEY HAVE FIXED IT. BUT THIS TIME AROUND THEY REFUSED. I HAVE ATTEMPTED SEVERAL TIMES FROM SEP 2006 UNTIL JAN 2007 AND EVEN CALLED TOYOTA USA REPS ON THE ISSUE. I STILL OWN THE TRUCK AND TO GET AROUND THE SYNCHRONIZER PROBLEM, I HAVE TO DOWNSHIFT BACK TO 3RD, 4TH BEFORE I CAN GO BACK TO 5TH GEAR. THIS CAN CAUSE A LOT OF DISTRACTION WHILE DRIVING AND TO CON UNWITTING DRIVER UNAWARE OF WHAT TO DO SUDDENLY SHIFTS TO 5TH FROM NEUTRAL THE MANUAL TRANSMISSION SQUEAKS/RATTLES LIKE THE SOUND OF GEARS HAVING PROBLEM MESHING OR BREAKING - THUS IN A WORST CASE SCENARIO ONE MAY LOOSE DRIVEABILITY AND CAPABILITY TO MOVE THE VEHICLE SINCE THE DRIVE COULD GET LOST AND MAY RESULT IN A FAILURE. I KIND A GIVE UP ON IT SINCE THE DEALERS AND TOYOTA USA BEFORE DON'T WANT TO PAY ATTENTION TO ME. I KNOW THIS CURRENT TOYOTA RECALL MAY RESULT IN THEM LOOKING INTO THIS - SAFETY ISSUE. *TR
Suspension, Parking brake, Fuel system, Gasoline, Power train, Structure, Dec 28, 2009
GAS TANK SHIELD SEVERELY RUSTED. UNDER SIDE OF GASTANK IS PROTECTED BY A SHIELD/SKID PLATE. IT IS RUSTED SO BADLY THAT WHEN HIT WITH A HAMMER THE HAMMER GOES RIGHT THROUGH. PRESUMABLY THIS SHIELD IS TO PROTECT THE GAS TANK FROM DEBRIS AND STONES ESPECIALLY IF THE TRUCK IS USED OFF ROAD. I DISCOVERED THIS AS I WAS INSPECTING THE UNDERSIDE OF THE TRUCK BEFORE DROPPING THE TRUCK OFF AT THE DEALER TO HAVE THE FRAME REPLACED. IN ADDITION TO THIS, IT IS APPARENT THAT THE DRIVE AXLE AND DIFFERENTIAL HOUSING ALSO HAVE SEVERE RUST. IF TAPPED WITH A HAMMER THE RUST COMES OF IN SHEETS. THE PARKING BRAKES ACTUATING LEVERS HAVE RUSTED IN PLACE AND CAN NO LONGER BE USED. THERE APPEARS TO BE MORE TO THIS RUST THAN SIMPLE FRAME RUST. THE RUST IS PERVASIVE THROUGH OUT THE UNDERSIDE OF THE TRUCK. *TR
Suspension, Power train, May 23, 2007
THE TOYOTA TACOMA HAD A REAR AXLE WRAP UP, THIS WAS WHERE THE TWO PIECE DRIVESHAFT BECOMES LOOSE AT THE SPLEEN AND CAUSED A CLUNG OR LOOSENESS IN THE DRIVE LINE, WHICH CAUSED UNDUE STRESS ON THE ENGINE AND THE TRANSMISSION, WHICH COULD CAUSE THE DRIVESHAFT TO BREAK AT THE YOKE AND FALL TO GROUND, CAUSING AN ACCIDENT. THIS WAS GETTING PROGRESSIVELY WORSE ON THE TRUCK. I HAVE TAKEN THE CAR UNDER WARRANTY TO THE DEALER. THEY DISMISSED IT AS NORMAL. THIS WAS NOT NORMAL. IT WAS A FLAW IN THE SPRINGS THEY USED ON THE TRUCK.*AK
