2002 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 360 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Tacoma model years with reports.
Of the 2002 reports, 30 involved a crash and 3 involved a fire. 23 people were injured.
What owners report most often
Recalls and investigations
Tires, temporary/emergency spare tireNov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Campaign 12V542000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Suspension, front, control arm, lower ball jointMay 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V225000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 19, 2003
ON CERTAIN PICKUP TRUCKS, DURING SIDE IMPACT NCAP TEST (I.E. LINCAP TEST), A FLANGE AT THE REAR END OF THE DOUBLE CAB BODY DEFORMED AND INTERFERED WITH THE FUEL INLET HOSE THAT CONNECTS THE FUEL FILLER PIPE AND FUEL TANK, RESULTING IN DAMAGE TO THE FUEL INLET HOSE.
THIS DAMAGE COULD RESULT IN FUEL LEAKAGE, WHICH COULD RESULT IN A FIRE IF IN THE PRESENCE OF AN IGNITION SOURCE.
DEALERS WILL INSTALL A FUEL HOSE PROTECTOR ON THE BODY FLANGE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 03V189000 on NHTSA.gov
Representative owner complaints
360 reports, newest first.
Service brakes, Hydraulic, Dec 21, 2004
2002 TOYOTA SEQUOIA BRAKES VIBRATE SEVERELY. VSC SYSTEM WARNING LIGHT FREQUENTLY COMES ON. PROBLEM HAS EXISTED SINCE CAR HAD 10,000 MILES, NOW HAS 36,000 AND DEALER AND TOYOTA CLAIM IT IS OUT OF WARRANTY. TOYOTA CLAIMS THAT CAR HAS NO BRAKE PROBLEMS, NO SAFETY PROBLEMS AT ALL, AND THAT ORIGINAL BRAKES ARE NOT DEFECTIVE IN DESIGN. I AM INFORMED THAT TOYOTA ISSUED A TECHNICAL SERVICE BULLETIN, ALTHOUGH TOYOTA DENIED THIS THE DEALER ADMITTED THAT IT EXISTED, BUT I HAD TO SPECIFICALLY COMPLAIN ABOUT THE SPECIFIC BRAKE PROBLEM, OR THEY WOULD NOT AND DID NOT ADVISE ME OF THE REMEDY. THESE BRAKE ISSUES ARE A SERIOUS SAFETY PROBLEM.*AK
Latches/locks/linkages, Dec 14, 2004
PLASTIC DOOR HANDLES ON TOYOTA SEQUOIAS EASILY BREAK OFF, VERY FLIMSY. THIS COULD LEAD TO SOMEONE GETTING TRAPPED IN THEIR CAR, ESPECIALLY IF YOU ARE INVOLVED IN AN ACCIDENT AND NEED TO OPEN THE DOOR QUICKLY OR AGGRESSIVELY. MY NEIGHBOR HAPPENS TO HAVE THE SAME VEHICLE EVEN THE SAME COLOR AND I ASKED HIM HOW HE LIKES IT AND HE SAID FANTASTIC, EXCEPT WE HAVE BROKEN OFF 2 DOOR HANDLES. WHEN I TOOK IT TO THE DEALER THE SERVICE WRITER CASUALLY MENTIONED, "OH, WE GET THESE IN ALL THE TIME". I CONTACTED THE DEALER AND THE TOYOTA ZONE OFFICE AND THEY WILL NOT PAY FOR THE $175 REPAIR. THIS IS A SERIOUS SAFTEY HAZARD AND A DEFECTIVE PRODUCT.*AK