Power train, May 19, 2007
ONE WEEK AGO I WAS RUNNING ERRANDS WITH THE TOYOTA SEQUOIA, BUT THE CAR REFUSED TO START ONCE I COMPLETED MY ERRANDS. EVENTUALLY, THE CAR HAD TO BE TOWED AND THE REPAIR SHOP REPORTED THAT THE GEAR SHIFT BRACKET AND LEVER WERE BROKEN AND THEREFORE PREVENTED THE GEAR FROM PROPERLY GOING INTO PARK. THE REPAIR SHOP REPORTED SEEING SEVERAL SUCH CASES RECENTLY BUT STATED THAT TOYOTA HAS INFORMED HIM THAT THE PROBLEM RESULTED FROM IMPROPER HANDLING OF THE GEAR SHIFT. I HAD THECAR FOR MORE THAN 5 YEARS AND HAVE ALWAYS FOLLOWED THE PROPER PROCEDURE. PERHAPS THIS NEEDED FURTHER INVESTIGATION. *AK
Power train, Jan 9, 2006
MY TOYOTA TACOMA HAS WHAT TOYOTA REFERS TO AS REAR AXLE WRAP UP, WHERE THE TWO PIECE DRIVE SHAFT BECOMES LOOSE AT THE SPLINE AND CAUSES A CLUNK OR LOOSENESS IN THE DRIVELINE WHICH CAUSE UNDUE STRESS ON THE ENGINE AND THE TRANSMISSION, WHICH COULD CAUSE THE DRIVE SHAFT TO BREAK AT THE YOKE AND FALL TO GROUND CAUSING ACCIDENT.*JB
Power train, Apr 21, 2005
TOYOTA 2002 MR2 SPYDER: SEQUENTIAL MANUAL TRANSMISSION (SMT) CREEPING WHILE IN FORWARD OR REVERSE GEAR. THIS HAPPEN TO THE CAR IN DEC OF 2004 BUT WENT AWAY BY ITSELF AFTER A WEEK. I REPORTED TO FREMONT TOYOTA DEALERSHIP IN CA BUT THEY SAID IT WAS NORMAL. AGAIN ON APRIL 15TH 2005, THE SMT CREEPING RECURRED. I BROUGHT THE CAR BACK TO THE SAME DEALERSHIP, THEY REPLACED THE ECU BUT CREEP IS STILL EXIST. AGAIN, THE DEALER PERSISTS THAT THIS IS NORMAL. ACCORDING THE MANUAL BOOK, IT STATES THAT UNLIKE AUTOMATIC TRANSMISSION, SMT DOES NOT CREEP. PLEASE HELP. *NM
Power train, Jan 4, 2005
ONCE YOU COME TO A STOP DURING NORMAL BREAKING, AND TAKE YOUR FOOT OFF THE BREAK PEDAL TO START MOVING FORWARD, THERE IS A ?THUMP? AS IF YOU ARE BEING HIT FROM THE REAR. THIS IS SIMILAR AS BEING REPORTED IN ODI?S 10089480 AND 10092834. DEALER STATES THIS IS NORMAL IN TRUCKS, THAT IT IS THE NATURAL SPACING IN THE DRIVE SHAFT WITH REAR WHEEL DRIVE.THE ONLY WAY FOR THE PROBLEM NOT TO OCCUR, IT TO GLIDE TO A SMOOTH STOP.*AK
Power train, Oct 15, 2004
TRANSMISSION-POWER TRAIN.WHILE DRIVING IN LOW SPEED SITUATIONS THE VEHICLE'S TRANSMISSION SHIFTS FROM 1ST TO 2ND.....BACK AND FORTH FROM 1ST TO 2ND AND 2ND TO 1ST. I TOOK THE VEHICLE TO THE DEALER AND THEY ADVISED THAT THEY COULDN'T FIND ANYTHING WRONG WITH IT. IT HAS 76K MILES ON IT. I WAS JUST WONDERING IF ANYONE ELSE WAS HAVING THIS PROBLEM.*AKL
Power train, Aug 4, 2004
POWER TRAIN - JUST BOUGHT MY TRUCK ABOUT 3 MONTHS AGO. DURING THE TEST DRIVE, I WAS EXTREMELY IMPRESSED BY THE RIDE OF MY TACOMA. A FEW WEEKS AFTER I HAD IT, I STARTED TO EXPERIENCE THE CLUNKING SOUND COMING FROM UNDERNEATH. I HAVE TO THE DEALERSHIP 3 TIMES NOW, AND EVERYTIME I HAVE BEEN TOLD WAS NORMAL. I WAS TOLD ALL AUTOMATIC TRANSMISSIONS DO THIS. THIS IS THE SECOND TOYOTA TRUCK I HAVE OWNED, AND I COULD TELL YOU THIS, THEY DON'T COME UP WITH A RESOLUTION, IT WILL BE MY LAST. I ALSO DRIVE A CELICA (GREAT CAR), BUT IF I LOSE THE TRUCK, THEN I LOSING THE CELICA, AND WILL WANT NOTHING TO DO WITH TOYOTA'S AGAIN!!! *AK
Power train, Jun 3, 2004
TRANSMISSION/DRIVESHAFT EXPERIENCES LOUD CLUNK NOISE WHEN BRAKES ARE APPLIED THEN RELEASED. THIS IS A KNOWN PROBLEM TO TOYOTA HOWEVER THEY OFFER NO RESOLUTION. RESEARCH HAS INDICATED ADDING LEAF SPRINGS TO STIFFEN REAR SUSPENSION RESLOVES THIS ISSUE TOYOTA WILL NOT DO THIS MODIFICATION. *JB
Service brakes, Air, Power train, Structure, Sep 29, 2003
MY 2002 TACOMA VIBRATES AT HIGH SPEEDS AND WHEN STOPPING. I'VE HAD THE BRAKES FIXED 5 TIMES NOW AND IT'S STILL NOT RIGHT. MY TRANSMISSION CLUNKS WHEN I STOP AND START, SHUTTERS WHEN COMING TO A STOP, AND SHIFTS HARD. SOMETIMES THE TRANSMISSION CLUNKS AFTER I'VE ALREADY STARTED MOVING. THE PROBLEMS STARTED ABOUT A YEAR AGO. I'VE RECENTLY BEEN TO TWO DEALERSHIPS BEFORE THE WARRANTY EXPIRED AND NOTHING WAS DONE. ONE TOYOTA TECHNICIAN SAID IT WAS MY BRAKES, YEAH RIGHT, THE OTHER WOULDN'T EVEN TAKE IT FOR A TEST DRIVE. I THINK THE PROBLEM IS CAUSED BY MY TRANSMISSION SLIDING BACK AND FORTH, WHICH I DON'T THINK IT'S SUPPOSED TO DO. WHENEVER I STOMP ON THE GAS TO PASS SOMEONE IT SHIFTS INTO THE WRONG GEAR AND THE ENGINE RED LINES. MY DASH SQUEAKS, SO I HAVE TO WEDGE MY WALLET IN BETWEEN THE WINDSHIELD AND DASH TO STOP IT. MY DRIVER'S SIDE DOOR DOESN'T SHUT FLUSH WITH THE BODY. LAST BUT NOT LEAST, I HAD TO REPLACE MY OXYGEN SENSOR. I WOULD LIKE TO SELL MY TRUCK, BUT CAN'T WITH ALL THE PROBLEMS. THIS WAS MY FIRST TOYOTA AND WILL PROBABLY BE MY LAST.