Equipment, Dec 7, 2004
I PURCHASED A 2002 TOYOTA SAQUOIA IN THE YEAR OF 2002,IN THE YEAR 2003 MY AIR CONDITIONING SYSTEM WENT OUT IN MY NEW VEHICAL UPON TAKING IT TO THE LOCAL TOYOTA DEALER I WAS TOLD THAT MY COMPLETE AIR CONDITIONING SYSTEM NEEDED TO BE REPLACED,I HAVE WENT A COMPLETE YEAR WITH OUT AN AIR CONDITION SYSTEM MIND YOU I LIVE IN AUGUSTA GEORGIA,THIS CAUSES SEVERAL THINGS TO NOT FUNCTION PROPERLY SUCH AS GAS GAGE NOT PROPERLT WORKING,WHEN YOU DRIVE THE CAR 60 MPH OR OVER THE TRUCK BEGAN TO BURN,THE AIR COMES ON AUTOMATICLLY AND THE TRUCK BEGAN TO JUMP VERY BADLY LIKE THE CAR IS GOING TO BLOW UP,THE HEAT ONLY WORKS WHEN YOU SET IT AT 80 DEGREES OR HIGHER SO YOU CAN ONLY LEAVE IT ON FOR SO LONG THEN YOU MUST TURN IT OFF AND WHEN IT GETS COLD AGAIN YOU HALF TO TURN IT ON AGAIN THIS GOES ON ALL DAY LONG.I CAN'T SEM TO GET ANY ONE FROM TOYOTA TO HELP ME WITH THERE DEFAULT, MY WIFE WON'T EVEN DRIVE THE CAR.SO WHEN I TOOK IT TO A NOTHER DEALER TO SEE IF THIS WAS REALLY THE PROBLEM HE TOLD ME THAT THE SYSTEM WAS REALLY BLOWEN.SIRS I WORK VERY HARD FOR MY MONEY AND I DON'T HAVE A LOT OF IT TO GIVE AWAY,IREALLY DON'T APPRICIATE A PRESTEGIOUS COMPANY SUCH AS TOYOTA TO PRAY ON ON IT'S CONSUMER. WHEN THE VEHICAL WAS CHECKED TO SEE IF THERE WAS A RECALL AT MY REQUEST THERE WAS WHAT YOU CALL A BULLITEN ON THIS PROBLEM,I THEN ASKED IF YOU KNOW THAT THIS PROBLEM ENOUGH WHY ISN'T THERE A RECALL I REALLY DON THINK THAT I THE CONSUMER SHOULD HALF TO FOOT A $2000 BILLL ON SOMETHING THAT WAS NOT MY FAULT I AM VERY SORRY THAT I PICKED A TOYOTA SEQUOIA THIS IS NOT A CHEAP VEHICAL IF YOU CAN HELP ME AND MY FAMILY PLEASE DO SO.THANK YOU IN ADVANCE. *AK
Suspension, Nov 15, 2004, crash
NO KNOWN EVENTS LEADING TO THE FAILURE. PROGRESSIVE, SUCCESSIVE FAILURE OF BOLTS HOLDING LEFT FRONT WHEEL ASSEMBLY AND SUSPENSION ARM TO THE TRUCK. THIS CAUSED SEPARATION OF MENTIONED MEMBER FROM THE VEHICLE RESULTING IN TOTAL LOSS OF CONTROL AND OVERTURNING OF SAID VEHICLE. THE VEHICLE WAS A TOTAL LOSS AS A RESULT OF THE INCIDENT.*AK
Power train, Oct 15, 2004
TRANSMISSION-POWER TRAIN.WHILE DRIVING IN LOW SPEED SITUATIONS THE VEHICLE'S TRANSMISSION SHIFTS FROM 1ST TO 2ND.....BACK AND FORTH FROM 1ST TO 2ND AND 2ND TO 1ST. I TOOK THE VEHICLE TO THE DEALER AND THEY ADVISED THAT THEY COULDN'T FIND ANYTHING WRONG WITH IT. IT HAS 76K MILES ON IT. I WAS JUST WONDERING IF ANYONE ELSE WAS HAVING THIS PROBLEM.*AKL