Suspension, Power train, Structure, Aug 10, 2003
FOR THE LAST YEAR I HAVE BROUGHT TRUCK BACK TO SF TOYOTA DEALERSHIP FOR TRANSMISSION PROBLEMS , SUSPENSION PROBLEMS RATTLING DASH BOARD, SQUEAKING SOUNDS FROM SEAT AND FRONT BUSHINGS. ALL THESE PROBLEMS STILL HAVE NOT BEEN FIXED. AFTER 15 VISITS TO DEALERSHIP, SF TOYOTA LEFT SCRATCHES ON BODY AND LOST MUD FLAP. BODY NOW TILTED AFTER SERVICE. *NLM
Power train, May 13, 2003
TRANSMISSION "CLUNKS" ON STOPS AND SURGES AFTER BRAKE IS RELEASED FROM STOP. FEELS LIKE YOU'VE BEEN REAR ENDED. DEALER SAID THIS IS NORMAL, "THEY ALL DO IT". I CONTACTED TOYOTA HQ AND THEY REFUSED TO COMMENT ON PROBLEM. VEHICLE VALUE IS GREATLY DIMINISHED. *JB
Power train, Apr 3, 2003, crash
THE VEHICLE DOWN SHIFTED 2 GEARS THEN SPUN OUT OF CONTROL. THE VEHICLE THEN CROSSED A HIGHWAY AND ROLLED OVER ONTO IT'S RIGHT SIDE. *JB *NLM
Power train, Feb 12, 2003
THE VEHICLE DID NOT MOVE OUT OF GEAR, AND IF IT DID MOVE OUT OF GEAR, IT ABRUPTLY DOWN SHIFTED TO SECOND GEAR WHILE DRIVING.*AK 2002 TOYOTA SPYDER) *JB
Power train, Jan 3, 2003
THE AUTOMATIC TRANSMISSION SHIFTS TOO SOON, MAKING THE ENGINE STRUGGLE AND VIBRATE AT LOW RPMS. WHILE STILL UNDER WARRANTY, I TOOK IT TO THE DEALERSHIP AND THEY SAID ALL THE NEW 4 CYLINDER TRUCKS WERE LIKE THIS. AT 12000 MILES, THE VALVES ARE TAPPING AT IDLE, AND THE HOOD VIBRATES. SEEING THE OTHER COMPLAINTS ON THIS FORUM, I NOW REMEMBER HOW SQUIRLY THE TRUCK GETS AFTER GOING OVER BUMPS. THAT WOULD EXPLAIN THE BAD FRONT SHOCKS. I HOPE I DON'T GET INTO A BAD ACCIDENT KNOWING THE AIR BAGS ARE NOT GOING TO WORK.
Suspension, Power train, Dec 18, 2002
BROUGHT TRUCK TO TOYOTA SERVICE FOR 5000 MILE SERVICE REPORTED AUTO TRANS JUMP IN GEAR SHIFT FROM 1ST TO SECOND (MECHANIC SAID NEEDED NEW TRANSMISSION, AFTER LEAVING SERVICE STATION NOTICED TRUCK WASN'T DRIVING PROPERLY BROUGHT TRUCK BACK MECHANIC SAID NEEDS NEW FRONT SHOCK AND REAR SHOCK. NOW IT DID NOT NEED NEW TRANSMISSION EVEN THOUGH IT STILL JUMPS FROM GEAR TO GEAR.
Power train, May 21, 2002
TRANSMISSION "CLUNKS" ON STOPS AND SURGES AFTER BRAKE IS RELEASED FROM STOP. DEALER SAID THIS IS NORMAL. I CONTACTED TOYOTA HQ AND THEY REFUSED TO COMMENT ON PROBLEM. SAID DEALER IS THE EXPERT. I GUESS THE EXPERTISE OF THE DESIGN OF THE VEHICLE IS LEFT UP TO THE DEALERS NOT TOYOTA.*AK
Power train, Mar 21, 2002
AFTER ABOUT 1100 MILES WE STARTED TO GET A BAD SHUDDER WHEN SETTING OF, TOYOTA SAID THIS NORMAL, THE TRUCK AS NOW STARTED TO SHUDDER GOING FROM 1ST TO 2ND, TOYOTA SAID THIS IS NORMAL, THEN THE ENGINE STARTED TO VIBRATE THROUGH THE CAB AT 3000 MILES,TOYOTA SAID THIS IS NORMAL, THE TRANSMISSION THEN STARTED HARD SHIFTING,CHANGING UP,THE LATER CHANGING DOWN, NOW WHEN PULLING GRADES AND THE TRANSMISSION GOES INTO 4TH GEAR THERE IS A VIBRATION ALL THROUGH THE DRIVE LINE AND CAB, WHEN IN CRUISE THE TRANSMISSION HUNTS UP AND FOR NO REASON, TOYOTA SAYS ALL THIS IS PERFECTLY NORMAL ALTHOUGH 2 TOYOTA TECHS AGREED THERE IS A PROBLEM 2 INDEPENDANT GARAGES SAID THERE IS A PROBLEM, EVERY TIME WE TAKE IT FOR REPAIR TO THE DEALERSHIP TOYOTA TELLS US THERE IS NOTHING WRONG EVEN THOUGH THE DEALERSHIP AS SAID THERE IS A PROBLEM TOYOTA REFUSES TO DO ANYTHING.*AK