Steering, Oct 1, 2004
WHILE DRIVING STEERING POWER ASSIT PUMP FAILED. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT STEERING PUMP NEEDED TO BE REPLACED. *AK
Tires, Wheels, Aug 27, 2004, crash
THE LEFT REAR TIRE (DUNLOP GRANDTREK P265) OF 2002 TOYOTA TACOMA BLEW OUT ON CA 215 FREEWAY (WITH SPEED OF 60-70 MPH). I LOST CONTROL OF THE VEHICLE, IT SPUN AND COLLIDED WITH ANOTHER VEHICLE WHICH RESULTED TO MINOR PHYSICAL INJURY TO THE OTHER VEHICLE'S DRIVER. ORIGINAL TIRES CAME FROM THE DEALERSHIP, CARSON TOYOTA (CALIFORNIA). CONTACTED TOYOTA AND THE DEALERSHIP--THEY GAVE US THE RUN-AROUND. THE DEALERSHIP WAS VERY UNRESPONSIVE STATING THAT THEY ARE NOT AT FAULT, DID NOT KNOW THAT THE TIRE WOULD BLOW UP ON THE VEHICLE THAT DURING THE SALE--NEVERTHELESS, TO CUT COST ON A $2OK VALUE TRUCK, PUT SUBSTANDARD, DEFECTIVE TIRES, LEAST EXPENSIVE IN THE MARKET. I WILL END UP PUTTING UP THE COSTS FOR REPLACING ALL TIRES WITH MORE RELIABLE TIRES (MICHELIN). I HOPE THAT THERE WOULD BE BETTER LAW/LEGISLATION PROTECTING CONSUMERS AND NO ONE WOULD EXPERIENCE THE SAME INCIDENT THAT OCCURED TO ME.*AK
Power train, Aug 4, 2004
POWER TRAIN - JUST BOUGHT MY TRUCK ABOUT 3 MONTHS AGO. DURING THE TEST DRIVE, I WAS EXTREMELY IMPRESSED BY THE RIDE OF MY TACOMA. A FEW WEEKS AFTER I HAD IT, I STARTED TO EXPERIENCE THE CLUNKING SOUND COMING FROM UNDERNEATH. I HAVE TO THE DEALERSHIP 3 TIMES NOW, AND EVERYTIME I HAVE BEEN TOLD WAS NORMAL. I WAS TOLD ALL AUTOMATIC TRANSMISSIONS DO THIS. THIS IS THE SECOND TOYOTA TRUCK I HAVE OWNED, AND I COULD TELL YOU THIS, THEY DON'T COME UP WITH A RESOLUTION, IT WILL BE MY LAST. I ALSO DRIVE A CELICA (GREAT CAR), BUT IF I LOSE THE TRUCK, THEN I LOSING THE CELICA, AND WILL WANT NOTHING TO DO WITH TOYOTA'S AGAIN!!! *AK
Service brakes, Hydraulic, Jul 6, 2004
I HAVE A TACOMA 2002 AND THE BRAKES HAVE BEEN REPLACED THREE TIMES. ALTHOUGH I HAVE CALLED AND EXPLAINED THE SOMETIMES THEY SLIP, TOYOTA REFUSES TO REALLY LOOK AT THEM. I WANTED TO FILE THIS IN CASE THEY DO GIVE WHILE I AM DRIVING, THERE WILL BE A RECORD OF THIS PROBLEM, SINCE I HAVE MENTIONED IT SEVERAL TIMES TO TOYOTA BUT THEY NEVER WRITE IT DOWN, ACCORDING TO THE NEWEST CUSTOMER SERVICE? PERSON I SPOKE TO. I HAVE BEEN TOLD THAT THE CLUNKING NOISES, THE 5 MONTH BRAKE CHANGES AND THE SLIPPING OF THE BRAKES IS NATURAL. THIS CANNOT BE RIGHT. *JB
Suspension, Jun 22, 2004
WHILE DRIVING 10 MPH CONSUMER HEARD A LOUD NOISE COMING FROM THE FRONT OF THE VEHICLE. CONSUMER WAS ABLE TO PULL OVER AND NOTICED THAT PASSENGER'S FRONT TIRE FELL OFF. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE UPPER AND LOWER BALL JOINTS NEEDED TO BE REPLACED. *AK
Latches/locks/linkages, Jun 9, 2004
DOOR HANDLE ON INSIDE OF DRIVER'S SIDE BROKE. IMPOSSIBLE TO OPEN DOOR. UNFORTUNATELY IT HAPPENED WHEN MILEAGE IS AT 38,000 AND PAST WARRANTY BY 2000 MILES. COST TO REPAIR WAS $117. TECHNICIAN STATED PROBLEMS WITH CAMRY AND COROLA WITH THAT RESPECT. THE HANDLE WAS NEVER TREATED ROUGHLY, JUST BROKE ONE DAY.*AK
Power train, Jun 3, 2004
TRANSMISSION/DRIVESHAFT EXPERIENCES LOUD CLUNK NOISE WHEN BRAKES ARE APPLIED THEN RELEASED. THIS IS A KNOWN PROBLEM TO TOYOTA HOWEVER THEY OFFER NO RESOLUTION. RESEARCH HAS INDICATED ADDING LEAF SPRINGS TO STIFFEN REAR SUSPENSION RESLOVES THIS ISSUE TOYOTA WILL NOT DO THIS MODIFICATION. *JB
Tires, Mar 31, 2004
TWO FIRESTONE TIRES ON MY TRUCK BLEW OUT ON THE FREEWAY WITHIN 10 DAYS OF EACHOTHER, WHILE MY WIFE WAS DRIVING. THIS PUT HER IN EXTREME DANGER AND A VERY UNSAFE SITUATION.*AK
Wheels, Feb 24, 2004
REAR WHEEL CAN'T BE REMOVED FROM HUB. DEALER WAS CONTACTED. DEALER STATED WE BEAT THE WHEEL OFF WITH A SLUDGE HAMMER. *AK
Vehicle speed control, Feb 16, 2004, crash
THE CRUISE CONTROL ON THE 2002 TACOMA PRE-RUNNER THAT I OWN DID NOT DIS-ENGAGE WHEN THE BRAKES WERE HIT AFTER GOING INTO A SKID DUE TO BLACK ICE. THIS CAUSED THE VEHICLE TO SPIN OUT OF CONTROL AND CRASH. *AK
Tires, Dec 26, 2003
PURCHASED TOYOTA MR2 SPYDER IN AUGUST OF 2002. CAR NOW HAS 18,300 MILES AND BOTH FRONT TIRES (YOKOHAMA ADVAN A043 185/50R15) ARE WORN BEYOND RECOMMENDED TREAD DEPTH AND BLISTERED ON INSIDE(BECAUSE OF FRONT-END MISALIGNMENT ACCORDING TO DEALERSHIP). *AK
Service brakes, Hydraulic, Oct 29, 2003
FRONT WHEELS WOBBLE WHEN THE BRAKE PEDAL IS DEPRESSED. ALSO, THERE'S AN UNKNOWN SQUEAKING NOISE. THIS IS CAUSED BY PREMATURE BRAKE WEAR, PER DEALERSHIP.*AK
Air bags, Oct 14, 2003, crash
I APPROACHED AN INTERSECTION WHEN A ON COMING CAR MADE A LEFT TURN IN TO MY CAR. WE COLLIDED HEAD ON IN THE MIDDLE OF THE INTERSECTION. NEITHER ONE OF THE AIR BAGS WORKED. I'M WORKING FOR AN AUTO SUPPLY SHOP AND THIS IS MY DELIVERY TRUCK SO I CAN'T ANSWER ALL THE QUESTIONS ABOUT THE VEHICLE. *LA
Service brakes, Air, Power train, Structure, Sep 29, 2003
MY 2002 TACOMA VIBRATES AT HIGH SPEEDS AND WHEN STOPPING. I'VE HAD THE BRAKES FIXED 5 TIMES NOW AND IT'S STILL NOT RIGHT. MY TRANSMISSION CLUNKS WHEN I STOP AND START, SHUTTERS WHEN COMING TO A STOP, AND SHIFTS HARD. SOMETIMES THE TRANSMISSION CLUNKS AFTER I'VE ALREADY STARTED MOVING. THE PROBLEMS STARTED ABOUT A YEAR AGO. I'VE RECENTLY BEEN TO TWO DEALERSHIPS BEFORE THE WARRANTY EXPIRED AND NOTHING WAS DONE. ONE TOYOTA TECHNICIAN SAID IT WAS MY BRAKES, YEAH RIGHT, THE OTHER WOULDN'T EVEN TAKE IT FOR A TEST DRIVE. I THINK THE PROBLEM IS CAUSED BY MY TRANSMISSION SLIDING BACK AND FORTH, WHICH I DON'T THINK IT'S SUPPOSED TO DO. WHENEVER I STOMP ON THE GAS TO PASS SOMEONE IT SHIFTS INTO THE WRONG GEAR AND THE ENGINE RED LINES. MY DASH SQUEAKS, SO I HAVE TO WEDGE MY WALLET IN BETWEEN THE WINDSHIELD AND DASH TO STOP IT. MY DRIVER'S SIDE DOOR DOESN'T SHUT FLUSH WITH THE BODY. LAST BUT NOT LEAST, I HAD TO REPLACE MY OXYGEN SENSOR. I WOULD LIKE TO SELL MY TRUCK, BUT CAN'T WITH ALL THE PROBLEMS. THIS WAS MY FIRST TOYOTA AND WILL PROBABLY BE MY LAST.
Other or unspecified, Sep 2, 2003
CONSUMER STATED WATER LEAKED ON THE PASSENGER SIDE OF THE VEHICLE, WHICH CAUSED THE FLOOR TO BE WET. THERE WAS A MILDEW SMELL. PLEASE PROVIDE ANY FURTHER INFORMATION. *PH
Structure, Vehicle speed control, Aug 29, 2003
TRUCK DASH HAS RATTLED SINCE SHORTLY AFTER WE BOUGHT THE TRUCK. NEVER HAS BEEN FIXED CORRECTLY. ALSO, THE CRUISE CONTROL DOESN'T KEEP YOU AT CONSISTENT SPEED AT ALL ON MOUNTAINS/HILLS. IF YOU WANT TO GO 55, IT WILL PUT YOU UP OVER 60 VERY QUICKLY AND THEN GRADUALLY DROP YOU DOWN TO AROUND 55. *AK
Service brakes, Hydraulic, Aug 29, 2003
BRAKING PROBLEMS WITH A 2002 TOYOTA TACOMA 4X4. SHAKING OF TRUCK WHEN BRAKES WERE APPLIED. FRONT BRAKES WERE RESURFACED AND ADJUSTED ON 8/6/03. PROBLEM CONTINUED AND I WAS CHARGED TO REPLACE REAR DRUMS & SHOES ON A TRUCK WITH LESS THAN 30000 MILES ON 8/15/03. *AK
Fuel system, Gasoline, Aug 22, 2003
DEALERSHIP DOESN'T HAVE THE EQUIPMENT TO PERFORM FUEL LEAKAGE RECALL 03 V 189 000 REPAIRS WITHIN A REASONABLE TIME FRAME.*AK
Engine and engine cooling, Aug 22, 2003
WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING, THE CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD, AND SHORTLY AFTER VEHICLE SHUT DOWN. *AK THE CONSUMER HEARD THAT THIS WAS A COMMON PROBLEM. *SCC *JB
Suspension, Power train, Structure, Aug 10, 2003
FOR THE LAST YEAR I HAVE BROUGHT TRUCK BACK TO SF TOYOTA DEALERSHIP FOR TRANSMISSION PROBLEMS , SUSPENSION PROBLEMS RATTLING DASH BOARD, SQUEAKING SOUNDS FROM SEAT AND FRONT BUSHINGS. ALL THESE PROBLEMS STILL HAVE NOT BEEN FIXED. AFTER 15 VISITS TO DEALERSHIP, SF TOYOTA LEFT SCRATCHES ON BODY AND LOST MUD FLAP. BODY NOW TILTED AFTER SERVICE. *NLM